Similar Documents at Cook |
|---|
Category:LICENSEE EVENT REPORT (SEE ALSO AO
MONTHYEARML17335A5641999-10-18018 October 1999
LER 99-024-00:on 990708,literal TS Requirements Were Not Met by Accumlator Valve Surveillance.Caused by Misjudgement Made in Conversion from Initial DC Cook TS to W Std Ts.Submitted License Amend Request.With 991018 Ltr
ML17335A5531999-10-0707 October 1999
LER 99-023-00:on 990907,inadequate TS Surveillance Testing of ESW Pump ESF Response Time Noted.Caused by Inadequate Understanding of Plant Design Basis.Surveillance Tests Will Be Revised & Implemented
ML17326A1291999-09-17017 September 1999
LER 99-022-00:on 990609,electrical Bus Degraded Voltage Setpoints Too Low for Safety Related Loads,Was Discovered. Caused by Lack of Understanding of Design of Plant.No Immediate Corrective Actions Necessary
ML17326A1121999-08-27027 August 1999
LER 99-021-00:on 990728,determined That GL 96-01 Test Requirements Were Not Met in Surveillance Tests.Caused by Failure to Understand Full Extent of GL Requirements. Surveillance Procedures Will Be Revised or Developed
ML17326A1011999-08-26026 August 1999
LER 99-020-00:on 990727,EDGs Were Declared Inoperable.Caused by Inadequate Protection of Air Intake,Exhaust & Room Ventilation Structures from Tornado Missile Hazards. Implemented Compensatory Measures in Form of ACs
ML17326A0911999-08-16016 August 1999
LER 99-019-00:on 990716,noted Victoreen Containment Hrrms Not Environmentally Qualified to Withstand post-LOCA Conditions.Caused by Inadequate Design Control.Reviewing Options to Support Hrrms Operability in Modes 1-4
ML17326A0771999-08-0404 August 1999
LER 98-029-01:on 980422,noted That Fuel Handling Area Ventilation Sys Was Inoperable.Caused by Original Design Deficiency.Radiological Analysis for Spent Fuel Handling Accidents in Auxiliary Bldg Will Be Redone by 990830
ML17326A0741999-07-29029 July 1999
LER 99-018-00:on 990629,determined That Valve Yokes May Yield Under Combined Stress of Seismic Event & Static,Valve Closed,Stem Thrust.Caused by Inadequate Design of Associated Movs.Operability Determinations Were Performed for Valves
ML17326A0661999-07-26026 July 1999
LER 99-017-00:on 990625,noted That Improperly Installed Fuel Oil Return Relief Valve Rendered EDG Inoperable.Caused by Personnel Error.Fuel Oil Return Valve Was Replaced with Valve in Correct Orientation.With 990722 Ltr
ML17326A0651999-07-22022 July 1999
LER 98-014-03:on 980310,noted That Response to high-high Containment Pressure Procedure Was Not Consistent with Analysis of Record.Caused by Inadequate Interface with W. FRZ-1 Will Be Revised to Be Consistent with New Analysis
ML17326A0491999-07-13013 July 1999
LER 99-016-00:on 990615,TS Requirements for Source Range Neutron Flux Monitors Not Met.Caused by Failure to Understand Design Basis of Plant.Procedures Revised.With 990713 Ltr
ML17326A0331999-07-0101 July 1999
LER 99-004-01:on 971030,failure to Perform TS Surveillance Analyses of Reactor Coolant Chemistry with Fuel Removed Was Noted.Caused by Ineffective Mgt of Tss.Chemistry Personnel Have Been Instructed on Requirement to Follow TS as Written
ML17326A0151999-06-18018 June 1999
LER 99-014-00:on 990521,determined That Boron Injection Tank Manway Bolts Were Not Included in ISI Program,Creating Missed Exam for Previous ISI Interval.Caused by Programmatic Weakness.Isi Program & Associated ISI Database Modified
ML17325B6311999-06-0101 June 1999
LER 99-S03-00:on 990430,vital Area Barrier Degradation Was Noted.Caused by Inadequate Insp & Maint of Vital Area Barrier.Repairs & Mods Were Made to Barriers to Eliminate Degraded & Nonconforming Conditions
ML17325B6421999-06-0101 June 1999
LER 99-013-00:on 990327,safety Injection & Centrifugal Charging Throttle Valve Cavitation During LOCA Could Have Led to ECCS Pump Failure.Caused by Inadequate Original Design Application of Si.Throttle Valves Will Be Developed
ML17325B6351999-05-28028 May 1999
LER 99-S02-00:on 990428,vulnerability in Safeguard Sys That Could Allow Unauthorized Access to Protected Area Was Noted. Caused by Inadequate Original Plant Design.Mods Were Made to Wall Opening to Eliminate Nonconforming Conditions
ML17265A8231999-05-24024 May 1999
LER 98-037-01:on 990422,determined That Ice Condenser Bypass Leakage Exceeds Design Basis Limit.Caused by Pressure Seal Required by Revised W Design Not Incorporated Into Aep Design.Numerous Matl Condition Walkdowns & Assessments Made
ML17325B6001999-05-20020 May 1999
LER 99-012-00:on 990420,concluded That Auxiliary Bldg ESF Ventilation Sys Not Capable of Maintaining ESF Room Temps post-accident.Caused by Inadequate Control of Sys Design Inputs.Comprehensive Action Plan Being Developed
ML17325B5861999-05-10010 May 1999
LER 99-002-00:on 990415,discovered That TS 4.0.5 Requirements Were Not Met Due to Improperly Performed Test. Caused by Incorrect Interpretation of ASME Code.App J Testing Will Be Completed & Procedures Will Be Revised
ML17325B5811999-05-0404 May 1999
LER 99-011-00:on 990407,air Sys for EDG Will Not Support Long Operability.Caused by Original Design Error.Temporary Mod to Supply Makeup Air Capability in Modes 5 & 6 Was Prepared
ML17325B5771999-05-0303 May 1999
LER 99-010-00:on 990401,RCS Leak Detection Sys Sensitivity Not in Accordance with Design Requirements Occurred.Caused by Inadequate Original Design of Containment Sump Level. Evaluation Will Be Performed to Clearly Define Design
ML17325B5581999-04-16016 April 1999
LER 99-006-00:on 990115,personnel Identified Discrepancy Between TS 3.9.7 Impact Energy Limit & Procedure 12 Ohp 4030.STP.046.Caused by Lack of Design Basis Control.Placed Procedure 12 Ohp 4030.STP.046 on Administrative Hold
ML17325B5471999-04-12012 April 1999
LER 99-009-00:on 990304,as-found RHR Safety Relief Valve Lift Setpoint Greater than TS Limit Occurred.Cause Investigation for Condition Has Not Been Completed.Update to LER Will Be Submitted,Upon Completion of Investigation
ML17325B5321999-04-0707 April 1999
LER 99-S01-00:on 990308,discovered That Lock for Vital Gate Leading to Plant 4KV Switchgear Area Was Nonconforming & Vulnerable to Unauthorized Access.Caused by Inadequate Gate Design & Inadequate Procedures.Mods Are Being Made to Gate
ML17325B5161999-04-0101 April 1999
LER 99-007-00:on 981020,calculations Showed That Divider Barrier Between Upper & Lower Containment Vols Were Overstressed.Engineers Are Currently Working on Analyses of Loads & Stress on Enclosures
ML17325B5221999-03-29029 March 1999
