ML19207B865
From kanterella
Revision as of 20:44, 15 August 2019 by StriderTol (talk | contribs) (Created page by program invented by StriderTol)
| ML19207B865 | |
| Person / Time | |
|---|---|
| Site: | Peach Bottom  |
| Issue date: | 08/29/1979 |
| From: | Cooney M PECO ENERGY CO., (FORMERLY PHILADELPHIA ELECTRIC |
| To: | NRC OFFICE OF INSPECTION & ENFORCEMENT (IE REGION I) |
| Shared Package | |
| ML19207B859 | List: |
| References | |
| LER-79-024-01T-01, LER-79-24-1T-1, NUDOCS 7909050443 | |
| Download: ML19207B865 (1) | |
Similar Documents at Peach Bottom | |
|---|---|
Category:LICENSEE EVENT REPORT (SEE ALSO AO
MONTHYEARML20045E9961993-07-0101 July 1993
[Table view]LER 93-012-00:on 930607,discovered That Surveillance Test on Fire Protection Sys Missed on 930601.Caused by Insufficient Degree of Attention Applied by Nonlicensed Individual.Test Satisfactorily completed.W/930701 Ltr ML20045E8661993-06-25025 June 1993 LER 93-011-00:on 930528,TS Violation Occurred When New Fuel Was Added to EDG Fuel Oil Storage Tank Prior to Completion of Chemical Analysis.Caused by Personnel Error.Individual counselled.W/930625 Ltr ML20044E7351993-05-20020 May 1993 LER 93-010-00:on 930425,noticed That Wide Range Reactor Level Indications Associated w/2A Condensing Chamber Drifted High than Level Instruments Associated w/2B Condensing Chamber.Caused by Level Instrument leaking.W/930520 Ltr ML20044E7341993-05-20020 May 1993 LER 93-008-00:on 930409,Tech Spec Violation Occurred.Caused by Setpoint Drift of Pressure Switch in Conjunction W/Less than Adequate Communication.Event Discussed W/Involved individuals.W/930520 Ltr ML20044E7381993-05-20020 May 1993 LER 93-009-00:on 930422,discovered Containment Sump Pump Collection & Flow Data Not Recorded in Surveillance Test. Caused by Personnel Error.Event Discussed W/Involved individuals.W/930520 Ltr ML20024G7391991-04-24024 April 1991 LER 91-004-00:on 910324,reactor Operator Failed to Initial Surveillance Test 5.3, Inoperable Valve Position Daily Log. Caused by Personnel Error Due to Failure to Follow Procedure.Operator counselled.W/910424 Ltr ML20028H3461990-12-10010 December 1990 Corrected LER 90-033-00:on 901108,discovered TS Limiting Condition of Operation Not Entered for Inoperable Containment Isolation Valve Due to Procedural Deficiency ML20044A6741990-06-25025 June 1990 LER 89-028-01:on 891108,determined That Standby Gas Treatment Sys Heater Control Relays Installed W/O Environ Qualification.Caused by Lack of Procedural Guidance.Relays relocated.W/900625 Ltr ML20043G8761990-06-14014 June 1990 LER 90-012-00:on 890815,discovered Valves Left Closed After Removal of Blocking Permit & on 890813,emergency Cooling Water Pump & Emergency Diesel Generator Removed from Svc. Caused by Inadequate procedures.W/900614 Ltr ML20043G0821990-06-11011 June 1990 LER 90-006-00:on 900511,blown Fuse from Battery Charger 3B Resulted in Declaring HPCI Sys,Core Spray B Logic,Rhr B Logic,Core Spray Subsystem B,Rhr Subsystem B & E2 & E4 Emergency Diesel Generators inoperable.W/900611 Ltr ML20043D7291990-06-0505 June 1990 LER 90-005-00:on 900507,Group 2A Primary Containment Isolation Sys Isolation Occurred During Surveillance Test. Caused by Inadequate Worker Practices.Blown Fuse Replaced & Personnel counseled.W/900605 Ltr ML20043D7211990-06-0404 June 1990 LER 90-011-00:on 900503,discovered That Tech Spec 3.4.1 Not Performed on 6-wk Frequency as Required.Caused by Personnel Error.Tracking of Surveillance Activities Scheduled to Be Transferred to Improved Software package.W/900604 Ltr ML20043C5921990-05-31031 May 1990 LER 90-010-00:on 900502,three Control Room Emergency Ventilation Actuations Occurred.Caused by Poor Electrical Continuity as Result of Oxidation Between plug-in Circuit Boards & Mating Electrical connections.W/900531 Ltr ML20043C5781990-05-30030 May 1990 LER 90-004-00:on 900430,Tech Spec Violation Occurred When MSIV Closure Timing Testing Not Performed in Required Surveillance Interval.Caused by Ambiguous Test Procedure. Surveillance Test revised.W/900530 Ltr ML20043C5721990-05-30030 May 1990 LER 90-009-00:on 900430,discovered That Rod Block Monitor Not Been Proven Operable Prior to Exceeding 30% Power as Required by Tech Specs.Caused by Programmatic Deficiency. General Plant Procedures revised.W/900530 Ltr ML20043A4691990-05-16016 May 1990 LER 90-008-00:on 900417,discovered That Testing of LPCI Pumps & Core Spray Subsystems Not Performed When LPCI Pump D Declared Inoperable on 900414.Caused by Personnel Error. Procedures Declaring Pump Inoperable revised.W/900516 Ltr ML20043A7831990-05-14014 