|
---|
Category:INSPECTION REPORT
MONTHYEARIR 05000382/19990201999-10-21021 October 1999 Insp Rept 50-382/99-20 on 990815-0925.Non-cited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support Activities IR 05000382/19990141999-10-19019 October 1999 Insp Rept 50-382/99-14 on 990913-17 & 1004-08.No Violations Noted.Major Areas Inspected:Operator Requalification Training Program IR 05000382/19990181999-09-29029 September 1999 Insp Rept 50-382/99-18 on 990830-0902.Violations Noted.Major Areas Inspected:Implementation of NRC-approved Fire Protection Program IR 05000382/19990191999-09-27027 September 1999 Insp Rept 50-382/99-19 on 990830-0903.No Violations Noted. Major Areas Inspected:Plant Support IR 05000382/19990151999-09-14014 September 1999 Insp Rept 50-382/99-15 on 990719-23 with in Ofc Insp Until 0819.No Violations Noted.Major Areas Inspected:Assessment of 10CFR50.59 Safety Evaluation Program & Review of Previous Insp Findings Involving Tornado Missile Protection IR 05000382/19990071999-09-0808 September 1999 Insp Rept 50-382/99-07 on 990601-11.Noncited Violations Identified.Major Areas Inspected:Operations IR 05000382/19990161999-09-0101 September 1999 Insp Rept 50-382/99-16 on 990704-0814.Noncited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support IR 05000382/19990101999-08-11011 August 1999 Insp Rept 50-382/99-10 on 990719-23.Violations Noted.Major Areas Inspected:Solid Radioactive Waste Mgt & Radioactive Matl Transportation Programs IR 05000382/19990131999-07-15015 July 1999 Insp Rept 50-382/99-13 on 990523-0703.Noncited Violations Noted.Major Areas Inspected:Aspects of Operations,Maint, Engineering & Plant Support Activities IR 05000382/19990121999-06-21021 June 1999 Insp Rept 50-382/99-12 on 990524-27.No Violations Noted. Major Areas Inspected:Operational Status of Licensee Emergency Preparedness Program IR 05000382/19990111999-06-18018 June 1999 Insp Rept 50-382/99-11 on 990524-28.No Violations Noted. Major Areas Inspected:Implementation of Liquid & Gaseous Radwaste Effluent Mgt Program,Status of Effluent Radiation Monitors & Counting Room Instruments IR 05000382/19990091999-06-0303 June 1999 Insp Rept 50-382/99-09 on 990411-0522.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19990061999-05-18018 May 1999 Insp Rept 50-382/99-06 on 990405-09.Non-cited Violations Identified.Major Areas Inspected:Issue Previously Identified During Architect Engineering Insp Which Documented NRC Insp Rept 50-382/98-201 IR 05000382/19990051999-05-10010 May 1999 Insp Rept 50-382/99-05 on 990228-0410.Non-cited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support ML20206F4801999-05-0303 May 1999 Insp Rept 50-382/99-08 on 990405-07.One Apparent Violation Noted & Being Considered for Escalated Eas.Major Areas Inspected:Plant Support Including Licensee Access Authorization Program IR 05000382/19990041999-04-0909 April 1999 Insp Rept 50-382/99-04 on 990301-19.One Violation Occurred & Being Treated as Noncited Violation.Major Areas Inspected: Review of Licensee Implementation of Facility ISI Program & Followup Review of Reactor Trip Breaker Performance IR 05000382/19990021999-04-0505 April 1999 Insp Rept 50-382/99-02 on 990117-0227.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Support Activities IR 05000382/19990031999-03-26026 March 1999 Insp Rept 50-382/99-03 on 990308-12.Violations Noted.Major Areas Inspected:Radiation Protection Program Focusing on RF09 Refueling Outage Activities IR 05000382/19990011999-03-0303 March 1999 Partially Deleted Insp Rept 50-382/99-01 on 990125-29 & 0208-12 (Ref 10CFR73.21).Violations Noted.Major Areas Inspected:Plant Support IR 05000382/19980181998-12-21021 December 1998 Insp Rept 50-382/98-18 on 981018-1128.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19980151998-11-24024 November 1998 Insp Rept 50-382/98-15 on 980906-1017.No Violations Noted. Major Areas Inspected:Aspects of Operations,Maint, Engineering & Plant Support Activities IR 05000382/19980131998-11-17017 November 1998 Insp Rept 50-382/98-13 on 980831-0901 & 981005-08.No Violations Noted.Major Areas Inspected:Maint Using Guidance of Temp Instruction 2515/137, Insp of Medium-Voltage & Low-Voltage Power Circuit Breakers ML20155D0561998-10-29029 October 1998 Insp Rept 50-382/98-17 on 981005-08.Violations Noted. Major Areas Inspected:Routine Review of Radiation Protection Program Activities ML20155D5111998-10-27027 October 1998 Partially Withheld Insp Rept 50-382/98-16 on 980914-18. Violations Noted.Major Areas Inspected:Licensee Physical Security Program.Portions Withheld (Ref 10CFR2.790) ML20154L1281998-10-0909 October 1998 Insp Rept 50-382/98-14 on 980726-0905.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19980121998-08-21021 August 1998 Insp Rept 50-382/98-12 on 980614-0725.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19992011998-07-27027 July 1998 Insp Rept 50-382/99-201 on 990511-0619.No Violations Noted Major Areas Inspected:Engineering IR 05000382/19980101998-07-20020 July 1998 Insp Rept 50-382/98-10 on 980622-26.No Violations Noted. Major Areas Inspected:Licensee Physical Security Program Including Access Authorization,Alarm Stations,Protected Area Access Control of Personnel & Packages & Vehicles IR 05000382/19980091998-07-10010 July 1998 Insp Rept 50-382/98-09 on 980503-0613.Violations Noted.Major Areas Inspected:Aspects of Operations,Maint,Engineering & Plant Support Activities.Fire Door in Reactor Auxiliary Bldg Was Observed to Be Open W/No Controls in Place IR 05000382/19980081998-05-29029 May 1998 Insp Rept 50-382/98-08 on 980322-0502.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Support ML20217B6981998-04-21021 April 1998 Insp Rept 50-382/98-06 on 980201-0321.Violations Noted.Major Areas Inspected:Operations,Maint & Engineering IR 05000382/19980021998-03-20020 March 1998 Insp Rept 50-382/98-02 on 980202-20.No Violations Noted. Major Areas Inspected:Current Performance & Effectiveness of Corrective Action Program Including Audits & Assessments, Operations & Engineering ML20216E1461998-03-12012 March 1998 Insp Rept 50-382/98-07 on 980302-06.Violations Noted.Major Areas Inspected:Plant Support ML20216E5991998-03-12012 March 1998 Insp Rept 50-382/98-05 on 980202-12.Violations Noted.Major Areas Inspected:Licensee Physical Security Program ML20216E7621998-03-12012 March 1998 Insp Rept 50-382/97-25 on 971201-980205.Violations Noted. Major Areas Inspected:Maint & Engineering IR 05000382/19980031998-03-10010 March 1998 Insp Rept 50-382/98-03 on 980216-20.No Violations Noted. Major Areas Inspected:Operational Status of Emergency Preparedness Program ML20203L2171998-03-0303 March 1998 Insp Rept 50-382/98-04 on 980202-06.Violations Noted.Major Areas Inspected:Radiation Protection Program Including External Exposure Controls,Training Qualifications, Facilities & Equipment & Procedures & Documentation IR 05000382/19970281998-02-11011 February 1998 Insp Rept 50-382/97-28 on 971214-980131.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support Activities IR 05000382/19980011998-01-29029 January 1998 Insp Rept 50-382/98-01 on 980112-15.No Violations Noted. Major Areas Inspected:Implementation of Solid Radwaste Mgt & Radwaste/Matls Transportation Program.Quality Assurance Oversight,Training & Procedural Guidance Were Also Reviewed ML20198M2801998-01-12012 January 1998 Insp Rept 50-382/97-24 on 971102-1213.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support ML20198C8871998-01-0505 January 1998 Insp Rept 50-382/97-26 on 971117-1205.No Violations Noted. Major Areas Inspected:Operator Activities Re Failure to Return Valve ACC-126A,auxiliary Component CWS Flow Control Valve,To Automatic Operation When Restoring CWS ML20198C4561998-01-0202 January 1998 Insp Rept 50-382/97-27 on 971117-1205.Violations Noted. Major Areas Inspected:Review of Licensee Identification That Plant Ventilation Sys Could Adversely Affect Level Indication for Refueling Water Storage Pool IR 05000382/19970181997-12-0505 December 1997 Insp Rept 50-382/97-18 on 971104-07.Violations Noted.Major Areas Inspected:Licensee Performance & Capabilities During full-scale,biennial Exercise of Emergency Plan & Implementing Procedures Performed IR 05000382/19970211997-12-0202 December 1997 Insp Rept 50-382/97-21 on 970922-26 & 1006-10.Violation Noted.Major Areas Inspected:Engineering,Maintenance & Mgt Meetings IR 05000382/19970221997-11-19019 November 1997 Insp Rept 50-382/97-22 on 970921-0001.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19970231997-11-0404 November 1997 Insp Rept 50-382/97-23 on 971006-10.No Violations Noted. Major Areas Inspected:Liquid & Gaseous Radioactive Effluent Waste Mgt Program Including Organization & Mgt Controls & Radioactive Effluent Monitoring IR 05000382/19970191997-10-24024 October 1997 Partially Withheld Insp Rept 50-382/97-19 on 970922-26 (Ref 10CFR73.21).No Violations Identified.Major Areas Inspected: Plant Support Re Land Vehicle Control Measures & Security Program IR 05000382/19970171997-10-23023 October 1997 Insp Rept 50-382/97-17 on 970929-1003.Violations Noted. Major Areas Inspected:Licensed Operator Requalification Program Following Guidelines in Insp Procedure 71001, Licensed Operator Requalification Program Evaluation IR 05000382/19970161997-10-17017 October 1997 Insp Rept 50-382/97-16 on 970810-0920.Violations Noted: Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19970201997-10-0909 October 1997 Insp Rept 50-382/97-20 on 970922-26.Violations Noted.Major Areas Inspected:External & Internal Exposure Control Programs,Surveys,Monitoring & Control of Radioactive Matl & Quality Assurance 1999-09-08
[Table view] Category:NRC-GENERATED
