ML20198G818
ML20198G818 | |
Person / Time | |
---|---|
Site: | Comanche Peak, 07002932 ![]() |
Issue date: | 05/16/1986 |
From: | TEXAS UTILITIES ELECTRIC CO. (TU ELECTRIC) |
To: | |
Shared Package | |
ML20198G771 | List: |
References | |
PROC-860516, NUDOCS 8605290777 | |
Download: ML20198G818 (50) | |
Text
y - .. - -~= n u . - .
7 I .JB , ,,
[ ~*"****-**===+e ee= : _,m ,
, g ,g ,, y ; . y_ _
f L
CONTROLLED COPY M0. [
COMANCHE PEAK STEAM ELECTRIC STATION
. GENERAL HEALTH PHYSICS PLAN 1
INFORMAT$oN _oNLY -
a i
(
4 8605290777 860516
{DR ADCCK 07002932 PDR
COMANCHE PEAK STEAM ELECTRIC STATION ;
SECTION: i CONTENTS GENERAL HEALTH PHYSICS PLAN REVISION: 7 1
ISSUE DATE: MAY 01 1986 l TABLE OF CONTENTS l PAGE 1 OF 3 SECTION TITLE REVISION
1.0 INTRODUCTION
(3) 1.1 PURPOSE 1.2 REVIEW AND APPROVAL 1.3 BASIS 1.4 RESPONSIBILITIES 1.5 IMPLEMENTATION 1.6 RADIATION PROTECTION SECTION 2.0 RADIATION PROTECTION STANDARDS (4) 2.1 DEVELOPMENT OF STANDARDS 2.2 PERSONNEL EXPOSURE LIMITS 2.3 PERSONNEL EXPOSURE CONTROL 3.0 PERSONNEL RADIATION DOSIMETRY (2) 3.1 EXTERNAL DOSIMETRY 3.2 INTERNAL DOSIMETRY 3.3 DOSIMETRY RECORDS AND REPORTING 4.0 RADIATION PROTECTION TRAINING (2) 4.1 REQUIREMENTS 4.2 RADIATION WORKER TRAINING 4.3 RADIATION PROTECTION PERSONNEL TRAINING 4.4 ON-THE-JOB TRAINING 4.5 TRAINING EVALUATION AND RECORDS
COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
CONTENTS GENERAL HEALTH PHYSICS PLAN REVISION: 7 ISSUE DATE:
MY 011986 TABLE OF CONTENTS PAGE 2 OF 3
_SECTION -
TITLE REVISION 5.0
_ RADIATION EXPOSURE CONTROL (3) 5.1 PERSONNEL EXPOSURE CONTROL 5.2 ACCESS CONTROL 5.3 AREA AND FACILITY CONTROL 6.0 PERSONNEL RADIATION PROTECTION (3) 6.1 PERSONNEL PROTECTIVE EQUIPMENT 6.2 RADIATION CONTROLLED AREA WORK REQUIREMENTS 6.3 PERSONNEL RADIATION MONITORING 7.0 HANDLING AND CONTROL OF RADIOACTIVE MATERIAL (4) 7.1 CONTAMINATION CONTROL 7.2 DECONTAMINATION 7.3 RADIOACTIVE WASTE DISPOSAL 7.4 CONTROL OF LICENSED MATERIAL 8.0
_ RADIOLOGICAL CONTROL INCIDENTS (2) 8.1 PERSONNEL EXPOSURE IN EXCESS OF LIMITS 8.2 LOSS OF CONTROL 8.3 FIRE IN A RADIATION CONTROLLED AREA 8.4 PER NNEL INJURY OR ILLNESS INSIDE A RADIATION I 8.5 PERSONNEL VIOLATIONS l
I I
\ _
i
COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
CONTENTS GENERAL HEALTH PHYSICS PLAN REVISION: 7 ISSUE DATE: MAY 011986 TABLE OF CONTENTS PAGE OF 3 3 SECTION TITLE REVISION
- 9. 0 RADIATION PROTECTION RECORDS AND REPORTS (2) 9.1 PERSONNEL EXPOSURE RECORDS AND REPORTS 9.2 RADIOACTIVE MATERIALS RECORDS AND REPORTS 9.3 REPORTING RADIOLOGICAL CONTROL INCIDENTS 10.0
_ RADIATION PROTECTION PROCEDURES AND INSTRUCTIONS (2) 10.1 HEALTH PHYSICS ADMINISTRATIVE MANUAL 10.2 HEALTH PHYSICS TECHNICAL MANUAL 10.3 HEALTH PHYSICS INSTRUCTION NOTEBOOK 11.0 DEFINITIONS (2) 12.0 POLICY (3) 12.1 STATEMENT OF POLICY 12.2 ALARA POLICY 12.3 RESPIRATORY PROTECTION POLICY 12.4 RADIOACTIVE WASTE MINIMIZATION POLICY
)k e '
. , .3 -
. 5
.I* #.
CONTROLLED COPY NO. bb! :
,3 .
COMANCHE PEAK STEAM ELECTRIC STATION C, r.l... +
- .y ,
GENERAL HEALTH PHYSICS PLAN :g'7
. , . .=.e-y k
x.
Section: 1 Y[# *.
3 Revision: 3 ' a.
Subject:
INTRODUCTION i' ,,
Submitted by: ,/
Radiation -
/ ff[
- 7 Date: ///'/)[ [3 tect n Engineer /
Approved by:
-'/ M Manager. Plant Operations Date: /I!D 7!f 7" .
..~ : - . . . . . . . -
e .
l COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 1.0 GENERAL HEALTH PHYSICS PLAN REVISION: 3 ISSUE DATE: JAN 0 51984 INTRODUCTION PAGE 2 OF 4 1.0 Introduction The operation of a nuclear power facility involves possible exposure of some personnel to significant levels of radiation; however, with proper radiation protection and exposure control measures the opera-tion safely, and maintenance of a nuclear power facility can be performed it is important to realize that radiation safety depends on the knowledge, training and attitude of each individual. This Plan is provided to each employee in an effort to promote a safe working environment and work practices to assure that personnel exposure to radiation is "as low as reasonably achievable" (ALARA).
Questions or concerns about radiation safety or this Plan should be directed to the Radiation Protection Engineer.
1.1 Purpose The purpose of this Plan is to provide the policy, procedures and requirements for radiological safety at CPSES to assure compli-ance with Federal and State regulations. The goal of this Plan is to provide appropriate protection for the public, the environ-ment, ALARA.
and station personnel and to reduce radiation exposure to 1.2 Review and Approval This plan is submitted by the Radiation Protection Engineer for the Station Operations Review Committee review. The plan is approved by the Manager, Plant Operations.
Revisions section. Atovertical this Plan shall be made by revising the applicable line on the right hand margin of the revised portion chall indicate the change. The Table of Contents shall be revised each time to reflect the change. Revisions shall be reviewed by SORC and approved by the Manager, Plant Operations.
_ _ m. . . _ ,
- . - . . _ _ -- -- - v~ ^
COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 1,O GENERAL HEALTH PHYSICS PLAN REVislON:
3 ISSUE DATE:JAN 0 51984 INTRODUCTION PAGE OF 3 4 1.3 Basis The General Health Physics Plan is based on the regulations and requirements established by the USNRC. These regulations and requirements were established from recommendations of the Inter-national Commission On Radiological Protection (ICRP) and the National Council On Radiation Protection and Measurements (NCRP),
leading authorities on radiation protection.
Additionally, Company policy statements in Section 12 of this plan provide the basis for specific requirements detailed in this Plan.