May 1990 LER 90-007-00:on 900412,evaluation Involving Seismic Qualification Performed Due to Postulated Failure of Condensate & Vacuum Pumps During Design Seismic Events. Caused by Design Oversight.Program updated.W/900514 Ltr ML20042F9581990-05-0707 May 1990 LER 90-001-01:on 900124,shift Surveillance Log Did Not Meet Requirements of Tech Specs.Caused by Deficient Procedure. Surveillance Log Revised to Include Daily Instrument Check. W/900507 Ltr ML20042F3211990-05-0202 May 1990 LER 90-006-00:on 900402,actuation of Emergency Diesel Generator Occurred.Caused by Personnel Miscommunication. Shift Mgt Will Be Reminded of Necessity to Control Activities in Control room.W/900502 Ltr ML20042E9811990-04-30030 April 1990 LER 90-002-01:on 900128,ESF Sys Actuations Occurred Due to Reactor Vessel Level Fluctuations After Manual Scram.Caused by Failure of O-ring on Fluid Inlet Port to Servo Valve for Hydraulically Operated Valve.Valve replaced.W/900430 Ltr ML20042E9101990-04-27027 April 1990 LER 90-005-00:on 900326,Tech Spec Surveillance Not Performed within Required Interval.Caused by Personnel Error.Personnel Counseled & Will Periodically Review Omitted Test Rept to Ensure Performance of Surveillance tests.W/900427 Ltr ML20042E6801990-04-23023 April 1990 LER 89-031-01:on 891206 & 900105,Agastat Relays Found Not Properly Secured by Seismic Support Straps.Caused by Inadequate Installation or Reinstallation of Seismic Straps. Straps Properly reconnected.W/900423 Ltr ML20042E6821990-04-19019 April 1990 LER 90-004-00:on 900321,discovered Potentially Inoperable Safety Sys Due to Inadequate Emergency Svc Water Cooling Flow Through Room Coolers.Caused by Gradual Buildup of Corrosion & Silt.Mod completed.W/900419 Ltr ML20012C4831990-03-12012 March 1990 LER 89-029-01:on 891117,primary Containment Isolation Sys Actuation Occurred During Performance of Refueling Floor Ventilation Exhaust Radiation Monitor Testing.Cause Unknown. Selector Switch & Relay Contacts cleaned.W/900312 Ltr ML20012C4821990-03-12012 March 1990 LER 89-024-01:on 891006,local Power Range Monitor Spike Caused Reactor Scram Signal While in Hot Shutdown.Caused by Design &/Or Mfg Process as Identified by Ge.Detector Placed in Bypass Position & Scram Signal reset.W/900312 Ltr ML20012A0171990-02-23023 February 1990 LER 90-002-00:on 900128,reactor Manually Scrammed Due to Leak of Electrohydraulic Control Sys Fluid.Caused by Lock Nut on Interlock Dump Valve Setting Adjustment Bolt Becoming Unsecured Due to Sys Vibration.Leak stopped.W/900223 Ltr ML20012A0021990-02-23023 February 1990 LER 90-001-00:on 900124,discovered That Daily Instrument Check of Main Stack Flow Rate Monitor Not Performed.Caused by Incomplete Procedure.Operating Shift Surveillance Log Revised to Include Daily Instrument check.W/900223 Ltr ML20012A0841990-02-0707 February 1990 LER 90-001-00:on 900108,HPCI Sys Declared Inoperable During Surveillance Testing When Start Time Exceeded 25 S.Caused by Inadequate Calibr Procedure Which Allowed Setting of 18 S. Ramp Generator & Signal Converter replaced.W/900207 Ltr ML20011F5791990-02-0707 February 1990 LER 89-007-01:on 890411,green Discoloration Discovered in Grease on Stabs of Several Control Fuses in 4 Kv Switchgear. Probably Caused by Incomplete Procedure.Maint Procedure M-054.004 Revised to Include Fuse insp.W/900207 Ltr ML20006A9621990-01-19019 January 1990 LER 89-033-00:on 891220,full Scram Signal Received When Technician Performed Surveillance on APRM D.Caused by Procedural Deficiencies & Inattention to Detail by Technician.Technician counseled.W/900119 Ltr ML19354E0121990-01-17017 January 1990 LER 89-032-00:on 891218,discovered That Weekly Surveillance Test Not Performed within Surveillance Interval.Caused by Inappropriate Action Based on Failure to Follow Procedure. Surveillance Test Coordinator counseled.W/900117 Ltr ML19354E0091990-01-16016 January 1990 LER 89-011-00:on 891213,discovered That Two Surveillance Tests of Turbine Stop & Control Valve Encl Not Performed Per Tech Specs.Caused by Incorrect Std Practice of Surveillance Testing.Programmatic Controls established.W/900116 Ltr ML19354E0101990-01-16016 January 1990 LER 89-015-01:on 890721,while Attempting to Remove Malfunctioning Reactor Pressure Vessel Regulator Set,Bypass & Control Valves Opened,Causing Steam Line Pressure to Increase to 480 Psig.Components replaced.W/900116 Ltr ML19354E0851990-01-11011 January 1990 LER 89-010-00:on 891211,monthly Surveillance Test ST 9.7 Not Performed within Surveillance Interval Established by Tech Spec Table 4.1.1.Caused by Combination of