Similar Documents at Cook |
|---|
Category:LICENSEE EVENT REPORT (SEE ALSO AO
MONTHYEARML17335A5641999-10-18018 October 1999
LER 99-024-00:on 990708,literal TS Requirements Were Not Met by Accumlator Valve Surveillance.Caused by Misjudgement Made in Conversion from Initial DC Cook TS to W Std Ts.Submitted License Amend Request.With 991018 Ltr
ML17335A5531999-10-0707 October 1999
LER 99-023-00:on 990907,inadequate TS Surveillance Testing of ESW Pump ESF Response Time Noted.Caused by Inadequate Understanding of Plant Design Basis.Surveillance Tests Will Be Revised & Implemented
ML17326A1291999-09-17017 September 1999
LER 99-022-00:on 990609,electrical Bus Degraded Voltage Setpoints Too Low for Safety Related Loads,Was Discovered. Caused by Lack of Understanding of Design of Plant.No Immediate Corrective Actions Necessary
ML17326A1121999-08-27027 August 1999
LER 99-021-00:on 990728,determined That GL 96-01 Test Requirements Were Not Met in Surveillance Tests.Caused by Failure to Understand Full Extent of GL Requirements. Surveillance Procedures Will Be Revised or Developed
ML17326A1011999-08-26026 August 1999
LER 99-020-00:on 990727,EDGs Were Declared Inoperable.Caused by Inadequate Protection of Air Intake,Exhaust & Room Ventilation Structures from Tornado Missile Hazards. Implemented Compensatory Measures in Form of ACs
ML17326A0911999-08-16016 August 1999
LER 99-019-00:on 990716,noted Victoreen Containment Hrrms Not Environmentally Qualified to Withstand post-LOCA Conditions.Caused by Inadequate Design Control.Reviewing Options to Support Hrrms Operability in Modes 1-4
ML17326A0771999-08-0404 August 1999
LER 98-029-01:on 980422,noted That Fuel Handling Area Ventilation Sys Was Inoperable.Caused by Original Design Deficiency.Radiological Analysis for Spent Fuel Handling Accidents in Auxiliary Bldg Will Be Redone by 990830
ML17326A0741999-07-29029 July 1999
LER 99-018-00:on 990629,determined That Valve Yokes May Yield Under Combined Stress of Seismic Event & Static,Valve Closed,Stem Thrust.Caused by Inadequate Design of Associated Movs.Operability Determinations Were Performed for Valves
ML17326A0661999-07-26026 July 1999
LER 99-017-00:on 990625,noted That Improperly Installed Fuel Oil Return Relief Valve Rendered EDG Inoperable.Caused by Personnel Error.Fuel Oil Return Valve Was Replaced with Valve in Correct Orientation.With 990722 Ltr
ML17326A0651999-07-22022 July 1999
LER 98-014-03:on 980310,noted That Response to high-high Containment Pressure Procedure Was Not Consistent with Analysis of Record.Caused by Inadequate Interface with W. FRZ-1 Will Be Revised to Be Consistent with New Analysis
ML17326A0491999-07-13013 July 1999
LER 99-016-00:on 990615,TS Requirements for Source Range Neutron Flux Monitors Not Met.Caused by Failure to Understand Design Basis of Plant.Procedures Revised.With 990713 Ltr
ML17326A0331999-07-0101 July 1999
LER 99-004-01:on 971030,failure to Perform TS Surveillance Analyses of Reactor Coolant Chemistry with Fuel Removed Was Noted.Caused by Ineffective Mgt of Tss.Chemistry Personnel Have Been Instructed on Requirement to Follow TS as Written
ML17326A0151999-06-18018 June 1999
LER 99-014-00:on 990521,determined That Boron Injection Tank Manway Bolts Were Not Included in ISI Program,Creating Missed Exam for Previous ISI Interval.Caused by Programmatic Weakness.Isi Program & Associated ISI Database Modified
ML17325B6311999-06-0101 June 1999
LER 99-S03-00:on 990430,vital Area Barrier Degradation Was Noted.Caused by Inadequate Insp & Maint of Vital Area Barrier.Repairs & Mods Were Made to Barriers to Eliminate Degraded & Nonconforming Conditions
ML17325B6421999-06-0101 June 1999
LER 99-013-00:on 990327,safety Injection & Centrifugal Charging Throttle Valve Cavitation During LOCA Could Have Led to ECCS Pump Failure.Caused by Inadequate Original Design Application of Si.Throttle Valves Will Be Developed
ML17325B6351999-05-28028 May 1999
LER 99-S02-00:on 990428,vulnerability in Safeguard Sys That Could Allow Unauthorized Access to Protected Area Was Noted. Caused by Inadequate Original Plant Design.Mods Were Made to Wall Opening to Eliminate Nonconforming Conditions
ML17265A8231999-05-24024 May 1999
LER 98-037-01:on 990422,determined That Ice Condenser Bypass Leakage Exceeds Design Basis Limit.Caused by Pressure Seal Required by Revised W Design Not Incorporated Into Aep Design.Numerous Matl Condition Walkdowns & Assessments Made
ML17325B6001999-05-20020 May 1999
LER 99-012-00:on 990420,concluded That Auxiliary Bldg ESF Ventilation Sys Not Capable of Maintaining ESF Room Temps post-accident.Caused by Inadequate Control of Sys Design Inputs.Comprehensive Action Plan Being Developed
ML17325B5861999-05-10010 May 1999
LER 99-002-00:on 990415,discovered That TS 4.0.5 Requirements Were Not Met Due to Improperly Performed Test. Caused by Incorrect Interpretation of ASME Code.App J Testing Will Be Completed & Procedures Will Be Revised
ML17325B5811999-05-0404 May 1999
LER 99-011-00:on 990407,air Sys for EDG Will Not Support Long Operability.Caused by Original Design Error.Temporary Mod to Supply Makeup Air Capability in Modes 5 & 6 Was Prepared
ML17325B5771999-05-0303 May 1999
LER 99-010-00:on 990401,RCS Leak Detection Sys Sensitivity Not in Accordance with Design Requirements Occurred.Caused by Inadequate Original Design of Containment Sump Level. Evaluation Will Be Performed to Clearly Define Design
ML17325B5581999-04-16016 April 1999
LER 99-006-00:on 990115,personnel Identified Discrepancy Between TS 3.9.7 Impact Energy Limit & Procedure 12 Ohp 4030.STP.046.Caused by Lack of Design Basis Control.Placed Procedure 12 Ohp 4030.STP.046 on Administrative Hold
ML17325B5471999-04-12012 April 1999
LER 99-009-00:on 990304,as-found RHR Safety Relief Valve Lift Setpoint Greater than TS Limit Occurred.Cause Investigation for Condition Has Not Been Completed.Update to LER Will Be Submitted,Upon Completion of Investigation
ML17325B5321999-04-0707 April 1999
LER 99-S01-00:on 990308,discovered That Lock for Vital Gate Leading to Plant 4KV Switchgear Area Was Nonconforming & Vulnerable to Unauthorized Access.Caused by Inadequate Gate Design & Inadequate Procedures.Mods Are Being Made to Gate
ML17325B5161999-04-0101 April 1999
LER 99-007-00:on 981020,calculations Showed That Divider Barrier Between Upper & Lower Containment Vols Were Overstressed.Engineers Are Currently Working on Analyses of Loads & Stress on Enclosures
ML17325B5221999-03-29029 March 1999