1.4 Responsibilities The ultimate responsibility for radiation safety rests with each -
individual. Each person is responsible for maintaining their exposure ALARA during the performance of their duties. Indivi-duals are responsible for complying with all Radiation Controlled Area rules, procedures and safety practices and reporting to their immediate Supervisor, conditions or practices which are unsafe.
The Manager of Plant Operations has the overall responsibility for tho establishment and implementation of the General Health Physics Plan for personnel radiation protection.
ble for compliance with the applicable Federal and StateHe is responsi-regulations pertaining to radiological safety.
, Station Supervision is responsible for assuring that personnel comply with all requirements of the Plan.
sible for maintaining Supervision is respon-and collective (group) personnel exposure ALARA on an individual basis. Additionally, Supervision is responsible for maintaining a current knowledge of personnel exposure and controlling such exposure so that limits are not exceeded and the ALARA concept is properly implemented.
The Radiation Protection Section is responsible in particular for development and implementation of the General Health Physics Plan.
The responsibility for implementation includes compliance with all Federal and State regulations, establishment and evalua-i tion of the plant radiological working environment, ALARA implementation, and personnel exposure control, monitoring and evaluation.
i
- . - ,, , _ _ . - _ , -- - - - .- -,_-. . . . ~ . . . . . . - . . , - . . - - . - - - , _ . _ . .
COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
GENERAL HEALTH PHYSICS PLAN
1.0 REVISION
3 ISSUE DATE: JAN 0 51984 INTRODUCTION PAGE OF 4 4 1.5 Implementation The implementation of this Plan is executed by the Radiation Protection supervision.
Section with the support and commitment of station The Radiation Protection Section shall establish ,
the procedures, rules and practices necessary to implement the requirements of this Plan. Each employee's cooperation and '
support is required for successful implementation.
1.6 Radiation Protection Section l The Radiation Protection Section shall establish radiation work permits, procedures and practices to assure control of personnel exposure. '
Their duties will include surveying, monitoring, l dosimetry, support of radioactive waste handling, and applicable records and reporting. Additionally, Radiation Protection will function in an advisory capacity to all personnel to assure successful implementation of the Plan. The Radiation Protection Section staff shall have the authority to stop work operations that are being conducted in an unsafe radiological condition, or that violates procedures. CPSES radiation protection standards and/or Radiation Protection shall maintain current exposure information '
for all personnel and provide this information to station super-vision to assure contrbl within limits and application of the ALARA philosophy.
Access to Radiation Controlled Areas is ,
controlled by Radiation Protection to assure a radiologically (
safe working environment prior to entry.
-.r.,.._. ..._...
?
SAFETY-RELUED i, COMANCHE PEAK STEAM ELECTRIC STATION GENERAL HEALTE PHYSICS PLAN Section: 2 Revision: 4
Subject:
Radiation Protection Standards Submitted by: - ,{
Date: t/!7[Q Radiation' Protection Engineer ' e Approved by: .
8@/[ #2 Date: $ / Y[
Mahager, Plant' Operations
~
~-
l ---
- - ~ - -
COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 2.0 GENERAL HEALTH PHYSICS PLAN REVISION: 4 ISSUE DATE: MAY 011986 RADIATION PROTECTION STANDARDS PAGE 2 OF 4 2.0 Radiation Protection Standards i
2.1 Development of Standards Radiation Protection standards were developed to assure that the risk associated with radiation exposure is acceptable to the individual and the population at large in view of the benefits received from the use of radiation and radioactive materials.
." Dose standards have been established such that the risk of
', radiation effects due to exposure is significantly less than the '.
risk associated with job hazards present in any occupation not involving radiation exposure.
Controversy exists over the effects of very low doses of radia-tion received over a long period of time. This issue will probably remain controversial for a long time since the effects
! are of the type which can only be observed statistically. The Radiation Protection Section will provide information, counseling and guidance to any employee concerning the effects of radiation and the CPSES program for radiation safety and protection.
2.2 Personnel Exposure Limits
! The USNRC has developed personnel radiation exposure limits following the criteria indicated above and these limits are set as CPSES.
the maximum permissible occupational exposure limits for It should be recognized that the philosophy of ALARA is dedicated to reducing exposure to radiation to the minimum practicable, therefore, these limits are not goals for exposure usage rather they are the framework in which ALARA shall be applied, a) Radiation Workers The following maximum permissible exposure limits apply to all radiation workers except those who are pregnant.
Personnel under eighteen (18) years of age will be pro-hibited from Radiation Controlled Areas.
I l
l I
_ l
COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 2.0 GENERAL HEALTH PHYSICS PLAN REVISION: 4 ISSUE DATE: MAY 011986 RADIATION PROTECTION STANDARDS PAGE 3 OF 4 NRC Maximum Permissible Exposure Limits Exposure Period Wole Body Skin Extremities Quarterly 1.25 rem
- 7.5 rem 18.75 rem Lifetime 5(N-18) rem None None N = Employee's age in ycars b'; _ Maximum Permissible Exposure Limits For Employees Wo Are Pre gnant NCRP recommendations are that pregnant employees be limited to a maximum permissible exposure of 0.5 rem during the gestation period.
- 1f the individual's exposure history is documented and the lifetime permissible exposure is not exceeded, an individual may be allowed to receive 3 rem whole-body exposure during a calendar quarter for each quarter during a calendar year, with prior approval by Radiation Protection.
1 J
c) Exposure Limits Applied to Airborne Concentrations The USNRC has established in 10CFR20 Appendix B maximum permissible concentration limits for airborne radioactive material to which a licensee may expose an individual. The limits in Table I, Column 1, of Appendix B apply to radiation workers, and limit exposure to those concentrations to a maximum of 40 hours4.62963e-4 days <br />0.0111 hours <br />6.613757e-5 weeks <br />1.522e-5 months <br /> per 7 consecutive days.
Specific and detailed information is available from Radia-tion Protection concerning exposure limits for airborne radioactive material. ~
2.3 Personnel Exposure Control As previously indicated, the above established limits are con-sidered the maximum permissible. Application of the ALARA philosophy to personnel exposure is best implemented by the use of administrative exposure controls to assure personnel exposure
- - . - - w -
.- - - - - , -- y y- ,,- y w ---w.
_ _ . . . w. . ----..-. .-
COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 2.0 GENERAL HEALTH PHYSICS PLAN REVISION: 4 ISSUE DATE: MAY 011986 RADIATION PROTECTION STANDARDS PAGE 4 OF 4 l
is ALARA and that the maximum limits will not be exceeded.
Therefore, the following administrative limits shall be applied at CPSES for the purpose of exposure control and ALARA planning.
In no US NRC case may the maximum permissible limits established by the be exceeded, a) CPSES Administrative External Exposure Control Limits Exposure.27riod Whole Body Skin Extremities Weekly. 0.3 rem 0.5 ren 1.5 rem Quarterly 1.25 rem 4 rem 9 rem Yearly 5 rem 16 rem 36 rem i
Specific authorization and approval to exceed these administrative limits is required by a Radiation Protection Supervisor for weekly limits, the Radiation Protection. Engineer or his designee for quarterly Ibnits and the Manager, Plant Operations for yearly limits.
b)
CPSES Administrative External Exposure Control Limit For Radiation Workers Who Are Pregnant The periodadministrative control limit for the entire gestation shall be 0.3 rem.*
Authorization shall not be given to exceed employees. the administrative control limits for pregnant c)
_CPSES Administrative Control Limits for Exposure to Airborne Radioactive Materials The administrative control limit for radiation workers shall be 20 hours2.314815e-4 days <br />0.00556 hours <br />3.306878e-5 weeks <br />7.61e-6 months <br /> per 7 consecutive days exposure at the maximum permissible concentration Table I, Column 1. specified in 10CFR20, Appendix B, l
i Specific authorization and approval from a Radiation Protection Supervisor is required to exceed this 7 consecutive day limit.
