|
---|
Category:INSPECTION REPORT
MONTHYEARIR 05000413/19990051999-09-24024 September 1999 Insp Repts 50-413/99-05 & 50-414/99-05 on 990718-0828. Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19990041999-08-13013 August 1999 Insp Repts 50-413/99-04 & 50-414/99-04 on 990606-0717. Non-cited Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support ML20209E2831999-07-0101 July 1999 Insp Repts 50-413/99-03 & 50-414/99-03 on 990425-0605. Non-cited Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support IR 05000413/19990111999-06-0202 June 1999 Insp Repts 50-413/99-11 & 50-414/99-11 on 990422-23 & 0503. No Violations Noted.Major Areas Inspected:Licensee Identified Frost & Ice Buildup Which Affected Unit 1 Ice Condenser Lower Inlet Doors IR 05000413/19990021999-05-20020 May 1999 Insp Repts 50-413/99-02 & 50-414/99-02 on 990314-0424.No Violations Noted.Major Areas Inspected:Aspects of Licensee Operations,Maint,Engineering & Plant Support ML20206U4161999-05-10010 May 1999 Insp Repts 50-413/99-10 & 50-414/99-10 on 990314-0424. Violation Being Considered for Escalated Enforcement Action Noted.Major Areas Inspected:Operations IR 05000413/19990011999-04-0606 April 1999 Insp Repts 50-413/99-01 & 50-414/99-01 on 990124-0313. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19980121999-02-17017 February 1999 Insp Repts 50-413/98-12 & 50-414/98-12 on 981213-990123. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19980111999-01-11011 January 1999 Insp Repts 50-413/98-11 & 50-414/98-11 on 981101-1212.No Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19980151999-01-0404 January 1999 Insp Repts 50-413/98-15 & 50-414/98-15 on 981102-06 & 16-20. No Violations Noted.Major Areas Inspected:Licensee Corrective Action Program by Sampling Activities Defined in Nuclear Sys Directive 210,rev 1 IR 05000413/19980161998-12-0404 December 1998 Insp Repts 50-413/98-16 & 50-414/98-16 on 980915-1101.No Violations Rept Encl.Major Areas Inspected:Licensee Maint, Surveillance & Engineering Programs Involving Unit 2 Ice Condenser IR 05000413/19980101998-11-23023 November 1998 Insp Repts 50-413/98-10 & 50-414/98-10 on 980927-1031.No Violations Noted.Major Areas Inspected:Licensee Operations, Engineering & Plant Support ML20155B3821998-10-19019 October 1998 Insp Repts 50-413/98-13 & 50-414/98-13 on 980807-0915. Apparent Violations Being Considered for Escalated Enforcement Action.Major Areas Inspected:Review Ice Condenser Related Problems,Which Led to Forced Shutdown IR 05000413/19980081998-09-14014 September 1998 Insp Repts 50-413/98-08 & 50-414/98-08 on 980705-0815. Violations Noted.Major Areas Inspected:Operations,Maint & Engineering IR 05000413/19980091998-08-26026 August 1998 Insp Repts 50-413/98-09 & 50-414/98-09 on 980816-0826. Examples of Two Apparent Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000413/19980071998-07-27027 July 1998 Insp Repts 50-413/98-07 & 50-414/98-07 on 980524-0704. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support,Including Physical Security IR 05000413/19980051998-06-22022 June 1998 Insp Repts 50-413/98-05 & 50-414/98-05 on 980412-0523.No Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19980061998-06-0505 June 1998 Insp Repts 50-413/98-06 & 50-414/98-06 on 980511-15. Violations Noted.Major Areas Inspected:Facts Surrounding Event Associated W/Degradation of CNS Unit Auxiliary Feedwater Sys During Rapid down-power on 980507 IR 05000413/19980031998-04-30030 April 1998 Insp Repts 50-413/98-03 & 50-414/98-03 on 980222-0411. Violations Being Considered for Escalated Enforcement Action.Major Areas Inspected:Aspects of Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19980041998-04-20020 April 1998 Insp Repts 50-413/98-04 & 50-414/98-04 on 980302-06.No Violations Noted.Major Areas Inspected:Observation & Evaluation of Biennial Emergency Preparedness Exercise for Plant ML20217G5661998-03-23023 March 1998 Insp Repts 50-413/98-01 & 50-414/98-01 on 980111-0221. Violations Noted.Major Areas Inspected:Operation,Maint, Engineering & Plant Support IR 05000413/19980021998-02-17017 February 1998 Partially Withheld Insp Repts 50-413/98-02 & 50-414/98-02 on 980112-13 (Ref 10CFR2.790).No Violations Noted.Major Areas Inspected:Plant Support,Including Malevolent Use of Vehicles at Plant ML20203L6301998-02-0909 February 1998 Insp Repts 50-413/97-15 & 50-414/97-15 on 971123-980110. Violations Noted.Major Areas Inspected:Operations,Maint & Plant Support ML20197F2861997-12-19019 December 1997 Insp Repts 50-413/97-14 & 50-414/97-14 on 971012-1122. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19970121997-11-10010 November 1997 Insp Repts 50-413/97-12 & 50-414/97-12 on 970831-1011. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support as Well as Results of Announced Inspection by Regional Security Inspector IR 05000413/19970111997-09-26026 September 1997 Insp Repts 50-413/97-11 & 50-414/97-11 on 970720-0830. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19970101997-09-11011 September 1997 Insp Repts 50-413/97-10 & 50-414/97-10 on 970623-0731.No Violations Noted.Major Areas Inspected:Licensee Calculations,Analysis & Other Engineering Documents ML20210N7341997-08-18018 August 1997 Insp Repts 50-413/97-09 & 50-414/97-09 on 970608-0719. Violations Noted.Major Areas Inspected:Aspects of Licensee Operations,Maint,Engineering & Plant Support ML20149F9291997-07-0707 July 1997 Insp Repts 50-413/97-08 & 50-414/97-08 on 970427-0607. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support ML20148F9441997-05-23023 May 1997 Insp Repts 50-413/97-07 & 50-414/97-07 on 970323-0426. Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19970051997-04-21021 April 1997 Integrated Insp Repts 50-413/97-05 & 50-414/97-05 on 970216- 0322.No Violations Identified.Major Areas Inspected:Maint, Operations,Engineering & Plant Support IR 05000413/19970061997-04-0404 April 1997 Insp Repts 50-413/97-06 & 50-414/97-06 on 970317-20.No Violations Noted.Major Areas Inspected:Conduct of Security & Safeguards Activities,Plant Support & Status of Security Facilities & Equipment ML20140B7631997-03-17017 March 1997 Insp Repts 50-413/97-03 & 50-414/97-03 on 970112-0215. Violations Noted.Major Areas Inspected:Licensee Operation, Maint,Engineering & Plant Support IR 05000413/19960191997-02-21021 February 1997 Insp Repts 50-413/96-19 & 50-414/96-19 on 961007, 961127, & 970206.Violation Noted.Major Areas inspected:in-office Review of Licensee Describing Changes to CNS UFSAR Re Lack of Circuit Breaker Coordination for 600-Vac IR 05000413/19960201997-02-10010 February 1997 Insp Repts 50-413/96-20 & 50-414/96-20 on 961201-970111.No Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19970041997-01-31031 January 1997 Insp Repts 50-413/97-04 & 50-414/97-04 on 970106-23.No Violations Noted.Major Areas Inspected:Operations & Engineering IR 05000413/19970021997-01-31031 January 1997 Insp Repts 50-413/97-02 & 50-414/97-02 on 970106-10.No Violations Noted.Major Areas Inspected:Plant Support IR 05000413/19960181996-12-30030 December 1996 Insp Repts 50-413/96-18 & 50-414/96-18 on 961020-1130.No Violations Noted.Major Areas Inspected:Operations,Maint & Engineering ML20135C2601996-11-15015 November 1996 Insp Repts 50-413/96-16 & 50-414/96-16 on 960908-1019.No Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19960151996-11-0707 November 1996 Insp Repts 50-413/96-15 & 50-414/96-15 on 960901-1012.No Violations Noted.Major Areas Inspected:Engineering & Plant Support IR 05000413/19960171996-11-0101 November 1996 Insp Repts 50-413/96-17 & 50-414/96-17 on 960930-1004.No Violations Noted.Major Areas Inspected:Plant Support ML20128R0951996-10-0707 October 1996 Insp Repts 50-413/96-13 & 50-414/96-13 on 960728-0907. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering,Plant Support & Plant Status ML20128J0391996-09-30030 September 1996 Insp Repts 50-413/96-12 & 50-414/96-12 on 960804-31. Violations Noted.Major Areas Inspected:Engineering, Summary of Plant Status & Observations & Findings IR 05000413/19940141994-06-0303 June 1994 Insp Repts 50-413/94-14 & 50-414/94-14 on 940509-20.No Violations Noted.Major Areas Inspected:Isi & Flow Assisted Corrosion IR 05000269/19930321994-01-0606 January 1994 Insp Repts 50-269/93-32,50-270/93-32,50-287/93-32, 50-369/93-31,50-370/93-31,50-413/93-35 & 50-414,respectively on 931213-17.Violations Noted.Major Areas Inpected:Licensee Safeguards Info Program to folow-up on Licensee Repts IR 05000413/19930321993-12-30030 December 1993 Insp Repts 50-413/93-32 & 50-414/93-32 on 931117-19 & 1129-1203.Violations Noted.Major Areas Inspected:Observation of Eddy Current (ET) Exam of SG Tubes,Inservice Activities Including Surface & Volumetric Exams,Review of Radiographs IR 05000413/19930331993-12-23023 December 1993 Insp Repts 50-413/93-33 & 50-414/93-33 on 931129-1203.No Violations Noted.Major Areas Inspected:Isi of Pipe Supports & Snubbers & TS Surveillance of Snubbers IR 05000413/19930311993-12-22022 December 1993 Insp Repts 50-413/93-31 & 50-414/93-31 on 931107-1204.No Violations Noted.Major Areas Inspected:Plant Operations, Maintenance,Engineering,Plant Support & follow-up of Previously Identifed Items IR 05000413/19930291993-12-12012 December 1993 Insp Repts 50-413/93-29 & 50-414/93-29 on 931115-19.No Violations Noted.Major Areas Inspected:Occupational Radiation Safety,Organization & Mgt Controls,Training & Qualification,Audits & Appraisals IR 05000413/19930281993-12-10010 December 1993 Insp Repts 50-413/93-28 & 50-414/93-28 on 931101-05.No Violations Noted.Deviation Noted.Major Areas Inspected: Adequacy of Licensee Programs,Procedures & Supporting Documentation for Implementation of Station Blackout Rule 1999-09-24
[Table view] Category:NRC-GENERATED