LER 99-001-00:on 960610,degraded Component Cooling Water Flow to Containment Main Steam Line Penetrations,Identified on 990226.Caused by Inadequate Understanding of Design Basis.Additional Investigations Ongoing
ML17325B4801999-03-18018 March 1999
LER 99-004-00:on 971030,failure to Perform TS Surveillance Analyses of Rc Chemistry with Fuel Removed Was Noted.Cause of Event Is Under Investigation.Corrected Written Job Order Activities Used to Control SD Chemistry Sampling
ML17325B4741999-03-18018 March 1999
LER 99-005-00:on 940512,determined That Rt Breaker Manual Actuations During Rod Drop Testing Were Not Previously Reported.Caused by Lack of Training.Addl Corrective Actions,Including Preventative Actions May Be Developed
ML17325B4571999-02-24024 February 1999
LER 99-003-00:on 990107,CR Pressurization Sys Surveillance Test Did Not Test Sys in Normal Operating Condition.Caused by Failure to Recognize Door 12DR-AUX415 as Part of CR Pressure Boundary.Performed Walkdown of Other Doors
ML17335A5171999-02-11011 February 1999
LER 99-002-00:on 990112,determined That RCS Pressurizer PORVs Had Not Been Tested,Per Ts.Caused by Inadequate Scheduling Controls Allowing Personnel Error.Surveillance Procedure Was Completed & Updated LER Will Be Submitted
ML17335A5141999-02-10010 February 1999
LER 99-001-00:on 990106,noted That GE Hfa Relays Installed in EDGs May Not Meet Seismic Qualification.Caused by Operating Experience Info Incorrectly Dispositioned in 1985. Updated LER Will Be Submitted by 990405
ML17335A5011999-02-0101 February 1999
LER 98-060-00:on 981231,identified That Rt Sys Response Time Testing Did Not Comply with TS Definition.Caused by Inadequate Procedures.Corrective Actions Will Be Developed & Update to LER Will Be Submitted by 990415.With 990201 Ltr
ML17335A4951999-01-29029 January 1999
LER 98-059-00:on 981230,interim LER -single Failure in Containment Spray Sys Could Result in Containment Spray Ph Outside Design Occurred.Investigation Into Condition Continuing.Update Will Be Submitted by 990514 Ltr
ML17335A4961999-01-27027 January 1999
LER 98-057-00:on 981228,discovered That AFW Valves Were Not Tested IAW Inservice Testing Program.Caused by Failure to Recognize Design Bases Features Re Afws by Personnel. Updated LER Will Be Submittted by 990415.With 990127 Ltr
ML17335A4921999-01-19019 January 1999
LER 98-052-01:on 981128,no Analysis for NSR Sc Manual Loader for Tdafwp Could Be Found in Original Design.Cause Due to All Failure Modes Not Considered When Compressed Air Sys Originally Designed.Performed Review of Components
ML17335A4721999-01-0606 January 1999
LER 98-055-00:on 981207,potential for Condition Outside of Design Bases for Rod Control Sys Was Noted.Caused by Calibration Error Coupled with Single Rod Failure.Condition Rept Investigation Is Ongoing
ML17335A4691999-01-0606 January 1999
LER 98-056-00:on 981211,hot Leg Nozzle Gaps Resulted in Plant Being in Unanalyzed Condition.Analyses Are Being Performed by W to Resolve Problem.Updated LER Will Be Submitted by 990211.With 990106 Ltr
ML17335A4661999-01-0505 January 1999
LER 98-049-00:on 981020,emergency Boron Injection Flow Path Was Inoperable.Caused by Original Design Deficiency. Engineering Evaluation of Event Is Continuing
ML17335A4631999-01-0404 January 1999
LER 98-054-00:on 981202,discovered That at Least One MSSV Had Not Been Reset as Required by Ts.Engineering Is Continuing Review of Extent of Condition for Event.Updated LER Will Be Submitted by 990129.With 990104 Ltr
ML17335A4481998-12-30030 December 1998
LER 98-053-00:on 981130,discovered Use of Inoperable Substitute Subcooling Margin Monitor.Caused by Condition Existing Since Installation of Plant Process Computer in 1992.Updated LER Will Be Submitted.With 981230 Ltr
ML17335A4581998-12-28028 December 1998
LER 98-052-00:on 981128,turbine Driven AFW Pump Speed Controller Failure Mode Occurred.Caused Because Not All Failure Modes Were Considered When Compressed Air Sys Was Originally Designed.Verified Current Design Change Process
ML17335A4281998-12-22022 December 1998
LER 98-051-00:on 981122,reactor Trip Signal from Manual Safety Injection Not Verified as Required by TS Surveillance,Was Discovered.Maintenance Currently Evaluating Significance & Cause of Event
ML17335A4111998-12-17017 December 1998
LER 98-047-00:on 981117,potential for Increase Leakage from Reactor Coolant Pump Seals Was Identified.Util Is Working with W to Resolve Issue.Current Expectations Are to Submit Update to LER by 990215.With 981217 Ltr
ML17335A4141998-12-16016 December 1998
LER 98-058-00:on 981216,postulated High Line Break Could Result in Condition Outside Design Bases for AF Occurred. Caused by Deficiencies Associated with Administration of HELB Program.Analysis of AF Will Be Completed by 990122
ML17335A4181998-12-16016 December 1998
LER 98-050-00:on 980814,ancillary Equipment Installed in Ice Condenser Was Not Designed to Withstand Design Basis Accident/Earthquake Loads.Caused by Lack of Established Design Criteria.Developed Design Criteria
ML17335A3871998-12-11011 December 1998
LER 98-031-01:on 980610,potential Common Mode Failure of RHR Pumps Were Noted.Caused by Inaccurate Values.Accurate Miniflow Numbers Have Been Determined by Flow Testing
ML17335A3821998-12-0808 December 1998
LER 98-039-01 Re EOP Step Conflicts with Small Break LOCA Analysis.Ler 98-039-00 Has Been Canceled.With 981208 Ltr
ML17335A3781998-12-0707 December 1998
LER 98-007-00:on 981106,high Energy Line Break Effects in Auxiliary FW Sys Was Noted.Cause of Event Is Under Investigation & Will Be Completed by 990220.Updated LER Will Be Submitted by 990310.With 981207 Ltr
ML17335A3771998-12-0303 December 1998
LER 98-046-00:on 981103,determined That Afs Was Unable to Meet Design Flow Requirements During Special Test.Caused by Failure to Consider All Aspects of Sys Operation in Design of Suction Basket Strainers.Sys Will Be Redesigned
ML17335A3741998-12-0202 December 1998
LER 97-011-02:on 970822,operation Was Noted Outside Design Bases for ECCS & CSP for Switchover to Recirculation Sump Suction.Caused by Ineffective Change Mgt.Revised Procedure for Switchover 01(02) Ohp 4023.ES-1.3
1999-09-17
[Table view]
Category:RO)
MONTHYEARML17335A5641999-10-18018 October 1999
LER 99-024-00:on 990708,literal TS Requirements Were Not Met by Accumlator Valve Surveillance.Caused by Misjudgement Made in Conversion from Initial DC Cook TS to W Std Ts.Submitted License Amend Request.With 991018 Ltr
ML17335A5531999-10-0707 October 1999
LER 99-023-00:on 990907,inadequate TS Surveillance Testing of ESW Pump ESF Response Time Noted.Caused by Inadequate Understanding of Plant Design Basis.Surveillance Tests Will Be Revised & Implemented
