3F0896-12, Forwards 90-Day Inservice Inspection Summary Report IAW 1983 Edition of ASME Boiler & Pressure Vessel Code,Section Xi,Article IWA-6000 Which Includes NIS-1 Form & Summary of Exams Performed Since Preceding Summary Rept
| ML20116M577 | |
| Person / Time | |
|---|---|
| Site: | Crystal River  |
| Issue date: | 08/15/1996 |
| From: | Boldt G FLORIDA POWER CORP. |
| To: | NRC OFFICE OF INFORMATION RESOURCES MANAGEMENT (IRM) |
| References | |
| 3F0896-12, 3F896-12, NUDOCS 9608200219 | |
| Download: ML20116M577 (109) | |
Text
- - . - - - - - - - - - _
\
@~
F12rida PSRgr
- ==:
August 15, 1996 3F0896-12 U. S. Nuclear Regulatory Commission Attn: Document Control Desk Washington, D.C. 20555-0001
Subject:
90-Day Inservice Inspection (ISI) Report
References:
A. FPC to NRC, 3F0288-09 dated February 9, 1988 B. NRC to FPC, TAC N0. M68246 dated April 13, 1992 C. FPC to NRC, 3F0393-09 dated March 25, 1993
Dear Sir:
Florida Power Corporation (FPC) is providing the attached 90-Day Inservice Inspection (ISI) Summary Report in accordance with the 1983 Edition of the ASME Boiler and Pressure Vessel Code,Section XI, Article IWA-6000. The Summary Report includes the NIS-1 form, "0wner's Data Report for Inservice Inspection"; a summary of examinations performed since the preceding (September 1994) Summary Report, including a summary listing of examinations conducted on Class 1 and 2 pressure retaining components and supports; and NIS-2 forms, "0wner's Reports for Repairs and Replacements". The detailed records supporting the attached ISI Summary Report are maintained on site as part of our quality files and are available for inspection upon request.
The Augmented Examinations section of the ISI Summary Report also provides additional technical information necessary to close an open item initiated by Reference C. This open item involves the withdrawal via Reference C of an FPC commitment made in Reference A to perform ultrasonic (UT) inspection of all Reactor Vessel (RV) Upper Core Barrei Bolts (UCBs), Lower Core Barrel Bolts (LCBs), Lower Thermal Shield (LTS) studs, Upper Thermal Shield (UTS) studs, Surveillance Specimen Holder Tube (SSHT) bolts and studs, Flow Distributor (FD) Bolts, and Guide Block (GB) bolts.
The original commitment to perform 100% UT inspection of the bolts was based on I experience with Core Support Assembly (CSA) fastener failure at Babcock & Wilcox (B&W) designed plants during the early 1980's. Over the course of several refueling outages h beginning with Refuel 4, CR-3 repaired several CSA fastener joints with redesigned studs, nuts, and bolts. The repair effort entailed replacement of 120 UCBs, 60 LCBs, 72 SSHT studs and nuts,-and 96 LTS studs and nuts. To facilitate this repair effort, FPC prepared Modification Approval Records (MARS) to document and approve replacement of the fasteners. As part of the established MAR process, the design engineer must address any required preservice or inservice inspection requirements applicable. In 200070 CRYSTAL RNER ENERGY COMPLEX
- 16760 W. Power uns Street
- Crystal Riyer
- Floride 34428-6708
U. S. Nuclear Regulatory Ccmmission .
3F0896-12 l Page 2 ;
the case of the fastener MARS, those MARS which addressed fasteners considered most susceptible to failure required that all stud-nut-locking cup assemblies be video inspected and UT inspected during the next ten year refueling outage when the CSA is positioned on the CSA support stand for RV inspection. MARS for fasteners considered l less susceptible to failure simply stated that inservice inspection requirements would be determined by the FPC organization responsible for the ASME Section XI Inservice Inspection program (ISI section). As a result of the common CSA fastener failures at B&W designed plants, in parallel with replacement of failed fastenera, the B&W Owners Group formed a task force to study, evaluate, and provide recommendations to preclude future failures. The results of the task force were published in January, 1986, in B&W Topical Report, BAW-1843PA. The topical report, which was reviewed and approved by NRC, recommended that each B&W designed plant evaluate each fastener connection in their respective CSA against specific criteria established by the task force. The report ouilined some key parameters to be considered when developing an inspection plan, if so desired. The topical report was reviewed by FPC to ensure the acceptability of the fastener replacements which were performed, however, no i specific review for inservice inspection requirements was performed at that time. l In 1987 when the ISI section began preparation of the ASME Section XI inspection plan '
for CR-3's second ten year interval of operation, no review of BAW-1843PA for determination of inservice inspection requirements was performed. As a result, the I MAR requirement to perform UT inspection of CSA fasteners considered most susceptible !
to failure was conservatively, but incorrectly, applied to all CSA fasteners, ;
including those with low probability of failure as determined by BAW-1843PA. l Misapplication of the MAR inspection requirement subsequently resulted in the FPC commitment to perform augmented 100% UT inspection of all CSA fasteners made in !
Reference A and approved by NRC in Reference B.
In 1989, INP0 issued SER 30-89 describing damage to reactor system components due to a loose Baffle Assembly Screw. Internal review of SER 30-89 for applicability to CR-3 ;
identified the need for a detailed review of CSA fasteners by design engineering prior ;
to the ten year inspection outage (Refuel Outage 10) to determine specific inspection 1 requirements necessary to assess the condition of each type of CSA fastener. A review ,
was subsequently initiated in December of 1994 with final recommendations for CSA fastener inspections documented in the resolution to Request for Engineering i Assistance (REA) 94-1328, dated August 14, 1995. REA 94-1328 recommended the following CSA fastener inspections be performed:
. UT inspection of UCBs
. Video inspection of UCB locking cups
. UT inspection of a random sample of SSHT studs
. Video inspection of SSHT locking cups, and
. Video inspection of all other CSA fasteners.
These recommended inspections were incorporated into the Refuel Outage 10 NDE inspection schedule and have been completed as described in the attached Summary Report. No defects were found during UT inspection of UCBs and SSHT studs and all CSA fasteners were confirmed by visual inspection to be in place with no visible degradation.
Since Refuel Outage 10 was the last scheduled refuel outage for CR-3's second ten year inspection interval, a self-assessment of the NDE Inspection plan was initiated in February of 1996. The intent of the self-assessment was to ensure that all ASME Section XI required inspections, as well as regulatory required inspections, would be completed during Refuel Outage 10 to allow close out of the second year inspection a
U. S. Nuclear Regulatory Commission 3F0896-12 Page 3 plan. As part of the self assessment, a review of the NDE Inspection plan was performed against Reference B, the NRC Safety Evaluation Report (SER) for the Second 10 year interval Inservice Inspection program plan. This review identified a discrepancy between the NDE Inspection plan (which required no CSA fastener inspections), the Refuel Outage 10 Inspection schedule (which included inspections j recommended by REA 94-1328), and Reference B (which acknowledged FPC commitment to 1 perform 100% UT inspection of all CSA fasteners). A historical review of revisions made to the NDE Inspection plan identified a revision on March 2,1992 which deleted all CSA fastener inspections from the plan. The only basis for this revision was that augmented exams were performed during the first inspection interval to satisfy MAR (i.e. CSA fastener MAR) requirements. Review of associated document records also determined that notification of this revision to the NDE Inspection plan was made via Reference C, however, no technical justification for the revision was provided.
Additionally, FPC has not received formal acceptance of this change through NRC issuance of an SER for the program revision.
In order to close this open item, FPC requests NRC review and approval of the technical basis for the UT inspections performed on CSA fasteners during Refuel Outage l 10, provided in the attached Summary Report, as justification for modification of the original commitment made in Reference A. Specifically, this change reduces the scope of the commitment from performance of 100% UT inspection of all CSA fasteners to i performance of the following: l
. UT inspection of 100% of Upper Core Barrel Bolts
. UT inspection of 75 randomly selected SSHT studs; and
. Visual inspection of all CSA fasteners.
Although this change in commitment requires less extensive UT inspection than the original commitment made in Reference A, it is FPC's position that the technical basis for this change is justified and that the inspections performed provide sufficient assurance of the continued integrity of the CSA fasteners.
Crystal River Unit 3's current 10-Year ISI Interval (Second Interval) ends in March 1997. Although Refuel 10 was the last refuel outage of this interval, several augmented examinations, pressure tests and corrective actions to resolve open problem reports initiated during program self assessment remain to be completed. Therefore, an additional Summary Report will be submitted by March 15, 1997 to close out the interval .
Sincerely, G. L. Boldt Vice President Nuclear Production Attachment xc: Regional Administrator, Region II Project Manager, NRR Senior Resident Inspector
1I U.S. Nuctstr R2gulatory Conynission 3FCC96-12 Attachment l FORM NIS 1 OWNER'S REPORT FOR INSERVICE INSPECTIONS f As Required by the Provisions of the ASME Code Rules l
1 l
- 1. Owner florida Power Corporation, P O ika 14042, St Petersburg. Il 33733-4042 (Name and Address of C wner)
- 2. Plant Crystal River Unit 3,15760 Power iine Seveet, Crystal River, florida, 34428-6708 j (Narne and Address of Plant) l
- 3. Plant Umt Crystal River Unit 3 4. Owner Certificate of Authorization (if required) N/A
- 5. Commercial Service Date 3-13-77 6. National Board Number for Unit N/A 7, Components inspected
! Components or Manufacturer Manufacturer or State or National Board l Appurtenance or installer installer Serial No. Province No. No.
Reactor Vessel B&W 620 % 07-51-52 N /A N-117 Pressurizer B&W 620-0007-59 N/A N-118 l Steam Generator A B&W 620-0007-55-1 N /A N-119 Steam Generator B B&W 6204:007-55-2 N/A N-120 Reactor Coolant Pump Byron Jackson 671-N-0530 N/A N/A RCP-1 A I Various Class 1 and -
N/A N/A N/A Class 2 Piping, Valves,
& Supports l
l l
l Note: Suppdemental sheets in form of lists, sketches, :n drawings may be used, provided (1) size in the same as this Data Report, (2) information in items 1 through 6 on this report is included on each sheet, and (3) each sheet is numbers and the er.smber of sheets is recorded at the top of this form, i
i Page 1
U.S. Nuctscr Regulstery Commission 3F0096-12 Attachment FORM NIS-1 (back)
- 8. Examination Dates 6/7/94 to 5/17/96 9. Inspection Interval from 3/14/87 to 3/15/97
- 10. Abstract of Examination. Include a tiet of examinatione and a statement conceming statue of work required for current intervat *See Attached
- 11. Abstract of Conditions Noted 'See Attached
- 12. Abstract of Corrective Measures Recommended and Taken *See Attached We certify that the statements made in this report are correct and the examinations and corrective measures takerc conform to the rules of the ASME Code, Section XL -
f Date 8/7 19,96, Signed Florida Power Corp. By _ ._1 -
Owner I/
Certifica'e of Authorization No. (if applicable) N/A Expiration Date N/A CERT 1FICATE OF INSERVICE INSPECTION 1, the undersigned, holding a valid commission leeued by the National Board of Boiler and Pressure Vessel inspectors and/or the State or Province of Fic4.IDA and employed by 7#F HSA 74 7 C3 of
- M1Tofbe LT have inspected the components described in this Owner's Data Report during the period 4-7 94 to a-I446 and state that to the best of my knowledge and beimf, the Owner has performed examinations and taken corrective measures described in this Owner's Data Report in accordance with the requiremonte of the ASME code,Section XI.
By signing this certificate neither the inspector nor his employer makes any warranty, expressed or implied, concoming the examination and corrective measures described in this Owner's Data Report. Furthermore, neither the Inspector nor his employer shall be liable in any manner for any personal injury or property damage or a loss of any kind arising from or connected with this inspection.
Date E-I4 19 '_f fa -
d,A/44[ Commissions Da 7150 C.TNCA) i~4195
' inspector's Signature National Board, State. Province, and No.
Page 2
1 U.S. Nuctscr RJgulatory Consnission 3F0896 12 ;
Attachment. I REFUEL 10
SUMMARY
REPORT The following is a summary of the Inservice Inspection examinations conducted i during operating cycle 10 up to and including Refuel 10 (R10) at Crystal River Unit 3. This report is submitted in accordance with the 1983 Edition and Summer Addenda of ASME Section XI, Subsection IWA-6230 and contains an abstract of the examination activities conducted during this period; with the detailed records on file and available at the plant site. NRC regulations (10CFR50.55) require that inservice examinations comply with the latest edition and addenda of the ASME Section XI Code incorporated by reference in the regulation 12 mcnths prior to the start of the 120 month interval. RIO was the last refueling outage in Inspection Interval 2 at Crystal River Unit 3. Several non ASME Section XI NRC mandated augmented examinations, corrective actions to open Problem Reports, and several system pressure tests remain to be completed before the end of the interval. These examinations will be conducted prior to the end of the inspection interval, 3/15/97; and reported on the Interval 2 close out Summary Report. ASME Code Cases utilized by the ISI Program are documented within this report and have been approved for use either through inclusion in NRC Regulatory Guide 1.147 or by NRC approved Relief Requests.
1 EXAMINATIONS:
Comoonents A summary listing of examinations conducted on ASME Class 1 and 2 piping and components performed by Framatome Incorporated, is included later in this report. These examinations were conducted as required by the 1983 Edition with the Summer 1983 Addenda of the ASME Section XI Code. Conservative adjustments in the number of examinations conducted in some categories were made where necessary to assure proper close out of the 10-year inservice inspection interval . Indications observed are documented and dispositioned on an Evaluation Report. There were no unacceptable indications observed during these examinations.
Reactor Vessel Examinations Ultrasonic examinations were conducted on reactor vessel shell welds in accordance with 10CFR50.55a augmented requirements for examination Category B-A as specified in the 1989 Edition of the ASME Section XI Code, Item Bl.10.
NRC approved Relief Request 95-030 provided relief from examining the reactor vessel lower head to transition piece weld due to a space limitation. Specific l examinations conducted are listed later in this report. There were no l unacceptable indications observed during these examinations. This constitutes
! completion of the 10-year inspection interval examination requirements for the reactor vessel.
Page 3
U.S. Nucts:r Rtgulatory Commission 3F0896-12 Attachment Reactor Coolant Pumo Examinations Relief from volumetric and surface examination of the reactor coolant pump motor flywheels in accordance with Regulatory Guide 1.14, " Reactor Coolant Pump Flywheel Integrity", Regulatory Position C.4.b, was granted in a one-time Technical Specification change that delayed the examination one cycle to coincide with the Spring 1998 refueling outage. The basis for this change was the operational experience of Crystal River Unit 3 and the industry which has demonstrated that the flywheels have a low probability of failure. A surface examination of 25'/. of the two scroll welds in one reactor coolant pump casing was performed in accordance with approved Relief Request 90-050. In addition, i VT-3 examinations of the internal surfaces and gasket seating surface of one l reactor coolant pump were completed during the reporting interval. No unacceptable indications were observed during these examinations.
Steam Generator Eddy Current Examinations Eddy current examinations were conducted on both steam generators during Refuel 10. A summary of the results of these examinations will be submitted in a separate report to the NRC within 90 days of the end of Refuel 10 as required by Crystal River Unit 3's Improved Technical Specification 5.7.2.C.
Snubbers A total of 64 snubber visual examinations have been conducted. Ten visual examinations were completed during cycle 10 with visual examination of 54 safety related snubbers completed during Refuel 10. Forty-one (41) functional tests of snubbers have been conducted in accordance with Section XI, 1983 Edition through Summer 1983 Addenda of the ASME Boiler and Pressure Vessel Code. Results of the snubber functional tests are on file and are available on request. A summary listing of these exams is included later in this report.
Comoonent Supports Twenty-four (24) component supports were examined during Refuel 10 to meet ASME Section XI requirements for the 10-year inspection interval in accordance with the alternative rules specified in ASME Code Case N-491, " Alternative Rules for Examination of Class 1, 2, 3 and MC Component Supports of Light Water Cooled Power Plants". This Code Case requires examination of 25'/. of Class 1 supports,15'/. of Class 2 supports and 10% of Class 3 supports during the 10-year inspection interval. Conservative adjustments in the number of examinations conducted in some categories were made where necessary to assure proper close out of the 10-year inservice inspection interval. A summary listing of these exams is included later in this report. No detrimental conditions were identified during these examinations.
Page 4
1 U.S. Nuclstr Rigulatory Commission 3F0896-12 Attachment System Pressure Tests Relief Request 95-020 was issued for use of ASME Section XI Code Case N-498-1,
" Alternative Rules for 10-Year System Hydrostatic Pressure Testing for Class 1, 2, and 3 Systems". Pressure testing was conducted on 9 systems to meet the
- ASME Section XI code requirements. Pressure testing for each Repair / Replacement is documented on the applicable NIS-2 form attached to this report. A summary listing of these tests is included later in this report.
AUGMENTED EXAMINATIONS:
) Ultrasonic examination of the Upper Core Barrel bolts (UCB) and the j Surveillance Specimen Holder Tube studs (SSHT) was performed during Refuel 10 as an augmented examination. This examination consisted of a 100% (120) UT
- of the Upper Core Barrel bolts and a random sampling (75) of the SSHT studs.
! These examinations are not ASME Section XI code required and were performed only to detect any crack type degradation of the fastener material. No defects were found in any of the fastener material.
- The basis for performing ultrasonic examination on 100% of the upper core barrel bolts and a random sampling of SSHT studs 1.s based on a comparison of
- peak operating stress and nominal operating stress for each bolt location to a statistically derived upper limit of stress founded in part from the operating data for other utilities. The comparative data has been extracted from B&W Topical Report BAW-1843PA and CR-3 White Paper, "A Basis for Reactor Vessel Core Support Assembly Bolting Examinations". I i
i 1. The upper core barrel bolts (UCB) are fabricated from SA-453 Grade 660, Class A material which is similar to the original bolting material that failed in the 1983 time frame; ASTM A-286. The SA-453 Grade 660, Class A material was selected based on availability and schedule after the failures were found on the original A-286 bolts. The replacement bolts were installed by torquing (940-1010 ft-lbs) with final preload being adjusted using UT. The average peak stress in the bolt was calculated to be 71,700 PSI. The statistical evaluation in BAW-1843PA shows that for greater than 95% confidence, there is a 99.9% probability that Alloy A-286 bolts stressed below 100,000 PSI should not exhibit failure before 6 to 10 years. It is noted that the calculated nominal peak stress for the Oconee-2 original UCB bolts (same as CR-3 originals) was 101,000 PSI with no failures having been reported. Oconee-2 went critical in Nov.1973.
The calculated nominal peak stress for the Arkansas Nuclear One - Unit 1 (AN0-1) original LCB bolts (same as CR-3 originals) is 72,000 PSI and no failures have been reported. ANO-1 went critical in Aug.1974. This data supports the theory that A-286 bolts with a peak stress less than 100,000 PSI have a high probability of success.
A 100% UT examination of the UCB joint was performed, even though the stress levels are less than the upper threshold, due to the fact that the replacement bolt material is chemically and physically the same as the original material; and during the testing performed by the B&W Owners Group, a failure of this material could not be produced in the test fixture. This would indicate that there may be additional, and currently unidentified parameters, leading to the failure of this type of material.
Page 5
/
l U.S. Nucle:r Regulstory Comission 3F0896-12 Attachment AUGMENTED EXAMINATIONS (cont.)
- 2. The sixty out of 108 replacement lower core barrel bolts (LCB) are fabricated from Inconel X-750 HTH with an Inconel X-750 HTH compression collar. The 60 replacement bolts are equally spaced in 12 groups of 5 around the joint. The remaining 48 bolts are the original A-286 bolts with locking clips. It must be noted that from a structural integrity standpoint, these bolts are not necessary. The LCB joint has been evaluated assuming the A-286 bolts have failed and joint integrity is being maintained only by the 60 replacement bolts. These 48 bolts were not replaced due to their proximity to the guide blocks and could not be removed due to the limited tooling space.
If a complete failure were to occur with one of the A-286 bolts, any unattached parts would become entrained within the flow stream and would be detected by the Loose Parts Monitoring System (LPMS). No LPMS alarms relative to this type of failure have occurred. Inconel X-750 HTH was selected because of its excellent overall elevated temperature properties, resistance to thermal and neutron induced relaxation, and is less susceptible to stress corrosion cracking.
The preload on the 60 replacement LCB bolts ranges from 48,660 lbs to 59,580 lbs. The bolts were torqued (750-3420 ft-lbs) and adjusted using UT to measure load. The nominal operating stress for these bolts was calculated to be 45,300 PSI. Service experience has shown that Inconel i
X-750 material has performed exceptionally well when the nominal operating stresses are maintained below 60,000 PSI. The original UCB, LCB, UTS,
- LTS, and FD bolted joints in the Three Mile Island 1 (TMI-1) CSA utilized 1
Inconel X-750 material. In April 1982, TMI-1 UT examined 96 of the 120 UCB bolts with no reported indications. In 1991, TMI-1 UT examined all 120 UCB bolts with no reported indications. TMI-1 went critical in May 1974 and had about 2.8 years of cold shutdown before the 1982 UT 1 examination. This converts to abot.t 19 years of operation with Inconel .
l X-750 bolting material. The operating stress for these bolts was l calculated to be 46,800 PSI.
i The Inconel X-750 HTH material has no? exhibited any indications of I
failure when the nominal stress levels are maintained below 60,000 psi.
Performance of an examination of this bolt ring was not warranted.