MONTHYEARIR 05000413/19990051999-09-24024 September 1999 Insp Repts 50-413/99-05 & 50-414/99-05 on 990718-0828. Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19990041999-08-13013 August 1999 Insp Repts 50-413/99-04 & 50-414/99-04 on 990606-0717. Non-cited Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support ML20209E2831999-07-0101 July 1999 Insp Repts 50-413/99-03 & 50-414/99-03 on 990425-0605. Non-cited Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support IR 05000413/19990111999-06-0202 June 1999 Insp Repts 50-413/99-11 & 50-414/99-11 on 990422-23 & 0503. No Violations Noted.Major Areas Inspected:Licensee Identified Frost & Ice Buildup Which Affected Unit 1 Ice Condenser Lower Inlet Doors IR 05000413/19990021999-05-20020 May 1999 Insp Repts 50-413/99-02 & 50-414/99-02 on 990314-0424.No Violations Noted.Major Areas Inspected:Aspects of Licensee Operations,Maint,Engineering & Plant Support ML20206U4161999-05-10010 May 1999 Insp Repts 50-413/99-10 & 50-414/99-10 on 990314-0424. Violation Being Considered for Escalated Enforcement Action Noted.Major Areas Inspected:Operations IR 05000413/19990011999-04-0606 April 1999 Insp Repts 50-413/99-01 & 50-414/99-01 on 990124-0313. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19980121999-02-17017 February 1999 Insp Repts 50-413/98-12 & 50-414/98-12 on 981213-990123. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19980111999-01-11011 January 1999 Insp Repts 50-413/98-11 & 50-414/98-11 on 981101-1212.No Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19980151999-01-0404 January 1999 Insp Repts 50-413/98-15 & 50-414/98-15 on 981102-06 & 16-20. No Violations Noted.Major Areas Inspected:Licensee Corrective Action Program by Sampling Activities Defined in Nuclear Sys Directive 210,rev 1 IR 05000413/19980161998-12-0404 December 1998 Insp Repts 50-413/98-16 & 50-414/98-16 on 980915-1101.No Violations Rept Encl.Major Areas Inspected:Licensee Maint, Surveillance & Engineering Programs Involving Unit 2 Ice Condenser IR 05000413/19980101998-11-23023 November 1998 Insp Repts 50-413/98-10 & 50-414/98-10 on 980927-1031.No Violations Noted.Major Areas Inspected:Licensee Operations, Engineering & Plant Support ML20155B3821998-10-19019 October 1998 Insp Repts 50-413/98-13 & 50-414/98-13 on 980807-0915. Apparent Violations Being Considered for Escalated Enforcement Action.Major Areas Inspected:Review Ice Condenser Related Problems,Which Led to Forced Shutdown IR 05000413/19980081998-09-14014 September 1998 Insp Repts 50-413/98-08 & 50-414/98-08 on 980705-0815. Violations Noted.Major Areas Inspected:Operations,Maint & Engineering IR 05000413/19980091998-08-26026 August 1998 Insp Repts 50-413/98-09 & 50-414/98-09 on 980816-0826. Examples of Two Apparent Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000413/19980071998-07-27027 July 1998 Insp Repts 50-413/98-07 & 50-414/98-07 on 980524-0704. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support,Including Physical Security IR 05000413/19980051998-06-22022 June 1998 Insp Repts 50-413/98-05 & 50-414/98-05 on 980412-0523.No Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19980061998-06-0505 June 1998 Insp Repts 50-413/98-06 & 50-414/98-06 on 980511-15. Violations Noted.Major Areas Inspected:Facts Surrounding Event Associated W/Degradation of CNS Unit Auxiliary Feedwater Sys During Rapid down-power on 980507 IR 05000413/19980031998-04-30030 April 1998 Insp Repts 50-413/98-03 & 50-414/98-03 on 980222-0411. Violations Being Considered for Escalated Enforcement Action.Major Areas Inspected:Aspects of Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19980041998-04-20020 April 1998 Insp Repts 50-413/98-04 & 50-414/98-04 on 980302-06.No Violations Noted.Major Areas Inspected:Observation & Evaluation of Biennial Emergency Preparedness Exercise for Plant ML20217G5661998-03-23023 March 1998 Insp Repts 50-413/98-01 & 50-414/98-01 on 980111-0221. Violations Noted.Major Areas Inspected:Operation,Maint, Engineering & Plant Support IR 05000413/19980021998-02-17017 February 1998 Partially Withheld Insp Repts 50-413/98-02 & 50-414/98-02 on 980112-13 (Ref 10CFR2.790).No Violations Noted.Major Areas Inspected:Plant Support,Including Malevolent Use of Vehicles at Plant ML20203L6301998-02-0909 February 1998 Insp Repts 50-413/97-15 & 50-414/97-15 on 971123-980110. Violations Noted.Major Areas Inspected:Operations,Maint & Plant Support ML20197F2861997-12-19019 December 1997 Insp Repts 50-413/97-14 & 50-414/97-14 on 971012-1122. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19970121997-11-10010 November 1997 Insp Repts 50-413/97-12 & 50-414/97-12 on 970831-1011. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support as Well as Results of Announced Inspection by Regional Security Inspector IR 05000413/19970111997-09-26026 September 1997 Insp Repts 50-413/97-11 & 50-414/97-11 on 970720-0830. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19970101997-09-11011 September 1997 Insp Repts 50-413/97-10 & 50-414/97-10 on 970623-0731.No Violations Noted.Major Areas Inspected:Licensee Calculations,Analysis & Other Engineering Documents ML20210N7341997-08-18018 August 1997 Insp Repts 50-413/97-09 & 50-414/97-09 on 970608-0719. Violations Noted.Major Areas Inspected:Aspects of Licensee Operations,Maint,Engineering & Plant Support ML20149F9291997-07-0707 July 1997 Insp Repts 50-413/97-08 & 50-414/97-08 on 970427-0607. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support ML20148F9441997-05-23023 May 1997 Insp Repts 50-413/97-07 & 50-414/97-07 on 970323-0426. Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19970051997-04-21021 April 1997 Integrated Insp Repts 50-413/97-05 & 50-414/97-05 on 970216- 0322.No Violations Identified.Major Areas Inspected:Maint, Operations,Engineering & Plant Support IR 05000413/19970061997-04-0404 April 1997 Insp Repts 50-413/97-06 & 50-414/97-06 on 970317-20.No Violations Noted.Major Areas Inspected:Conduct of Security & Safeguards Activities,Plant Support & Status of Security Facilities & Equipment ML20140B7631997-03-17017 March 1997 Insp Repts 50-413/97-03 & 50-414/97-03 on 970112-0215. Violations Noted.Major Areas Inspected:Licensee Operation, Maint,Engineering & Plant Support IR 05000413/19960191997-02-21021 February 1997 Insp Repts 50-413/96-19 & 50-414/96-19 on 961007, 961127, & 970206.Violation Noted.Major Areas inspected:in-office Review of Licensee Describing Changes to CNS UFSAR Re Lack of Circuit Breaker Coordination for 600-Vac IR 05000413/19960201997-02-10010 February 1997 Insp Repts 50-413/96-20 & 50-414/96-20 on 961201-970111.No Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19970041997-01-31031 January 1997 Insp Repts 50-413/97-04 & 50-414/97-04 on 970106-23.No Violations Noted.Major Areas Inspected:Operations & Engineering IR 05000413/19970021997-01-31031 January 1997 Insp Repts 50-413/97-02 & 50-414/97-02 on 970106-10.No Violations Noted.Major Areas Inspected:Plant Support IR 05000413/19960181996-12-30030 December 1996 Insp Repts 50-413/96-18 & 50-414/96-18 on 961020-1130.No Violations Noted.Major Areas Inspected:Operations,Maint & Engineering ML20135C2601996-11-15015 November 1996 Insp Repts 50-413/96-16 & 50-414/96-16 on 960908-1019.No Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19960151996-11-0707 November 1996 Insp Repts 50-413/96-15 & 50-414/96-15 on 960901-1012.No Violations Noted.Major Areas Inspected:Engineering & Plant Support IR 05000413/19960171996-11-0101 November 1996 Insp Repts 50-413/96-17 & 50-414/96-17 on 960930-1004.No Violations Noted.Major Areas Inspected:Plant Support ML20128R0951996-10-0707 October 1996 Insp Repts 50-413/96-13 & 50-414/96-13 on 960728-0907. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering,Plant Support & Plant Status ML20128J0391996-09-30030 September 1996 Insp Repts 50-413/96-12 & 50-414/96-12 on 960804-31. Violations Noted.Major Areas Inspected:Engineering, Summary of Plant Status & Observations & Findings IR 05000413/19940141994-06-0303 June 1994 Insp Repts 50-413/94-14 & 50-414/94-14 on 940509-20.No Violations Noted.Major Areas Inspected:Isi & Flow Assisted Corrosion IR 05000269/19930321994-01-0606 January 1994 Insp Repts 50-269/93-32,50-270/93-32,50-287/93-32, 50-369/93-31,50-370/93-31,50-413/93-35 & 50-414,respectively on 931213-17.Violations Noted.Major Areas Inpected:Licensee Safeguards Info Program to folow-up on Licensee Repts IR 05000413/19930321993-12-30030 December 1993 Insp Repts 50-413/93-32 & 50-414/93-32 on 931117-19 & 1129-1203.Violations Noted.Major Areas Inspected:Observation of Eddy Current (ET) Exam of SG Tubes,Inservice Activities Including Surface & Volumetric Exams,Review of Radiographs IR 05000413/19930331993-12-23023 December 1993 Insp Repts 50-413/93-33 & 50-414/93-33 on 931129-1203.No Violations Noted.Major Areas Inspected:Isi of Pipe Supports & Snubbers & TS Surveillance of Snubbers IR 05000413/19930311993-12-22022 December 1993 Insp Repts 50-413/93-31 & 50-414/93-31 on 931107-1204.No Violations Noted.Major Areas Inspected:Plant Operations, Maintenance,Engineering,Plant Support & follow-up of Previously Identifed Items IR 05000413/19930291993-12-12012 December 1993 Insp Repts 50-413/93-29 & 50-414/93-29 on 931115-19.No Violations Noted.Major Areas Inspected:Occupational Radiation Safety,Organization & Mgt Controls,Training & Qualification,Audits & Appraisals IR 05000413/19930281993-12-10010 December 1993 Insp Repts 50-413/93-28 & 50-414/93-28 on 931101-05.No Violations Noted.Deviation Noted.Major Areas Inspected: Adequacy of Licensee Programs,Procedures & Supporting Documentation for Implementation of Station Blackout Rule 1999-09-24
[Table view] Category:INSPECTION REPORT