MONTHYEARIR 05000382/19990201999-10-21021 October 1999 Insp Rept 50-382/99-20 on 990815-0925.Non-cited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support Activities IR 05000382/19990141999-10-19019 October 1999 Insp Rept 50-382/99-14 on 990913-17 & 1004-08.No Violations Noted.Major Areas Inspected:Operator Requalification Training Program IR 05000382/19990181999-09-29029 September 1999 Insp Rept 50-382/99-18 on 990830-0902.Violations Noted.Major Areas Inspected:Implementation of NRC-approved Fire Protection Program IR 05000382/19990191999-09-27027 September 1999 Insp Rept 50-382/99-19 on 990830-0903.No Violations Noted. Major Areas Inspected:Plant Support IR 05000382/19990151999-09-14014 September 1999 Insp Rept 50-382/99-15 on 990719-23 with in Ofc Insp Until 0819.No Violations Noted.Major Areas Inspected:Assessment of 10CFR50.59 Safety Evaluation Program & Review of Previous Insp Findings Involving Tornado Missile Protection IR 05000382/19990071999-09-0808 September 1999 Insp Rept 50-382/99-07 on 990601-11.Noncited Violations Identified.Major Areas Inspected:Operations IR 05000382/19990161999-09-0101 September 1999 Insp Rept 50-382/99-16 on 990704-0814.Noncited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support IR 05000382/19990101999-08-11011 August 1999 Insp Rept 50-382/99-10 on 990719-23.Violations Noted.Major Areas Inspected:Solid Radioactive Waste Mgt & Radioactive Matl Transportation Programs IR 05000382/19990131999-07-15015 July 1999 Insp Rept 50-382/99-13 on 990523-0703.Noncited Violations Noted.Major Areas Inspected:Aspects of Operations,Maint, Engineering & Plant Support Activities IR 05000382/19990121999-06-21021 June 1999 Insp Rept 50-382/99-12 on 990524-27.No Violations Noted. Major Areas Inspected:Operational Status of Licensee Emergency Preparedness Program IR 05000382/19990111999-06-18018 June 1999 Insp Rept 50-382/99-11 on 990524-28.No Violations Noted. Major Areas Inspected:Implementation of Liquid & Gaseous Radwaste Effluent Mgt Program,Status of Effluent Radiation Monitors & Counting Room Instruments IR 05000382/19990091999-06-0303 June 1999 Insp Rept 50-382/99-09 on 990411-0522.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19990061999-05-18018 May 1999 Insp Rept 50-382/99-06 on 990405-09.Non-cited Violations Identified.Major Areas Inspected:Issue Previously Identified During Architect Engineering Insp Which Documented NRC Insp Rept 50-382/98-201 IR 05000382/19990051999-05-10010 May 1999 Insp Rept 50-382/99-05 on 990228-0410.Non-cited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support ML20206F4801999-05-0303 May 1999 Insp Rept 50-382/99-08 on 990405-07.One Apparent Violation Noted & Being Considered for Escalated Eas.Major Areas Inspected:Plant Support Including Licensee Access Authorization Program IR 05000382/19990041999-04-0909 April 1999 Insp Rept 50-382/99-04 on 990301-19.One Violation Occurred & Being Treated as Noncited Violation.Major Areas Inspected: Review of Licensee Implementation of Facility ISI Program & Followup Review of Reactor Trip Breaker Performance IR 05000382/19990021999-04-0505 April 1999 Insp Rept 50-382/99-02 on 990117-0227.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Support Activities IR 05000382/19990031999-03-26026 March 1999 Insp Rept 50-382/99-03 on 990308-12.Violations Noted.Major Areas Inspected:Radiation Protection Program Focusing on RF09 Refueling Outage Activities IR 05000382/19990011999-03-0303 March 1999 Partially Deleted Insp Rept 50-382/99-01 on 990125-29 & 0208-12 (Ref 10CFR73.21).Violations Noted.Major Areas Inspected:Plant Support IR 05000382/19980181998-12-21021 December 1998 Insp Rept 50-382/98-18 on 981018-1128.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19980151998-11-24024 November 1998 Insp Rept 50-382/98-15 on 980906-1017.No Violations Noted. Major Areas Inspected:Aspects of Operations,Maint, Engineering & Plant Support Activities IR 05000382/19980131998-11-17017 November 1998 Insp Rept 50-382/98-13 on 980831-0901 & 981005-08.No Violations Noted.Major Areas Inspected:Maint Using Guidance of Temp Instruction 2515/137, Insp of Medium-Voltage & Low-Voltage Power Circuit Breakers ML20155D0561998-10-29029 October 1998 Insp Rept 50-382/98-17 on 981005-08.Violations Noted. Major Areas Inspected:Routine Review of Radiation Protection Program Activities ML20155D5111998-10-27027 October 1998 Partially Withheld Insp Rept 50-382/98-16 on 980914-18. Violations Noted.Major Areas Inspected:Licensee Physical Security Program.Portions Withheld (Ref 10CFR2.790) ML20154L1281998-10-0909 October 1998 Insp Rept 50-382/98-14 on 980726-0905.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19980121998-08-21021 August 1998 Insp Rept 50-382/98-12 on 980614-0725.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19992011998-07-27027 July 1998 Insp Rept 50-382/99-201 on 990511-0619.No Violations Noted Major Areas Inspected:Engineering IR 05000382/19980101998-07-20020 July 1998 Insp Rept 50-382/98-10 on 980622-26.No Violations Noted. Major Areas Inspected:Licensee Physical Security Program Including Access Authorization,Alarm Stations,Protected Area Access Control of Personnel & Packages & Vehicles IR 05000382/19980091998-07-10010 July 1998 Insp Rept 50-382/98-09 on 980503-0613.Violations Noted.Major Areas Inspected:Aspects of Operations,Maint,Engineering & Plant Support Activities.Fire Door in Reactor Auxiliary Bldg Was Observed to Be Open W/No Controls in Place IR 05000382/19980081998-05-29029 May 1998 Insp Rept 50-382/98-08 on 980322-0502.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Support ML20217B6981998-04-21021 April 1998 Insp Rept 50-382/98-06 on 980201-0321.Violations Noted.Major Areas Inspected:Operations,Maint & Engineering IR 05000382/19980021998-03-20020 March 1998 Insp Rept 50-382/98-02 on 980202-20.No Violations Noted. Major Areas Inspected:Current Performance & Effectiveness of Corrective Action Program Including Audits & Assessments, Operations & Engineering ML20216E1461998-03-12012 March 1998 Insp Rept 50-382/98-07 on 980302-06.Violations Noted.Major Areas Inspected:Plant Support ML20216E5991998-03-12012 March 1998 Insp Rept 50-382/98-05 on 980202-12.Violations Noted.Major Areas Inspected:Licensee Physical Security Program ML20216E7621998-03-12012 March 1998 Insp Rept 50-382/97-25 on 971201-980205.Violations Noted. Major Areas Inspected:Maint & Engineering IR 05000382/19980031998-03-10010 March 1998 Insp Rept 50-382/98-03 on 980216-20.No Violations Noted. Major Areas Inspected:Operational Status of Emergency Preparedness Program ML20203L2171998-03-0303 March 1998 Insp Rept 50-382/98-04 on 980202-06.Violations Noted.Major Areas Inspected:Radiation Protection Program Including External Exposure Controls,Training Qualifications, Facilities & Equipment & Procedures & Documentation IR 05000382/19970281998-02-11011 February 1998 Insp Rept 50-382/97-28 on 971214-980131.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support Activities IR 05000382/19980011998-01-29029 January 1998 Insp Rept 50-382/98-01 on 980112-15.No Violations Noted. Major Areas Inspected:Implementation of Solid Radwaste Mgt & Radwaste/Matls Transportation Program.Quality Assurance Oversight,Training & Procedural Guidance Were Also Reviewed ML20198M2801998-01-12012 January 1998 Insp Rept 50-382/97-24 on 971102-1213.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support ML20198C8871998-01-0505 January 1998 Insp Rept 50-382/97-26 on 971117-1205.No Violations Noted. Major Areas Inspected:Operator Activities Re Failure to Return Valve ACC-126A,auxiliary Component CWS Flow Control Valve,To Automatic Operation When Restoring CWS ML20198C4561998-01-0202 January 1998 Insp Rept 50-382/97-27 on 971117-1205.Violations Noted. Major Areas Inspected:Review of Licensee Identification That Plant Ventilation Sys Could Adversely Affect Level Indication for Refueling Water Storage Pool IR 05000382/19970181997-12-0505 December 1997 Insp Rept 50-382/97-18 on 971104-07.Violations Noted.Major Areas Inspected:Licensee Performance & Capabilities During full-scale,biennial Exercise of Emergency Plan & Implementing Procedures Performed IR 05000382/19970211997-12-0202 December 1997 Insp Rept 50-382/97-21 on 970922-26 & 1006-10.Violation Noted.Major Areas Inspected:Engineering,Maintenance & Mgt Meetings IR 05000382/19970221997-11-19019 November 1997 Insp Rept 50-382/97-22 on 970921-0001.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19970231997-11-0404 November 1997 Insp Rept 50-382/97-23 on 971006-10.No Violations Noted. Major Areas Inspected:Liquid & Gaseous Radioactive Effluent Waste Mgt Program Including Organization & Mgt Controls & Radioactive Effluent Monitoring IR 05000382/19970191997-10-24024 October 1997 Partially Withheld Insp Rept 50-382/97-19 on 970922-26 (Ref 10CFR73.21).No Violations Identified.Major Areas Inspected: Plant Support Re Land Vehicle Control Measures & Security Program IR 05000382/19970171997-10-23023 October 1997 Insp Rept 50-382/97-17 on 970929-1003.Violations Noted. Major Areas Inspected:Licensed Operator Requalification Program Following Guidelines in Insp Procedure 71001, Licensed Operator Requalification Program Evaluation IR 05000382/19970161997-10-17017 October 1997 Insp Rept 50-382/97-16 on 970810-0920.Violations Noted: Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19970201997-10-0909 October 1997 Insp Rept 50-382/97-20 on 970922-26.Violations Noted.Major Areas Inspected:External & Internal Exposure Control Programs,Surveys,Monitoring & Control of Radioactive Matl & Quality Assurance 1999-09-08
[Table view] Category:INSPECTION REPORT