- 3. All of the original SSHT bolts in the upper, lower, and middle brackets were replaced with studs / nuts. The studs / nuts are 3/4"-10VNCR and are Inconel X-750 material . The preload on the SSHT stud ranges from 7,100 lbs to 11,850 lbs. The nuts were torqued (70-80 ft-lbs) and adjusted using UT to measure load. The nominal operating stress is about 39,100 PSI.
Service experience has shown that Inconel X-750 material has performed exceptionally well when the nominal operating stresses are maintained below 60,000 PSI. Because of the stud / nut configuration of the o replacement design and the reduced operating stress, there is a
! significant difference with respect to failures documented for the bolt l design. Failures in the threaded portion of bolts and/or studs / nuts have not been reported for Inconel X-750 HTH material in B&W reactors.
Page 6 i
U.S. Nuctetr Rigulatory Commission 3F0896-12 Attachment AUGMENTED EXAMINATIONS (conL)
The stress levels in the replacement studs do not warrant an examination on_their own. The primary basis for performing a random examination on '
the studs was to provide additional assurance to FPC that the new configuration was structurally adequate.
- 4. The upper thermal shield bolts (UTS) are fabricated from A-286 material.
No failures have been reported at this joint. The torque on the UTS bolts is 800 to 900 ft-lbs resulting in a stress of 20,000 PSI. The nominal operating stress is 22,000 PSI and is well below the stress at which failures have been reported in A-286 bolts.
Based on the lack of failures of bolts at the joint location and the low nominal operating stress, an examination of this bolt ring is not warranted at this time.
- 5. The lower thermal shield bolts (LTS) were replaced with studs / nuts in 1983 after 74 bolts were found to have failed. The replacement LTS studs / nuts !
are fabricated from Inconel X-750 HTH material. The nominal preload on the LTS stud resulted in a stress of 28,500 psi and an operating stress of 55,300 psi. i Because of the stud / nut configuration, there is a significant difference with respect to failures documented for the bolt design along with reduced operating stresses as discussed for the lower core barrel bolts. Failures in the threaded portion of bolts and/or studs / nuts have not been reported for Inconel X-750 HTH material in B&W reactors. The stud / nut configuration is an improvement over the bolt design since it eliminates the head-to-shank transition radius where failures were found.
The Inconel X-750 HTH material has not exhibited any indications of failure when the nominal stress levels are maintained below 60,000 psi.
Based on the stress levels in these studs, an examination of this bolt ring was not warranted.
- 6. The flow distributor bolts (FD) are fabricated from A-286 material and were torqued to 330 ft-lbs resulting in a nominal stress of 36,000 PSI with a nominal operating stress of 35,000 PSI. This value is well below the stress at which failures have been reported in A-286 bolts.
Based on the lack of failures of bolts at the joint location and the low nominal operating stress, an examination of this bolt ring was not warranted.
Page 7
)
i l
U.S. Nuc1scr Rigutatory Commission 3F0896-12 Attachment AUGMENTED EXAMINATIONS (cont.)
- 7. The guide block bolt (GB) is fabricated from ASTM A-193 Grade B8 (stainless steel) with a stainless steel washer under the bolt head. The shear pin is 1-1/2" diameter and is fabricated from Inconel X-750. The I bolts were torqued to 230 ft-lbs resulting in a nominal stress of 25,300 PSI. The nominal operating stress is not known but is estimated to be minimal since there is no load on the blocks during normal operation. If the CSA were to drop, the shear pin would be subjected to a shear load with minimal load on the bolt.
Based on the lack of failures of bolts at the joint location and the low nominal operating stress, an examination of this bolt ring was not warranted.
Augmented examination of the Building Spray systeia was also performed during Refuel 10. Approximately 7.5% (6 welds) of the welds in the system received both a surface and volumetric examination. These examinations were performed in response to a NRC concern relative to IGSCC in thin wall stainless steel piping.
l i
l l
l Page 8
- Y
U.S. Nuctser RIguistcry Commission 3F0896 12 Attachment EXAMINATION
SUMMARY
This section contains a tabulated summary of NDE examinations performed during RIO, and a comprehensive listing of all ASME Section XI Code Cases and NRC approved Relief Requests applicable to these examinations. The information shows the identification numbers for the examinations, the component examined, the type of examination performed, and whether or not evaluation reports (ER) were generated.
Section XI Code Cases Used Code Case N-356, Certification Period for Level III NDE Personnel.
Code Case N-416, Alternative Rules for Hydrostatic Testing of Repair or Replacement of Class 2 Piping Section XI Division 1.
Code Case N-424, Qualification of Visual Examination Personnel.
l Code Case N-446, Recertification of Visual Examination Personnel.
Code Case N-460, Alternative Examination Coverage for Class 1 and 2 Welds.
Code Case N-474-1 Design Stress Intensities and Yield Strength Values for Alloy 690 with a Minimum Yield Strength of 35 KSI.
Code Case N-491, Alternative Rules for Examination of Class 1, 2, 3, and MC Components Supports of Light Water Cooled Power Plants.
Code Case N-498, Alternative Rules for 10 Year Hydrostatic Pressure Testing for Class 1 and Class 2 Systems.
Code Case N-498-1, Alternative Rules for 10 Year System Hydrostatic Testing for Class 1, 2, and 3 Systems.
Code Case N-523, Mechanical Clamping Devices for Class 2 and 3 Piping.
Code Case N-2142 F-Number Grouping for Ni-Cr-Fe, Classification UNS N06052 Filler Metal Section IX.
Relief Reauests88-100 IWA-2300(a)/IWA-2300(a)(1) Recertification of Level III personnel by examination on a triennial basis. Use extended certification period of 5 years as detailed in Code Case N-356.
90-10 Core Flood nozzle Item Bl.6 examination category B-F Surface Examination. Relief from performing the surface examination.
Page 9
- ~ _ . . . - . . . - . . . ~ ~ . - - - - - . - . . . . . ~ . . . - . . . - .. --- .- .. . - . . . _ - _ . . .
U.S. Nuclssr Rigulttory Commission 3F08 & 12 l Attachment i
l Relief Reauests (cont]
90-020 Hydrostatic pressure test and visual examination of specific limited class 2 components.90-050 Volumetric examination of pump casing welds and visual examination of pump ' casing internal surfaces, IWB-2500-1 Cat. B-L-1, Item l
B12.10, and Cat. B-L-2, Item B12.20.
t 90-060 Visual inspection of the Reactor Vessel support skirt, IWF-2500-1 l
Cat. F-A, Item F1.30.
l 91-010 Code Case N-498, inservice leak testing in lieu of hydrostatic testing. '92-010 Use of OM-4 as an alternative to the sample selection requirements of ASME Section XI, IWF-5400(c), Snubbers That Fail Inservice Tests.93-030 Volumetric or surface examination performed on any 6 CRDM'S removed for maintenance or cleaning in lieu of 10% of the peripheral drives.95-010 Alternate examination requirements for the core flood nozzle surface ,
examinations. See also RR-90-10.95-020 Use of ASME Code Case N-498-1. Alternative Rules for 10 Year System Hydrostatic Testing for Class 1, 2, and 3 Systems.95-030 Relief from examination of the Reactor Vessel lower head to l transition piece weld, ISI inspection number Bl.2.2. !95-040 Relief to use flat ultrasonic calibration blocks in lieu of curved -
blocks.
t 95-055 Relief to use ASME Code Case N-523 for temporary repair to the j Emergency Feedwater (EF) System. '
1 l
Page 10 i
etr Rigulatory Commission Attachment Comoonent haminations l l
IDENTIFICATION NO. COMPONENT NDE TYPE COMMENTS l Bl.3.2.1 RX VESSEL HEAD MT ,
Bl.12.1 RX VESSEL SKIRT VT l B1.16.1 RX VESSEL INT. ATT. VT !
Bl.16.2 RX VESSEL INT. ATT. VT -
B1.17.1 RX VESSEL CSA VT 81.18.3.2 CRDM DRIVE
{
PT l Bl.18.4.2 CRDM DRIVE PT l l Bl.18.5.2 CRDM DRIVE PT l B1.18.3.3 CRDM DRIVE PT i Bl.18.4.3 CRDM DRIVE PT Bl.18.5.3 CRDM DRIVE PT Bl.18.3.44 CRDM DRIVE PT I Bl.18.4.44 CRDM DRIVE PT ,
l Bl.18.5.44 CRDM DRIVE PT Bl.11.1.2 CRDM BOLTING VT l Bl.11.1.3 CRDM BOLTING VT l Bl.11.1.4 CRDM BOLTING VT Bl.11.1.5 CRDM BOLTING VT Bl.11.1.10 CRDM BOLTING VT ,
! Bl.11.1.14 CRDM BOLTING VT Bl.11.1.19 CRDM BOLTING VT Bl.11.1.20 CRDM BOLTING VT
! Bl.11.1.22 CRDM BOLTING VT .
i B1.11.1.26 CRDM BOLTING VT Bl.11.1.41 CRDM BOLTING VT Bl.11.1.42 CRDM BOLTING VT i Bl.11.1.43 CRDM BOLTING VT i Bl.11.1.44 CRDM BOLTING VT I
Bl.11.1.45 CRDM BOLTING VT Bl.11.1.53 CRDM BOLTING VT Bl.11.1.55 CRDM BOLTING VT l B1.11.1.58 CRDM BOLTING VT Bl.11.1.68 CRDM BOLTING VT Bl.11.1.9 CRDM BOLTING VT B2.3.1 PZR HTR BUNDLE VT B2.6.1 PZR MWY STUDS UT B2.2.6 PZR N0Z WELD UT ER 96-1 ACCEPTED i AFTER ENHANCED SIZING W/ FOCUSED TRANSDUCER B3.1.1 SG-1A VESSEL WELD UT B3.1.2C SG-1A VESSEL WELD UT B3.2.1 SG-1A VESSEL WELD UT B3.2.1.1 SG-1A VESSEL WELD UT i B3.7.1C SG-1A VESSEL WELD UT i B3.10.7 SG-1A BOLTING VT B3.2.4 SG-1B VESSEL WELD UT B3.2.4.1 SG-1B VESSEL WELD UT B3.10.4 SG-1B BOLTING VT l
B4.5.48 CLASS 1 PIPING PT l B4.5.50 CLASS 1 PIPING PT l
l Page 11
]
N str Rigulatory Comission Attachment Comoonent Examinations (cont.)
IDENTIFICATION NO. COMP 0NENT NDE TYPE COMMENTS B4.5.53 CLASS 1 PIPING PT B4.5.54.1 CLASS 1 PIPING PT B4.5.55 CLASS 1 FlPING PT B4.5.59 CLASS 1 PIPING UT/PT B4.5.71 CLASS 1 PIPING PT B4.5.135 CLASS 1 PIPING UT/PT B4.5.150 CLASS 1 PIP 1NG PT B4.5.152 CLASS 1 PIPING PT B4.5.153 CLASS 1 PIPING PT B4.5.160 CLASS 1 PIPING PT 84.5.161 CLASS 1 PIPING PT B4.5.162 CLASS 1 PIPING PT 84.5.163 CLASS 1 PIPING PT 84.5.174 CLASS 1 PIPING PT B4.5.175 CLASS 1 PIPING PT B4.5.184 CLASS 1 PIPING PT B4.5.185 CLASS 1 PIPING PT B4.5.186 CLASS 1 PIPING PT B4.5.187 CLASS 1 PIPING PT B4.5.192 CLASS 1 PIPING UT/MT B4.5.200 CLASS 1 PIPING UT/PT B4.5.205 CLASS 1 PIPING UT/MT B4.5.209 CLASS 1 PIPING UT/MT B4.5.258 CLASS 1 PIPING UT/PT B4.5.280 CLASS 1 PIPING PT B4.5.377 CLASS 1 PIPING PT B4.5.395 CLASS 1 PIPING PT B4.5.396 CLASS 1 PIPING PT B4.9.1 CLASS 1 PIPING PT ER 96-9 DH PIPING LUG ACCEPTABLE AFTER NON-RELEVANT INDICATION REMOVAL B4.9.2 CLASS 1 PIPING PT B4.9.3 CLASS 1 PIPING PT B4.9.8 CLASS 1 PIPING PT B4.9.9 CLASS 1 PIPING PT l B4.9.13 CLASS 1 PIPING PT B4.9.14 CLASS 1 PIPING PT B4.9.15 CLASS 1 PIPING PT B4.9.16 CLASS 1 PIPING PT B4.9.17 CLASS 1 PIPING PT B5.1.1 RC PU 3Al BOLTING UT l B5.2.11 RC PU 3B1 GSK SURFACE VT l B5.7.05 RC PU 381 PUMP INT. SURF VT B5.7,06 RC PU 3B1 PUMP BODY / VANE VT B5.3.03 RC PU 381 BOLTING VT B5.3.04 RC PU 382 BOLTING VT B5.6.01 RC PU 3Al BOLTING PT B5.6.02 RC PU 3Al BOLTING PT B6.6.01.01 RCV-10 PT B6.6.01.02 RCV-10 PT B6.6.02.01 RCV-11 PT Page 12 3
Nu ear RIgulatory Commission Attachment Comoonent Examinations (cont.)
IDENTIFICATION NO. COMP 0NENT NDE TYPE COMMENTS B6.6.02.02 RCV-11 PT
, B6.7.08 CFV-3 VT B6.9.05 RCV-9 BOLTING VT
- B6.9.06 RCV-9 BOLTING VT l B6.9.17 MUV-163 BOLTING VT l B6.9.18 MUV-163 BOLTING VT B6.9.19 MUV-36 BOLTING VT B6.9.20 MUV-36 BOLTING VT B6.9.27 RCV-11 BOLTING VT ;
B6.9.28 RCV-11 BOLTING VT !
C1.1.1 SG-1A VESSEL WELD UT C1.1.2 SG-1A VESSEL WELD UT C1.1.11 SG-1A VESSEL WELD UT ,
C1.1.16 SG-1A VESSEL WELD UT l C1.2.1A SG-1A VESSEL WELD UT/MT C1.2.1B SG-1A VESSEL WELD UT C1.3.1.1 SG-1A SUPPORT LUG MT C1.3.1.2 SG-1A SUPPORT LUG MT C1.3.1.3 SG-1A SUPPORT LUG MT C1.3.1.4 SG-1A SUPPORT LUG MT C1.1.3.C SG-1B VESSEL WELD UT C1.1.4 SG-1B VESSEL WELD UT C1.2.2A SG-1B VESSEL WELD UT/MT C1.2.2B SG-1B VESSEL WELD UT C1.3.2.5 SG-1B SUPPORT LUG MT C1.3.2.6 SG-1B SUPPORT LUG MT C1.3.2.7 SG-1B SUPPORT LUG MT C1.3.2.8 SG-1B SUPPORT LUG MT !
C1.1.5A DH COOLER WELD UT C1.1.6A DH COOLER WELD UT C2.1.111 CLASS 2 PIPING UT ER 96-2 ACCEPTABLE INDICATION AFTER ENHANCED UT IMAGING C2.1.111 CLASS 2 PIPING MT ER 96-3 ACCEPTABLE INDICATION AFTER ,
UT SIZING C2.1.117 CLASS 2 PIPING UT/MT C2.1.120 CLASS 2 PIPING UT/MT C2.1.130 CLASS 2 PIPING UT/MT C2.1.134 CLASS 2 PIPING MT C2.1.136 CLASS 2 PIPING UT/MT C2.1.139 CLASS 2 PIPING UT/MT C2.1.146 CLASS 2 PIPING MT C2.1.174 CLASS 2 PIPING PT C2.1.177 CLASS 2 PIPING PT C2.1.178 CLASS 2 PIPING PT C2.1.182 CLASS 2 PIPING PT C2.1.726 CLASS 2 PIPING UT/PT C2.3.11 CLASS 2 PIPING MT C2.3.12 CLASS 2 PIPING MT Page 13
l N ser R1gulatory Commission Attachment Reactor Vessel Examinations EXAMINATION AREA DESCRIPTION WELD IDENTIFICATION t
Flange to Nozzle Belt Circ. Bl.3.1A&B Weld at Z of 32.13" Nozzle Belt Intermediate Circ. Bl.2.3 weld at Z of 97.25" Nozzle Belt to Upper Shell Circ. Weld Bl.1.1 at Z of 162.25" l
l Upper Shell Long Seam at Theta Bl.1.2 of 72.37' l Upper Shell Long Seam at Theta Bl.1.3 of 252.37' l Lower Shell Long Seam at Theta Bl.1.5 of 110.06*
Lower Shell Long Seam at Theta Bl.1.6 of 290.06 Upper Shell to Lower Shell Circ. Weld Bl.1.4 '
at Z of 235.38" Lower Shell to Lower Head Circ. Weld Bl.2.1 at Z of 30B.50" 0* Core Flood Nozzle to Shell Bl.4.1A&B weld from the Vessel ID ,
0* Core Flood Nozzle to Safe-End Weld B1.6.1 0* Core Flood Nozzle Safe-End to Pipe Weld B4.5.266 30' Inlet Nozzle to Shell Weld from vessel ID Bl.4.3A 30* Inlet Nozzle to Shell from Nozzle Bore / Taper Bl.4.3A l
30' Inlet Nozzle Inner Radius from Nozzle Taper Bl.4.3B 30' Inlet Nozzle to Pipe Weld B4.5.221 90* Outlet Nozzle to Shell Weld from Vessel ID Bl.4.7A 150' Inlet Nozzle to Shell Weld from Vessel ID Bl.4.4A ,
4 150' Inlet Nozzle to Shell from Nozzle Bore / Taper Bl.4.4A l
150' Inlet Nozzle Inner Radius from Nozzle Taper Bl.4.4B Page 14
N etr Rigulatory Consnission Attachment Reactor Vessel Examinations (cont.)
EXAMINATION AREA DESCRIPTION WELD IDENTIFICATION 180* Core Flood Nozzle to Shell Weld from the Bl.4.2A&B -
Vessel ID j 180* Core Flood Nozzle to Safe-End Weld B1.6.3 '
180* Core Flood Nozzle Safe-End to Pipe Weld B4.5.271 210' Inlet Nozzle to Shell Weld From Bl.4.5A Vessel ID 210' Inlet Nozzle to Shell from Nozzle Bore / Taper Bl.4.5A l 210' Inlet Nozzle Inner Radius from Nozzle Taper Bl.4.5B 270* Outlet Nozzle to Shell Weld from the Bl.4.8A l Vessel ID 270* Outlet Nozzle to Pipe Weld B4.5.198 330' Inlet Nozzle to Shell Weld from Vessel ID Bl.4.6A 330' Inlet Nozzle to Shell from Nozzle Bl.4.6A Bore / Taper 330* Inlet Nozzle Inner Radius from Nozzle Taper Bl.4.6B i
Snubbers Functionallv Tested SNUBBER TAG # jl0Rf 0 STROKE MANUFACTURER CFH-13 2.5 5.0 Power Piping CFH-14 2.5 5.0 Power Piping CFH-17 4.0 5.0 Power Piping DCR-31 1.5 5.0 Power Piping DHH-18 2.5 5.0 Power Piping DHH-39 1.5 5.0 Power Piping DHH-661 2.0 5.0 Power Piping DHR-28 1.5 5.0 Power Piping EFH-27 2.5 5.0 Power Piping EFH-107 1.5 5.0 Power Piping EFH-144 2.0 5.0 Power Piping FWH-133 5.0 5.0 Power Piping FWH-140 2.5 5.0 Power Piping FWH-146 2.5 5.0 Power Piping FWH-156 2.5 5.0 Power Piping FWH-159 2.5 5.0 Power Piping Page 15 t
U.S. Nuclear Rigulstory Commission l 3F0896-12 Attachment Snubbers Functionally Tested (cont.)
SNUBBER TAG # BORE STROKE MANUFACTURER MSH-123A 2.5 5.0 Power Piping MSH-126 4.0 5.0 Power Piping MSH-150 5.0 5.0 Power Piping l MSH-167 4.0 5.0 Power Piping l MSH-575 1.5 5.0 Power Piping MSH-576U 1.5 5.0 Power Piping
, MSH-581 2.0 5.0 Power Piping l MUH-38 1.5 5.0 Power Piping l MUH-40 1.5 5.0 Power Piping l MUH-45 1.5 5.0 Power Piping l MUH-52 1.5 5.0 Power Piping l MUH-53 1.5 5.0 Power Piping RCH-26 2.0 5.0 Power Piping
. RCH-39 2.0 5.0 Power Piping
! RCH-52 2.0 5.0 Power Piping l
RCH-59 2.0 5.0 Power Piping RCH-84 2.0 5.0 Power Piping RCH-85 2.0 5.0 Power Piping RCH-87 2.0 5.0 Power Piping RCH-90 2.0 5.0 Power Piping RCH-530 1.5 5.0 ITT Grinnell
! RCH-531 1.5 5.0 ITT Grinnell l SWR-425A 1.5 5.0 Power Piping l SWR-440 1.5 5.0 Power Piping l SWH-493U 1.5 5.0 Power Piping i
l Snubbers Visuallv insoected l
l l
SNUBBER TAG # fLORE STROKE MANUFACTURER l CFH-13 2.5 5.0 Power Piping CFH-14 2.5 5.0 Power Piping l CFH-17 4.0 5.0 Power Piping DCR-31 1.5 5.0 Power P ;,ing DHH-18 2.5 5.0 Power Piping DHH-21 2.5 5.0 Power Piping DHH-39 1.5 5.0 Power Piping DHH-661 2.0 5.0 Power Piping DHR-28 1.5 5.0 Power Piping EFH-27 2.5 5.0 Power Piping EFH-107 1.5 5.0 Power Piping EFH-144 2.0 5.0 Power Piping FWH-133 5.0 5.0 Power Piping FWH-140 2.5 5.0 Power Piping Page 16 l
l
I
).
l Nu 3:r Rigulstory Commission Attachment i Snubbers Visually Insoected (cont.) ]
j SNUBBER TAG # Q ILORE STROKE MANUFACTURER l FWH-146 2.5 5.0 Power Piping FWH-156 2.5 5.0 Power Piping
, FWH-159 2.5 5.0 Power Piping
! MSH-123 2.5 5.0 Power Piping ]
MSH-126 4.0 5.0 Power Piping ,
! MSH-150 5.0 5.0 Power Piping l MSH-167 4.0 5.0 Power Piping MSH-575 1.5' 5.0 Power Piping MSH-576L 1.5 5.0 Power Piping MSH-576U 1.5 5.0 Power Piping MSH-581 2.0 5.0 Power Piping '
MUH-38A 1.5 5.0 Power Piping MUH-40 1.5 5.0 Power Piping MUH-45 1.5 5.0 Power Piping MUH-52 1.5 5.0 Power Piping ,
MUH-53 1.5 5.0 Power Piping .
