Text

Submits Quantity of Tubes Insp from Either Side of SGs A-D & Lists Tubes with Imperfections,Locations & Size.No Tubes Removed from Svc by Plugging.Total of Eleven Tubing Wear Indications Identified at Secondary Side Supports in SGs
	ML20217F326
Person / Time
Site:	McGuire
Issue date:	10/13/1999
From:	Barron H; DUKE POWER CO.
To:	; NRC OFFICE OF INFORMATION RESOURCES MANAGEMENT (IRM)
References
	NUDOCS 9910200291
	Download: ML20217F326 (10)
	v • d • e

% !

F .. .+. I i ,,_ ._;

' Duk3 Energy Corporatiin

[-'

D. bg,

/

iM McGuire Nuclear Station 12700 Hagers Ferry Road I

Ifuntersville, NC 28078-9340 ti.' B. Barroh (704) 875-4800 omcs

( Vice President (704) 875-4809 FAX l October 13,1999.

U. S. Nuclear Regulatory Commission Document Control Desk -

Washington, D.C. 20555

Subject:

McGuire Nuclear Station I Docket Nos. 50-369 Unit i Steam Generators EOC-13 Refueling Outage !

)'

Pursuant to Technical Specification 5.6.8 part a and part b, the following information is submitted:

a. The following quantity of tubes were inspected from either side of the generator.

Tubes Inspected Steam Generator Full Leneth A 2017 B 2024 C 2069 D 2017

'he following information is submitted concerning tube indications ofimperfections. (The attached list identifies the tubes with imperfections, their locations and their size)

Steam Generator Attachment A 1 B 2 C 3 D 4 c.There were no tubes removed from service by plugging.

1 A total of eleven tubing wear indications were identified at the secondary side supports in all four steam generators. These indications were sized with a qualified rotating pancake coil technology and exhibited l typical wear characteristics.' The largest indication was 13% through wall which is less than the 40%

through wall Technical Specification repair criteria. Therefore, no tubes were removed from service by plugging. l Any questions should be directed to Kay Crane, McGuire Regulatory Compliance, at (704) 875-4306.

Sincerely, i

% f H. B. Barron, Vice President

' McGuire Nuclear Station

/_

{l j

.s cmn80 9910200291 991013 PDR ADOCK 05000369 P PDR -

I I

L

p 7 ..

l: -#

1

,, U.S. Nuclear Regulatory Commission

<- > October 13,1999 Page 2 .

cc:- ' Mr.L. A Reyes

~ Regional Administrator, Region 11 '

. U, S. Nuclear Regulatory Commission

'61 Forsyth St., SW, Suite 23T85 ~

< Atlanta, Georgia 30323

, Mr. F. Rinaldi, Project Manager .

- Office of Nuclear Reactor Regulation - a

- U. S. Nuclear Regulatory Commission I Washington, D.C. 20555 Mr. Scott Shaeffer

' Senior NRC Resident Inspector -

. McGuire Nuclear Station i

.t'.

1 t-

, _~

l u.,

V i.

i*************' FTI TUBAN II;(Vareion 2.3) . 10/06/1999 15:07:01- *************

E******4******

McGuira N.S. - Unit.Ona Replcczmsnt *************

j S/G-A' *************.

p.

09/99 RFO.. *************

f :=************* BOBBIN,MRPC.C/L'SI;MRPC H/L SI,MRPC UBEND SI r

!. := #

l' l' Page 1 cATTACHMENT #1 - INDICATIONS OF IMPERFECTIONS INDS OF IMPERFECTIONS'- SGA

( . ROW COL OUTAGE _ TEST. TYPE

, IND %TW VOLTS LOCATION.

, -2 17.09/99 BOBBIN ADI 0.60 02H +22.40 l .

09/99 .MRPC H/L.SI- VOL 0.37 02H +22.32 2.- . 95 05/99- BOBBIN ADI. 1.05 04H +9.24 2 103 09/99 ' BOBBIN ADI 1.22 04H +13.47

, 6 39 09/99' BOBBIN ADI 0.18 02C +16.32 09/99 MRPC C/L SI' VOL 0.13 02C +16.16 ,

s 6c.41 09 99 BOBBIN 'ADI 0.84 08H +37.53 t 6; 47 09 99 BOBBIN ODI 24 0.20 08C +21.97

7. 52 09 99 BOBBIN- . .ODI- 19 0.30 01C +14i15 09 99 MRPC C/L SI VOL 0.28 01C- +13.56 15 128 09 99 BOBBIN- ADI' O.19 08C +24.32 22 45 09/99 BOBBIN ADI '0.20'01H' +12.15 09 99. MRPC H/L SI VOL '0.29 O1H +11.79

'22- 71 09 99 " BOBBIN ODI. 10 .0.42 01C +21.92

23 100 09 99 BOBBIN ADI 0.50 07H +30.75 to +32.00 24 39 09/99 BOBBIN- ODI- 4 0.53 05H +7.69 09/99 BOBBIN ODI 11 0.37 06C +36.94 >

