ML20138P114
ML20138P114 | |
Person / Time | |
---|---|
Site: | South Texas, 05000000 |
Issue date: | 11/11/1976 |
From: | Arnold J, Lomasney W IMPERIAL PROFESSIONAL COATINGS |
To: | |
Shared Package | |
ML20138M609 | List:
|
References | |
FOIA-85-59 95-76, NUDOCS 8511060407 | |
Download: ML20138P114 (12) | |
Text
l
.n- .
.--- , g :,,;.. m , . , _
.7,,.._. . ~ , - .
-M-
~
I 4
A
.I TECHNICAL REPORT i
I Nt31BER 95-76 TITLE DBA: NUTEC 10/115/11/1:01 OVER MAGIC KOTE FOR.MED CONCRETE FOR HOUSTON LIGHTING $ POWER ,
1 l CtJSTOMER i
I Submit:ed by: Jerry Arnold N Approved: W. J. Lomasney M u I
j Date: 11/11/76 I
' SOUTHERN BtPERIAL COATLNGS CORPORAT:CN. LNC.
P. O. Box 9077,
- New Orleans. Loutmana 70189 Phone: (504) 254-1433 .
f
- [ t w - . ..., . . - .- .... . ~ . ,. ,
- l't;"Li.'*l.;
r7.:%=,-
":..=.L'."."".:.:.~'t*rJ,'".,,::*.0%
. ~ . . . . . .
B511060407 051016 - - ~ ----- - -
. . - . n . .g - . v ._ _; _; .
- , , .,z ..- - < -.
- y
, ,; , . g v i
i
' TITLE: D3A: NUTEC 10/115/11/1201 OVER MAGIC XOTE FORMED CONCRETE 03 JECT: To determine the feasibility of applying Imperial's
.! NUTEC 10/11S/11/1201 system over concrete poured in j j' plywood forms coated witn Symon's Magic Kote.
INTRODUCTICN: This. test was performed at the request of Imperial representatives at the !!ouston Lighting and Power, South Texas jobsite where Symon's Magic Kote may be used as a plywood form release agent.
1
SUMMARY
- Designed Basis Accident (DBA) testing at the HL5P pressure and temperature curve was performed on con-crete coupons formed in Magic Kote treated plywood and coated with the NUTEC 10/11S/11/1201 rystem. No j flaking, blistering, cracking, delamination, or other l,
t effects were observed. ,
y
! PROCEDURE: A 2"x4"x2" concrete specimen, lab panel No. 390, was i prepared in a plywood form previously treated witn i : Magic Kote. The concrete mix used was as specified by
' Bechtel Cp956: .
, 30.0 lb Type II low alkaline Lone Star Cement ASTM C150 72.8 lb Jahncke cement sand ASTM C33 57.6 lb Jahncke Crescrete 3/8" dry gravel ASTM C33
- 13.7 lb Deionited water 2.4 g Master Builder's MB-VR Air Entrainment Admixture 44.4 g Master Builder's Pottolita 122-N l
Water Reducing Admixture she coupon was then sealed and coated with the NUTEC 10/11S/11/1201 system. For application and curing data see the following panel preparation sheet. The specimen was allowed to fully cure and then tested under DBA
- conditions at the HL5P curve by Coastal Science Associates.
t
' Joe attached Coastal Science Associates Report.
RESULTS:
REFERENCE:
Lab Book f4, Vol. 1, pg. 101
)
i e
i
~
i o
~ -- .- . . . . ,. . -. m.,.. .y, . .. . _ . . . . .
,.,_._,m..., ,.,-_c-. .
- ._ u- r g g g w x ,, y , ,.
-y.. . . .