MONTHYEARIR 05000413/19990051999-09-24024 September 1999 Insp Repts 50-413/99-05 & 50-414/99-05 on 990718-0828. Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19990041999-08-13013 August 1999 Insp Repts 50-413/99-04 & 50-414/99-04 on 990606-0717. Non-cited Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support ML20209E2831999-07-0101 July 1999 Insp Repts 50-413/99-03 & 50-414/99-03 on 990425-0605. Non-cited Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support IR 05000413/19990111999-06-0202 June 1999 Insp Repts 50-413/99-11 & 50-414/99-11 on 990422-23 & 0503. No Violations Noted.Major Areas Inspected:Licensee Identified Frost & Ice Buildup Which Affected Unit 1 Ice Condenser Lower Inlet Doors IR 05000413/19990021999-05-20020 May 1999 Insp Repts 50-413/99-02 & 50-414/99-02 on 990314-0424.No Violations Noted.Major Areas Inspected:Aspects of Licensee Operations,Maint,Engineering & Plant Support ML20206U4161999-05-10010 May 1999 Insp Repts 50-413/99-10 & 50-414/99-10 on 990314-0424. Violation Being Considered for Escalated Enforcement Action Noted.Major Areas Inspected:Operations IR 05000413/19990011999-04-0606 April 1999 Insp Repts 50-413/99-01 & 50-414/99-01 on 990124-0313. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19980121999-02-17017 February 1999 Insp Repts 50-413/98-12 & 50-414/98-12 on 981213-990123. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19980111999-01-11011 January 1999 Insp Repts 50-413/98-11 & 50-414/98-11 on 981101-1212.No Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19980151999-01-0404 January 1999 Insp Repts 50-413/98-15 & 50-414/98-15 on 981102-06 & 16-20. No Violations Noted.Major Areas Inspected:Licensee Corrective Action Program by Sampling Activities Defined in Nuclear Sys Directive 210,rev 1 IR 05000413/19980161998-12-0404 December 1998 Insp Repts 50-413/98-16 & 50-414/98-16 on 980915-1101.No Violations Rept Encl.Major Areas Inspected:Licensee Maint, Surveillance & Engineering Programs Involving Unit 2 Ice Condenser IR 05000413/19980101998-11-23023 November 1998 Insp Repts 50-413/98-10 & 50-414/98-10 on 980927-1031.No Violations Noted.Major Areas Inspected:Licensee Operations, Engineering & Plant Support ML20155B3821998-10-19019 October 1998 Insp Repts 50-413/98-13 & 50-414/98-13 on 980807-0915. Apparent Violations Being Considered for Escalated Enforcement Action.Major Areas Inspected:Review Ice Condenser Related Problems,Which Led to Forced Shutdown IR 05000413/19980081998-09-14014 September 1998 Insp Repts 50-413/98-08 & 50-414/98-08 on 980705-0815. Violations Noted.Major Areas Inspected:Operations,Maint & Engineering IR 05000413/19980091998-08-26026 August 1998 Insp Repts 50-413/98-09 & 50-414/98-09 on 980816-0826. Examples of Two Apparent Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000413/19980071998-07-27027 July 1998 Insp Repts 50-413/98-07 & 50-414/98-07 on 980524-0704. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support,Including Physical Security IR 05000413/19980051998-06-22022 June 1998 Insp Repts 50-413/98-05 & 50-414/98-05 on 980412-0523.No Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19980061998-06-0505 June 1998 Insp Repts 50-413/98-06 & 50-414/98-06 on 980511-15. Violations Noted.Major Areas Inspected:Facts Surrounding Event Associated W/Degradation of CNS Unit Auxiliary Feedwater Sys During Rapid down-power on 980507 IR 05000413/19980031998-04-30030 April 1998 Insp Repts 50-413/98-03 & 50-414/98-03 on 980222-0411. Violations Being Considered for Escalated Enforcement Action.Major Areas Inspected:Aspects of Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19980041998-04-20020 April 1998 Insp Repts 50-413/98-04 & 50-414/98-04 on 980302-06.No Violations Noted.Major Areas Inspected:Observation & Evaluation of Biennial Emergency Preparedness Exercise for Plant ML20217G5661998-03-23023 March 1998 Insp Repts 50-413/98-01 & 50-414/98-01 on 980111-0221. Violations Noted.Major Areas Inspected:Operation,Maint, Engineering & Plant Support IR 05000413/19980021998-02-17017 February 1998 Partially Withheld Insp Repts 50-413/98-02 & 50-414/98-02 on 980112-13 (Ref 10CFR2.790).No Violations Noted.Major Areas Inspected:Plant Support,Including Malevolent Use of Vehicles at Plant ML20203L6301998-02-0909 February 1998 Insp Repts 50-413/97-15 & 50-414/97-15 on 971123-980110. Violations Noted.Major Areas Inspected:Operations,Maint & Plant Support ML20197F2861997-12-19019 December 1997 Insp Repts 50-413/97-14 & 50-414/97-14 on 971012-1122. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19970121997-11-10010 November 1997 Insp Repts 50-413/97-12 & 50-414/97-12 on 970831-1011. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support as Well as Results of Announced Inspection by Regional Security Inspector IR 05000413/19970111997-09-26026 September 1997 Insp Repts 50-413/97-11 & 50-414/97-11 on 970720-0830. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19970101997-09-11011 September 1997 Insp Repts 50-413/97-10 & 50-414/97-10 on 970623-0731.No Violations Noted.Major Areas Inspected:Licensee Calculations,Analysis & Other Engineering Documents ML20210N7341997-08-18018 August 1997 Insp Repts 50-413/97-09 & 50-414/97-09 on 970608-0719. Violations Noted.Major Areas Inspected:Aspects of Licensee Operations,Maint,Engineering & Plant Support ML20149F9291997-07-0707 July 1997 Insp Repts 50-413/97-08 & 50-414/97-08 on 970427-0607. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support ML20148F9441997-05-23023 May 1997 Insp Repts 50-413/97-07 & 50-414/97-07 on 970323-0426. Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19970051997-04-21021 April 1997 Integrated Insp Repts 50-413/97-05 & 50-414/97-05 on 970216- 0322.No Violations Identified.Major Areas Inspected:Maint, Operations,Engineering & Plant Support IR 05000413/19970061997-04-0404 April 1997 Insp Repts 50-413/97-06 & 50-414/97-06 on 970317-20.No Violations Noted.Major Areas Inspected:Conduct of Security & Safeguards Activities,Plant Support & Status of Security Facilities & Equipment ML20140B7631997-03-17017 March 1997 Insp Repts 50-413/97-03 & 50-414/97-03 on 970112-0215. Violations Noted.Major Areas Inspected:Licensee Operation, Maint,Engineering & Plant Support IR 05000413/19960191997-02-21021 February 1997 Insp Repts 50-413/96-19 & 50-414/96-19 on 961007, 961127, & 970206.Violation Noted.Major Areas inspected:in-office Review of Licensee Describing Changes to CNS UFSAR Re Lack of Circuit Breaker Coordination for 600-Vac IR 05000413/19960201997-02-10010 February 1997 Insp Repts 50-413/96-20 & 50-414/96-20 on 961201-970111.No Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19970041997-01-31031 January 1997 Insp Repts 50-413/97-04 & 50-414/97-04 on 970106-23.No Violations Noted.Major Areas Inspected:Operations & Engineering IR 05000413/19970021997-01-31031 January 1997 Insp Repts 50-413/97-02 & 50-414/97-02 on 970106-10.No Violations Noted.Major Areas Inspected:Plant Support IR 05000413/19960181996-12-30030 December 1996 Insp Repts 50-413/96-18 & 50-414/96-18 on 961020-1130.No Violations Noted.Major Areas Inspected:Operations,Maint & Engineering ML20135C2601996-11-15015 November 1996 Insp Repts 50-413/96-16 & 50-414/96-16 on 960908-1019.No Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19960151996-11-0707 November 1996 Insp Repts 50-413/96-15 & 50-414/96-15 on 960901-1012.No Violations Noted.Major Areas Inspected:Engineering & Plant Support IR 05000413/19960171996-11-0101 November 1996 Insp Repts 50-413/96-17 & 50-414/96-17 on 960930-1004.No Violations Noted.Major Areas Inspected:Plant Support ML20128R0951996-10-0707 October 1996 Insp Repts 50-413/96-13 & 50-414/96-13 on 960728-0907. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering,Plant Support & Plant Status ML20128J0391996-09-30030 September 1996 Insp Repts 50-413/96-12 & 50-414/96-12 on 960804-31. Violations Noted.Major Areas Inspected:Engineering, Summary of Plant Status & Observations & Findings IR 05000413/19940141994-06-0303 June 1994 Insp Repts 50-413/94-14 & 50-414/94-14 on 940509-20.No Violations Noted.Major Areas Inspected:Isi & Flow Assisted Corrosion IR 05000269/19930321994-01-0606 January 1994 Insp Repts 50-269/93-32,50-270/93-32,50-287/93-32, 50-369/93-31,50-370/93-31,50-413/93-35 & 50-414,respectively on 931213-17.Violations Noted.Major Areas Inpected:Licensee Safeguards Info Program to folow-up on Licensee Repts IR 05000413/19930321993-12-30030 December 1993 Insp Repts 50-413/93-32 & 50-414/93-32 on 931117-19 & 1129-1203.Violations Noted.Major Areas Inspected:Observation of Eddy Current (ET) Exam of SG Tubes,Inservice Activities Including Surface & Volumetric Exams,Review of Radiographs IR 05000413/19930331993-12-23023 December 1993 Insp Repts 50-413/93-33 & 50-414/93-33 on 931129-1203.No Violations Noted.Major Areas Inspected:Isi of Pipe Supports & Snubbers & TS Surveillance of Snubbers IR 05000413/19930311993-12-22022 December 1993 Insp Repts 50-413/93-31 & 50-414/93-31 on 931107-1204.No Violations Noted.Major Areas Inspected:Plant Operations, Maintenance,Engineering,Plant Support & follow-up of Previously Identifed Items IR 05000413/19930291993-12-12012 December 1993 Insp Repts 50-413/93-29 & 50-414/93-29 on 931115-19.No Violations Noted.Major Areas Inspected:Occupational Radiation Safety,Organization & Mgt Controls,Training & Qualification,Audits & Appraisals IR 05000413/19930281993-12-10010 December 1993 Insp Repts 50-413/93-28 & 50-414/93-28 on 931101-05.No Violations Noted.Deviation Noted.Major Areas Inspected: Adequacy of Licensee Programs,Procedures & Supporting Documentation for Implementation of Station Blackout Rule 1999-09-24
[Table view] Category:UTILITY
MONTHYEARIR 05000413/19900281990-10-26026 October 1990 Insp Repts 50-413/90-28 & 50-414/90-28 on 901001-04. Violations Noted.Major Areas Inspected:Physical Security Program for Power Reactors W/Emphasis on Compensatory Measures & Records & Repts IR 05000413/19900251990-10-11011 October 1990 Insp Rept 50-413/90-25 & 50-414/90-25 on 900924-28.No Violations Noted.Major Areas inspected:post-refueling Startup Tests for Both Units & Core Performance Surveillance Performed on Unit 2 IR 05000413/19900241990-09-27027 September 1990 Insp Repts 50-413/90-24 & 50-414/90-24 on 900803-0905. Violations Noted.Major Areas Inspected:Plant Operations, Surveillance Observation,Maint Observation,Review of LERs & Followup of Previously Identified Items IR 05000413/19900231990-09-10010 September 1990 Insp Repts 50-413/90-23 & 50-414/90-23 on 900730-0803.No Violations or Deviations Noted.Major Areas Inspected: Radiation Protection Program in Areas of Internal & External Exposure & Contamination Control & ALARA IR 05000413/19900191990-08-30030 August 1990 Insp Repts 50-413/90-19 & 50-414/90-19 on 900624-0802. Violations Noted.Major Areas Inspected:Plant Operations, Refueling Activities,Surveillance/Maint Observations,Review of LERs & Followup of Previously Identified Items IR 05000413/19900201990-08-28028 August 1990 Insp Repts 50-413/90-20 & 50-414/90-20 on 900724-26. Unresolved Item Identified.Major Areas Inspected: fitness-for-duty Program IR 05000413/19900221990-07-30030 July 1990 Insp Repts 50-413/90-22 & 50-414/90-22 on 900709-13.No Violations or Deviations Noted.Major Areas Inspected:Records Review of Maint Activities Following 5-yr Insp of Emergency Diesel Generator 2A & Review of Test Procedures IR 05000413/19900211990-07-19019 