09/99 .MRPC C/L SI VOL 0.16 06C +38.91

'09/99 MRPC C/L SI. VOL' O.29 06C +36 98 09 99: MRPC H/L SI- VOL 0.37 OSH +7,75 24 69 09 99: BOBBIN ADI 0.18 04H +26.60 09 99 JMRPC H/L SI- VOL 0.16'04H +25.85 25 72:09/99. BOBBIN ODI 4 0.43 03H +10.43 25 126 09/99. BOBBIN ODI 3 0.22 04C +16.25 J29 70 09/99.' BOBBIN OXP 36.74 TEH' +23.02 to +24.88 v32 101-.09/99-- BOBBIN- ODI- 6 0.38 08C '+3.22 09/99 MRPC C/L SI VOL o0.09 08C +3.41 41_~134 09/99 BODBIN L ODI 4' O.13 02H +37.35 09/99 MRPC H/L SI- VOL .0.08 02H +25.40 _i 09/99' MRPC H/L SI VOL 0.12 02H +37,35 45 118 09/99 BOBBIN NQI 0.07 04H +5.71 09/99 BOBBIN ODI 10 0.17 04H +17.70 09/99 MRPC H/L SI VOL 0.08 04H +17.70 3

i 09/99 MRPC H/L SI VOL 0.19 04H +5.71 I

'47 40.09/99 BOBBIN ADI 0.27 05H +21.57 j 09/99 BOBBIN ADI 0.34 05H +17.02 i 09/99 BOBBIN ADI 0.37 OSH +32.38

-47 52 09/99 BOBBIN ODI 14 0.20'TSH +3.80 48- 43.09/99- BOBBIN ADI 0.36 02C +17.38 i 09/99 BOBBIN ADI 0.50 02C +19.36 {

.09/99 BOBBIN

'ODI 21 0.21 03H -2.52 09/99 MRPC.C/L SI' .VOL 0.46 02C +17.51 )i 09/99 -MRPC C/L SI- VOL 0.55 02C. +19.54 )

52- 35 09/99 BOBBIN. ADI 0.80 TSH +4.69 55' 56.09/99 . BOBBIN ODI 9 0.27 OBC +14.64 65 .54 09/99 BOBBIN . ADI 0.20'03H +5.74

09/99 MRPC H/L SI VOL 0.15 03H +5.38 F69- 58 09/99 BOBBIN .

ODI 7 0.18 02H' +3.52 09/99 MRPC H/L SIL VOL 0.14 02H +3'36 79 ;72 09/99- BOBBIN ODI 11 0.37 03H +17 33 83 60 09/99L BOBBIN NOI 0'20 FB4

. -0.53 $

~09/99 MRPC UBEND SI WAR 8 0.35 FB4 -0.60 94 ..77-09/99 BOBBIN NQI 0.07 FB4 +0.71 09/99 MRPC UBEND SI~ . WAR 7 0.12 FB4. +0.48 97 102 09/99 BOBBIN IRR 23.90 TEH +12.93

'107' 60'09/99 BOBBIN ODI 11 0.39 03C +16.34 Total 1 Indications Found'= 56 Total Tubes Found = 31 l-L i

?

J

D,.^l^' '

%v::***,**********

l

'e************

JFTILTUBAN II (Varsion.2.3)- . 10/06/1999 15i14:17 '*************-

,McGuire N.S. 'Unitions Rsplactm3nt- ' *************

- - - - ' S/G.B- '*************-

- - - - - 09/99 RFO' *************

~ *************

nc;.************* ~ BOBBIN,MRPC C/L'SI,MRPC H/U SI,MRPC UBEND SI' l- c

+ t JATTACHMENT #2 - INDICATIONS'OF IMPERFECTIONS -

'INDS-OF IMPERFECTIONS - SGB~

. ROW COL OUTAGE TEST TYPE IND:%TW VOLTS LOCATION

'lL134 09/99 ~ BOBBIN- ADI 0.22 03H +30.41' 27125 09/99 BOBBINt .

ODI : 10 - 0.22 01H' +4.50 09/99' MRPC-H/LlSIJ VOL 0.14'01H . +4.19' i

3.-88109/99 BOBBIN- ~

ADI 0.24 02C- +5.46 )

.O9/991 MRPC C/L SI VOL -0.08 02C' +4.66 3-114 09/99 cBOBBIN . ADI 0.29 O1H +14.10

'09/99 MRPC H/L SI VOL 0.23 O1H +13.96 c3i142.09/99 BOBBIN' NEX- 11.29 TSH -0.27 4: 5 09 99 BOBBIN NEX 11.06 TSH. -0.31 to +0100-

~5: 1 22 09 99 BOBBIN- . ADI 0.24 04C +18.31 09/99- MRPC C/L SI VOL 0.12 04C +17.52 5- 72LO9/99-' BOBBIN NQI 0.36 07H +1.02

.. ! '.09/99; MRPC-H/L SI- WAR 7 0.32 07H +1.45~

6 111 09 99 BOBBIN ADI 'O.38 02H +18.44-8 :5 09 99 BOBBIN .NEX' .9.20.TSH -0.24-9- 14 09/99'# BOBBIN . .,

ADI. 0.41 03C' +2.82

_09/99 MRPC C/L SI: VOL 'O.36 03C^ +2.43 10 5,09/99 . BOBBIN NEX' 7.33 TSH -0.26 1 113 ' 80 09/99 -BOBBIN ADI 0.19 08H- -+6.60