- . . m y
- - - --, 7 c-
,,l; q . . e ,
'DBA r
V TEST PANEL PREPARATION DATA i
i $
- 1. PRODUCT To sE TESTED NUTEC 10 /11S/11/1201 k 2. TYPE sUssTRATE: ConcTete (Bechtel Mix) sIzz 2" r 4" y 2"
- 3. SURFACE PRERARATION (describe): None (Cene?ete neu?ed in nivweed #n - <
treated with Svmon's Marie Kotel 4 PRODUCT DATA: SAMPLE NO.(s) 390 -
. 5. DATE AND TIME CURING CCMFOUND OR PRIMER APPLIED 5/19/*6 TIME &
PRODUCT AP P LICATIO N CONDITICNS TIICKNESS DATE gal PRoDee? codes an?cs e METHOD R/M(OF)tR.N. (ins) APPLIEO NUTEC 10 5606/5607 Spray --- .004 005 5/13/76 NUTEC 11S 5409/5413/ Squeegee 82/72 .030 050 5/24/76 5700 NUTEC 11 5409/5413 Squeegee 82/72 .015 .030 5/24/76 NUTEC 1201 5786/5655 Spray 86/70 .005 .007 5/23/76 TOTAL FILM THICINESS .050. 090 i 4 i !
j 6. CURINGConDIkIONS: AMsIENT TEMP 70-80 OF REL. HUMIDITY ,45-63 MINIMUM CU RE 60 DAYS
- 7. TEST P ROCEDURZ : DBA (HL8P Curvel i
I S. TESTING PE:tFORMED sYsCoastal Science Assoc. DATE S U B M I TT ED _7,41[fl$_ _, ,
i Coastil S ei en; ,Ja.3 Q.C12;JL5 .
TES T REPO RT NO . A01 ? O T 2 **4 8
Southern Imcerial Coatings j .
i !
l Test Report No. 95-76 l
l
. _ _ _ . . _ . . . .c. ,..,,,,,,,_ ,. . _ .,_ ,.. _.. _ _ _
i l
. - - - . . .. -=
e s . .% - 1,.q w g. _ v -. . . 7,g,, . . . ; .
.._~._:_ .. =,.. _.
I .
?
1 1
b ..
COASTAL SCHEMCE ASSOCEATES CANAL 80utav4ao . NEW O A L- E A tJ S . i. O u l 5 f A N A 70314 l ._
(504) 28M258 { 0 900 I
Date: July 27, 1C76 l
J i
, ~
Preduct Id e nt ificat ion i Steel Panel I Concrote Bloci:
l ]
DBA Test Results:
Houston Lighting and Power: South Texas Projoct A=. !!o . 3. tt/16/74 DBA Prescuro Response rigure 6.2-17.
DBA Te=perature nesponse Figure 6.7.-18 l
~
l St=cle N. Cc ments 390 No flaking, blistering. er cracking
- on any sace. Anere is a .ign; brown discoloration - i" frc= the bottc= of the block. Cela=1 nation was act, ensen; cus ;ne coa;;ng was I .not re=oved for a ec=plete check.
i I .
i l
4 ,
Additiensi Cc-c. ente i
' Approved /. A * *f# .
{t s- Repor. ..c.A01$072776 se i
CQQPCk ATIVE $1GOlti$
- 1 F CittitC Al. Pft0GR AM CV ALU A TIOtl
- l*0Lt.U Tlort AU A TCMEt. f
, l MARIIJL COATitIG$ & T I \ flNlo e (.llV:NIC Al. / VIIs'of s.$ t.QNSUt. flNG a
- - - . *O %-TW --P #gh& 9v g'me8Wh 4 6 ggi,
__.,4p,.-.. g--__..,_,-,,.4 ,-.,-_.--.__._,,__-.,,.,-.,_,%--..-.,.we - - . _ _ _ . - _ _ _ _ _ _ _ _ _..-~y- , v._ .,. , pw y
- 3. g ,. , ~,.fst- ,_ mwje.y .. w.
, q.g_ _ .
l
~
ts04) 28312sl E coalm sessnes assocmss 6 900 C AN A L acuusvAno . N Ew onLE An s, coulss An A 10: 24 Date: July 27, 1976 i
Sa=pis No. 390 ~ ' ' . -
, DBA Solution Cc: osition: ,
Sodium borate-thiosulfate buffered at pH 9 5 DEA Test Conditien:
Time (sin) Te=p.(CF) Pressure (psiel Cc==ents I '23/76 0 1c4 ,
i 5 230 22 8 25$ 32 .
10 264 39 12 279 42 14 277 48 15 280 50 O@- .