MONTHYEARIR 05000382/19990201999-10-21021 October 1999 Insp Rept 50-382/99-20 on 990815-0925.Non-cited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support Activities IR 05000382/19990141999-10-19019 October 1999 Insp Rept 50-382/99-14 on 990913-17 & 1004-08.No Violations Noted.Major Areas Inspected:Operator Requalification Training Program IR 05000382/19990181999-09-29029 September 1999 Insp Rept 50-382/99-18 on 990830-0902.Violations Noted.Major Areas Inspected:Implementation of NRC-approved Fire Protection Program IR 05000382/19990191999-09-27027 September 1999 Insp Rept 50-382/99-19 on 990830-0903.No Violations Noted. Major Areas Inspected:Plant Support IR 05000382/19990151999-09-14014 September 1999 Insp Rept 50-382/99-15 on 990719-23 with in Ofc Insp Until 0819.No Violations Noted.Major Areas Inspected:Assessment of 10CFR50.59 Safety Evaluation Program & Review of Previous Insp Findings Involving Tornado Missile Protection IR 05000382/19990071999-09-0808 September 1999 Insp Rept 50-382/99-07 on 990601-11.Noncited Violations Identified.Major Areas Inspected:Operations IR 05000382/19990161999-09-0101 September 1999 Insp Rept 50-382/99-16 on 990704-0814.Noncited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support IR 05000382/19990101999-08-11011 August 1999 Insp Rept 50-382/99-10 on 990719-23.Violations Noted.Major Areas Inspected:Solid Radioactive Waste Mgt & Radioactive Matl Transportation Programs IR 05000382/19990131999-07-15015 July 1999 Insp Rept 50-382/99-13 on 990523-0703.Noncited Violations Noted.Major Areas Inspected:Aspects of Operations,Maint, Engineering & Plant Support Activities IR 05000382/19990121999-06-21021 June 1999 Insp Rept 50-382/99-12 on 990524-27.No Violations Noted. Major Areas Inspected:Operational Status of Licensee Emergency Preparedness Program IR 05000382/19990111999-06-18018 June 1999 Insp Rept 50-382/99-11 on 990524-28.No Violations Noted. Major Areas Inspected:Implementation of Liquid & Gaseous Radwaste Effluent Mgt Program,Status of Effluent Radiation Monitors & Counting Room Instruments IR 05000382/19990091999-06-0303 June 1999 Insp Rept 50-382/99-09 on 990411-0522.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19990061999-05-18018 May 1999 Insp Rept 50-382/99-06 on 990405-09.Non-cited Violations Identified.Major Areas Inspected:Issue Previously Identified During Architect Engineering Insp Which Documented NRC Insp Rept 50-382/98-201 IR 05000382/19990051999-05-10010 May 1999 Insp Rept 50-382/99-05 on 990228-0410.Non-cited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support ML20206F4801999-05-0303 May 1999 Insp Rept 50-382/99-08 on 990405-07.One Apparent Violation Noted & Being Considered for Escalated Eas.Major Areas Inspected:Plant Support Including Licensee Access Authorization Program IR 05000382/19990041999-04-0909 April 1999 Insp Rept 50-382/99-04 on 990301-19.One Violation Occurred & Being Treated as Noncited Violation.Major Areas Inspected: Review of Licensee Implementation of Facility ISI Program & Followup Review of Reactor Trip Breaker Performance IR 05000382/19990021999-04-0505 April 1999 Insp Rept 50-382/99-02 on 990117-0227.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Support Activities IR 05000382/19990031999-03-26026 March 1999 Insp Rept 50-382/99-03 on 990308-12.Violations Noted.Major Areas Inspected:Radiation Protection Program Focusing on RF09 Refueling Outage Activities IR 05000382/19990011999-03-0303 March 1999 Partially Deleted Insp Rept 50-382/99-01 on 990125-29 & 0208-12 (Ref 10CFR73.21).Violations Noted.Major Areas Inspected:Plant Support IR 05000382/19980181998-12-21021 December 1998 Insp Rept 50-382/98-18 on 981018-1128.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19980151998-11-24024 November 1998 Insp Rept 50-382/98-15 on 980906-1017.No Violations Noted. Major Areas Inspected:Aspects of Operations,Maint, Engineering & Plant Support Activities IR 05000382/19980131998-11-17017 November 1998 Insp Rept 50-382/98-13 on 980831-0901 & 981005-08.No Violations Noted.Major Areas Inspected:Maint Using Guidance of Temp Instruction 2515/137, Insp of Medium-Voltage & Low-Voltage Power Circuit Breakers ML20155D0561998-10-29029 October 1998 Insp Rept 50-382/98-17 on 981005-08.Violations Noted. Major Areas Inspected:Routine Review of Radiation Protection Program Activities ML20155D5111998-10-27027 October 1998 Partially Withheld Insp Rept 50-382/98-16 on 980914-18. Violations Noted.Major Areas Inspected:Licensee Physical Security Program.Portions Withheld (Ref 10CFR2.790) ML20154L1281998-10-0909 October 1998 Insp Rept 50-382/98-14 on 980726-0905.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19980121998-08-21021 August 1998 Insp Rept 50-382/98-12 on 980614-0725.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19992011998-07-27027 July 1998 Insp Rept 50-382/99-201 on 990511-0619.No Violations Noted Major Areas Inspected:Engineering IR 05000382/19980101998-07-20020 July 1998 Insp Rept 50-382/98-10 on 980622-26.No Violations Noted. Major Areas Inspected:Licensee Physical Security Program Including Access Authorization,Alarm Stations,Protected Area Access Control of Personnel & Packages & Vehicles IR 05000382/19980091998-07-10010 July 1998 Insp Rept 50-382/98-09 on 980503-0613.Violations Noted.Major Areas Inspected:Aspects of Operations,Maint,Engineering & Plant Support Activities.Fire Door in Reactor Auxiliary Bldg Was Observed to Be Open W/No Controls in Place IR 05000382/19980081998-05-29029 May 1998 Insp Rept 50-382/98-08 on 980322-0502.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Support ML20217B6981998-04-21021 April 1998 Insp Rept 50-382/98-06 on 980201-0321.Violations Noted.Major Areas Inspected:Operations,Maint & Engineering IR 05000382/19980021998-03-20020 March 1998 Insp Rept 50-382/98-02 on 980202-20.No Violations Noted. Major Areas Inspected:Current Performance & Effectiveness of Corrective Action Program Including Audits & Assessments, Operations & Engineering ML20216E1461998-03-12012 March 1998 Insp Rept 50-382/98-07 on 980302-06.Violations Noted.Major Areas Inspected:Plant Support ML20216E5991998-03-12012 March 1998 Insp Rept 50-382/98-05 on 980202-12.Violations Noted.Major Areas Inspected:Licensee Physical Security Program ML20216E7621998-03-12012 March 1998 Insp Rept 50-382/97-25 on 971201-980205.Violations Noted. Major Areas Inspected:Maint & Engineering IR 05000382/19980031998-03-10010 March 1998 Insp Rept 50-382/98-03 on 980216-20.No Violations Noted. Major Areas Inspected:Operational Status of Emergency Preparedness Program ML20203L2171998-03-0303 March 1998 Insp Rept 50-382/98-04 on 980202-06.Violations Noted.Major Areas Inspected:Radiation Protection Program Including External Exposure Controls,Training Qualifications, Facilities & Equipment & Procedures & Documentation IR 05000382/19970281998-02-11011 February 1998 Insp Rept 50-382/97-28 on 971214-980131.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support Activities IR 05000382/19980011998-01-29029 January 1998 Insp Rept 50-382/98-01 on 980112-15.No Violations Noted. Major Areas Inspected:Implementation of Solid Radwaste Mgt & Radwaste/Matls Transportation Program.Quality Assurance Oversight,Training & Procedural Guidance Were Also Reviewed ML20198M2801998-01-12012 January 1998 Insp Rept 50-382/97-24 on 971102-1213.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support ML20198C8871998-01-0505 January 1998 Insp Rept 50-382/97-26 on 971117-1205.No Violations Noted. Major Areas Inspected:Operator Activities Re Failure to Return Valve ACC-126A,auxiliary Component CWS Flow Control Valve,To Automatic Operation When Restoring CWS ML20198C4561998-01-0202 January 1998 Insp Rept 50-382/97-27 on 971117-1205.Violations Noted. Major Areas Inspected:Review of Licensee Identification That Plant Ventilation Sys Could Adversely Affect Level Indication for Refueling Water Storage Pool IR 05000382/19970181997-12-0505 December 1997 Insp Rept 50-382/97-18 on 971104-07.Violations Noted.Major Areas Inspected:Licensee Performance & Capabilities During full-scale,biennial Exercise of Emergency Plan & Implementing Procedures Performed IR 05000382/19970211997-12-0202 December 1997 Insp Rept 50-382/97-21 on 970922-26 & 1006-10.Violation Noted.Major Areas Inspected:Engineering,Maintenance & Mgt Meetings IR 05000382/19970221997-11-19019 November 1997 Insp Rept 50-382/97-22 on 970921-0001.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19970231997-11-0404 November 1997 Insp Rept 50-382/97-23 on 971006-10.No Violations Noted. Major Areas Inspected:Liquid & Gaseous Radioactive Effluent Waste Mgt Program Including Organization & Mgt Controls & Radioactive Effluent Monitoring IR 05000382/19970191997-10-24024 October 1997 Partially Withheld Insp Rept 50-382/97-19 on 970922-26 (Ref 10CFR73.21).No Violations Identified.Major Areas Inspected: Plant Support Re Land Vehicle Control Measures & Security Program IR 05000382/19970171997-10-23023 October 1997 Insp Rept 50-382/97-17 on 970929-1003.Violations Noted. Major Areas Inspected:Licensed Operator Requalification Program Following Guidelines in Insp Procedure 71001, Licensed Operator Requalification Program Evaluation IR 05000382/19970161997-10-17017 October 1997 Insp Rept 50-382/97-16 on 970810-0920.Violations Noted: Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19970201997-10-0909 October 1997 Insp Rept 50-382/97-20 on 970922-26.Violations Noted.Major Areas Inspected:External & Internal Exposure Control Programs,Surveys,Monitoring & Control of Radioactive Matl & Quality Assurance 1999-09-08
[Table view] Category:UTILITY
MONTHYEARIR 05000382/19900221990-10-23023 October 1990 Insp Rept 50-382/90-22 on 900905-1001.Violations Noted.Major Areas Inspected:Followup of Events,Monthly Maint & Surveillance Observation,Operational Safety Verification, Followup of Previously Identified Items & LER Followup IR 05000382/19900211990-10-12012 October 1990 Insp Rept 50-382/90-21 on 900910-14.No Violations Noted. Major Areas Inspected:Liquid & Gaseous Radwaste Mgt Program IR 05000382/19902001990-09-10010 September 1990 Interfacing Sys LOCA Insp Rept 50-382/90-200 on 900730-0810. Major Areas Inspected:Plant Design Features,Sys,Equipment, Procedures,Operations Activities & Human Actions That Could Affect Initiation or Progress of Interfacing Sys LOCA IR 05000382/19900171990-08-27027 August 1990 Insp Rept 50-382/90-17 on 900625-29.No Violations or Deviations Noted.Major Areas Inspected:Operational Status of Emergency Preparedness Program Including Changes to Emergency Plans & EPIPs & Changes to Emergency Facilities IR 05000382/19900111990-07-29029 July 1990 Insp Rept 50-382/90-11 on 900625-29.No Violations or Deviations Noted.Major Areas Inspected:Radioactive Matl Transportation Program.Licensee Implemented Effective Program & Personnel Highly Qualified & Motivated IR 05000382/19900141990-07-17017 July 1990 Insp Rept 50-382/90-14 on 900625-29.Violation Noted.Major Areas Inspected:Containment Local Leak Rate Testing Data, Surveillance Test & Calibr Program & Followup of Previous Insp Findings IR 05000382/19900101990-07-0505 July 1990 Cancelled Insp Rept 50-382/90-10 IR 05000382/19900091990-06-26026 June 1990 Errata to Insp Rept 50-382/90-09,inserting Page 6a.No Violations or Deviations Noted ML20055C7821990-06-14014 June 1990 Insp Rept 50-382/90-09 on 900501-31.No Violations or Deviations Noted.One Unresolved Item Noted.Major Areas Inspected:Plant Status,Onsite Followup of Events,Monthly Surveillance Observation & Operational Safety Verification IR 05000382/19890231989-09-26026 September 1989 Insp Rept 50-382/89-23 on 890801-31.No Violations Noted. Major Areas Inspected:Plant Status,Onsite Followup of Events,Monthly Maint Observation,Monthly Surveillance Observation,Operational Safety Verification IR 