'16L139 09 99.; BOBBIN- ADI 0.85 FB5 +6.13

'17 116a09 99. BOBBIN. ODI- 4 0.19-03C +29.51

.09/99 fBOBBIN' ~ODI- 6 0.20 06H- +9.27 109/99MRPC.C/L SI VOL 0.24 03C +29.42 09/99- MRPC H/L SI VOL -0.33106H " +9.30

-20 . l5LO9/99 -BOBBIN- .NEX 8.39 TSH -0.35 220: 65-09/99 -BOBBIN NQI 0.25 08H +35.33

20 139,09/99? BOBBIN. 'NDI 2.02'FB5 -2.17

.23= '6 09/99 . BOBBIN NEX. 8.24 TSH -0.37

.140 09/99- ' BOBBIN OXP 34.20 TEC. +11.64 25 6 09/99 BOBBIN- NEX 6.90 TSH -0.26 27c -6 09/99 BOBBIN NEX 8.04 TSH~ -0.33

-. 2 7 ? 8 09/99.! BOBBIN -ODI 11 0.12 01C +22.66 09/99 MRPC C/L SI: VOL 0.17 01C . +22.66

'27- 12 09/99 BOBBIN ADI 0.17 02H +23.60 29 .6.09/99 fBOBBIN NEX 7.50 TSH -0.20 31: 6 09/99 BOBBIN 'NEX ~8.51 TSH -0.31 32- 5'09/99 BOBBIN }HDL -8.65 TSH -0.24 37 6.09/39' BOBBIN NEX 8.29 TSH -0.25

'37.120 09/99. BOBBIN ODI, 9 0.50 TSH +13.60 39; 90=09/99 : BOBBIN .. . ODI' 11 0.27 02H +37.63 09/99 MRPC H/L SI VOL 0.26 02H +37.59 39 102.09/99 ' BOBBIN ODI 17 0.19 02H +4.98 09/99 MRPC H/L SI VOL 0.19 02H +5.15 39 13009/99 BOBBIN-

- OXP 36.82 TEC +5.65

-41 6 09/99 : BOBBIN' NEX 10iOO TSH -0.22 42- 75 09/99 BOBBIN -ODI 8 0.23 01C +5.89 09/99 MRPC C/L SI VOL 0.07 01C +4.64 09/99 MRPC C/L SI .VOL 0.07 01C +30.35 L09/99 MRPC C/L SI VOL 0.15 Olc- +5.87 1143^270 09/99 BOBBIN' ' LOXP 33.78 TEC +19.90

' 54 - 85 09/99 . BOBBIN' ADI .0.43 08H +29.46' l

09/99MRPC H/L SI .VOL 0.46 08H +29.52 09/991 MRPC H/L SI VOL 'O.47 08H +28.52 54l 93 09/99 - BOBBIN .

NQI' O.08 02H +23.66

'09/99 MRPC H/L sis VOL 0.21 02H +23.45 256. 11',09/99 BOBBIN- ADI 0.21 08H +16.44

-58L 91 09/99' BOBBIN: ODI. 2 0.69 02H +11.52 sz . <09/99 'MRPC H/L SI VOL OJ43 02H +11.36

'l' 159' 46 09/99 sBOBBIN' ODI 13 0.23 03C +12.92 60< 85109/99 ' BOBBIN . .ODI- 3 0.18 04H +30.49

'09/99 MRPC H/L SI VOL 0.25 04H +30.85 601109:09/99.- BOBBIN ADI. 0.14 05C -2.81 61~ 00.09/99 _ BOBBIN ADI 0.42 TSC +5.89 c Gi 85 09/99' BOBBIN- ADI 0.21 04C +36.63

'09/991 MRPC C/L'SI -VOLs 0.26 04C +36.63 l a

1 Ii' *****e*******L FTI' TUBAN II'(Varsion 2.3) 10/06/1999 15:14:17. *************

e************i

- - - - e6**;

McGuira N.S. - Unit Ona Rsplacamant *************

S/G B- *************

09/99 RFO *************

fBOBBIN,MRPC C/L SI,MRPC H/L SI,MRPC UBEND SI *************

ATTACHMENT, #2 -~' INDICATIONS OF IMPERFECTIONS

'INDS OF' IMPERFECTIONS - SGB '

ROW COL OUTAGE TEST TYPE IND %TW VOLTS LOCATION

'67'130'09/99 : BOBBIN OXP 87.03'TEC +12.22 68JL35 09/99 BOBBIN OXP 47.10 TEC- ' +0.48 to +19,68 y 68( 55~09/99 BOBBIN: NEX 8,57 TSH -0.33 70 71 09/99 BOBBIN ~ ADI. 0.17 07H +8.35

'71 82 09/99 BOBBIN- ODI 2 0.18 08H' -+32.43 09 99 BOBBIN ODI 8 0.16 06C +0.84 09 99 MRPC C/L SI VOL: 0.14 06C +8.84 09 99 -MRPC H/L SI VOL 0.15 08H +32.29 73 .60 09/99^ , BOBBIN ADI 0.21'07C +4.21 09/99 MRPC C/L SI VOL 0.07 07C - +4.21

.73.120 09/99- BOBBIN. OXP 23.96 TEC' +10.64 73'128 09/99 - BOBBIN- OXP 35.48 TEC +11.24 74 111 09/99 BOBBIN- ADI 0.52 TSC +15.25 75-100 09/99 B03 BIN OXP 33.38 TEC +11.48

.75.124 09/99 BOBBIN OXP t33.64 TEC +12.69

.78 55 09/991 BOBBIN OXP 47.'02 TEC +10.77 -j 79 24 09/99. BOBBIN ADIE 0.16 03H +13.84 1 79 82 09/99 BOBBIN - ODI 17 0.13 04C . +10.93 I 09/99- MRPC C/L SI VOL 0.19 04C +24.66 I 09/99 :MRPC C/L SI _VOL 0.20-04C +10.57 09/99^ MRPC C/L SI VOL 0.22 04C- +13.21 81-104'09/99 ? BOBBIN ODI .. 4 0.21:02C +8.77 84: 35 09/99 BOBBIN OXP- 37.55 TEC +11'.87 86 115'09/99 BOBBIN "OXP 52.45 TEC +9.47 87 26.09/99 BOBBIN- OXP- _ 35.02 TEC +6.67 88 53 09/99 BOBBIN ODI- 5 0.24'TSH +11.74 09/99 MRPC H/L SI -VOL 0.07 TSH +12.02 09/99 BOBBIN OXP 40.31 TEC +4.95 to +8.18

-90 115 09/99 l BOBBIN ADI 0.20 03C ~+29.41 1 09/99 MRPC C/L SI VOL 0.24 03C +29.41 l 101 66 09/99- BOBBIN .