I i
e [ a6 r-
- u. . . ....: . . . . . . .
[;?
- c. 3 CONTROLLED COPY NO. b/
i Comanche Peak Steam Electric Station General Health Physics Plan Section: 3 Revision: 2
Subject:
Personnel Radiation Dosimetry 4
9 e
e O
e
, e Radiation Pto'tectioMngineer / /
ig, roved 3y: / h M b ,- s ,
.na. Date: .. e. = > / 43
..r.na.y..ra.i... . .
- - . - - - . , , . ,, ., , , - , ,., - -..--.-..n. - , . . - , - -
COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 3.0 GENERAL HEALTH PHYSICS PLAN REVISION: 2 ISSUE DATE:JAN 0 51984 PERSONNEL RADIATION DOSIMETRY PAGE 2 OF 4 3.0 Personnel Radiation Dosimetry All personnel who enter Radiation Controlled Areas are required to wear approved personnel dosimetry devices.
Personnel who are assigned dosimetry devices shall wear them at all times within Radiation Controlled Areas and are responsible for their safekeeping. All dosimetry devices shall be serviced, maintained and evaluated by Radiation Protection. Personnel assigned dosimetry devices shall not tamper with them in any way or cause them to be exposed or the dose otherwise altered except during the performance of work requirements at CPSES. Personnel dosimetry devices shall not be removed from CPSES premises without prior authorization and approval by the Radiation Protection Engineer. Lost or damaged dosimetry devices shall be reported to Radiation Protection immediately.
Dosimetry devices shall normally be worn on the front of the body, between the waist and head and if more than one device is issued they shall be worn together. Other placement of dosimetry will require prior approval by Radiation Protection. Dosimetry shall be worn so as to prevent contamination of the dosimetry itself.
3.1 External Dosimetry The official and permanent record of an individual's external radiation exposure wil1 be obtained frem thermoluminescent dosimeters (TLD's). Badges will be issued to individuals requir-ing dosimetry and will contain several TLD elements to be used for assessment of external exposure. Dosimeters (TLDs) will be processed periodically on a scheduled basis to determine each individual's exposure, and new badges issued. Processing frequency may be increased depending on each individual's work requirements within the Radiation Controlled Area.
Additionally, a pocket ionization chamber dosimeter will be used for estimating personnel exposure for specific jobs and between periods of badge (TLD) processing. The pocket dosimeter will allow dose control by the individual since it can be read direct-i ly at any time. Pocket dosimeters shall be reset (Zeroed) by Radiation Protection prior to exceeding the maximum dose indi-cated on the scale. Each individual shall return his pocket dosimeter to Radiation Protection for resetting (Zeroing) when the indicated dose is 75% of full scale on the dosimeter.
~
COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 3.0 CENERAL HEALTH PHYSICS PLAN '
REVISION: 2 issue oars: JAN 0 51984 PERSONNEL LADIATION DOSIME"RY PAGE 3 OF 4 Radiation for certainProtection jobs. Such may establish special dosimetry requirements dosimetry may include finger rings (TLDs),
devices.
extremity badges (TLDs), neutron dosimetry or other prcvided by Instructions Radiation and information Protection at thefor these time devices will be of issue.
3.2 Internal Dosimetry Internal dose determination will be made by special methods of body burden analysis, including whole-body counting, thyroid-counting (HPA-103).
and bioassay as described in the Bioassay Program Additionally, for exposure to known concentrations of specific isotopes, calculational methods may be required to support dose determinations.
Uhole body counting will be used to determine the dose resulting from the uptake by the body of radioisotopes. Each employee who will work in Radiation Controlled Areas shall have a whole-body count prior to initial entry into Radiation Controlled Areas.
Whole-body counts will be required annually thereaf ter, or more frequently as determined by Radiation Protection.
Whole-body counting will be required for non-plant personnel prior to initial entry into Radiation Controlled Areas except at the discretion of the Radiation Protection Engineer. Persons who have received c'whole body count at'CPSES shall have a final whole at CPSES.body count prior to termination of employment or assignment Bioassay will be used as a supplement to whole-body counting'for internal dose determination, except in the case of alpha or beta emitting radionuclides when it will be the primary means of dose determination. Bioassay is the radiochemical analysis of tissues, fluids, or excretions from the body and commonly invcives both urine and fecal analysis. Bioassay shall be performed ' routinely for selected personnel, as confirmation of the effectiveness of CPSES radiation, protection measures.
3.3 Dosimetry Records and Reporting l Radiation Protection shall maintain personnel exposure records for all ' persons personnel entering' the Radiation Controlled Area and issued dosimetry.
Recorde shall include previous occupational exposure prior to employment with TUCCO at CPSES, occupational exposure received at CPSES or at other facilities while employed ,
i
E i
COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 3,0 GENERAL HEALTH PHYSICS PLAN REVf$lON: 2 '
i3 SUE DATE: JAft 0 51984 PERSONNEL RADIATION DOSIMETRY PAGE 4 CF 4 at CPSES, and the results of all personnel external and internal dosimetry while esiployed at CPSES. ,
Radiation Protection shall issue reports pertaining to radiation exposure as required by Federal and State regulations. Radiation l exposure reports will include daily or weekly exposure as esti-mated by pocket dosimeters, and monthly, quarterly, and annual exposure for each individual as determined by TLD badge rescits. ;
Additionally, reports of accidental or emergency exposure, as well as exposure investigations, shall be made as required by Radiation Protection.
9 4
4
,-m- - -ms
~
CONTROLLED COPY NO.
hC/ _ ;,
4 ,-
i Concuene Peak Steam Electric Station General Health Physics Plan Section: 4 ,
Revision: 2
Subject:
Radiation Protection Training
^
Submitted by: . ,
N*/ M /7 Date: *
~
[/ /f f Radiation Prote ion Engineer /'/
Approved by: y .. Date: /Q_ o 7. 9 "y Manager,flantOperations -
l l
1 I
i l
i
)
~
- a l
l l
l COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
GENERAL HEALTH PHYSICS PLAN 4.0 REVISION: 2 ISSUE DATE: JAN 0 51984 RADIATION EXPOSURE TRAINING PAGE OF 2 3 4.0 Radiation Protection Training All personnel who enter Radiation Controlled Areas at CPSES shall have received prior training in radiation protection, rules, regulations and requirements unless escorted by a radiation worker. Radiation radiation safety, a safe working environment, and impleme the Health Physics program and ALARA philosophy.
4.1 Requirements All radiation workers shall be properly trained in radiation protection methods and procedures prior to entry and work in Radiation Controlled Areas at CPSES.
4.2 Radiation Worker Training Training for those persons requiring entry and work within Radiation Controlled Areas shall include both theory and practi-cal aspects of radiation protection necessary to assure the worker can perform his duties within Radiation Controlled Areas at CPSES this Plan. in a safe manner, consistent with the requirements of General Radiation Worker Training will be supplemented with '
additional specialized training depending on the requirements for Radiation Controlled Area work and the work group involved.
4.3 Radiation Protection Personnel Training Radiation Protection technicians will be given specialized training in Radiation Protection in accordance with TRA-301 .
4.4 On-The-Job Training Whenever on-the-job training is given to personnel, supervisors shall include Radiation Protection work practices, contamination control, exposure control and reduction (ALARA), and other specific areas determined by the type of work and location.
On-the-job by supervision training or by will theirbe a continuous effort provided directly designate.
p -e __ -
a- . . . -
COMANCHE PEAK STEAM ELECTRIC STATION ,
i SECTION: 4.0 !