ML17326A1291999-09-17017 September 1999
LER 99-022-00:on 990609,electrical Bus Degraded Voltage Setpoints Too Low for Safety Related Loads,Was Discovered. Caused by Lack of Understanding of Design of Plant.No Immediate Corrective Actions Necessary
ML17326A1121999-08-27027 August 1999
LER 99-021-00:on 990728,determined That GL 96-01 Test Requirements Were Not Met in Surveillance Tests.Caused by Failure to Understand Full Extent of GL Requirements. Surveillance Procedures Will Be Revised or Developed
ML17326A1011999-08-26026 August 1999
LER 99-020-00:on 990727,EDGs Were Declared Inoperable.Caused by Inadequate Protection of Air Intake,Exhaust & Room Ventilation Structures from Tornado Missile Hazards. Implemented Compensatory Measures in Form of ACs
ML17326A0911999-08-16016 August 1999
LER 99-019-00:on 990716,noted Victoreen Containment Hrrms Not Environmentally Qualified to Withstand post-LOCA Conditions.Caused by Inadequate Design Control.Reviewing Options to Support Hrrms Operability in Modes 1-4
ML17326A0771999-08-0404 August 1999
LER 98-029-01:on 980422,noted That Fuel Handling Area Ventilation Sys Was Inoperable.Caused by Original Design Deficiency.Radiological Analysis for Spent Fuel Handling Accidents in Auxiliary Bldg Will Be Redone by 990830
ML17326A0741999-07-29029 July 1999
LER 99-018-00:on 990629,determined That Valve Yokes May Yield Under Combined Stress of Seismic Event & Static,Valve Closed,Stem Thrust.Caused by Inadequate Design of Associated Movs.Operability Determinations Were Performed for Valves
ML17326A0661999-07-26026 July 1999
LER 99-017-00:on 990625,noted That Improperly Installed Fuel Oil Return Relief Valve Rendered EDG Inoperable.Caused by Personnel Error.Fuel Oil Return Valve Was Replaced with Valve in Correct Orientation.With 990722 Ltr
ML17326A0651999-07-22022 July 1999
LER 98-014-03:on 980310,noted That Response to high-high Containment Pressure Procedure Was Not Consistent with Analysis of Record.Caused by Inadequate Interface with W. FRZ-1 Will Be Revised to Be Consistent with New Analysis
ML17326A0491999-07-13013 July 1999
LER 99-016-00:on 990615,TS Requirements for Source Range Neutron Flux Monitors Not Met.Caused by Failure to Understand Design Basis of Plant.Procedures Revised.With 990713 Ltr
ML17326A0331999-07-0101 July 1999
LER 99-004-01:on 971030,failure to Perform TS Surveillance Analyses of Reactor Coolant Chemistry with Fuel Removed Was Noted.Caused by Ineffective Mgt of Tss.Chemistry Personnel Have Been Instructed on Requirement to Follow TS as Written
ML17326A0151999-06-18018 June 1999
LER 99-014-00:on 990521,determined That Boron Injection Tank Manway Bolts Were Not Included in ISI Program,Creating Missed Exam for Previous ISI Interval.Caused by Programmatic Weakness.Isi Program & Associated ISI Database Modified
ML17325B6311999-06-0101 June 1999
LER 99-S03-00:on 990430,vital Area Barrier Degradation Was Noted.Caused by Inadequate Insp & Maint of Vital Area Barrier.Repairs & Mods Were Made to Barriers to Eliminate Degraded & Nonconforming Conditions
ML17325B6421999-06-0101 June 1999
LER 99-013-00:on 990327,safety Injection & Centrifugal Charging Throttle Valve Cavitation During LOCA Could Have Led to ECCS Pump Failure.Caused by Inadequate Original Design Application of Si.Throttle Valves Will Be Developed
ML17325B6351999-05-28028 May 1999
LER 99-S02-00:on 990428,vulnerability in Safeguard Sys That Could Allow Unauthorized Access to Protected Area Was Noted. Caused by Inadequate Original Plant Design.Mods Were Made to Wall Opening to Eliminate Nonconforming Conditions
ML17265A8231999-05-24024 May 1999
LER 98-037-01:on 990422,determined That Ice Condenser Bypass Leakage Exceeds Design Basis Limit.Caused by Pressure Seal Required by Revised W Design Not Incorporated Into Aep Design.Numerous Matl Condition Walkdowns & Assessments Made
ML17325B6001999-05-20020 May 1999
LER 99-012-00:on 990420,concluded That Auxiliary Bldg ESF Ventilation Sys Not Capable of Maintaining ESF Room Temps post-accident.Caused by Inadequate Control of Sys Design Inputs.Comprehensive Action Plan Being Developed
ML17325B5861999-05-10010 May 1999
LER 99-002-00:on 990415,discovered That TS 4.0.5 Requirements Were Not Met Due to Improperly Performed Test. Caused by Incorrect Interpretation of ASME Code.App J Testing Will Be Completed & Procedures Will Be Revised
ML17325B5811999-05-0404 May 1999
LER 99-011-00:on 990407,air Sys for EDG Will Not Support Long Operability.Caused by Original Design Error.Temporary Mod to Supply Makeup Air Capability in Modes 5 & 6 Was Prepared
ML17325B5771999-05-0303 May 1999
LER 99-010-00:on 990401,RCS Leak Detection Sys Sensitivity Not in Accordance with Design Requirements Occurred.Caused by Inadequate Original Design of Containment Sump Level. Evaluation Will Be Performed to Clearly Define Design
ML17325B5581999-04-16016 April 1999
LER 99-006-00:on 990115,personnel Identified Discrepancy Between TS 3.9.7 Impact Energy Limit & Procedure 12 Ohp 4030.STP.046.Caused by Lack of Design Basis Control.Placed Procedure 12 Ohp 4030.STP.046 on Administrative Hold
ML17325B5471999-04-12012 April 1999
LER 99-009-00:on 990304,as-found RHR Safety Relief Valve Lift Setpoint Greater than TS Limit Occurred.Cause Investigation for Condition Has Not Been Completed.Update to LER Will Be Submitted,Upon Completion of Investigation
ML17325B5321999-04-0707 April 1999
LER 99-S01-00:on 990308,discovered That Lock for Vital Gate Leading to Plant 4KV Switchgear Area Was Nonconforming & Vulnerable to Unauthorized Access.Caused by Inadequate Gate Design & Inadequate Procedures.Mods Are Being Made to Gate
ML17325B5161999-04-0101 April 1999
LER 99-007-00:on 981020,calculations Showed That Divider Barrier Between Upper & Lower Containment Vols Were Overstressed.Engineers Are Currently Working on Analyses of Loads & Stress on Enclosures
ML17325B5221999-03-29029 March 1999
LER 99-001-00:on 960610,degraded Component Cooling Water Flow to Containment Main Steam Line Penetrations,Identified on 990226.Caused by Inadequate Understanding of Design Basis.Additional Investigations Ongoing
ML17325B4801999-03-18018 March 1999
LER 99-004-00:on 971030,failure to Perform TS Surveillance Analyses of Rc Chemistry with Fuel Removed Was Noted.Cause of Event Is Under Investigation.Corrected Written Job Order Activities Used to Control SD Chemistry Sampling
ML17325B4741999-03-18018 March 1999