ODI 10 0.35 02C +33.17 09/99 MRPC C/L SI VOL 0.28 02C +33.17 102 35-09/99 BOBBIN ODI 18 0.24 O1H +14.43 104 45 09/99 BOBBIN' NEX 8.59 TSC -0.26 106 65 09/99' BOBBIN -- OXP 29.84 TEC +7.59 107 60_09/99- BOBBIN OXP 38.05 TEC +8.48

'107 '80 09/99- BOBBIN OXP 34.46 TEC +5.78-108 '45 09/99 BOBBIN -NEX 8.73 TSC __-0.31 to +0.00

-09 99 BOBBIN OXP 46.16 TEC +0.42 to +7.77 114 .53 09 99.. BOBBIN NEX 8.74 TSH -0.31 114 55 0'9 99' BOBBIN NEX 7.02 TSH -0.29 !

114 87 09 99 BOBBIN' OXP' 46.36 TEC +17.37 3 114 91 09 99 ' BOBBIN OXP 44.82-TEC +0.31 to +9.08 l 115 56 09 99- BOBBIN NEX 6.25 TSH -0.26

-116- 55"09 99 BOBBIN- NEX 7.93 TSH -0.23 {i 117 58 09/99 BOBBIN NEX .9.32 TSH -0.26 3 117 L70 09/99 BOBBIN -OXP 49.18 TEC +2.55 to +25.05 l

-117- 86 09/99 -BOBBIN OXP 45.12 TEC +13.33 zTotal Indications'Found = 113 Total Tubes Found =:80 -

W

) i 1

1 l

1 I- 4 1

i I

E". .

I*~************ 'FTI TUBAN I'I-(Version-2.3):

10/06/1999 15:17:48 *************

- - - - McGuira N.S.' - Unit One Raplacemant 't

.'*e************_ .

S/G C *************

'09/99 RFO- *************

. BOBBIN,MRPC C/L SI,MRPC H/L SI,MRPC UBEND SI *************

" ATTACHMENT #3~~ INDICATIONS OF IMPERFECTIONS

'INDS OF, IMPERFECTIONS - SGC' ROW COL OUTAGE TEST TYPE IND . %TW VOLTS ' LOCATION 1< 48109/99: BOBBIN- ADI 'O.18 09H' +4.55

.2- 21 09/99 ' BOBBIN ADI 0.71'07C~ +4.74 to: +18.80

'2.? 6 3 09/99 ' BOBBIN ADI' O.33 05H +35.94.

3 84!09/99.'. BOBBIN- NQI- 3.30 TSH +0.00

'4' -- 51 l 09/ 99 BOBBIN OXP- 56.64 TEC- +12.46-4- 55.09/99- BOBBIN- ADI 0.13 02C +31.61 09/99 MRPC C/L SI' VOL. 0.15 02C +31.33

'4 .59 09/99: BOBBIN OXP- 77.56 TEC 4 67.09/99 BOBBIN OXP

'+12.55

-56.22.TEC +12.34 to' +13.56-6 .77 09/99 BOBBIN . -

ADI 0.27 01C +17.97-09/99 MRPC C/L SI VOL' O.26 01C +17.25 7 .80109/99- BOBBIN ODI 3 0.23 02C: +16,66 JO9/99 MRPC C/L SI VOL- -0.07 02C +16.60-

, 101141 09/99 ' BOBBIN ODI 12- 0.23 01H +16.39-

" 12 ; 49 09/99 . BOBBIN ADI 0.30 08C +6.10 09 99 . BOBBIN ODI 10. 0.26 04C' +12.65 09 99 BOBBIN - ODI 20 10.39'04C. +15.03 09/99-lbGtPC C/L SI VOL 0.10'08C- +5.79 09/99. MRPC C/L SI VOL 0.11 04C +12.81 09 99 MRPC C/L'SI VOL 0.28 04C +15.13 12 105i09 99 BOBBIN ODI. 14 0.19 01C - +16.57 13 54 09 99, BOBBIN' . ODI. 6 0.77 01C +6.88 09 99 'MRPC C/L SI VOL 0.67 01C +7.00 13 122 09 99- BOBBIN ADI 0.16 05H +26.15 09/99 -MRPC H/L'SI_ VOL 0.11 05H +25.70 09/99'lMRPC H/L SI VOL- 0.36 05H +23.95 14 43~09/99 - BOBBIN ADI. 'O.35 04C +2.71 09/99.'MRPC C/L SI VOL 0.11 04C +2.87 !