GENERAL HEALTH PHYSICS PLAN REVISION: 2 ISSUE DATE:JAN 0 51984 RADIATION EXPOSURE TRAINING PAGE 3 OF 3 4.5 Training Evaluation and Records The technical competence and proficiency of personnel in radia-tion protection methods and procedures shall be evaluated through testing, demonstration exercises and other means as appropriate.
The evaluation of training and a record of the specific training provided and experience possessed shall be maintained for each individual.
Successful completion of the appropriate training shall be prerequisite for Radiation Controlled Area entry.
h 14 O
Comanche Peak Steam Electric Station General Health Physics Plan Section: 5 Revision: 3
Subject:
Radiation Exposure Control Submitted by: .
h4 Date: [
Radiation Protect 1 ngineer Approved by: _ /-. of, Date:
Manager, Pla K 0perations " '
')?1 Ff'~
/
i
i COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 5.0 GENERAL HEALTH PHYSICS PLAN REVISSON: 3 ISSUE DATE: NAY 0 61985 RADIATION EXPOSURE CONTROL PAGE 2 OF 4 5.0 _ Radiation Exposure Control Methods of personnel exposure control are necessary to assure expos is maintained within limits and further reduced to ALARA. Control of personnel exposure will require control of access to Radiation Con-trolled Areas, control over the storage, handling and use of radioactive material and use of appropriate personnel work practices.
5.1 Personnel Exposure Control Each person is responsible for controlling his exposure within the limits specified and furthermore to take all' practical step s to reduce his exposure to "as low as reasonably achievable" (ALARA).
of good radiation /coatsmination area work practice exposure reduction (ALARA status of one's exposure.) methods, and knowledge of the current Radiation / Contamination area work practices will be presented as part of the Radiation Worker Training, specific procedures developed by Radiation Protection and other groups, and on-the-job training.
(ALARA) methods are detailed in the ALARA Program (HPA-101) E .
Radiation Protection will provide periodic reports giving the current exposure status for all Radiation workers as an aide to personnel exposure control and planning.
5.2 Access Control Access by the usetoofthe Radiation certain Controlled administrative Areas methods, at CPSES including general is co access permits (GAPS), radiation work permits (RWPs), access control points, posting and specific procedures.
General Access Permit (GAP) or Radiation (RWP),
Work Pe appropriate prior training, and appropriate dosimetry. Without
' appropriate Radiation Worker Training, access shall be permitted ately iftrained only the individual escort. is escorted by an approved and appropri-Areas shall be controlled by the use, appropri- of control poi be controlled as required by 10CTR20, with posi locked barriers or.other authorized means of positive physical
i COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 5.0 GENERAL HEALTH PHYSICS PLAN i REVISION: 3 ISSUE DATE:
MAY 0 61985 i RADIATION EXPOSURE CONTROL PAGE 3 OF 4 access control.
labeled as required by 10CFR20. Additionally, all such areas shall be pos Entry into Radiation, High Radiation, Extremely High Radiation .
jobs will require a Radiation Work Permit (RWP) w specify the job to be performed and the radiation protection measures to be used for the job.
Entry into such areas may other means of positive control of personnel exp occupancy of the area.
5.3 Area and Facility Control For the purposes of exposure control, the following controls cadingbeofused shall specificat CPSES areas. for the establishment, posting and barri-t All posting shall be done in accordance with the requirements of 10CFR20.
5.3.1 Airborne Radioactivity Area - any room, enclosure, or operating area in which airborne radioactive materials, composed wholly or partly of licensed material, exist in concentrations 10CFR20, in excess of the amounts specified in Appendix "B",
Table I, Column 1; or any room, enclosure, or operating area in which airborne radioactive material composed wholly or partly of licensed material exists of hoursin in concentrations any week which, averaged over the number are in the area, excee(d 25% of the amounts specifie 10CFR20, Appendix "B",
Table I, Column 1.
5.3.2 Contamination Area - any area, accessible to personnel in which or equalloose to: surface contamination levels are greater than 1000 dpm/100 cm 2 2 for beta-gamma radiation 20 dpm/100 cm for alpha radiation
, i COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 5.0 GENERAL HEALTH PHYSICS PLAN REVISION: 3 ISSUE DATE: NAY 061985 RADIATION EXPOSURE CONTROL PAGE 4 OF 4 5.3.3 Radiation Area - any area, accessible to personnel, in which there exists radiation originating in whole or in part within licensed material, at such levels that a major portion of the body could receive in any one hour a dose in excess of 5 millirem, or in any 5 consecutive days a dose in excess of 100 millirem.
5.3.4
_High Radiation Area - any area, accessible to personnel, in which there exists radiation originating in whole or in part within licensed material, at such levels that a major portion of the body could receive in any one hour a dose in excess of 100 millirem.
5.3.5 Extremely High Radiation Area - any area, accessible to individuals, in which there exists radiation at such levels that a major portion of the body could receive in any one hour a dose in excess of 1000 millirem.
5.3.6
_ Radiation Controlled Area - any area where access is controlled by the licensee for purposes of protection of materials. from individuals exposure to radiation and radioactive The following are examples of RCA's:
Radiation Area. High Radiation Area, Extremely High Radiation Area, Airborne Radioactivity Area, Contamination Area, and Radioactive Material (s) Area.
5.3.7 Radioactive Material (s) Area - any area or room in which licensed material is used or stored and which contains any radioactive material in an amount exceeding the quantity specified in 10CFR20, Sec. 20.203(e)(1) and (2).
O
(
Comanche Peak Steam Electric Station General Health Physics Plan Section: 6 Revision: 3 Subj ect:
Personnel Radiation Protection
)
Submitted ly: i[d7 h Date: / >
Radiation Protection Engineer Approved by: [ h- Date: 3 67 Aianager, Plant Operations
COMANCHE PEAK STEAM ELECTRIC STATION GENERAL, HEALTH PHYSICS PLAN SECTION: 6.0 REVISION: 3 ISSUE DATE; MAR 1 3 1985 PERSONNEL RADIATION PROTECTION PAGE 2 OF 3 6.0 Personnel Radiation Protection The CPSES facility is operated with the philosophy of minimizing radiation and contamination levels throughout the plant in order to maintain ALARA. a safe working environment and reduce personnel exposure to Specific measures are taken and equipment provided to assure personnel radiation contamination levels safety and protection for the radiation and present.
means of specific procedures and work practices for RadiationPersonn Controlled Area work, by personnel protective equipment and supplies and by continuing assessment of the hazards present to determine ,
appropriate corrective action when needed.
6.) Personnel Protective Equipment Personnel protective equipment for Radiation Controlled Area work gloves, shoe covers and other items. includes protective clothin The requirements for use of specific clothing items shall be established by Radiation Protec-tion and communicated through the Radiation Work Permit (RWP) or General Access Permit (GAP).
depends upon the conditions encountered and as previouslyT mentioned, facility operation is based on the philosophy of maintaining clothing willareas in the plant such that a minimum of protective be required.
Additionally, protective equipment shall be provided when neces-sary for respiratory protection. A special program has been developed for respiratory protection and the equipment available use and care are detailed therein. Use of re,piratory protective equipment nel, with no exceptions to this rule.shall be allowed only for qualifie are detailed in the Respiratory Protection Program (RPA-102). Qualif 6.2 Radiation Controlled Area Work Requirements i
Access and work in Radiation Controlled Areas requires a Radia-tion Work Permit, or General Access Permit. j General Access Permits (GAPS) are required for routine entry, inspection, testing and equipment operation in the Radiation Controlled Area when radiation levels are known and generally stable. Radiation Work Permits (RWPs) are required for non-routine activities where radiation levels are subject to erratic or large changes. Access and work permits provide the means of communicating personnel job, for ALARA analysis. protection requirements and accountability of!
i
.w
COMANCHE PEAK STEAM ELECTRIC STATION
\.