July 1990 Insp Repts 50-413/90-21 & 50-414/90-21 on 900627-29.No Violations or Deviations Noted.Major Areas Inspected:Main Steam Safety Relief Valve Setpoint Testing & Maint & Repair of Coatings on Steel Containment Vessel ML20056A5101990-07-19019 July 1990 Insp Repts 50-413/90-15 & 50-414/90-15 on 900527-0623. Violation Noted.One Noncited Violation Noted.Major Areas Inspected:Review of Plant Operations,Surveillance Observation & Maint Observation IR 05000413/19900181990-07-11011 July 1990 Insp Repts 50-413/90-18 & 50-414/90-18 on 900625-29.No Violations Noted.Major Areas Inspected:Inservice Insp & Maint,Including Plan for Outage,Reviews of NDE Procedures & Independent Exam of Verifications IR 05000413/19900161990-07-0909 July 1990 Insp Repts 50-413/90-16 & 50-414/90-16 on 900611-15. Violations Noted But Not Cited.Major Areas Inspected: Conformance to Reg Guide 1.97 & Instrumentation for Light water-cooled Nuclear Power Plants During Accidents IR 05000413/19900141990-06-13013 June 1990 Partially Withheld Physical Security Insp Repts 50-413/90-14 & 50-414/90-14 on 900521-25 (Ref 10CFR2.790(d) & 73.21).No Violations or Deviations Noted.Major Areas Inspected: Physical Barriers & Security Sys Power Supply IR 05000413/19890281989-10-10010 October 1989 Partially Withheld Insp Repts 50-413/89-28 & 50-414/89-28 on 890911-15 (Ref 10CFR2.790(d) & 73.21)Violations Noted.Major Areas Inspected:Mgt Support,Security Program Plans,Audits, Detection & Assessment Aids & Testing & Maint IR 05000413/19890251989-09-25025 September 1989 Insp Repts 50-413/89-25 & 50-414/89-25 on 890801-28 & 0912-15.Violations Being Considered for Enforcement.Major Areas Inspected:Two Events Re Overspeeding & Tripping of Auxiliary Feedwater Pump IR 05000413/19890261989-09-20020 September 1989 Insp Repts 50-413/89-26 & 50-414/89-26 on 890821-24.No Violations or Deviations Noted.One Unresolved Item Identified.Major Areas Inspected:Organization & Mgt Controls & Maintaining Radiation Exposures ALARA IR 05000413/19890241989-09-0707 September 1989 Insp Repts 50-413/89-24 & 50-414/89-24 on 890807-11.No Violations Noted.Major Areas Inspected:Physical Security Program for Program Power Reactors IR 05000413/19890221989-08-22022 August 1989 Insp Repts 50-413/89-22 & 50-414/89-22 on 890723-28.No Violations or Deviations Noted.Major Areas Inspected:Fire Protection & Followup on Previously Identified Insp Items IR 05000413/19890201989-08-11011 August 1989 Insp Repts 50-413/89-20 & 50-414/89-20 on 890717-21.No Violations or Deviations Noted.Major Areas Inspected:Environ Qualification of Electrical Equipment,Generic Ltr 83-28 & NRC Bulletins 88-001 & 88-003 IR 05000413/19890181989-08-11011 August 1989 Insp Repts 50-413/89-18 & 50-414/89-18 on 890717-21. Violation Re Turbine Bldg Sump Analyses Noted But Not Cited. Major Areas Inspected:Chemistry,Liquid Waste Controls & Previously Identified Inspector Followup Items IR 05000413/19890231989-08-0303 August 1989 Partially Withheld Insp Repts 50-413/89-23 & 50-414/89-23 on 890728 (Ref 10CFR2.790 & 73.21)).Violations Noted.Major Area Inspected:Security Event Logs ML20247R7511989-07-24024 July 1989 Insp Repts 50-413/89-16 & 50-414/89-16 on 890528-0701.Two Violations & One Deviation Noted.Major Areas Inspected:Plant Operations,Surveillance Observation,Maint Observation, Licensee Nonroutine Event Repts & Part 21 Insps IR 05000413/19890171989-07-13013 July 1989 Partially Withheld Insp Repts 50-413/89-17 & 40-414/89-17 on 890605-09.Violations Noted Re Protected Area Access Controls & Visitor Controls.Major Areas Inspected:Mgt Support, Security Program Plans & Audits & Physical Barriers IR 05000413/19890191989-07-13013 July 1989 Insp Repts 50-413/89-19 & 50-414/89-19 on 890616-0628. Violations Noted.Major Areas inspected:890616 Event Re Channels of Reactor Vessel Level Instrumentation Sys Inoperable for Period of Time in Excess of Tech Specs ML20246P7321989-07-10010 July 1989 Insp Repts 50-413/89-09 & 50-414/89-09 on 890410-0505. Violations Noted.Major Areas Inspected:Various Plant Groups Including Operations,Maint,Qa,Engineering & Training in Support of Safe Plant Operations IR 05000413/19890151989-06-27027 June 1989 Insp Repts 50-413/89-15 & 50-414/89-15 on 890430-0527. Violation Noted Re Failure to Meet Overtime Restriction Requirements & Unlocked Valves.Major Areas Inspected:Plant Operations,Surveillance & Maint Observations & Plant Mods IR 05000413/19890131989-06-27027 June 1989 Insp Repts 50-413/89-13 & 50-414/89-13 on 890326-0429. Violations Noted.Major Areas Inspected:Review of Plant Operations,Surveillance Observation,Maint Observation & Review of Licensee Nonroutine Event Repts IR 05000413/19890121989-06-0606 June 1989 Corrected Page to Insp Repts 50-413/89-12 & 50-414/89-12. No Violations or Deviations Noted.Major Area Inspected: Annual Radiological Emergency Response Exercise on 890427 ML20245F3421989-05-23023 May 1989 Insp Repts 50-413/89-12 & 50-414/89-12 on 890425-28.No Violations or Deviations Noted.Major Areas Inspected: Observation & Evaluation of Annual Radiological Emergency Response Exercise IR 05000413/19890111989-05-18018 May 1989 Insp Repts 50-413/89-11 & 50-414/89-11 on 890417-21.No Violations or Deviations Noted.Major Areas Inspected: Radiation Protection Activities During Extended Outages & Control of Radioactive Matls & Surveys IR 05000413/19890101989-05-0202 May 1989 Insp Repts 50-413/89-10 & 50-414/89-10 on 890403-07 & 13. Violations Noted.Major Areas Inspected:Liquid & Gaseous Radwaste,Plant Chemistry,Environ Monitoring,Confirmatory Measurements & Followup on Previously Identified Items IR 05000413/19890071989-04-20020 April 1989 Insp Repts 50-413/89-07 & 50-414/89-07 on 890226-0325. Violations Noted.Major Areas Inspected:Plant Operations, Surveillance Observation,Maint Observation & Review of Licensee Nonroutine Event Rept IR 05000413/19890081989-04-19019 April 1989 Insp Repts 50-413/89-08 & 50-414/89-08 on 890313-14,16-17 & 27-31.No Violations or Deviations Noted.Major Areas Inspected:Inservice Insp Program Implementing Procedures, Reviews of NDE Procedures & Personnel Qualifications ML20244A8991989-03-29029 March 1989 Insp Repts 50-413/89-05 & 50-414/89-05 on 890204-25. Violations Noted.Major Areas Inspected:Review of Plant Operations,Surveillance Observation,Maint Observation & Review of Nonroutine Event Repts IR 05000413/19890041989-03-13013 March 1989 Insp Repts 50-413/89-04 & 50-414/89-04 on 890213-17.No Violations or Deviations Noted.Major Areas Inspected: Emergency Preparedness Program to Determine If Program Maintained in State of Operational Readiness Re Emergencies ML20246L6721989-03-0303 March 1989 Insp Repts 50-413/89-02 & 50-414/89-02 on 890130-0203. Violations Noted.Major Areas Inspected:Preoutage Planning, Preparations & Mgt Support for Implementing Licensee Radiation Protection Program ML20236A2241989-02-25025 February 1989 Resident Insp Repts 50-413/88-38 & 50-414/88-38 on 881127-890204.One Strength,One Weakness & One Apparent Violation Identified.Major Areas Inspected:Plant Operations, Surveillance Testing,Maint Observation & Procedures Review IR 05000413/19890031989-02-23023 February 1989 Insp Repts 50-413/89-03 & 50-414/89-03 on 890130-0203.One Weakness Identified Re Photomultiplier Tube.Major Areas Inspected:Design Changes,Plant Mods & Licensee Action on Previously Identified Insp Findings ML20206J5961988-11-15015 November 1988 Insp Repts 50-413/88-34 & 50-414/88-34 on 880926-1025. Violations Noted.Major Areas Inspected:Plant Operations, Surveillance Observation,Maint Observation & Review of Licensee Nonroutine Event Repts IR 05000413/19880331988-10-14014 October 1988 Insp Repts 50-413/88-33 & 50-414/88-33 on 880826-0925. Violations Noted.Major Areas Inspected:Review of Plant Operations,Surveillance Observation,Maint Observation & Review of Licensee Nonroutine Event Repts IR 05000413/19880301988-09-20020 September 1988 Insp Repts 50-413/88-30 & 50-414/88-30 on 880726-0826.No Violations Noted.Major Areas Inspected:Review of Plant Operations,Surveillance Observation,Maint Observation,Review of Licensee Nonroutine Event Repts & Part 21 Repts IR 05000413/19880271988-09-0909 September 1988 Insp Repts 50-413/88-27 & 50-414/88-27 on 880719-22. Violations Noted.Major Areas Inspected:Radiation Protection, Including Organization & Mgt Controls,Solid Waste Program, Transportation & Licensee Action on Previous Insp Findings IR 05000414/19880311988-09-0808 September 1988 Partially Withheld Insp Repts 50-413/888-31& 50-414/88-31 on 880815-19 (Ref 10CFR2.790 & 73.21).No inspector-identified Violations or Deviations Noted.Major Areas Inspected:Testing & Maint & Physical Barriers - Protected Area ML20154E9461988-09-0606 September 1988 Page 11 to Insp Repts 50-413/88-25 & 50-414/88-25 IR 05000413/19880261988-09-0202 September 1988 Insp Repts 50-413/88-26 & 50-414/88-26 on 880801-05.No Violations Noted.Major Areas Inspected:Qa & Confirmatory Measurements for in-plant Radiochemcial Analysis ML20154A6241988-08-31031 August 1988 Insp Repts 50-413/88-29 & 50-414/88-29 on 880801-05. Violation Noted.Major Areas Inspected:Areas of Catawba Safety Review Group Activities & 10CFR21 Reportability Determinations IR 05000413/19880281988-08-23023 August 1988 Insp Repts 50-413/88-28 & 50-414/88-28 on 880725-29.No Violations or Deviations Noted.Major Areas Inspected:Liquid & Gaseous Waste Mgt,Effluent Sampling,Monitoring & Analysis & Radiological Environ Monitoring ML20153C5451988-08-19019 August 1988 Insp Repts 50-413/88-25 & 50-414/88-25 on 880626-0725. Violations Noted.Major Areas Inspected:Plant Operations, Surveillance & Maint Observations,Review of LERs & Followup of Previously Identified Items & NRC Bulletins ML20151E5681988-07-0808 July 1988 Insp Repts 50-413/88-22 & 50-414/88-22 on 880526-0625. Violations Noted.Major Areas Inspected:Plant Operations, Surveillance & Maint Observations,Review of Licensee Nonroutine Event Repts & Previously Identified Items IR 05000413/19880231988-06-22022 June 1988 Partially Withheld Insp Repts 50-413/88-23 & 50-414/88-23 on 880607-10.Violation Noted.Major Areas Inspected:Security Plan & Implementing Procedures,Mgt Effectiveness,Security Program & Organization,Records & Repts & Alarm Stations IR 05000413/19880191988-06-21021 June 1988 Insp Repts 50-413/88-19 & 50-414/88-19 on 880517-20 & 0603. No Violations or Deviations Noted.Major Areas Inspected: Emergency Plan & Implementing Procedures,Emergency Facilities & Organization & Mgt Control 1990-09-27