05000382/19890251989-09-21021 September 1989 Insp Rept 50-382/89-25 on 890828-0901.No Violations or Deviations Noted.Major Areas Inspected:Radiological Environ Monitoring Program,Including Organization & Mgt Controls, Qualification & Training & Licensee QA & Contractor Audits IR 05000382/19890161989-09-15015 September 1989 Insp Rept 50-382/89-16 on 890717-21.Violation Noted.Major Areas Inspected:Operations Procedures IR 05000382/19890221989-08-0909 August 1989 Insp Rept 50-382/89-22 on 890701-31.Violation Noted.Major Areas Inspected:Onsite Followup of Events,Monthly Maint Observation,Monthly Surveillance Observation,Operational Safety Verification & LER Followup IR 05000382/19890201989-07-25025 July 1989 Insp Rept 50-382/89-20 on 890705.No Violations or Deviations Noted.Major Areas Inspected:Svc Failure of Shaft in Chilled Water Pump B IR 05000382/19890171989-07-14014 July 1989 Insp Rept 50-382/89-17 on 890601-30.Violations Noted.Major Areas Inspected:Onsite Followup of Events,Monthly Maint Observation,Monthly Surveillance Observation & Operational Safety Verification IR 05000382/19890181989-07-13013 July 1989 Insp Rept 50-382/89-18 on 890626-30.Noncited Violation Noted.Major Areas Inspected:Corrective Action Program & Licensee Actions on Previously Identified Findings IR 05000382/19890151989-07-0606 July 1989 Insp Rept 50-382/89-15 on 890605-09 & 20-21.No Violations or Deviations Noted.Major Areas Inspected:Storage of Emergency Diesel Generator Fuel Oil,Containment Bldg Temp Profiles & Action on Previously Identified Insp Findings IR 05000382/19890141989-07-0303 July 1989 Insp Rept 50-382/89-14 on 890522-26.No Violations or Deviations Noted.Major Areas Inspected:Radwaste Mgt & Effluent Control Programs & Review of Special & Semiannual Effluents Repts IR 05000382/19890131989-06-14014 June 1989 Insp Rept 50-382/89-13 on 890522-26.No Violations or Deviations Noted.Major Areas Inspected:Followup to Previous Insp Findings & Licensee Expeditious Actions Re Generic Ltr 88-17, Loss of Dhr ML20244C6951989-06-0808 June 1989 Insp Rept 50-382/89-12 on 890416-0531.Violations Noted. Major Areas Inspected:Monthly Maint Observation,Monthly Surveillance Observation,Onsite Followup of Events & Evaluation of Licensee QA Program Implementation IR 05000382/19890081989-05-16016 May 1989 Insp Rept 50-382/89-08 on 890301-0415.Violations Noted. Major Areas Inspected:Status,Monthly Maint Observation,Event Followup,Esf Walkdown & LER Followup IR 05000382/19890111989-05-0808 May 1989 Insp Rept 50-382/89-11 on 890327-31.Violations Noted.Major Areas Inspected:Engineering & Technical Support Activities & QA Audits of Activities IR 05000382/19890041989-04-18018 April 1989 Insp Rept 50-382/89-04 Cancelled ML20245C7281989-04-12012 April 1989 Insp Rept 50-382/89-07 on 890227-0303 & 890313-17.Violation Noted.Major Areas Inspected:Previously Identified Findings, Licensee self-assessment Capabilities & Procurement Activities ML20244A7551989-04-0303 April 1989 Insp Rept 50-382/89-09 on 890308-09.Violations Noted.Major Areas Inspected:Licensee Action on Previous Insp Findings Associated W/Testing,Low Recirculation Flow Condition & Corrective Maint of HPSI Pump B ML20247K3951989-03-25025 March 1989 Insp Rept 50-382/89-06 on 890201-28.Violations Noted.Major Areas Inspected:Plant Status,Monthly Maint Observation, Operational Safety Verification,Onsite Followup of Events, ESF Walkdown & Followup of Previously Identified Items IR 05000382/19890101989-03-15015 March 1989 Cancels Insp Rept 50-382/89-10.No Insp Rept Will Be Issued for Rept Number ML20247A5101989-03-14014 March 1989 Insp Rept 50-382/89-05 on 890213-17.Violation Noted.Major Areas Inspected:Licensee Action on Previously Identified Violations & Unresolved Items Re Equipment Qualification of Electric Equipment IR 05000382/19890011989-03-14014 March 1989 Insp Rept 50-382/89-01 on 890117-0210.Violations Noted.Major Areas Inspected:Maint Performance,Overall Plant Performance Re Maint,Mgt Support of Maint & Maint Implementation ML20235Z7771989-03-0303 March 1989 Insp Rept 50-382/89-02 on 890109-13.Violations Noted.Major Areas Inspected:Followup of Previous Insp Items,Followup of NRC Info Notices & Bulletins Applicable to Procurement & Insp of 10CFR21 Activities ML20235M7561989-02-16016 February 1989 Insp Rept 50-382/89-03 on 890101-31.Violations Noted.Major Areas Inspected:Plant Status,Monthly Surveillance Operation, Onsite Followup of Events,Diesel Generator Fuel Oil QA & NRC Bulletin 87-002 & LER Followup IR 05000382/19880271988-11-22022 November 1988 Insp Rept 50-382/88-27 on 881017-27 & 881101-07.Violations Noted.Major Areas Inspected:Licensee Actions on Previously Identified Items Re Equipment Documented in NRC Insp Rept 50-382/86-32 on 870416 ML20195J6561988-11-17017 November 1988 Insp Rept 50-382/88-25 on 880917-1031.Violations Noted. Major Areas Inspected:Plant Status,Onsite Followup of Events,Operational Safety Verification,Monthly Maint Observation & Monthly Surveillance Observation IR 05000382/19880261988-11-16016 November 1988 Insp Rept 50-382/88-26 on 881024-26.No Violations or Deviations Noted.Major Areas Inspected:Followup to Previous Insp Findings,Lers,Steam Generator Noise,& Replacement of Valve in Letdown Flow Sys IR 05000382/19880241988-11-0909 November 1988 Insp Rept 50-382/88-24 on 881011-13.No Violations or Deviations Noted.Eight Deficiencies Identified.Major Areas Inspected:Licensee Performance & Capabilities During Annual Exercise of Emergency Plan & Procedures IR 05000382/19880211988-10-12012 October 1988 Insp Rept 50-382/88-21 on 880801-0916.Violation & Deviation Noted.Major Areas Inspected:Plant Status,Onsite Followup of Events,Followup of Previously Identified Items,Operational Safety Verification & Monthly Maint Observation IR 05000382/19880231988-09-27027 September 1988 Insp Rept 50-382/88-23 on 880822-26 & 0919-23.Violations Noted.Major Areas Inspected:Potential Enforcement Findings Identified by Vendor Insp Branch in Insp Rept 50-382/87-19 ML20153D4311988-08-19019 August 1988 Insp Rept 50-382/88-19 on 880618-0731.Violations Noted. Major Areas Inspected:Enforcement Followup on Quality Verification Function Insp,Monthly Maint Observation, Allegation Followup & Operational Safety Verification ML20153C2521988-08-17017 August 1988 Insp Rept 50-382/88-20 on 880710-15.No Violations or Deviations Noted.Major Areas Inspected:Transportation of Radioactive Matls & Low Level Radwaste Mgt IR 05000382/19880181988-08-0909 August 1988 Insp Rept 50-382/88-18 on 880706-14.No Violations or Deviations Noted.Major Areas Inspected:Facility Emergency Operating Procedures,Including Control Room & Plant Walkdown,Simulator & Human factors-related Guidance ML20151E2391988-07-14014 July 1988 Insp Rept 50-382/88-13 on 880501-0617.Violations Noted.Major Areas Inspected:Monthly Maint Observation,Ler Followup, Containment Integrated Leak Rate Test,Plant Status & Followup of Previously Identified Items IR 05000382/19880171988-06-14014 June 1988 Insp Rept 50-382/88-17 on 880531-0603.One Violation & No Deviations Noted.Major Areas Inspected:Startup Testing IR 05000382/19880141988-06-13013 June 1988 Partially Withheld Insp Rept 50-382/88-14 on 880523-27 (Ref 10CFR73.21).No Violations or Deviations Noted.Major Areas Inspected:Testing & Maint Program,Facility Lighting,Security Training & Qualification Plan & Safeguards Info Program IR 05000382/19880081988-06-0202 June 1988 Insp Rept 50-382/88-08 on 880316-0430.Violations Noted.Major Areas Inspected:Onsite Followup of Events,Monthly Maint Observation,Monthly Surveillance Observation,Refueling Activity Observation,Esf,Sys Walkdown & Plant Status IR 05000382/19880101988-06-0101 June 1988 Insp Rept 50-382/88-10 on 880418-22.Violations Noted.Major Areas Inspected:Licensee Corrective Action Program Effectiveness IR 05000382/19880121988-05-27027 May 1988 Insp Rept 50-382/88-12 on 880501-06.No Violations Noted. Major Areas Inspected:Radiation Protection Activities During Cycle 2 Refueling Outage ML20154S2301988-05-27027 May 1988 Insp Rept 50-382/88-16 on 880512-20.Potential Violation & Deviation Noted.Major Areas Inspected:Events Which Occurred & Actions Taken by Util Prior To,During & Subsequent to 880512 Incident Re Possible Loss of Shutdown Cooling IR 05000382/19882001988-05-16016 May 1988 Insp Rept 50-382/88-200 on 880201-12.Weaknesses Noted.Major Areas Inspected:Quality Verification Organization Ability to Identify,Resolve & Prevent Recurrence of safety-significant Deficiencies in Functional Areas of Plant Operations IR 05000382/19880111988-05-16016 May 1988 Insp Rept 50-382/88-11 on 880418-22.Violations Noted.Major Areas Inspected:Licensee Action on Previously Identified Insp Findings,Inservice Insp & 10CFR21 ML20153E3091988-04-26026 April 1988 Insp Rept 50-382/88-09 on 880404-08.No Violations or Deviations Noted.Major Areas Inspected:Licensee Surveillance Procedures & Records & Verification of RCS Leak Rates 1990-09-10
[Table view] Category:TEXT-INSPECTION & AUDIT & I&E CIRCULARS