RCH-26 2.0 5.0 Power Piping l RCH-27 2.0 5.0 Power Piping RCH-32 2.0 5.0 Power Piping RCH-33 2.0 5.0 Power Piping RCH-34 2.0 5.0 Power Piping RCH-35 2.0 5.0 Power Piping RCH-39 2.0 5.0 Power Piping RCH-40 2.0 5.0 Power Piping RCH-51 2.0 5.0 Power Piping RCH-52 2.0 5.0 Power Piping RCH-53 2.0 5.0 Power Piping RCH-54 2.0 5.0 Power Piping RCH-56 2.0 5.0 Power Piping RCH-57 2.0 5.0 Power Piping RCH-59 2.0 5.0 Power Piping RCH-61 2.0 5.0 Power Piping ',
RCH-62 2.0 5.0 Power Piping RCH-66 1.5 5.0 Power Piping RCH-82 EAST 2.0 5.0 Power Piping RCH-82 WEST 2.0 5.0 Power Piping RCH-83 2.0 5.0 Power Piping RCH-84 2.0 5.0 Power Pipint, RCH-85 2.0 5.0 Power Piping i RCH-87 2.0 5.0 Power Pipirig l RCH-88 2.0 5.0 Power Pipirg RCH-90 2.0 5.0 Power Pipin3 RCH-530 1.5 5.0 ITT Grinnell RCH-531 1.5 5.0 ITT Grinnell RCH-614 14.0 4.3 Paul Monroe RCH-620 14.0 4.3 Paul Monroe SWR-425 1.5 5.0 Power Piping ;
SWR-440A 1.5 5.0 Power Piping SWR-493L 1.5 5.0 Power Piping i SWR-493U l.5 5.0 Power Piping RCH-614 Page 17
. _ . _ . _ . . . . . _ . . . _ _ . _ . _--_______m
_ ____.__m_ . _ . . _ _ _ _ _ .
f I
S N ser RIgulatory Consnission f Attachment Comoonent Sucoorts COMP 0NENT TAG # COMPONENT DESCRIPTION ASME CATEGORY- t l DHH-11 SLIDING GUIDE Type A l DHH-643 BOX GUIDE Type B 4 EFH-117 CONSTANT SUPPORT Type C EFH-130 U-BOLT PIPE SUPPORT Type B FWH-75 VARIABLE SPRING Type C l
FWH-114 CONSTANT SUPPORT Type C FWH-141 SNUBBER Type C MUH-13 CONSTANT SUPPORT Type C .
MUH-14 VARIABLE SPRING Type C '
MUH-517 VARIABLE SPRING Type C i MUH-535 RIGID R0D Type A l MUH-583 U-BOLT Type B ,
MUHE-1B COMPONENT SUPPORT FOUNDATION N/A RCH-1A VARIABLE SPRING Type C i i RCH-66 SNUBBER Type C :
RCH-72 CONSTANT SUPPORT Type C RCT-1 COMPONENT SUPPORT LUGS N/A
! )
RCP-1B LINK BAR COMPONENT SUPPORT N/A :
RCP-1B CONSTANT SUPPORT Type C RCSG-1B COMPONENT SUPPORT SKIRT N/A ;
RCSG-1B LINK BAR COMPONENT SUPPORT N/A j SFR-1 ANCHOR Type A J SFH-533 RESTRAINT Type A !
SWR-182 RIGID STRUT Type A c
f System Pressure Tests l RW Nuclear Services and Decay Heat Seawater System l SF Spent Fuel Cooling System l MS Main Steam System l CD Condensate System
! RC Reactor Coolant System i MU Makeup System (requires testing outside RB for interval closure)
CA Liquid Sampling System l CF Core Flood System BS Building Spray System i
Page 18
r N sir RIgulstory Commissior.
Attachment NIS-2 OWNER'S REPORT C)I7 REPAIR OR REPLACEMENT REPAIR AND REPLACEMENT:
The following NIS-2 forms are attached in compliance with the requirements of ASME Section XI Repair and Replacement program.
WORK REQUEST # NAME OF COMPONENI REPAIRED / REPLACEMENT 320647 VALVE AND PIPING REPLACEMENT
- 33411 PIPE SUPPORT REPLACEMENT 308145 HANGER REPLACEMENT 308632 HANGER REPLACEMENT 331943 VACUUM RELIEF VALVE REPLACEMENT 316153 PIPING / PUMP SUPPORT REPAIR / REPLACEMENT 318827 STEAM GENERATOR REPAIR 333963 VALVE REPLACEMENT 324503 PIPING SYSTEM REPLACEMENT 334922 PIPE SUPPORT REPLACEMENT 329401 PIPING SYSTEM REPLACEMENT 325553 VALVE REPLACEMENT 334733 HANGER REPLACEMENT 319559 HANGER RFPLACEMENT 318740 HANGER Pi. PLACEMENT 307148 PIPE SUPPORT REPLACEMENT 307149 PIPE SUPPORT REPLACEMENT 307130 PIPE SUPPORT REPLACEMENT 307104 VALVE REPLACEMENT 298238 HANGER REPLACEMENT 319626 PIPE SUPPORT REPLACEMENT 316153 HANGER REPLACEMENT I
308890 HANGER REPLACEMENT 308860 HANGER REPLACEMENT 308141 HANGER REPLACEMENT '
332599 THRU 332606 PIPING SYSTEM (THERM 0 WELLS) REPLACEMENT 307088 HANGER REPLACEMENT 307071 PIPE SUPPORT REPLACEMENT 307085 PIPE SUPPORT REPLACEMENT 307089 HANGER REPLACEMENT 307087 HANGER REPLACEMENT 320648 VALVE REPLACEMENT 319003 PIPE SYSTEM REPLACEMENT ;
332100 VACUUM RELIEF VALVE REPLACEMENT 325420 VALVE (S) REPLACEMENT 325843 STEAM GENERATOR REPAIR 326545 PIPE SUPPORT REPLACEMENT 325418 VALVE (S) REPLACEMENT Page 19
)
l l
U.S. Nucts:r Rigulatory Connission 3F0896-12 Attachment REPAIR AND REPLACEMENT (CONT) j WORK REQUEST # NAME OF COMPONENT REPAIRED / REPLACEMENT 334085 PIPE SUPPORT REPLACEMENT ,
326542 PIPE SUPPORT REPLACEMENT 326478 PIPE SUPPORT REPLACEMENT 319425 VALVE SUPPORT (S) REPLACEMENT 326499 PIPE SUPPORT REPLACEMENT F
f L
l l
Page 20
NIS-2 OWNER'S REPORT OF REPAIR OR l
l 9""*""" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI l
l O M ER Florid 3 Power Corporation DATE I'
P.O. Box 14042 gq3,p SL Petersburg, FL 33733 4042 ,
l PLANT Florida Power Corporation l l
Crystal River Energy Complex dnit-3 1
15780 W. Power Line Street i Crystal River, FL 34428 8708 Page / of 2 i
VORK PERFORMED BY (NAMQ REPAIR ORGANIZATION P O NUMBER. WR NUMBER. ETC. I 0'
FLD21bA PotdEt: cc2P. WR 32064 7 !
ADDRESS
/57bD W. Pou!Erl LJME S7' CRYERL RIVER ~ > FL 3'19Zt3 IDENTIFICATION OF SYSTEM
- 4. m APPUCABLE CONSTRUCTION CODE EDITION ADDENDA. CODE CASES Sa. ygpS g3,_ , , , S ay (og (gg g3; .g g APPUCABLE EDTION OF SECTION XI UTluZED FOR REPAIRS OR ADDENDA. CODE CASES Sb. REPLACEMENTS l jy g3 .SW3 ADDEa/A9
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED. REPLACED C'.MPON ENT MANUFACTURER SERIAL NUMBER BD.NO. IDENTIFICATION BUILT OR REPLACEMENT yts NC t/hU/G AWitDC Mat.Irg E- 2 602-I-I N/A MSV-l%4 MA REf2AGHM x l P2PIAlle SYJ12M W//1 WM W/A N//) N/A REhACB1EAfr x 1
P 11/94 RET; Life of Plant RESP; Nupeat Engmee<mg 900 431 l
NIS-2 CONTINUATION N4 320647 paa. 2 of 2.
$ Af g- 5 g D c;- 4% 7j g yf ( y DESCRJPTsON OF MORM R&h.ML L/ALU2 /?MD LEc77od of l'/G OA) ik?l ~Tl= DF VAlt& /W 4] ECD /AIC-7.
'ESTS C" OUCTED PRE 55vRE 'E5TTEMP ydrost. tic 0 en.um.i. O womin.i op.r. tina pr...ur. Ooin., //4o a .' 77- *F REMARKS IINCLUDE MANUF ACTURER $ DATA REPORT NUMBER IF APPLICABLE)
NOAIE 9.
CERTIFICATE OF COMPLIANCE Wa certify that the statements made in this report are correct and this Repair dReplacement conforms to Szction XI of the ASME Code.
, m C#4ER OR C#dE B c. St$ N SIGN $TURE LTLE La!E L 'le *%2* t P4 L b49(fCA 7 a
[o
/
t CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of Ekbt)4 ,
employed by W /88 7 5/l (o - of
- eW7 era > C7~ have inspected the components described in this Owner's Report during the period /- 6' % to
~7- 29 -96 and state that to the best of my knowledge and belief, the Owner has l performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither
- the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
/+4 A A66d NB 7tKO AAlc/ R W Inspector s sioNAruRE cowuissiONs (NATIONAL BOARD, STATE, PROVINCE OR ENDORSEMENTS) 7-29-96 DATE 900 431 Page 2
l l
NIS-2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS 9""*""" OF ASME CODE SECTION XI l
OMER Floridi Power Corporation DATE
- 1. P.O. Box 14042 St. Petersburg, FL 33733-4042 6 % l ptANT Florida Power Corporation
- 2. Crystal River Energy Compiex.uve r s !
15760 W. Power Line Street l Crystal River, FL 34428 6708 Page / of 2 VWORK PERFORMED BY (NAME) REP AIR ORGANIZATION, P O NUMBER, M NUMBER. ETr.
3' RDetM RNFK Chef. 33341l
, ADDRESS l 15740 W. ibitu LINE JZ. CMJ7K A///67e FL 3%2B o 1
IDENTIFICATION OF SYSTEM j 4. y APPUCABLE CONSTRUCTION CODE EDITION ADDENDA, CODE CASES Sa.
gggg g3;;,4 , , (, .y 9,4 APPUCABLE EDTION OF SECTION XI UTluZED FOR REPAIRS OR ADDENDA, CODE CASES l Sb. REPLACEuEurS 1923 .5 83 AWalM i
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED COMPONENT MANUFACTURER SERIAL NUMBER BD. NO. IDENTIFICATION ButLT OR REPLACEMENT vEs NO l PIPE Ju/RvfI PDW Pl!!& NM ^'!A SkN- 4W UIA MME^ff V i
)
SWH-So& V l .5WH- So1 y l
1 JwH Std v
! StuH ES.C v Jtot 36I /
< , , , swk. 36Z. , ,
/
l i
i 11gM RET: Lde of PierW RESP: Nuclear Engmeenng 900 431
(
l l
NIS-2 CONTINUATION l
P.ge 2. of 2.
DESCRIPTION OF MRK RBukE 'd" 6NZ3 s 30L75, Adb NUT.E .
7.
)
PRESSLRE TEST TEMP TESTS CONOUCTEG O Nomin.i oo.r.i ng pr...ur. Ocinc, N/A pi e///F *F O svaro.i.ie 0 en.um.i. <
REMARAS (INCLUDE MANUF ACTURER'S DAT A REPORT NUMBER. IF APPUCABLE) 1 l hbA/S l 9. l l
1 l
l CERTIFICATE OF COMPLIANCE i
We certify that the statements made in this report are correct and this Repair Replacement conforms to j
Ssction XI of the ASME Code.
hTLE DATE QWNER OR OWNER S D Gh FE S4 NA 'U a
_. ms hinopat Eeu e 7/zu e
l 1 l
CERTIFICATE OF INSPECTION
! I, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel I inspectors and the State or Province of Roca4 ,
employed by 7%: 4 M To e S m r o w s*<c T/I(o of l have inspected the
- e n%ea .c7-components' described in this Owner's Report during the period /- 6 '7 6 to l
7-4o-14 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
l By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, I concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither
! the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a
'oss of any kind arising from or connected with this inspection.
b6 WNE Nd rhD Anti R./W lNSPECToR'S SIGNATURE COMMISSIONS (NATIONAL BOARD. STATE. PROVINCE OR ENDORSEMENTS) 7-3o-96 oATE eoo m en.1
Og Power NIS-2 OWNERoS REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI l
I OWNER Florida Power Corporation DATE !
P.O. Box 14042 St. Petersburg, FL 33733-4042
/
7/ 79 plf
)
I 2*
^"' "'"'"**'*" l Cryotel River Energy Complex-Umr3 ;
15760 W. Power Line Street l Crystel River, FL 34428-6708 Page [ Of L l WORK PERFORMED BY (NAME) REPAIR ORGANI2ATION, P.O. NUMBER, WR NUMBER, ETC. .
S a m R w ere A m /
n!e noswT~
ADDRESS
/s 7/d) 4) Awee bM Zr, IDENTIFICATION OF SYSTEM
, 01xnx S W R MV2'Y '
i Dwy MT l APPUCABLE CONSTRUCTION CODE EDITION ADDENDA, CODE CASES l
l/cM BSJ. ) 194'? #
APPUCABLE EDITION OF SECTION XI UTIUZED FOR REPAIRS OR REPLACEMENTS ADDENDA. CODE CASES <
/Qff h9ntp6;( /@E Y.
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED CpPONENT MANUFACTURER SERIAL NUMBER BD, NO. IDENTIFICATION BUILT OR REPLACEMENT YES NO ,
]Yh$ 1 Y $ N ~ llL ll}$ ? r / /, 7 (ALACCM(4 T l
l I
l 11/94 RET: Lde of PierW RESP. Nuclear Engineeeen0 000 431
NIS-2 CONTINUATION DESCRIPTION OF WC4A tvd 3o6/</f P.ge Aof b
/h een Al w a A nwem Err 7.
TESTS CONDUCTED PRESSURE TEST TEMP.
O sve,.. .tio O en.Um.tio O womin.i op.,.iin, e,.S.u,. O ots., p$i r a/ei sv4 REMARKS $NCLUDE MANUFACTURER'S DATA REPORT NUMBER,IF APPLICA.LE)
Alert?
9.
CERTIFICATE OF COMPLIANCE W3 certify that the statements made in this report are correct and this O Repair %Repi.coment confo,ms to Section XI of the ASME Code. '
OWNER OR OWN S TITLE DATE I Ef Si ATURE V//
-- sktM L Eac,.afre dak
'I l
1 l
CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of ravuM ,
employed by 7:W NJ/5 J / J (o of M/#Tath , c7 haveinspected the components described in this Owner's Report during the period _ /-B to {
7-3o46 . and state that to the best of my knowledge and belief, the Owner has '
performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or I implied, concerning the examinations and corrective measures described in this Owner's Report.
Furthermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury i or property damage or a loss of any kind arising from or connected with this inspection.
4c$//44sW INSPECTOR'S SIONATURE A/B 72@ $AX/ ft /'M '
COMMISSIONS WATIONAL BOARD, STATE, PROVINCE OR ENDORSEMENTS) 7 9 6 DATE soo 431 Page 2
O NIS-2 OWNER'S REPORT OF REPAIR OR 9'*"'""" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI OWNER Florida Power Corporation DATE P.O. Box 14042
/
St. Petereburg, FL 33733-4042 7/29 f(f
*"' 'd*"**'*'"'*"
2* Crystal River Energy Complex .u u,7 3 15760 W. Power Line Street Crystal River, FL 34428-6708 Page / of b WORK PERFORMED BY INAME) REPAIR ORGANIZATION, P.O. NUMBER, WR NUMBER, ETC. -
A c M d <ct 0 p. 102 302682-ADDRESS
/574610. bawe IDENTIFICkTION OF SYSTEM bd6' $rerr > 6eK7Al Sws R EVV2/
l l
h alv / v r
/CONSTRUCTION CODE EDITION ADDENDA, CODE CASES 5a. APPUCAyBLfjg g 3 j, j ,, g7 _ _
APPUCABLE EDITION OF SECTeON XI UTru2ED FOR REPAIRS OR REPLACEMENTS ADDENDA, CODE CASES MP3 SawseiW3 /GJJ.
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED COMPONENT MANUFACTURER SERIAL NUMBER SD. NO. BDENTIFICATION BUILT OR REPLACEMENT YEs NO
/
/ 1ANfY. $Y6 '
NA NA EYY-5/3 Ub E: .'9 = : V hk7tAcanedT O, Y . CN y
l 11/64 RET: Ufo of Plant RESP. Nuclear Eremeesm0 000 431
l NIS-2 CONTINUATION i
g e.g. Z oe Z_ i DESCRIPTION OF WORK hk hY Mlhhhh? k$
7.
l
- ESib CONDUCTED PRESSURE 7EST TEMP Hydrost. tic 0 en.um.ie O nomin.i oper. tina pr...ur. e>/4 psi e//g 5 O oin r HEMARKS (INCLUDE MANUF ACTURER'S DAT A REPORT NUMBER. IF APPLICABLE) j AlocE 9.
l l
CERTIFICATE OF COMPLIANCE i I
Wa certify that the statements made in this report are correct and this Repair kReplacement conforms to Ssction XI of the ASME Code. l QWNER OR OVWJER'S slob GHAT E TITLE DATE h,ww bavanz 7!29 C.
/ ,/
~
' i CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of /2oc/M ,
employed by 7M #4f r/JG . of AM"/WA er- have inspected the I components described in this Owner's Report during the period /-8-% to
~7 9 4 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither !
the inspector nor his emplofsr shall be liable in any manner for any personalinjury or property damage or a l loss of any kind arising from or connected with this inspection.
)41sd,6def A41 rsm MtJ & /4[
INSPECTOR'S SIGNATURE COMMIS$10NS (NATIONAL BOARD. STATE. PROVINCE OR ENDORSEMENTS) l i 7-so 44 f DATE I
l 900 431 Page 2
i l
l NIS-2 OWNER'S REPORT OF REPAIR OR i
9"~" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI l
OVWER Florida Power Corporation DATE 1* P.O. Box 14042 St. Petersburg, FL 33733-4042 7~/'70 l ptANT Flor 6da Power Corporation
, 2. Cry. tai Rev.r Energy Compien 15780 W. Power Line Street Crystal River. FL 344284708 Page / of 2 VWORK PERFORMED BY (NAME) REPAIR ORGANtZATION, P O NUMBER. VWR NUMBER. ETC.
3*
Fwr.t.A4 fawE< cor.P. 4//2 3.5/94'3 ADORESS
/S 74 o W. A 4/C 4 /JntE J i -~
cits.tru. A%gra, ic i? Jq4&8 IDENTIFICATION OF SYSTEM
- 4. y APPLICABLE CONSTRUCTION CODE EDITION ADDENOA, CODE CASES AGf6 JEc71rr/ V/// 19 W N/A APPLICABLE EDITION OF SECTION N UTILIZED FOR REPAIRS OR ADDENDA, CODE CASES Sb. REPLACEMENTS
/983 583 do MA/M
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED COMPOPvENT MANUFACTURER SERIAL NUMBER BD. NO. IDENTIFICATION BUILT OR REPLACEMENT vgs No
}WCUOM 4At04W.JOAl W$ Wsf bN//-7$ $N hMW N wrFmue 6tas/4xob l
l l
l l
11794 RET: LWo of Pteret RESP; Numeer Eng'aeonag 900 431
NIS-2 CONTINUATION Pag. 2 of g DESCRIPTION OF VORK REPtacE Ct.D val.V6; 7.
PRE 55uRE TE$T TEMP
'E$TS CONDUCTED
- 8. O mro.i.= 0 en...i.e O womin.i o,. rating Pressur. O om., "/4 pai ## 'F HEMARKS (INCLUDE MANUF ACTURER S DATA REPORT NUMBER IF APPLICABLE) i M?t Ys 72EriTD k JP-Co *Z .
9.
CERTIFICATE OF COMPLIANCE Wa certify that the statements made in this report are correct and this O Repair Meptacement conforms to Section XI of the ASME Code.
