ML18106A787

Forwards Discharge Monitoring Rept for Sgs, for June 1998. Rept Is Prepared Specifically for EPA & Nj Dept of Environ. Observed Results of Measurements & Analyses Required to Be Performed by Listed Agencies,Presented

ML18106A787
Person / Time
Site:	Salem
Issue date:	07/23/1998
From:	TRUM M J Public Service Enterprise Group
To:	NEW JERSEY, STATE OF
Shared Package
ML18106A788	List: ML18106A787 ML18106A789
References
NUDOCS 9808040259
Download: ML18106A787 (16)

Text

• P*utiiic Se'rvice Electric and Gas Company P.O. Box 236 Hancocks Bridge, New Jersey 08038-0236 Nuclear Business Unit New Jersey Department of Environmental Protection Division of Water Quality Bureau of Permit Management CN029 Tran.ton, NJ 08625-0029 Certified Mail Number P 461 187 838 July 23, 1998 NEW JERSEY POLLUTANT DISCHARGE ELIMINATION SYSTEM DISCHARGE MONITORING REPORTS SALEM GENERATING STATION PERMIT NO. NJ0005622 Attached is the Discharge Monitoring Report for Salem Generating Station containing the information as required in Permit No. NJ0005622 for the month of June, 1998. This report is required by and prepared specifically for the Environmental Protection Agency (EPA) and the New Jersey Department of Environmental Protection (NJDEP). It presents only the observed results of measurements and analyses required to be performed by the above agencies.

The choice of the measurement devices and analytical methods is controlled by EPA and NJDEP, not by ttie company, and there are limitations on the accuracy of such measurement devices and analytical techniques exen when used and maintained as required.

Accordingly, this report is not intended as an assertion that any instrument has measured, or any reading or analytical result represents, the true value with absolute accuracy, nor is it an endorsement of the suitability of any analytical or measurement procedure.

Attachments rtin rum Genera Manager -(Acting) Salem Operations

• 1' NJPDES Report June, 1998 2 C Mr. Gerald M. Hansler -Executive Director USNRC -Document Control Desk Unit#1-50-272 Unit#2-50-311 General Manager -Salem Operations Director-Licensing, Regulation, and Fuels M. Vaskis D. Hurka J. Schloss Central Record Facility E. Keating NJPDES Report Explanation of Deviations June, 1998 The following explanations are included to clarify possible deviations from permit conditions.

General -The columns labeled, "No. Ex. " on the enclosed DMR, tabulate the number of daily discharge values outside the indicated limits. Data reporting and accuracy reflect the working environment, the design capabilities and reliability of the monitoring instruments and operating equipment.

All reported concentrations are based on daily discharge values. Total residual .chlorine is performed three times per week during chlorination unless otherwise indicated.

Analytical values which are less than detectable are reported as zero unless otherwise indicated.

Analytical results for all parameters other than* pH, temperature, TSS, TRC and Bioassay results are provided by Raytheon Environmental Services Laboratory. (NJDEP certification 77373) or South Jersey Testing Laboratory (NJDEP certification 06431). Bioassay results are provided by ENSR Environmental Toxicology Laboratory (NJDEP certification 82888).

• Net negative discharge values are reported as negative.

489C-Flow thru outfall 489 is calculated based on Oil Water Separator Lift Pump run times. 481-486-Chlorination of the circulation water system normally does not occur except as otherwise noted. Service water system chlorination is normally continuous and is monitored on the circulating water system outfall. Chlorination of both systems will be indicated by results reported for both and represents their combined effect upon the circulating water outfall.

NJPDES Report Explanation of Deviations June, 1998 48C -Non-Radioactive Liquid Waste -This system continues to be operated in a batch mode to treat for hydrazine and ammonia by the addition of sodium hypochlorite.

No hydrazine has been discharged from this outfall during the reporting period. Residual chlorine is monitored at the outfalls of DSN's 481, 482, 484, and 485, and has not exceeded the permit limits at these outfalls.

The following excursions are included in the attached report and are explained below. Excursions have not endangered nor significantly impacted public health or the environment.