LER 99-005-00:on 940512,determined That Rt Breaker Manual Actuations During Rod Drop Testing Were Not Previously Reported.Caused by Lack of Training.Addl Corrective Actions,Including Preventative Actions May Be Developed
ML17325B4571999-02-24024 February 1999
LER 99-003-00:on 990107,CR Pressurization Sys Surveillance Test Did Not Test Sys in Normal Operating Condition.Caused by Failure to Recognize Door 12DR-AUX415 as Part of CR Pressure Boundary.Performed Walkdown of Other Doors
ML17335A5171999-02-11011 February 1999
LER 99-002-00:on 990112,determined That RCS Pressurizer PORVs Had Not Been Tested,Per Ts.Caused by Inadequate Scheduling Controls Allowing Personnel Error.Surveillance Procedure Was Completed & Updated LER Will Be Submitted
ML17335A5141999-02-10010 February 1999
LER 99-001-00:on 990106,noted That GE Hfa Relays Installed in EDGs May Not Meet Seismic Qualification.Caused by Operating Experience Info Incorrectly Dispositioned in 1985. Updated LER Will Be Submitted by 990405
ML17335A5011999-02-0101 February 1999
LER 98-060-00:on 981231,identified That Rt Sys Response Time Testing Did Not Comply with TS Definition.Caused by Inadequate Procedures.Corrective Actions Will Be Developed & Update to LER Will Be Submitted by 990415.With 990201 Ltr
ML17335A4951999-01-29029 January 1999
LER 98-059-00:on 981230,interim LER -single Failure in Containment Spray Sys Could Result in Containment Spray Ph Outside Design Occurred.Investigation Into Condition Continuing.Update Will Be Submitted by 990514 Ltr
ML17335A4961999-01-27027 January 1999
LER 98-057-00:on 981228,discovered That AFW Valves Were Not Tested IAW Inservice Testing Program.Caused by Failure to Recognize Design Bases Features Re Afws by Personnel. Updated LER Will Be Submittted by 990415.With 990127 Ltr
ML17335A4921999-01-19019 January 1999
LER 98-052-01:on 981128,no Analysis for NSR Sc Manual Loader for Tdafwp Could Be Found in Original Design.Cause Due to All Failure Modes Not Considered When Compressed Air Sys Originally Designed.Performed Review of Components
ML17335A4721999-01-0606 January 1999
LER 98-055-00:on 981207,potential for Condition Outside of Design Bases for Rod Control Sys Was Noted.Caused by Calibration Error Coupled with Single Rod Failure.Condition Rept Investigation Is Ongoing
ML17335A4691999-01-0606 January 1999
LER 98-056-00:on 981211,hot Leg Nozzle Gaps Resulted in Plant Being in Unanalyzed Condition.Analyses Are Being Performed by W to Resolve Problem.Updated LER Will Be Submitted by 990211.With 990106 Ltr
ML17335A4661999-01-0505 January 1999
LER 98-049-00:on 981020,emergency Boron Injection Flow Path Was Inoperable.Caused by Original Design Deficiency. Engineering Evaluation of Event Is Continuing
ML17335A4631999-01-0404 January 1999
LER 98-054-00:on 981202,discovered That at Least One MSSV Had Not Been Reset as Required by Ts.Engineering Is Continuing Review of Extent of Condition for Event.Updated LER Will Be Submitted by 990129.With 990104 Ltr
ML17335A4481998-12-30030 December 1998
LER 98-053-00:on 981130,discovered Use of Inoperable Substitute Subcooling Margin Monitor.Caused by Condition Existing Since Installation of Plant Process Computer in 1992.Updated LER Will Be Submitted.With 981230 Ltr
ML17335A4581998-12-28028 December 1998
LER 98-052-00:on 981128,turbine Driven AFW Pump Speed Controller Failure Mode Occurred.Caused Because Not All Failure Modes Were Considered When Compressed Air Sys Was Originally Designed.Verified Current Design Change Process
ML17335A4281998-12-22022 December 1998
LER 98-051-00:on 981122,reactor Trip Signal from Manual Safety Injection Not Verified as Required by TS Surveillance,Was Discovered.Maintenance Currently Evaluating Significance & Cause of Event
ML17335A4111998-12-17017 December 1998
LER 98-047-00:on 981117,potential for Increase Leakage from Reactor Coolant Pump Seals Was Identified.Util Is Working with W to Resolve Issue.Current Expectations Are to Submit Update to LER by 990215.With 981217 Ltr
ML17335A4141998-12-16016 December 1998
LER 98-058-00:on 981216,postulated High Line Break Could Result in Condition Outside Design Bases for AF Occurred. Caused by Deficiencies Associated with Administration of HELB Program.Analysis of AF Will Be Completed by 990122
ML17335A4181998-12-16016 December 1998
LER 98-050-00:on 980814,ancillary Equipment Installed in Ice Condenser Was Not Designed to Withstand Design Basis Accident/Earthquake Loads.Caused by Lack of Established Design Criteria.Developed Design Criteria
ML17335A3871998-12-11011 December 1998
LER 98-031-01:on 980610,potential Common Mode Failure of RHR Pumps Were Noted.Caused by Inaccurate Values.Accurate Miniflow Numbers Have Been Determined by Flow Testing
ML17335A3821998-12-0808 December 1998
LER 98-039-01 Re EOP Step Conflicts with Small Break LOCA Analysis.Ler 98-039-00 Has Been Canceled.With 981208 Ltr
ML17335A3781998-12-0707 December 1998
LER 98-007-00:on 981106,high Energy Line Break Effects in Auxiliary FW Sys Was Noted.Cause of Event Is Under Investigation & Will Be Completed by 990220.Updated LER Will Be Submitted by 990310.With 981207 Ltr
ML17335A3771998-12-0303 December 1998
LER 98-046-00:on 981103,determined That Afs Was Unable to Meet Design Flow Requirements During Special Test.Caused by Failure to Consider All Aspects of Sys Operation in Design of Suction Basket Strainers.Sys Will Be Redesigned
ML17335A3741998-12-0202 December 1998
LER 97-011-02:on 970822,operation Was Noted Outside Design Bases for ECCS & CSP for Switchover to Recirculation Sump Suction.Caused by Ineffective Change Mgt.Revised Procedure for Switchover 01(02) Ohp 4023.ES-1.3
1999-09-17
[Table view]
Category:TEXT-SAFETY REPORT
MONTHYEARML17335A5641999-10-18018 October 1999
LER 99-024-00:on 990708,literal TS Requirements Were Not Met by Accumlator Valve Surveillance.Caused by Misjudgement Made in Conversion from Initial DC Cook TS to W Std Ts.Submitted License Amend Request.With 991018 Ltr
ML17335A5531999-10-0707 October 1999
LER 99-023-00:on 990907,inadequate TS Surveillance Testing of ESW Pump ESF Response Time Noted.Caused by Inadequate Understanding of Plant Design Basis.Surveillance Tests Will Be Revised & Implemented
ML17335A5631999-09-30030 September 1999
Monthly Operating Rept for Sept 1999 for DC Cook Nuclear Plant,Unit 1.With 991012 Ltr
ML17335A5621999-09-30030 September 1999
Monthly Operating Rept for Sept 1999 for DC Cook Nuclear Plant,Unit 2.With 991012 Ltr
ML17335A5481999-09-30030 September 1999
Non-proprietary DC Cook Nuclear Plant Units 1 & 2 Mods to Containment Sys W SE (Secl 99-076,Rev 3).