LER 99-001-00:on 960610,degraded Component Cooling Water Flow to Containment Main Steam Line Penetrations,Identified on 990226.Caused by Inadequate Understanding of Design Basis.Additional Investigations Ongoing
ML17325B4801999-03-18018 March 1999
LER 99-004-00:on 971030,failure to Perform TS Surveillance Analyses of Rc Chemistry with Fuel Removed Was Noted.Cause of Event Is Under Investigation.Corrected Written Job Order Activities Used to Control SD Chemistry Sampling
ML17325B4741999-03-18018 March 1999
LER 99-005-00:on 940512,determined That Rt Breaker Manual Actuations During Rod Drop Testing Were Not Previously Reported.Caused by Lack of Training.Addl Corrective Actions,Including Preventative Actions May Be Developed
ML17325B4571999-02-24024 February 1999
LER 99-003-00:on 990107,CR Pressurization Sys Surveillance Test Did Not Test Sys in Normal Operating Condition.Caused by Failure to Recognize Door 12DR-AUX415 as Part of CR Pressure Boundary.Performed Walkdown of Other Doors
ML17335A5171999-02-11011 February 1999
LER 99-002-00:on 990112,determined That RCS Pressurizer PORVs Had Not Been Tested,Per Ts.Caused by Inadequate Scheduling Controls Allowing Personnel Error.Surveillance Procedure Was Completed & Updated LER Will Be Submitted
ML17335A5141999-02-10010 February 1999
LER 99-001-00:on 990106,noted That GE Hfa Relays Installed in EDGs May Not Meet Seismic Qualification.Caused by Operating Experience Info Incorrectly Dispositioned in 1985. Updated LER Will Be Submitted by 990405
ML17335A5011999-02-0101 February 1999
LER 98-060-00:on 981231,identified That Rt Sys Response Time Testing Did Not Comply with TS Definition.Caused by Inadequate Procedures.Corrective Actions Will Be Developed & Update to LER Will Be Submitted by 990415.With 990201 Ltr
ML17335A4951999-01-29029 January 1999
LER 98-059-00:on 981230,interim LER -single Failure in Containment Spray Sys Could Result in Containment Spray Ph Outside Design Occurred.Investigation Into Condition Continuing.Update Will Be Submitted by 990514 Ltr
ML17335A4961999-01-27027 January 1999
LER 98-057-00:on 981228,discovered That AFW Valves Were Not Tested IAW Inservice Testing Program.Caused by Failure to Recognize Design Bases Features Re Afws by Personnel. Updated LER Will Be Submittted by 990415.With 990127 Ltr
ML17335A4921999-01-19019 January 1999
LER 98-052-01:on 981128,no Analysis for NSR Sc Manual Loader for Tdafwp Could Be Found in Original Design.Cause Due to All Failure Modes Not Considered When Compressed Air Sys Originally Designed.Performed Review of Components
ML17335A4721999-01-0606 January 1999
LER 98-055-00:on 981207,potential for Condition Outside of Design Bases for Rod Control Sys Was Noted.Caused by Calibration Error Coupled with Single Rod Failure.Condition Rept Investigation Is Ongoing
ML17335A4691999-01-0606 January 1999
LER 98-056-00:on 981211,hot Leg Nozzle Gaps Resulted in Plant Being in Unanalyzed Condition.Analyses Are Being Performed by W to Resolve Problem.Updated LER Will Be Submitted by 990211.With 990106 Ltr
ML17335A4661999-01-0505 January 1999
LER 98-049-00:on 981020,emergency Boron Injection Flow Path Was Inoperable.Caused by Original Design Deficiency. Engineering Evaluation of Event Is Continuing
ML17335A4631999-01-0404 January 1999
LER 98-054-00:on 981202,discovered That at Least One MSSV Had Not Been Reset as Required by Ts.Engineering Is Continuing Review of Extent of Condition for Event.Updated LER Will Be Submitted by 990129.With 990104 Ltr
ML17335A4481998-12-30030 December 1998
LER 98-053-00:on 981130,discovered Use of Inoperable Substitute Subcooling Margin Monitor.Caused by Condition Existing Since Installation of Plant Process Computer in 1992.Updated LER Will Be Submitted.With 981230 Ltr
ML17335A4581998-12-28028 December 1998
LER 98-052-00:on 981128,turbine Driven AFW Pump Speed Controller Failure Mode Occurred.Caused Because Not All Failure Modes Were Considered When Compressed Air Sys Was Originally Designed.Verified Current Design Change Process
ML17335A4281998-12-22022 December 1998
LER 98-051-00:on 981122,reactor Trip Signal from Manual Safety Injection Not Verified as Required by TS Surveillance,Was Discovered.Maintenance Currently Evaluating Significance & Cause of Event
ML17335A4111998-12-17017 December 1998
LER 98-047-00:on 981117,potential for Increase Leakage from Reactor Coolant Pump Seals Was Identified.Util Is Working with W to Resolve Issue.Current Expectations Are to Submit Update to LER by 990215.With 981217 Ltr
ML17335A4141998-12-16016 December 1998
LER 98-058-00:on 981216,postulated High Line Break Could Result in Condition Outside Design Bases for AF Occurred. Caused by Deficiencies Associated with Administration of HELB Program.Analysis of AF Will Be Completed by 990122
ML17335A4181998-12-16016 December 1998
LER 98-050-00:on 980814,ancillary Equipment Installed in Ice Condenser Was Not Designed to Withstand Design Basis Accident/Earthquake Loads.Caused by Lack of Established Design Criteria.Developed Design Criteria
ML17335A3871998-12-11011 December 1998
LER 98-031-01:on 980610,potential Common Mode Failure of RHR Pumps Were Noted.Caused by Inaccurate Values.Accurate Miniflow Numbers Have Been Determined by Flow Testing
ML17335A3821998-12-0808 December 1998
LER 98-039-01 Re EOP Step Conflicts with Small Break LOCA Analysis.Ler 98-039-00 Has Been Canceled.With 981208 Ltr
ML17335A3781998-12-0707 December 1998
LER 98-007-00:on 981106,high Energy Line Break Effects in Auxiliary FW Sys Was Noted.Cause of Event Is Under Investigation & Will Be Completed by 990220.Updated LER Will Be Submitted by 990310.With 981207 Ltr
ML17335A3771998-12-0303 December 1998
LER 98-046-00:on 981103,determined That Afs Was Unable to Meet Design Flow Requirements During Special Test.Caused by Failure to Consider All Aspects of Sys Operation in Design of Suction Basket Strainers.Sys Will Be Redesigned
ML17335A3741998-12-0202 December 1998
LER 97-011-02:on 970822,operation Was Noted Outside Design Bases for ECCS & CSP for Switchover to Recirculation Sump Suction.Caused by Ineffective Change Mgt.Revised Procedure for Switchover 01(02) Ohp 4023.ES-1.3
1999-09-17
[Table view]
Category:RO)
MONTHYEARML17335A5641999-10-18018 October 1999
LER 99-024-00:on 990708,literal TS Requirements Were Not Met by Accumlator Valve Surveillance.Caused by Misjudgement Made in Conversion from Initial DC Cook TS to W Std Ts.Submitted License Amend Request.With 991018 Ltr
ML17335A5531999-10-0707 October 1999
LER 99-023-00:on 990907,inadequate TS Surveillance Testing of ESW Pump ESF Response Time Noted.Caused by Inadequate Understanding of Plant Design Basis.Surveillance Tests Will Be Revised & Implemented