SECTION: 6.0 GENERAL HEALTH PHYSICS PLAN REVISION: 3 ISSUE DATE: MAR 131985 PERSONNEL RADIATION PROTECTION PAGE 3 OF 3 General rules for Radiation Controlled Area work are issued by Radiation entries.
Protection and apply to all Radiation Controlled Area Individuals are required to acknowledge their understanding of radiation conditions, protective and safety measures required, and their responsibility for following all Radiation Controlled Area rules and practices, by signing access and work permits or by entering access information into Radiation Protection computer systems.
6.3 Personnel Radiation Monitoring Monitoring of plant radiological conditions is accomplished by several methods including fixed monitoring instrumentation,
- portable monitoring instrumentation employed by Radiation Protec-tion and monitoring instrumentation employed by personnel entering or leaving the Radiation Controlled Areas.
Fixed monitoring instrumentation is provided throughout the plant to monitor area and process (liquid and gaseous) systems. This instrumentation provides warning for personnel of increasing or abnormally high radiation levels in a work area and providas monitoring of process systems for controlling the transfer and release of radioactive concentrations in air and water.These systems provide records for trend analysis and information concerning emergency or accident conditions.
Portable instrumentation is utilized by Radiation Protection to during theradiological establish progress of conditions work. and monitor the conditions This instrumentation provides a means for planning and controlling exposure of personnel and controlling radioactive material and contamination. This instru-mentation provides the primary means for radiological monitoring and establishing personnel exposure control methods.
Monitoring instrumentation is provided for personnel entering or exiting Radiation Controlled Areas to assure control of contami-nation and radioactive material.
The instrumentation consists of portal monitors, hand and foot monitors and probe detectors to monitor personnel and equipment and thus prevent the spread of contamination to unrestricted areas of the facility. Use of this equipment is required by all personnel upon leaving Radiation Controlled Areas.
I a
Comanche Peak Steam Electric Station '
General Health Physics Plan Section: 7
- Revision: 4
Subject:
Handling and Control of Radioactive Material Submitted by: .
[
~
Date: / /3 ((
Radiation Prote on Engineer '
Approved by: _ ,
M Date: T2
' %nagergant Operations / /
COMANCHE PEAK STEAM ELECTRIC STATION t
SECTION: 7.0 GENERAL HEALTH PHYSICS PLAN -
REvlslON: 4 ISSUE DATE:
i APR 021985 HANDLIND AND CONTROL OF RADIOACTIVE MATERIAL PAGE 2 OF 5 7.0 Handling and Control of Radioactive Material
^
s where it is unwanted. Radioactive contamination is simply radioactive ma The purpose of control of radioactive material at CPSES is to control contamination and provide as clean a work area and environment as possible, resulting in reduced exposure of person-nel.
To assure proper control of radiation and contamination, all materials and equipment to be removed from the Radiation Controlled Area, or to be transferred between radiation control areas, require monitoring and authorization for transfer, by Radiation Protection .
7.1 Contamination Control
- Contamination control is accomplished by several methods includ-ing establishment and posting of Contaminated Areas, controls for 4 movement of traffic and materials, protective clothing for personnel, contamination containment methods, and proper surveil-lance measures to indicate corrective action when necessary of control is dependent upon the severity or amount The degree contamination. of 2
Additionally, specific limits have been established for control of contamination within the CPSES facility. The following working limits have been established for personnel, equipment and ,
surfaces in both Radiation Controlled and unrestricted area
- The trolledbasis such that forthe these hazard limits to personnel is thatiscontamination minimal and shall be co compliance with exposure limits (internal and external) is assured.
A.)
_ Contamination Limits for Unrestricted Areas *
(Applicable to tools, equipment and surfaces)
Removable:
Less than 1000 dpa/100 cm* beta-samma.
Less than 20 dpm/100 can alpha.
l Total: Less than 5000 dpm/100 cm 2
! or 100 counts / minute
~
As measured with a HP-210 fTisker probe or equivalent, j
1
- Above background.
l..
l i
__. ._. _ _ . . _ _ _ _ _ _ _ _ _ _ . _ _ _ _ _ _ _ _ _ . . _ . . , . _ . . _ _ _ _ _ . _ _ . . . _ . . _ ~ _
COMANCHE PEA K STEAM ELECTRIC STATION GENERAL HEALTH PHYSICS PLAN SECTION: 7.0 REVISION: 4 :
ISSUE DATE:APR 021985 ,
HANDLIND AND CONTROL OF RADIOACTIVE MATERIAL PAGE 3 OF 5 I
B.) i Contamination Limits for Radiation Controlled Area Storage Contaminated equipment and material should be stored in areas which are contaminated to the same range of levels as the equipment. General storage requirements within the Radiation Controlled Area are:
Contamination Level, Location / Storage Requirements
> 1000 dpm/100 can B-I and 20 dpm/100 cm2 ,4 loose Contaminated Equipment
> 100 cpm / probe area total Storage
> 10,000 dpm/100 cm 2 B-200 dpm/cm2 oc and
[ loose Decontamination or Special
> 5000 cpm / probe area total Storage l
Contaminated equipment storage areas are provided within the Radiation than Controlled 10,000 dpm/100 cm 2 Area for items contaminated with less (B,f) and 200 dpm/100 cmape),
C.) Protective Clothing Protective clothing used within the Radiation Controlled Area specialshall be monitored, sorted and laundered as defined by instructions.
must be free of removable contamination before use.Af ter la D.) Personnel Contamination Personnel found with any detectable contamination will be decontaminated.
The method of decontamination is dependent upon the type of location of the contamination and shall be determined on an individual basis.
Contamination containment methods shall be used whenever practi-cal to control contamination on equipment and surfaces. Plastic bags or other containment shall be used for storage of equipment and materials.
Containment work structures shall be used when-ever practicable to minimize the spread of contamination and promote rapid cleanup.
Radiation Protection will provide guld-ance and instructions through the RWP and on-the-job evaluation.
2 Radiation Protection shall provide routine 'and periodic surveil-lance of Cont ==f antion Areas and equipment and evaluate the
COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
GENERAL HEALTH PHYSICS PLAN 7.0 REVISION: 4 ISSUE CATE: APR 021985 HANDLIND AND CONTROL OF RADIOACTIVE MATERIAL PAGE 4 OF 5 conditions are to determine if decontamination or special precautions necessary.
7.2 Decontamination Contamination occurs as a result of reactor operations, mainte-of radioactive materials. nance, sampling, vaste disposal operations When contamination levels exceed the working limits established, decontamination is preferred rather than " reclassifying" the area as a Contamination Area As an .
increased from { 1000 dpm/100cmexample, 8 if levels in a por\
toQtl 2 than establishing the area as a permane.000 dpm/100cm Area, nt Contamination , rather it should be posted temporarily as a Contamination Area until decontaminated to the original levels or less.
In accordance" with the philosophy of keeping contamination levels at CPSES as low as reasonably achievable, routine decontamination is desirable even though limits have not been reached.
4 Surfaces, areas, and equipment will be decontaminated routin to minimize personnel exposure, prevent the spread of contami na-tion as a general condition in the plant, and to prepare for shipment, transfer or release of items from the plant. It is the responsibility of each individual to perform his work in such a manner as to prevent or minimize the spread of c '
specific work activities, the personnel whose work resulted in a
for decontamination.the contamination should clean up on their work dedicated decon crew under the guidance of Radiation .