ML17335A5451999-09-28028 September 1999
Rev 1 to Containment Sump Level Design Condition & Failure Effects Analysis for Potential Draindown Scenarios.
ML17326A1291999-09-17017 September 1999
LER 99-022-00:on 990609,electrical Bus Degraded Voltage Setpoints Too Low for Safety Related Loads,Was Discovered. Caused by Lack of Understanding of Design of Plant.No Immediate Corrective Actions Necessary
ML17326A1481999-09-17017 September 1999
Independent Review of Control Rod Insertion Following Cold Leg Lbloca,Dc Cook,Units 1 & 2.
ML17326A1211999-08-31031 August 1999
Monthly Operating Rept for Aug 1999 for Cook Nuclear Plant, Unit 2.With 990915 Ltr
ML17326A1201999-08-31031 August 1999
Monthly Operating Rept for Aug 1999 for Cook Nuclear Plant, Unit 1.With 990915 Ltr
ML17326A1121999-08-27027 August 1999
LER 99-021-00:on 990728,determined That GL 96-01 Test Requirements Were Not Met in Surveillance Tests.Caused by Failure to Understand Full Extent of GL Requirements. Surveillance Procedures Will Be Revised or Developed
ML17326A1011999-08-26026 August 1999
LER 99-020-00:on 990727,EDGs Were Declared Inoperable.Caused by Inadequate Protection of Air Intake,Exhaust & Room Ventilation Structures from Tornado Missile Hazards. Implemented Compensatory Measures in Form of ACs
ML17326A0911999-08-16016 August 1999
LER 99-019-00:on 990716,noted Victoreen Containment Hrrms Not Environmentally Qualified to Withstand post-LOCA Conditions.Caused by Inadequate Design Control.Reviewing Options to Support Hrrms Operability in Modes 1-4
ML17326A0771999-08-0404 August 1999
LER 98-029-01:on 980422,noted That Fuel Handling Area Ventilation Sys Was Inoperable.Caused by Original Design Deficiency.Radiological Analysis for Spent Fuel Handling Accidents in Auxiliary Bldg Will Be Redone by 990830
ML17335A5461999-08-0202 August 1999
Rev 0 to Evaluation of Cook Recirculation Sump Level for Reduced Pump Flow Rates.
ML17326A0871999-07-31031 July 1999
Monthly Operating Rept for July 1999 for DC Cook Nuclear Plant,Unit 1.With 990812 Ltr
ML17326A0861999-07-31031 July 1999
Monthly Operating Rept for July 1999 for DC Cook Nuclear Plant,Units 2.With 990812 Ltr
ML17326A0741999-07-29029 July 1999
LER 99-018-00:on 990629,determined That Valve Yokes May Yield Under Combined Stress of Seismic Event & Static,Valve Closed,Stem Thrust.Caused by Inadequate Design of Associated Movs.Operability Determinations Were Performed for Valves
ML17326A0661999-07-26026 July 1999
LER 99-017-00:on 990625,noted That Improperly Installed Fuel Oil Return Relief Valve Rendered EDG Inoperable.Caused by Personnel Error.Fuel Oil Return Valve Was Replaced with Valve in Correct Orientation.With 990722 Ltr
ML17326A0651999-07-22022 July 1999
LER 98-014-03:on 980310,noted That Response to high-high Containment Pressure Procedure Was Not Consistent with Analysis of Record.Caused by Inadequate Interface with W. FRZ-1 Will Be Revised to Be Consistent with New Analysis
ML17326A0491999-07-13013 July 1999
LER 99-016-00:on 990615,TS Requirements for Source Range Neutron Flux Monitors Not Met.Caused by Failure to Understand Design Basis of Plant.Procedures Revised.With 990713 Ltr
ML17326A0331999-07-0101 July 1999
LER 99-004-01:on 971030,failure to Perform TS Surveillance Analyses of Reactor Coolant Chemistry with Fuel Removed Was Noted.Caused by Ineffective Mgt of Tss.Chemistry Personnel Have Been Instructed on Requirement to Follow TS as Written
ML17326A0511999-06-30030 June 1999
Monthly Operating Rept for June 1999 for DC Cook Nuclear Plant,Unit 2.With 990709 Ltr
ML17326A0501999-06-30030 June 1999
Monthly Operating Rept for June 1999 for DC Cook Nuclear Plant,Unit 1.With 990709 Ltr
ML17326A0151999-06-18018 June 1999
LER 99-014-00:on 990521,determined That Boron Injection Tank Manway Bolts Were Not Included in ISI Program,Creating Missed Exam for Previous ISI Interval.Caused by Programmatic Weakness.Isi Program & Associated ISI Database Modified
ML17325B6421999-06-0101 June 1999
LER 99-013-00:on 990327,safety Injection & Centrifugal Charging Throttle Valve Cavitation During LOCA Could Have Led to ECCS Pump Failure.Caused by Inadequate Original Design Application of Si.Throttle Valves Will Be Developed
ML17325B6311999-06-0101 June 1999
LER 99-S03-00:on 990430,vital Area Barrier Degradation Was Noted.Caused by Inadequate Insp & Maint of Vital Area Barrier.Repairs & Mods Were Made to Barriers to Eliminate Degraded & Nonconforming Conditions
ML17326A0061999-05-31031 May 1999
Monthly Operating Rept for May 1999 for Dcp.With 990609 Ltr
ML17326A0071999-05-31031 May 1999
Monthly Operating Rept for May 1999 for DC Cook Nuclear Plant,Unit 2.With 990609 Ltr
ML17325B6351999-05-28028 May 1999
LER 99-S02-00:on 990428,vulnerability in Safeguard Sys That Could Allow Unauthorized Access to Protected Area Was Noted. Caused by Inadequate Original Plant Design.Mods Were Made to Wall Opening to Eliminate Nonconforming Conditions
ML17265A8231999-05-24024 May 1999
LER 98-037-01:on 990422,determined That Ice Condenser Bypass Leakage Exceeds Design Basis Limit.Caused by Pressure Seal Required by Revised W Design Not Incorporated Into Aep Design.Numerous Matl Condition Walkdowns & Assessments Made
ML17325B6001999-05-20020 May 1999
LER 99-012-00:on 990420,concluded That Auxiliary Bldg ESF Ventilation Sys Not Capable of Maintaining ESF Room Temps post-accident.Caused by Inadequate Control of Sys Design Inputs.Comprehensive Action Plan Being Developed