18 277 38 Q 20 27 270 35 259 36 31 266 40 36 270 42 38 271 41 43 262 32 48 248 26 50 223 25
^
55 230 22 95 230 21 204 212 18 7/24/76 1373 208 15 1695 207 14 7/25/76 3382 203 13 7/26/76 4484 196 12 Re=cve fr:m heater, 8
Approve? Aw% W e
Report No. A018072776 e'
e CCCPthATIVE ST UCIt
- TECitNICAL PMCGRAM EVALUA TICN
- PCLLUTIQn AS ATEMEN T MARINE COA TING $ L TCSTING e
\ . CHEMICAL / PHY$lcs CCN$UL TING l t l
1 l
4
'T "
,"=.- f- ..v9, . .
^
,y.,'
- e. , ,._ . ,
I O
/n90et&id 4
g 1
l TECHNICAL REPORT NL'MBER L*S-77-C TITLE "C:MPAT 30%"Y OF BCETJ" TCRM RE:.I.ASZ TC 27IRIA:.'S C0ttC7ITE COAT liG SYSTIMS" i FOR i
1 COMANCIE PTAK
' CL'STOMER Tr2As c; =:r.IS
}
( ,
Submitted by: Jer:/ Arnold t
Apptwed:
f Date: 8/5/77 1
4 SOUTHER.N IMPEPJAL COATD.C5 CORPCRATlON LNC.
l P. O. Box 9077
- New Orleans. Lompana 70119 Phone: (304):!4-1433
,.........w.w......e..,...,,.,..,
. tmm...-......,
. . . . em . . . . . . .
. . , . . - . . , %.. m u. . . . . .
- * ** - +*-.e==. ,
l
.1 4
1
. m meRA=u==N =Cuu=
i 0***Y; 537 PArtC. P*IPARAMON CA"'A
~
i
- 1. PRC::CCT T3 BE 23 5 D: _ NUTIC 115/!M:IC 11/ REAC:'IC 1:01
- 2. TrPr stas RA= Cenerste - Bechtel CP 956 s:= : ** x 4" x 2*
- 3. s;RTACI PREPARACCN (Descrihe): Burke's Form Release was generously applied to all surfaces with a clean cloth.
- 4. PBCOCCT ::Ana SA G2 NC. (s) : eea 3, 5. v
- A= Mc n.J: C R::tc COMPCC:tD CR PR.*.vfR APPCID: Burkes amlied 7/5/77 10:00 a.m.
't i
l PRCDCCT APPI.ICATICN CC CITIONS
- HIC OTE35 7 .T & OA*l.
COAT PocCCC"" CCCES BATC3 4 MD R/M(07)tR.R. (ins.) A.P F*.CO 1 NC': C 113 217 / 275/2173 Squeegee 78'r/53% R.H. .C10 .0:0* 7/5/77
. 4:00 p.:.
- NO3C 11 117:/2:75 squeegee 8: r/614 R.H. .003 .CC5* 7/6/77 4:00 p. .
3 REACn c 1:01 6171/7434 Spray 86'T/70% R.H. .005 .007 7/8/77 11:00 a.m.
.)
1 l
1
+
5
- 6. CORI:tc C:: C*n0 ts: AM32:r; ;r:9. 70-80 F PC. E*'M* In 40-40 g
.C:TIMCM COPI 5 egyg i
I 7 TIS; PPrc:::cRI __ g A e r 'r:. 4P (Pavision 0, 10/22/75) l
- 8. 23CNC PERTOP.'CD ST: Coastal Sciences "A2 573:C""20 7/13/77 APPPCVID:
i TEST FIPCRT lC . 1?8-??
- l i , . CATE: 8/5/77 PREPARED SY _. .dM[ +M1 I
i .
I
.. - - - . . _ . ~ - . .
. ..~>- .,._ys er _ .;,:y g q, _
. , , w: v- - .