ML17326A1291999-09-17017 September 1999
LER 99-022-00:on 990609,electrical Bus Degraded Voltage Setpoints Too Low for Safety Related Loads,Was Discovered. Caused by Lack of Understanding of Design of Plant.No Immediate Corrective Actions Necessary
ML17326A1121999-08-27027 August 1999
LER 99-021-00:on 990728,determined That GL 96-01 Test Requirements Were Not Met in Surveillance Tests.Caused by Failure to Understand Full Extent of GL Requirements. Surveillance Procedures Will Be Revised or Developed
ML17326A1011999-08-26026 August 1999
LER 99-020-00:on 990727,EDGs Were Declared Inoperable.Caused by Inadequate Protection of Air Intake,Exhaust & Room Ventilation Structures from Tornado Missile Hazards. Implemented Compensatory Measures in Form of ACs
ML17326A0911999-08-16016 August 1999
LER 99-019-00:on 990716,noted Victoreen Containment Hrrms Not Environmentally Qualified to Withstand post-LOCA Conditions.Caused by Inadequate Design Control.Reviewing Options to Support Hrrms Operability in Modes 1-4
ML17326A0771999-08-0404 August 1999
LER 98-029-01:on 980422,noted That Fuel Handling Area Ventilation Sys Was Inoperable.Caused by Original Design Deficiency.Radiological Analysis for Spent Fuel Handling Accidents in Auxiliary Bldg Will Be Redone by 990830
ML17326A0741999-07-29029 July 1999
LER 99-018-00:on 990629,determined That Valve Yokes May Yield Under Combined Stress of Seismic Event & Static,Valve Closed,Stem Thrust.Caused by Inadequate Design of Associated Movs.Operability Determinations Were Performed for Valves
ML17326A0661999-07-26026 July 1999
LER 99-017-00:on 990625,noted That Improperly Installed Fuel Oil Return Relief Valve Rendered EDG Inoperable.Caused by Personnel Error.Fuel Oil Return Valve Was Replaced with Valve in Correct Orientation.With 990722 Ltr
ML17326A0651999-07-22022 July 1999
LER 98-014-03:on 980310,noted That Response to high-high Containment Pressure Procedure Was Not Consistent with Analysis of Record.Caused by Inadequate Interface with W. FRZ-1 Will Be Revised to Be Consistent with New Analysis
ML17326A0491999-07-13013 July 1999
LER 99-016-00:on 990615,TS Requirements for Source Range Neutron Flux Monitors Not Met.Caused by Failure to Understand Design Basis of Plant.Procedures Revised.With 990713 Ltr
ML17326A0331999-07-0101 July 1999
LER 99-004-01:on 971030,failure to Perform TS Surveillance Analyses of Reactor Coolant Chemistry with Fuel Removed Was Noted.Caused by Ineffective Mgt of Tss.Chemistry Personnel Have Been Instructed on Requirement to Follow TS as Written
ML17326A0151999-06-18018 June 1999
LER 99-014-00:on 990521,determined That Boron Injection Tank Manway Bolts Were Not Included in ISI Program,Creating Missed Exam for Previous ISI Interval.Caused by Programmatic Weakness.Isi Program & Associated ISI Database Modified
ML17325B6311999-06-0101 June 1999
LER 99-S03-00:on 990430,vital Area Barrier Degradation Was Noted.Caused by Inadequate Insp & Maint of Vital Area Barrier.Repairs & Mods Were Made to Barriers to Eliminate Degraded & Nonconforming Conditions
ML17325B6421999-06-0101 June 1999
LER 99-013-00:on 990327,safety Injection & Centrifugal Charging Throttle Valve Cavitation During LOCA Could Have Led to ECCS Pump Failure.Caused by Inadequate Original Design Application of Si.Throttle Valves Will Be Developed
ML17325B6351999-05-28028 May 1999
LER 99-S02-00:on 990428,vulnerability in Safeguard Sys That Could Allow Unauthorized Access to Protected Area Was Noted. Caused by Inadequate Original Plant Design.Mods Were Made to Wall Opening to Eliminate Nonconforming Conditions
ML17265A8231999-05-24024 May 1999
LER 98-037-01:on 990422,determined That Ice Condenser Bypass Leakage Exceeds Design Basis Limit.Caused by Pressure Seal Required by Revised W Design Not Incorporated Into Aep Design.Numerous Matl Condition Walkdowns & Assessments Made
ML17325B6001999-05-20020 May 1999
LER 99-012-00:on 990420,concluded That Auxiliary Bldg ESF Ventilation Sys Not Capable of Maintaining ESF Room Temps post-accident.Caused by Inadequate Control of Sys Design Inputs.Comprehensive Action Plan Being Developed
ML17325B5861999-05-10010 May 1999
LER 99-002-00:on 990415,discovered That TS 4.0.5 Requirements Were Not Met Due to Improperly Performed Test. Caused by Incorrect Interpretation of ASME Code.App J Testing Will Be Completed & Procedures Will Be Revised
ML17325B5811999-05-0404 May 1999
LER 99-011-00:on 990407,air Sys for EDG Will Not Support Long Operability.Caused by Original Design Error.Temporary Mod to Supply Makeup Air Capability in Modes 5 & 6 Was Prepared
ML17325B5771999-05-0303 May 1999
LER 99-010-00:on 990401,RCS Leak Detection Sys Sensitivity Not in Accordance with Design Requirements Occurred.Caused by Inadequate Original Design of Containment Sump Level. Evaluation Will Be Performed to Clearly Define Design
ML17325B5581999-04-16016 April 1999
LER 99-006-00:on 990115,personnel Identified Discrepancy Between TS 3.9.7 Impact Energy Limit & Procedure 12 Ohp 4030.STP.046.Caused by Lack of Design Basis Control.Placed Procedure 12 Ohp 4030.STP.046 on Administrative Hold
ML17325B5471999-04-12012 April 1999
LER 99-009-00:on 990304,as-found RHR Safety Relief Valve Lift Setpoint Greater than TS Limit Occurred.Cause Investigation for Condition Has Not Been Completed.Update to LER Will Be Submitted,Upon Completion of Investigation
ML17325B5321999-04-0707 April 1999
LER 99-S01-00:on 990308,discovered That Lock for Vital Gate Leading to Plant 4KV Switchgear Area Was Nonconforming & Vulnerable to Unauthorized Access.Caused by Inadequate Gate Design & Inadequate Procedures.Mods Are Being Made to Gate
ML17325B5161999-04-0101 April 1999
LER 99-007-00:on 981020,calculations Showed That Divider Barrier Between Upper & Lower Containment Vols Were Overstressed.Engineers Are Currently Working on Analyses of Loads & Stress on Enclosures
ML17325B5221999-03-29029 March 1999
LER 99-001-00:on 960610,degraded Component Cooling Water Flow to Containment Main Steam Line Penetrations,Identified on 990226.Caused by Inadequate Understanding of Design Basis.Additional Investigations Ongoing
ML17325B4801999-03-18018 March 1999
LER 99-004-00:on 971030,failure to Perform TS Surveillance Analyses of Rc Chemistry with Fuel Removed Was Noted.Cause of Event Is Under Investigation.Corrected Written Job Order Activities Used to Control SD Chemistry Sampling
ML17325B4741999-03-18018 March 1999
LER 99-005-00:on 940512,determined That Rt Breaker Manual Actuations During Rod Drop Testing Were Not Previously Reported.Caused by Lack of Training.Addl Corrective Actions,Including Preventative Actions May Be Developed