[Table view] Category:TEXT-INSPECTION & AUDIT & I&E CIRCULARS
MONTHYEARIR 05000413/19993021999-10-12012 October 1999 NRC Operator Licensing Retake Exam Repts 50-413/99-302 & 50-414/99-302 (Including Completed & Graded Tests) for Tests Administered on 990921-23.Two Out of Three RO Candidates & One SRO Passed Retake Exam IR 05000413/19993011999-09-30030 September 1999 NRC Operator Licensing Exam Repts 50-413/99-301 & 50-414/99-301 (Including Completed & Graded Tests) for Tests Administered on 990524-27,0603,07-10 & 16.Eight of Fourteen Applicants Passed Exam IR 05000413/19990051999-09-24024 September 1999 Insp Repts 50-413/99-05 & 50-414/99-05 on 990718-0828. Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19990041999-08-13013 August 1999 Insp Repts 50-413/99-04 & 50-414/99-04 on 990606-0717. Non-cited Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support ML20210H2211999-07-22022 July 1999 Notice of Violation from Insp on 990314-0424.Violation Noted:Sss Was Not Inoperable for Thirteen Days Because Electrical Breakers Associated with SSS Motor Control Ctr Were Mispositioned ML20209E2831999-07-0101 July 1999 Insp Repts 50-413/99-03 & 50-414/99-03 on 990425-0605. Non-cited Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support IR 05000413/19990111999-06-0202 June 1999 Insp Repts 50-413/99-11 & 50-414/99-11 on 990422-23 & 0503. No Violations Noted.Major Areas Inspected:Licensee Identified Frost & Ice Buildup Which Affected Unit 1 Ice Condenser Lower Inlet Doors IR 05000413/19990021999-05-20020 May 1999 Insp Repts 50-413/99-02 & 50-414/99-02 on 990314-0424.No Violations Noted.Major Areas Inspected:Aspects of Licensee Operations,Maint,Engineering & Plant Support PNO-II-99-017, on 990515,indication of Main Generator Ground Fault Was Received While Performing Turbine Startup in Preparation for Placing Unit on Line.Licensee Is Conducting Investigation to Determine Actual Cause of Ground1999-05-18018 May 1999 PNO-II-99-017:on 990515,indication of Main Generator Ground Fault Was Received While Performing Turbine Startup in Preparation for Placing Unit on Line.Licensee Is Conducting Investigation to Determine Actual Cause of Ground ML20206U4161999-05-10010 May 1999 Insp Repts 50-413/99-10 & 50-414/99-10 on 990314-0424. Violation Being Considered for Escalated Enforcement Action Noted.Major Areas Inspected:Operations PNO-II-99-015, on 990503,shutdown in Excess of 72 H Occurred. Licensee Is Still Conducting Investigation Into Cause of Main Generator Protection Lockout & Making Preparations to Inspect & Remove Any Excessive Fouling from Inside Afws1999-05-0505 May 1999 PNO-II-99-015:on 990503,shutdown in Excess of 72 H Occurred. Licensee Is Still Conducting Investigation Into Cause of Main Generator Protection Lockout & Making Preparations to Inspect & Remove Any Excessive Fouling from Inside Afws IR 05000413/19990011999-04-0606 April 1999 Insp Repts 50-413/99-01 & 50-414/99-01 on 990124-0313. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support ML20207A5881999-02-17017 February 1999 Notice of Violation from Insp on 981213-990123.Violation Noted:Licensee Made Change to Procedures as Described in Updated Final Safety Analysis Rept & Failed to Perform Written Safety Evaluation IR 05000413/19980121999-02-17017 February 1999 Insp Repts 50-413/98-12 & 50-414/98-12 on 981213-990123. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19980111999-01-11011 January 1999 Insp Repts 50-413/98-11 & 50-414/98-11 on 981101-1212.No Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19980151999-01-0404 January 1999 Insp Repts 50-413/98-15 & 50-414/98-15 on 981102-06 & 16-20. No Violations Noted.Major Areas Inspected:Licensee Corrective Action Program by Sampling Activities Defined in Nuclear Sys Directive 210,rev 1 IR 05000413/19980161998-12-0404 December 1998 Insp Repts 50-413/98-16 & 50-414/98-16 on 980915-1101.No Violations Rept Encl.Major Areas Inspected:Licensee Maint, Surveillance & Engineering Programs Involving Unit 2 Ice Condenser IR 05000413/19980101998-11-23023 November 1998 Insp Repts 50-413/98-10 & 50-414/98-10 on 980927-1031.No Violations Noted.Major Areas Inspected:Licensee Operations, Engineering & Plant Support ML20155B3821998-10-19019 October 1998 Insp Repts 50-413/98-13 & 50-414/98-13 on 980807-0915. Apparent Violations Being Considered for Escalated Enforcement Action.Major Areas Inspected:Review Ice Condenser Related Problems,Which Led to Forced Shutdown ML20154C4301998-09-14014 September 1998 Notice of Violation from Insp on 980705-0815.Violation Noted:Licensee Failed to Establish Adequate Surveillance Procedures IR 05000413/19980081998-09-14014 September 1998 Insp Repts 50-413/98-08 & 50-414/98-08 on 980705-0815. Violations Noted.Major Areas Inspected:Operations,Maint & Engineering PNO-II-98-037A, on 980807,update Shutdown in Excess of 72 H Made.Licensee Has Cleaned & Satisfactorily Inspected IC Flow Channels.Licensee Identified Discrepancies in Bolting of IC Intermediate Deck Door Frames & Hinges.Conditions Addressed1998-08-28028 August 1998 PNO-II-98-037A:on 980807,update Shutdown in Excess of 72 H Made.Licensee Has Cleaned & Satisfactorily Inspected IC Flow Channels.Licensee Identified Discrepancies in Bolting of IC Intermediate Deck Door Frames & Hinges.Conditions Addressed IR 05000413/19980091998-08-26026 August 1998 Insp Repts 50-413/98-09 & 50-414/98-09 on 980816-0826. Examples of Two Apparent Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support PNO-II-98-037, on 980808,shutdown in Excess of 72 H Occurred. Licensee Inspected Approximately Half of Unit 2 Ice Condenser Bay Flow Channels from Intermediate Deck W/No Ice Obstructions in Excess of TS Limit Identified1998-08-10010 August 1998 PNO-II-98-037:on 980808,shutdown in Excess of 72 H Occurred. Licensee Inspected Approximately Half of Unit 2 Ice Condenser Bay Flow Channels from Intermediate Deck W/No Ice Obstructions in Excess of TS Limit Identified ML20236V7351998-07-27027 July 1998 Notice of Violation from Insp on 980524-0704.Violation Noted:Licensee Failed to Identify & Take Prompt C/A Following Unit 1 Upper Surge Tank over-temp Events on 960120,980111 & 0507 IR 05000413/19980071998-07-27027 July 1998 Insp Repts 50-413/98-07 & 50-414/98-07 on 980524-0704. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support,Including Physical Security IR 05000413/19980051998-06-22022 June 1998 Insp Repts 50-413/98-05 & 50-414/98-05 on 980412-0523.No Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support ML20236J7471998-06-11011 June 1998 Notice of Violation from Insp on 980222-0411.Violation Noted:Adminstrative & Surveillance Procedures Not Implemented as Evidenced by Listed Examples IR 05000413/19980061998-06-0505 June 1998 Insp Repts 50-413/98-06 & 50-414/98-06 on 980511-15. Violations Noted.Major Areas Inspected:Facts Surrounding Event Associated W/Degradation of CNS Unit Auxiliary Feedwater Sys During Rapid down-power on 980507 PNO-II-98-025, on 980507,AFW Sys Declared Inoperable.Licensee Isolated Valves 1CM-127 & 2CM-127 in Units 1 & 2, Respectively,To Prevent Recurrence Until Permanent Corrective Actions Can Be Developed1998-05-11011 May 1998 PNO-II-98-025:on 980507,AFW Sys Declared Inoperable.Licensee Isolated Valves 1CM-127 & 2CM-127 in Units 1 & 2, Respectively,To Prevent Recurrence Until Permanent Corrective Actions Can Be Developed IR 05000413/19980031998-04-30030 April 1998 Insp Repts 50-413/98-03 & 50-414/98-03 on 980222-0411. Violations Being Considered for Escalated Enforcement Action.Major Areas Inspected:Aspects of Licensee Operations, Maint,Engineering & Plant Support IR 05000413/19980041998-04-20020 April 1998 Insp Repts 50-413/98-04 & 50-414/98-04 on 980302-06.No Violations Noted.Major Areas Inspected:Observation & Evaluation of Biennial Emergency Preparedness Exercise for Plant ML20217G5661998-03-23023 March 1998 Insp Repts 50-413/98-01 & 50-414/98-01 on 980111-0221. Violations Noted.Major Areas Inspected:Operation,Maint, Engineering & Plant Support ML20217G5551998-03-23023 March 1998 Notice of Violation from Insp on 980111-0221.Violation Noted:Licensee Failed to Perform Written Safety Evaluation for Closing Valves 1CA-6 & 2CA-6 IR 05000413/19980021998-02-17017 February 1998 Partially Withheld Insp Repts 50-413/98-02 & 50-414/98-02 on 980112-13 (Ref 10CFR2.790).No Violations Noted.Major Areas Inspected:Plant Support,Including Malevolent Use of Vehicles at Plant ML20203L6301998-02-0909 February 1998 Insp Repts 50-413/97-15 & 50-414/97-15 on 971123-980110. Violations Noted.Major Areas Inspected:Operations,Maint & Plant Support ML20203L6251998-02-0909 February 1998 Notice of Violation from Insp on 971123-980110.Violation Noted:Changes to Radiological Conditions in 1B Residual Heat Removal Pump Room Not Logged to Reflect Changes in Dress Requirements ML20199L6301998-02-0202 February 1998 Notice of Violation from Insp & Exam on 971117-21 & 971201-19.Violation Noted:As of 971219,selected Officers from Site Security Force Had Not Been Retrained to Perform non-licensed Operator Emergency Tasks for Starting Ssf PNO-II-97-066, on 971230,RCS Leakage Requiring Forced Unit Cooldown Occurred.No Radioactive Release Outside of Reactor Containment Facilities Due to Leakage.Licensee Informed States on Nc & Sc1997-12-31031 December 1997 PNO-II-97-066:on 971230,RCS Leakage Requiring Forced Unit Cooldown Occurred.No Radioactive Release Outside of Reactor Containment Facilities Due to Leakage.Licensee Informed States on Nc & Sc PNO-II-97-064, on 971229,inadvertent Safety Injection Occurred Due to Operators Failing to Perform Step Which Resulted in Cold Leg Injection Valve Being Left Open. Licensee Engineers Performing Evaluation1997-12-29029 December 1997 PNO-II-97-064:on 971229,inadvertent Safety Injection Occurred Due to Operators Failing to Perform Step Which Resulted in Cold Leg Injection Valve Being Left Open. Licensee Engineers Performing Evaluation ML20197F2481997-12-19019 December 1997 Notice of Violation from Insp on 971012-1122.Violation Noted:Licensee Failed to Follow Radiation Protection Procedures in That,Current Radiation Dose Rates Were Not on Vacuum Cleaner Label as Required IR 05000414/19970081997-12-19019 December 1997 Notice of Deviation from Insp on 971012-1122.Deviation Noted:On 971020,licensee Had Not Performed Alarm Set Point Adjustment Evaluation Discussed in Violation 50-414/97-08-01 ML20197F2861997-12-19019 December 1997 Insp Repts 50-413/97-14 & 50-414/97-14 on 971012-1122. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support ML20199G0351997-11-10010 November 1997 Notice of Violation from Insp on 970831-1011.Violations Noted:Licensee Failed to Follow Procedures for Security Badge Access Control as Evidenced.On 970909,security Failed to Destroy & Unassign Access Badge of Terminated Individual IR 05000413/19970121997-11-10010 November 1997 Insp Repts 50-413/97-12 & 50-414/97-12 on 970831-1011. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support as Well as Results of Announced Inspection by Regional Security Inspector ML20211L3051997-09-26026 September 1997 Notice of Violation from Insp on 970720-0830.Violation Noted:On 970727,technician Failed to Correctly Review Drawing Number CNEE-2792-01.02,connection Diagram,Main Steam Sys Terminal Cabinet 2SMTC1,rev 12 IR 05000413/19970111997-09-26026 September 1997 Insp Repts 50-413/97-11 & 50-414/97-11 on 970720-0830. Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000413/19970101997-09-11011 September 1997 Insp Repts 50-413/97-10 & 50-414/97-10 on 970623-0731.No Violations Noted.Major Areas Inspected:Licensee Calculations,Analysis & Other Engineering Documents ML20210N7341997-08-18018 August 1997 Insp Repts 50-413/97-09 & 50-414/97-09 on 970608-0719. Violations Noted.Major Areas Inspected:Aspects of Licensee Operations,Maint,Engineering & Plant Support ML20210N7111997-08-18018 August 1997 Notice of Violation from Insp on 970608-0719.Violation Noted:On 970424,operations Test Group Technician Failed to Open Valve 2NV-873 as Required by Step 2.2.3 of PT/2/A/4200/01C,resulting in Closed Test Vent Flowpath 1999-09-30
[Table view] |
See also: IR 05000413/1989002
Text
c ,
\
I. 1 J
5
b. . .
'"
.
- f'p o%g4L UNITED STATES
1
j
,
[ NUCLEAR REGULATORY COMMISSION -
'o.
lf- REGION il
101 MARIETTA ST., N.W. q
eo,, ATLANTA, GEORGIA 30323 g
t
i
11AR 0 31989
Report Nos.: 50-413/89-02 and 50-414/89-02
Licensee: Duke Power Company
.422 South Church Street
Charlotte, NC 28242
Dccket Nos.: 50-413 and 50-414 License Nos.: NPF-35 and NPF-52
-Facility Name: Catawba 1 and 2
, . Inspection Conducte : J nuar 30 - February 3, 1989
Inspector: 8 /
A F. N(Wright pifeSigned
Approved by:
J. M Potter, Chief
8 /f
D'at'e Signed
.
Facilities Radiation Protection Section
Emergency Preparedness and Radiological Protection
Branch
Division of Radiation Safety and Safeguards
SUMMARY
Scope
This routine, unannounced inspection was conducted in the areas of pre-outage
planning, preparations, and management support for implementing the licensee's
radiation protection program. The review included: licensee organization and
management controls; maintaining occupational exposures as low as reasonably
achievable (ALARA); training and qualifications; outage preparations and
provisions; and licensee action on previously identified inspection findings.
Results
Two violations of NRC requirements were identified:
1. Failure to take adequate timely corrective action on NRC identified
violations.
2. Failure to provide licensee workers adequate training on the
. significance of yellow flashing lights, and failure to post the
L
'
associated high radiation area. This was similar to a violation
concerning training cited in a Notice of Violation issued
September 16, 1988.
The input from section supervisors on methods to further reduce
l
occupational radiation exposure was found to be minimal, although the
!
8903240244 890303 P
gDR ADDCK 05000413
PNU ig
- _ = - _ -
.
.---
- - - - - - . - - - _ - - - - - - - _ - _ _ _ ,
n. .
.
.
2
person-rem totals per unit were low for a facility having two partial
refueling outages during the year.
The outage radiological controls were generally effective even
though there had been a reduction in radiation protection technician
support when compared to previous outages.
l
!
l
l
1
l
_ _ _ _ _ _ _ _ . _ _ . - _ - _ - - - i
- _
_ _ _ - _ _ - _ - _ - - _. _ _ _
- _ _ _
- __ _
.
.
. .
.
REPORT DETAILS j
i
L1. Persons Contacted
'
Licensee Employees
- V. _Barbour, . Quality Assurance, Director of Operations 1
W. Bradley, Manager, Quality-Assurance Verification !
- W. Deal, Station Health Physicist :
A. Duckworth, Director, Technical Services Training
- R. Glover, Compliance Engineer
'*V. King, Compliance Engineer
- P. LeRoy, Regulatory Compliance
T. Owens~ Station Manager ,
R. Rivard, ALARA Planning Supervisor
Other' licensee employees contacted during this inspection included
technicians and office personnel.
Nuclear Regulatory-Commission
- M. Lesser, Resident Inspector
- W. Orders, Senior Resident Inspector
2. Organization'n and Management Controls
Through interviews with the licensee's staff, the inspector reviewed-the
licensee's health physics (HP) outage organization plans, staffing levels,
lines of_ authority and degree of interaction with other plant work groups,
a. Health Physics Organization
The licensee had a HP staff which was' highly specialized, in that,
the staff was divided into small units having specific areas of
responsibility. During refuelina outages the licensee's four
surveillance and control (SC) orups were deployed to provide
continuous HP outage support in the auxiliary and containment
buildings.
The licensee used contract HP supervisors for steam generator and
auxiliary building work. The licensee contracted with approximately
ten supervisors and one hundred ANSI qualified HP technicians to
provide for outage surveillance and control activities. In areas
where. the licensee did' not have utility employee supervisors, the
licensee tries to place experienced ANSI qualified licensee HP
'
technicians to control work. The licensee also used contract
technicians and clerical help in the HP support units.
j
. --_--_~_-.-a a .--
- - . - _ .- - - - - _ - - - - . - - - - - - - - - - - - -
.
.
.
2 i
l
Through interviews with licensee representatives, the inspector
determined that the ' licensee had used approximately 180 contract HP
support personnel during previous outages. During the Unit 1 Cycle 3
outage, the licensee had reduced the number of contract support
personnel by 10 percent and was planning to have 15 fewer contract j
support personnel during the Unit 2 Cycle 2 refueling outage. These j
reductions were being made in the licensee's radiation protection j
staffing levels in an effort to reduce utility expenses. Licensee
'
representatives, in the HP section, reported that the reductions in
outage staffing levels had not adversely affected the licensee's
ability to implement the radiation protection program. Except as
noted in Paragraph 2.c. and 4 of this report, the inspector found that
appropriate radiological controls were being implemented with this
reduced staffing-level.
No violations or deviations were identified.
b. Licensee Audits 3
!
Technical Specification (TS) 6.11 requires that procedures for
personnel radiation protection be prepared consistent with the
requirement of 10 CFR 20 and be approved, maintained, and adhered to
for all operations involving personnel radiation exposure.
Catawba Nuclear Station (CNS) Directive 3.8.3, Contamination
Prevention, Control and Decontamination Responsibilities,
,
Revision 24, dated November 29, 1988, requires in Section 4.6.2.2
that personnel perform a survey for contamination when leaving a
radiation control area (RCA). If frisking just the hands and feet, a
minimum frisk of 40 seconds is required.
CNS Directive 3.8.6 (TS), Radiation Exposure Control, Revision 17,
dated November 21, 1988, requires in Section 2.7 that all individuals
complete a Daily Exposure Time Record Card (DETRC) for each entry
into the RCA/ radiation control zone (RCZ) and each change of I
radiation work permit (RWP).
The inspector reviewed licensee Quality Assurance (QA) Surveillance
Audit CN-88-34 which was conducted December 5-9, 1988. The
surveillance reported the following radiological control findings on
January 27, 1989.
(1) Employees were exiting an RCA from areas that cre not normal i
exit points (i.e., back door of Auxiliary Building, !
elevation 594' and Unit 1 Control Room location).
(2) Hand held items were not being frisked.
(3) Dose cards were not being completed for each entry / exit of RCA
(mostly at Unit 2 entry / exit point)
.
- - - - - - - -
,
.
.
. .
3
(4) A HP Technician (Vendor) was reaching into the RCZ and
performing work without being dressed in accordance with the
RWP.
As a result of the findings, the licensee terminated the vendor HP
technician that had violated the RWP requirements. The Station
Health Physicist also issued a letter to station management
concerning the audit. The letter, Intrastation Letter to Group
Superintendents and Section H ea.ds , issued December 29, 1988,
addressed radiation protection practices relative to the QA
-Surveillance Audit CN-88-34. The letter, in part, discussed the
following conditions:
- Employees were observed exiting the RCA at points other than the
Single Point Access (SPA). The exit points observed did not
meet procedural requirements for emergency conditions or
escorting of material. One observed exit at the Material j
Control Point did not include the required hand and foot frisk. i
Several exits were discovered to be into and out of the Control
Room using the Unit 1 side access, as well as the access door to
the ventilation equipment room. Both doors were clearly marked
as not being an exit and, in addition, did not have any frisking
equipment.
- A similar situation was discovered by HP when personnel were !
detected exiting at the 560' elevation below the SPA. This exit
also had no frisking equipment available. This door was clearly
marked as not being an RCA exit. These persons were challenged
and given preper instruction.
- Frisks of hand held items were observed to be inadequate (not
frisked at all or frisked too fast). Many of these observations
were made at the Unit 2 Control Room entrance / exit.