DSN NO. EXPLANATION 489 See attached 5 Day Report for DSN 489

-... ..,. (

Public Service Electric and Gas Company P.O. Box 236 Hancocks Bridge, New Jersey 08038-0236 Nuclear Business Unit .. CERTIFIED MAIL RETURN RECEIPT REQUESTED

• ARTICLE NUMBER: P 462 770 277 JUN 171998 LR-E980310 Assistant Director of Water and Hazardous Waste Enforcement Division of Enforcement Field Operations New Jersey Department of Environmental Protection 401 East State Street P.O. Box 422 Trenton, New Jersey 08625 To Whom It May Concern: PSE&G SALEM GENERA TING STATION NJPDES PERMIT NO. NJ0005622 DISCHARGE OF OIL -5 DAY REPORT CASE NO. 98-06-12-0758-23 Per NJAC 7: 14A-6.10 1 PSE&G has prepared this report concerning the discharge of approximately 16 ounces of oil. This discharge occurred through the Salem Generating Station oil/water separator (OWS) outfall (DSN 489) to the Delaware River on June 12 1 1998. On June 12, the discharge was discovered and confirmed at 7:45 AM during a routine walkdown of the OWS outfall. An oil sheen of approximately two square feet was observed at DSN 489 in the Delaware River. The OWS system treats stormwater runoff and equipment drains from areas within the Salem Generating Station, including equipment containments, yard drains, and parking areas. An estimated 16 ounces of oil passed through the OWS, untreated, during the rain event which began earty on the morning of June 12. The OWS was taken out of service and sorbent booms were placed around the outfall pipe. The OWS effluent chamber was cleaned, and the fuel oil sheen on the influent chamber was removed from the OWS. " -

.. , . ' NJDEP LR-E980310 *JUN 171998 Because of the small size of the sheen, PSE&G does not believe the discharge posed a threatio human health or the environment.

PSE&G notified the National Response Center at 9:45 AM, and the discharge was assigned Case No. 441283. In addition, PSE&G notified the Nuclear Regulatory Commission pursuant to 10 CFR 50. 72, Significant Events. ' . The exact cause of the discharge is not known at this time. PSE&G has initiated an internal investigation through our Corrective Action Program to determine the root cause of the discharge as well as any additional actions warranted to correct the cause of the discharge.

The results of this investigation will be forwarded to NJDEP within 30 days after completion of the investigation . .. Please contact Don Bowman of my staff at (609) 339-1477 if you have any questions.

Sincerely, David R. Powell Licensing/Regulation

'& Fuels C New Jersey Department of Environmental Protection Bureau of Water and Hazardous Waste Compliance and Enforcement Southern Region One Port Center 2 Riverside Drive, Suite 201 Camden, New Jersey 08103 Attention:

Steven Mathis . -

i ' ' -1.' i NJDEP LR-E980310 DFB/ BC .. General Manager -Salem Operations (S05) Manager-Salem Operations (S01) Chemistry Superintendent

-Salem (S07) Environmental Licensing Manager (N21) J. F. Leopardi (S07)

• M. J. Kubiak (S07) D. K. Hurka (N21) S. F. Kugler (N21)

• E. J. Keating (104) M. F. Vaskis (T5C) Microfilm JUN 1 7 *1998 Nuclear Business Support Records Management (NBS RM -N64) File 2.1.1 (S) . PIRS CLOSED: #980612096 CRCA-01 PIRS OPEN: #980612096 CRCA-02

.

2:59PM TSTNG SERVS 201 761 MAPLEWOOD TESTING SERVICES REPORT TO:

• Dave Hurka Sr. Staff Engineer -Nuclear PSE&G July 17, 1998 Report No. TP98005

SUBJECT:

DETERMINATION OF CIRCULATING WATER FLOW AT SALEM GENERATING STATION-UNIT N0.1 CONDUCTED BY: Joseph Fiumara Sr. Test Engineer, Maplewood Testing Services PURPOSE To determine the flow capacities of the Unit No.1 circulating water pumps.

SUMMARY

On June 23 and 24, 1998 the Mechanical Division of Maplewood Testing Services conducted a series of test runs at Salem Unit No.1 to determine the pump capacities of the 11A, 118, 12A, 128, 13A and *138 {CMS designations H, J, K, M, Land A respectively) circulating water pumps. Final test results are shown in Table 1 and Figure 1. DISCUSSION . Total dynamic head is calculated by subtracting the inlet head from the discharge head in feet of water. The discharge pressure is normally taken on the discharge pipe in close proximity to the pump. At Salem the discharge pressure feeler lines are not functional and the pressure is read at the inlet waterbox.

Therefore, the observed -* *

• discharge pressure is affected by the pressure drop in the pipe leading from the pump. Thls condition causes the total dynamic head to be depressed.

When plotted on the pump curve, the data usually falls well below the curve. P.2

.. 7-20-1998 2:59PM TSTNG SERVS 201 761 *L* Dave Hurka . Sr. Staff Engineer -Nuclear PSE&G TEST METHOD July *11. 1998 Report No.TP98005 The circulating water flow was determined by fluorometry using MTS Mechanical Division Procedure Mech-40 "Determination of Water Flow Using The Turner Fluorometer".