MONTHYEARIR 05000382/19990201999-10-21021 October 1999 Insp Rept 50-382/99-20 on 990815-0925.Non-cited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support Activities IR 05000382/19990141999-10-19019 October 1999 Insp Rept 50-382/99-14 on 990913-17 & 1004-08.No Violations Noted.Major Areas Inspected:Operator Requalification Training Program PNO-IV-99-038A, on 990929,restart of Waterford 3 Occurred. Cause Identified as Failed Seal Water Heat Exchanger Baffle. New Battle & Seal Assembled Were Installed & Reactor Coolant Pump 2B Was Returned to Svc Satisfactorily1999-10-0101 October 1999 PNO-IV-99-038A:on 990929,restart of Waterford 3 Occurred. Cause Identified as Failed Seal Water Heat Exchanger Baffle. New Battle & Seal Assembled Were Installed & Reactor Coolant Pump 2B Was Returned to Svc Satisfactorily IR 05000382/19990181999-09-29029 September 1999 Insp Rept 50-382/99-18 on 990830-0902.Violations Noted.Major Areas Inspected:Implementation of NRC-approved Fire Protection Program IR 05000382/19990191999-09-27027 September 1999 Insp Rept 50-382/99-19 on 990830-0903.No Violations Noted. Major Areas Inspected:Plant Support PNO-IV-99-038, on 990910,operators Manually Tripped Reactor from 100% Power in Response to Indications of Failure of RCP 2B Seal.New Baffle & Seal Assembly Were Installed & Plant Was Returned to Power Operations on 9908101999-09-15015 September 1999 PNO-IV-99-038:on 990910,operators Manually Tripped Reactor from 100% Power in Response to Indications of Failure of RCP 2B Seal.New Baffle & Seal Assembly Were Installed & Plant Was Returned to Power Operations on 990810 IR 05000382/19990151999-09-14014 September 1999 Insp Rept 50-382/99-15 on 990719-23 with in Ofc Insp Until 0819.No Violations Noted.Major Areas Inspected:Assessment of 10CFR50.59 Safety Evaluation Program & Review of Previous Insp Findings Involving Tornado Missile Protection IR 05000382/19990071999-09-0808 September 1999 Insp Rept 50-382/99-07 on 990601-11.Noncited Violations Identified.Major Areas Inspected:Operations IR 05000382/19990161999-09-0101 September 1999 Insp Rept 50-382/99-16 on 990704-0814.Noncited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support PNO-IV-99-032A, on 990801,Waterford 3 Operators Manually Tripped Reactor from 100% Power in Response to Indications of Failure of RCP 2B Seal.Pump Was Secured Immediately Following Plant Sd.New Baffle & Seal Assembly Was Installed1999-08-12012 August 1999 PNO-IV-99-032A:on 990801,Waterford 3 Operators Manually Tripped Reactor from 100% Power in Response to Indications of Failure of RCP 2B Seal.Pump Was Secured Immediately Following Plant Sd.New Baffle & Seal Assembly Was Installed IR 05000382/19990101999-08-11011 August 1999 Insp Rept 50-382/99-10 on 990719-23.Violations Noted.Major Areas Inspected:Solid Radioactive Waste Mgt & Radioactive Matl Transportation Programs PNO-IV-99-032, on 990801,Waterford 3 Operators Manually Tripped Reactor from 100% Power in Response to Indications of Failure of RCP 2B Seal.Pump Was Secured Immediately Following Plan Shutdown.Resident Inspectors Will Monitor1999-08-0303 August 1999 PNO-IV-99-032:on 990801,Waterford 3 Operators Manually Tripped Reactor from 100% Power in Response to Indications of Failure of RCP 2B Seal.Pump Was Secured Immediately Following Plan Shutdown.Resident Inspectors Will Monitor IR 05000382/19990131999-07-15015 July 1999 Insp Rept 50-382/99-13 on 990523-0703.Noncited Violations Noted.Major Areas Inspected:Aspects of Operations,Maint, Engineering & Plant Support Activities IR 05000382/19990121999-06-21021 June 1999 Insp Rept 50-382/99-12 on 990524-27.No Violations Noted. Major Areas Inspected:Operational Status of Licensee Emergency Preparedness Program IR 05000382/19990111999-06-18018 June 1999 Insp Rept 50-382/99-11 on 990524-28.No Violations Noted. Major Areas Inspected:Implementation of Liquid & Gaseous Radwaste Effluent Mgt Program,Status of Effluent Radiation Monitors & Counting Room Instruments ML20196C9461999-06-15015 June 1999 Notice of Violation from Insp Completed on 990422.Violation Noted:Licensee Failed to Consider Info Contained During Background Investigation Before Granting Temporary Unescorted Access to Contractor Employee IR 05000382/19990091999-06-0303 June 1999 Insp Rept 50-382/99-09 on 990411-0522.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support ML20209B8581999-05-25025 May 1999 EN-98-046A:on 990524,staff Withdrew Proposed Civil Penalty in Amount of $110,000 Issued to Licensee.Action Based on Severity Level III Problems Associated with ECCS & Afws IR 05000382/19990061999-05-18018 May 1999 Insp Rept 50-382/99-06 on 990405-09.Non-cited Violations Identified.Major Areas Inspected:Issue Previously Identified During Architect Engineering Insp Which Documented NRC Insp Rept 50-382/98-201 IR 05000382/19990051999-05-10010 May 1999 Insp Rept 50-382/99-05 on 990228-0410.Non-cited Violations Noted.Major Areas Inspected:Operations,Maintenance, Engineering & Plant Support ML20206F4801999-05-0303 May 1999 Insp Rept 50-382/99-08 on 990405-07.One Apparent Violation Noted & Being Considered for Escalated Eas.Major Areas Inspected:Plant Support Including Licensee Access Authorization Program IR 05000382/19990041999-04-0909 April 1999 Insp Rept 50-382/99-04 on 990301-19.One Violation Occurred & Being Treated as Noncited Violation.Major Areas Inspected: Review of Licensee Implementation of Facility ISI Program & Followup Review of Reactor Trip Breaker Performance IR 05000382/19990021999-04-0505 April 1999 Insp Rept 50-382/99-02 on 990117-0227.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Support Activities IR 05000382/19990031999-03-26026 March 1999 Insp Rept 50-382/99-03 on 990308-12.Violations Noted.Major Areas Inspected:Radiation Protection Program Focusing on RF09 Refueling Outage Activities IR 05000382/19990011999-03-0303 March 1999 Partially Deleted Insp Rept 50-382/99-01 on 990125-29 & 0208-12 (Ref 10CFR73.21).Violations Noted.Major Areas Inspected:Plant Support ML20207F1581999-03-0303 March 1999 Notice of Violation from Insp on 990125-29 & 0208-12. Violation Noted:Inspector Determined That Waterford Audits SA-98-025.1 & SA-98-036.1,dtd 980916,were Conducted by Individuals Not Independent of Program Mgt Being Audited IR 05000382/19980181998-12-21021 December 1998 Insp Rept 50-382/98-18 on 981018-1128.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19980151998-11-24024 November 1998 Insp Rept 50-382/98-15 on 980906-1017.No Violations Noted. Major Areas Inspected:Aspects of Operations,Maint, Engineering & Plant Support Activities PNO-IV-98-054, on 981117,plant Shutdown Greater than 72 H Due to Unidentified Leak.Investigations by Licensee Verified That Leakage Occurred from RCP 2b Seal Area1998-11-19019 November 1998 PNO-IV-98-054:on 981117,plant Shutdown Greater than 72 H Due to Unidentified Leak.Investigations by Licensee Verified That Leakage Occurred from RCP 2b Seal Area IR 05000382/19980131998-11-17017 November 1998 Insp Rept 50-382/98-13 on 980831-0901 & 981005-08.No Violations Noted.Major Areas Inspected:Maint Using Guidance of Temp Instruction 2515/137, Insp of Medium-Voltage & Low-Voltage Power Circuit Breakers ML20155D0561998-10-29029 October 1998 Insp Rept 50-382/98-17 on 981005-08.Violations Noted. Major Areas Inspected:Routine Review of Radiation Protection Program Activities ML20155D0411998-10-29029 October 1998 Notice of Violation from Insp on 981005-08.Violation Noted: Inspectors Identified That Radiation Surveys to Evaluate Extent of Radiation Levels Had Not Been Performed Prior to Operations Personnel Entering Area ML20155D5111998-10-27027 October 1998 Partially Withheld Insp Rept 50-382/98-16 on 980914-18. Violations Noted.Major Areas Inspected:Licensee Physical Security Program.Portions Withheld (Ref 10CFR2.790) ML20155D5021998-10-27027 October 1998 Notice of Violation from Insp on 980914-18.Violation Noted: Performance Tests of Protected Area Detection Sys Identified That Two Detection Zones Did Not Meet Design Criteria to Detect Test Individuals ML20154L0831998-10-0909 October 1998 Notice of Violation from Insp on 980726-0905.Violation Noted:On 980721,NRC Inspectors Found Door 206,vital Area Portal,Unlocked & Not in Alarm at Central Alarm Station ML20154L1281998-10-0909 October 1998 Insp Rept 50-382/98-14 on 980726-0905.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support PNO-IV-98-045, on 980926,Unit 3 Declared Unusual Event of Hurricane Warning in St Charles Parish.River Bend Station Continued to Operate at Full Power Since Hurricane Force Winds Were Not Predicted in Vicinity of Site1998-09-28028 September 1998 PNO-IV-98-045:on 980926,Unit 3 Declared Unusual Event of Hurricane Warning in St Charles Parish.River Bend Station Continued to Operate at Full Power Since Hurricane Force Winds Were Not Predicted in Vicinity of Site PNO-IV-98-040, on 980917,licensee Commenced Shutdown of Reactor in Order to Replace Pressurizer Code Safety Valve That Had Been Experiencing Increased Leakage.Licensee Plans to Restart Facility on 9809231998-09-18018 September 1998 PNO-IV-98-040:on 980917,licensee Commenced Shutdown of Reactor in Order to Replace Pressurizer Code Safety Valve That Had Been Experiencing Increased Leakage.Licensee Plans to Restart Facility on 980923 IR 05000382/19980121998-08-21021 August 1998 Insp Rept 50-382/98-12 on 980614-0725.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000382/19992011998-07-27027 July 1998 Insp Rept 50-382/99-201 on 990511-0619.No Violations Noted Major Areas Inspected:Engineering IR 05000382/19980101998-07-20020 July 1998 Insp Rept 50-382/98-10 on 980622-26.No Violations Noted. Major Areas Inspected:Licensee Physical Security Program Including Access Authorization,Alarm Stations,Protected Area Access Control of Personnel & Packages & Vehicles ML20236P2431998-07-10010 July 1998 Notice of Violation from Insp on 980503-0613.Violation Noted:On 980521,AP UNT-005-013 Was Not Implemented in That Impairment to Fire Door D150 Was Not Controlled IR 05000382/19980091998-07-10010 July 1998 Insp Rept 50-382/98-09 on 980503-0613.Violations Noted.Major Areas Inspected:Aspects of Operations,Maint,Engineering & Plant Support Activities.Fire Door in Reactor Auxiliary Bldg Was Observed to Be Open W/No Controls in Place ML20249A9611998-06-16016 June 1998 Notice of Violation & Proposed Imposition of Civil Penalty in Amount of $100,000.Violation Noted:Licensee Identified That Calculated Peak Fuel Cladding Temp Would Have Exceeded 2200 F Using Licensing Basis Analysis & HPSI Flow ML20151R9131998-06-0909 June 1998 EN-98-046:on 980616,notice of Proposed Imposition of Civil Penalty in Amount of $110,000 Issued to Licensee.Action Based on Level III Problem Involving HPSI Flow Issues at Waterford-3 Facility IR 05000382/19980081998-05-29029 May 1998 Insp Rept 50-382/98-08 on 980322-0502.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Support ML20248F6801998-05-29029 May 1998 Notice of Violation from Insp on 980322-0502.Violation Noted:Licensee Failed to Establish Adequate Procedures for Operation of EDG When in No or Low Electrical Loading Condition in That No Specific Guidance Provided IR 05000382/19980991998-04-24024 April 1998 SALP Rept 50-382/98-99 for 961201-980321 ML20217B6731998-04-21021 April 1998 Notice of Violation from Insp on 980201-0321.Violation Noted:On Past Occasions,Engineer Operated Governor Valve on Emergency Feedwater Turbine W/O Direction or Concurrence of Shift Superintendent or Control Room Supervisor ML20217B6981998-04-21021 April 1998 Insp Rept 50-382/98-06 on 980201-0321.Violations Noted.Major Areas Inspected:Operations,Maint & Engineering 1999-09-08
[Table view] |
See also: IR 05000382/1989007
Text
. - _ _ _ _ _ _ -
. .