Special decon equipment is available for decontamination of i personnel, areas, surfaces and equipment.
areas are provided at CPSES for decon work. Additionally, Specific decon special Protection. procedures and methods will be recommended by Radiation 7.3 Radioactive Waste Disposal
,I _
Release of radioactive material from CPSES shall be co within the limits specified by 10CFR20 and other applicable guidelines and regulations. Therefore, all radioactive waste disposal (solid, liquid, and gaseous) shall be performed under
COMANCHE PEAK STEAM ELECTRIC STATION 4
I GENERAL HEALTH PHYSICS PLAN SECTION: 7.0 1 I
REVISH3N: 4 ISSUE DATEAPR 02 1985 HANDLIND AND CONTROL OF RADIOACTIVE MATERIAL PAGE 5 OF 5 the guidance and direction of Radiation Protection.
ally, it is the policy of TUGC0 to reduce the amount Addition-of radioactive material waste disposal to ALARA.
Liquid and gaseous radioactive material disposal will require the release and review from approval of the Shift Supervisor prior to disposal or process systems.
All handling and disposal activi-ties shall be performed in accordance with procedures for contamination and personnel exposure control.
" clean," as indicated by meeting the limits for release toMaterial which is unrestricted waste. areas, shall not be disposed of as radioactive Additionally, every effort shall be made to minimize waste volumes prior to final disposal.
7.4 Control of Licensed Material I
Licensed radioactive material must be strictly controlled and accounted for in accordance with the requirements of 10CFR20 and the license conditions. License applications for source and by-product materials for use or shipment to CPSES shall be submitted by the Radiation Protection Engineer. Requirements for obtaining and using licensable material are established by the Radiation Protection Engineer, and his approval is required for the order of such material.
Radiation Protection shall be notified immediately upon receipt of licensed material to allow period of time required by 10CFR20. proper monitoring, inspect be assigned to individuals who will act as cuetodians of theAll licen material storage and andhandling.
be responsible for its safekeeping, proper use, to maintain accountability and prove such for periodic inve -
ries of licensed material performed by Radiation Protection.
Licensed storage. material, while not in use, shall be kept in locked prior notification to and approval from Radiation Pro i !
1
,n
-L .. .
E i .
I i
CONTROLLED COPY NO. 17 0 /
i f
1 r
i 1
a Comanche Peak Steam Electric Station L
General Health Physics Plan i
i Section: 8
! Revision: 2 i
Subject:
Radiological Control Incidents 5
i i
6 1
Submitted by: /b r /M/d tr' Date: // /,( O Radiation frotecti. Engineer /' ~
Approved by: _
i
' Manager,PlgtOperations t ,
Dates / 7- 9 7 (T
' ~
t 4
1 r
- - - , , . , - _,-------.e.. , , - . - , - _ , . -- , . - . , - , - , , -
6 =
COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
GENERAL HEALTH PHYSICS PLAN 8.0 REVl510N:
2 ISSUE DATE: JAN 0 51984 RADIOLOGICAL CONTROL INCIDENTS PA OF 2 4 8.0 Radiological Control Incidents Radiological control incidents are events which involve the actual or -
potential loss of control of radioactive materials, concentrations or radiation dose rates. Loss of control creates the potential for 4 -
personnel injury, damage to equipment or facilities, and financial loss due to cleanup or disposal. Prompt action is necessary to minimize conditions.the impact of or prevent the loss of control of radiological Each person is responsible for being alert to any situa-tion which could lead to a loss of control and reporting such situations promptly to the Shif t Supervisor and Radiation Protection.
Immediate action will be taken to insure the safety of all personnel, evaluate the radiological conditions, minimize the consequences, and
- reestablish control as quickly as possible.
The Radiation Protection Engineer or designee shall determine if incidents require notification to theas tions State, USNRC, or other agencies and shall ef fect such notifica-required.
and responses is provided below.Information concerning some of the major incide 8.1 Personnel Exposure in Excess of Limits If an individual exceeds a personnel exposure limit, administra-tive or mandatory (10CFR20), or it is suspected that a limit has been exceeded, it shall be reported to the Radiatiqn Protection Engineer immediately. Such an individual will be prohibited from entering a Radiation Controlled Area until the actual dose received is ascertained and approval and authorization from the Radiation Protection Engineer is granted. If it is suspected that the dose received could result in illness or injury, prompt medical care shall be provided for the individual. Surveys and sampling by Radiation Protection will be initiated upon notifica-tion of a potential overexposure to assure prompt identification of radiological conditions which the individual was exposed to.
Once the initial response to protect the individual and establish the dose and radiological conditions present during the incident has been taken, an official investigation will be initiated.
reports of overexposure investigations shall be sent to the Alll Manager of Plant Operations and a copy of the report maintained in the individual's personnel exposure history file.
8.2 Loss of Control of Radioactive Material Loss of control includes spills, unexpected high airborne acti-vity, unplanned release of radioactive materials, unexpected high
t COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
8.0 GENERAL HEALTH PHYSICS PLAN REVISION:
2 155UE DATE: JAN 0 51934 RADIOLOGICAL CONTROL INCIDENTS PAGE OF 3 4 radiation levels, and contamination detected outside of estab-lished Contamination Areas in excess of allowable limits. As in all radiological incidents, the initial action shall be to protect personnel then minimize the spill or consequences of the loss of control and reestablish control as quickly as possible.
The consequences of the loss of control shall then be determined and formal investigation and reporting made as required.
8.3 Fire in a Radiation Controlled Area Fires involving radioactive materials require the assumption that airborne activity exists and therefore, respiratory protection is mandatory. Only personnel trained in radiation protection shall be involved assistance is in fighting such fires, unless off-site fire fighting required.
When off-site fire fighting personnel are involved, they shall be accompanied by TUGC0 personnel trained in radiation protection. The response will be to assure the safety of personnel first, then to minimize the spread of fire and damage, and of course extinguishing the blaze as soon as possible.
All equipment (including that to fight the fire) and areas affected by the fire, smoke and ventilation from the fire area vill be assumed contaminated until proven otherwise.
Radiation Protection shall provide approval and authorization for re-entry, recovery and decontamination work, after the fire is extinguished. Working times shall be established by Radiation Protection during the fire fighting procedure and for subsequent cleanup to assure personnel exposures do not exceed limits.
Radiation protection methods and responses for loss of control of radioactive material will apply to all fires involving such material.
8.4 Personnel Injury or Illness Inside a Radiation Controlled Area Personnel illness or injury in a Radiation Controlled Area requires response conditions present. which takes into consideration the radiological Immediate response for serious illness or injury is to protect the injured and assure his cafety and well being.
)
Treatment of ill or injured personnel shall always take l precedence over contamination or radiation control. However, every effort should be made to control personnel exposure and the spread treatment. of contamination without jeopardizing the person needing It shall be assumed that the person involved is contaminated until proven otherwise,;therefore tearing of cloth-4 ing, opening of wound areas, dressing wounds and all first aid measures shall consider this hazard. ' If the ill or. injured cau
- 1
I i
COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
8.0 GENERAL HEALTH PHYSICS PLAN REVISION:
2 ISSUE DATE:JAN 0 51984 RADIOLOGICAL CONTROL INCIDENTS # '
4 4 be moved (based on sound first aid practices) he should be taken as soon as possible to an area of minimal or no contamination or radiation, and a control zone shall be established to prevent the spread of contamination.
Radiation Protection shall be notified and present as soon as possible during transfer or treatment of the person to assure proper radiation protection measures are taken. Any incident involving the transport of a person out of the Radiation Controlled Area or off-site requires the constant accompaniment by Radiation Protection. Any support by personnel who have not received radiation protection training requires the constant attendance by Radiation Protection. Radiation Protec-tion shall perform the necessary surveys and collect the necessary data to assure accurate dose or exposure determination for the person treated and for those providing treatment.