In fluorometry, a dye containing fluorescent particles is injected at a known flow rate sufficiently upstream to insure complete mixing. Dilution of the dye is measured downstream by a fluorometer and the flow is determined as a ratio. Manager Mechanical Division cc F. Todd S. Davies F:\MAG\IP98005\TP98005.DOC Senior Supervising Test Engineer Mechanical Division P.3

... '

2:59PM Pump CMS No. Pump Desig. 11A H 11 B J 12A K 128 M 13A L 136 A TSTNG SERVS 201 761 Table 1 Salem Generating Station Circulating Water Pump Flow Test Maplewood Testing Services Mechanical Division Report Number TP98005

SUMMARY

OF TEST RESULTS Test Measured Pump Date Pump Suction Capacity Head (gpm) (ft h2o) 06/24/98 181,770 -9.3 06/24/98 171,529 -8.5 06/24/98 173,979 -7.6 06/23/98 161,528 -12.9 06/23/98 188,203 -12.5 06/23/98 183,592 -11.7 Pump Discharge Head (ft h2o) 13.7 14.7 15.5 13.3 10.8 14.5 Note: Pump suction heads and discharge heads corrected to elevation 100' P.d Total Dynamic Head (ft h2o) 23.0 23.2 23.1 26.2 23.3 26.2 GSALEM Q'. w 3: u.. a ti w u.. ::r Q.. ::!! ::> a... 0 I-SALEM GENERATING STATION-UNIT N0.1 TOTAL PUMP HEAD VS. CIRCULATING WATER PUMP FLOW D Pum11 H (11A) 'V PumpJ(118) 0 Pump I( (t2AJ

• PumpM(128)

<> Pump L (13A) /),. Pumi>A(13BJ . : : . . , , I . l

... *-* ........... " ...... -*-*-* *-*-* ... *****-*I*

..... '" .. ......... " ........ ***-** .. ,. ... . .........

.; .........

• • .i::;*:*"****

..... ... . ..............

.........

• -:.*:!:::

.. .. 60t---+---;.--;--...,,.,..;---+--.;-----+--;.--.;-----+---;.--.:__--;-

_ _.;, __ .;.-_-;-_-;.

__

• • l i l ---_, ____ , _____ , __ ------1---1--1--

--:-------;

• ,:** ...........

r ...............................

• ..................

t ........ : ............

! ..........

., ........ T ..... .. I I 1 I . . GuAAANrEE P01Nr i .........

..: .........

...........

..........

..: ....................

.........

.. ....... -.........

']" ..............

---.. -------------.........

i ..........

j ...........

..........

! ...... .. ... ***:-*******

--*.::, ..........

• .*,,,*.***********:***********

• • • • • • • • • • ,_*-****-****:,_*** . . . i : ! 1 i i ':'.'IM"':.

ro: i , ' : ! :

.........

+ ... -... + ........ .........

+-* ........ . ......... , ........ r ................... , ........ .. **********:**********-;**********':'"'"'''''' . . ! ! ;

_ __..___....__--1.

__ _.__--1. __ .._ _

_ _,_ __ .__ _ _._ __

0 50 100 PUMP FLOW -1000 GPM FIGURE 1 150 200 PSE..&G Maplewood Tevtin,g Ser.Weg Report NG. TP98005 June 1008

.... .{ '-I I\) (S) I (!) co CP w (S) (S) \J :!:: T] JJ 0

• r 0 0 0 -l (/) -l z C) (/) rn JJ < (/) I\) (S) "' m * \J U1 !

3:00PM TSTNG SERVS 201 761 MAPLEWOOD TES'11NG SERVICES REPORT TO: Dave Hurka Sr. Staff Engineer -Nuclear

• July 17,*1998 Report No. TP98005-A PSE&G

SUBJECT:

RECORD OF RHODAMINE WT DYE INJECTION FOR CIRCULATING WATER FLOW TEST AT SALEM GENERATING STATION -UNIT N0.1 CONDUCTED BY: Joseph Fiumara Sr. Test Engineer, Maplewood Testing Services PURPOSE . . To report the date, time, amount and concentration of Rhodamine VVT dye released to the river while testing at Salem Generating Station -Unit No.1 .

SUMMARY

Listed in Table 1 are the data pertinent to the injection of Rhodamine WT dye at Salem Generating Station -Unit No.1 . . . Testing is complete at this station. Manager Mechanical Division c F Todd S. Davies F:\MAG\TP98005\TP98005.00C Senior Supervising Test Engineer Mechanical Division .: ..

• P.6

. °"Z;:::-20-1998 3:00PM ,. Test Pump Date No. 06/24/98 11A 06/24/96 118 06/24/98 12A 06/23/98 128 06/23/9S:

13A 06/23/98 13B 06/23/98 138 .. ..