ML17325B5861999-05-10010 May 1999
LER 99-002-00:on 990415,discovered That TS 4.0.5 Requirements Were Not Met Due to Improperly Performed Test. Caused by Incorrect Interpretation of ASME Code.App J Testing Will Be Completed & Procedures Will Be Revised
ML17325B5811999-05-0404 May 1999
LER 99-011-00:on 990407,air Sys for EDG Will Not Support Long Operability.Caused by Original Design Error.Temporary Mod to Supply Makeup Air Capability in Modes 5 & 6 Was Prepared
ML17325B5771999-05-0303 May 1999
LER 99-010-00:on 990401,RCS Leak Detection Sys Sensitivity Not in Accordance with Design Requirements Occurred.Caused by Inadequate Original Design of Containment Sump Level. Evaluation Will Be Performed to Clearly Define Design
ML17335A5301999-04-30030 April 1999
Monthly Operating Rept for Apr 1999 for DC Cook Nuclear Plant,Unit 1.With 990508 Ltr
ML17335A5291999-04-30030 April 1999
Monthly Operating Rept for Apr 1999 for DC Cook Nuclear Plant,Unit 2.With 990508 Ltr
ML17325B5581999-04-16016 April 1999
LER 99-006-00:on 990115,personnel Identified Discrepancy Between TS 3.9.7 Impact Energy Limit & Procedure 12 Ohp 4030.STP.046.Caused by Lack of Design Basis Control.Placed Procedure 12 Ohp 4030.STP.046 on Administrative Hold
ML17325B5471999-04-12012 April 1999
LER 99-009-00:on 990304,as-found RHR Safety Relief Valve Lift Setpoint Greater than TS Limit Occurred.Cause Investigation for Condition Has Not Been Completed.Update to LER Will Be Submitted,Upon Completion of Investigation
ML17325B5321999-04-0707 April 1999
LER 99-S01-00:on 990308,discovered That Lock for Vital Gate Leading to Plant 4KV Switchgear Area Was Nonconforming & Vulnerable to Unauthorized Access.Caused by Inadequate Gate Design & Inadequate Procedures.Mods Are Being Made to Gate
ML17325B5161999-04-0101 April 1999
LER 99-007-00:on 981020,calculations Showed That Divider Barrier Between Upper & Lower Containment Vols Were Overstressed.Engineers Are Currently Working on Analyses of Loads & Stress on Enclosures
ML17325B5491999-03-31031 March 1999
Monthly Operating Rept for Mar 1999 for DC Cook Nuclear Plant Unit 2.With 990408 Ltr
ML17325B5441999-03-31031 March 1999
Monthly Operating Rept for Mar 1999 for DC Cook Nuclear Plant,Unit 1.With 990408 Ltr
ML17325B5221999-03-29029 March 1999
LER 99-001-00:on 960610,degraded Component Cooling Water Flow to Containment Main Steam Line Penetrations,Identified on 990226.Caused by Inadequate Understanding of Design Basis.Additional Investigations Ongoing
ML17325B4801999-03-18018 March 1999
LER 99-004-00:on 971030,failure to Perform TS Surveillance Analyses of Rc Chemistry with Fuel Removed Was Noted.Cause of Event Is Under Investigation.Corrected Written Job Order Activities Used to Control SD Chemistry Sampling
ML17325B4741999-03-18018 March 1999
LER 99-005-00:on 940512,determined That Rt Breaker Manual Actuations During Rod Drop Testing Were Not Previously Reported.Caused by Lack of Training.Addl Corrective Actions,Including Preventative Actions May Be Developed
ML17325B5671999-03-0202 March 1999
Summary of Unit 1 Steam Generator Layup Chemistry from 980101 to 990218.
ML17325B4631999-02-28028 February 1999
Monthly Operating Rept for Feb 1999 for DC Cook Nuclear Power Station,Unit 2.With 990308 Ltr
ML17325B4621999-02-28028 February 1999
Monthly Operating Rept for Feb 1999 for DC Cook Nuclear Plant,Unit 1.With 990308 Ltr
ML17325B4571999-02-24024 February 1999
LER 99-003-00:on 990107,CR Pressurization Sys Surveillance Test Did Not Test Sys in Normal Operating Condition.Caused by Failure to Recognize Door 12DR-AUX415 as Part of CR Pressure Boundary.Performed Walkdown of Other Doors
1999-09-30
[Table view] |
Text
ACCELERATED DI~UBUTION DEMONS~TION SYSTEM V
REGULATORY INFORMATION DISTRIBUTION SYSTEM (RIDS)
ACCESSION NBR:9111210148 DOC.DATE: 91/11/15 NOTARIZED: NO DOCKET FACIL:50-315 Donald C. Cook Nuclear Power Plant, Unit 1, Indiana M 05000315 AUTH. NAME AUTHOR AFFILIATION WOJCIK,J.T. Indiana- Michigan Power Co. (formerly Indiana & Michigan Ele BLIND,A.A. -
Indiana Michigan Power Co. (formerly Indiana & Michigan Ele RECIP.NAME RECIPIENT AFFILIATION
SUBJECT:
LER 91-010-00:on 911016,sampled but unmonitored liquid release occurred when liquid radwaste effluent header sample D gamma radiation detector went into alarm. Caused by poor human factors. Enhancements made to procedure.W/911115 ltr.
DISTRIBUTION CODE: IE22T COPIES RECEIVED:LTR ENCL SIZE:
TITLE: 50.73/50.9 Licensee Event Report (LER), ncident Rpt, etc.
A NOTES RECIPIENT COPIES RECIPIENT COPIES D ID CODE/NAME LTTR ENCL ID CODE/NAME LTTR ENCL PD3-1 LA 1 1 PD3-1 PD 1 1 D COLBURN,T. 1 1 INTERNAL: ACNW 2 2 AEOD/DOA 1 1 AEOD/DSP/TPAB 1 1 AEOD/ROAB/DS P 2 2 NRR/DET/ECMB 9H 1 1 NRR/DET/EMEB 7E 1 1 NRR/DLPQ/LHFB10 1 1 NRR/DLPQ/LPE B 1 0 1 1 NRR/DOEA/OEAB 1 1 NRR/DREP/PRPBll 2 2 NRR/DST/SELB SD 1 1 NRR/DST/SICBSH3 1 1 PLBSD1 1 1 NRR/DST/SRXB SE 1 1 G FILE 02 1 1 RES/DSIR/EIB 1 1 RGN3 FILE 01 1 1 EXTERNAL: EG&G BRYCE,J.H 3 3 L ST LOBBY WARD 1 1 NRC PDR 1 1 NSIC MURPHY,G.A 1 1 NSIC POORE,W. 1 1 NUDOCS FULL TXT 1 1 D
D D
NOTE TO ALL "RIDS" RECIPIENTS:
PLEASE HELP US TO REDUCE iVASTE! CONTACT THE DOCUMENT CONTROL DESK, ROOii! Pl-37 (EXT. 20079) TO Iil.l!i'IliPATE YOUR NM IE FROM DISTRIBUTION LISTS FOR DOCUKIENTS YOU DON'T NEED!