- Dose cards were not completed for each entry / exit from the RCA.
Most of these observations also occurred at the Unit 2 Control
Room extrance/ exit. For these observations, the individual was
identified by the auditor, and dose card records were audited
the next day and no dose record was available.
- A contract HP technician was observed reaching into an RCZ and
performing work without meeting dress requirements. HP action
was to terminate the individual immediately.
In addition, the licensee issued a CNS Radiological Protection
Practices Training Package as an attachment to the letter. The
training package was prepared for section supervisors for use in crew
tailgate meetings. The report findings of hand held items nei being
frisked and dose cards not being completed for each exit of 1he RCA
in accordance with the above requirements were recurring examples of
'
L' 4
-_ - . - - -
. .
. .
. 4
the earlier violation issued in Inspection Report (IR) No. 50-413,
414/87-31'.
c. Management Controls and Corrective Action
10 CFR 50; Appendix B, Criterion XVI states that measures shall be
established to assure that conditions adverse to_ quality, such as
deviations and nonconformances, are promptly identified and
corrected. In the case of significant conditions adverse to quality',
the measures shall assure that the cause of the condition is
determined and corrective action taken to preclude repetition.
TS 6.11 requires that procedures for personnel radiation protection I
be prepared consistent with the requirements of 10 CFR 20 and be
approved, maintained and adhered to for all operations involving i
personnel radiation exposure.
l
CNS Directive 3.8.3, Contamination Prevention, Control and
Decontamination Responsibilities, Revision 24, dated November 29,
1988, requires in Section 4.6.2.2 that personnel perform a survey for
contamination when leaving the RCA. If frisking just the hands and
feet, a minimum frisk of 40 seconds is required.
CNS Directive 3.8.6 (TS), Radiation Exposure Control, Revision 17,
dated November 21, 1988, requires in Section 2.7 that all individuals
complete a DETRC for each entry into the RCA/RCZ and each change of ,
the RWP.
IR No. 50-413, 414/87-31 documented the results of an inspection made
September 14-18, 1987. A Severity Level IV violation (50-413,
414/87-31-02) was issued for failure to adhere to radiological
control procedures in that:
(1) From September 14 to September 17, 1987, ten of twelve
individuals observed frisking at the RCA access / exit point
located at the top of the spiral stairway on the 609' elevation,
frisked for only 20-25 seconds and;
(2) Two individuals who worked inside an RCA/RCZ on the removal,
repair, or replacement of a detector in the Unit 1 Reactor
Building on August 24, 1987, did not complete a daily dose card
as required.
On November 17, 1987, the licensee responded to the violation issued
in IR No. 50-413, 414/87-31 for violation 87-31-02. The NRC reviewed l
'r
the licensee's proposed corrective action and determined that the
proposed corrective action was not sufficient to prevent recurrence, (j
and a supplemental response was received dated December 11, 1987, and
with clarification, it was accepted in an NRC letter dated i
January 15, 1988.
l
1
_--------_----J
_ _ _ --
'I,
'
.
'
5
f .
,
I' !
t
(
,
On' December 10, 1987, the NRC issued IR No. 50-413, 414/87-40. In
Paragraph 7 of the. report, the inspector reported numerous examples
of personnel failing to perform personnel monitoring in accordance
with licensee procedures. The Notice of Violation described a
L failure to properly store contaminated tools and post a copy of a
previous' Notice of Violation.
On April 7,1988, the NRC issued IR No. 50-413,414/88-12 for an
~
i' inspection made on February 22-26, 1988. In Paragraph 4.f of the
report, the inspector reported on discussions held with licensee
representatives.concernin
Single Point Access (SPA)g .
the uses
Licensee and limitations
representatives of the personnel
indicated that
they were still evaluating the adequacy of the SPA in minimizing the
,
. potential of low level contamination leaving the RCA. The inspector
noted that the HP technician nearest to the area was located one
level above and could only be reached by telephone. The
tools / equipment frisking station was also located one elevation above
the exit. Some individuals were confused about whether items frisked
at the tools / equipment frisking station must be frisked again at the -
SPA. . Licensee representatives acknowledged the inspector's comments
and agreed:to evaluate equipment release practices.
The inspector noted that the signs regarding personnel monitoring in
the men's change room, next to friskers indicated that the frisker:
were there for " convenience". Licensee representatives had indicated
that personnel contamination surveys were " required" in the change
rooms when personnel had been working in contaminated areas.
Licensee representatives indicated that they would reevaluate the
adequacy of the signs.
On September 16, 1988, the NRC issued IR No. 50-413, 414/88-27,
documenting a violation involving the failure of operations personnel
to follow radiological control procedures on two occasions during
responses to stop leaks in radioactive systems. The report also
documented the licensee's failure to take full corrective action for
violation 50-413, 414/87-31-02.
The licensee's response to these violations indicated that an
immediate program of HP SPA routine observations would be implemented
to improve compliance with the frisking and dose card requirements
and they would be in full compliance on March 1,1988. However, as
of July 19-22, 1988, the program of routine observations had not been
implemented. The inspector noted that this was the second time in as
many inspections that the licensee had failed to meet all aspects of
their commitments to the NRC by the date established by the licensee.
The cover letter for the September 16, 1988 NRC report discussed the
licensee's failure to take full corrective actions on the violation
50-413, 414/87-31-02, and for another violation 50-413, 414/87-40-03, ;
The cover letter stated that the NRC views failure to take full
'
corrective action on these radiological safety as a serious matter.
i
__c______
-
_ _ _ _ _ _ _ _ _ _
__
_ _ - _ _ _ _ _ _ . _ _ _
. .
, {
6 l
l
'
On October 28, 1988, the licensee issued their response to the
Severity Level IV violation issued in IR No. 50-413, 414/88-27 which
included, management audit of several new records at Catawba such as:
HP Problem Reports
Dose Card Error Reports 4
Single Point Access Logbook
Radiological Incident Investigations
The licensee also discussed continuing management involvement in
ALARA training and pre-outage meetings and that hand and foot
monitors had been purchased and placed in service throughout the
plant. The licensee reported that whole body friskers had been
purchased and would be delivered in late 1988.
The licensee addressed the corrective action associated with the hot
tool room prncedure violation discussed in IR No. 50-413,414/87-40.
-The licensee listed these corrective actions for the root .cause of.
the problems:
Organizational changes were made which allowed the technical and
work execution aspects of the maintenance group to be separated. !
A new position was created that would separate the technical and
executional aspects of a job. The licensee stated that "with
better job planning packages available, the execution crews can
now devote full attention to procedures, training, and improving
performance."
~
The inspector attempted to verify completion of corrective action for
violation 50-413, 414/87-31-02. However, during the inspection, as
detailed in Paragraph 2.b, the inspector noted a QA Surveillance made
in December 1988, which documented additional examples of failure to i
perform contamination frisks in accordance with licensee procedures !
and failure to complete daily dose cards in accordance with licensee
procedures.
1
These findings by the licensee are additional examples of failure to ;
follow procedures and indicate a failure to take adequate and timely !
corrective action sufficient to preclude recurrence of a similar
violation cited on September 16, 1988. Failure to take adequate and
timely corrective action is therefore, a violation of 10 CFR 50,
Appendix B, Criterion XVI (50-413/89-02-01). ;
!
One violation was identified.
3. Outage Planning and ALARA Activities
10 CFR 20.1.c states that persons engaged in activities under licenses
issued by the NRC should make every reasonable effort to maintain
radiation exposures ALARA. The recommended elements of an ALARA program
- - _ __ _-____ _ -
!
I
-
. !
. .
7 ,
i
radiation exposures ALARA. The recommended elements of an ALARA program
are contained in Regulatory Guide 8.8, Information Relevant to Ensuring
That Occupational Radiation Exposure at Nuclear Power Stations will be l
ALARA, and Regulatory Guide 8.10, Operating Philosophy for Maintaining -
Occupation Radiation Exposures ALARA.
a, ALARA
The inspector reviewed the licensee's program for maintaining
occupational exposures ALARA, including the station's ALARA goals and
objectives, the effectiveness in setting and meeting ALARA goals,
participation by different station groups in the ALARA program, and
the functions of the onsite ALARA group.
The licensee's ALARA goal for 1988 was 552 person-rem. The goal was
based on the licensee's task schedule for the year and the licensee's
person-rem exposure history for .the planned work. The integration
scheduling staff provided the ALARA group with a list of planned
tasks. The ALARA group reviewed the job history files and
established an ALARA package for jobs which are expected to exceed
one person-rem exposure. The ALARA packages included detailed job
dose reduction recommendations, copies of RWPs, surveys, and other
information obtained in previous work experience for the job. The
inspector reviewed selected ALARA planning packages and determined
that dose exposure reductions were being made through in depth ,
planning and application of basic ALARA techniques.
Through interviews with licensee representatives, the inspector
determined that the ALARA group had solicited comments and dose
reduction recommendations from section supervisors on the 1988
exposure estimates and that only one supervisor had commented on his
section's estimated exposure for the year. The remaining supervisors
reported that the person-rem estimate determined by the ALARA group
appeared appropriate. In general, the ALARA group set the annual
goal based on their estimates and there was very little input from
the plant staff supervisors to further reduce exposures.
The licensee exceeded its 1988 person-rem goal by approximately four
l person-rem. The licensee's 1988 ALARA goal of 552 person-rem was the
1988 person-rem estimate. While the licensee demonstrated an ability
to accurately project work and implement ALARA techniques to maintain
personnel exposures ALARA, the input from section supervisors on
, methods to further reduce exposures was minimal. However, the 278
l person-rem totals per unit were low for a facility having portions of
j two refueling outages during the year.
l
The inspector attended an outage planning meeting which included key
licensee staff personnel, representatives from Turkey Point, and
corporate staff personnel. The meeting agenda included an open
discussion on lessons learned during the Unit 1 refueling outage and
plans for the upcoming refueling outage. Discussion topics included
- _ _ _ _
. _ _ .
. _ _ . _ _ _ _ _ _ _ _ _ _ . . _ . __ _ _ _ - - __
! ,, .
l . .
l 8
improving worker efficiency, use of mockup . training equipment,
preparation of equipment, improved communications, shielding,
limitations on overtime, training, and exposure-reduction activities.
The inspector observed a free exchange of information in a spirit of'
cooperation to improve work objectives.
The inspector reviewed the following licensee procedures.
ALARA Manual, Revision 3
Maintenance Management Procedure 1.9, CNS ALARA Planning, dited
July 21, 1988
CNS Directive 3.8.1 (TS) ALARA Program, dated August 21, 1988
No violations or deviations were identified.
b. Provisions
Through interviews with licensee representatives the . inspector i
determined that the licensee had established resources to support the '
outage. such as protective clothing, respirators, radiation warning
signs, etc. and had the ability to borrow supplies or equipment from
the utility's other nuclear facilities.
No violations or deviations were identified. .i
c. Training and Qualifications of Vendor Health Physics Technicians !
TS 6.3 requires that each member of the facility staff meet or exceed
the minimum qualifications of ANSI N18.1-1977 for comparable i
positions, except for the Radiation Protection Manager, who shall
'
meet or exceed the qualifications in Regulatory Guide 1.8,
September 1975.