8.5 Personnel Violations Personnel in violation of radiation protection rules, and prac-tices shall be reported immediately. Any person observing such actions on the part of others shall report such incidents to their immediate Supervisor and Radiation Protection. Such violations include tampering with personnel or radiation monitor-ing devices so as to alter the dose or dose rs.te recorded or render the instrument inoperable, violation of control boundaries or administrative controls regarding control of exposure or radioactive material, violation of GAP or RWP requirements, and
" horseplay" or improper conduct in radiologically controlled areas.
--__.c_. . J. . . , J . ..:. '. . . .
./........_.c.._. . ,
o it. .)
CONTROLLED COPY NO. _ 0 _ , _
Comanche Peak Steam Electric Station General Health Physics Plan t.
l Section: 9
! Revision: 2
Subject:
Radiation Protection Records and Reports j
e i
Submitted by: , .
[h//d /1 Dates ///'//f T3 Radiation 4rotectio ngineer Approved by:
M'td Dates /d 7 q ,-
(
Kanager, Pla,# 0perations
COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 9.0 GENERAL HEALTH PHYSICS PLAN REVISION: 2 ISSUE DATE:JAN 0 5 be4 RADIATION PROTECTION RECORDS AND REPORTS PAGE 2 OF 3 9.0 Radiation Protection Records and Reports Records and reports of radiation protection activities and radioactive material control are required by 10CFR19 and 10CFR20. The records required include those for personnel exposure, radiation surveys, monitoring, sampling and analysis, licensed material control, waste disposal, ALARA analysis, radiological control incidents and others.
for audits.protection records shall be readily accessible and available Radiation 9.1 Personnel Exposure Records and Reports Recorde of personnel exposure and applicable reports shall be maintained and issued by Radiation Protection and will include personnel exposure history, current exposure, body burden or bioassay analysis, reports and investigations of overexposure.
Non-occupational or medical radiation exposures will not be recorded or filed. Additionally, requests and approvals for exceeding administrative control limits shall be recorded and filed. Personnel exposure records will include status of train-ing for use of respiratory protective equipment, related medical / physical history, and status of training for work in Radiation Controlled Areas.
9.2 Radioactive Materials Records and Reports Records shall be maintained and reports issued concerning the shipment, receipt, transfer, use and* disposal of all licensed radioactive material in accordance with HPT-201. Included in such records shall be the specific activity, isotopic analysis, custodians, users and methods of disposal of licensed radioactive material.
Radioactive material shipment records and inventory records shall be maintained. Releases of radioactive effluents shall be recorded and reported as required.
9.3 Reporting Radfological Control Incidents Records and reports of all radiological control incidents shall be maintained extent and shall include details as to persons involved, of the incident, and resolution of the incident, impact on personnel including correctiveand the environment, action requirements. --
Any incidents requiring notification to offsite i authorities shall be documented and filed, including records of telephone conversations and telegraph messages as well as letters or other supporting documents. A specific file shall be l
o COMANCHE PEAK STEAM ELECTRIC STATION GENERAL HEALTH PHYSICS PLAN SECTION: 9.0 REVISION: 2 ISSUE DATE:JAN 0 51984 RADIATION PROTECTION RECORDS AND REPORTS PAGE 3 OF 3 maintained for each separate incident, containing all necessary information and appropriate approval signatures to indicate that all actions related to the incident have been completed properly.
o
- . . . . . . . s :. . :.! i . . u: .
. z --. . . . . . , . .. ... . a : _.... ; . .a._...._._..... . . . . . . . . . . . . __.;.,
'f r
CONTR'JLLED COPY NO. Oh/
t 0
1 i
i Comanche Peak Steam Electric Station
- 1 General Health Physics Plan
/
)
I I
Section: 10 Revision: 2
Subject:
Radiation Protection Procedures and Instructions t
I Submitted by: . [Md)
Radiation Protection E eer Dates ///-
8 h
/
Approved by: u M Date: # d. /o > 9' 3 Manager, Plant 0,perations 1 1 e
i
_ . .. .,..m COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
GENERAL HEALTH PHYSICS PLAN 10.0 REVISION:
2 ISSUE DATE: JAN 0 51984 RADIATION PROTECTION PROCEDURES AND INSTRUCTIONS PAGE OF 2 2 10.0 Radiation Protection Procedures and Instructions Implementation of this plan requires the development of certain Radiation Protection procedure and instructions. Compliance with the requirements of this plan, procedures and instructions is manditory unless specifically exempted or excluded as detailed below.
10.1 Health Physics Administrative Manual The Health Physics Administrative Manual contains administrative procedures applicable to all personnel at CPSES. These proce-dures establish various programs which implement this plan.
10.2 Health Physics Technical Manual The Health Physics Technical Manual contains procedures applica-ble to Radiation Protection personnel only. These procedures control the various programs and requirements of this plan.
10.3 Health Physics Instruction Notebook The Health Physics Instruction Notebook contains instructions for use by Radiation Protection personnel in impicmenting the various Radiation Protection Section Programs.,
1 1
l
- 7. .- ,
. .J. . - . .
. . . . . _ . . . _ . . ._..u... . .;.. _ . . .. . . . . .. .
CONTROLLED COPY NO.
[/[i/
f '
t Comanche Peak Steam Electric Station-General Health Physics Plan Section: 11 Revision: 2
Subject:
Definitions Submitted by: .
f l#h.3? Dates //ff Radiation Protection Engineer /' <
Approved by: jL Date: /d 27 97 n naa.r. y t o,.r.ti.n. ; , , -
. l COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 11.0 GENERAL HEALTH PHYSICS PLAN REVISION: 2 ISSUE DATE: JAN 0 51994 DEFINITIONS PAGE 2 OF 4 11.0 Definitions Airborne Radioactivity Area - An area where airborne radioactive materials exist in concentrations greater than or equal to those specified in 10CFR20, Appendix B Table 1. Column 1, or any area where the average concentration over a 40 hour4.62963e-4 days <br />0.0111 hours <br />6.613757e-5 weeks <br />1.522e-5 months <br /> week, during which indivi-duals are in the area, is greater than or equal to 25% of the concentrations indicated above.
ALARA "as low as reasonably achievable;" the philosophy that expo-sure to ionizing radiation involves some risk, no matter how small, and should be reduced to the minimum amount practicable considering all technical and economical factors in light of the benefits result-ing from the exposure received.
Calendar Quarter - thirteen consecutive calendar weeks. The first calendar quarter begins on January 1 of each year with subsequent quarters beginning on April 1 July 1, and October 1 respectively.
Contamination Area - Any area accessible to personnel in which con-tamination levels are greater than or equal to:
2 1,000 dpm/100 cm for beta-gamma radiation 20 dpm/100 cm2 for alpha radiation Dose of the -body.
Radiation absorbed per unit of mass, by the body or any portion Dose Rate - Absorbed dose over a specific period of time.
Exposure - Dose in air as opposed to dose absorbed by the body.
External Exposure - Exposure to radiation sources which are outside (external to) the body.
Extremely High Radiation Area - any area, accessible to individuals, in which there exists radiation at such levels that a major portion of the body could receive in any one hour a dose in excess of 1000 millirem.
Extremity Dose - Dose to the hands, fingers, forearms, feet or ankles.
High Radiation Area - Any area, accessible to personnel, in which radiation levels are such that a major portion of the body could receive, in any one hour, a dose in excess of 100 millirems.
. ~ . .. . . . . . .
.w COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
GENERAL HEALTH PHYSICS PLAN 11.0 REVistON:
2 ISSUE DATE: JAN 0 51984 DEFINITIONS PAGE OF 3 4 Internal Exposure - Exposure to radiation sources which are inside (internal to) the body.
Non-Plant personnel. Personnel - Personnel cther than those defined as plant Plant Personnel - Personnel employed by TUGC0 and permanently assigned to CPSES.