Programmatic Weaknesses.Review performed.W/900111 Ltr ML20005G2451990-01-11011 January 1990 LER 89-016-01:on 890720 & 22,LPRM Detector 4B-40-33 Spiked High,Resulting in Full Reactor Scram Signal While in Cold Shutdown.Caused by Design/Mfg Defect in GE Detector. Detector Placed in Bypass position.W/900111 Ltr ML20005G1901990-01-0808 January 1990 LER 89-009-00:on 891207,HPCI Sys Declared Inoperable When Sys Failed to Start During Pump,Valve & Flow Surveillance Test.Caused by Loose Lock Nut on HPCI Oil Sys Relief Valve. Lead Seal Wire to Be Placed on Valve caps.W/900108 Ltr ML20005F8711990-01-0505 January 1990 LER 89-031-00:on 891206,discovered That Four Agastat Relays Not Properly Secured by Seismic Support Straps.Root Cause Under Investigation & Will Be Reported in Rev to Ler.Support Straps Promptly reconnected.W/900105 Ltr ML20005E3911989-12-26026 December 1989 LER 89-030-00:0n 891126,steam Leak Discovered Coming from Packing on RCIC Injection Check Valve AO-22.Caused by Failure of Valve Stem Packing.Normal Reactor Level Restored & Mods of Valve Will Be pursued.W/891226 Ltr ML20011D2331989-12-18018 December 1989 LER 89-029-00:on 891117,Group III Primary Containment Isolation Sys Actuation Occurred During Refueling Floor Ventilation Exhaust Radiation Monitor Testing.Cause Unknown. Test Procedure to Be revised.W/891218 Ltr ML19332E7081989-12-0606 December 1989 LER 89-028-00:on 891108,review Determined That Standby Gas Treatment Sys Heater Control Relays Unqualified for post-LOCA Radiation Environ & Declared Inoperable.Cause Undetermined.Radiation Shielding installed.W/891206 Ltr ML19332E6331989-11-27027 November 1989 LER 89-007-00:on 891026,reactor Vessel Temp & Reactor Coolant Pressure Not Logged Every 15 Minutes as Required by Tech Spec 4.6.A.2 During Performance Integrated Leak Rate Testing.Caused by Procedure deficiency.W/891127 Ltr ML19332E7591989-11-27027 November 1989 LER 89-008-00:on 891027,primary Containment Isolation Sys Group II & III Isolations Occurred When Spurious Reactor Low Level Signal Sensed by Instruments.Possibly Caused by Air Bubble in Sensing Lines.Line backfilled.W/891127 Ltr ML19332D3401989-11-22022 November 1989 LER 89-006-00:on 891023,during Reactor Temp Adjustment, Reactor High Pressure Scram Occurred.Caused by Improper Planning & Coordination of Multiple Evolutions.Surveillance & Hydrostatic Test revised.W/891122 Ltr ML19332C4931989-11-20020 November 1989 LER 89-005-00:on 891020,reactor Protection Sys Actuation & Primary Containment Isolation Sys Actuation Occurred Due to False High Reactor Pressure Signal & lo-lo Reactor Vessel Level Signal,Respectively.Caused by spike.W/891120 Ltr ML19332C8191989-11-15015 November 1989 LER 89-027-00:on 891016,observation & Logging of Suppression Pool Temp as Required by Tech Spec 4.7.2 Not Met.Caused by Personnel Error.Operations Shift Team counseled.W/891115 Ltr ML19324C4361989-11-0808 November 1989 LER 89-026-00:on 891012,control Room Emergency Ventilation Sys Actuation Occurred Due to Momentary False High Radiation Signal from Control Room Radiation Monitor B.Caused by Sensitivity of Thumbwheel switch.W/891108 Ltr ML19324C1781989-11-0606 November 1989 LER 89-023-00:on 891005,outboard MSIV Ac Solenoid Pilot Valves de-energized,resulting in Expected Closure of Outboard MSIV D & Automatic Reactor Scram.Caused by Incomplete Guidance.Procedure revised.W/891106 Ltr ML19325F1801989-11-0606 November 1989 LER 89-024-00:on 891006,reactor Protection Sys Initiated Full Reactor Scram Signal.Caused by Output Signal for LPRM 40-33A Spiking High.Lprm Detector Placed in Bypass Position & Scram Signal reset.W/891106 Ltr ML19325F1811989-11-0202 November 1989 LER 89-022-00:on 891003,unterminated Lead in Circuit to HPCI Trip Solenoid Rendered HPCI Stop Valve Trip Functions Inoperable.Caused by Leads Loosely Hanging Inside Door Panel.Hanging Leads Secured & Panel inspected.W/891102 Ltr ML19325F1791989-11-0202 November 1989 LER 89-025-00:on 891007,determined That nonsafety-related Bellows Leak Detecting Pressure Switches Installed on Main Steam Relief Valves Could Prevent Opening During Design Basis Condition.Plant Alteration installed.W/891102 Ltr 1993-07-01 Category:RO) MONTHYEARML20045E9961993-07-0101 July 1993