TS 6.4.1 states that a retraining and replacement training program
for the facility staff shall be in accordance with ANSI N18.1-1971.
Paragraph 5.5 of ANSI N18.1 states that a training program shall be
established which maintains the proficiency of the operating
organization through periodic training exercises, instruction
periods, and reviews.
The inspector reviewed plant procedure HP/0/B/1000/19, Vendor Health
Physics Technician Training / Qualification, Revision 0. The inspector
determined that the procedure provides specific guidance for
evaluating the previous work experience of vendor HP technicians in
order to comply with the ANSI N18.1-1971 requirements. The procedure
also specifies the training requirements necessary to meet the
requirements of TS 6.4.1.
No' violations or deviations were identified.
- - _ _ - _ - _ _ - . _.
_ -- - - - - - - - - . - - _ _ _ _ - - - -- _ - - - - - - - - _ - - - - - - - - - - - - - . - . - - - - - - - - - - - - _ - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - _ - _ - - - -
. .
. .
9
4. High Radiation Area Control Event-
10 CFR 19.12 requires a licensee to provide certain specified information
and instructions to individuals who work in or frequent any portion of a
restricted area.
10 CFR 20.203(c)(1) requires a licensee to post each high radiation area -
with a conspicuous sign or signs bearing the radiation caution symbol and '
the words: CAUTION HIGH . RADI ATION AREA. A "high radiation area" is
defined in 10 CFR 20.202(b)(3), as any area, accessible to personnel, in
which there exists radiation, originating in whole or in part within
licensed material, at such levels that a major portion of the body could
receive in any one hour a dose in excess of 100 millirems.
TS 6.12 requires that, for individual high radiation areas accessible to
personnel:with radiation levels of greater than 100 mR/hr that are located
within large areas, such as pressurized water reactor (PWR) containment,
where no enclosure exists for purposes of locking, and where no enclosure
can be reasonably constructed around the individual areas, that individual
area. shall be barricaded, conspicuously posted, and a flashing light shall
be activated as a warning device.
NRC Information Notice (IN) No. 88-79: Misuse of Flashing Lights for High
Radiation Area Controls, was issued on October 7,1988. The Notice was
issued to all holders of operating licenses for nuclear power reactors.
The purpose of the Notice was to alert addressees to problems involving
misuse of flashing lights .for high radiation controls. The Notice
discussed five events involving improper access control of high radiation
areas. As discussed in the Notice, inappropriate use of such access
controls could lead to potentially significant, inadvertent, radiation ;
exposures. Additionally, the Notice stated that it was apparent that
plant workers and supervisors did not fully understand the TS requirements
for high radiation access control.
During the inspection the inspector determined that on December 16, 1988,
two employees apparently entered a high radiation area unknowingly. One
of the two employees was assigned to the Catawba mechanical maintenance
staff and the other was a construction maintenance department (CMD)
employee based at the Oconee facility on site to support the Unit 1
outage.
'
The inspector reviewed the HP Investigation Data sheet which described the
, event and the written statement of the event prepared by the Catawba
I worker. According to the worker, the employees entered lower containment
I
after reviewing RWP No.88-919 and after discussing their work with a HP
representative. The two employees were going to perform preventive
maintenance (PM) on several limitorque operators.
According to the worker's statement, he asked the HP technician if a
respirator would be required for entry and was told that respirators would
not be required for the planned work. The workers checked in with the HP
~
<, ,
\
- - - - - - - - _ - _ - - _ . _ _ _ - - - _ _ _ _ - _ _ _ _ - - _ _ . _ _ - - . - - . - - - _ . - _ _ _ - - _ _ _ - - . _ _ _ . - - - - _ . _ - - - - i
__ _ __
, . ..
. .
10
rover for permission to enter lower containment and were told to proceed.
The- employees climbed down a ladder into lower containment to work on
,
-
their first valve. After completing- work on the first valve the workers ,
crossed over an airduct and up some scaffolding to the second limitorque j
operator. As the men began their paperwork, they were interrupted by HP :
personnel monitoring the B and C steam generator platform and told that
l they were in a respirator required area and a high radiation area. The HP
technician told the men to exit the platform area which had a flashing
yellow light. The workers exited containment, were surveyed, and found to
be' free of external contamination. One worker received only 10 mrem whole
,
body exposure while the second worker received 30 mrem whole body exposure
i for the entry. An air sample taken on the platform did not indicate any
airborne radioactive material .on the steam generator platform.
'
The Catawba worker reported in his write-up of the event that they had not
crossed any identified rope or signs in getting to the platform from
above. The worker also stated that he was unaware of the significance of
'
a flashing yellow light. The HP Investigation Data sheet also documented
that the licensee workers had entered the platform area from above and
that the workers did not know the significance of the flashing yellow
'
light.
The.immediate steps taken to prevent recurrence of this type of event was
i
to post the access taken by the workers as a high radiation area. The j
l long-term steps taken to prevent recurrence was to proceduralize the i
posting of the area. The inspector determined that the dose rate on the !
platform was 500 mrem per hour (mr/hr) beta and 500 mr/hr gamma at the
cold leg side of the generator. The dose rate was approximately 35 mr/hr
four feet from the manway. The gamma dose rate twelve inches from the
manway was 300 mr/hr gamma.
Through interviews with the General Employee Training (GET) supervisor,
the inspector determined that the Catawba worker had taken bypass training
for the last four years and that the use and meaning of yellow flashing
[ warning lights was not included in the bypass training. The inspector
contacted the resident inspector at Oconee and determined that, for the
'
CMD employee based at Oconee, the bypass training there also did not
include training on the use and significance of flashing yellow lights.
l Failure of the licensee to provide adequate training for employees
concerning the significance of flashing yellow lights and failure of the
licensee to post accessible areas of a high radiation area in accordance
with the requirements of 10 CFR 20.203(c)(1) are examples of a violation
of NRC requirements of 10 CFR 19.12 requiring the licensee to provide
information and instructions to workers (50-413, 414/89-02-02). This
violation is similar to a violation concerning training cited in a Notice
of Violation issued September 16, 1988, and could reasonably be expected
to have been prevented by previous corrective action.
0ne violation was identified.
- - - - _ -
_ -. _-_- ___-- -_. - __
_ _ _ - _ _ _ _ _ _ - _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ - _ _ _ ..
l
I
. -
.: .
!
11
1
5. Licensee Action on Previous Enforcement Matters (92702)
L (0 pen) Violation 87-31-02: Failure to. adhere to radiological control
! procedures for personnel contamination monitoring and completion of daily
l
dose. cards. The item will remain open since previous implementation of
L licensee corrective actions had not been adequate. . This was exemplified
L by a licensee' audit conducted in December 1988, which reported findings
!
concerning -persons exiting the RCA from areas that were not normal exit
points, - hand held -items not properly surveyed, dose cards not being
completed for each entry and exit portal, and a contract HP technician
reaching in a RCZ and performing work without being dressed in accordance
with the RWP.
6. Exit' Interview
a. Inspector Comments
The inspection included a review of selected QA Surveillance, Outage
Planning and the ALARA program for control of radiation exposures.
Through review of representative records and discussions with
licensee representatives the inspector reviewed the licensee's
planning, preparations, and management support for implementing the
radiation protection program during outages.
The inspector discussed staffing levels for the outage and
determined that due to budget restraints the licensee had
completed the Unit 1 outage with fewer HP vendor technicians
than previously utilized. Licensee representatives reported
that adequate radiation protection controls were maintained even
with the reduced staff during the outage.
The inspector reviewed licensee's utilization of special
training including use of mockup training.
The inspector discussed the licensee's methods for ensuring
adequate supplies were available to support outage activities.
The inspector reviewed selected ALARA work packages and
determined that the licensee was taking steps to reduce
exposures by clearly defining job sequences and taking measures
to improve worker efficiency and lowering personnel exposures.
The inspector reviewed selected documented which demonstrated
that numerous ALARA pre-job planning and post job meetings were
taking place to ensure that persons were adequately prepared for
upcoming work and methods for improving the tasks were being .
evaluated. )
I
The inspector discussed management support for the radiation l
protection program including the purchase of additional
personnel monitors (hand and foot) which were installed and in
- _ _ _ _ _ - - _ - _ _ _ _ _ - _ _
_ _ _ _ _ - _ - _ -
i
-
.
. &
12
!
use. Whole Body Friskers had been purchased and the licensee
had initiated the installation of whole body friskers during the
inspection which should enhance personnel monitoring
capabilities. .,
l
The inspector. reviewed the licensee's GET program and determined
that the instructors were adequately qualified and that lesson ,
plans were well documented. The inspector determined that the ,
l.icensee could provide the general employee training during the
peak periods prior to outage start dates.
The inspector determined that the licensee had an adequate training
program for vendor HP technicians. i
l
b. Inspection Findings !
!
The inspector discussed violation 50-413, 414/87-31-02 issued
October 19, 1987, for failure to adhere to radiological control
procedures for personnel contamination monitoring and completion of
daily dose cards. The item will remain open since previous
implementation of licensee corrective actions had not been
sufficient.
The inspector stated that procedure violations in personnel
monitoring had been documented in the recent radiation protection
inspections. The previously identified violations and those
documented in the licensee's audit report will be reviewed by
Region 11 management for the need to consider additional enforcement ,
actions. The item was left as an unresolved item (URI)*. j
(
Upon review by Region II staff, the licensee's failure to take timely !
corrective actions of radiological protection violations to preclude j
recurrence was identified as a violation of 10 CFR 50, Appendix B, I
Criterion XVI 50-413, 414/89-02-01 (Paragraph 2.c).
During the inspection, the inspector determined that on December 16,
1988, two licensee employees had unknowingly entered a respirator and
high radiation area established for steam generator work. The area
was monitored by a video system and HP personnel took action to
remove the employees from the area. The inspector reviewed the
radiological investigation sheet and the written account of the
event. According to one of the employees they had not crossed any
high radiation or respirator required boundaries until approached by
HP personnel. The employees had noticed a flashing yellow light but
claimed that they did not know the significance of the light. The
inspector determined that the employees did not receive any internal .
contamination, external contamination, or significant external I
exposure. The inspector stated that there appeared to be a violation
- Unresolved items are matters about which more information is required to
i
determine whether they are acceptable or may involve violations or deviations.
_ _ _ _ _ _ _ - _ _ _ _ _ _ _ _ _ _ - .
___ _ _ _ . __ __.
)
\.
l .'
1
.
.
13
l l
- for inadequate GET since neither employee claimed to know the
. significance of flashing yellow lights and/or failure of the licensee
to adequately post a high radiation area. The inspector stated that
the event would be discussed with Region 11 staff following the
inspection.
l The NRC has determined that there were two ' violations; one for
failure to adequately post a high radiation area in accordance with
the requirements of 10 CFR 2.203(c)(1) and one for failure to provide
adequate training for individuals who work in or frequent a
restricted area. The licensee did not identify as proprietary any of
the material provided to or reviewed by the inspector during this
inspection. The inspector expressed his appreciation for the staff
cooperation during the conduct of the inspection.
I
I
!
I
me____________ _m_ _ _ _ _.______ _._ _ _ _ _ .