- ^ -
- n......._......
s
=-
! }
l t
August 5, 1977
. l I
6 CtMPAT!3::,ITY CF StNutES FCRM RZ'IAST
! IMPERIA ,'S CttfCRZTE C*.A*DiC SYS':TMS l
1 l
Purpose:
The purpose of this test was to determine if Burke's form release would 1
1 effect the perforanace of :nperial's concrete coating systems, if the release i
i agent were transferred to the concrete.
j - )
i j Procedures In order to expedite the generation of data, and to test under ex- {
t
- treme conditionar the surke's form release was applied directly to the conerste
. prior to application of the trJ:20 ells. The form release was applied genereusly )
I to all surfaces with a clean cloth at a spread rate of approximately 4C0 ft / gal.
l The concrete coating system was applied as outlined in the attached panel pre-j paration data. All specimens were cured at roca temperature and relative htaidity, a
- Jnan, submitted to Coastal Sciences for CBA testing per Houston I.ighting and i Power Davision 0, 10/22/75. All specimens were inspected for defects immediately j l
i teen reenval from the autoclave, especially delanination of the frCTEC 8113 fr:a the concrete which would indicate an incompatibility.
w' nesults: All surfacea were free of any defeets. ;
i i
d Conclusiense Burke's form release does not pose any threat to the perfor-t +
1 una:e of Zager1Al's concrete coating systems.
)
I
{
i l
i l
i l
i l
1
! ! t i *
=
4
{
t )
l u__.__.. . _ _ - _ . . . _ , _ . . _ _ _ . , _ . . _ . . _ _ _ _ _ _ _ . _ _ . _ . _ . _ _ . , . . . . - , _ . _ - , . _ _ _ . . . . . __.__ . . _ . . _ _ _ . _
, - . . . , , . .~ ,
-=- . . . .- . ._
1 i
l CO ASTAL SCIENCE ASSO CI AT ES NEw0MLEAN5 t. Q u i s J A N A tot 2*
(504) :s31:ss l 6 000 C A acutsvAR0
- e NAL i
Date: July 18, 1977 Product Identifications _ Steel Panels 1 Concrete Blocks OSA Test Conditions: Ecuston Lighting and Power Cu.- re, Rev 0,
- Oct. 22, 1975, abbreviated to 28 hrs.
t i
1 Samele 4 ce=ent s l
' sides 1,2,3,4, free from blisters, cracks, flakes, 3054 and no loss of adhesion detected, t
W e
1 h
i Approved [
\
Hoport #043071677 i
i i
C:CatM ATIvi $7u;tts
- TECnNICAL paccMAu gvsguait0N * *0LLuTicNsasTt9 TNT MAMINE C0A TING $ A TESTING e CHENICAL / PHY$lCS CCN$uLTING 4
a m ap- ew.
g m ,m ,e+-4.-..
- - ~ ~
f k
- O,
. i
.l
, l e
, F .' )
i
.... l .. .
g ' . .' . . )-
e p ,
.. i !
i .
i .e . .n N.
7
' 4.~-
, . f i , s.,
.g J.
f ... .
, -j ,
, ' .,..l 1 , , _i,
'. i l *
,. l'i .' . J:
I
. .t. . .. .
{ , .
. , . 4.-- - -.-
m
- i. . . i ; ,
...I. .
i 6 i.t- et 1
. .. .,i 1 l -l i t ! e a i l I.I t I ' -
j g. .> ' '
s . ..
I~ !-l I * ;f
__t ..
t
. !. . ,I ... _ { ..
l
.. . .t .- . .
_I t s j l D l .i l
'..._.. . '__ ) ,_.. , . . . - - '
.l 8
l .
l l 6
- l .;:. 2 l
i _ _. : _
}
i i i . ,i.
i 6
. }
- 6
._ ._ . a . : '
t l'
i 6 ;. I
'. .s. . _-
i
- t l ..
e i
. , . : i , , , , , i
.a.- u
.i . _ _ ._. : - i 1 -
. 4 i - i i : # 4,- .__i .. _ .._.i ,
. i i
< i .i u
) _. .,i .
., - .- q .q r.._ ,
.: i i !
- _.l...j.,/...
..;.._).
. . t . .J w
~
l-lC l
, f -
}
l f' e t ,
I ) ! . l a,,,, .c ... . e, . .
e .., / , t . i
. 6 g -
- s 3,, '
.' ,3 . ~ .
F4
. . . M. .
.f*
r *
.. .A' .'..i.
4 g
i
- ,;.../i , e i
. ..,I l
. Ml l $-.
- p
""l-- i .. Q ... --.
M CO i t /. "i: l
."a.
l l
w
.. i .. ., . !. ' . l..
w.
.! g . .. .".,' l
.I' . - . . -
I
.. l . C
_ g Q .
t _ _ _, . ..
l ,. . 6 "A l 3 p . l- . . l .