TITLE LA76 a
Q#dLR OR C#4 iQtgE{iGNA URE r '
L'-i 0nnenL Erwrn1L 8l1NG
/f 1
- CERTIFICATE OF INSPECTION I, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel inspectors and the State or Province of ,,_ft 04/04 ,
employed by 7'df H4/?IN~ H3 M */c&z I/ZCo . have inspected the of I
// M di) , 7 components described in this Owner's Report during the period A 6-7 6 to i-A f4 and state that to the best of my knowledge and belief, the Owner hss performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a j loss of any kind arising from or connected with this inspection.
/s /., /M A/G 79t** AAFC/ F t. / W INSPECTOR'S SIGNATURE COMMISSIONS (NATIONAL 80 add. STATE. PROVINCE OR ENCORSEMENTS) iW-%
DATE 900 431 Page2
)
j NIS 2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF l g ASME CODE SECTION XI
..a
- a .4 anion.i .p. is n.e....ry, u.. soppi.m.ni.i wis.2 osmam 93-o665 part Fionda Power Corporation 1-P. O. Box 14042
- St. Petersburg, FL 33733 4042 Ikg y 93 j i
- n. ant norms Power cesp.
g, Oped Rher Energy Comphs 187s0 W. Power the sweet Oped power.M.3442s470s Page 1 of 2 wann eenrosenen = ae nuam omwmanon.e.o. =wout a nuusu Em Florida Power Corp. Work Request # 3)415 3 l
- 3. o 15760 W. Power Line Street, Crystal River, FL. , 34428 semacanon or - =
A. I g .
an.pcame comemcon coas anmaa ^omaa, coot casa
" USAS B3 \.1 1s69 331-as cates acr. me mums annom o, menom a man con acrase on acew.aons anotaos. coot caus '
1983 Edition Sununer 1983 Addends.
- a. Identification of Components Repaired or Replaced and Replacement Component.
suunt OF NAMEoF MANUFACTURER'S NADONAL OTHER YEAR REPAIREB. AMACED '$"/.E coupoNENT MANUFACTURER SEAtAL NUN.ER 80. NO. IDD(nnCAnoM DUILY OR REPLACDdDet vu ! e
'Ploiw G NA NA uA un un Gema /
Pusp N/A N/A W/h ib H- sa9 @ lea m uWI V
.50 % 0.7 I
I a . nas e a , w am um em a.-- er ei
A ,
4 N43 NUWSim
- lS bb4G NIS 2 CONTINUATION Pa08 2 of 2 oEscalPfeON OF womm G R.WD k %-(4 ELD LJPPER FLAN GE ro PIPE OtSco MFFQFdTlK BtlTT @lb . SPoeL ASSEM 8 L'/ 15 t.o c4 r6D dPSTEEAM o f esp-t5 , RE9 TACE MAtJ &cR, PmES&uant itsis TEWP TESTS CONouCTEo E O Hydrostatic O Pneumatic 12( Nominal Operating Pressure O Other 36 psi S S' 'F mEuAmma ONCLuDE MANUFACTumtm~S DATA REPORT MuMDER. IP APPUCASLO
'"& 5'a.. rot coseodeaT .soeFbdT : OS AS 631.1 - 1967 .
s.
CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this % Repair O Replacement conforms to Section XI of the ASME Code.
e n ._
owwgm On T E DAff bww{m5 ofsah (( &aGNATumi raimem. E,u,la, e a ,mc i
[ _t k/. v v/m j
a 5
F .
CERTIFICATE OF INSPECTION 1, the undersigned, holding a vahd commission issued by the National Board of Boiler and Pressure Vessel inspectors and the State or Province of EM employed by N NI O of N ACTO LD # C have inspected the components described in this Owner's Report during the period 3# to VIdb and state that to the best of my knowledge and belief, the Owner has performed v:xaminations and taken corrective measures described in this Owner's Report in accordance with the resquirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, espressed or implied, concoming the examinations and corrective measures described in this Owner's Report. Fur.
thermore, neither the inspector nor his employer shall be liable in any manner for any personal injury or property damage or a loss of any kind arising from or connected with this inspection.
Ad f M A)$ 7$3 0 kWC/ R/fd' COWW151 eon 5 (8sAttoh&L SoanD. StaTt PmovimCg ca thDoRSIWENTsi estiPECfon t SIGNatumf l-/-96 oATE
) !
l PAGE 2 goc 431
9 NIS 2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI wrw muusta N additional space is necessary, use Supplemental NIS 2 ownsa f#-/f33 Florida Power Corporation cars 1*
P. O. Box 14042 St. Petersburg, FL 337334 042 / /
ev=r rw w. pow. Corp.
f/7P/$p
,, C W Nv. Enww Compia 15700 W. Power uno Street Crystal Nver. R.34426 e70s Page / of 8 moam novonuto e, game naram omoAmuanop. e.o. woupta, me muusta, etc.
EL O/2/D A TC N f A D A.R N5Y AS$UOY Neo 3jQg7
- a. ano iSw e J. pcida t. air.srtrET, cessr:4L Ri/64, n. 3f4ze
- - or ., r.
fC
- .ooo,x con can. i
$fif 4G7kn.eu co 1,mo.,h 6M L 1e K muca.a inmon o, ucno= = ummo con apua on apuctutun anoo.m. com cases
.Summea 6 7 - -
/983 ED)770A/ SMMEl /983 ALIDCA/Di9
- 4. Identification of Components Repaired or Replaced and Replacement Components staast OF NAmt oF ttAMUFACTURER'S NATIONAL. OTHER YEAR coespoNENT MANUFACTURER AEPAIRED, REPLACED $E SERIAL NUMsER 80. No. IDENTIFICATIoM BUILT OR REPLACDierf vos no !
.,ST&1py BA6cw 4 6 FN C7'A ToA'. (U.'l CCx 8E6 d @ 7~55~- E A/-/2 O kCM-18 /97/ Act'nin. V
.. -, - -- _ :_.. a :. -- .n
% nas art: us. ,w asse: == - em A -. me e
t i
I
=.5:munesa I 94-6(83 l NIS 2 CONTINUATION Page E of f
, -- - -o-l A/CONJF St<tf7 RVs~ ? URD m a O ac cf en7c l Acasts sNaravs/nts.
s
- vests comoucteo paassuns vsers fue E O Hydrostatic g Nominal Operating Pressure l 0 Pneumatic O Other qcO pel 5% 'F 1 SSAAfMES pscLUos MANuPAcTusERs DerA RepoNt asuussa,IP AppWCAeLS j
j
! E l
.i s
CERTIFICATE OF COMPLlANCE We certify that the statements made in this report are correct and this [ Repair O Replacement conforms to Section XI of the ASME Code.
a( )
i ses ~ s osassa on b - iv o.og34 (ynearwas t e iec t P4 L bauurd ears7 [3I 1W=
/ l F 7 CERTIFICATE OF INSPECTION
^
- l. the undersigned, holding a valid commission issued by the National Soard of Boller and Pressure Vessel inspectors and the State or Province of MM employed by N N8INO
- of
/MNO I have inspected the components described in this Owners Report during the period MM to NO - and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owners Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concoming the examinations and corrective measures described in this Owners Report. Fur.
thermore, neither the inspector nor his employer shall be liable in any manner for any personal injury or pro any kind aris f con led w this inspecilon.
seseectons sinuvuna comuassons pAticut sonno. stats. Psoveses on smoonssuons IW$$
- mes Y
PaOE 8 m c1
NIS-2 OWNER'S REPORT OF REPAIR OR l
REPLACEMENT AS REQUIRED BY THE PROVISIONS i
OF ASME CODE SECTION XI i
OMER Flor 6da Power Corporation DATE P.O. Box 14042 /
St. Petersburg, FL 33733-4042 7 / /%
PtAgt Flor 6da Power Corporation
- 2. '
Cryst : Rev., En.rgy Compi.x - va / 3 15780 W. Power Line Street Crystal River, FL 344284708 Page [ of 1 VORK PERFORMED BY (NAMQ REPAIR ORGANIZATION, P O. NUMBER, WR NUMBER. ETC.
F/or: A Powe- G e o. 333 % 3 ADDRESS 1524.0 w. (%. < L ; n $ 4. dr nd! Pu v e .' /=L ?W 2 2 IDDmFICATION'OF SYSTEM /
- 4. g APPUCABLE CONSTRUCTION CODE EDTION ADOENOA, CODE CASES Sa~* ----
)
A stM S cen iou n.t. , C L 1 19 G5 b e.2 G 7 Acomon ,
APPUCABLE EDITION OF SECTION XI UTluZED FOR REPA;RS OR ADOD40A, CODE CASES Sb. REPLACEMENTS t *\E % 2cm&. .S o m c a 83 Accenoa l
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED COMPONENT MANUFACTURER SERIAL NUMBER BD.NO. IDENTIFICATION BUILT OR REPLACEMENT vEs NO Atuc kwrbo ba.iu a4 - W y G hA gc,gf . : 3 o s4 kg g4cy,g g y g 1
i l
9gm RET: Life of Plant RESP: Nuoser Engmeermg 900 a31
- * , wp eee **- ~.
o" NIS-2 CONTINUATION W/4 53 5 % 3 P.g. 2 of 1 DESCRIPTION OF WORK Re at n e e.l O lcl Udue 7.
T E ST S CONDUCT ED PRES $URE 'EST TEMP Owyero.i.i. Opn.um.i: O nomin.i on r. tina pr...ur. Motn.r O/g
/
p.i 4//#
- F REMARKS (INCLUDE MANUF ACTURER'S DAT A REPORT NUMBER. IF APPUCABLE)
None CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this Repair [ Replacement conforms to Srction XI of the ASME Code.
0#4ER OR OVW4E G* EtPGN TURE TITLE DATE o . . n -- Mt bauartE 'Ib e/ /
CERTIFICATE OF INSPECTION I, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of /Ecca4 employed by 71M= HJA I /I L of
/M/>* XTS , c7' have inspected the 1
~
components described in this Owner's Report during the period /-8 4 6 to 7- x -96 . and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the Inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
) di AC 4 da d INSPECTOR'S SIGNATURE 267s'sD ANU R /%'
COMMISSIONS (NATIONAL BOARD. STATE. PROVINCE OR ENDORSEMENTS) 7-3o 4 6 l j
DATE 900 431 Page 2 l
NIS-2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS 9""*""" OF ASME CODE SECTION XI I
OMER Florida Power Corporation DATE I* P.O. Box 14042
/
St. Peter. burg, FL 33733-4042 7df %
PLANT Florida Power Corporation
- 2. '
Cry.t : Rev.r En.rgy Compi.x - va / 3 7 157s0 W. Power Line Street 4
Crystel River, PL 3442s470s Page / of 1 VORK PERFORMED BY (NAME) REPAlR ORGANIZATION. P O NUMBER. Wt NUMBER. ETC-V/or-:ds 90 w, ( oc o. 32.4503 ADDRESS I 5 ~7 6 0 w. P c w., t. ; n 54. Cr nd! R.~ '
i=L 4422 IDENTIFICATION'OF SYSTEM /
ac.inu APPUCABLE CONSTRUCTION CODE EDrTION ADDENDA, CODE CASES EE EMAMS 19 APPUCABLE EDITION OF SECTION XI UT1UZED FOR REPAIRS OR ADOENDA, CODE CASES Sb. RenACEMEurs 14 83 G otrio*4 .5 ue e e S *3 4omenoa
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED 4 o CLMPONENT MANUFACTURER SERIAL NUMBER BD. NO. IDENTIFICATION BUILT OR REPLACEMENT YEs No R,.. .serms Jn da ~l a
, n)A n/4 Aca r v O
qqg PE7: Lde et Plant R88P: Nucseer Engweermg 900 a31 e .;- ***p '
- { ' ~ _
s .
JP NIS-2 CONTINUATION Page)ofd l 4/4 B2.4A3 DESCR;PTION OF WORK fD dL t f f" M fftvf $0L f-n L4
/
we i d t n t L *s a c e ,, + do t*10v - %
d d TESTS CONDUCTED PRESSURE T EST TEMP
'F h Hydrostatic 0 Pn.umat. O Nominal Operating Pressur. O oin.r 7 35c> pai r37 REMARKS (INCLUDE MANUF ACTURER'S DATA REPORT NUMBER IF APPLICABLE)
- BC Sys ef,, : VSAs 6 31.3 , 1968 % tu 9 &,-s Mu fu sk , f l/545 8 31.) !
. /161 C o.e. C<se N31 -9 3 i
CERTIFICATE OF COMPLIANCE Wa certify that the statements made in this report are correct and this Repair h Replacement conforms to Srction XI of the ASME Code.
/1' OWNER OR R DE ONEE GNATURE ' E DATE et em A 7 9 kC f / /
CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of FasM employed by 7W M6Z4TCo. of W W N b ,c7' have inspected the components described in this Owner's Report during the period /-6-96 to 7-5o-90 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
/
bdp4NV N619 ANYJ FL /W INSPECTOR'S SIGNATURE COMMISSIONS (NATIONAL BOARD. ST ATE, PROVINCE OR ENDORSEMENTS) 1 - h - 9 (s j
DATE l
I 900 431 Page 2
_JL
i NIS-2 OWNER'S REPORT OF REPAIR OR :
"""~" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI .
I OVWER Florida Power Corporation DATE P.O. Box 14042 St. Petersburg. FL 337334042 72 N l ptANT Florida Power Corporation
- 2. c,y.t.: Riv., Energy Compi.x 15780 W. Power Line Street Crystal River, FL 3442B4708 Page / of 2, work PERFORMED BY (NAMQ REPAIR ORGANIZATION, P O. NUMBER, %R NUMBER. ETC.
ele e.s o A oto e.t C.o't coR A Tion 4)4 # 33 4R 2,2_
ADDRESS IS%O (d. ScJ ee. Levet St. b e.ysto c k we a., El. .3442.,6
- DENTIFICATION OF SYSTEM Su !
APPUCABLE CONSTRUCTION CODE EDITION ADDENDA. CODE CASES O5AS G 31.1 19 6") N/4 APPUCABLE EDITION OF SECTION XI l'TIUZED FOR REPAIRS OR ADDENDA. CODE CASES Sb. REPtACEueNTs 1983 6 etrieg S u m e e. 83 A o Dc+s c A
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR COMPONENT MANUFACTURER REPAIRED REPLACED o SERIAL NUMBER BD.NO. IDENTIFICATION BUILT OR REPMCEMENT yes No j N L,.o b 2,. n/4 uh sea uu A uh br.eney r /
l' 11/94 RET: Lde of Plant RE$P: Nuclear Engineering 900 431
l '
l -
l NIS-2 CONTINUATION l 4/4 ,$M 931,,, P.ge of DESCRIPTION OF WORK Ltw '
6a. '
Ikk M '
De I J In s K- A4
/
'ESTS CONDUCTED PRESSURE TEST TEMP Ootn., 5 O svoro.i.i.e 0 en.um.iic 0 uomin.i op.r.i.no a r...ur. /v//t.
poi aff#
NEMARKS (INCLUDE MANUF ACTURER'S DAT A REPORT NUMBER, ,F APPL, CABLE)
N1 $
8 9.
CERTIFICATE OF COMPLIANCE Wa certify that the statements made in this report are correct and this Repair Replacement conforms to Section XI of the ASME Code.
/3 QWNER OR O 'S , rITLC DATE
>SFNE[Si NATURE
- , < /Ro M ac buaAL 'ffk1 G
- ,, n a l
1 CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of /umM employed by 7%F Nd IVf G . of v44r7wb , c7- have inspected the components described in this Owner's Report during the period /- P- 96 to 7- w f4 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures desenbed in this Owner's Report. Furthermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
Jh h kb Nb 7$4D AAlCl /~g / */[**
INSPECTOR'S SIGNATURE COMMISSIONS (NATIONAL BOARD, ST ATE, PROVINCE OR ENDORSEMENTS)
,- u- e i.
DATE l
900 431 Page 2
l NIS-2 OWNER'S REPORT OF REPAIR OR 9........... REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI l
OMER Florida Power Corporation DATE P.O. Box 14042 St Petersburg, FL 33733-4042 %
PLANT Florida Power Corporation l
- 2. c ,y ,,,,ai,,,gn ,,,com pi ,. v.,y 3 !
15780 W. Power Line Street Crystal River, FL 34428-6708 Page [ of 1 tWtK PERFORMED BY (NAME) REPAIR ORGANIZATION, P O. NUMBER. VWR NUMBER. ETC.
R oc:da Pow , ( <> r o. 32 % 01 ADORESS I51so w. pw c L- 5 /. Crn sI ! R ve<- F' ~3 Y 4 '2 2 ocunnCAnON OF sysTEu / '
65
~ ~ ~ " " * """ ^ "* " '***
Sa.
USA 5 (b 'a l . 'l 19 6 % C.c oe C.ese GJ i- B3 APPUCABLE EDITION OF SECTION XI UTIUZED FOR REPAIRS OR ADDENDA. CODE CASES Sb. REPLACEMENTS (403 E oirnov Som e.e. 8 3 A Ooeuo4
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR COMPONENT MANUFACTURER REPLACED s o SERIAL NUMBER BD.NO. IDENTIFICATION BUILT REPAIRED'ACEMENT OR REPL vgs NO M % ren n/a ah ak ula ah Rerwe~ ear /
l i
l 1
{
i
)
i i
9w4 PET; Lee of Plant RE$P: Nuoear Eng+neenng 900 431 I
o NIS-2 CONTINUATION
/#8 32940/ Page 2 of 1 DESCRIPTION OF WORK n 4 Y /SC 0 %&H= $A ,a w rit*e kr*O L 7-AAJ w 4 -A, vor- r3 5g - e r 3 TESTS CONDUCTED PRESSURE TEST TEMP 5
Hydrostatic 0 Pn.umatic % Nominal Operating Pressure 0otner 35 psi 65 REMARKS ONCLUDE MANUF ACTURER'S DAT A REPORT NUMBER. IF APPUCABLE) 9.
CERTIFICATE OF COMPLIANCE W3 certify that the statements made in this report are correct and this Repair Replacement conforms to Szction XI of the ASME Code.
.1
,fD
- OWNER OR OWNE hTL DATE flE +GNEE $NA RE L b.
' l
__ _ us,et/ A t m a n V__ 'T /feb i I CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel l
Inspectors and the State or Province of Roc /o# ,
employed by 77E H/t? WTCo. _
of necrNb # have inspected the components described in this Owner's Report during the period /-8 '/6 to
~7 '14 4 6 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
4 t4-1 A d 6 6 A/d75Yo AWC/ fc/h' COMMISSIONS (NATIONAL BOARD, STATE PROVINCE OR ENDORSEMENTS)
INSPECTOR'S SIGNATURE 7-3o-%
DATE l
900 431 Page 2
i
=
f
% NIS-2 OWNER'S REPORT OF REPAIR OR Power REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI I
i omet Fionda Power Corporation DATE 1* P.O. Box 14042 St. Petersburg. FL 33733-4042
//
7/E /%
PLANT Florida Power Corporation I #
l
- Crystal River Energy Complex - Va/ 3 15780 W. Power Line Street Crystal River, FL 34428 6700 Page / of 1 vcRK PERFORMED BY (NAME) REPAIR ORGANIZATION P O. NUMBER. VWt NUMBER, ETC.
f/oc : ch Powc, G cp. 3 :% 5 5 5 3 ADDRESS 1 5' 7 c, o w. (' c w< < L;ne 5l. d r' n r M IG- r l= L 'V422 noENTwiCAnON'Or sysTEu /
4' tis APPUCABLE CONSTRUCTION CODE EDITION A00ENDA, CODE CASES 5'-
e 3i.1 ao ~/o APPuCAstE EanON OF SECTION XI UTIUZED FOR REPAIRS OR ADDENDA. CODE CASES Sb. REPLACEMENTS 1963 Eo,.T,x 50-c a. 83 AnoE-u
- 6. Identification of Componerits Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED o COMPONENT MANUFACTURER SERIAL NUMBER BD.NO. IDENTIFICATION BUILT OR REPLACEMENT vES NO AL4G (sHC2 NfA H A n3 d ' 2. (, HfA kCptACEH cut" W '
1 i
l t
1144 RST: Ldo of Plant RE $P: Nuaoer Engineenng 900 431
1 NIS-2 CONTINUATION l De3Escs3 p.e. 3 at 7 oeScRiPriON OF u;rm 1 f () L rr h n n t' wF
/
- 7. ;
l i
1ESTS CONDUCTED PRESSURE 'ESTTEMP O s varo.i.ile 0 en.um. tic $nomin.iop.r.tinar...ur.e Ooin., goo poi Sao 5 REMARKS (INCLUDE MANUF ACTURER'S DAT A REPORT NUMBER. IF APPLICABLE) 9.
l l
l l
CERTIFICATE OF COMPLIANCE ilblO W3 certify thct the statements made in this report are correct and this- Tepair Replacement conforms to Szction XI of the ASME Code.