[Table view]LER 93-012-00:on 930607,discovered That Surveillance Test on Fire Protection Sys Missed on 930601.Caused by Insufficient Degree of Attention Applied by Nonlicensed Individual.Test Satisfactorily completed.W/930701 Ltr ML20045E8661993-06-25025 June 1993 LER 93-011-00:on 930528,TS Violation Occurred When New Fuel Was Added to EDG Fuel Oil Storage Tank Prior to Completion of Chemical Analysis.Caused by Personnel Error.Individual counselled.W/930625 Ltr ML20044E7351993-05-20020 May 1993 LER 93-010-00:on 930425,noticed That Wide Range Reactor Level Indications Associated w/2A Condensing Chamber Drifted High than Level Instruments Associated w/2B Condensing Chamber.Caused by Level Instrument leaking.W/930520 Ltr ML20044E7341993-05-20020 May 1993 LER 93-008-00:on 930409,Tech Spec Violation Occurred.Caused by Setpoint Drift of Pressure Switch in Conjunction W/Less than Adequate Communication.Event Discussed W/Involved individuals.W/930520 Ltr ML20044E7381993-05-20020 May 1993 LER 93-009-00:on 930422,discovered Containment Sump Pump Collection & Flow Data Not Recorded in Surveillance Test. Caused by Personnel Error.Event Discussed W/Involved individuals.W/930520 Ltr ML20024G7391991-04-24024 April 1991 LER 91-004-00:on 910324,reactor Operator Failed to Initial Surveillance Test 5.3, Inoperable Valve Position Daily Log. Caused by Personnel Error Due to Failure to Follow Procedure.Operator counselled.W/910424 Ltr ML20028H3461990-12-10010 December 1990 Corrected LER 90-033-00:on 901108,discovered TS Limiting Condition of Operation Not Entered for Inoperable Containment Isolation Valve Due to Procedural Deficiency ML20044A6741990-06-25025 June 1990 LER 89-028-01:on 891108,determined That Standby Gas Treatment Sys Heater Control Relays Installed W/O Environ Qualification.Caused by Lack of Procedural Guidance.Relays relocated.W/900625 Ltr ML20043G8761990-06-14014 June 1990 LER 90-012-00:on 890815,discovered Valves Left Closed After Removal of Blocking Permit & on 890813,emergency Cooling Water Pump & Emergency Diesel Generator Removed from Svc. Caused by Inadequate procedures.W/900614 Ltr ML20043G0821990-06-11011 June 1990 LER 90-006-00:on 900511,blown Fuse from Battery Charger 3B Resulted in Declaring HPCI Sys,Core Spray B Logic,Rhr B Logic,Core Spray Subsystem B,Rhr Subsystem B & E2 & E4 Emergency Diesel Generators inoperable.W/900611 Ltr ML20043D7291990-06-0505 June 1990 LER 90-005-00:on 900507,Group 2A Primary Containment Isolation Sys Isolation Occurred During Surveillance Test. Caused by Inadequate Worker Practices.Blown Fuse Replaced & Personnel counseled.W/900605 Ltr ML20043D7211990-06-0404 June 1990 LER 90-011-00:on 900503,discovered That Tech Spec 3.4.1 Not Performed on 6-wk Frequency as Required.Caused by Personnel Error.Tracking of Surveillance Activities Scheduled to Be Transferred to Improved Software package.W/900604 Ltr ML20043C5921990-05-31031 May 1990 LER 90-010-00:on 900502,three Control Room Emergency Ventilation Actuations Occurred.Caused by Poor Electrical Continuity as Result of Oxidation Between plug-in Circuit Boards & Mating Electrical connections.W/900531 Ltr ML20043C5781990-05-30030 May 1990 LER 90-004-00:on 900430,Tech Spec Violation Occurred When MSIV Closure Timing Testing Not Performed in Required Surveillance Interval.Caused by Ambiguous Test Procedure. Surveillance Test revised.W/900530 Ltr ML20043C5721990-05-30030 May 1990 LER 90-009-00:on 900430,discovered That Rod Block Monitor Not Been Proven Operable Prior to Exceeding 30% Power as Required by Tech Specs.Caused by Programmatic Deficiency. General Plant Procedures revised.W/900530 Ltr ML20043A4691990-05-16016 May 1990 LER 90-008-00:on 900417,discovered That Testing of LPCI Pumps & Core Spray Subsystems Not Performed When LPCI Pump D Declared Inoperable on 900414.Caused by Personnel Error. Procedures Declaring Pump Inoperable revised.W/900516 Ltr ML20043A7831990-05-14014 May 1990 LER 90-007-00:on 900412,evaluation Involving Seismic Qualification Performed Due to Postulated Failure of Condensate & Vacuum Pumps During Design Seismic Events. Caused by Design Oversight.Program updated.W/900514 Ltr ML20042F9581990-05-0707 May 1990 LER 90-001-01:on 900124,shift Surveillance Log Did Not Meet Requirements of Tech Specs.Caused by Deficient Procedure. Surveillance Log Revised to Include Daily Instrument Check. W/900507 Ltr ML20042F3211990-05-0202 May 1990 LER 90-006-00:on 900402,actuation of Emergency Diesel Generator Occurred.Caused by Personnel Miscommunication. Shift Mgt Will Be Reminded of Necessity to Control Activities in Control room.W/900502 Ltr ML20042E9811990-04-30030 April 1990 LER 90-002-01:on 900128,ESF Sys Actuations Occurred Due to Reactor Vessel Level Fluctuations After Manual Scram.Caused by Failure of O-ring on Fluid Inlet Port to Servo Valve for Hydraulically Operated Valve.Valve replaced.W/900430 Ltr ML20042E9101990-04-27027 April 1990 LER 90-005-00:on 