ML17325B4571999-02-24024 February 1999
LER 99-003-00:on 990107,CR Pressurization Sys Surveillance Test Did Not Test Sys in Normal Operating Condition.Caused by Failure to Recognize Door 12DR-AUX415 as Part of CR Pressure Boundary.Performed Walkdown of Other Doors
ML17335A5171999-02-11011 February 1999
LER 99-002-00:on 990112,determined That RCS Pressurizer PORVs Had Not Been Tested,Per Ts.Caused by Inadequate Scheduling Controls Allowing Personnel Error.Surveillance Procedure Was Completed & Updated LER Will Be Submitted
ML17335A5141999-02-10010 February 1999
LER 99-001-00:on 990106,noted That GE Hfa Relays Installed in EDGs May Not Meet Seismic Qualification.Caused by Operating Experience Info Incorrectly Dispositioned in 1985. Updated LER Will Be Submitted by 990405
ML17335A5011999-02-0101 February 1999
LER 98-060-00:on 981231,identified That Rt Sys Response Time Testing Did Not Comply with TS Definition.Caused by Inadequate Procedures.Corrective Actions Will Be Developed & Update to LER Will Be Submitted by 990415.With 990201 Ltr
ML17335A4951999-01-29029 January 1999
LER 98-059-00:on 981230,interim LER -single Failure in Containment Spray Sys Could Result in Containment Spray Ph Outside Design Occurred.Investigation Into Condition Continuing.Update Will Be Submitted by 990514 Ltr
ML17335A4961999-01-27027 January 1999
LER 98-057-00:on 981228,discovered That AFW Valves Were Not Tested IAW Inservice Testing Program.Caused by Failure to Recognize Design Bases Features Re Afws by Personnel. Updated LER Will Be Submittted by 990415.With 990127 Ltr
ML17335A4921999-01-19019 January 1999
LER 98-052-01:on 981128,no Analysis for NSR Sc Manual Loader for Tdafwp Could Be Found in Original Design.Cause Due to All Failure Modes Not Considered When Compressed Air Sys Originally Designed.Performed Review of Components
ML17335A4721999-01-0606 January 1999
LER 98-055-00:on 981207,potential for Condition Outside of Design Bases for Rod Control Sys Was Noted.Caused by Calibration Error Coupled with Single Rod Failure.Condition Rept Investigation Is Ongoing
ML17335A4691999-01-0606 January 1999
LER 98-056-00:on 981211,hot Leg Nozzle Gaps Resulted in Plant Being in Unanalyzed Condition.Analyses Are Being Performed by W to Resolve Problem.Updated LER Will Be Submitted by 990211.With 990106 Ltr
ML17335A4661999-01-0505 January 1999
LER 98-049-00:on 981020,emergency Boron Injection Flow Path Was Inoperable.Caused by Original Design Deficiency. Engineering Evaluation of Event Is Continuing
ML17335A4631999-01-0404 January 1999
LER 98-054-00:on 981202,discovered That at Least One MSSV Had Not Been Reset as Required by Ts.Engineering Is Continuing Review of Extent of Condition for Event.Updated LER Will Be Submitted by 990129.With 990104 Ltr
ML17335A4481998-12-30030 December 1998
LER 98-053-00:on 981130,discovered Use of Inoperable Substitute Subcooling Margin Monitor.Caused by Condition Existing Since Installation of Plant Process Computer in 1992.Updated LER Will Be Submitted.With 981230 Ltr
ML17335A4581998-12-28028 December 1998
LER 98-052-00:on 981128,turbine Driven AFW Pump Speed Controller Failure Mode Occurred.Caused Because Not All Failure Modes Were Considered When Compressed Air Sys Was Originally Designed.Verified Current Design Change Process
ML17335A4281998-12-22022 December 1998
LER 98-051-00:on 981122,reactor Trip Signal from Manual Safety Injection Not Verified as Required by TS Surveillance,Was Discovered.Maintenance Currently Evaluating Significance & Cause of Event
ML17335A4111998-12-17017 December 1998
LER 98-047-00:on 981117,potential for Increase Leakage from Reactor Coolant Pump Seals Was Identified.Util Is Working with W to Resolve Issue.Current Expectations Are to Submit Update to LER by 990215.With 981217 Ltr
ML17335A4141998-12-16016 December 1998
LER 98-058-00:on 981216,postulated High Line Break Could Result in Condition Outside Design Bases for AF Occurred. Caused by Deficiencies Associated with Administration of HELB Program.Analysis of AF Will Be Completed by 990122
ML17335A4181998-12-16016 December 1998
LER 98-050-00:on 980814,ancillary Equipment Installed in Ice Condenser Was Not Designed to Withstand Design Basis Accident/Earthquake Loads.Caused by Lack of Established Design Criteria.Developed Design Criteria
ML17335A3871998-12-11011 December 1998
LER 98-031-01:on 980610,potential Common Mode Failure of RHR Pumps Were Noted.Caused by Inaccurate Values.Accurate Miniflow Numbers Have Been Determined by Flow Testing
ML17335A3821998-12-0808 December 1998
LER 98-039-01 Re EOP Step Conflicts with Small Break LOCA Analysis.Ler 98-039-00 Has Been Canceled.With 981208 Ltr
ML17335A3781998-12-0707 December 1998
LER 98-007-00:on 981106,high Energy Line Break Effects in Auxiliary FW Sys Was Noted.Cause of Event Is Under Investigation & Will Be Completed by 990220.Updated LER Will Be Submitted by 990310.With 981207 Ltr
ML17335A3771998-12-0303 December 1998
LER 98-046-00:on 981103,determined That Afs Was Unable to Meet Design Flow Requirements During Special Test.Caused by Failure to Consider All Aspects of Sys Operation in Design of Suction Basket Strainers.Sys Will Be Redesigned
ML17335A3741998-12-0202 December 1998
LER 97-011-02:on 970822,operation Was Noted Outside Design Bases for ECCS & CSP for Switchover to Recirculation Sump Suction.Caused by Ineffective Change Mgt.Revised Procedure for Switchover 01(02) Ohp 4023.ES-1.3
1999-09-17
[Table view]
Category:TEXT-SAFETY REPORT
MONTHYEARML17335A5641999-10-18018 October 1999
LER 99-024-00:on 990708,literal TS Requirements Were Not Met by Accumlator Valve Surveillance.Caused by Misjudgement Made in Conversion from Initial DC Cook TS to W Std Ts.Submitted License Amend Request.With 991018 Ltr
ML17335A5531999-10-0707 October 1999
LER 99-023-00:on 990907,inadequate TS Surveillance Testing of ESW Pump ESF Response Time Noted.Caused by Inadequate Understanding of Plant Design Basis.Surveillance Tests Will Be Revised & Implemented
ML17335A5631999-09-30030 September 1999
Monthly Operating Rept for Sept 1999 for DC Cook Nuclear Plant,Unit 1.With 991012 Ltr
ML17335A5621999-09-30030 September 1999
Monthly Operating Rept for Sept 1999 for DC Cook Nuclear Plant,Unit 2.With 991012 Ltr
ML17335A5481999-09-30030 September 1999
Non-proprietary DC Cook Nuclear Plant Units 1 & 2 Mods to Containment Sys W SE (Secl 99-076,Rev 3).
ML17335A5451999-09-28028 September 1999
Rev 1 to Containment Sump Level Design Condition & Failure Effects Analysis for Potential Draindown Scenarios.