Prefixes: i Prefix Symbol Multiplication Factor wega M 6 10 9
kilo K 10' ce'nti c 10' milli m 10
~
micro p 10
-6 <
nano yt 10
-9 pico- p -12 j 10 Radiation - Any or all of the followins: alpha rays, beta rays, gamma rays, X-rays, neutrons, high-speed electrons or protons, or other atomic particles; ultraviolet light. but not sound or radio waves, visible infrared or Radiation Area - Any area, accessible to personnel, in which radiation levels are such that a major portion of the body could receive in any one hour a dose in excess of 5 millirems, or'in any five consecutive days (40 hours4.62963e-4 days <br />0.0111 hours <br />6.613757e-5 weeks <br />1.522e-5 months <br />) a dose in excess of 100 millirems, Radiation Controlled Area,- Any area to which access is controlled for i the purposes of radiation protection. Any area where an individual l period.receive a dose in excess os 2 millirem during any one hour could t Radiation Worker - Those individuals which have successfully completed Radiation Worker Training, are knowledgeable in radiation protection rules and practices and have established exposure histories.
COMANCHE PEAK STEAM ELECTRIC STATION SECTION: 11.0 GENERAL HEALTH PHYSICS PLAN REVISION: 2 ISSUE DATE: JAN 0 51984 DEFINITIONS PAGE OF 4 4 Radioactive Material - Material which emits radiation spontaneously.
Radioactive Waste - Material which is radioactive such that decon-tamination for unrestricted use is not practicable and the material must be disposed of under prescribed conditions.
Rem - A unit biological of measure effect. of absorbed radiation dose in terms of its Unrestricted Area - Any area to which access is not controlled or limited for purpose of radiation protection.
Whole Body Dose - A dose to the entire body or major portion of the body such the lens ofas thethe gonads, blood-forming organs, the head and trunk, or cyc.
m*
. .: . :.s 1. * . '. .a.' '
.- .~n...
e CONTROLLED COPY NO. Ob!
Comanche Peak Steam Electric Station General Health Physics Plan -
Section: 12 Revision: 3
Subject:
Policy Submitted by: ,
!d'[/dM Date: ![ /Y [6 P.ad~1ation trotection' ngineer -
/
Approved by: .
Date: _ / 7 , 'O 7/ D
' Manager, Plany peracions 1
- n ',
~: , ,
.m. - - . .
COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
GENERAL HEALTH PHYSICS PIAN 12.0 REVISION:
3 t$5UE DATE: JAN 0 51984 POLICY PAGE OF 2 5 STATEMENT OF__ POLICY This General Health Physics Plan establishes the Radiation Protection requirements, responsibilities and policy to be implemented at Comanche Peak Steam Electric Station by station and non-station personnel, for all
. entry and work in Radiation Controlled Areas at the station.
The requirements of this Plan are implemented with the authority of the Manager ment. of Plant Operations with the complete support of Company manage-are subjectaspects of the administration and implementation of this Plan All to the concurrence of the Engineering Superintendent and subject to review and approval by the Radiation Protection Engineer.
All persons performing work or directing the work of others under the guidance of this Plan are required to familiarize themselves with the policies, procedures and guidelines set forth in this manual, and shall be responsible for executing those requirements pertinent to their respective assignments. ,
B. R. Clements, Vice President. Nuclear p ,.
RECEs s m; C4sMS, TEXAS ag W.
- ?..;w,,f .. 4
a __
.tc.
COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
GENERAL HEALTH PHYSICS PLAN 12.0 REVISION: 3 ISSUE DATE: JAN 0 51984 POLICY PAGE OF 3 5 ALARA POLICY STATEMENT It is the policy of Texas Utilities Generating Company (TUGCO) that all such that every reasonable effort shall be made to reduce r exposures.
public and the release of radioactive material to unrestricte be maintained specified As Low As Reasonably Achievable (ALARA) below the limits in 10CFR20.
" Reasonably achievable" will take into account the benefits to TUGC0 and its employees or to public healt .
The Manager, Plant Operations has the responsibility and authority to develop Electric Station.end imple=cnt an effective ALARA Program at Comanche Peak Steam He has the complete support of Company management.
Accomplishment considerations: of the ALARA policy objectives requires the following ma 1.
Management commitment and support.
2.
Careful design of facilities and equipment.
3.
Good radiation protection practices, including good planning and well-trained, and dedicated personnel. proper use of appropriate 4
Continual vigilance by the operational staff to reduce exposure ,
minimize releases, minimize the generation of radioactive waste, and control radioactive airborne and surface contamination All persons involved in operations involving radiation and radioactive material are required to familiarize themselves with the associated policies, those requirements plans, and procedures pertinent and shall be responsible for executing to their assignments.
B. R. Clements, Vice President, Nuclear
. .. _ _ . . . _ . ?- : -
. - . . . . . - _ _ __ - - .~ ,_ __ __ __ _
. -~
I I
COMANCHE PEAK STEAM ELECTRIC STATION _ ;
SECTION:
GENERAL HEALTH PHYSICS PLAN 12.0 REVISION: 3 ISSUE DATE: JAN 0 51984 POLICY PAGE OF 4 5 RESPIRATORY PROTECTION POLICY It is the intent of Texas Utilities Generating Company (TUGCO) Comanche Peak Steam Electric Station (CPSES) to maintain the levels of ra and non-radioactive airborne contaminants as low as is reasonably achievable (ALARA) under routine, non-routine and emergency conditions.
This intent will be primarily accomplished by accepted engineering control Only when such controls are not reasonably achievable wil respiratory protection devices be permitted.
It is the policy of TUGC0 to provide only approved respiratory protection equipment for use by trained and qualified personnel and to prohibit the use of such requirc= catsequipment by personnel not qualified according to the of this program.
Personnel who wear respiratory protection equipment have the righte to leav any area where respiratory protection equipment is required at anytime for relief from respirator use in the event of equipment malfunction, physical or psychological distress, procedural or communication failure, significant deterioration require such relief. of operating conditions, or any other condition that might It is the policy of TUGC0 to reduce personnel exposure to all forms of radioactive material to ALARA. '
B. R. Clements, Vice President, Nuclear
?
= _
__ , , , _ ]
p *~
COMANCHE PEAK STEAM ELECTRIC STATION SECTION:
GENERAL HEALTH PHYSICS PLAN 12.0 g
REVISION:
3 ISSUE DATE.JAN 0 5 1984 POLICY PAGE OF 5 5 RADI0 ACTIVE WASTE MINIMIZATION It is the intent and goal of Comanche Peak Steam Electric Station to minimize the production of radioactive waste, which will result in savings to the plant in manpower, .ime, money and personnel exposure.
To attain this goaf,~ a volume reduction program *shall be implemented consisting of the following: -Control"df materials. entering into contami- j nated areas, an aggressive, decontamination'"piogram, vaste stream control i
and segregation of~radfoactive vaste from.non-radioactive waste.
All personnel performing work or directing Jhe.vork of others in the Radiation Controlled Areassho'sl3 remain cognizant of how their activities impact radioactive vaste,and_ strive to minimize radioactive waste generation.
. - .~.. y.7 y,; _ __ .
, Y., :.'W _.
_ jRJ1'u
. B..R...Clementsi-Vice President, Nuclear
, , . _ =_ _ _. - - --
I g 33 go. e .w 9. * ""' * * " " '
,, p , W eau. 4 * #**~
,g wa. 9> #*'
i.5.17 I M ...--
1 l
-- - - - - ~-
v __
e-0
efd DATE RCVD. 4.5"//9//d FCUF PDR FCAF LPDR W 1&E REF. 1.YJR SAFECUARDS-FCTC OTHER DESCRIPTION: - / / / / , Ild N [ INITIAL / / c .b