0#4ER OR OW4ER, Ey N E SIGN TV E E DATE
. ,M __
' bdC,\ M L f# ta/hd
,ra--- ,
CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of 74wM ,
employed by 774 Ed ryTG. of d'M%eh , C have inspected the i components described in this Owner's Report during the period /- 8-16 to 7- % 'M and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither j the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
l tb1 $ h# W8 75'S0 kAE/ ll / W INSPECTOR'S SIGNATURE COMMISSIONS (NATIONAL BOARD, ST ATE. PROVINCE OR ENDORSEMENTS)
>- so -9 b DATE 900 431 Page 2 1j
r
. l 4
NIS-2 OWNER'S REPORT OF REPAIR OR l 9"""~" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI l
g* OWNER Florida Power Corporation DATE P.O. Box 14042 St. Petersburg. FL 33733-4042 [ 27 f 4,
"'^"' "d*'**'*'"
2* Crystal River Energy Compiex .u,/r 5 15760 W. Power Line street Crystal River, FL 34428-6708 Page / d E l
woRx PERFoRufD ey tNAuti REPAIR O GAN12ATION. P.O. NUMBER. wR NUMBER, ETC. l k W/D/? huff 2 9. A b bb l
/ lbd /A). kdE!C Uf IXYET ,
YS7$6 63f , k' 5 5
- DENTIFICATION OF S TEM 3/U '
APPUCABLE CONSTRUCTION CODE EDITION ADDENDA. CODE CASES fMS 83/, / 1947 - -
l APPUCABLE EDITION OF SECTION XI UTlu2ED FOR REPAIRS M4 REM.ACEMENTS #
ADDENDA. CODE CASES
/ff5 e $'t?1111Gd /9P3 S d. l
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED CpPONENT MANUFACTURER SERIAL NUMBER BD. NO. IDENTIFICATION BUILT OR REPLACEMENT YES NO
- ^ //Al$f{ h) 8 ~
$hl$~ f YA : ' " *S Nf'afcEmEllT
, , o i p q\vl\P l
1 l
l l
11/94 RET: Lde of Plant RESP Nuclear En0meerme 900 431
o NIS-2 CONTINUATION N 4 3 W 73.9 e.o. Lr L DESCRIPTION OF WORE
& aim > tl-A r "/ltdrs 7.
TESTS CONDUCTED PRES $VRE TEST TEMP.
O ave,..t.tio O en.Um. tic 0 uomin.i op.,.iina e,...U,. O ots., e//g poi e.& r REMARKS ONCLUDE MANUFACTURER'S DATA RtPORT NUMBER,IF APPUCA8LE)
A/ws 9.
CERTIFICATE OF COMPLIANCE Wo certify that the statements made in this report are correct and this Repair Rapia.avient widuriis to Section XI of the ASME Code.
OWNER OR OWNER'S DESI EE N TUR TITLE DATE
/ot Ex.nXEL 'l!A*\
// '
CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of /hv&M employed by M /88 I/ f G- of Afht#WW C7' haveinspected the components described in this Owner's Report during the period 1-P% to 740-96 . and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report.
Furthermore, neither the Inspector nor his employer shall be liable in any manner for any personal injury or property damage or a loss of any kind arising from or connected with this inspection.
)*4dY INSPECTOR'S SiONATURE A/O d[O AWc/ fg /93 COMMISSIONS (NATIONAL BOARD, STATE, PROVINCE OR ENDORSEMENTS) 7 W76 DATE 90 431 Page 2 i
4 I
NIS 2 OWNER'S REPORT OF REPAlR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF g ASME CODE SECTION XI me a man N edetional space is necessary, use Supplementel NIS 2 9 .(gW ownsa par Florida Power Corporation ~
1- P, O. Box 14042 St. Petersburg, FL 33733-4042 PLANT Flortda Power Corp.
[26-Crystal her Energy Compier . 04/T 3 i
15700 W. Power une Street i Crystal her. FL 34426-6708 Page / of f l wona raaronuto av game muun omaA=uAnop. e.o. avusta. m wuweta eve,
/ LOA /DA fotJfA 01R A'0A Y SSQUS$Y Ye. }lf9$ f
- 8. aconss
/.4*760 kl. PCkifA l./Alf WffT, CAU57Al R//dl, FL. 3f(28 ;
memncanonpr snrvu N /1 an,ucasa co svaveto= cooc remo= aoma,coor casu t/s/K B3 l. l 19 t 7 -
1 mucasa sorm or secnon m unuzte coa apuns on apuctutun aootuo4. caos casu '
/985 EDn7ed 3dnwEne 1983 ADDcdM
- g. Identification of Components Repaired or Replaced and Replacement Components ItAsBE OF NAME oF btANUFACTURE.A*8 NAfloNAL OTHER YEAR REPAIRED REPLACED EE C00sPONDtf IAANUFACTUREA SEA 4AL NUMSER SD. NO. IDENTIFICATION SUILT OR REPLACDIDrf ves as 1// h Alb NY Uk # ff &? f8WW /
/
l
.. n. -
S 9
$m NEI; uG Of $@. Nl#Clas ng A46 tem W@
u um 1
@$-603 9
! NIS 2 CONTINUATION Page 8 of 8 I
Yfhl r
/
A' 1
7.
rssrs comouctto ratsups rists O' O Hydrostatic 0 Pneumatic C Nominal Operating Pressure G Other f/// pel A 'F nosanus p ctuos mamurAcrusos utA urosrr uvuotA er appucAsta <
Mh
/
9.
CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this O Repair ,3D Replacement conforms to Section XI of the KME e.
AT^ f
- O Cc7e om runs ,- uss l - <J Ao - Wid7/U( fdf///862 '
L 1US
/ [
r m CERTIFICATE OF INSPECTION
~
1, the ondersigned, holding a valid commission lssued by the National Board of Boller and Prossure Vesse!
Inspectors and the State or Province of FLM/oA employed by 7#6 h.1/4 .T d I C" - of NANG ' CT have inspected the components described in thl Owners Report during the period 6- U - T'8 to 7 % - and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this owners Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector not his employer makes any warranty, expressed or Impfled, concoming the examinations and corrective measures described in this Owners Report. Fur.
thermore, neither the Inspector nor his employer shall be liable in any manner for any personalinjury e or a loss of any kind arising from or connected with this inspection.
or propprty M4 / damag/rdsM NO 7.T[a ACAH FL / 9.C" pespecToms scenArunt couussaons paartoNAL acAmo, start PmovveCs on tmoomstutwfa 1 ~/( ~ 4 L, *
, .An L J PAet 2 se ei I
9 NIS 2 OWNER'S REPORT OF REPAlR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI mesa wounta if additlenet space is necessary, use Supplemental NIS 2 ouvNEA ft[-((t/[
DATE Florida Power Corporation 1-P. O. Box 14042 St. Petersburg, FL 337334042 ruarf Floruss Power Corp.
f[Il
/ [
Crystal FVver Energy Complex . UM/T 3 L 15700 W. Power une Street Crystal FUvor. Ft.34426470s Pa0e / of 2 wona Ptaromuto av game , pc uvustm. M NUuSEA, ETC.
[LO/2/DA retJf8 &fR atPAm NAY oncAucAnop$ST AS$U Y0.
}gfg 1 Anontas
/S 76 0 d PCidfA L/A/f W.fGT, CRysTA/. 2//d/2, /2. 3$(28 sotunrcAnoa or srsruu l dd APPUCASLE CoNSTMUCToM Coot EDmoN ADotWCA Coot CAiES t]SAS BS /. I 196 7 A,,ucA.a aunon or seenoa a vnuran eoa ac,Ami on muuCeutnis Aootnoa. Coos cass
" /983 Enric2 3dnwEl 1983 ADDGx/Di9
- 3. IdentiflCation of Components Repaired or Replaced and Replacement Components 9 TAME OF COMPONENT NAME OF MANUFACTUREA MANUFACTUREA*3 SERIAL NUMsER NATIONAL sD. No.
OTHER 10ENTIFICAThoM YEAR sWILT REPA*ED, REPLACED oA REPLACEMDff E '
g van so
///1f/2 / l N Y2 A' l'tAcfMfAl?
~
t nos3asuws)n Cry-cc W NIS 2 CONTINUATION Page 8 of f esacarrom or -+-
Kffft/f'f fVff00 /t (7)Y B f)/t/7 $ R// farm D /Ch e 1.
1 I
vaars comouctso E O Hydrostatic Pasu una rears rper 0 Pneumatic C Nominal Operating Pressure G Other A f8 pel nemuus emetuos uAguracrusen cara apont uuusca, w aroucAsm A[# 'F i
/lh n
'__ \
l 1
CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this O Repair J!f Replacement conforms to Section XI of the ASME Code.
, n
\
omta on iceiu %ruas oara b
e
.[
A b4 6 7fL 19 %
F -
7 CERTIFICATE OF INSPECTION I, the undersigned, ho6 ding a valid commission issued by the National Board of Boller and Pressure Vessel inspectors and the State or Province of %2d employed by THC HL~B I /I Co og MND / CT have inspected the components described in this Owners Report during the period 4 M4 to 7-/444
- and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owners Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any wmanty, expressed or l Implied, concerning the examinations and corrective measures described in this Owners Report. Fur-l thermore, neither the inspector not his employer shall be liable in any rnanner for any personalinjury or property damage or aJoss of any kind arising from or connected with this inspection.
Did,48&<V HD 7Ecr Msti n iwc-msesciosm scuruiu comum.c=s cano.= eoAno. sure. caov=ce on cuoansruone 7-il.- 4 (,1
- eAtt PA4! 3 SDC C-l
9 i
NIS 2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ,
% ida ASME CODE SECTION XI !
.N. . .m. . .e. .r.
mis-a =vustn If additional space is necessary, use Supplemental NIS 2 @-gg Cnvi gm pa'T g Florida Power Corporation 1-P. O. Box 14042 St. Petersburg, FL 337334042 ['- / -f 3 M NT Crystal River Unit 3
- 2. P. O. Box 1240 Crystal River. FL 32629 1240 Page 1 of 2 pryns Ptas opulD SY thaWD AL' Aim OPC.AmilAtcas . P O NVWSta. JCS huwelm. Elc 3.
Florida Power Corp.
.x [ss Work Request # 3C7//$
P. O. Box 1240 Crystal River. FL. 32629 j
.cc w.c,vo orsmt.
fij w / G & W :v' N f D a h 7Cm C
. me.o . at~eA coicAsc.
5'- ..c../. cc~,,.o6 ea53/. / 194 7 z545 ADD (NOA, COO ( CA3(3
/
A#P.iCAS.E (>?sDa Of SECices r WTitttto som A('AA5 om agtsegwtes'3
'D' Sumtr.er 1983, AL/,d 1983
- 6. Identification of Components Repaired or Replaced and Replacement Components hawt or hAuf or W ANur ActuatR s NATIONAL oTHER YEAR RLPA'R(0,AIP OCID
'Y cc uPoNExt W ANuracTUR ER SERIAL huWBER 8 0. No. IDENTincADON SUILY ORAIPOCtMDrf '"1 s mo
~
$INMr $$th " "a B~d- /f M Sutcawr /
\
i 1 6*->e wg .&- __W
-- 4 mew e -
.-m e a M i
___ ___ _ _ . _ _ _ J_
$0. 12 $$ AIT L/4 Df P hil A L $P. N WC L.4* I RS ^#.S*$ $ 3 9W'WS FX &)*
his t muutta 95-cc M NIS 2 CONTINUATION page 2 of 2 ptsc=>tson of vvona 22 K /J-3 2 vc A:IAW 9 E O S-C/-C/
awcer ms w aoomeo m uo ou n A^ MNy'S/f 70 EEDtk& sdOAffs d abMd4TE ulA7EBM/DhFf ,
itsts cowDvcito entssps itsts sty
- 0*
O Hydrostatic O Pneumatic O Nominal Operating Pressure O Other v/# pst gjg *F atwans.s phCLuot wanuf actuata s Cata kiPOR1 N wll4. lf APPLiCa 86tl NA s.
i CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this O Repair / Rep!acement conforms to Section XI of the ASME Code.
I l
JA sic =atunt Mn 5 b
e,.i t ca=taoE 4i LaA &,w 7/t . w%
( s CERTIFICATE OF INSPECTION l 1, the undersigned, holding a $ahd commission issued by the Nat.ona: Board of Bc::et anc Pressure Vessel inspectors and the State or Prcvince of ___ FloAIM .
cmployed by TNG H5A TdI Co _ of
__fA/7To(!D / CT have inspected the components described in this owner's Report during the period S 2/,C to
~
__ _l-14-4l, . and state that to the best of my kn)*tedge and belief, the Owner has performed examinations and taken corrective rne asures described in this owner's Report in accordance with the requirements of the ASME Code, Se: tion XI.
By signing this certificate, r.either the inspector not his em;*:,er makes any na*rantw, t apessed or impl,ed, concerning the esaminations and corrective r .easures described in th s Owner's Report. Fur.
thermore, neither the inspector nor his employer shaf t be liatte in any mar.e* 'Or a9) pc t ena! injury or pro rty damage or a loss of any kind arising from or co .nected with this inspection.
g3C , A ,f,fd A/B TfM AAIC/ f219[
. sricica5s.w . vat cc vu:ss.:~s .s. .:s.. :ia: cast a:, :t c. c :.: si.c.,,s,
%l9 9(o oait -4*- csc P AGE I DT 43-
9 M NIS.2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI
~u .,,
if additional space is necessary, use Supplemental NIS 2 Q&f-g[/[
Ow=gn Dah Fhteda heer Corporation l'
P. O. Box 14042 m=,
St. Petersburg. FL 33733 4042 [-[ -f 3 Crystal River Unli 3 2-P. O. Son 1240 Crystal Ri.or. FL 32629 1240 Page 1 of 2 o, et.,o..ie s, , .un atra a oaca=cato. e o = swain.xs =vw.in oc Florida Power Corp. Work Reauest # 397Mf
- 3. . :>xi u
~
P. O. Box 1240 Cryst.al River, FL. 32629 i:.c i.,Cc,o. o,s s,c.
.'- ...,,c...
EsnWOKY w....x, m fMDah?762 m, . net. . c ,c.,,,
5'-
d4s' AP%C.8 8 t>'C 3 3 /. / is4 7 - -
D8 SIC
- ion r W42tD #0A st* Ai8t5 08 4tP.Actut=?5 ADOLNDA. CODt cA5t$
'D' 1983 Summer 1983, Ad.ltu.d. .
- e. Identification of Components Repaired of Repla:ed and Replacement Comoonents A AW[ CF h AWf oF C C W PC h t WT W ANUFACTLRER W ANUF ACTURER'S SERIAL NUWBtR h AT6CN AL 80 No CTMLA IDENilFIC ADoW y t.A R B utLT REPA; arc.ACPL.ACt0r'* Y 08 kip ACCWLWT L
E ens { me
$!nkpdT p M "A EfW /5~ WA h+AcercAr /
e i
I' i
f, l
8 e* 4 89 # f1 L 's v P e n s if,p h,,c.e s E *; + +e v s 8 s s. asc e ple @
~u .v.st.
95 CClb NIS 2 CONTINUATION P*oe 2 of 2 ptsCRiPtson or yvoas Prd K N'.32 ro N4f 92 C/ -O/
'* Suppoer A'45 Bf6W JNOD/F/6D B& SED ox) A ff AA//1(y'S/f 70 EfDlIG SdUAffS /EkO'A7f A'l97f8/A/Diff, t LSis CO= DUCit D Patsssm TL8TSitup I'
C Hydrostatic O Pneumatic C Nomine' Operating Pressure O Other M/4 pgl ff/p *p etwamu i,=csvot wa*ve actu ton s cata atoont =swsim. p ape.ica s.t.
b/
/
9, 1
CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this C Repair g Replacement conforms to Section XI of the ASME Code.
e_
n
- n ts - ts %tt seaget T(t gatg Ma r w - fe.eW4< - beWLM *1[3 . ilF%
'i /
l m_-
~
CERTIFICATE OF INSPECTION 1, th] undersigned, hold >ng a vahd commission issut'd by the Nationa: Board of BDer and Pressure Vessel Inspectors and the State or Province of FtI>t>DA _ _ _
l employed by ~l W M SB I 4 I Ce. _ _ ng l
.. ? W N A ' G have inspected the com;cr.ents described in this Cener's Repcrt during the pe'iod SLU __ to 7-/9-94 ; and State that to the best of my knosted;e and belief, the Owner has periormed exa'ninations and taken correctae measures described in this Canet's Re; ort in a:cordance with the requirements of the ASME Code,Section XI.
By signing this cier1ificate, r.either the inspector nor h;s empI0;er mab es ary wa'ranty, e sp'essed or implied, concerning the examinations and correctise r 4asu es described in this Owner s Re;.sr1 Fur-thermore, r.either the Ir.spector nor his employer shall be liable in a y tr.6- er for any pcesonali .py or propVy damage pt) Icss of any kind a': sing from or covected with ;his ir spect.;n.
e4sf A cu.f s M/.i 7CfD A AIC 1 FL/9F i~ m c W .55 c .,u.t ecww: .s.e~ w.:u. .:..: sw a :..~a 3. E,:.a n ,c 5, 7-/9 9 4
- .tt - --oc i
F40t I M 439
l NIS 2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI Il additional space is necessary, use Supplemental NIS 2 433'_f?g7/g Owkga Ga't g Florida Power Corporation l'
P. O. Box 14042 v =1 St. Petersburg, FL 33733-4042 ['-[- f 3 !
Co,stal River Unit 3 l 2.
- r. o. Box 1240 Crystal Ri.er, FL 32629 1240 Page 1 of 2 waas gnscowlD 3 thawr) ALPAim OPCa=4ATIOas. P o WW8im #CS kWsta (1C Florida Power Corp. Work Request # 387/ 3D
- 3. E.i ss P. O. Box 12l.0 Crystal River. FL. 32629 iDLhtit GAtioh 08 S'51(W fA'lEbfl$ ffh aPPuc A Dii CONSi AX16*e dOO( l DiTiON ADDt wC A. CODI CA5t5 i l-sA5' B3/. / 196 7
.c... i> c o, m. o velm ,o. .e. o .t. ciut , .Dec c. c w e Casi.
sb.
1983 Summer 1983 AMd
- 6. Identification of Components Repaired or Repta:ed and Repla:ement Components NAWL of h AW[ oF WANUFACTURER'S NAtloNAL oTHER v t.AR 'atp A;a g g, nLueg g gQ cow >oNINT MANUFACTURER SERIAL NUWeER B D. No. IDthTireCATioN B UILT Cp R[MetWLWT vas . mo l
/*// f WR & M N V
. _SU/'tbdT p/,Ji>J <(i ,
/
WOMA W/9 h/tMi' ort u
l i
+
Pe. 12110 RET L'8 8' P a't 81 SP %d *e (*; a,ag a ss.r as:e ex. 43' l
l
l
...v...
%- M,)f NIS 2 CONTINUATION pace 2 of 2 og seniet.c,= os wona f[f fl & f
~ ~
$'/ 'l 'C L' 7 kf$ bffW kl00/f/60 N5ED (M) k
/E- Ad1(>'cK 7c EENk& s/MA&YG / 8bOMTF uk7EAM/DJN~2.
ttsts comovetto 8' eatssuft itsts tye O Hydrostatic O Pneumatic O Nominal Operating Pressure O Other N// psi ///g 'F e t w a n.4 c=:wot wa=,eact 5 ca sa atacat m.w st a. it aP*.ica.6t> '
9.
CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this C Repair [ Replacement conforms to Se: tion XI of the ASME Code.
n n 0 6%[8 G8 yk.s [ht ' *
.Gh([ k alwnl f it 04tl m h/. s ' I e'AfdcrL be#rvFiHL ~7!_3 19 %
l 7 i
~ ~ . , _ _ -.
CERTIFICATE OF INSPECTION 1,the undersigned, hold n; a wa'id commist.on ess ed by the NaSoaa' B3a'd cf B>Ier and Pressure Vessel Inspectors and the State or Fic,ince of FlMM empicyed by __N_ Ud UI CO ' of
__[kRf'TPot'D___, C T ha,e inspected the c: cr ; cr e r.tt d :. :rit< d in this C o r e r's Re port during the pe' od __.-b27- 9_&___ __
to I
%/ 4 '1(,
. and state that to the best of my kncatedge and belief, )
- the Car.er has ;.dormed examinations and taken cortective rm asures descr. bed in this Oa ner's Report ir, accordance . th tr.e rechements of the ASVE Code, Se: tion XI.
E, s,gning this cert 1f.cate, r eitt er the insoe: tor not h s em;':,er r-ales an *a ra .ty, e s pressed or impi.ed, conce ..n; the es aminabors and corrective r e ature s described in th.s Ow ner's Re p:,rt. Fur.
t' ermcre, ncither the inspe: tor no' h t, emp'cyer sha'l te 1:o* *e in aay r .ar ee for any persLnal injury Or pto;, rty dama;e or a less o' &* Aind afssing from or Co".~.e:ted *,th th 5 inspe: tion.
A g}_ SV NB m m AAlc/ FL t'fr :
. ,,icic,ss.cs.. . .: cow w.ss.c~s .s. .:s.. .: ..: c. t ,,:. :t 3. i.,rmt.t es, 7 -/1- % -~ ~
- **- c ft-
~
- a1t d
=
gy - -
l
. .ci , re o, i
9 g
NIS 2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI
.......... N,u NUM .