FULL TEXT CONVERSION REQUIRED TOTAL NUMBER OF COPIES REQUIRED: LTTR 31 ENCL 31
Indiana Michigarl Power Company Cook Nuclear Piani One Cook Place Bridgman. MI 49106 616 465 5901 INfMANA NtCHIGAbf POWER November 15, 1991 United States Nuclear Regulatory Commi.ssion Document Control Desk Rockville, Maryland 20852 Operating Licenses DPR-58 Docket No. 50-315 Document Control Manager:
In accordance with the criteria established by 10 CFR 50.59 entitled Licensee Event Re ort S stem the following report is being submitted:
91-010-00 Sincerely,
~ A. Blind
~
Plant Manager AAB:sb Attachment co D. H. Williams, Jr.
A. B. Davis, Region E. E. Fitzpatrick III P. A. Barrett B. F. Henderson R. F. Kroeger B. Walters Ft. Wayne NRC Resident Inspector T. Colburn NRC J. G. Keppler M. R. Padgett G. Charnoff, Esp.
D. Hahn INPO S. J. Brewer/B. P. Lauzau B. A. Svensson
NRC FORM 366 V.S. NUCLEAR REGULATORY COMMISSION (639) APPROVED OMB NO. 31504104 EXPIRES: 4/30/92 ESTIMATED BURDEN PER RESPONSE TO COMPLY WTH THIS INFORMATION COLLECTION REQUESTs 50.0 HRS. FORWARD LICENSEE EVENT REPORT {LER) COMMENTS REGARDING BURDEN ESTIMATE TO THE RECORDS AND REPORTS MANAGEMENT BRANCH (PS30), V.S. NUCLEAR REGULATORY COMMISSION, WASHINGTON, OC 20555, AND TO THE PAPERWORK REDUCTION PROJECT (31500104). OFFICE OF MANAGEMENTAND BUDGET, WASHINGTON, DC 20503.
FACILITY NAME (1) DOCKET NUMBER (2) PA E 3
'
Donald C. Cook Nuclear Plant Unit 1
'" Liquid Release to Unrestricted Area in Violation of Technical Specification 0 5 0 0 0 315 ioF04 Due to Poor Human Factors in the Desi n and 0 eration of the Release Monitor EVENT DATE (51 LER NUMSFR (6) REPORT DATE (7) OTHER FACILITIES INVOLVED (6)
MONTH OAY YEAR YEAR c'j'j,'EQUENTIAL FrFS RSVlSION MQNTH DAY YEAR FACILITY NAMES DOCKET NUMBER(S)
NUMBER %$ > NUMBER D. C. Cook Plant Unit 0 5 0 0 0 3 1 0 1 6 9 1 9 1 0 10 00 111 59 1 0 5 0 0 0 THIS REPORT IS SUBMITTED PURSUANT 7 0 THE RLQUIREMENTS OF 10 CFR (): ICnece one or more of rne followinpl (11 OPERATING MODE (9) 1 20.402(b) 20.405(c) 50.734)(2)(iv) 73.71(S)
POWER 20.405( ~ I (1)(I) 50.36(cl(1) 50.73(e)(2)(v) 73.7) lc)
LEYEL (10) 1 0 0 20.405 ( ~ ) ( I I(i(i 50.36(c)(2) 60,73( ~ ) (2((vii) DTHER (specify ln Aostrect below end ln Tert. NIIC Form 20.405 (c) (I ) (iti I X 50.73(e)(2HO 60,73(el(2)(xiii) (Al 366AI 20.405( ~ IIII(iv) 50.73( ~ l(2) (ii) 60,73( ~ l(2) (villi(BI 20.405(el(1 I (vl 50.7 3 (el l2) (iii) 50.73( ~ )(2)(xl LICENSEE CONTACT FOR THIS I.ER (12)
J. T. Vojcik Technical Physical Sciences " TELEPHONE NUMBER AREA CODE Department Superintendent 616 46 5-5 901 COMPLETE ONE LINE FOR EACH COMPONENT FAILURE DESCRIBED IN THIS REPORT l13)
CAUSE SYSTEM COMPONENT MANVFAC. REPORTABLE MANUFAC < X~c 'come'PORTABLE TURER TO NPROS CAUSE SYSTEM COMPONENT TURER TO NPRDS X IL MO N E 0 7 0 IP%%&r SUPPLEMENTAL REPORT EXPECTED (14) MONTH DAY YEAR EXPECTED SUBMISSION DATE (15)
YES Ill yer, complete EXPECTED S(ISAIISSfOff DA TEI NO 0 5 1 5 9 2 ABSTRACT ILlmlt to 1400 spetes, ie., epproximetely frfmen sinpie specs typewritten lineD (16)
On October 16, 1991 approximately 1310 hours0.0152 days <br />0.364 hours <br />0.00217 weeks <br />4.98455e-4 months <br />, a sampled but unmonitored liquid release occurred when the liquid radwaste effluent header sample gamma radiation detector RRS-1000 went into an external fail status change alarm. At that time the alarm was acknowledged by depressing the acknowledge button. This action also bypasses the trip functions which allows opening of the waste release isolation valve to initiate sample flow to above the low flow trip setpoint of 3.1 gpm. To re-arm the trip function the sample flow must be increased to 5.5 gpm. During the 6 minutes of release prior to detecting the monitor's inoperable status, the re-arming flowrate had not been reached, and only 598 gallons of the 16,134 gallon tank had been zeleased.
The event was caused by poor human factors in the design and operation of the system which made it difficult for the operators to determine they had bypassed the trip function when the alazm aknowledge button was depressed.
Enhancements were made to the liquid waste release procedure to require increasing the sample flow rate to the level required for arming the trip setpoint. 1n addition, to aid the operators'n identifying the alarm condition the duration of the audible alarm will be increased. from seven to fifteen seconds. Further, noise suppression was installed to prevent radio fzequency field fz'om causing spurious alarms and design changes will be pursued to decrease the potential for personnel error.
NRC Form 366 (649)
NRC FORM 366A U.S. NUCLEAR REGULATORY COMMISSION
~ APPROVED OMB NO. 31500')04 (64)9)
EXPIRES: 4/30/92 ESTIMATED BURDEN PER RESPONSE TO COMPLY WTH THIS LICENSEE EVENT REPORT ILER) INFORMATION COLLECTION REQUEST: 50A) HRS. FORWARD COMMENTS REGARDING BURDEN ESTIMATE TO THE RECORDS TEXT CONTINUATION AND REPORTS MANAGEMENT BRANCH (P.530), U.S. NUCLEAR REGULATORY COMMISSION, WASHINGTON, DC 20555, AND TO THE PAPERWORK REDUCTION PRO/ECT (31500104), OFFICE OF MANAGEMENTAND BUDGET, WASHINGTON, DC 20503 FACILITY NAME (1) DOCKET NUMBER u) LER NUMBER LB) PAGE (3)
VEAR SEQUENTIAL REVISION NUMBER NUMSER D. C. Cook Nuclear Plant Unit 1 p p p p p 3 1 5 9 1 1 0 00 02 OF 0 4 TEXT /// moro 4/>>co /1 PSII/)od, Irro odd/o'or>>/F/RC Form 366A'4/ (17)
Conditions Prior to Occurrence Unit 1 and Unit 2 in Mode 1 (Power Operation) at 100X power.