ML17326A1291999-09-17017 September 1999
LER 99-022-00:on 990609,electrical Bus Degraded Voltage Setpoints Too Low for Safety Related Loads,Was Discovered. Caused by Lack of Understanding of Design of Plant.No Immediate Corrective Actions Necessary
ML17326A1481999-09-17017 September 1999
Independent Review of Control Rod Insertion Following Cold Leg Lbloca,Dc Cook,Units 1 & 2.
ML17326A1211999-08-31031 August 1999
Monthly Operating Rept for Aug 1999 for Cook Nuclear Plant, Unit 2.With 990915 Ltr
ML17326A1201999-08-31031 August 1999
Monthly Operating Rept for Aug 1999 for Cook Nuclear Plant, Unit 1.With 990915 Ltr
ML17326A1121999-08-27027 August 1999
LER 99-021-00:on 990728,determined That GL 96-01 Test Requirements Were Not Met in Surveillance Tests.Caused by Failure to Understand Full Extent of GL Requirements. Surveillance Procedures Will Be Revised or Developed
ML17326A1011999-08-26026 August 1999
LER 99-020-00:on 990727,EDGs Were Declared Inoperable.Caused by Inadequate Protection of Air Intake,Exhaust & Room Ventilation Structures from Tornado Missile Hazards. Implemented Compensatory Measures in Form of ACs
ML17326A0911999-08-16016 August 1999
LER 99-019-00:on 990716,noted Victoreen Containment Hrrms Not Environmentally Qualified to Withstand post-LOCA Conditions.Caused by Inadequate Design Control.Reviewing Options to Support Hrrms Operability in Modes 1-4
ML17326A0771999-08-0404 August 1999
LER 98-029-01:on 980422,noted That Fuel Handling Area Ventilation Sys Was Inoperable.Caused by Original Design Deficiency.Radiological Analysis for Spent Fuel Handling Accidents in Auxiliary Bldg Will Be Redone by 990830
ML17335A5461999-08-0202 August 1999
Rev 0 to Evaluation of Cook Recirculation Sump Level for Reduced Pump Flow Rates.
ML17326A0871999-07-31031 July 1999
Monthly Operating Rept for July 1999 for DC Cook Nuclear Plant,Unit 1.With 990812 Ltr
ML17326A0861999-07-31031 July 1999
Monthly Operating Rept for July 1999 for DC Cook Nuclear Plant,Units 2.With 990812 Ltr
ML17326A0741999-07-29029 July 1999
LER 99-018-00:on 990629,determined That Valve Yokes May Yield Under Combined Stress of Seismic Event & Static,Valve Closed,Stem Thrust.Caused by Inadequate Design of Associated Movs.Operability Determinations Were Performed for Valves
ML17326A0661999-07-26026 July 1999
LER 99-017-00:on 990625,noted That Improperly Installed Fuel Oil Return Relief Valve Rendered EDG Inoperable.Caused by Personnel Error.Fuel Oil Return Valve Was Replaced with Valve in Correct Orientation.With 990722 Ltr
ML17326A0651999-07-22022 July 1999
LER 98-014-03:on 980310,noted That Response to high-high Containment Pressure Procedure Was Not Consistent with Analysis of Record.Caused by Inadequate Interface with W. FRZ-1 Will Be Revised to Be Consistent with New Analysis
ML17326A0491999-07-13013 July 1999
LER 99-016-00:on 990615,TS Requirements for Source Range Neutron Flux Monitors Not Met.Caused by Failure to Understand Design Basis of Plant.Procedures Revised.With 990713 Ltr
ML17326A0331999-07-0101 July 1999
LER 99-004-01:on 971030,failure to Perform TS Surveillance Analyses of Reactor Coolant Chemistry with Fuel Removed Was Noted.Caused by Ineffective Mgt of Tss.Chemistry Personnel Have Been Instructed on Requirement to Follow TS as Written
ML17326A0511999-06-30030 June 1999
Monthly Operating Rept for June 1999 for DC Cook Nuclear Plant,Unit 2.With 990709 Ltr
ML17326A0501999-06-30030 June 1999
Monthly Operating Rept for June 1999 for DC Cook Nuclear Plant,Unit 1.With 990709 Ltr
ML17326A0151999-06-18018 June 1999
LER 99-014-00:on 990521,determined That Boron Injection Tank Manway Bolts Were Not Included in ISI Program,Creating Missed Exam for Previous ISI Interval.Caused by Programmatic Weakness.Isi Program & Associated ISI Database Modified
ML17325B6421999-06-0101 June 1999
LER 99-013-00:on 990327,safety Injection & Centrifugal Charging Throttle Valve Cavitation During LOCA Could Have Led to ECCS Pump Failure.Caused by Inadequate Original Design Application of Si.Throttle Valves Will Be Developed
ML17325B6311999-06-0101 June 1999
LER 99-S03-00:on 990430,vital Area Barrier Degradation Was Noted.Caused by Inadequate Insp & Maint of Vital Area Barrier.Repairs & Mods Were Made to Barriers to Eliminate Degraded & Nonconforming Conditions
ML17326A0061999-05-31031 May 1999
Monthly Operating Rept for May 1999 for Dcp.With 990609 Ltr
ML17326A0071999-05-31031 May 1999
Monthly Operating Rept for May 1999 for DC Cook Nuclear Plant,Unit 2.With 990609 Ltr
ML17325B6351999-05-28028 May 1999
LER 99-S02-00:on 990428,vulnerability in Safeguard Sys That Could Allow Unauthorized Access to Protected Area Was Noted. Caused by Inadequate Original Plant Design.Mods Were Made to Wall Opening to Eliminate Nonconforming Conditions
ML17265A8231999-05-24024 May 1999
LER 98-037-01:on 990422,determined That Ice Condenser Bypass Leakage Exceeds Design Basis Limit.Caused by Pressure Seal Required by Revised W Design Not Incorporated Into Aep Design.Numerous Matl Condition Walkdowns & Assessments Made
ML17325B6001999-05-20020 May 1999
LER 99-012-00:on 990420,concluded That Auxiliary Bldg ESF Ventilation Sys Not Capable of Maintaining ESF Room Temps post-accident.Caused by Inadequate Control of Sys Design Inputs.Comprehensive Action Plan Being Developed
ML17325B5861999-05-10010 May 1999
LER 99-002-00:on 990415,discovered That TS 4.0.5 Requirements Were Not Met Due to Improperly Performed Test. Caused by Incorrect Interpretation of ASME Code.App J Testing Will Be Completed & Procedures Will Be Revised
ML17325B5811999-05-0404 May 1999
LER 99-011-00:on 990407,air Sys for EDG Will Not Support Long Operability.Caused by Original Design Error.Temporary Mod to Supply Makeup Air Capability in Modes 5 & 6 Was Prepared
ML17325B5771999-05-0303 May 1999
LER 99-010-00:on 990401,RCS Leak Detection Sys Sensitivity Not in Accordance with Design Requirements Occurred.Caused by Inadequate Original Design of Containment Sump Level. Evaluation Will Be Performed to Clearly Define Design
ML17335A5301999-04-30030 April 1999
Monthly Operating Rept for Apr 1999 for DC Cook Nuclear Plant,Unit 1.With 990508 Ltr
ML17335A5291999-04-30030 April 1999
Monthly Operating Rept for Apr 1999 for DC Cook Nuclear Plant,Unit 2.With 990508 Ltr
ML17325B5581999-04-16016 April 1999
LER 99-006-00:on 990115,personnel Identified Discrepancy Between TS 3.9.7 Impact Energy Limit & Procedure 12 Ohp 4030.STP.046.Caused by Lack of Design Basis Control.Placed Procedure 12 Ohp 4030.STP.046 on Administrative Hold
ML17325B5471999-04-12012 April 1999
LER 99-009-00:on 990304,as-found RHR Safety Relief Valve Lift Setpoint Greater than TS Limit Occurred.Cause Investigation for Condition Has Not Been Completed.Update to LER Will Be Submitted,Upon Completion of Investigation
ML17325B5321999-04-0707 April 1999
LER 99-S01-00:on 990308,discovered That Lock for Vital Gate Leading to Plant 4KV Switchgear Area Was Nonconforming & Vulnerable to Unauthorized Access.Caused by Inadequate Gate Design & Inadequate Procedures.Mods Are Being Made to Gate
ML17325B5161999-04-0101 April 1999
LER 99-007-00:on 981020,calculations Showed That Divider Barrier Between Upper & Lower Containment Vols Were Overstressed.Engineers Are Currently Working on Analyses of Loads & Stress on Enclosures
ML17325B5491999-03-31031 March 1999
Monthly Operating Rept for Mar 1999 for DC Cook Nuclear Plant Unit 2.With 990408 Ltr
ML17325B5441999-03-31031 March 1999
Monthly Operating Rept for Mar 1999 for DC Cook Nuclear Plant,Unit 1.With 990408 Ltr
ML17325B5221999-03-29029 March 1999
LER 99-001-00:on 960610,degraded Component Cooling Water Flow to Containment Main Steam Line Penetrations,Identified on 990226.Caused by Inadequate Understanding of Design Basis.Additional Investigations Ongoing
ML17325B4801999-03-18018 March 1999
LER 99-004-00:on 971030,failure to Perform TS Surveillance Analyses of Rc Chemistry with Fuel Removed Was Noted.Cause of Event Is Under Investigation.Corrected Written Job Order Activities Used to Control SD Chemistry Sampling
ML17325B4741999-03-18018 March 1999
LER 99-005-00:on 940512,determined That Rt Breaker Manual Actuations During Rod Drop Testing Were Not Previously Reported.Caused by Lack of Training.Addl Corrective Actions,Including Preventative Actions May Be Developed
ML17325B5671999-03-0202 March 1999
Summary of Unit 1 Steam Generator Layup Chemistry from 980101 to 990218.