Il cdditional space is necessary, veo Supplemental NIS 2 9 3 - CD2 7 DATE OWNtm Florida Power Corporation l'
P. O. Box 14042 St. Petersburg, FL 33733 4042 2- / /- 93 PLANT Crystal River Unit 3 2- P. O. Box 1240 Crystal River. FL 32629 1240 Page 1 of 2 wona pgmpDmW(D gY (NAWE) mEPAim OPGANIZATION P.O NUWS!R. JOB NUMBER ETC Florida Power Corp. Work Reauest # 30 7/0 /
- 3. ADDaru P. O. Box 1240 Crystal River, FL. 32629 IDENTIFICATION of Sv$71W Ed EDITCN ADDENDA. CODE CA8(5
- ' l6/)lE AlP LiCASLi Shnoxj 7T7~
CONSTRuC10N CODE to W Sbamne & 7, ~
ADDENDA. CODE CAS(8 APPLeCABLE tD8?CN 08 EECTCes II UtiL2tD FOR REPAIR $ Om A(PLAC(W(NTS
'D' 1983 Summer 1983. //imA
- 6. Identification of Components Repaired or Replaced and Replacement Components NAT)oNAL oTHER YEAR REPAIRED REPLActo *E$ m*"_
NAMEoF NAMEoF MANUFACTURER'S
- 30. NO. IDENTIFICATION ButLT OR REPLACEMENT ves no CoWPoNENT MANUFACTURER SERLAL NUWsER Ibfl/E hT/C Bif03/8 NA Adb 9 Wn biwec /
YbWE REWER B0 03/49' A/A AYlL9 AM fuusHce~
l l
art. u. e ri.ni nrse Nociw tagonas A.w.ac. sac e
- ' 2 8'
- assauwsta 43-60Z 7 NIS 2 CONTINUATION gPage 2 of 2 ,
otscmietiO= or wona l
[
.I Pt AC 6 vat M >
DJ% >
4 tS ii s s . l
\
1.
1E5f t CONDUCTED PRE ESURE 1(STSttup I'
O Hydrostatic O Pneumatic g Nominal Operating Pressure O Other 2:57 psi sif 'F atwaas.s onctuot wa=ve actuata s caf a atmo=1 avusta. it APPucastt, See PC F '77) G~l6h D
@eae.oen $P-G5D no SP-ZoM CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this O Repair 7 Replacement conforms to l Section XI of the ASME Code. I n
ow%ta om I s.Ct iGN siGNatumt it ' catt N . - t utorqc hfe.sant 7f3 1% l
/ / l f 3
, CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel inspectors and the State or Province of M DA employed by M NA b- of
- 8MCM<CP have inspected the components described in this Owners Report during the period 3 0 to 7-ZL 9 6 : and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corTective measures described in this Owners Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concrrning the examinations and corrective measures described in this Owners Report. Fur-thermore, neither the inspector nor his employer shall be liable in any manner for any personal injury
! or property damage pr a loss of any kind arising from or connected with this inspection.
l
_ d ,/, / & & Z A'o 11'm M!O F2 /W Ih5PECToR E SIGhafunt CowwiS5lohi thaTeOhat 93amD 5tatt enoviw t on twoomstugnis, 7-22-96 oaTE 4 L u.
i PaGE 2 900 a31 l
I i
9 NIS 2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI Nr 2 NUwSER If additional space is necessary, use Supplemental NIS 2 DATE 3@L OWNt h Flonda Power Corporation 1*
P. O. Box 14042 St. Petersburg, FL 337334 042 3-2593 punt Crystal River Unit 3
- 2. P. O. Box 1240 Crystal River, FL 32629 1240 Page 1 of 2 wona etarDautD e, swAwo atraia opcA=sto=
P. O. Box 1240 Crystal River , FL. 32629
- DthTIFICAtch OF Sv51tW Apr 67'fn'6SEV MOW /97Cf'(DitlOh CODE CA5t5
- f. E5CON 6slA 83h 5tAuC10h C/O t 196 7 ADCEN/Dw cacal +9 nrm -
APPLaCASLI (Ditom D8 EECfon si utiLQto #Da atPAim5 om atPLActutzt1 ADDENDA CODE CA$t1
1983 Summer 1983, Atled
- 6. Identification of Components Repaired or Replaced and Replacement Components NAMEOF NAMEoF WANUFACTURER*$ NAfteNAL oTHER YEAR REP AIRED, REPLACE 0 ***W SERIAL NUMBER 80. No. IDENTIFICADoN SUILT OR REPLACEMDrT vs so COMPohENT MANUFACTURER
/bW6'B! $?S$6 NA "A EfH-/8 MA brukBerur I
< , 1 i )
l l l
i l.
I i
1 f l "IT L8 P'**' mt se hec w t as.aeenas Anws.ce er os kw 12m l
I o o .
! .is , v Sim h3-@
NIS 2 CONTINUATION Page 2 of 2 OtsCmiP F WOmE
~ Kcf;t Ace CtalK . Eb b > Ev6- WT 4 UW ULT, ;
1
-- ) >
1.
l tests comovcit0 Patssynt itsist we O'
O Hydrostatic O Pneumatic O Nominal Operating Pressure O Other d/4 psi g 'F E
mtwamns chCLuDt WANWF ACtynta s DATA mtPont MswSER, aF APPUCABLt)
M s.
l l
CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this C Repair Dif Replacement conforms to S0ction XI of the ASME Code.
On%tm om on a et h t 4G=Atymt fit Datt L- - V 4saZIM L 4/A @ L 73 ,19%
u
/
CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiter and Pressure Vessel inspectors and the State or Province of Fl(OdA employed by 7% /N I I 60 of M64M M have inspected the components described in this Owner's Report during the period 5*/2'94 to 7-22-9 6 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector not his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Fur.
thermore, neither the Inspector nor his employer shall be liable in any manner for any personal injury erty dama or,/Ntprop /nAAr%ge W or a loss of any kind N6arising 7BD AWu fromf/_
or /W connected with this inspection.
CowulssioNs (hatio%At goanD statt rmovinct om gnpopstuthist I s'sPECrom N s siGNatums l 7h2)16 DATt .44 c.a.g i
PAGE 90C A31
(VO) NIS 2 OWNER'S REPORT OF REPAIR @R REPLACEMENT AS REQUIRED BY THE PROVISIONS OF g ASME CODE SECTION XI waa=Uween if additional space is necessary, use Supplemental NIS 2 f/-sp g"/
OsuteEn DATE Florida Power Corporation
P. O. Sox 14042 St. Petersburg, FL 3373lH042 Zfl/f punt Florten Power Corp.
CrystalNver Energy Compion uun s isroo w.Poww une strom crystal Nver. Ft. 34426470s Page / of 2.,
wona revonuto sv psAme atrMn OnGANGAnoN. P O. NUMSEA Joe =UueEA. ETC s.
spa /b s+ A/Yfb &LA AooAEM 4)/L4 Af$USSf ff/fsf24
/E~76 8 d). /0 /ulf.l bdf JC, [Mf77+4. bVS$ AA. .YYYZP i es.wtwcAnow or svritu kC AmeA.a m 1=:To com como Aooc=x cow cAn.
AJMf S"YWdUk S/ 5 19 h ( ft/ M sv1 f A. ,/ fd'pf ArcucAsa somon or section a vnuzzo con nouns on musAccuturs Acco.oa. ooce cAss:
/,9/J f)/ f/o A) f u M MG /P / J A4bE~1lb A
- s. Identification of Components Repaired or Replaced and Replacement Components NAASE oF ooMPoNENT NAME oF MANUFACTURER MANUFACTUREA's SERIAL NUMSEA NAT)0NAL sD. No.
oTHEA IDENTIFICATION YEAR sUILT RDAIRED, AEPLACED EE oR REPLACEMOff . rus no 3() 7~ t #f b Slb kC/l*//h b $l5AW 4
l l
1 i
l m.== ner: u .e r= nsse. am A mm ei I
,f .
V INSI IuWWMA 9f osrP NIS 2 CONTINUATION page z of z.
esscwrom on wona 004 R&Y oS*M LW sal #CK A.f.f5>H44J R fL,
A?C & ~ ti /P.
vssrs comouctto su rests .
O' O Hydrostatic 0 Pneumatic C Nominal Operating Pressure G Other entasp/
N// poi // 'F REMAARS pecLuot MANWFACTusWr1 DafA REPORT 88uMetA,IF APPucASLS d)/A f
S.
l 5
CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this O Repair EI Repfacement conforms to ,
Section XI of the ASME Code. I r /\ s A owisan on W m ts rust mati Mi a ueAE boramL '7!L ,10%
/ /
I l CERTIFICATE OF INSPE_CTION 1, the undersigned, holding a valid commission issued by the National Board of Boller and Pressure Vessel Inspectors and the State or Province of FloOM employed by 7W M6 T d T Co of
- RTrorA i (7 have inspected the components described in this owners Report during the period 5-26 '/4 to i ~74 3 'f 6 - and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owners Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any wananty, expressed or j impiled, concoming the examinations and corrective measures described in this owners Report. Fur.
thermore, neither the Inspector nor his employer shall be liable in any manner for any personal injury j
or Aa property
& Ma damag& Ve or a loss of any WA kind 7troartsing mkfrom or connected with this inspection.
J R/W )
erspectoms somatunt cowussens patomAL soAse, statt. Paowoca on enconstutxta l
! 7-77 96 -
l oars L J PAots ese ci i
1
...s -
4g NIS 2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI n as.i .oo = oe e... . ..e so,,ie-ni.i mi ~"97ggf ownsa para Florida Power Corporation I* P. O. Box 14042 [//gjf St. Petersburg, FL 337334042 /7 ruurf Fkwtds Power Corp.
Crystal fever Energy Corgies -omT 3 157so w. Power t.he Street Crysesi power, Pt.344as470s Pa0e / of f wona paneonuto sv apae naram onaamunop. pm. muupan, me muuseA rre.
ftoRIDA 7o'wrd Cod.F: htwX REQuds7 Ne. j)gjS,$
8- anosass
/$760 kl. PCu24 t./Alf 57Af&Y, Crys 7AL RI6ldk FL, 3$g'28 mormcanow or sysreu L
B5 aerucasa constaucio= coac somon acocuna. coot casts
(.l.C9s B.5/./ so67 -
l arrucasa somou or escrum a visuso con acrass on asrucomers acosmo4, coot casas '
' /983 f27102 3dmMEt 1983 AwCdDA t, Identification of Components Repaired or Replaced and Replacement Cornponents maasE oF NAME OF ttANUFACTUREA1 NADoNAL OTHER YEAA REPAREB. REPLACED $ "g" CossroseOff MANUFACTUREA SullAL NUMBER 30. Iso. IDENTIFICADON BUILT OR REPLAcessuf vus me
/badEt '
.55$6
/
Na Na 85/i'53 8 1.m freiww l -
O n. . . .a,n. .r - n. ~- u,- - . .
1 i
has 2 tuwe8a 94-NEC I
NIS 2 CONTINUATION Page 8 of 8 h/Y'M O/fM foD fM4D
/ / /
/ 72MA/Batkt=7 Ks7/pg/V 1.
vasts comouceso passaup vasta rape i "' O Hydroetatic 0 Pneumatic C Nominal Operating Pressure O Other N/4 pel h/g,*F
- assaanus sucLuos uAmuracTunett eATA espoNr Nuuss% F APPucAeLS
/N i
) .
i CERTIFICATE OF COMPLIANCE 1
J
! We certify that the statements made in this report are correct and this O Repair T Replacement conforms to Section XI of the ASME Code.
l A. -
- ownsa on ownsas mm tg cart
- 1%x < Pat. En r,we te-. 2 19 %
l .
1 o r 7
I l i
CERTIFICATE OF INSPECTION j 1, the undersigned, holding a valid comtnission issued by the National Board of Boller and Pressure Vessel inspectors and the State or Province of AIC0A
- employed by 7/M 8 /I I O O - of
) M NJFvfb / C7' have inspected the components described in this Owners Report during the perod 'r /W to
~7 -13 "7 6 - and state that to the best of my knowledge and belief, 4 the Owner has performed examinations and taken corrective measures described in this Owners Report j in accordance with the requirements of the ASME Code,Section XI.
I By signing this certificate, neither the inspector not his employer makes any warranty, expressed or
- implied, concoming the examinations and corrective measures described in this Owners Report. Fur.
i thermore, neither the Inspector not his employer shall be liable in any manner for any personalinjury j or prope>ty d or a loss of any kind arising from or connected with 131s inspection.
hek /M A/B 7Cfu Mc/ R /Y5 j
! esseactors scaAruns couwssens cano=AL soAmo. stars. Paovw.ca on tuoomsturw?m '
- 7-23-96
- j i DATs j I
N A PAGE 3 at 01 i i l
- I
/ g
( \
) ) NIS2 OWNER'S REPORT OF REPAIR OR REPLACEMENT C/ AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI If Odditional space is necessary, use Supplemental NIS 2 3 004$
Daig Owwg m Florida Power Corporation 1- P. O. Box 14042 St. Petersburg. FL 33733-4042 h-l3,$ 3 PL.A h1 Crystal River Unit 3 2- P. O Box 1240 Crystal River, FL 32629 1240 Page 1 of 2 Woms PERFOmuto av thAWts atPaim OPGAN.2AfiO**. P O NUMB ( A JOB NWWB(R ['TC Florida Power Corp. Work Request # 306690 l
- 3. ADDRE 55 l
P. O. Box 1240 Crystal River, FL. 32629 l tDENTif CaflON OF SYSTEW ,
4-DetAv LgAT E DitiOh ADDENDA, CODE CA5($
l f
APPUC& L[ Jh5TmvC10h CODE Sa. g3 l, l 39 Q ,
/
- j ADDENDA. CODE CA5t$
APrieC'aBLE ED' Tech DF SECteoh si UTitt2ED FOR REPalR$ On #EP.ACEWENTE Sb. 983 er 1983 M A
- 6. Identification of Components Repaired or Replaced and Replacement Components NAMEoF NAMEoF MANUFACTURER's NAtloNAL OTHER YEAR REP AIRED, REPLACED '$"2 E
- 80. NO, IDENTIFICATION ButLT oR RE;iACEWENT vas : me COMPONENT MANUFACTURER SERIAL NUMBER hh O h h (Y$
1 l
l i
I m <,.. ~,,,, h_..., _ ,A...... ..
~ . ,
I I
I
~
~
ws: muusen 45-004 5 NIS 2 CONTINUATION Page 2 of 2 NGkMNN oescairtion a wona O DlW d6d lN 7-(JiTA MAR 012. 01 -Di A tt$f5 CONDUCit0 PaE55 sat it5TS tjwp 8' O Nominal Operating Pressure C Other psi *F C Hydrostatic C Pneumatic w/4 (4 atwaans onctuot wanusacTuata s cata acroat wwwsta it araucastri uA
- 9. )
CERTIFICATE OF COMPLIANCE 1
We certify that the statements made in this report are correct and this C Repair E Replacement conforms to S:ction XI of the ASME Code.
m 8on om do, as, =tt sio=atv at Y ct ca's A e.
- u iL2'A #AL fpnML 73 e I9N e <
( .
)
CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel inspectors and the State or Province of F/IVJoe employed by W UA D f O - of
- 4MCM ' CT have inspected the components described in this Owner's Report during the period */3 - 9 3 to 7- z4-14 - and state that to the best of my knowledge and belief, l the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
l By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Fur.
thermore, neither the inspector nor his employer shall be liable in any manner for any personal injury l
l or property damage or a loss of any kind arising from or connected with this inspection.
A/,,/ ,dduF N& 7KtD M C/ FL /W siSPECToa 5 SaGhafvat CowwfSSIONS lhaTIONat BOsa0 $1stt Pa0ViNCE On (NDOa5Ewtht$i
]* 24
- 9de oaTt 44. c.14 l
.act , - .m l
.(
l ,, \
{ \
'$ ) NIS 2 OWNER'S REPORT OF REPAIR OR REPLACEMENT V' AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI
=+: NvWeta l
l if additional space is necessary, use Supplemental NIS-2 Q3 @ Q OWNg a Daft Florida Power Corporation 1- t P. O. Box 14042 St. Petersburg, FL 33733 4042 L.@,%
9LANT Crystal River Unit 3
- 2. P. O. Box 1240 Crystal River, FL 32629 1240 Page 1 of 2 wenn einsonute av mauti atPaia occa=vTioN. e o Nuwera. sos NvWeta. nC Florida Power Corp. Work Request # SO88(,0
- 3. ADongs3 P. O. Box 1240 Crystal River. FL. 32629 IDENTIFICATION OF Sv5f EW
'DscAV NEAT l Cap [ CONSTRJCTON COD ( EDITION ADD (NOA. CODE CASE 5 53-APdPSA8 a3 l.l is M -
J i 08 SECTiON si WTILt2tD FOA *EPaists on atPLACEWENTS APeilCalif ED'T on ADDENDA. Coot CA$ts 5b. 1983 Summer 1983, A//d
- 6. Identification of Components Repaired Or Replaced and Replacement Components f NAME OF NAME OF MANUFACTURER'S NATIONAL SD, NO.
OTNER YEAR RD A3 RED. R& LACED M MANUFACTURER SERIAL NUMBER IDENTIFICATION ButLT on REPLACEMDrf vus : .c COMPoN ENT l
l pou)L"1L n j l AA96c12. 9tes96- 4A MA DW -50 -
tshAcfMM l
l l
l l
I i'
.n u. m.,..cir . , ... ., ..... . . o,
... ,z
Nib IRAISER b00%
NIS 2 CONTINUATION Page 2 of 2 DESCRIPT40N of WOmm A/lo 01W Id At0 6 C-12. I LI A C O C O A islC G
'- M AC or z-o G-o\ -ol A unnt Tisf 5 CONDUCTED PmE55 sat i TESTS Tium
- 8. C Hydrostatic O Pneumatic O Nominal Operating Pressure O Other ,v/g. psil///g 'F 7ttuamK5 (INCLUDE M ANuf ACTunga 5 DAT A mEPORT NUMB (R. W APPUCABLE) to A 9.
l CERTIFICATE OF COMPLIANCE We cartify that the statements made in this report are correct and this : Repair 7 Replacement conforms to S3ctisn XI of the ASME Code.
. n NNER On OwNg DATE
$ %il'ilGAfumi TAEm Ew e ,h . tes
! /
F 7 CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel inspectors and the State or Province of Flo M A employed by TM HSB IdICo. og t/nN / CT have inspected the components described in this Owner's Report during the period 4-/M 3 to 7-Z4-96 : and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report l l
in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, conceming the examinations and corrective measures described in this Owner's Report. Fur.
thermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
4 4 // 2 6 /;^ NLSTrCD ANC/ Ft./%~
4ESPECTOR $ SIGNATURE COMWtSSIONS IN ATioNAL 3DARD ST AT(. PRQv NO[On(NDOR$(WENTS-7-Z.#f -M DATE -.AS. CM l
l Pact sto Asi I
i 1
1 .
l (~~^3 NIS2 OWNER'S REPORT OF REPAIR OR REPLACEMENT V)
AS REQUIRED BY THE PROVISIONS OF g
ASME CODE SECTION XI
- NuWsea if additional space is necessary, use Supplemental NIS 2 .OQQ DWNER Daft l Florida Power Corporation )
l 1-P. O. Box 14042 St. Petersburg, FL 337334 042 h . l3.%
~N, Crystal River Unit 3
- 2. P. O. Box 1240 Crystal River, FL 32629 1240 Page 1 of 2 REPalm OPGANGATION, P O NUWSER. JOB NvWSim. ETC WORK P1880RWLD Bt INAWE)
Florida Power Corp. Work Reauest # D S)kl
- 3. Apo.cs$
P. O. Box 1240 Crystal River, FL. 32629 IDENTIFICA ta0** OF Sv$TEW
'- D ecAY hSAT I Au E DITION ADDENDA. CODE CASES
- i. puCA8 is 0 sA8 f CON $taXTON 'iDEB3 .I AP*L ICAS E (DrTom 08 SEC*ich II UTILGtD F0m p(Pai815 OA R[PLACEM(NTS ADD (NDA. CODE CASES
/
1983 Summer 1983,
- 8. Identification of Components Repaired or Reptar,ed and Replacement Components NAMEoF NAMEoF MANUFACTURER *$ NATIONAL OTHER YEAR REP AIRED. REPLACED **"2.$$' _
SERIAL NUMBER SD. No. IDENTIFICATION BUILT oR REPLACEMENT vos se COMPONENT NANUFACTURER NkNdN l l NA M bMW-O O tJA b9tACfMrdT l
l art. v. ., m.ni mise N.,ci..< sara as A.w.nc. ao ci
- m. was
! .u u .
- O Y I NIS 2 CONTINUATION paos 2 of 2 Desemirfion Or woan l
1 O DI b/ NAd6 d Id kCCOTEOANC6 d\TN MM2 9z-os -ot -ot A .
l TESTS CONDUCTED PRES &gaf TESTSTjup
! 8' O Hydrostatic O Pneumatic O Nominal Operating Pressure O Other #/4 psi 4//4 'F MEWARK5 tlNCLUDE M ANUF ACTvagm 1 DATA PEPG8tT NUMSER.17 APPLICABLO Nk 9.
i CERTIFICATE OF COMPLIANCE L l We certify that the statements made in this report are correct and this : Repair % Replacement conforms to Section XI of the ASME Code.
DATE
' SwNER On Ow 1 s ipGNATv41 TIKE 2 s. L 4 eoav Er,ane i/3 19 %
l s(
l f
CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Bc;ler and Pressure Vessel inspectors and the State or Province of DDOA g
employed by 7h6 h l% IT I Co -
HMrXToeb , f 7~ have inspected the j components described in this Owner's Report during the period 4-/3 C to 7-24 44 . and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Fur.
thermore, neither the inspector nor his employer shall be liable in any manner for any personal injury or property damag os f any kind arisinD from or connected with this inspection.
l f&4 t- AI6 7[FO AMC/ Ff /4'.1~
lESPECTOm S SIGN ATURE COWMissaONS (NATIONAL SDARD STATE PmovlNCE OR ENDORSEWENT&i 7-7M - 76 DATE f
..cc , -.