Descri tion of Event On October 16, 1991 at 1300 hours0.015 days <br />0.361 hours <br />0.00215 weeks <br />4.9465e-4 months <br /> while preparing to release L91-136, a liquid radwaste release from Monitor Tank 3, RRS-1001, the radioactive liquid waste effluent header sample gamma radiation detector (EIIS/IL-MON) had an external fail status change alarm. At the same time the local area monitor associated with the liquid waste area monitor, RRS-1003, had a high fail status change alarm. At 1305 hours0.0151 days <br />0.363 hours <br />0.00216 weeks <br />4.965525e-4 months <br />, the external fail status change alarm was cleared by pressing the alarm acknowledge button. The alarm acknowledgement also bypasses the trip functions to allow opening of the waste release isolation valve to initiate sample flow to clear the low flow trip setpoint of 3.1 gpm. However, to re-arm the trip function the sample flow must be increased to 5.5 gpm. During this release the re-arming flowrate was never reached.
When the external fail status change alarm cleared RRS-1001 exhibited a high fail status change alarm. The high fail status change alarm had probably been present since 1310 hours0.0152 days <br />0.364 hours <br />0.00217 weeks <br />4.98455e-4 months <br /> but was masked by the external failure. At 1309 hours0.0152 days <br />0.364 hours <br />0.00216 weeks <br />4.980745e-4 months <br /> RRS-1003 went into a low fail status. Also, at 1313 hours0.0152 days <br />0.365 hours <br />0.00217 weeks <br />4.995965e-4 months <br /> a channel check was performed in accordance with the operations procedure to ensure operability during the release. The release was manually terminated at this time.
Cause of Event The event was caused by poor human factors in the design and operation of the system which made it difficult for the operators to determine they had bypassed the trip function when the alarm acknowledge button was depressed.
Factors contributing to this event include the following:
r
- 1. Audible alarms are short in duration and are not discernable from one channel to another or from one status to another with the exception of a high alarm.
Procedure guidance did not require the sample flow rate be increased to re-arm the trip function following an alarm acknowledge.
The radiation monitor microprocessor locks up due to generation of a radio frequency (RF) noise created by the trip relays during rapid status changes.
NRC Form 366A (64)9)
NRC FORM 366A U.S. NUCLEAR REGULATORY COMMISSION (64)9) APPROVED OI'IB NO. 31500)04 EXP IR ESI 4I30/92 ESTIMATED BURDEN PER RESPONSE TO COMPLY WTH THIS LICENSEE EVENT REPORT (LERI INFORMATION COLLECTION REQUEST: 500 HRS. FORWARD COMMENTS REGARDING BURDEN ESTIMATE TO THE RECORDS TEXT CONTINUATION AND REPORTS MANAGEMENT BRANCH (PJ)30). U.S. NUCLEAR REGULATORY COMMISSION, WASHINGTON, DC 20555, AND TO 1HE PAPERWORK REDUCTION PROJECT (3)500104), OFFICE OF MANAGEMENTAND BUDGET, WASHINGTON, DC 20503.
FACILITY NAME 0 ) DOCKET NUMBER (2) LER NUMBER (6I PAGE (3)
.NR sEGUENTIAL REvlsroN YEAR BN2 D. C. Cook Nuclear Plant Unit 1 Qr(C< NIJMSE R NUM ER 0 5 0 0 0 3 1 5 9 1 01 0 00 03 oF 0 4 TEXT ffimore soeoeis ~ Jrrr)ed, Iree eddtdonel HRC Form 3664'4) l)2)
Anal sis of Event This event is considered reportable pursuant to 10 CFR 50.73(a)(2)(i)(B) as operation prohibited by the Technical Specification. Technical Specification 3/4.3.3 LCO 3.3.3.9 requires that with a required channel inoperable, releases may continue up to thirty days provided at least two independent samples are analyzed in accordance with Specification 4.11.1.1.1 and; at least two technically qualified members of the facility staff independently verify discharge valving prior to initiating the release otherwise, suspend releases via this pathway. Contrary to Technical Specification 3/4.3.3 Release L91-136 was not monitored for 6 minutes (598 gallons of the 16,134 gallons planned) via RRS-1001 nor was the dual sampling and independent discharge valving verification completed.
Reviews of the radiation monitoring system data, release flow rate, dilution water flow rate and the radioanalytical results indicated that at no time did the concentration of radioactive material discharged to Lake Michigan exceed the concentration limits listed in 10 CFR 20 Appendix B, Table 2. Therefore, this event did not have an impact on the health and safety of the public.
Corrective Action 4
Extensiv'e troubleshooting was performed on'RS-1000. It was found that if the signal to the sample flow switch was rapidly increased and decreased it created an RF noise which caused the microprocessor to lockup. The lockups cause RRS-1000 to become unresponsive. To correct this situation a modification was completed to install metal oxide varistors. The varistors prevent the RF field from developing.
In addition, enhancements were made to the operations liquid waste release procedure to require increasing the sample flow rate to the level required for arming the trip setpoint.
To raise the operator awareness of the radiation monitoring system status changes, the duration of the audible alarm will be increased *from seven to fifteen seconds. Design changes will also be pursued to remove the potential personnel error in the future.
Failed Com onent Identification Liquid Waste Discharge Monitor Plant Designation: RRS-1000 Manufacturer: Eberline Installed Design: American Electric Power Service Corporation (AEPSC)
NRC Form 366A (64)9)
NRC FORM 366A US. NUCLEAR REGULATORY COMMISSION (64)9) APPROVED OMB NO,31500104 EXPIRES: 4/30/92 ESTIMATED BURDEN PER RESPONSE TO COMPLY WTH THIS LICENSEE EVENT REPORT (LER) INFORMATION COLLECTION REOUFSTI 50.0 HRS. FORWARD COMMENTS REGARDING BURDEN ESTIMATE TO THE RECORDS TEXT CONTINUATION AND REPORTS MANAGEMENT BRANCH IPB30), U.S. NUCLEAR REGULATORY COMMISSION, WASHINGTON, OC 20555. AND TO 1'HE PAPERWORK REDUCTION PROJECT (31504)104)> OFFICE OF MANAGEMENTAND BUDGET.WASHINGTON, DC 20503.
FACILITYNAME (1) DOCKET NUMBER (2) LER NUMBER (6) PAGE (3)
YEAR SEQUENTIAL REVISION NUMSER NUMSER D. C. Cook Nuclear Plant Unit 1 o 5 o o o 3 9 1 0 1,0 0 0 0 4 OF 0 4 TEXT /lfmore 4aeoe ie rtyked, ore odd/done/ /iRC Form 36(/43/ ((7)
Previous Similar Events LER 50-315/91-003 NRC Form 366A (669)
