|
---|
Category:NOTICE OF VIOLATION OF A REGULATION
MONTHYEARML20203F1431999-02-10010 February 1999 Notice of Violation from Insp on 981125-990112.Violation Noted:On 981203,quality Control Inspector Failed to Implement Step 5.3(4) of GMP-INST-011,in That Individual Did Not Verify That Profile of Component Lead Was Visible ML20236V6971998-07-28028 July 1998 Notice of Violation from Insp on 980429-0609.Violation Noted:On 980513,licensee Conducted Primary Containment Closeout Insp,Activity Affecting Quality & Failed to Verify That Drywell General Area Was Free of Trash & Tools ML20236U4911998-06-30030 June 1998 Notice of Violation from Insp on 980505-06.Violations Noted: on 980412,licensee Maint Staff Failed to Adequately Document & Reroute Through Affected Departs for Review & Approval,Changes Made in Scope of Work to Listed Request ML20248J4471998-05-29029 May 1998 Notice of Violation from Insp on 980318-0428.Violation Noted:On 980408,STP 42B012-CY,Prerequisite 6.4,was Not Properly Implemented ML20247K3231998-05-12012 May 1998 Notice of Violations from Insp on 980413-0504.Violations Noted:On 980404,licensee Did Not Make Sure Surveys to Assure Compliance w/10CFR20.1902(b),which Describes Posting of High Radiation Areas ML20217L0531998-04-28028 April 1998 Notice of Violation from Insp on 980318-20.Violation Noted: on 980313,Operating Log Did Not Contain Entry for Restoration of Reactor Manual Control Sys to Service After Completion of Mods ML20216G4441998-04-0909 April 1998 Notice of Violation from Insp on 980205-0317.Violation Noted:Between 980210 & 0306,licensee Failed to Follow Administrative Control Procedure 1408.9,Step 3.7(2) ML20202G4541998-02-0606 February 1998 Notice of Violation from Insp on 971223-980204.Violations Noted:Between 960102 & 04,for Total of 58 Hours While Plant in Power Operating Conditions,Containment Isolation Valves CV5704B & CV5718B for Well Water Sys,Inoperable IR 07100111/20120221998-01-0202 January 1998 Notice of Violation from Insp on 971111-1222.Violation Noted:Nrc Identified on 971218,three Individuals Designated as Requiring Annual Respirator Fit Testing Overdue for Training ML20202E9211997-12-0202 December 1997 Notice of Violation from Insp on 970928-1110.Violation Noted:From 970519-1029,inspectors Identified That on Ten Occasions Licensee Failed to Balance Mal at Least Once Per Calendar Day When Work in FME Zone ML20217C5281997-09-22022 September 1997 Notice of Violation from Insp on 970718-0821.Violation Noted:On 970806,inspectors Identified That Licensee Had Not Promptly Corrected Two Loose Emergency Diesel Generator Fuel Oil Pipe Supports,Per Emergency Operating Procedure ML20216B0871997-09-0202 September 1997 Notice of Violation from Insp on 970324-0701.Violation Noted:As of 970425,C/As Taken in Response to Previous Violation Involving Procedure Deficiencies & Cited in Insp Rept 96005,had Not Been Adequate to Preclude Repetition ML20210R3931997-08-15015 August 1997 Notice of Violation from Insp on 970530-0717.Violation Noted:A Standby Diesel Generator Was Inadvertently Made Inoperable Due to Inadequate Procedure for Corrective Maint Activity ML20151J6831997-07-24024 July 1997 Notice of Violation from Insp on 970518-0703.Violation Noted:Licensee Performed Turbine Stop Valve Testing in Abnormal Plant Configuration Without Written Safety Evaluation to Provide Basis That Test Did Not Involve USQ ML20141D7181997-05-0909 May 1997 Notice of Violation from Insp on 970318-0425.Violation Noted:Surveillance Test Procedure Failed to Incorporate Acceptance Limits Contained in Applicable Design Documents ML20137A3581997-03-11011 March 1997 Notice of Violation from Insp on 961220-970203.Violation Noted:From 961124-1218,w/reactor Power at Approx 100% Rated Power,Main Steam Line Radiation Monitors Were Set Greater than 3x Normal Rated Power Background ML20136F6431997-03-0606 March 1997 Notice of Violation from Insp on 970210-14.Violation Noted: Licensee Personnel Failed to Inform Health Physics Personnel Prior to Opening Contaminated Sys ML20134C8901997-01-29029 January 1997 Notice of Violation from Insp on 961025-1220.Violation Noted:On 961105,plant Operators Failed