NIS-2 OWNER'S REPORT OF REPAIR OR 9""*""" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI OMER Florida Power Corporation DATE 1' P.O. Box 14042 SL Petersburg, FL 33733-4042 7~/~ N PLANT Florida Power Corporathe
- 2. c,y. Riv., En.rgy Compiex -0Anra 15760 W. Power Line Street Crystal River, FL 344284708 Page / of 7.
WDRE PERFORMED BY (NAME) REP AIR ORGANIZATION, P O NUMBER, WR NUMBER. ETC.
3' FLLhDr4 lbWEK coKP ses psways ADDRESS
/S760 W. /bW&rl /JME JC CLYJ7AC. 2/VEd. ii=L 3442B IDENTIFICATION OF SYSTEM
- 4. gz-APPUCA8LE CONSTRUCTION CODE EDITION ADDENDA. CODE CASES Sa.
USAS E31.2 bMT 19(a 2 N/A APPUCABLE EDITION OF SECTION XI UTILIZED FOR REPAIRS OR ADDENDA, CODE CASES Sb. REPLACEMENTS 1983 5 213 k b M it/D A \
l
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED e COMPONENT MANUFACTURER SERIAL NUMBER ED.NO. IDENTIFICATION BUILT OR REPLACEMENT YEs No f/RMcJYJ7a4 CDNM ovM WA N/A Sexc &ntrJ MR mccxW /
UltEntoWea.9 l
l I
1im RET: LWe of Ptart itESP: Nuclear Engineenne 900 431 1 I
4 NIS-2 CONTINUATION
-*ne- e e p a. I of 2
- CRIPTlON OF WORM RERAc2 OLD Tht~fkoW8ul ay' WEd.D/WG.
- 7. RSCTclMGD J77tEsf g6usf af wet _af.
uRE nvRE ~Est TEup wis coNoucTEO O eyaro.iatic O Pn.umate E Nominal Operating Pressu,. Ooin., 2z41 ... s.z r REMARKS (INCLUDE MANUF ACTURER S CAf A REPORT NUMBER #F APPLICABLE)
W od t ret 90&E73 : 3AifS99 TMd .338 04 1 ne 3 ue 9- 77MitMoWath /b : RC-4A-72=/ < &94-72?3 : RC- 48-7Et i AC-48-TE3 i
&SA-TE/ i AC-SA- TE3 i bsB-Te/, AMD RGEB-TE3.
CERTIFICATE OF COMPLIANCE W3 cartify that the statements made in this report are correct and this Repair b Replacement conforms to l i
Szction XI of the ASME Code.
l NA RE tit ; DATE !
Q#aER OR OM4ER Sir E C)% '
/. *G' [+/u W E2 7f24hl.-
I' /
CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel inspectors and the State or Province of READ 4 ,
employed by 7#F NSA 74I Ga. of W/'JTorf4 C7 have inspected the components described in this Owner's Report during the period /- tL 9 (- to
'7 2.t 'f 6 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
44 /MT Na 2CED AWC/ R /95 INSPECTOR'S SIGNATURE COMMISSIONS (NATIONAL BOARO. STATE. PROVINCE OR ENDORSEMENTS) 7-24-96 oATu 900 431 Page 2
~
/
9 NIS 2 OWNER'S REPORT OF REPAlR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI w .edni i .p.e. i. n.e....ry. . sopprom.nt.: was.2 ___
on=sm 94-ooz9 1-Florida Power Corporation art P. O. Box 14042 St. Petersburg. FL 337334042 rwa Florkts Power Corp. t/-26-94 8- Crystal FDver Erwgy CoWo. iT 3 15700 W. Poww Lks Strew Cryseal FWver. R.34428470s wom euvo=co er m _ Page / of 2 nuun onumancy. ,a muuten, m wuuna arc.
/2cRIDA Pos.>re Cox.R Mld REQUdST No. 307pfgr
- 8. meness
/S7&D Al. PCAEA L/Alf M&T, CD57AL D/duk fl. .E$4'ZB eunncanon or eretsu EF -
aneucasa consrauerou coac
- - tomou necam. ooor cans tJsAS BfI.I 1e6 7 -
- aerucama somou or ucta a mano con wuns on acnacrwuns Anocum coo cases
/983 Ermos) 3dmmEt /983 AaocdM 4.
Identification of Cornponents Repaired or Replaced and Replacement Components NAast or mAate or coespowtwT alAwWACTUREA'S NAfl0NAL OTHEA YEAR
, a AwwAcTvAsa acuALNUWSER 4DAmsa, REPucts$g BR. HO. 800rfinCAfloN SUILT OR ReucDIOff vus e HAW $fd /g(p /vn Mn v # t2A sin feixe, sir- /
O e e e
O ,
e
m.t se.
94-Mr?
NIS.2 CONTINUATION page E of E esacmanom or woan
[dPL/9df jar /pf ctgsyyf M ys / Aftf75'. /A/STAU Ned
'* SIZE 20 A?/G/b JtdAf st)cor, Paz isag P92-os-o/-o/ l vests comouctas pasasuna E O Hydrostatic 0 Pneumatic C heninal Operating Pressure rests spe sesa no powos asamuractum.s esta aeront enams '.er appucasun D Other g//) poi g/g y e
i AJA S,
CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this O Repair .g Replacement confonns to Section XI of the ASME Code.
ownsa en ger W--- nas y ears WubN ,
j
. MmAL EAc ratnt- ~1l2- ,10%
I ~
l !
~
CERTIFICATE OF INSPECTION ~
~
~
1, the undersioned, holding averid commission issued by the National Board of Boller and Prossure Veseet inspectors and the State or Province of hM omployed my 7w #JOIt'[ G. I i
_ of
//I M N # h e & have inspected the components described in this Owners Report during the period 2-/*- U to 7-2 0 f(,
_- and state that to the best of my knowledge and belief, the Owner has performed examinations and taken t.orrective measures described in this Owners Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector not his employer makes any warranty, expressed or implied, concoming the examinations and corrective measures described in this Owners Report. Fur.
thermore, neither the inspector not his employer shall be liable in any manner for any personal injury
.c
& 7rs5 f
.-e- - -
7 26 H e.is L ;
i l ,. .
1 l NIS.2 OWNER'S REPORT OF REPAIR OR REPLACEMENT l AS REQUIRED BY THE PROVISIONS OF
%dda ASME CODE SECTION XI W
l wu =vwSta If additional space is necessary, use Supplemental NIS 2 Ownst h
@-t[$
Dait Florida Power Corporation l'
P. O. Box 14042 es4=5 St. Petersburg, FL 337334042 ['-/-f.3 Crystal River Unit 3 2.
P. O. Box 1240 Crystal River, FL 32629 1240 Page 1 of 2
- c. et..o.u(D e, p aun atron occA= cation. e o =vusta. as =vusta. rte Florida Power Corp. Work Reauest # 36767/
- 3. aooats:
P. O. Box 1240 Crystal River, FL. 32629 u ,, ,, ,C. , ~ 0, . ... t .
firrf G B K V R fDu/A 76 d APetica8.f Cons,m.8CT6= C00t (Difioso ADDENDA. COD: CASES RA5' B3/. / 194 7 -
a.P*tsCAs.1 EDrich 08 $lttion II u%IllD FDA AtPosts on atPLActWENTS ADDENDA. Coot CASES
$b.
983 Su m 1983, U./d .
- 6. Identification of Components Repaired or Replaced and Replacement Components Nawt eF couroNEN1 NAWt oF WANurActuRER WANuFAcTURER's stRIAL NuwstR N ADoN AL 8 0. No.
ofMEA IDENTIFICAnoW YEAR ButLT REP AJR E D. kCPLAct D oR RieLActWDrf
$Q vi ! eo
& 7'hhdT ls/ #A N fM-8 MA hhacO!Off V
.m l
l i
- r. im art. v. .e e.wi atsr. wo., tas a-s 4.wy.c. sac .3,
. 0 .
o his 2 huwSt A 93-cc 24 NIS 2 CONTINUATION Paoe 2 of 2 m c... .. ...
72% FCh32 70 NAf092-OS-C/-O/
Cunber iMS BEEN' M6 OinED B/7 SED o/J /?
A^- MlWK TLsts conduct (0 7c EED0&& si.W889's / 88&i97f 4/47E8Y/M)HF2, Pagisvag ttstsigwp
- s. a p n , , , ,,,,
gg,,,,,,,,,, g u , ,,n ,, o p ,,,,in ,p,,,,,,, a o,n,, 37,,,f ,,, gg;, ,,
etwanna il=CLUD( WakyF ACTUA( A $ DAT A A(>QR1 NUWB(R,(F APPLICABL()
N/9 9.
CERTIFICATE OF COMPLIANCE )
We certify that the statements made in this report are correct and this C Repair 2' Repfacement conforms to Section XI of the ASME Code. !
l C6%E8 (s'c Et siG% Alunt LE DAfg
.I - .maat Em.,o e e.t 7/3 1N
/ l
\
. s. - _
CERTIFICATE OF INSPECTION 1 1, the unders,gned, holding a valid commission issued by the Nationa: Board of Bo ter and Pressure Vesset inspectors and the State or Province of FMM employed by M N UM _ of M_./%_.C_ have inspected the components, described in this O*ner's Report during the period 2-4 W go 7 .1I- N . and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this O* ner's Report in accordance with the requirements of the ASME Code,Section XI.
l By signing this certificate, neither the inspector not his empicyer makes any wa'ranty, empressed or i
, implied, concerning the examinations and corrective measures described in tNs O*ner's Report. Fur. l thermore, neither the Inspector nor his employer shall be liabfe in any manner for any pctsonal injury !
or pro rty damaae or a loss of any kind arising from or connected with this inspection. l j ,srecto.
m 5 s. ,%arunt
& A/d / @ 4AX/ Ff /9f cewuissio~s watie a, s:a.o statt em:m: ca =:c.siutes, l 7.tv- 9g cast - , , - =
l I _ _ _ _ _
paGt 3 pr a3s
l h
NIS 2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI
- .t. -
if additional space is necessary, use Supplemental NIS 2 @ -gj $
Cweat h DAit Florida Power Corporation 1*
P. O. Box 14042 St. Petersburg, FL 33733 4042 ['-[ - f 3 PLANT Crystal River Unit 3 2.
P. O. Box 1240 Crystat River. FL 32629 1240 Page 1 of 2 vvona ptaromwt0 av gnaut) REPAIA OPGANL2.AfsCN. P Q NVW8(R, JQ$ hdW$[R, l'TC, Florida Power Corp. Work Request # 236768 [
3- .ooat ss P. O. Box 1240 Crystal River, FL. 32629 eDt%tif aCAfiOh Of Systtu firW/G6- KV fMDttS%d N57AsC16mdODE (Ditioes obOENDA. CCDI C A5tl 5
APPLtCAS[LI#5' 53/, / 194 7 -
A.PetsCAtsE (Dation DF stC? ion si utiL12tD Fon atPAsms on AIPLACEWINt$ ADDENDA. C006 CAST $
'D' 1983 Summer 1983 J /M
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME oF cow eoh Efff NAME oF MANUFACTURER M AN UF ACT UREA'S SERIAL NUMBER NATeoNAL BD. No.
oTHEA IDENTIFtCATHl>N YLAR surly RD AJ8 t D. RIPLActD 08 REttAcEN Drf 71Q naino f/ N SHEk */ "A h/ukwg Soy'/ tdt pyh/ 6
/
FR/- /9 t&7 I
/
_ l l
t l
t i
l n., i s , att ui. .' mw use. now too as s .m. am
.ise vustm 93-oc 2G~
NIS 2 CONTINUATION Page 2 of 2 ptscmipteon or wona 7 hic FCN' .32 ,c M4f898-0S-C/-O/
Sunber //45 Br6W #6 DiR6D sasED ou n
/f- /?dl(Vfd 70 EED0df sdOAA f5 MNOUWF//b'7ED//2WHi~2, TLsts coNDUCitD Patssume itstsitWP l
j I'
O Hydrostatic O Pneumatic O Nominal Operating Pressure O Other A/[// psi A/g
/ *F l stwama.s ti=ctuot wa=vractuata s cita at*ont avwsta. a aamucanto {
n/9 l l
e.
i i
l CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this O Repair / Replacement conforms to Section XI of the ASME Code.
oaft o*% s on
.f t{ 't ic%tt sic =atumt gitt J) .
tit ,cen t1.4ee 7/3 19 %
"' / .
F , 3 l CERTIFICATE OF INSPECTION 1, the unders;gned, holding a wated commission issued by the National Boat of Boiler and Pressure vessel l
inspectors and the State or Province of #44C/M employed by 7M" #J~d l' d b - of Abf#I/~4CDs C7' haye inspec!ed the l components described in this O*ner's Report during the period _2-fo-93 to 2-14"-9 4 . and state that to the best of my knowledge and belief, the Owner has performed examinations and taken cortective measures described in this O*ner's Report in accordance with the requirements of the ASVE Code,Section XI.
By signing this certificate, r.either the inspector nor his employer makes any wa'ranty, expressec or implied, concerning the examinations and corrective measures descr. bed in ins Onr.er's Report. Fur-thermore, neither the Inspector nor his employer shall be liabte in a .y manner for aq) personalinjury or pr y damage of a loss of any kind arising from or connected with this inspection.
,4: M Jo K9 _fMC / Ac /W ses cica 5 sicswas ccw-ss.o~s ri c.:~4 n:.ao s et ra:. ~:t cm (~:est otes, 7- w 't&
Daft &
dbs PAGE2 tx a31
9 NIS 2 OWNER'S REPORT OF REPAlR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI w .4mn.n.i e,e.e. is nec....ry. n. soppiem.nt.: wis.: _ _ _
90 e30 Florida Power Corporation oArt 1-P. O. Box 14042 St. Petersburg, FL 33733-4042 runt Pionde Power Corp. 4/ -2.f-94 Csystal mver Energy Congdes -u9rr 3 E 157s0 W. Power une Street cryssaiSver. R 3442s4ms
- Page / of 2 wona rwonuto av?w,fl GM.R flcR/DA atram onwou4now p.o. woupsm. Joe avusta, ric.
S. anoassa ACKY REQLlBT Ne. 30*/fy
/S74,0 Al. PCkEl L/Ald' MET, CRk%TAL R//dd, FL. 3f(28 asunncanow or avstum ff aneucama cowerauctou conc
- - somou anotana, coor cases L/SAS 8/l.1 19 6, 7 -
aneucteu sanoi or escoa a vnuno paa airass on apuccuens aoocana. coon cass:
/983 EnricAl 3dmmfit /983 ADOG/JDt9 g,
Identification of Components Repaired or Replaced and Replacement Components ItAasE OF IIAalt 0F IRANUFACTURUt*S NATIONAL OTHER YEAA 0048PONDrf MANUFACTURUL REPAIREB, REPLACED E '"'a scuAL NUtstER B0. 800. 100rfinCAnoN sWILT OR IdPLACGIINT ves a p/ $M Nk
/gh Yk $YSb U$ fWWSNe$
~
I I
. .. .i . .
A8' tW Art: LNe et MarW RESP: hvetear Engheenne answaus 95 @
l 1
a
- u..,.-
94-oso
)
{ NIS 2 CONTINUATION Page E of f i saum , .
i ff9496f P/P6 cMJt$ Betr$ / A/t/7T. tarintL Aww 1
sap zo stGib SwnY nuo7~ hv /M,e P92 -oS-of-o/
/
4 nsrs comouctee
! E O Hydrostatic ratsspas 0 Pneumatic 0 Nominal Operating Pressure O Other Ai/4 pal usrsp)w Al// 'F asuume mamuos umasactwen eara aeront esumeat a appucaa6a 1l NA s.
9 i
I l
CERTIFICATE OF COMPLIANCE We certify that the statements mtdo in this report are correct and this O Repair
[ fleplacement confonns to
} Section XI of the ASME Code.
- i /
ownsene Dmetsem p
- vont y ears L
- . w,me Eu, e , /t. .mt j / [ '
4
{ f ,
3 l -
CERTIFICATE OF INSPECTION 1
j' t, the undersigned, holding a valid commission issued td the National Board of Soiler and Prossure Vessei inspectors and the State or Province of Fw/M l employed by 7#6' //18 J9/I O -
of
- N e C have inspected the j
components described in this Ownefs Report during the period 2-to-9 3 to D 90
- and state that to the best of my knowledge and belief, i
j the Owner has performed examinations and taken corrective measures described in this Owners Report
' in accordance with the requirements of the ASME Code,Section XI.
e Sy signing this certif'cate, neither the inspector por his employer makes any warranty, expressed or implied, concoming the examinations and corrective rnfeasures described in this Owner's Report. Fur-thermore, neither the inspector not his employer shall be liable in any manner for any personal injury i or property damage or a loss of y kind arising frw or connected with this laspectiert i
i MA 4/672 0 4WC/ M /94~~
esEmocion semanna couvosos pianomat soum, stars. enoveses on eseansameau
~7249[
- aus i k J
1 9 NIS 2 OWNER'S REPORT OF REPAlR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI if additional space is necessary use S p lu p emental NIS 2 maa muuun ownsa 94-6628 Florida Power Corporation o4TE 1-P. O. Box 14042 St. Petersburg, FL 33733-4042 rwar Fkwtda Power Corp. J/-26-94 E CrystalRNorEnergyComptes-om1" 3 I
15700 W. Power une Street Crystal Rher. R.3442tHI70s Page / of 8 Mwona nomos etwonuto a svLameam uer onaamaa%.
naram ea a, a muumca, rrc.
o.P.o.
song,7 woJu
- s. 40
/S766o,imiu a.mncar kl. PCkEA t.M/f 7dffT, CR)%7AL R//dd, R. 3$$28 SF
- - uc = acoustaueva con somon towuo cow can.
tJSAS BfI.I 106 7 -
" muca.a oman or ucno a vnumo noa ae4mi on neuccucm3 aowmo4.oom cau.
/983 Enriod 3dnwEt /983 ADD 6dM g.
Identification of Components Repaired or Replaced and Replacement Components mAast or etAME OF MANUFACTUREA'S NAT1oNAL OTHER YEAR ootspoN Dff MANUFACTURER RDARER, REPLACED E a""
SERIAL NUMBER sO. 88o. toD(TIFICATIoM sWILT OR REPLAcDIBff vus se M (/ /Al NA WA SY'$D UA hWlAlblEA!I
- W.
m+
e A eM&*
E e s
/
RMs # IsutretA 94-eetr cmo o, NIS2 CONTINUATION Pao E of f fcPM61 P/PE corm / wrs / A/dir. /Nsma deu/
T-sze zo Mrsa JwnY J72dr MA MNZ E92-QS'-CV-W
== oo uctio n.= n.
E O Hydrostatic 0 Pneumatic C Nominal Operating Pressure G Other s/4 poi g/g y senasse een== isamuractueen enra aeront asuusan, w appucasta i
A/A I CERTIFICATE OF COMPLIANCE We certify that the statements made in this report are correct and this O Repair F Replacement conforms to Section XI of the ASME Code.
e sei ro bac,e C_ ~7 !L 19'%
I l CERTIFICATE OF. INSPECTION
~
t, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel inspectors and the State or Province of FNA4 employed by 7NG NJA[4b of MM T have inspected the components described in this Owners Report during the period 2-/o-93 to 7-2f-9 6 - and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures de scribed in this Owners Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector not his employer makes any warranty, expressed or impiled, concoming the examinations and corrective measures described in this Owners Report. Fur-thermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury or pro rty damage of a loss of any kind artsing from or connected with this inspection.
// dM N8nYO ANtl Ft./95~
eispectons scenatunt couwesoes peatiosant comme, stan, reovests on smoonsusawte
- 7d-9 C
- sais esor s er e
NIS-2 OWNER'S REPORT OF REPAIR OR 9'""""" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI OMER Florida Power Corporation DATE i I' P.O. Box 14042 St Petersburg, FL 33733-4042 g fO ih I
l PLANT Florida Power Corporation I Crystal River Energy Complex - Va*Y 3 15780 W. Power Line Street Crystal River, FL 34425 670s Page [ of 1 VCRK PERFORMED BY (NAME) REPAIR ORGANIZAnON. P O. NUMBER. VWt NUMBER. ETC.
f/cc:ch pow - & ,, o. w azoc.4 s A00RESS l I 5 ~16 o w. (> c -. c L;a 54. d(H &-l O ' v ' <-
i'L 34422 ioENnncAnON OF sv5 TEM /
l M c, n 5 4 A ,,.
l APPucAatE cONSTRucnON cOoE EamON AooENoA. cOoE CASES l 2' l
O5,45 6317 19 M Cm c. e 831-33 APPUCABLE EDmON OF SECnON XJ UTIUZED FOR REPAIRS OR ADDENDA. CODE CASES l
Sb. REPLACEMENTS I 93 T S u r>, ~ c IM3 lN
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACT*JRER'S NATIONAL OTHER YEAR REPAIRED, REPLACED COMPONENT MANUFACTURER SERIAL NUMBER BD. NO. IDENTIFICATION BUILT OR REPLACEMENT vEs No l
% .c Vd ue 09 E -z s n-i-1 ivjn nsu-iro Nln (Lp. ,, ,,. i )(
I l
l l
i l
l l
ggy RET: Lee et Plant RESP: Nuaser Engmeenng 900 431
- y i.orp *=e-
0 NIS-2 CONTINUATION l f4/4 .320@ Page of 1 l r
%$CRIPTION OF WORK Snla n U
- I ve be, Ue Idin m W d
- 7. l TEST S CONDUCTED PRESSURE 'EST TEMP 5
Hydrostatic 0 Pneumatic 0 Nominal Operating Pressure O otner i 2o o pai n.9 j REMARKS (INCLUDE MANUF ACTURER'S DAT A REPORT NUMBER, IF APPLICABLE) ru" l 9.