ML17325B4631999-02-28028 February 1999
Monthly Operating Rept for Feb 1999 for DC Cook Nuclear Power Station,Unit 2.With 990308 Ltr
ML17325B4621999-02-28028 February 1999
Monthly Operating Rept for Feb 1999 for DC Cook Nuclear Plant,Unit 1.With 990308 Ltr
ML17325B4571999-02-24024 February 1999
LER 99-003-00:on 990107,CR Pressurization Sys Surveillance Test Did Not Test Sys in Normal Operating Condition.Caused by Failure to Recognize Door 12DR-AUX415 as Part of CR Pressure Boundary.Performed Walkdown of Other Doors
1999-09-30
[Table view] |
Text
ACCELERATED DOCUMENTDISTRIBUTION SYSTEMREGULAT+INFORMATION DISTRIBUTIO!YSTEM (RIDE)ACCESSION NBR:9308200131 DOC.DATE:
93/08/13NOTARIZED:
NODOCKET¹FACIL:50-315 DonaldC.CookNuclearPowerPlant,Unit1,IndianaM05000315AUTH.NAMEAUTHORAFFILIATION BREWER,S.J.
IndianaMichiganPowerCo.BLINDFA.A.
IndianaMichiganPowerCo.RECIP.NAME RECIPIENT AFFILIATION
SUBJECT:
LER93-010-01:on 900824,routing ofcableforUnits162notincompliance w/10CFR50,App R.Initiat plantmodifications forcablecompliance.Rev correctserrorinidentified controlroominstrumentation duringfire.W/930813 ltr.DISTRIBUTION CODE:IE22TCOPIESRECEIVED:LTR ENCLSIZE:TITLE:50.73/50.9 LicenseeEventReport(LER),IncidentRpt,etc.NOTES:RECIPIENT IDCODE/NAME PD3-1LADEAN,WINTERNAL:
ACNWAEOD/DSP/TPAB NRR/DE/EELB NRR/DORS/OEAB NRR/DRCH/HICB NRR/DRIL/RPEB R~QSSPLBGFIL02RGN3FILE01COPIESLTTRENCL1111221111111111111111RECIPIENT IDCODE/NAME PD3-1PDAEOD/DOAAEOD/ROAB/DSP NRR/DE/EMEB NRR/DRCH/HHFB NRR/DRCH/HOLB NRR/DRSS/PRPB NRR/DSSA/SRXB RES/DSIR/EIB COPIESLTTRENCL111122111111221111EXTERNALEGGGBRYCEFJ~HNRCPDRNSICPOOREFW~221111LSTLOBBYWARDNSICMURPHY,G.A NUDOCSFULLTXT111111NOTETOALL"RIDS"RECIPIENTS:
PLEASEHELPUSTOREDUCEWASTE!CONTACI'HE DOCUMENTCONTROLDESK,ROOMPl-37(EXT.504-2065)
TOELIMINATE YOURNAMEFROMDISTRIBUTION LISTSFORDOCUMENTS YOUDON'TNEED!FULLTEXTCONVERSION REQUIREDTOTALNUMBEROFCOPIESREQUIRED:
LTTR30ENCL30 I'X IndianaMichiganPowerCompanyCookNuclearPlant~OneCookPlaceBridgman, Ml491066164655901lNDIAMANlCHletAN POWERAugust13,1993UnitedStatesNuclearRegulatory Commission DocumentControlDeskRockville, Maryland20852Operating LicensesDPR-58DocketNo.50-315DocumentControlManager:Inaccordance withthecriteriaestablished by10CFR50.73entitledLicenseeEventReortSstemthefollowing reportisbeingsubmitted:
90-010-01 Sincerely, A.A.BlindPlantManager/sbAttachment c:J.B.Martin,RegionIIIE.E.Fitzpatrick P.A.BarrettR.F.KroegerW.E.Walters-Ft.WayneNRCResidentInspector B.A.Wetzel-NRCM.R.PadgettG.Charnoff, Esp.D.HahnINPOS.J.BrewerB.A.Svensson;-OAi3~f'.9308200i3i 9308i3PDRADOCK050003i58PDR NRCFORM366(569)VS.NUCLEARREGULATORY COMMISSION LICENSEEEVENTREPORTILER)APPROVEDOMBNO.3)504)104 EXPIRES:4I30I92ESTIMATED BURDENPERRESPONSETOCOMPLYWTHTHISINFORMATION COLLECTION REGUESTt50.0HRS.FORWARDCOMMENTSREGARDING BURDENESTIMATETOTHERECORDSANDREPORTSMANAGEMENT BRANCH(Pc)30).U.S.NUCLEARREGULATORY COMMISSION, WASHINGTON, DC20555.ANDTOTHEPAPERWORK REDUCTION PROJECT131500104),
OFFICEOFMANAGEMENT ANDBUDGET,WASHINGTON, DC20503.FACILITYNAMElllD.C.CookNuclearPlant-Unit1DOCKETNUMBER(2)PAE3)o5ooo31510(-05"10CFR50AppendixRDeficiencies Resulting inPotential LossofLocalShutdownIndication PanelFunctionEVENTDATE(SILERNUMBERIS)REPORTDATE(7)OTHERFACILITIES INVOLVED(SlMONTHDAYYEARYEARSEQUENTIAL r..epiNUMBERN'c>NUMSERMONTHOAYYEARFACILITYNAMESD.C.Cook-Unit2DOCKETNUMBERISI 0500031608249090010008139305000OPERATING MODEIS)jth'sxcNCi...Cv':
POWERLEVEL'1ppy'v'0.402()t) 20A05(el(1 (0)20AOSleHI)(Q)20,405(sl(1) liiil20.405(4)(I)(lr)20.405(el(1)(r)20.405(c)
BOM(e)II!50M(e)(2)50.73(el(2) ll)50.73(sl(2)
Iiil50.73ls)(2)liiilLICENSEECONTACTFORTHISLER(12I50.73(ell2)lie)50,'73(s)
(2)(r)50.73(s)(2)lr)I)50.73(~)(2)(xiii)
IA)50.73(eI(2)ls)ill(5)50.73(~Il2)Ix)THISREPORTISSUBMITTED PURSUANT70THERLDUIREMENTB of10cFR(i:IcsrcconrotmtNroitnrfottowinpl Ill73.71(o)73.71(clOTHERISpectiyinApttrectOrlowendinText,Hi)CForm36SAJNAMES.J.Brewer-NuclearSafety,Licensing andAssessment, ManagerTELEPHONE NUMBERAREACODE614223-202COMPLETEONELINEFOREACHCOMPONENT FAILUREDESCRIBED INTHISREPORTl13)CAUSESYSTFMCOMPONENT MANUFAC.TVREREPORTABLE TONPRDSCAUSESYSTEMCOMPONENT MANUFAC.TVREREPORTABLTONPRDS5~8%SKI&SVPPLEMENTAL REPORTEXPECTED(14)YESIifyet,compirteEXPECTEDSVS4IISSIOH DATfiNOABSTRACTILlmitto14IX)tprcrt,i.r.,rppmximetriy fifteensinplrg>>crtyprwn'ttrn imrslIIS)EXPECTEDSUBMISSION