to Obtain Vibration Data as Required by Dcf.Dcf Not Incorporated Into STP ML20134B7911997-01-23023 January 1997 Notice of Violation from Insp on 960907-1105.Violation Noted:W De-Ion Circuit Breakers Type Gm,Rev 1,was Not Appropriate for Circumstance ML20059K4811994-01-19019 January 1994 Notice of Violation from Insp on 930824-1014.Violation Noted:Reactor Operating at Approx 75% Power B Sbdg Became Inoperable & Was Not Restored to Operable Status within 7 Days ML20059K8351993-11-0505 November 1993 Notice of Violation from Insp on 930824-1014.Violation Noted:Licensee Failed to Maintain Adequate Cleanliness in Vicinity of Reactor Vessel,Evident by Tie Wraps & Wood Found in Reactor Cavity ML20059G2431993-11-0202 November 1993 Notice of Violation from Insp on 930907-1001.Violation Noted:Conditions Adverse to Quality Were Not Promptly Corrected When Licensee Identified Inoperable Fire Barriers Between Control Room & Cable Spreading Room on 920929 ML20058P4711993-10-15015 October 1993 Notice of Violation from Insp on 920701-0831.Violation Noted:Licensee Determined That Records Required to Be Maintained by Commission Regulations or License Conditions Not Complete & Accurate in All Matl Respects ML20057E4781993-10-0101 October 1993 Notice of Violation from Insp on 930809-13.Violation Noted: on 930728,two Individuals Entered Posted High Radiation Area in Torus Room W/O Being Provided Radiation Monitoring Device That Continuously Indicated Radiation Dose Rate in Area ML20211G0041987-02-18018 February 1987 Notice of Violation from Insp on 861202-05,09-12,15-18 & 870112-16 1999-02-10
[Table view] Category:TEXT-INSPECTION & AUDIT & I&E CIRCULARS
MONTHYEARIR 05000331/19993021999-10-25025 October 1999 NRC Operator Licensing Exam Rept 50-331/99-302OL(including Completed & Graded Tests) for Tests Administered on 990920- 24.Six Applicants Passed Exam & Were Issed Operating Licenses IR 05000331/19990111999-10-0707 October 1999 Insp Rept 50-331/99-11 on 990820-0930.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000331/19990081999-09-0202 September 1999 Insp Rept 50-331/99-08 on 990712-16 & 0810-12.No Violations Noted.Major Areas Inspected:Radiation Protection & Chemistry Programs IR 05000331/19990091999-08-26026 August 1999 Insp Rept 50-331/99-09 on 990708-0819.Violations Noted.Major Areas Inspected:Licensee Operations,Engineering,Maint & Plant Support IR 05000331/19990101999-08-17017 August 1999 Insp Rept 50-331/99-10 on 990802-06.No Violations Noted. Major Areas Inspected:Review of Emergency Preparedness Program,Aspect of Plant Support IR 05000331/19990051999-07-27027 July 1999 Insp Rept 50-331/99-05 on 990601-0701.Violations Noted.Major Areas Inspected:Engineering,Technical Support & Corrective Actions IR 05000331/19990071999-07-16016 July 1999 Insp Rept 50-331/99-07 on 990526-0707.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000331/19993011999-07-13013 July 1999 NRC Operator Licensing Exam Rept 50-331/99-301OL (Including Completed & Graded Tests) for Tests Administered on 990525. Written Retake Exam Administered by Licensee to One Applicant.Applicant Passed Exam & Issued RO License IR 05000331/19980051999-07-12012 July 1999 Insp Rept 50-331/98-05 on 990622-24.No Violations Noted. Major Areas Inspected:Maint IR 05000331/19990061999-06-25025 June 1999 Insp Rept 50-331/99-06 on 990607-11.No Violations Noted. Major Areas Inspected:Physical Security Program IR 05000331/19990041999-06-0909 June 1999 Insp Rept 50-331/99-04 on 990414-0525.Non-cited Violations Noted.Major Areas Inspected:Operations,Engineering, Maintenance & Plant Support IR 05000331/19990031999-04-23023 April 1999 Insp Rept 50-331/99-03 on 990303-0413.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support PNO-III-99-024, on 990416,licensee Commenced Controlled Power Reduction to Approx 10% to Identify & Repair Main Generator Field Ground.Troubleshooting Efforts Are Still in Progress. Ris Monitored SD & Troubleshooting & Will Review Activities1999-04-19019 April 1999 PNO-III-99-024:on 990416,licensee Commenced Controlled Power Reduction to Approx 10% to Identify & Repair Main Generator Field Ground.Troubleshooting Efforts Are Still in Progress. Ris Monitored SD & Troubleshooting & Will Review Activities IR 05000331/19990011999-03-24024 March 1999 Insp Rept 50-331/99-01 on 990113-0302.