900326,Tech Spec Surveillance Not Performed within Required Interval.Caused by Personnel Error.Personnel Counseled & Will Periodically Review Omitted Test Rept to Ensure Performance of Surveillance tests.W/900427 Ltr ML20042E6801990-04-23023 April 1990 LER 89-031-01:on 891206 & 900105,Agastat Relays Found Not Properly Secured by Seismic Support Straps.Caused by Inadequate Installation or Reinstallation of Seismic Straps. Straps Properly reconnected.W/900423 Ltr ML20042E6821990-04-19019 April 1990 LER 90-004-00:on 900321,discovered Potentially Inoperable Safety Sys Due to Inadequate Emergency Svc Water Cooling Flow Through Room Coolers.Caused by Gradual Buildup of Corrosion & Silt.Mod completed.W/900419 Ltr ML20012C4831990-03-12012 March 1990 LER 89-029-01:on 891117,primary Containment Isolation Sys Actuation Occurred During Performance of Refueling Floor Ventilation Exhaust Radiation Monitor Testing.Cause Unknown. Selector Switch & Relay Contacts cleaned.W/900312 Ltr ML20012C4821990-03-12012 March 1990 LER 89-024-01:on 891006,local Power Range Monitor Spike Caused Reactor Scram Signal While in Hot Shutdown.Caused by Design &/Or Mfg Process as Identified by Ge.Detector Placed in Bypass Position & Scram Signal reset.W/900312 Ltr ML20012A0171990-02-23023 February 1990 LER 90-002-00:on 900128,reactor Manually Scrammed Due to Leak of Electrohydraulic Control Sys Fluid.Caused by Lock Nut on Interlock Dump Valve Setting Adjustment Bolt Becoming Unsecured Due to Sys Vibration.Leak stopped.W/900223 Ltr ML20012A0021990-02-23023 February 1990 LER 90-001-00:on 900124,discovered That Daily Instrument Check of Main Stack Flow Rate Monitor Not Performed.Caused by Incomplete Procedure.Operating Shift Surveillance Log Revised to Include Daily Instrument check.W/900223 Ltr ML20012A0841990-02-0707 February 1990 LER 90-001-00:on 900108,HPCI Sys Declared Inoperable During Surveillance Testing When Start Time Exceeded 25 S.Caused by Inadequate Calibr Procedure Which Allowed Setting of 18 S. Ramp Generator & Signal Converter replaced.W/900207 Ltr ML20011F5791990-02-0707 February 1990 LER 89-007-01:on 890411,green Discoloration Discovered in Grease on Stabs of Several Control Fuses in 4 Kv Switchgear. Probably Caused by Incomplete Procedure.Maint Procedure M-054.004 Revised to Include Fuse insp.W/900207 Ltr ML20006A9621990-01-19019 January 1990 LER 89-033-00:on 891220,full Scram Signal Received When Technician Performed Surveillance on APRM D.Caused by Procedural Deficiencies & Inattention to Detail by Technician.Technician counseled.W/900119 Ltr ML19354E0121990-01-17017 January 1990 LER 89-032-00:on 891218,discovered That Weekly Surveillance Test Not Performed within Surveillance Interval.Caused by Inappropriate Action Based on Failure to Follow Procedure. Surveillance Test Coordinator counseled.W/900117 Ltr ML19354E0091990-01-16016 January 1990 LER 89-011-00:on 891213,discovered That Two Surveillance Tests of Turbine Stop & Control Valve Encl Not Performed Per Tech Specs.Caused by Incorrect Std Practice of Surveillance Testing.Programmatic Controls established.W/900116 Ltr ML19354E0101990-01-16016 January 1990 LER 89-015-01:on 890721,while Attempting to Remove Malfunctioning Reactor Pressure Vessel Regulator Set,Bypass & Control Valves Opened,Causing Steam Line Pressure to Increase to 480 Psig.Components replaced.W/900116 Ltr ML19354E0851990-01-11011 January 1990 LER 89-010-00:on 891211,monthly Surveillance Test ST 9.7 Not Performed within Surveillance Interval Established by Tech Spec Table 4.1.1.Caused by Combination of Programmatic Weaknesses.Review performed.W/900111 Ltr ML20005G2451990-01-11011 January 1990 LER 89-016-01:on 890720 & 22,LPRM Detector 4B-40-33 Spiked High,Resulting in Full Reactor Scram Signal While in Cold Shutdown.Caused by Design/Mfg Defect in GE Detector. Detector Placed in Bypass position.W/900111 Ltr ML20005G1901990-01-0808 January 1990 LER 89-009-00:on 891207,HPCI Sys Declared Inoperable When Sys Failed to Start During Pump,Valve & Flow Surveillance Test.Caused by Loose Lock Nut on HPCI Oil Sys Relief Valve. Lead Seal Wire to Be Placed on Valve caps.W/900108 Ltr ML20005F8711990-01-0505 January 1990 LER 89-031-00:on 891206,discovered That Four Agastat Relays Not Properly Secured by Seismic Support Straps.Root Cause Under Investigation & Will Be Reported in Rev to Ler.Support Straps Promptly reconnected.W/900105 Ltr ML20005E3911989-12-26026 December 1989 LER 89-030-00:0n 891126,steam Leak Discovered Coming from Packing on RCIC Injection Check Valve AO-22.Caused by Failure of Valve Stem Packing.Normal Reactor