DATEIISIMONTHDAYYEARThepurposeoftherevisionistocorrectanerrorintheidentified controlroominstrumentation available duringafireinUnit2firearea29.Therevisionalsoisinresponsetoacommitment inLER50-316f93-005dated-5/20/93.Thecommitment inLER50-316893-005wastorevisethisLERuponre-evaluation oftheAppendixRcompliance strategyforthesub)ectfireareas.OnAugust24,1990,withUnit1operating at100percentpowerandUnit2inModeSix,itwasdiscovered thattheroutingofcableassociated withtheUnit1LocalShutdownIndication (LSI)panelswasnotincompliance with10CFR50AppendixR.OnSeptember 6,1990,i.twassubsequently di.scovered thatasimi.larcondition existedfortheUnit2LSIpanels.Theimmediate corrective actiontakenwasinitiation ofplantmodi.fications tobringthesubjectplantcablingintocompliance with10CFR50AppendixR.Allidentified areasareprovidedwithadequatefiredetection andsuppression tosubstantially mitigatetheimpactofafireonnormalandLSIinstrumentation.
Therefore, thiseventdidnotadverslyimpactthehealthandsafetyofthepublic.NRCFottn365(569)
NRCFORM344A(4$9)U.S.NUCLEARAEGULATOAY COMMISSION LICENSEEEVENTREPORT(LER)TEXTCONTINUATION APPAOVEDOMBNO.S(500(05 EXPIRES:el30N2ESTIMATED BURDENPERRESPONSETOCOMPLYWTHTHISINFORMATION COLLECTION REOUESTI500HRS.FORWARDCOMMENTSREGARDING BURDENESTIMATETOTHERECORDSANDREPORTSMANAGEMENT BRANCHIP430).U.S.NUCLEARREGULATORY COMMISSION.
WASHINGTON, DC20555,ANDTOTHEPAPERWORK REDUCTION PROJECT(3(5041041.
OFFICEOFMANAGEMENT ANDBUDGET,WASHINGTON, OC20503.FACILITYNAME(1)D.C.CookNuclearPlant-Unit1DOCKETNUMBER(2)YEARLERNUMBER(4155GVCNTIAL r(2NVMIIEVISION NVM5OPAGE(3)TEXTlllmoreepecelrrer)o(red.
Ireeeddldorml llRC%%drm35EABI(12)o5ooo315900100102OF05CoditionsPriortoOccurrence Unit1inMode1at100percentRatedThermalPowerUnit2inMode6.DescritionofEventOnAugust24,1990,itwasdiscovered thattheroutingofcablesassociated withtheUnit1LocalShutdownIndication (LSI)panelswasnotincompliance with10CFR50AppendixRrequirements.
Apostulated fireinanyofthreeUnit1fireareascouldhaveresultedinaninability tomaintainpowertotheLSIpanels.The.following describes theanalysisperformed.
Unit1FireAreas40(Zone41),48(Zone55),and49(Zone56).Theareaanalysesperformed identified thatafireinanyoneofthesefireareascouldhaveeliminated boththeUnit1andUnit2powertotheLocalShutdownIndication (LSI)panels.Thediscrepant cableinquestionwascable1-29685G(EIIS/ED-CBL3) whichrunsbetweenpanels1-LSI-6and1-LSI-6X.
Afaultofthiscableduetoafirewouldhaveeliminated theUnit2Alternate feed-totheUnit1LSIpanels.TheUnit1normalpowerfeedtotheLSIpanelswasalreadyassumedlostforafireinanyoftheseareasbecausevariouscablesassociated withtheavailability ofMCC1-ABC-Bwouldhavebeenlost.OnSeptember 6,1990,itwassubsequently discovered thatasimilarcondition existedfortheUnit2LSIpanels.Apostulated fireinoneoftheUnit2fireareascouldhaveresultedinaninability tomaintainpowertotheLSIpanels.Thefollowing describes theanalysisperformed.
Unit2FireArea29(Zones24,25)Theareaanalysesperformed identified-thatafireinFireZone24wouldhavefaultedboththeUnit1andUnit2powertotheLSIpanels.Thediscrepant powersourcetotheUnit2LSIpanelsrunsinFireZone24whichalsocontainstheUnit2normalsourcecable2-12467(EIIS/ED-CBL3).
Although2-12467alsorunsinZone25,1-1936Rdoesnot.FireZones24and25areseparated byathree-hour fire-rated wall.NRCForm344A(509)
NRCFORM35SA)509)ILS.NUCLEARREQULATORY COMMISSION LICENSEEEVENTREPORT(LER)TEXTCONTINUATION APPROVED0MBNO.31504)0>>
EXPIRES:>>/30/92ESTIMATED BURDENPERRESPONSETOCOMPLYWTHTHISINFORMATION COLLECTION REQUEST.'00 HRS.FORWARDCOMMENTSREGARDING BURDENESTIMATETOTHERECORDSANDREPORTSMANAQEMENT BRANCH(P430),U.S.NUCLEARREQULATORY COMMISSION, WASHINQTON, DC20555,ANDTOTHEPAPERWORK REDUCTION PROJECT(3150410i).
OFFICEOFMANAQEMENTANDBUDGET,WASHINQTON,DC20503.FACILITYNAME11)D.C.CookNuclearPlant-Unit1DOCKETNUMBER12)o5ooo315LERNUMBER15)YEAR<~SEQUENTIAL
)~AEVI>>ION>0?3NUM>>II.sW:NUMB>>A90-010-01~AOEC))03oF05TEXT///mor>><<ec>>4r>>r/unrLu>>>>>>~Ar/ICformSr/SAS/(illCauseofEventThecondition wastheresultofinsufficient scopingfor10CFR50AppendixRdesignchanges.Insufficient controlswereinplacetoensurethatnewcablesaddedtotheplantcompliedwith10CFR50AppendixRrequirements.
nalsisofEventThiseventisbeingreportedinaccordance with10CFR50.73 (a)(2)(ii)(B) and10CFR50.73 (a)(2)(ii)(C) inthatthecondition wasoutsidethedesignbasisandnotcoveredbytheplant's.operating andemergency procedures respectively.