- 7. f e .*'
. ..-)
p .m.. . 'e . . .- ,,
l M
at . .s]
n I f * 8" l ... ,
a f.e.e . . a 3 >' T.,,.a..._...
- l
. .I. ,.a- , l i_ w I.
, . .s . . . .... .
., . .i .
' = g, t ; ! i i .4 -*
,, .a > .. - -
. cch. .
g . # .
- ... ; ... A _ ,
i..i
- l. . .. . . . . . ... . . J. . . ; .. .
, y ,
i t
.' l l s
. - .a s. . .i _ . . > . - . . - . _
l < e j i .
l l ,
_u',
g._ ; .
,. q. ,. ., p .3 ..., 7.. . _ . }
.i
, ~
- ~ . _ .
' I '
- t i , i , ,
I
- o. . .
t
. _ . l. .t,._ .. ! -
i l 6 I t 1'j
,_g ..
. ... .t i
2
,p, 4
.. l t i .
i ,
l p
- ~_ -
i . .a
. i
,f _... . . .i . .
I , ,P' l i - r- -
i' il e * ;
= * -
a e f : lt- * *, . 4._ .
=="'
1 c. i
, l j l
.q_ . ,
6 r
t ',4 ;. . . i .
,a _
. 7 . . .
- 1'
. . .e. l .. .. . .I ,,
- l. .
- 4n e .
I . !
- I .
@ m.ir .
--W 'n
. i i
- l. .,.--... g l .. . ..
g4
, . .: . .: c . :.; .
.l . . _ . .
. c. 'a l .I_ .- _'. C ,
- l: 6 l
, . . . . .....l*
I l . lN i
.. l.
I c.:. H, g
/,
/, i.
e
-e-I .6 i ,.</
s
, . e 6 , l
, . l . ,i .o. i ., .. . .
- ; 1 . ..
.i- . ~ . .st' .
l
'.. +
S - . _
! \g l -" ' " ~ ~ .
2.J ,,. ., .3 3 'J ,. ..
s
""-==.
,. . . i ~~'"i s
.\ . : ,
l i
- \ sh
.$ ' s e, *
)
r, * .
- s. , .
. . o .
f
- . g . .. 7 g .. - 7
$ t I I
..\.
t
$ . 4 l i t . .. .i O,.y ; . , g.
. 4
, l .. . .
e h 4
_ .. i , ... l .. . . ! l ... . .,
- l. .
j I
i
- 1. _l l ' 8 O
t .
9
[ .!
I
.I . f./ 4 . 'l . J./f f I #
. ...e. p 2... . I... t, . ....I.. .. . ..l ..l..... ... . .. ... .. .' . I.. . . . d #
i 1. .,. :' l . !'
f l 8 g i .
.,.. ,, .g.
- l t
.n.
,:l .
l._ ...!
- i. 5. i
.*..;.. i y... .. .. p. :
p : I- . ,
m . .. . . . . .
., :. ..q. . . q. . . ... ,..
... . l .. . . . i . . .. t - I y,,, . . . . . . . . .
.t. < .
. -.._-.4.. _ . . - - _ . .
i ,,
- { '. l 'l' l l
- I i ,
l' l
.i . i .i...,i g
.' . ' _ l
.[
l , '
. il .
. .i.. . . .! . _. . _, _....e _, , 'i 1
l- ); I :
...l .,.;
j .j i 1..
. l ..,l. !*.p.1' .
a }. l' .!' ._
..l ..l. l , i l .f
. _ _;#- . !...l/ ..J.' . . . ,
I '. . . . .
j !.
.'i +
.. p .
e j .;.
t ,
t ,4
. 9. ._j l ; l 4 'l .l.... I .. !. { i ! t . 6 v.
\ - - 6 6 - ' . . . . I.. . _. Ii l
.. . . _ . -. _ . . . . _e .. .* L .' .l . . _ . _-
l
.i ; i * . '
- i y , .
, ,i 3.
.4... 6 . . , ..1-...' .a . ..
.4.. .
( . .j
'. t_ <
' ...i. '
i.t i. _.i l , _ . .
_.. . .i . ._.._I . . .i.. _
.. j . l . .i-t .... , l' .. . , . .
,. l . . .