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support ML20203F1431999-02-10010 February 1999 Notice of Violation from Insp on 981125-990112.Violation Noted:On 981203,quality Control Inspector Failed to Implement Step 5.3(4) of GMP-INST-011,in That Individual Did Not Verify That Profile of Component Lead Was Visible IR 05000331/19980151999-02-10010 February 1999 Insp Rept 50-331/98-15 on 981125-990112.Violations Noted. Major Areas Inspected:Aspects of Licensees Operations, Engineering,Maint & Plant Support IR 05000331/19990021999-02-0101 February 1999 Insp Rept 50-331/99-02 on 990119-21.No Violations Noted. Major Areas Inspected:Reviewed C/As for Previously Identified Issues from Sys Operational Performance Insp Completed on 970425 IR 05000331/19980211999-01-0505 January 1999 Insp Rept 50-331/98-21 on 981214-17.No Violations Noted. Major Areas Inspected:Licensing Corrective Actions & Engineering Involvement in Corrective Action Process IR 05000331/19980201998-12-29029 December 1998 Licensed Operator Requalification Training Program Insp Rept 50-331/98-20 Conducted on 981204.Exam Results:Two Operating Crews Passed Operating Portion of Exam.One SRO & Two ROs Failed Written Exam IR 05000331/19980191998-12-23023 December 1998 Insp Rept 50-331/98-19 on 981130-1204.No Violations Noted. Major Areas Inspected:Radiation Protection & Chemistry Program IR 05000331/19980141998-12-18018 December 1998 Insp Rept 50-331/98-14 on 981014-1124.No Violations Noted. Major Areas Inspected:Operations,Engineering,Maint & Plant Support IR 05000331/19980181998-12-16016 December 1998 Insp Rept 50-331/98-18 on 981116-20 Onsite & 1208 NRC Region 3 Ofc.No Violations Noted.Major Areas Inspected:Review of Physical Security Program IR 05000331/19980131998-11-12012 November 1998 Insp Rept 50-331/98-13 on 980905-1013.No Violations Noted. Major Areas Inspected:Operations,Maint,Engineering & Plant Support IR 05000331/19980161998-11-0303 November 1998 Emergency Preparedness Exercise Insp Rept 50-331/98-16 on 981020-23.Major Areas inspected:1998 Emergency Preparedness Exercise IR 05000331/19980171998-10-30030 October 1998 Insp Rept 50-331/98-17 on 981013-16.No Violations Noted. Major Areas Inspected:Implementation of Solid Waste Mgt Program & Radioactive Material Shipping Program IR 05000331/19980121998-10-0202 October 1998 Insp Rept 50-331/98-12 on 980730-0904.No Violations Noted. Major Areas Inspected:Operations,Engineering,Maint & Plant Support PNO-III-98-045, on 980914,empty Type B Shipping Cask Received with Removable Contamination Levels of Approx 40,000 Dpm Per 100 Square Centimeters.Licensee Decontaminated Cask1998-09-16016 September 1998 PNO-III-98-045:on 980914,empty Type B Shipping Cask Received with Removable Contamination Levels of Approx 40,000 Dpm Per 100 Square Centimeters.Licensee Decontaminated Cask IR 05000331/19980091998-08-19019 August 1998 Insp Rept 50-331/98-09 on 980610-0729.No Violations Noted. Major Areas Inspected:Aspects of Licensee Operations, Engineering,Maint & Plant Support IR 05000331/19980111998-08-14014 August 1998 Insp Rept 50-331/98-11 on 980803-07.No Violations Noted. Major Areas Inspected:Evaluation of Effectiveness of Aspects of Radiation Protection & Chemistry Program ML20236V6971998-07-28028 July 1998 Notice of Violation from Insp on 980429-0609.Violation Noted:On 980513,licensee Conducted Primary Containment Closeout Insp,Activity Affecting Quality & Failed to Verify That Drywell General Area Was Free of Trash & Tools IR 05000331/19980081998-07-28028 July 1998 Insp Rept 50-331/98-08 on 980429-0609.Violations Noted.Major Areas Inspected:Operations,Maint & Engineering ML20236U4911998-06-30030 June 1998 Notice of Violation from Insp on 980505-06.Violations Noted: on 980412,licensee Maint Staff Failed to Adequately Document & Reroute Through Affected Departs for Review & Approval,Changes Made in Scope of Work to Listed Request ML20236U4931998-06-30030 June 1998 Insp Rept 50-331/98-10 on 980505-06.No Violations Noted. Major