Level Restored & Mods of Valve Will Be pursued.W/891226 Ltr ML20011D2331989-12-18018 December 1989 LER 89-029-00:on 891117,Group III Primary Containment Isolation Sys Actuation Occurred During Refueling Floor Ventilation Exhaust Radiation Monitor Testing.Cause Unknown. Test Procedure to Be revised.W/891218 Ltr ML19332E7081989-12-0606 December 1989 LER 89-028-00:on 891108,review Determined That Standby Gas Treatment Sys Heater Control Relays Unqualified for post-LOCA Radiation Environ & Declared Inoperable.Cause Undetermined.Radiation Shielding installed.W/891206 Ltr ML19332E6331989-11-27027 November 1989 LER 89-007-00:on 891026,reactor Vessel Temp & Reactor Coolant Pressure Not Logged Every 15 Minutes as Required by Tech Spec 4.6.A.2 During Performance Integrated Leak Rate Testing.Caused by Procedure deficiency.W/891127 Ltr ML19332E7591989-11-27027 November 1989 LER 89-008-00:on 891027,primary Containment Isolation Sys Group II & III Isolations Occurred When Spurious Reactor Low Level Signal Sensed by Instruments.Possibly Caused by Air Bubble in Sensing Lines.Line backfilled.W/891127 Ltr ML19332D3401989-11-22022 November 1989 LER 89-006-00:on 891023,during Reactor Temp Adjustment, Reactor High Pressure Scram Occurred.Caused by Improper Planning & Coordination of Multiple Evolutions.Surveillance & Hydrostatic Test revised.W/891122 Ltr ML19332C4931989-11-20020 November 1989 LER 89-005-00:on 891020,reactor Protection Sys Actuation & Primary Containment Isolation Sys Actuation Occurred Due to False High Reactor Pressure Signal & lo-lo Reactor Vessel Level Signal,Respectively.Caused by spike.W/891120 Ltr ML19332C8191989-11-15015 November 1989 LER 89-027-00:on 891016,observation & Logging of Suppression Pool Temp as Required by Tech Spec 4.7.2 Not Met.Caused by Personnel Error.Operations Shift Team counseled.W/891115 Ltr ML19324C4361989-11-0808 November 1989 LER 89-026-00:on 891012,control Room Emergency Ventilation Sys Actuation Occurred Due to Momentary False High Radiation Signal from Control Room Radiation Monitor B.Caused by Sensitivity of Thumbwheel switch.W/891108 Ltr ML19324C1781989-11-0606 November 1989 LER 89-023-00:on 891005,outboard MSIV Ac Solenoid Pilot Valves de-energized,resulting in Expected Closure of Outboard MSIV D & Automatic Reactor Scram.Caused by Incomplete Guidance.Procedure revised.W/891106 Ltr ML19325F1801989-11-0606 November 1989 LER 89-024-00:on 891006,reactor Protection Sys Initiated Full Reactor Scram Signal.Caused by Output Signal for LPRM 40-33A Spiking High.Lprm Detector Placed in Bypass Position & Scram Signal reset.W/891106 Ltr ML19325F1811989-11-0202 November 1989 LER 89-022-00:on 891003,unterminated Lead in Circuit to HPCI Trip Solenoid Rendered HPCI Stop Valve Trip Functions Inoperable.Caused by Leads Loosely Hanging Inside Door Panel.Hanging Leads Secured & Panel inspected.W/891102 Ltr ML19325F1791989-11-0202 November 1989 LER 89-025-00:on 891007,determined That nonsafety-related Bellows Leak Detecting Pressure Switches Installed on Main Steam Relief Valves Could Prevent Opening During Design Basis Condition.Plant Alteration installed.W/891102 Ltr 1993-07-01 Category:TEXT-SAFETY REPORT MONTHYEARML20217K9931999-10-14014 October 1999
[Table view]Safety Evaluation Supporting Amend 234 to License DPR-56 ML20217B4331999-10-0505 October 1999 Safety Evaluation Supporting Amend 233 to License DPR-56 ML20217G3541999-09-30030 September 1999 Monthly Operating Repts for Sept 1999 for Pbaps,Units 2 & 3. with ML20216H7091999-09-24024 September 1999 Safety Evaluation Supporting Amends 229 & 232 to Licenses DPR-44 & DPR-56,respectively ML20212D1281999-09-17017 September 1999 Safety Evaluation Supporting Proposed Alternatives CRR-03, 05,08,09,10 & 11 ML20212A5871999-08-31031 August 1999 Monthly Operating Repts for Aug 1999 for Peach Bottom,Units 2 & 3.With ML20211D5501999-08-23023 August 1999 Safety Evaluation Supporting Amends 228 & 231 to Licenses DPR-44 & DPR-56,respectively ML20212H6311999-08-19019 August 1999 Rev 2 to PECO-COLR-P2C13, COLR for Pbaps,Unit 2,Reload 12 Cycle 13 ML20210N7641999-07-31031 July 1999 Monthly Operating Repts for Jul 1999 for PBAPS Units 2 & 3. with ML20209H1121999-06-30030 June 1999 Monthly Operating Repts for June 1999 for Pbaps,Units 2 & 3. with ML20195H8841999-05-31031 May 1999 Monthly Operating Repts for May 1999 for Pbaps,Units 2 & 3. with ML20206N1661999-04-30030 April 1999 Monthly Operating Repts for Apr 1999 for Pbaps,Units 2 & 3. with ML20206A2921999-04-20020 April 1999 Safety Evaluation Concluding That Proposed Changes to EALs for PBAPS Are