16.139 09/99 BOBBIN ODI- 18 0.15 08H +30.82 i

-09/99 MRPC H/L SI VOL 0.66 08H ' +30.82

'16'141 09/99 BOBBINi ODI. 4' O.26 04C +20.65 L17c 90 09/99. BOBBIN ADI 0.36 03C' +28.46

09/99 ,MRPC C/L SI VOL 0.12 03C +

'28.58 -i 18- !9 09/99 -BOBBIN OXP 35.73 TEC +14.63

18. 25 09/99 BOBBIN OXP 32.86 TEC +14.33 to +16.29 19 12 09/99 -BOBBIN ODI 9 0.31 06H. +13.78 I

'09/99..MRPC H/L SI' VOL 0.23 06H +13.55 '

'21 ; 10 09/99-- BOBBIN ~ ODI -

0.15 03H +13.06 09/99';MRPC UDEND SI .VOL 0.61 03H +13.05

21. -20 09/99 ' BOBBIN ODI 12 0.20.04H +19.96 09/99- MRPC H/L SI , .VOL 0.25 04H' +19.73

22 121-09/99' BOBBIN ODI 8 0.40'09H +4.17

-23: 78 09/99 - BOBBIN 'ODI 10 0.48~03C +16.23 09/99 LBOBBIN' ODI J23 0.46 01C +12.48 09/99'- MRPC.C/L SI .VOL 0.14 03C- .+15.73 09/99 -MRPC.C/L SI VOL O.50 01C +12.33 24'115-09/99- BOBBIN .

ADI 0.16 03C +33.69 09/99 LMRPC C/L;SI ~VOL 0.21 03C- +33.88 250: 66'09/99- BOBBIN 'ODI 10 0.49 06C +32.44 09/99 ;MRPC C/L.SI -VOL .

0.13 06C +32.39 29< 20'09/99 ? BOBBIN ODI f12 .0.59 06C +23.93

~09/99 MRPC'C/L SI VOL 0.~26 06C +23.78

.29 102'09/99 ' BOBBIN . ADI. 0.25 TSC +10.98 09/99- MRPC.C/L SI VOL 0.18'TSC +11,05

'30- 69JO9/99- BOBBIN' ADI'. Oi,14 ' 0 5H +7.20

'09/99 ' BOBBIN ADI 0.19 03H +7.15

'09/99 BOBBIN ADI 0.22 07H ' +2.67 f- 109/99'> BOBBIN .

ADI 0.65 01C- +13.26

.09/99 MRPC C/L SI VOL 0.19'01C +14.04 09/99RMRPC H/L SI VOL 0.20 07H +2.32 09/99 'MRPC H/L SI' VOL 'O.25 03H +6.95 109/99 lMRPC'H/L SI- VOL 0.31 05H +7.21 34- 93 09/99- BOBBIN- . ODI 2 0.81 04C +26.48 l09/99. MRPC C/L SI VOL 0.31 04C +26-.68

35 126.09/991 BOBBIN' ADI 0417 05H +6.95 i;_

E. :

V i.

, e************1 ' FTI TUBAN :II (Varsion 2.3)'

L/.*************

10/06/1999 15:17:48 *************

'll McGuire N.S. - Unit Ona Replacement *************

J++*********** S/G C' *************

L '*************- 09/99 RFO *************

h *************

BOBBIN,MRPC C/L SI,MRPC H/L SI,MRPC UBEND SI *************

, e o Page 2

. ATTACHMENT #3 ' INDICATIONS OF IMPERFECTIONS 1:

INDS:OF-IMPERFECTIONS.- SGC. j ROW COL OUTAGE TEST TYPE: ' IND %TW VOLTS LOCATION '

36 27'09/99'.' BOBBIN ODI 11- 0.34 02C +14.80 09/99 .MRPC C/L SI VOL 0.14 02C +15.12 1

37' 6 09/99.-BOBBIN ADI 0.43 05H +16.94 09/99 MRPC H/L SI VOL 0.17 05H +16.65 38 65'09/99f MRPC-C/L SI VOL 0.10 04C +22.64 09/99 MRPC-C/L SI VOL 0.12 04C +21.86 1 09/99 MRPC C/L'SI VOL O.12 04C +25.30 )

.-09/99' MRPC C/L SI VOL 0.16 04C +23.72 1 09/99 BOBBIN ADI 0.32 04C +21.00 to +26.26 l 38'137 09/99 BOBBIN OXP 28.54 TEC +10.30 39 16 4 09/99- BOBBIN- ODI 10 0.28 02C +27.52 09/99. MRPC C/L SI VOL 0.26 02C +27.98 40 49 09/99 BOBBIN ODI 8 0.18 04C +21.93 46' 37:09/99' BOBBIN. .

ODI 12 .0.46.06C +19.73

~09/99 MRPC'C/L SI. :VOL 0.13 06C +19.12 09/99. MRPC C/L SI. VOL 0.17 06C +20.17 L49 104 09/99 ' BOBBIN ADI 0.18 03C +16.66 09/99 MRPC C/L SI VOL' O.24 03C +17.24 51 20-09/99' BOBBIN -ODI 17 0.29 04C +19.53

! 09/99 ~MRPC-C/L SI VOL 0.08 04C +19.76 109/99 MRPC C/L'SI VOL 0.15 04C +22.81

. 09/99 MRPC C/L SI VOL 0.28 04C +21.91 l

.52',75 09/99 BOBBIN ODI 16 0.23 06C +22.69 09/99 MRPC C/L SI VOL 0.13 06C +21.99

.59 130 09/99 -BOBBIN ODI 15 0.19 02C +4.21 09/99 MRPC C/L SI VOL -0.12 02C +4.19 60.115'09/99 BOBBIN ADI 0.09 01C +9.93

.61 68 09/99 BOBBIN 'NQI 0.15 FB5 +0.75 63 :70 09/99. BOBBIN- OXP 93.50 TEC +0.86 to +3 04 63 '82 09/99' BOBBIN ADI 0.09 02C +3.59