. .
8
I
APPENDIX B
U.S. NUCLEAR REGULATORY COMMISSION
REGION IV
NRC Inspection Report: 50-382/89-07 Operating License: NPF-38
Docket: 50-382
Licensee: Louisiana Power & Light Company (LP&L)
317 Baronne Street
'
New Orleans, Louisiana 70160
Facility Name: Waterford Steam Electric Steam Station, Unit 3 (W3SES)
Inspection At: W3SES, Taft Louisiana
Inspection Conducted: February 27 through March 3, and March 13-17, 1989
Inspectors: 8-5 M
L. D. Gilbert, Reactor Inspector, Materials and
/#42.h?
Date
Quality Programs Section, Division of Reactor
Safety
'
Y
W. M. McNeill, Reactob Inspector, Materials and Date
Quality Programs Section, Division of Reactor
Safety
bct o N trd 2./r9
R. C. Stewart, Reactor Inspector, Materials and Date
Quality Programs Section, Division of Reactor
Safety
Approved: # $bo, u./2/99
I.Barnes, Chief,Materialsann.OualRy Date
Programs Section. Division of Reactor Safety
i
4270360 890415
0 ADOCK 05000392
PNV
1
!
(
_ _ . - . - - -.
_ _ _ _ _ _ _ _ _ _ _ _ _ ._____________j
___ _
- _ _ _ _ - - _ _ _ _ _ _ ._ _ _ _ . -
. .
< ,' '.
, ..
,
_2
J
Inspection Summary
'
Inspection Conducted February 27 through March 3, and March 13-17, 1989
~~'
(Report 50-382/89-07)
Areas Inspected: Routine, unannounced inspection of action on previously
identified findings, licensee self-assessment capabilities, and procurement
activities.
Results: The licensee has established programs and procedures in regard to
onsite and offsite review committees as well as an independent safety
engineering group (ISEG). The activities of the Safety Review Committee (SRC)
appeared to be well documented and followup on items was satisfactory with some
l
minor exceptions. One apparent violation was identified (paragraph 3.a) in
r
regard to the failure of SRC to review certain 10 CFR 50.59 evaluations.
Activities of the Plant Operations Review Committee (PORC) were not, in
general, well documented. In certain cases, the lack of detail regarding PORC
meeting comments was such that actions on comments could not be verified. Two
examoles of one ~ apparent violation were identified (paragraph 3.b) in regard to
the failure of PORC to satisfy the requirements of the Technical
Specifications (TS). Specifically, PORC failed to meet in a quorum for all
meetings and also failed to review two radioactive releases. ISEG was also
found to be in need of improvement in regard to control and documentation of
work activities. In general, programs for. procurement, receipt, storage, and
handling of safety-related equipment and materials, including the dedication of
commercial grade components, were found to be satisfactory. One apparent
violation was identified (paragraph 4) in regard to the absence of measures for
control of items for which vendors had made unsolicited shelf life
recommendations. Items were also observed in storage without imposed shelf
life limitations and for which current procurement practices would request
shelf life information from vendors. The licensee has committed in response to
Violation 382/8902-03 to establish an overall program for control of limited
shelf life materials, including review of items currently stocked in
warehouses.
i
_ ._ ..
. .
t
-
- ,
,
. .
-3- !
!
DETAILS
1. Persons Contacted i
LP&L Personnel
- R. C. Azzaretto, Nuclear Operations Engineering & Construction (N0EC)
Manager
- P. N. Backes, Assistant Plant Manager
- D. E. Baker, N0SA Manager
B. C. Baptist, Materials Management Superintendent
- R. P. Barkhurst, Vice President
- L. L. Bass, Nuclear Operations Engineering & Construction (NOEC)
Supervisor
R. F. Burski, Nuclear Safety & Regulatory Affairs Manager
- N. 'S. Carnes, Plant Manage,'
li. Collyer Fire Protection Engineer
- G. M. Davis, Event Analysis Manager
S. E. Farkas, Licensing Engineer
- D. V. Gallodoro, Procurement Engineering Supervisor
- E. B. Hyatt, Nuclear Safety Review Engine (*
- J. E. Howard, NOEC Manager-
- J. H. Johnston, Operations Assessment and Information Dissemination (OA&ID)
Engineer ,
- G. F. Koehler, Quality Assurance (QA) Audit Supervisor
W. T. LaBonte, Radiation Protection Superintendent
- L. W. Laughlin, Site Licensing Supervisor
J. Lawrence, Associate Analysts
M. L. Layton, N0SA Engineer
H. C. Leason, Radiological Engineer
B. G. Morrison, Licensing Engineer
- D. F. Packer, Assistant Plant Manager, Operations & Maintenance
0. P. Pipkins, Safety Review Committee, Support Engineer
R. J. Pollock, QA Auditor i
- P. V. Prasankumar, Assistant Plant Manager, Technical Services 1
J. A. Ridgel, Assistant Radiation Protection Supervisor , I
R. D. Riser, Procurement Engineer j
C. Schmaltz, Warehouse Foreman i
- J. Sleger, Nuclear Safety Review Manager l
H. R. Sonmmers, OA&ID Engineer i
- P. E. Troy, Independent Safety Engineering Group (ISEG) Supervisor )
J. H. Wade, QA Engineer i
M. Wilson, Warehouse Foreman j
R. F. Wilson, Systems Engineer <
- J. J. Zabritski, QA Nanager J
NRC Personnel l
- T. R. Staker, Resident Inspector
- W. F. Smith, Senior Resident Inspector
_ --_ _ - - _ _ _ - _ _ - _ _ - _ _ _ _ _ _ - _ _ - _
-
_
f.
, . .
.
..
'i.
-4-
- Denotes those persons that attended the exit meeting on March 17, 1989.
In addition, the NRC inspectors contacted other members of the licensee's
staff.
2. Followup on Previous' Inspection Findings (92701 and 92702)
I
a. (Closed)OpenItem(382/8823-04): The Safety Issues Management
System (SIMS) had blanks in the safety-related data fields.
The NRC inspector reviewed the licensee's actions set out in
Memorandum W3M88-124 dated October 4,1988. The.SIMS data base was
searched on March 16, 1989, at the request of the NRC inspector for
any blanks in safety-related fields. Only four items were found
which had blank fields because of apparent data entry errors. This
is a significant reduction from the 1500 blanks that had been found
earlier. The processing and updating of SIMS now appears in control.
This item.is considered closed,
o
b. (Closed) Violation (382/8810-01): Failure to have documentation of
qualification for the containment cooling fan motors which use
Mobil-Temp SHC-32 grease in lieu of Chevron SRI-2.
During this inspection, the NRC inspector reviewed the applicable
correspondence relative to the compatibility of the subject greases,
including analysis conducted by Mobil Oil Corporation, letter dated
April 20, 1987, and an analysis conducted by Bolt & Associates
Consulting Services, letter dated November 29, 1988. The results of
.
those studies indicate that the two greases are compatible and that
there is no potential safety concern; however, the licensee plans to
replace the Mobil-Temp SHC-32 grease with the Chevron SRI-2 during
the next extended plant shutdown period. This item is considered
closed,
c. -(Closed) Violation (382/8811-01): Failure to follow procedures with
respect to evaluation of Quality Notices (QNs) for 10 CFR Part 21 ;
deportability. J
J
'
Durir.g this inspection, the NRC inspector reviewed the licensee's
letter of response to this violation and the referenced QAP-012 and
UNT-5-015 precedure revisions dated June 15, and July 1,1988,
respectively. In addition to the procedure revisicns, the licensee's
corrective actions included the change of responsibility for review j
and coordination of ONS for potentially reportable 10 CFR Part 21 {
items to the event analysis reporting and response group. Also, the !