.I t.. ...i.
t :
.} ,
s
, i i . .' ' . !'
6
.. 1 i
t.J m: l - . ' -
e i
.l.
l ..
1
... . . . . l.
,_..6..
i i . . ! ,' . .i . . . . l . . l. . . . . , . i
, D".
N
.l .
t .l ,. t . . . . .
i 6
. .,....i , .l l l
. . I.
t a _ -%. l . .._ , : .a. l 6' t ' t l .. :
I
. l .. . '. _ l, k ., . ;
j i
.. . . .- . . . ' . . .q . . j .
..l.. :
l I j i ,
.5 . ll.>..
j .i .w .y li e w .C. " _- - ._ _i i .. - ... I r
i '
- _E ;: e
- c. a.o} 1. .i l..J c
. I i e
f' > I . ..
._ .im.. .
.m , l l l ~. J
- 9. ,, . g - _ ;__ j. _ . . . .g:- . . . '.. .i.__..;. . .,
. . f** . )- w
.z.
~>,
.l..
e
, . l 4 - ..
..q. .,
s m
,e 9 d- = i e + a- .
4 g ..x ,
-. .W. t I
l ... ,y, _l e i Q,y
, , ... ....l..... I p .I . .......l. 6 :
. ._,.. : 1 i i , .
. t w e i 8
- I
.g' _
y .l i ' .. - 4. '
i *
- i I
l
- _ .l . l . -l . , . .. l . . .. p 4 -
- . s.
i d
r..G.1. ! .. ..l. /a/ . e
.. ,,si :
-
- i , i .
_~_
i i ._ i._._.._.i i i ,
e .r i . .sj..., l _.
- e. ,., n , i
.ll....i_
. i . .......
- i. : 4 : : . . . i . . j .. .
I* ' ce M i l -. . . l . . ' i
. i
.I_ _.
.i _ ,,
! . _ _ _i .
- o. ..I _ . . . - _ . i. i.., _. . l . ._ F. ._l..., i.
i ., .. . ; i..:
. . . ~ .
I i . L . i. ._-
e p : i .. I .. t .. , ; r i .
. i i - i i a.. _
a .., x ,.. -
o
- q. . g . . . . , p p.. . .
. .l _... . . .t q _ ..
i i
. .ie ... : . i
- p. ,.. .;._. ..i, . . .i .g . ; _.-
.) r.- t-n s .. . l
> i i
- r S
t..,
i e
- 1. . . g . . i.
l 1,i. ..
g
.. i.
i . ., en. . . >; i i
u,t , . . . g _..i.. .:
g* . ; . l b.. l , < , . ; "'
- 4 l . . .. l i.
. ,l l' .
l i .
- .. w . . .e . l .n . ,
- I _ ,,,g, i,
e'""'
);, . n.. ..J.
I
. .. . ij ; .. . . . . . .e ..j..'..
.i . :: i ,
.i e i ..I 6 t .;.'.
g4, * ' .
. *. . l . .
.i., . l. ..,
__ -. 1,~ l I '
p Il
'. it i i
- ..., 'i .
i i i
.~.',i.y i .6 O f
..l .- .m'% * * '
[
g ... l ,l ,. ' ' ........,......p.
l: 6 l
'" p,1 . .c .
..l
' I l .. !' . '.. ' .. l.
! . n.
} t i l...;,..,,....,.
,A j
y d
.l I
i
'l
..l.i.
! ... . . . ]...... 1 . ..'.
.l { . . l. .. '
.. . . f .. . l .;',
j.. l I
i, I..
iN . , !. 1 l iI
..]/ . . I
(
i j
l i
.' i I 6
. . . _ - .' ' . i i i
.d , 3 4 0 J.'J A 3.J r* 'l ;
i
.._6.ae ,
l
{ g l l, , .
- Y.
a; . . . . ,
l i ,
l t ,.
, i i
. 1. e
,., l, _j-l._..1_._----- l.
t n
3 es ,
d vi O.
. n .b' g
- 4. * .A. , we ci p-0
.. . . . . . u,. -- . .. . . . .
. . . ;;; -g. ts - . , - s - _v ~ . . .
i e
O I
I YAULT A cKA&E #1 4
M%
..-... ._ .. N **MM -_,
'MTSW fg6 e egg
.-_a