.09/99' MRPC C/L'SI VOL 0.12 02C' +3.47

.64 25 09/99 BOBBIN ODI 12 0,38 03H +8.95 09/99 'MRPC H/L SI VOL 0.18 03H +8.70

65. 98 09 99 ' BOBBIN ADI 0.34 03H +6.06 09 99 MRPC H/L'SI VOL 0.13 03H +5.90 68 ~99 09 99 BOBBIN ODI 6 0.26 01C +26.15 09/99- BOBBIN -ODI 13 0.28 01C +28.15 09/99 MRPC C/L SI. -VOL 0.22 01C +28.10 09/99 MRPC C/L SI. ;VOL 0.25 01C +26.14

69 60 09/99 BOBBIN NQI 0.13 FB4 -0.87 69 H88 09/99- BOBBIN . ADI ~0.22 02C- +12.39 09/99 THRPC C/L SI 'VOL 1.17 02C +12.32 70 ,55 09/99- BOBBIN ADI 0.22 03C +5.17 09/99 'MRPC C/L SI VOL 0.14 03C +5.46 70 107 09/99- BOBBIN ADI 0.18 05H +26.57

-09/99 'MRPC H/L SI' VOL 0.15 05H +26.14 71 72 09/99 BOBBIN 'ADI 0.28 02H +20.36 09/99 MRPC H/L SI .VOL 0.27 02H +20.48

73 ~ 18 09/99 BOBBIN ADI 0.28 02H +25.74 73.-60 09/99 BOBBIN NQI 0.24 PB4 -0.73

'l 09/99 MRPC UBEND SI WAR- 8 0.30 FB4 -0.73

'73!'70 09/99' BOBBIN- ADI 0.32 01C +28.09

-09/99' MRPC C/L SI VOL- 0.21 ^*. +27.88 09/99 .MRPC C/L SI VOf. v.a5 01C +28.42 73 90 09/99 1 BOBBIN ADI 0.32 03C +33.09 09/99 VOL 0.25 03C' +33.16 75- 60 09/99 ~BOBBIN MRPC C/L.SI' ADI~ 0.10 02H +33.55 09 99 BOBBIN ADI 0.20 02H +15.02 i 09 99 MRPC H/L SI _VOL 0.10 02H +33.56 i 09 99 MRPC H/L SI VOL 0.21 02H +15.00 l

-77.'22-09/99 BOBBIN. OXP 29.63 TEH +12.88 1 77' 60 09/99 .' BOBBIN . NQI 0.24 FB4 -0.56 !

09/99 MRPC UBEND.SI '

WAR .8 0,29 FB4 -0.68 l

' 78- '35 09/99 BOBBIN NOI 0.11 08C +12.23 l 09/99 BOBBIN ODI 16 'O.17 06C +5.08 j l

l

n= _,

k[

. FTI-TUBAN II (Varaion 2.3). 10/06/1999 15:17 48 *************

McGuiro N.S.'- Unit OnD Rzplacemant . *************

L************* s/G.C *************

09/99 RFO' *************

r ' BOBBIN,MRPC C/L SI,MRPC H/L SI,MRPC UBEND SI *************

9

ATTACHMENT #3 - ' INDICATIONS OF. IMPERFECTIONS 11NDS OF: IMPERFECTIONS - SGC ROW COL OUTAGE. TEST TYPE IND %TW VOLTS LOCATION

.09/99- MRPC C/L SI. VOL 0.68 08C +12.23 'l 179':52109/99 BOBBIN- . ADI 0.09 01C- +19.72 09/99. MRPC C/L SI- VOL- 0.39 01C +19.61 79-, 68 09/99 BOBBIN ADI 0.39 01C +12.30 09/99 MRPC C/L SI VOL 0.31 01C +12.65 83 50 09/99' BOBBIN ADI 0.16 05H- +24.26 09/99 MRPC H/L SI: VOL 0.52 05H +23.35 83 60 09/99 ; BOBBIN NOI 0.12 FB4 -0.43 09/99- MRPC UBEND SI WAR 8 0.31 FB4 -0.62' 85~ 28 09/99 BOBBIN ADI' O 26 04C +21.02

~85 = 48 09/99 BOBBIN ODI 6 '.31.TSC O ' +17'.47 09/99'.MRPC C/L SI VOL 0.37 TSC +17.50

'85 50.09/99~ BOBBIN NQI . 0.33 FB4 -0.53 09/99 MRPC UBEND SI WAR. 13 0.51 FB4 -0.68- i 861:255 09/99 BOBBIN ADI 0.29 02H +27.96 '

09/99 MRPC H/L'SI VOL 0.28 02H. +27.52 87 70'09/99. BOBBIN ADI ~ 0.18 FB8 .* 7 . 5 6

~ ' '

192- 51 09/99 ' BOBBIN ODI .5 0.67 04H' +33.77 '

i 09/99 MRPC H/L-SI .VOL . 0.35 04H +33.41

. 94'- 65 09/99' -BOBBIN ODI-.15 0.35 02C +21.57

-09 99MRPC.C/L'SI VOL 0.23 02C +21.95 l 94 3 67'09 99- BOBBIN ODI 14 0.29 05C +16.60 l 95 .60 09 99-. BOBBIN .