NRC inspector reviewed the licensing QN log and verified that all
velfd QNs were properly recorded as having beer reviewed for Part 21
reporteoility. This item is e,onsidered clond.
d. (Closed) Unresolved Item (382/8815-01): QN QA-87-069, relating to
valve stroke time data, remained open on the current QN status report
!
. _ _ _ _ - _ _ _ -
, ..
. .
.
.
-5-
despite a completion schedule 9 months earlier and without supportive
'
justification.
During this inspection, the NRC inspector observed that this QN was
also identified in Violation 382/8811-01 noted above. Based on the
licensee's corrective actions, which incorporates this is:ue, this
item is closed.
3. Licensee Self-Assessment Capabilities (40500)
The objective of this inspection was to evaluate the effectiveness of the
licensee's self-assessment programs. In this regard, the NRC inspector
reviewed the activities of the SRC, the PORC, and the ISEG. The thrust of l
this inspection was to measure how effective these groups were in l
identifying of concerns and following them to resolution.- '
a. SRC
The activities of the SRC were governed by a manual which contained
the charters of the SRC and its two subcommittees. The current SRC
manual is under review and revision by the licensee to incorporate
such changes as a new subcommittee on corrective action. The SRC
currently meets every other mcnth with a quorum of nine: the Vice
President-Nuclear, and managers of Nuclear QA, Nuclear Safety and
Regulatory Affairs, Nuclear Operations Engineering and Construction,
Nuclear Plant Operations, Nuclear Operations Support and
Assessment (NOSA), and also three consultants. The meetings
addressed agenda items such as:
Plant operating status (trips, outages, team inspections, etc.)
Outstanding action items
3,.
Reviews by Operations Assessment and Information
Dissemination (OA&ID) of Institute of Nuclear Power
Operations' (INP0s) Significant Operating Experience
Reports -($0ERs), and Significant Event Reports (SERs), and
Combustion Engineerit,g
as well as, Licensee (CE) Availability)
Event Reports (LERs andData
EOSAProgram Reports,
Surveillance
and Assessments
NRC issued violations ;
Reports of design deficiencies
OA audits and findings
Licensee amendments and Technical Specification (TS) changes
Standing committee reports (audit subcommittee and review ,
subcommittee) I
u__
- . _ _ __ _ _ _ _ _ _ _ _ _ _ _
. .
! , .
. .
-6-
<
The NRC inspector reviewed the last three meeting minutes in detail
which were numbered 89-01, 88-19, and 88-16. It was noted that prior
to the above point in time. a different format for SRC meeting was
[ used. There were additional meetings of SRC which were called
"special" in which TS change requests were addressed. The NRC
L -inspector attended the 89-02 meeting.
,
Some observations by the NRC inspector were the following:
Agenda Item III-B in the 69-01 meeting discussed Potential
Reportable Event (PRE)88-054 which dealt with the installation
in Station Modification No.138 of a refueling level indication
system with an excess length of tygon tubing. The root cause
analysis by the licensee concluded that the shift supervisor
! >
should not have accepted the station modification in a. partial
status, namely, without an implementation procedure for'the
operation of the refueling level indication system. It appeared
that the SRC did not question the historical and generic impact.
In other words, were there other station modifications without
an implementation procedure for the system or equipment
modification.
Agenda Item III-C addressed two recommendations of a Quality
Effectiveness Assessment Report received by LP&L which was
performed at W3SES by Middle South Utilities. It was not clear
to the NRC inspector if all,'or at least the significant
recommendations, would be discussed by SRC in future meetings.
The Quality Effectiveness Assessment had 26 recommendations and
six dealt with the SRC. The NRC inspector then asked how such
items as INP0 evaluations were dealt with by SRC. The NRC
inspector found that the most recent evaluation had been
addressed in Meetings 88-01 and -02 before the INP0 report had
been issued to LP&L. The discussions were.only of the tentative
or possible findings, and not of the final report's findings and
the corrective actions associated with such. It appeared that
the final reports of external assessments such as INP0
evaluations of W3SES were not subject to a review of SRC.
Agenda item IV-B of 89-01 addressed follow up on the revision of
Procedure N0P-014 on design change control. The subject was
c'losed although it was not clear that the specific question
raised in the 88-19 meeting on the controls to be in the
procedure, in regard tu partial closed verus partial turr.over,
was addresud. There appeared to be only a general discussion
of the design change process. The tracking of the question from
one meeting to the next appeared to have been lost in this case.
Agende Item X-A addressed QA audits and states that no
significant QNs were issued. The NRC inspector noted that the
attachment summarized that there had been three QNs on the
subject of bypassing and other controls of " hold points" and the ,
Quality Effectiveness Assessment had observed the same problem !
!
__ _ _ _ - - _ _ _ _
- _ - -
l' e *
.
.
4 8
-7-
, . -
.and found it significant enough to issue a recommendation. It
would appear that what is significant for SRC, discussion has not
been clearly defined.
'
Agenda Item X-B addressed the SRC review subcommittee
activities. The attachment to the minutes, which was the' review
subcommittee report', stated that the 1988 annual
10 CFR 50.59 report contained 39 evaluations of which 14 had not
been received by the subcommittee. At the request of the NRC
inspector, the licensee followed up further_ on this subject. As
a result, it was established that 32 of the 65 safety
evaluations in the report t<ere not received by SRC until after
the annual 10 CFR 50.59 report. It was identified that the
following four 10 CFR S0.59 evaluations had not been submitted
to SRC:
(1) Project Evaluation /Information Request (PEIR) No. 20000,
" Spent Fuel Pool Heat Load Calculation," with an August 27,
1986, 10 CFR 50.59 evaluation and no apparent PORC review.
(2) PEIR No. 70795 "Use of the Refueling Water Storage Pool
Cross. Connect Line," with a October 8, 1986, 10 CFR 50.59
evaluation and October 14, 1986, PORC review.
-(3) Condition Identification (CI)/ Work Authorization (WA)
Nos. 255672/01017834, "In-Core Instrument Thimble Failure,"
with a May 26, 1988, 10 CFR 50.59 evaluation and May 27,
1988, PORC review.
(4) Special Test Procedure No. 99000104-1, " Seal Oil System
Post Mod Operation," with an April 12, 1988,
10 CFR 50.59 evaluation and May 17, 1988, PORC review.
The failure to perform SRC reviews of these 10 CFR 50.59 evaluations
was identified as an apparent violatica of TS (382/8907-01).
In the above review effort, it was noted that Station Modification
Packages (SMPs) 0097, 0441, 0502, 0804, 1215, 1427, and 1494 were
revised after SRC. review. Inst.f ficient time was availatle during the
4 inspection to ascertain whether a;1ditional 10 CFR 50.59 evaluations
were performed and which were reviewed by the SRC. This is an NRC
inspector followup item (382/8907-04),
- Tne 89-02 neeting was attended by e QA representative, who had
also attended a PORC meeting where some of the same agenda items
were revieved;;e.g.,'iS Change Ivo, 88-21. Attendance at both
meetings appears to have occurred because of a recent change in
the organization. The individual in question did not excuse
himself from the discussion, and he mentioned the PORC review
comments. This situation would appear to be inconsistent with
TS requirements for independent review of PORC by SRC.
l
_ _ _ _ _ _ - - _ _ _ _ _ _ _ . _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ - _ _ _ _ _ _ _ _ _ - _ _ -
_.
. .
. .
. .
-8-
Summary
- . The SRC meetings appeared to be well documented and followup on items
appeared to be satisfactory with the exceptions noted above. It
should be noted that the above review was possible because of the
excellent level of detail and documentation in the SRC meeting
minutes. Also it should be noted the apparent violation on
10 CFR 50.59 reviews reflects more on the' failure of PORC to input
into the SRC.
b. .PORC
The activities of the PORC were governed by Administrative Procedure
No. UNT-1-003 and some associated procedures. The current procedures
were under review by the licensee in order to simplify and clarify
the process of PORC review. The PORC currently meets every week with
a quorum of seven: Assistant Plant Managers of Operations,
Maintenance, and Technical Services; Manager of Operations QA; and
Superintendents of Plant Engineering, Operations, Maintenance, and
Radiation Protection. The meetings addressed such agenda items as:
Procedure changes and revisions
LERs and PRES
TS changes
SMPs and Design Changes
CIs and WAs
- Justification for Continued Operations
The NRC inspector reviewed the meeting minutes numbered 88-100
through -127. The NRC inspector attended PORC Meeting 89-24.
Some observations by the NRC inspector were the following:
A significant fraction of the PORC meeting minutes were
characterized as " walk-thrcugh" meetings where PORC did not meet
es a quorum meeting with all members present. It appeared that
only one or two items were addressed in each of these :
" walk-through" meeting minutes. The " walk-through" process was
a serial ballot review technique in which the members
sequentially reviewed an agenda item. This was described in the
implementing procedure in Step 5.2.7.2. It should be noted t. hat
American National Standard Institute (ANSI) N18.7-1976, a
comm1trent of W3SES, states in 4.3.2.3 for a meeting to be he16,
a cuorum shall be present. The failure to have a qaorum present
for " walk-through" meetings was identified as one example of an
apparent violation (38E/8907 02).
At Meetings88-107 and -112 radioactive releases were presented
to PORC which were not voted upon or apparently reviewed except
to the extent to conclude that the releases were not to be given
PORC review. The releases in question occurred on April 3 and
)
.
_
. __ ._ - - _ _ .
_ _ _ _ _ _ - - _ _ , _ _ _ _ _ - _ _ _ _ -
.
'
. .
. .
I
- ,' .
,
.g.
L,
M May 23, 1988, and were minor in character and for which LERs
'
.were not' required. The review of accidental, unplanned or
uncontrolled radioactive releases. including the' evaluations,
recommendations, and disposition of the corrective actions to
prevent.. recurrence is required by TS. The failure to review
these releases was identified'as the second example of an
apparent violation (382/8907-02)..
Because of the use of the same forms'by PORC and the normal
document review process to document comments, it is not always
clear what were the comments made at the PORC level of review.
In certain cases, the recorded PORC level coments made during
meetings- failed to have.. sufficient detail to allow verification
of resolution of the coments. It appeared that coments made
in regard to Procedure MI-0-462 made at 88-120 and -127 meetings
were not complied with by the staff. Because of the lack of
detail, an effective evaluation of PORC review activities was
not possible.
Sumary
Improvement is needed in the area of documentation of PORC review
activities which would allow verification of the identification of
4
items and followup on such. The licensee plans revision of the PORC
procedures and activities.