Consistent with Guidance in NUMARC/NESP-007 & Identified Deviations Meet Requirements of 10CFR50.47(b)(4) & App E to 10CFR50 ML20205K7411999-04-0707 April 1999 Safety Evaluation Supporting Amends 227 & 230 to Licenses DPR-44 & DPR-56,respectively ML20205P5851999-03-31031 March 1999 Monthly Operating Repts for Mar 1999 for Peach Bottom Units 2 & 3.With ML20207G9971999-02-28028 February 1999 Monthly Operating Repts for Feb 1999 for Peach Bottom Units 2 & 3.With ML20199E3471998-12-31031 December 1998 Monthly Operating Repts for Dec 1998 for Peach Bottom,Units 1 & 2.With ML20205K0381998-12-31031 December 1998 PECO Energy 1998 Annual Rept. with ML20206P1651998-12-31031 December 1998 Fire Protection for Operating Nuclear Power Plants, Section Iii.F, Automatic Fire Detection ML20206D3651998-12-31031 December 1998 1998 PBAPS Annual 10CFR50.59 & Commitment Rev Rept. with ML20206D3591998-12-31031 December 1998 1998 PBAPS Annual 10CFR72.48 Rept. with ML20196G7021998-12-0202 December 1998 SER Authorizing Proposed Alternative to Delay Exam of Reactor Pressure Vessel Shell Circumferential Welds by Two Operating Cycles ML20196E8261998-11-30030 November 1998 Response to NRC RAI Re Reactor Pressure Vessel Structural Integrity at Peach Bottom Units 2 & 3 ML20198B8591998-11-30030 November 1998 Monthly Operating Repts for Nov 1998 for Pbaps,Units 2 & 3. with ML20206R2571998-11-17017 November 1998 PBAPS Graded Exercise Scenario Manual (Sections 1.0 - 5.0) Emergency Preparedness 981117 Scenario P84 ML20198C6751998-11-0505 November 1998 Rev 3 to COLR for PBAPS Unit 3,Reload 11,Cycle 12 ML20195E5341998-10-31031 October 1998 Monthly Operating Repts for Oct 1998 for Pbaps,Units 2 & 3. with ML20155C6071998-10-26026 October 1998 Safety Evaluation Supporting Amend 226 to License DPR-44 ML20155C1681998-10-22022 October 1998 Safety Evaluation Accepting Proposed Alternative Plan for Exam of Reactor Pressure Vessel Shell Longitudinal Welds ML20155H7721998-10-12012 October 1998 Rev 1 to COLR for Peach Bottom Atomic Power Station Unit 2, Reload 12,Cycle 13 ML20154J2401998-10-0505 October 1998 Safety Evaluation Supporting Amends 224 & 228 to Licenses DPR-44 & DPR-56,respectively ML20154H4771998-10-0505 October 1998 Safety Evaluation Supporting Amends 225 & 229 to Licenses DPR-44 & DPR-56,respectively ML20154G6821998-10-0101 October 1998 SER Related to Request for Relief 01A-VRR-1 Re Inservice Testing of Automatic Depressurization Sys Safety Relief Valves at Peach Bottom Atomic Power Station,Units 2 & 3 ML20154G6631998-10-0101 October 1998 Safety Evaluation Supporting Amends 223 & 227 to Licenses DPR-44 & DPR-56,respectively ML20154H5541998-09-30030 September 1998 Monthly Operating Repts for Sept 1998 for Pbaps,Units 2 & 3. with ML20153B9651998-09-14014 September 1998 Safety Evaluation Supporting Amend 9 to License DPR-12 ML20151Y2901998-08-31031 August 1998 Monthly Operating Repts for Aug 1998 for Pbaps,Units 2 & 3. with ML20238F2661998-08-24024 August 1998 Safety Evaluation Supporting Amend 222 to License DPR-44 ML20237B9531998-08-10010 August 1998 Specification for ISI Program Third Interval,Not Including Class Mc,Primary Containment for Bpaps Units 2 & 3 ML20237A7761998-08-10010 August 1998 SER Accepting Licensee Response to NRC Bulleting 95-002, Unexpected Clogging of RHR Pump Strainer While Operating in Suppression Pool Cooling Mode ML20237A5351998-07-31031 July 1998 Monthly Operating Repts for July 1998 for Pbaps,Units 2 & 3 ML20236R8281998-07-15015 July 1998 Safety Evaluation Approving Proposed Alternative (one-time Temporary non-Code Repair) Pursuant to 10CFR50.55a(a)(3) (II) ML20236M3471998-06-30030 June 1998 Monthly Operating Repts for June 1998 for Pbaps,Units 2 & 3 ML20249C4791998-06-0202 June 1998 Rev 6 to COLR for PBAPS Unit 2 Reload 11,Cycle 12 ML20248F4781998-06-0101 June 1998 Corrected Page 1 to SE Supporting Amends 221 & 226 to Licenses DPR-44 & DPR-56,respectively.Original Page 1 of SE Had Three Typos ML20248F7441998-05-31031 May 1998 Reactor Vessel Working Group,Response to RAI Regarding Reactor Pressure Vessel Integrity ML20248M3001998-05-31031 May 1998 Monthly Operating Repts for May 1998 for Pbaps,Units 2 & 3 ML20247N5351998-05-11011 May 1998 SER Accepting Third 10-year Interval Inservice Program for Pump & Valves for Plant,Units 2 & 3 ML20249C4751998-05-0707 May 1998 Rev 5 to COLR for PBAPS Unit 2 Reload 11,Cycle 12 ML20247G0721998-04-30030 April 1998 Monthly Operating Repts for Apr 1998 for Pbaps,Units 2 & 3 1999-09-30 |
Text
w on. A%H S NULLE AH HuiUL AIOhV COMMMMUN l15 Unit 3 LICENSEE EVEN i HEPORI Ite po r t No.