Unit1FireAreas40,48and49AnalysisFireArea402OurSafeShutdownSystemAnalysis(SSSA)showsthatforafireinArea40controlroomindications equivalent tothosefoundontheLSIcabinetwouldbelost.Duetocablemisrouting, theLSIpanelindications wouldalsohavebeenlost.Furtherinvestigation revealedthereasonthatthecontrolroomindication wouldhavebeenlostisbecauseoneofthealternate sourcestotheCRIDpanels,theisolimeters, islocatedinthisarea.WhattheSSSAdoesnotshowisthatthepreferred sourcetotheGRIDpanelswouldhavebeenavailable.
Theinverters arelocatedinFireArea41(FireZone42C).Therefore, normalcontrolroomindication ofprocessmonitoring wouldhavebeenavailable forfireinArea40.b.FireAreas48and492Underconservative assumptions oflossoffunctionforanareafire,theSSSAshowsthatforafireinAreas48and49boththecontrolroomandtheLSIpanelindications wouldhavebeenlost.However,FireAreas48and49areprovidedwithadequatesuppression anddetection tosubstantially mitigatetheimpactonnormalandLSIinstrumentation.
NRCForm356A15$9)
NRCFORM388A(889)U.S.NUCLEARREGULATORY COMMISSION LICENSEEEVENTREPORT(LER)TEXTCONTINUATION APPROVEDOMBNO.3)504)08EXPIRES:O)30NQESTIMATED BURDENPERRESPONSETOCOMPLYWTHTHISINFORMATION COLLECTION REQUEST:50J)HRS.FORWARDCOMMENTSREQARDINQ BURDENESTIMATETOTHERECORDSANDREPORTSMANAGEMENT BRANCH(P430).U.S.NUCLEARREGULATORY COMMISSION, WASHINGTON, OC20555,ANDTOTHEPAPERWORK REDUCTION PROJECT(31504104),
OFFICEOFMANAGEMENT ANOBUDGET,WASHINGTON, DC20503.FACILITYNAME(1)D.C.CookNuclearPlant-Unit1DOCKETNUMBER(2)LERNUMBER(8)YEARI))OISSQUSNTIALg~ASVISIQN PAIIUMSII'ANUMSII~AQEI3)TEXTlitmonJOoco*roOIdmd.
usooddldoool HRCFomI388AQJ(17)ooooo31590010-01040"05AnalsisofEventUnit2FireArea29(Zones24and25)Analysis:
AlthoughpowertotheLSIpanelswouldbelostforafireinzone24,necessary controlroomindication wouldstillhavebeenavailable withtheexception ofRCStemperature (RCScoldlegtemperature couldhavebeenderivedindirectly fromtheavailable steamgenerator pressureinstrumentation.
According toourSafeShutdownSystemsAnalysis, afireinFireArea29(Zones24and25)wouldnothaveeliminated processmonitoring indication inthecontrolroomforsteamgenerators 1and4.Thefollowing indication wouldhavebeenavailable intheUnit2controlroom:2-BLP-112 2-BLP-142 2-MPP-210 2-MPP-240 2-M312-NLP-151 or2-NLP-153 2-NPS-121 SG1WaterLevel(normalrange)SG4WaterLevel(normalrange)SG1PressureSG4PressureSourceRangeMonitoring Channel1Pressurizer WaterLevelRCSPressure(widerange)**Subsequent investigation indicates that2-NPS-121 wouldnothavebeenavailable sincethecablefor2-NPS-121 wasunprotected andisalsoroutedthroughzone24.Lossof2-NPS-121 duringapotential fireinzone24couldhavebeencompensated forthroughtheuseofacontingency procedure withintheemergency operating procedures.
Thisprocedure providedfortheuseoftestinstruments connected totheRVLIScabinetinthecontrolroomtoreadRCSpressure.
Controlroomoperators weretrainedontheuseofthisprocedure.
Theseindications couldprovideanindirectmeansofdetermining RCStemperature.
Thisareaisprovidedwithadequatedetection andsuppression tosubstantially mitigatetheimpactonnormalandLSIinstrumentation.
NR0FomI388A(589)
NRCFORM355A(549)U.S.NUCLEARAEGULATOAY COMMISSION LICENSEEEVENTREPORT(LER)TEXTCONTINUATION APPAOVEO0MBNO.31504'105 EXPIRES(tl30/92 ESTIMATED BURDENPERRESPONSETOCOMPLYWTHTHISINFORMATION COLLECTION REQUEST:508)HRS.FORWARDCOMMENTSREGARDING BUADENESTIMATETOTHERECOAOSANDREPORTSMANAGEMENT BRANCH(P4301,U.S.NUCLEARREGULATORY COMMISSION, WASHINGTON, OC20555,ANDTOTHEPAPERWORK AEDUCTION PROJECT(31504)04),
OFFICEOFMANAGEMENT ANOBUDGET.WASHINGTON, DC20503.FACILITYNAME(I)D.C.CookNuclearPlant-Unit1DOCKETNUMBER(2)YEARLERNUMBER(5)ttQVtNTIAL NVMtRRtVI510NNVMtRPAGEIS)TEXTllfmcttSottolttNFdctd,ototddidootl NRCFomlÃ)4'tl(17)05000315900100105oFo5Conclusion Inconclusion, thecondition didnotadversely impactthehealthandsafetyofthepublicduetothefactthatAreas40,48and49ofUnit1andArea29ofUnit2andprovidedwithsuppression anddetection tosubstantially mitigatetheimpactonnormalandLSZinstrumentation.
Also,alargeportionofthestation's normalinstrumentation wouldremainfunctional sincefirespropagate atafiniteratherthancausinganinstantaneous lossoffunctionforanentirearea.Corrective ActionsUnitOneAplantTemporary Modification wasinitiated whichinstalled a1amperefusein1-LSI-6ontheloadsideofthe1>>29685Gcable.Thiswayafireinthefireareasofconcernwouldnoteliminate theabilityofproviding Unit2powertotheLSIpanels.~UktTeeAplantMinorModification wasinitiated toprovideaone-hourfireenclosure (wrapped) aroundConduit2-12467thatexistsinFireZone24.Conduit2-12467wasin10CFR50AppendixRcompliance on9/20/90.Subsequent investigation hasrevealedthatwhenmodifications 2900-B.04 (October5,1990)and12-3053(December 19,1990)werecompleted/installed thesub)ectcablenolongerneededtobewrappedbecausezone24couldnowbecategorized asmeetingAppendixRZIZ.G.1criteriaduetotheinstallation ofadditional instrumentation.
Znaddition, thereissuppression anddetection inthearea.~GeeralOurprogramforensuringcontinued 10CFRSOAppendixRcompliance willberevised.Itisanticipated thatthisrevisionwillbeinplacebyMarch1,1991.FailedComonentIdentification NonePreviousSimilarEvents050"315/90-0083 10CFR50AppendixRdeficiencies resulting inpotential lossofauto-start ofservicewaterpumpsduetoincorrect implementation ofdesignchange.NRCFonll35SA(589)