TSTNG SERVS 201 761 Table 1 Salem Generating Station Circulating Water Pump Flow Test Maplewood Testing Services Mechanical Division Report No. TP98005-A RECORD OF RHODAMJNE WT INJECTION Injection Pure Number of Total Time Dye Pumps in System Injected Service Flow (start) (stop) (ml) (1000 gpm) 1340 1354 19.55 12 2220.0 1305 1323 24.89 12 2220.0 1038 1052 19.36 12 2220.0 1620 1534: . 19.26 12 2220.0 1540 1554 19.25 12 2220.0 1446 1519 44.95 12 2220.0 1421 1440 25.46 12 2220.0 P. 7 Effluent Concentration (ppb) 0.17 0.16 0.16 0.16 0.16 0.16 0.16

. *

• COUNTY OF SALEM

• STATE OF NEW JERSEY I, Martin J. Trum, of full age, being duly sworn according to law, upon my oath depose and say: 1. I am General Manager (Acting) of Salem Generating Station, and as such, am authorized to sign Discharge Monitoring Reports submitted to the New Jersey Department ofEnvironmental Protection pursuant to the Station's New Jersey Pollutant Discharge Elimination System permit. 2. I have reviewed the attached Discharge Monitoring Reports. Pursuant to NJ. A. C. 7:14A-2.4, I certify under penalty oflaw that I have personally examined and am familiar with the information submitted in this document and all attachments and that based on my inquiry of those individuals responsible for obtaining the information, I believe the submitted information is true, accurate and complete.

I am aware that there are significant penalties for submitting false information including the possibility of fine and imprisonment.

3. The signature on the attached Discharge Monitoring Reports is my signature and I am submitting this affidavit in satisfaction of the requirement that my signature be notarized.

Sworn and subjribed before me this z;2 day 1998 SHERI L. HUSTm!

PUBLIC OF tmfJ JERSr£1* /

Cornmlsslo11 Elplras llac. w 19 qr

.l. T-VWX-014 NEW JERSEY DEPARTMENT OF ENVIR.OMENTAL PROTECTION DIVISION OF WATER QUALITY MONITORING REPORT -TRANSMIIT AL SHEET -. * -NJPDESNO.

IOIOIOl51612121 REPORTING PERIOD Mo.Yr. 101619181 Mo.Yr. 101619181 PERMITI'EE:

Name : Public Service Electric and Gas Company Address: P.O. Box 236 FACILITY:

Name : Salem Nuclear Generating Station Address: Alloway Creek Neck Road Hancock's Bridge Telephone:

(609) 935-6000 FORMS A IT ACHED (Indicate Quantity of Each) SLUDGE REPORT-SANITARY

_Q_T-VWX-007

__Q_T-VWX-008

_Q_T-VWX-009

_Q_EPA FORM3320-l SLUDGE REPORT-INDUSTRIAL

_Q_T-VWX-OlOA

_Q_T-VWX-OlOB WASTEWATER REPORTS _Q_T-VWX:-011

_Q_T-VWX-012

_Q_T-VWX-013 GROUNDWATER REPORTS _Q_ VWX-015(A,B)

_Q_ VWX-016 _Q_ VWX-017 _Q_ELECTRONIC SUBMISSION NJPDI;:S DISCHARGE MONITORING REPORT ll_EPAFORM3320-l Operating Exceptions Yes No DYE TESTING x

• TEMPORARYBYPASSING x DISINFECTION INTERUPTION x MONITORING MALFUNCTIONS x UNITS OF OPERATION x OTHER x (Detail any "Yes" on reverse side in appropriate space) NOTE: The "Hours Attended at Plant" on the reverse of this sheet must also be completed.

AlITHENTICATION I certify under penalty of law that this document and all attachments were prepared under the direction of supervision in accordance with a system designed to assure my inquiry of the person or persons who manage the system or those persons directly responsible for gathering the infonnation, the infonnation submitted is, to the best of my knowledge and belief, true, accurate, and complete.

I am aware that there are significant penalties for submitting false information, including the possibility of fine and imprisorunent for knowing violations.

.. LICENSED OPERATOR Name (Printed)

Michael J. Kubiak Date ;/zz Cfg PRINCIPAL EXECUTIVE OFFICER or DULY AUTHORIZED REPRESENTATIVE Name Title Date ______

I OPERATING EXCEPTIONS DETAILED e Page 2 Maplewood Testing Services performed Rhodamine WT dye injection eesting for Unit 1 circulating water flow test. The date, time, amount, and concentration of Rhodamine dye released to the river during testing is detailed on the attached test report in the cover letter. HOURS ATTENDED AT PLANT Month l..Q_L§_j Year LJ!1]J Day of Month 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Licensed Operator 8 8 8 8 8 0 0 8 8 8 8 8 0 0 8 8 Others 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 Day of Month 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 Licensed Operator 8 8 8 0 0 8 8 8 8 8 0 0 8 8 Others 4 4 -*. 4 4 4 4 4 4 4 4 4 4 4 4