Areas Inspected:Maint Activities Related to Grayboot Applications Including Training & Qualifications of Maint Staff to Perform Grayboot Applications ML20248J4471998-05-29029 May 1998 Notice of Violation from Insp on 980318-0428.Violation Noted:On 980408,STP 42B012-CY,Prerequisite 6.4,was Not Properly Implemented IR 05000331/19980041998-05-29029 May 1998 Insp Rept 50-331/98-04 on 980318-0428.Violations Noted.Major Areas Inspected:Operations,Maint & Engineering ML20247K3231998-05-12012 May 1998 Notice of Violations from Insp on 980413-0504.Violations Noted:On 980404,licensee Did Not Make Sure Surveys to Assure Compliance w/10CFR20.1902(b),which Describes Posting of High Radiation Areas IR 05000331/19980071998-05-12012 May 1998 Insp Rept 50-331/98-07 on 980413-0504.Violations Noted. Major Areas Inspected:Review of Radiological Planning & Controls for Work Conducted During Ongoing Refueling Outage Including ALARA Reviews & Outage Dose Trending ML20217L0531998-04-28028 April 1998 Notice of Violation from Insp on 980318-20.Violation Noted: on 980313,Operating Log Did Not Contain Entry for Restoration of Reactor Manual Control Sys to Service After Completion of Mods ML20217L7211998-04-28028 April 1998 Insp Rept 50-331/98-06 on 980318-20.Violations Noted.Major Areas Inspected:Circumstances Surrrounding Removal of Sys from Service,Review of Selected Procedures & Records & Interviews W/Personnel Involved W/Removing Sys from Service ML20216G4541998-04-0909 April 1998 Insp Rept 50-331/98-03 on 980205-0317.Violations Noted.Major Areas Inspected:Operations,Maint,Engineering & Plant Support ML20216G4441998-04-0909 April 1998 Notice of Violation from Insp on 980205-0317.Violation Noted:Between 980210 & 0306,licensee Failed to Follow Administrative Control Procedure 1408.9,Step 3.7(2) ML20202G4541998-02-0606 February 1998 Notice of Violation from Insp on 971223-980204.Violations Noted:Between 960102 & 04,for Total of 58 Hours While Plant in Power Operating Conditions,Containment Isolation Valves CV5704B & CV5718B for Well Water Sys,Inoperable ML20202G4731998-02-0606 February 1998 Insp Rept 50-331/98-02 on 971223-980204.Violations Noted. Major Areas Inspected:Operations,Engineering,Maintenance & Plant Support ML20202E9461998-01-0202 January 1998 Insp Rept 50-331/97-17 on 971111-1222.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Support IR 07100111/20120221998-01-0202 January 1998 Notice of Violation from Insp on 971111-1222.Violation Noted:Nrc Identified on 971218,three Individuals Designated as Requiring Annual Respirator Fit Testing Overdue for Training IR 05000331/19970161997-12-0202 December 1997 Insp Rept 50-331/97-16 on 970928-1110.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Support ML20202E9211997-12-0202 December 1997 Notice of Violation from Insp on 970928-1110.Violation Noted:From 970519-1029,inspectors Identified That on Ten Occasions Licensee Failed to Balance Mal at Least Once Per Calendar Day When Work in FME Zone IR 05000331/19970141997-11-12012 November 1997 Insp Rept 50-331/97-14 on 970822-0927.No Violations Noted. Major Areas Inspected:Licensee Operations,Engineering,Maint & Plant Support IR 05000331/19970011997-11-0505 November 1997 SALP Rept 50-331/97-01 for 951029-970927 IR 05000331/19970121997-09-22022 September 1997 Insp Rept 50-331/97-12 on 970718-0821.Violations Noted. Major Areas Inspected:Operations,Maintenance,Engineering & Plant Status 1999-09-02
[Table view] |
Text
1 NOTICE OF VIOLATION lES Utilities, Inc. Docket No. 50-331 Duane Amold Energy Center License No. DPR-49 During an NRC inspection conducted on February 5 through March 17,1996, a violation of NRC requirements was identified. In accordance with the " General Statement of Policy and Procedure for NRC Enforcement Actions," NUREG-1600, the violation is listed below:
~
10 CFR Part 50, Appendix B, Criterion V," Instructions, Procedures and Drawings," states, in part, that " Activities affecting quality shall be prescribed by documented instructions, procedures, or drawings, of a type appropriate to the circumstances and shall be accomplished in accordance with these instructions, procedures, or drawings."