3-79-2h/1T CON HOL DLOCK. l llll'll;.LE ASE PHINT OR TYPE ALL REQUIRED INFOnMATION)
I 6 5 (2 l A l P l B S l3 l@l010l-lO l0l0l0l0l-l0l0l@l4l1l1l1 1 l@!!!@8 9 LICENSEE CODE 14 IS LICENSE NUMutM
/>26 LICENSE TYPE JO
$7 CA T $8
.'N'Tl1 s[R$ M l0 l5 l Ol -l 0l2 l7 8 @l 0 l 81 1 l $ l 7 l9 !@l0l8l2 o I 7 l 9 l@
d 60 61 DOCKET NUMBER 6d bd EVENT 04Tt 74 75 REPORT DATE 80 EVENT DESCRIPTION AND PROBABLE CONSEQUENCES h Inspection program performed in response to IE Bulletin 79-02 identified i 2 3 1 3 of L test failed anchor bolts in one saport en the 3D RHR pump suct-lion piping. During a seicnic event with the failed anchor support the
]4"[Tl [piping system could possibly fail and caase ficoding in one of four RHR lTT) I rocms. Because redundant RER pumps and backup Core Spray System are j i7 lavailable, safety significance is censidered mini"vtl.
[8l_]8 9 80 SYSTEM CAUSE CAUSE COMP VALVE COCE CODE SU8 CODE COMPONENT CODE SUSCCDE SUECODE i9il s lF l@ l Bl@ l C l@ l Si Ul P l 0 lR lT l@ l3 @ [Zj @
8 9 to 11 12 I3 is 19 20 SE GUEN TI AL OCCUHHFNO R 90GT HEVISION LEA /PO EVENT YEAR REPORT NO.
CODE TYPE NO.O at,g";1719 I l-l I 0121 hl d 10111 1Tl L-J 1 01 u_ 21 22 23/4 26 29 2')30 31 32 ACTION CUTUHG EFFECT SH ' 1100 W N ATT ACHMENT NPRC 4 PniME COMP COMPONEN1 TAKEN ACTION ON Pt. AN T VETHOD HOCHS (-SUBMs TT E D FOHM:>UH SUPPi t E R MANUFACTUnEH l A l@l Z l@
lZl@!Z l@l 0] 0 0f_j
[1]@l N l@lAl@l Il 2l 0 l 91@
33 34 35 3G 3#40 41 42 43 44 41 CAUSE DESCRIPTION AND CORRECTIVE ACTIONS o lThe most probable cause of failure was improper installation. The three I yltest failed anchor bolts were replaced with wedre type anchors and I 7lsuccessfully torque tested.
I 11 l 1 ITI I i e 9 e STAR% POWhH OTHER S T A TUS D C e UI'.COV L H Y DE SCHiP TION M lEl@ l0l8l6_j@l U/Al[Dj @ l Work on IE Bulletin 79-02
]'ASTivi ry c$ rt NT
- """"" L:u @ l Z 1 8 1_
iMOuNT OF AC1.v,Tv @ l LUC ATION OF RRE ASE @
aEuAsEn OP nuE ASe N/AlU/A l'-u 9 10 11 44 45 SO rf nsONNr L F x PO'.UHE S N';*A ts F H IYPE DESLHIP TION 10 10 10 !@l Z l@i n/A I i>N 9 il if 33 40 Pt HSONNt L INJUlHE5 g 4-Q g; d
- 1.be.
k'." Nij V 8 E n DESCH PTION i M In lo lo l@l U/A I as.d 9 l'17 UO t.O',5 GB ()H l} A V AGE T ri F At'it.t T Y
.9 99( 5(>-I VPt s li '.CH sP f 6ON 1i [Zj@l N/Al, , H, ,o Puut sti Tv NHC USE UNt Y F SU E n@ot sCniP Tion N/A i' i bd l! I ' I I I I I I ! 1 ;2
" H 9 10 Cg sy y HQ[C77;eY ,ld. J. Cooney (215) 841-5020
, o NAME OF PREPARER PHONE-"
Retrieved from "https://kanterella.com/w/index.php?title=ML19207B865&oldid=1874791"