- c. ISEG-
The activities of the ISEG were governed by Procedure N0 SAP-102 and a
,
supporting procedure. The licensee was planning an additional
procedure, N0 SAP-109, to further define ISEG activities. ISEG was
staffed with a supervisor and four other engineers. ISEG addressed
items identified by management of ISEG and other management sources.
In addition, ISEG performed surveillance and assessments in
accordance with a schedule.
Operating experience, outside and inside W35ES, was reviewed by ISEG.
The NRC inspector reviewed the monthly reports for the last 3 months, f
^
the 1988 schedule, and a sample of " Assessment" and "Survefilance"
reports.
Some observations by the NRC inspector were the following:
' "
The monthly reports for December through February were
inaccurate-in that the number of recommendations were not ,
reported correctly.
A schedule for 1989 had not been established as of the time of
this inspection.
_ - _ _ _ _ - - _ _ _ _ _ _ _ _ _ - - - _ - _ - - _ _ _ _ _ _ _ _ _ _ _ _ _ - _ _ _ _ _
_ _ _ _ _ _ - _ _ _ -
v . ;.
, *J;
>' , '; ,
,i
>
, i
~ '
< - -10- I
Reports of.." Assessments" and " Surveillance" failed.to include
A '
.significant details. For example, Re' port 239-88 failed to
L fidentify that a. recommendation in the report was also' identified
'
in a QN and that the closeout of the recommendation would be via
closecut of'the QN .
The' status of recommendations and reports was misleading. . .
Reports 194-88 and 197-88 were signed off as closed, when in.
N fact, their status was open. Report 183-88 was not signed.off?
- -
<
.as closed, when in fact, its status was closed.
p
.There appears.to be a lack of timely. followup on recommendations
which were the result of." Assessments" and " Surveillance." In
~
,
1988, there^had been 54 recommendations issued.of which 27 were
open.as of the time of this inspection.
;
There was no documentation of the reviews performed of NRC
Notices, Bulletins, Notice.of Violations, LERs, 10 CFR 50.59
reviews, PRES, SMPs, procedures and other operating experience
. reports when ,the review by ISEG did not result in'a comment or
recommendation.
- The!1icensee had performed a QA audit of ISEG activities and
, -identified some of the above observations. The QA audit did not
identify the problems above as findings and the report was'in a
draft status as of the time of this inspection.
Summary ,
ISEG activities were found to be in need of improvement. -ISEG
activities in the'past appears to'have been better managed in certain
areas. such as monthly-reports, and should be reviewed again after
.
implementation of N0 SAP-109.
7 d.- 0ther Organi n tions
-The activitin of N0SA, in particular DA&lD and the assessment group,
were reAewed. -These activities tvers governed by Proceduras N05AP-103
anu 104. 0A&IO performs reviews of operating experience reports such
i'
..
- as Significant Occurrence Reports (50Rs) and PRES in accordarce with
6 a checklist for deportability on the nuclear network. INPO S0s,
l<,. SOERs, and SEPS are also reviewed by OA&ID. Several recent evaluations
<" > of PRES and SERS by 0A&ID were examined by the NRC inspector. The
j -identification of items and followup appeared satisfactory.
'
I
" In regard-to the assessment group, it was noted that it shared the
same problem ISEG- had, as identified above, in regard to timely
followup of recommendations. The assessment group reviewed third
,
party audits of W3SES by INP0, Middle South Utilities, and others, in
=. - ___ _. _ _ _ _ _ _ .-_ _ _ _ _ _ ___ _____ __ _ ___-__ - - - - - - -
'
'
[,
. . ]
p
p. -
m .. .
,
h -11-
L
order to establish priorities for its assessment and surveillance
schedule.
Summary
Other organizational activities in regards to self-assessment
appeared to be implemented at W3SES. Some of these activities
appeared to cover areas that are normally addressed by ISEG.
4. Procurement, Recei)t, Storage, and Handling of Equipment and Materials
Program (38701,-33702. and 38703)
Initial NRC inspection of the programs for procurement, receipt, storage,
and handling of equipment and materials is documented in NRC Inspection
Report 50-382/89-02.. During this inspection, the NRC inspectors reviewed
the following additional documents in. order to verify that administrative
controls exist and that they provido measures to ensure that received
materials and equipment will be examined for conformance with requirements
specified in the procurement documentation. The documents were reviewed
to verify that acceptance criteria were' clearly established and that
requirements for documenting the~ performance of receipt inspections were
= delineated.- They were also reviewed to assure that controls exist with
respect to storage and maintenance of safety-related items, and
responsibilities were assigned in writing.
Document No. Revision Title
N0EP-004 1 The Engineering Procurement Process
QAP-251 2.0 Material Storage Inspection
UNT-8-013 3 Receiving, Handling, and' Storage
ME-4-703 7 Routing Electrical' Equipment Inspection
and Maintenance
The NRC inspectors reviewed the licensee's computer listing of commercial
grade parts or components which were designated Quality Class 3 items that
had been installed in safety-related systems or equipment and selected the
following items for review of the procurement and dedication processes:
-
Condition Purchase
identification _ Order Stockcode Description _
252256 14436 101-A04159 Flanged Bearing for Personnel
Air Lock Hand Wheel Shaft
254069 16795 135-C11563 Diaphragm for Resin Tank
Isolation Valve
_ _ __ _
,
-. -
. .
.
.
. o
,
-12-
256126 15740 151-F00027 Adhesive Thread Sealant for
Reactor Coolant Loop 2A Cold
Leg Temperature Detector
257372 11740 135-C30772 Insert Disc with Pin and
22961 160-A00034 Bellows Subassembly for
Charging Pump A Discharge
Header Relief Valve
259165 73018 102-C50002 Stud Bolt Nut for Reactor
Coolant Pump 1A and Motor
Coupler Assembly
260848 16688 101-D38476 Seal Kit, Jackscrew
22958 135-C00191 Assembly, Spiral
135-C58055 Assembly, Seal Nut, and
135-C70187 Cylinder Assembly for
23258 135-C00209 Component Cooling Water
Supply Valve Operator
The NRC inspectors reviewed the procurement and receiving inspection
documents while reviewing the commercial grade dedication process for the
items selected above. The reviewed documentation consisted of a purchase
order, a receipt checklist which addresses shipping damage,
identification, documentation received, protective devices, and
cleanliness, and an engineering evaluation. The programs for procurement,
receiving inspection, and dedication of commercial grade parts and
components appeared to be effective with respect to meeting the committed
objectives.
The NRC inspectors also inspected for proper storage of safety-related
equipment ard materials in Warehouses 7B and 2B, and the Service Buildir.g
Warehouse. The buildings were designated Storage Leval B except for a
small room in the Service Building which was controlled as a Storage
Level A. The NRC inspectors reviewed the Warehouse Surveillance
inspection Records of the sturage areas fnr March 6-12, 1989. The
environmental conditions in the storage areas were consistent with the
stora5e level requirements o# Procedure UNT-8-013. Electric motors, which
are required to be heated while in storage, were observed with heaters
energized and maintained as specified in Procedure ME-4-703. During the
tour of the storage areas, tha NRC inspectors selected the following items
to verify the tagging or marking for traceability of the item to purchase
documents, receipt documents, quality certification documents, and if
applicable, limited shelf life.
Stockcode Purchase Order Description
120-A73132 83287 Stainless Steel Tubing
135-B81240 48296 Globe Valve
107-C00001 66121 Alumina Activated Desiccant
- _ _ _ _ _ _ . _ _ _ _ _ _ - _ _ _ _ _
_
.. .
. .
. o
,
-13-
105-A46185 19475 Limitorque Electric Motor
135-B80910 14639 Valve Solenoid
152-C19300 16679 Mass Flowmeter
138-A15424 10458 Welding Material
151-B15408 66101 Welding Material
151-B15407 66101 Welding Material
101-D53873 96954 0-Ring
102-C53947 16176 0-Ring Gland Plate
102-C54033 23305 0-Ring
102-C53944 20768 0-Ring Gland
127-B38461 24764 Spare Parts Kit
127-B53849 24764 0-Ring
The above items were traceable to purchased documents, receipt documents,
and quality certification documents; however, discrepancies were noted
regardir.g the identification of limited shelf life for the following
items:
a. Unsolicited Shelf Life Limitations Provided by Vendor _s,
' The Material Management Information System specified no shelf
life requirements for Stockcode 152-019300 but the vendor
documentation received for the mass flowmeter gave an unsolicited
shelf life of 3 years.
The Material Management Information System specified no shelf
life requirements for Stockcode 101-D53873 but the vendor
documentation received for the 0-Ring gave an unsolicited shelf
life of 20 years.
Although the licensee was attempting to implement unsolicited shelf
life limitations received from vendors, no formal program was in
place to handle this matter. The licensee stated that a procedure
will soon be issued to promulgate the requirements for limited shelf
life, including handling of uronlicited info;mation. This is in
apparent violation for failure to identify and control limited shelf
life materials. (382/8907-03)
b. Shelf Life Limitations Not Requested From Vendors
- The Material Management Informatten System specified no shelf
life requirements for Stockcode 102-C53947. The vendor was not
' requested to provide shelf life limitations for this 0. Ring
gland plate, therefore no information ws.s provided.
The Material Management Information System spec 1fied no shelf
life requirements for Stockcode 102-C54033 from Purchase
Order 23305. The vendor was not requested to provide shelf life
limitations for this 0-Ring, therefore no information was
provided. However, a shelf life was received on another
purchase order for this stockcode.
,
_ __ - _ _ - - _ _ - - _ - - - _ _ - _ _
- - - -. _ _ _ - _ _ - _
... .. -
. # ll .
y . .
.
-14- 1
J
The Material Management Information System specified no shelf
life requirements for Stockcode 127-B38461. The vendor was not
requested to provide shelf life limitations for.this spare parts
kit, therefore no information was provided.
The Material Management Information System specified no shelf
life requirements for Stockcode 127-B53849. The vendor was not
requested to provide shelf life limitations for this 0-Ring;
therefore no information was provided.
The above discrepancies are additional examples of a recent inspection
finding, Violation 382/8902-03, documented in NRC Inspection
Report 50-382/89-02. The licensee has written Quality Notice QA-89-071
which will assure that'these items are included in the corrective
action developed for Violation 382/8902-03. The licensee has
committed in response to this violation to establish an overall
program for control of limited shelf life materials, including review
of items currently' stocked in warehouses.
5. Exit Meeting
An exit meeting was held on March 17, 1989, with those individuals denoted
in paragraph 1 of this report. At this meeting, the scope of the inspection
and the findings were sunnarizeo. The NRC resident inspectors also
attended. The licensee did not identify as proprietary any of the
information provided to, or reviewed by the NRC inspectors.
.
I
k
i