Administrative Control Procedure 1408.9, " Control of Transient Equipment / Materials," Step 3.7(2),
provides a list of unacceptable plant elements for the restraint of unstable equipment, such as conduit, small bore pipe (less than four inches), heating, ventilation, and air conditioning (HVAC) duct or related hangings, and safety-related equipment.
Contrary to the above, between February 10 and March 6,1998, the licensee failed to follow Administrative Control Procedure 1408.9, Step 3.7(2). Unstable transient equipment / materials were restrained to unacceptable plant elements: a rolling cart was restrained to a conduit in the control room back panel area, panel doors were restrained to a conduit in the reactor recirculation motor generator room, two rolling carts were restrained to control building chiller safety-related piping, two high efficiency particulate air filter units were restrained to HVAC hangers, two carts were restrained to small bore piping in the reactor building, a ladder was restrained to a conduit in the reactor building, and two light bulb boxes and a ladder were restrained to a conduit in the intake structure. 1 This is a Severity Level IV violation (Supplement I).
Pursuant to the provisions of 10 CFR 2.201, Duane Amold Energy Center is hereby required to l submit a written statement or explanation to the U.S. Nuclear Regulatory Commission, ATTN: j Document Control Desk, Washington, D.C. 20555 with a copy to the U.S. Nuclear Regulatory l Commission, Region til,801 Warrenville Road, Lisle, Illinois 60532-4351, and a copy to the NRC Resident inspector at the Duane Arnold Energy Center within 30 days of the date of the letter transmitting this Notice of Violation (Notice). This reply should be clearly marked as a " Reply to a Notice of Violation" and shoula include for each violation: (1) the reason for the violation, or, if contested, the basis for disputing the violation or severity level, (2) the corrective steps that have been taken and the results achieved, (3) the corrective steps that will be taken to avoid further violations, and (4) the date when full compliance will be achieved. Your response may reference or include previously docketed correspondence, if the correspondence adequately addresses the ;
required response. If an adequate reply is not received within the time specified in this Notice, l an order or a Demand for Information may be issued as to why the license should not be l modified, suspended, or revoked, or why such other action as may be proper should not be taken. Where good cause is shown, consideration will be given to extending the response time.
If you contest this enforcement action, you should also provide a copy of your response to the Director, Office of Enforcement, United States Nuclear Regulatory Commission, Washington, l DC 20555-0001. !
9804200355 980409 PDR ADOCK 05000331 G PDR J
Notice of Violation 2-l Because your response will be placed in the NRC Public Document Room (PDR), to the extent l possible, it should not include any personal privacy, proprietary, or safeguards information so that l
~ it can be placed in the PDR without redaction. If personal privacy, or proprietary information is i necessary to provide an acceptable response, then please provide a bracketed copy of your j response that identifies the information that should be protected and a redacted copy of your 4 response that deletes such information. If you request withholding of such material, you mygt !
specifically identify the portions of your response that you seek to have withheld and provide in '
detail the bases for your claim of withholding (e.g., explain why the disclosure of information will create an unwarranted invasion of personal privacy or provide the information required by ;
10 CFR 2.790(b) to support a request for withholding confidential commercial or financial - i
. information). If safeguards information is necessary to provide an acceptable response, please provide the level of protection described in 10 CFR 73.21. :!
i Dated at Lisle, Illinois !
this 9th day of April 1998 !
l l
l l
i l
-l l
l l
4 L
l l
1 l
l
..