NQI 0.14 FB4 -0.49 j 09/99' 'MRPC'UBEND SI WAR 11 0.43 FB4 ' -0.66 I

96. 97 09/99 BOBBIN. ODI 7 0.19 02C +26.22

.97" 68 09/99- BOBBIN ODI 8 0.17 08C +27.61 98 103:09/99 BOBBIN ODI 3 0.29 03H +17.84

'09/99 -MRPC H/L SI-VOL 0.19 03H +17.94 I 99- 34 09/99 BOBBIN' NEX 7.21 TSC -0.26 104',67 09/99 -BOBBIN ADI 0.32 03C +9.49

'09/99 MRPC C/L SI VOL 0.27 03C +9.60 2

105 40 09/99 BOBBIN ADI 0.25 04H +10.91 <

108- 45 09/99_.l BOBBIN NQI 0.81 09H +1.70 1 110 . 71.09/99 : BOBBIN ADI 0.38 06C +22.96 117' 58 09/99 BOBBIN. NQI 1.12 09C +1.48 09/99 MRPC C/L SI WAR- 8 0.35 09C +1.50 Total Indications Found = 166 Total 1 Tubes'?ound = 86 I

l-I' I

L

IUE .

w c[;-

(le*eeeee******

[ FTI TUBAN II (Varsion 2.3) 10/06/1999 15:18:55 *************

i >************* '

McGuira-N.S.1 - Unit Ons:Raplactmant. *************

- - - - .S/G D *************-

c*************;

- - - - 4 09/99 RFO . *************

!? BOBBIN,MRPC C/L SI,MRPC H/L SI,MRPC UBEND SI- *************

Fage 1

ATTACHMENT #4 - INDICATIONS OF' IMPERFECTIONS-

~ INDS OF. IMPERFECTIONS-- SGD. I.

_ ROW COL OUTAGE TEST. TYPE.

IND %TW VOLTS LOCATION

l1-' 14'09/9F BOBBIN ODI- 18 0.20 06C +5,87 !

09/99:. MRPC C/L SI VOL 0.34 06C +5.81 f l' 76 09/99~ BOBBIN ADI 0.88 02C -+10.99

'78,09/99 BOBBIN'

'l ADI 0.53 01C +26.12

, 2 '7 09/99 BOBBIN .ODI 8' O.14 02C- +8.64 (09/99- MRPC C/L SI. VOL 0.39 02C +0.56-

'2 51 09/99 - BOBBIN ADI; 0.91 05C. +21.67

.2 e57'09/99 BOBBIN ADI 0.15 02C- .+6.66

'25103'09/99 BOBBIN 'ADI 0.14 08C .+34.98 2-125 09/99 ' BOBBIN ADI 0.12 07H +15.65' "]

3 138 09/99=- BOBBIN- . ADI 0.15 03C +25.76 09/99 MRPC.C/L SI VOL- 0.11 03C +25.51 5 132 09/99 BOBBIN ADI 0.11 08C +34.72 j

.5 142 09/99 BOBBIN- ADI 0.17'04C +8.73 i 7 140-09/99 BOBBIN ~OXP 28.84 TSC- .-0.85

'11 60 09/99 ' BOBBIN OXP . 30.92 TSC -0.92 14 95 09/99, BOBBIN ODI 12- 0.21 04C +4.72

.09/99 .MRPC C/L~SI VOL- 0.~28 04C +4.74 i

--15 142'09/99 BOBBIN NQI 0.28'07H +0.35

.09/99 ' BOBBIN ODI 7 0.26 01C- +20.57 09/99 MRPC C/L SI VOL 0.09 01C +20.59

~09/99: MRPC H/L SI WAR '3 0.19 07H +0.41

16.139 09/99. BOBBIN' NOI 0.59 09C +5.12 l :20.139:09/99- BOBBIN NQI 0.39 09C +4.51 22 131 09/99- BOBBIN ADI- 0.22 07C +11.46 09/99 _ BOBBIN ODI 1 0.17 06H +29.89 09/99 MRPC C/LSI- VOL 0.09 07C +11.31 09/99 MRPC H/L SI VOL 0.09 04H +32.60

.09/99. MRPC H/L SI VOL- 0.10 04H +34.16

.09/99.-MRPC H/L SI VOL. 0.50 06H +29.80 l

,09/99 BOBBIN M)I 0.24 04H +32.05 to +34.86 !

23'130LO9/99 BOBBIN OXP 30.57 TEH +1.17 '

24 59 09/99 BOBBIN ADI 0.20 05H +27.45 09/99 BOBBIN ADI 0.20'05H- -+29.47

09/99- MRPC H/L SI.. VCI 0.31 OSH +29.46 09/99 iMRPC H/L SI VO~ 0.61 05H +27.53

'24 .65 09/99 BOBBIN: OXL 35.11 TSH -0.74 1 25 160 C9/99 BOBBIN: . ODI 16 0.43 04C .+20.27 )

.09/99 MRPC C/L SI VOL 0.35 04C +20.52 30 109 09/99 BOBBIN NOI 0.34.04H +11.49 09/99- MRPC H/L SI VOL 0.42 04H +11.43

31' 30'09/99 . BOBBIN, .ADI 0.33 07C +30.67

.34 71 09/99- BOBBIN 'ODI 10 0.35 02H' +31.50

.09/99 MRPC H/L SI VOL 0.37 02H. +31.33 j

-34 135;-09/99 BOBBIN OXP 35.98 TSH -1.67 to -0.62 1 35 138 09/99 BOBBIN OXP 28.53 TSC -1.23 to -0.21 361105.09/99 BOBBIN . ADI. 0.28 01C .+18.28 09/991 MRPC C/L.SI. VOL 0.11 01C +18.18 138 71 09/99 BOBBIN ADI' O.14.04C +10.54 09/99 BOBBIN. ADI 0.15 04C +14.81 42 71.09/99' BOBBIN .ADI .0.41 01C +25.40

-09/99 MRPC C/L SI- VOL 0.32 01C +25.95 i43' 18.09/99 BOBBIN '

ODI '2 0.33 02H . +21.14

'. 4 4 7109/99. BOBBIN ODI 4 0.19 04H +15.12

'09/99 MRPC H/L'SI- ,.VOL. . 0.42 04H +14:99 D45 66 09/99 BOBBIN- , . ODI 10 0.39 03H +9.59 09/99 MRPC H/L SI' =VOL 0.42 03H ' +9.62 l 53- 84 09/99 . BOBBIN ADI 0.22 02H +20.89 l 109/99 . BOBBIN ODI 10 0.16 02H- +18.72 09/99' MRPC.H/L SI YOL 0.12 02H +18,66 I 09/99 'MRPC H/L SI VOL 0.23 02H +20.76 i 55 30.09/99' BOBBIN. ADI 0.11 02H +15.65 j 56 :65 09/99^ BO9 BIN OXP 26.60 TSH -0.78 p' 56 :93 09/99 . BOBBIN ADI 0.13 04H +14.11 i

'09/99_'BOBBIF ADI .0.20 02H +21.85 L

i l

, . j

. . . I j[ 1'I -

- - - - .FTI TUBAN II (Varaion 2.3)- 10/06/1999 15:18:55 ************* !

- - - - ~ -McGuira N.S. - Unit Ona RIplactmant *************

.-e**ee******** S/G D- *************

**ee'********* ..

09/99 RFO *************

- - - - BOBBIN,MRPC C/L SI,MRPC H/L SI,MRPC UBEND SI *************

.. 4

. ATTACHMENT #4 - INDICATIONS OF IMPERFECTIONS INDS OF' IMPERFECTIONS - SGD' ROW COL OUTAGE TEST. TYPE- IND tTW VOLTS LOCATION 09/99- MRPC H/L SI'- VOL 0.12 02H +21.54 I 58.. .47 09/99 " BOBBIN ODI 9 0.31 02H +28.92 09/99 BOBBIN ODI 12 0.22 06H +21.93 09/99- MRPC H/L SI VOL 0.17 06H +21.85 09/99 MRPC H/L SI VOL 0.26 02H +28.99 09/99E MRPC H/L SI- VOL .0.45 02H +9.83 09/99 MRPC H/L SI VOL 0.72 06H +23.50 60 .75 09/99 BOBBIN ADI 1.32 TSC +0.40 to +4.78

~63 130 09/99'- BOBBIN ADI 0.13 05H +16.73 09 99 MRPC H/L SI- VOL 0.56 05H +16.46

=64 ;57.09 99 BOBBIN ADI 10.27 02H +23.08

'09/99 MRPC H/L SI VOL -0.41 02H +22.60 64- 85 09/99- BOBBIN OXP 28.92 TEC. +19.74

70. 91 09/99 BOBBIN ADI' O.33 03C +37.46 ,

09/99 :MRPC C/L SI. VOL 0.17 03C. +37.02 l 7 3 '. 96 09/99' BOBBIN ADI 0.38 FB1 +6.33 ;

09/99, MRPC UBEND SI VOL 0.37 FBl~ +6.69 76 .85 09/99 BOBBIN NOI 0.11 FB4 +0.96 09/99 ' BOBBIN WAR 2 C 06 FB4 +1.07 09/99= MRPC UBEND SI -WAR 3 RL.11 FB4- +1.07 84 93 09/99 BOBBIN ODI 15 0.30 07H +15.01 09/99 MRPC C/L SI VOL 0.16 03C +13.23 09/99 MRPC C/L SI VOL 0.27 03C +10.75 09/99' MRPC H/L SI. VOL 0.45.07H +15.00 09/99 BOBBIN ODI 2 0.20 03C +10.32 to +13.12

85. 24 09/99- BOBBIN ADI 0.22 O1H +29.10 09/99 MRPC H/L SI VOL 0.13 O1H +28.42 85 120 09 99 BOBBIN ADI 0.22 04C +28.04 i 86 109 09 99 ' BOBBIN ADI 0.17 04C +10.59

.'09 99 'MRPC C/L SI. VOL S.14 04C +10.37 ]z

.93 102,09/99 BOBBIN ODI 9 0.16 06H +22.69

=09/99 MRPC H/L SI VOL 0.78 06H +23.23 l 95 140 09/99 . BOBBIN NQI 0.68 09C +1.76 s 196; 55 09/99 ~ BOBBIN. NOI 1.84 09C +1.62 106 '75 09/99 MRPC H/L SI VOL 0.22 03H +20.55 f 09/99 MRPC H/L SI VOL 0.23 03H +23.17 -l 09/99 BOBBIN ADI 0.19 03H +20.55 to +23.52 j 110 97 09 99 BOBBIN OXP 29.59 TEH +1.65 '

116 75 09 99-' BOBBIN ADI 0.24 FB7 +9.80 Total' Indications Found = 104 Total-Tubes Found = 55 i

i I

l I

t i

l I

i i

i b

y 9

-

ML20217F326

Text

Subject:

Navigation menu

Search