I 1
CERTIFICATE OF COMPLIANCE W3 certify that the statements made in this report are correct and this Repair Replacement conforms to Szction XI of the ASME Code.
/p n OWNER - SIGNAYURE TITLE UATE f 4ER S $ SIGN' n -..
0,.rdst bcmcet 29bL
. ,. h, , ,
i CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel ;
Inspectors and the State or Province of FuooA ,
employed by 77/E /#6 I97 ro. of ,
44rff7;feb ,v f have inspected the components described in this Owners Report during the period / W- to 7-t9 #1(, and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owners Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the Inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
l
)td,A4bW , Nd /Cro Aes// fg /'lf INSPECTOR'S SIGNATURE COMMi$$10NS (NATIONAL BOARD, STATE, PROVINCE OR ENDORSEMENTS)
~7-29 M &
DATE i l
l 1
900 431 Page 2 ij
NIS-2 OWNER'S REPORT OF REPAIR OR 9'""""" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI !
OvWER Florida Power Corporation DATE 1' P.O. Box 14042 St Petersburg, FL 337334042 hh [Q h PLAur Florida Power Corporation
- 2. Cryste: River Energy Compien - va Y 3 15760 W. Power Line Street Crystal River, FL 344254708 Page / of 1 WORN PERFORMED BY (NAME) REPAIR ORGANIZATION P O. NUMBER, YWt NUMBER. ETC.
Pe w f/oc: L % o. Wl*3 I R 003 ADDRESS I 5 7 c, o w. p n, - L;n 5f Cr nH! R.v - <
t= L '4422 :
iDeunnCAnON'OF SvSTEu / l 6c /mu l APPUCABLE CONF /TRUCTION CODE EDITION ADDENDA. CODE CASES kre be m.c ls 5 19 APPUCABLE EDITION OF SECTION XI UTluZED FOR REPAIRS OR ADDENDA. CODE CASES l Sb. REPuCEMENTS '
Idi 9 ~5 $It #e n Iu w M83 Sh
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED COMPONENT MANUFACTURER SERIAL NUMBER BD. NO. IDENTIFICATION BUILT OR REPLACEMENT vES NO l o% <bs blh Yl$ NhW hh$ CDlea cN Y 4
f ) '
/ / / I l
l 1
I l
i 11/94 RET: LWe of Plant RESP: Nucteer Engmeenng 900 431
- f h W y y '**
l e
- l NIS-2 CONTINUATION !
6/A .3/9t273 Page l of 1 j CESCRIPTION OF WORK Ae ' otm N~. i %~r a s .fe~ ed 6m
/
w d J rn , a *, & c e F -In 77 th/ 't 1 d J I
TESTS cot DUCTED PRESSURE TEST TEMP
'F Hydro.tatic O Pneumate O nomin.i o,.r. ting er...ur. D otn.r U s 6 p*' Or REMA8iKS (INCLUDE MANUF ACTURER'S DAT A REPORT NUMBER. IF APPLICABLE)
O> L % h ,., dSAS [3 31. J ,1 A C 8 . % Hg1 fu /. j J '
- . case B ri m 11 0 La .
USAs B3i.>. in n . fa,
) ! l l
l CERTIFICATE OF COMPLIANCE !
W3 certify that the statements made in this report are correct and this Repair kReplacement conforms to S ction XI of the ASME Code.
,/ 7 t W4ER OR O GN ' S1 NATURE TfTLE DATE 6N> saaut Sau.:ce2 7 i i G ~
j y j-l CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of RacM ,
employed by 7he #/d 7(EO of
/#/?/9/1D, c7" _
have inspected the components described in this Owner's Report during the period /-#-96 to 1-21 '/6 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken correct;ve measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
h ti, A < 6 b t V A/8 7$50 4A/W 2 /9[
IN5PECTOR'S SIGNATURE COMMISSIONS (NATIONAL BOARD, ST ATE, PROVINCE OR ENDORSEMENTS) j l
l was DATE 900 431 Page 2
NIS-2 OWNER'S REPORT OF REPAIR OR 9"*"~" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI OMER FloridE Power Corporation DATE P.O. Box 14042 St. Petersburg, FL 33733-4042 g4 PLANT Florida Power Corporation
- 2. Cryatal River Energy Complex -u AlsT .)
15780 W. Power Line Street Crystal River, FL 344284708 Page / of 2
, VORK PERFORMED BY (NAME) REP AIR ORGANIZATION. P O NUMBER, Wt NUMBER. ETC.
Rabb4 M M 33Zl0D ADDRESS
/5740 W. Axeck out Jf~. CMJfkC N(/EK o ff. 34478 IDENTIFICATION OF SYSTEM
- 4. pg APPLICABLE CONSTRUCTION CODE EDITION ADDENDA. CODE CASES 5a. Asy; Sgy,g y, g gg gg j APPUCABLE EDITION OF SECTION XJ UTluZED FOR REPAIRS OR ADDENDA. CODE CASES Sb. REPLACEMENTS
' /4 E3 523 A6bc%IbA
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED COMPONENT MANUFACTURER SERIAL NUMBER BD. NO. IDENTIFICATION BUILT OR REPLACEMENT vES NO VAcouM 4AIMdfoAl HM stM pnI449 MM LEAActuGvr /
i AGlJEF WWE GRE&lWxD d
- O 4
!I 11/94 RET: Life of Plafit RESP: Nucseer Engineenng 900 431
( .
l NIS-2 CONTINUATION
/04 332/o0 P.ge 2 of 2 OESCRIPTION 7 WORK I
l
/EdRAci ab //Kt/G 7.
PRE 55uRE ~EST TEMP )
'ESTS CONDUCTED 5 '
- 8. O m ro.i.i. O en.um.t. O somin i o,er.iin, pr.S.ur. Mein ,, A//4 pi x//4 REMARKS (INCLUDE MANUF ACTURER'S DATA REPORT NUMBER LF APPUCABLE) 1852n UNb;2 t/A:JJM A W. JP-GoL i l
i
- 9. 1 l
l l
CERTIFICATE OF COMPLIANCE I l
W3 certify that the statements made in this report are correct and this Repair NReplacement conforms to S:;ction XI of the ASME Code.
i l
7;TLE DATE Q#4ER OR O#iER NEG %b E
, - e co m E+-et 'dz9hc l
ic
. I CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of FucM ,
of employed by ne NIgr v.r c.
' have inspected the
- f7Fiv:'D cT
/- 66 to components described in this Owner's Report during the period 1-24 -9( and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
/tLh A46f Nd16o M C/ Ft /W COMMISSIONS (NATIONAL BOARD. STATE, PROVINCE OR ENDORSEMENTS)
INSPECTOR'S SIGNATURE f
oATE 900 431 Page 2
NIS-2 OWNER'S REPORT OF REPAIR OR 9"""'"" REPLACEMENT AS REQUlRED BY THE PROVISIONS OF ASME CODE SECTION XI OMER Floridi Power Corporation DATE P.O. Box 14042 St. Petersburg, FL 33733-4042 ggg PLANT Florida Power Corporation
- 2. Crystal River Energy Complex -94tr 3 15780 W. Power Line Street Crystal River, FL 344284708 Page / of '2 MORK PERFORMED BY (NAME) REPAlR ORGANIZATION, P O. NUMBER. VWt NUMBER. ETC.
3* RMb9 lbW4K CBfA WR 325420 ADDRESS
/5740 W Ibwr2 udE st ctgrInt ht/c4 iFC 344b6 IDENTIFCATION OF SYSTEM
- 4. g(
APPUCABLE CONSTRUCTION CODE EDmON ADDENDA. CODE CASES Sa. p3pg gg(_yyo,, _,y pgp g 3,(,g _Sgy py,gygg APPUCABLE EDITION OF SECTION XI UTIUZED FOR REPAIRS OR ADDENDA, CODE CASES Sb. REPt4CEMEurs l']S3 J23 ALVle*WDA
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED n COMPONENT MANUFACTURER SERIAL NUMBER BO. NO. IDENTIFICATION BUILT OR REPLACEMENT vEs Y VALVE DAdH&'!- Bl.DE90 i M/A RCV-to W/A LERAcgHtwr /
1 ygt.ys VEu1AI SISto N/A ACV-// W/A A&RAC2Htntr '
I 1
l 11/s4 RET: Late of Plant pESP: Nudeat Engmeenng 900 431
T A
NIS-2 CONTINUATION gggzo p.a. 2 of Z DESCRIPTION OF WORK ASPtACE IMu/H Ac6/0 AMD Ac6//
- 7. /ERAM J7 par AvD Nur.T.
l i press.lRE 'EST TEMP
'ESTS CONOUCTED 0' Ooin., zzw n6 5 I O syoro.i.iic Opn.um.iie S uomin.i on.r.i.no pr...ur. asi3 REMARKS (INCLUDE MANUF ACTURER'S DATA REPORT NUMBER. IF APPUCABLE)
TMT prmrtwten as vnt w s a At= rs nM(,f ocstGAl-
, 9.
i l
l CERTIFICATE OF COMPLIANCE 1
W3 certify that the statements made in this report are correct and this Repair h Replacement conforms to i
Section XI of the ASME Code. !
- (
mtE aATE .
omeR OR OwnE- so ersi NATURE f,- - RioctM L N6eet92- 7!E'%
i
- l r/
l CERTIFICATE OF INSPECTION f
1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of Fom 6 A ,
of l
employed by W MS I 4I G 4AcKoch ,c7' have inspected the components described in this Owner's Report during the period i 'e-4 L to l
l '7-?A -% and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his amployer makes any warranty, expressed or implied.
l concerning the examinations and corrective measures described in this Owner's Repod. Furthermore, neither
! the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
cAAkbE J Ud 7[sD M C/ R/W 2 INSPECTORS SIGNATURE COMMISSIONS (NATIONAL BOARD. STATE. PROVINCE OR ENDORSEMENTS) 7.ze m 04TE i
{
900 431 Page 2
r NIS-2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS .
l OF ASME CODE SECTION XI l i
l QWNER Florida Power Corporation DATE I
~7/// //9[,
P.O. Box 14042 SL Petersburg, FL 33733-4042 2- Crystal River Energy Complex-tieJ ar 3 15760 W. Power Line Street Crystal River, FL 34428 6708 Page \ of ~2 WORK PERFORMED BY (NAME) REPAlR ORGANIZATION, P O. NUMBER. Wt NUMBER. ETC.
bt.c4.t04 ) owc-e. CoAP. Mi'- 3 2. 5 8 4 3 ADDRESS
~
! lS16 0 d. Poma Laus Sucez Gysta t. 2.act FL. 3we. u' IDENTIFICATION OF SYSTEM ke a ct o2. C. cot.4er (dC APPUCABLE CONSTRUCTION CODE EDITION ADDENDA, CODE CASES sa.
ASM Seaim lit, C uss 1 1965 so-ca. 67 l APPUCABLE EDITION OF SECTION XI UTIUZED FOR REPAIRS OR ADDENDA, CODE CASES sb. REPLACEMENTS 1463 f orreod .So - c2 63 Acacuo s i
- 6. Identification of Components Repaired or Replaced and Replacement Components
]
NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED COMPONENT MANUFAC7URER SERIAL NUMBER BD. NO. IDENTIFICA's10N BUILT OR REPLACEMENT YES NO G m a tt .l'__ t t>x G ED- COO 7*SS~ 2 H- 12 O ACM- I & 19'1I rkc%112 Eb l l
l l
I I
l 1144 RET: Life of Plant RE8P: Nuclear Engineermg 9'JO 431
i o
NIS-2 CONTINUATION
[(//8 3I Page 2 of 2.
DESCRIPTION OF WORK
~
W lS $l/ N85 UO.$ AY N U/A//WF 1"xant ML/ 7D &y ct/M StRH/Af#770 A).
PRE 5suRE TEST TEMP
'ESTS CONDUCYED O syoro.iai,e O pn.umai,e O Nominal Operating Presaur. Ooin., ## oii ## 5 l
REMARKS (INCLUCE MANUF ACTURER'S DATA REPORY NUMBER.1F APPLICABLE) voas 9.
1 1
i 1
l CERTIFICATE OF COMPLIANCE Wa certify that the statements made in this report are correct and this O Repair Replacement conforms to Section XI of the ASME Code.
QWNER OR C# 5 o O 4GNEE SIG ATURE OATE s e.i ci en t.- besteett '
M 6 '
i f CERTIFICATE OF INSPECTION I, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of Rece4 ,
of employed by 774 Nrd I v'ICo
- W &'#A > W have inspected the
/-d-9 4- to components described in this Owner's Report during the period 7-t9 '/6 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither i l
the Inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
44 4 SW 4/B 7 D t) RWo fi- /9f COMMISSIONS (NATIONAL BOARD, STATE. PROVINCE OR ENDORSEMENTS)
INSPECTOR'S SIGNATURE 7-2944 oATE 900 431 Page 2 C
NIS-2 OWNER'S REPORT OF REPAIR OR 8"'"""" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI OMER FloridI Power Corporation DATE
- I* P.O. Box 14042 St. Petersburg, FL 33733 4042 3~ 'N
! PLANT Florida Power Corporation
- 2. e,y,t., gly., En.rgy Compi.x .uasir 3 15780 W. Power Line Street Crystal River. FL 34420 6708 Page / of 7 WORK PERFORMED BY (NAME) REPAIR ORGANI2ATION. L k MJMOCR. WR NUMBER. ETC.
fuwM lbWGd. Colf. WK 32LS'AS~
i ADORESS
, /5740 /4 PoRErf. DA/ESi~ C/XJTMC EllGsc FL 3MLB IDENTIFICATION OF SYSTEM A'
hU APPUCABLE CONSTRUCTION CODE EDITION ADOENDA, CODE CASES
, 50. y3pj g 3,, , ,, g 7 gig APPUCABLE EDITION OF SECTION XI UTlu2ED FOR REPAlR$ OR ADDENDA. CODE CASES
- Sb. REPLACEMENTS 1923 313 A% DEA /DR
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REP AIRED, REPLACED COMPONENT MANUFACTURER SERIAL NUMBER BD.NO. IDENTIFICATION BUILT OR REPLACEMENT YES no
}YM JUAMT RhtGd pipidG 730/43 N/A Ht/H-4 0 NM AEPLA G:0 i PINS &ytytr RM4 pip /AIG- 730 /4 o M/A hV//-40 AVA R&A AC2H1ntr A o
1144 RE7: Lde of Plant RESP: Nucent Engmeenne 900 431
6 O i 1
NIS-2 CONTINUATION '
4/4 3%s4f p.g. 2 or 2, DESCRIPTION OF WORK W !fE $ SAf&bl$sitT,, l l
7.
l TE575 CONOUCTED PRE 5SURE TEST TEVP O syaro.i.i.e O en.um. tic 0 Nomin.1 Oper. ting Pressur. Ooin., "M pii we 5 AEMARKS ONCLUCE MANUF ACTURER S DATA REPORT NUMBER. IF APPLICABLE)
NDR/G
- 9. '
l 1
l CERTIFICATE OF COMPLIANCE i l WD certify that the statements made in this report are correct and this O Repair b Replacement conforms to S:ction XI of the ASME Code.
s n OWNER OR O#4ER S DE 3h E g WLE LME M8-NAT - LE u- ddc' il CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel inspectors and the State or Province of 76v&M employed by 7/ F / N J J # J Co . of
/MrtTFo d C T have inspected the l components described in this Owner's Report during the period / 9 6 to l 7-L9-9 (, and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code.Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
l
,&G4A f.edef N87rso AWC/ FY /W IN!iPECTOR'S SIGNATURE COMMISSIONS (NATIONAL BOARO. STATE. PROVINCE OR ENDORSEMENTS)
~7*b'$ Af h DATE 1 -
900 431 Page 2 1
1
)
l
' i NIS-2 OWNER'S REPORT OF REPAIR OR !
REPLACEMENT AS REQUIRED BY THE PROVISIONS I OF ASME CODE SECTION XI OMER Florida Power Corporation DATE g*
P.O. Box 14042 St. Petersburg, FL 33733 4042 7'I~ Y I" PLANT Florida Power Corporation Crystal River Energy Complex.uver.h 15780 W. Power Line Street Crystal River, FL 34428-8708 Page / of 2.
WORK PERFORMED BY (NAME) REPAIR ORGANIZATION, P O NUMBER, Vdt NUMBER. ETC.
Flea /M ftWEst COAP. WK 32S412 ADDRESS
/5760 W. /bWEK f./MG .57" CMkk R/KM. , FL J#428 IDENTIFICATION OF SYSTEM EC APPUCASLE CONSTRUCTION CODE EDITION ADDENDA. CODE CASES Sa. ggfg 374gt, ,p _ gy 9 ,,g, 3,99 ,ggygg APPUCABLE EDITION OF SECTiON XI UTluZED FOR REPAlRS OR ADDENDA. CODE CASES Sb. REPuCEMENTS
/983 3 83 Ah2.M.
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRFD, REPLACED i n COMPONENT MANUFACTURER SERIAL NUMBER BD.NO. IDENTIFICATION BUILT OR REPLACEMENT YES NO VAWG besHEL BU 03/42 Nbt R& Y- 9 1179 Ac/receO /
L/A W S besBEtt. BU O3/49 WM AtV-9 1979 pestaceMa/r v 1
l l
11/94 RET: Ldo of Plant RESP: Nucsear Engineering 900 431
NIS-2 CONTINUATION g gg p,,e z or z Of;3CRIPYlON OF VORK NW# OlO Ukk 7.
PRE 55VRE 'EST TEVP
'ESTS CONDUCTED I/II fis T O s vero.t.ii. O Pneumatic E Nominal Operating Pre.sure Other PSI REMARKS (INC,LUDE MjNUF ACTURER'S DATA REPORT NUMBER if APPUCABLE)
Aled 'k\g, rhLT 4Y W d stn ) M 70 vALJt~flAM Q C'Si G6 9.
CERTIFICATE OF COMPLIANCE Wa certify that the statements made in this report are correct and this C Repair Replacement conforms to Ssction XI of the ASME Code.
J A Q#4ER OR OM4ER S ICP E $6G AT E '!TLE GATE
,M e 4AOL /ht , rei Alt'll d$
r /
CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of rwcM ,
employed by THe //JE I/ T (o- of 44cnbEA , dr have inspected the components described in this Owner's Report during the peried I-946 to 7-z9 'i 6 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Codo,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the Inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
) car 4 #04~ A/B rno Act ft /9[
INSPECTOR'S SIGNATURE COMMISSIONS (NATIONAL BOARD. STATE, PROVINCE OR ENDORSEMENTS) 7-29 4/ h DATE h
l l
l 900 431 Page 2
NIS-2 OWhER'S REPORT OF REPAIR OR 9""*""" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI g* O M ER FlorkfE Power Corporation DATE P.O. Box 14042 St. Petersburg, FL 33733-4042 3h%
PLANT Florida Power Corporation
- 2. Crystai River Energy Compien-u ir a 15780 W. Power Line Street Crystal River, FL 34428 6708 Page / of 2 WORK PERFORMED BY (NAME) REPAlR ORGANIZATION, P O. NUMBER. Ydt NUMBER. ETC.
Ro//DA AWC,C CD/lf UA 3.sda2S ADDRESS
/S740 M /hWart. tjA/E J7 CAMT;k PJVol a FL 3 4488 IDENTIFICATION OF SYSTEM APPUCABLE CONSTRUCTION CODE EDTION ADOENDA, CODE CASES Sa. gjpg g3,, , , , ,, .y gg APPUCABLE EDTION OF SECTION XI UTluZED FOR REPAlRS OR ADDENDA, CODE CASES Sb. REPtACEMcNTS
/923 E83 At)MA/DA
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED n COMPONENT MANUFACTURER SERIAL NUMBER BD. NO. IDENTIFICATION BUILT OR REPLACEMENT vES Y P/PEJuhbtr RW&c hhdG 7CD12A H)? H.9/- 574 0 MA reb 4ren X pigJapscr Rant MtNG 766/9 5 A//4 MW-S/h u M/A MftK.fHaar ><
e 1154 RET: Ufo of Plant Rf SP: Nuoear Engmee<mo 900 431
NIS-2 CONTINUATION
$h2 $$W Page 2. of 2.
DESCRsPTION OF WORK 9Z/ & 2 W A JAJ 08 6Erf-7.
'ESTS CONDUCTED PRE 55URE 'EST TEMP O s varo.i.i.e O pn.um.iic 0 Nominal Operating Pres.ur. Ooin., NM pi #4 'F REMARKS (INCLUDE MANUF ACTURER S DAT A REPORT NUMBER IF APPUCABLE)
MONG 9.
CERTIFICATE OF COMPLIANCE W3 certify that the statements made in this report are correct and this Repair @ Replacement conforms to Section XI of the ASME Code.
n omER OR CMER , ' iN E'SIG ATURE TITLE DATE
S.4L/4L eW f Mf_
'n j CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of Ez'oe'< M ,
employed by 7Mr #td J# 6 . of
/A&7 fore ,cT have inspected the components described in this Owner's Report during the period /- d-96 to 7-24-96 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner'r, Report. Furthermore, neither the Inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
A t/,A' A M A)6 XG AsW R /W INSPECTOR'S SIGNATURE COMMISSIONS (NATIONAL BOARD. STATE. PROVINCE OR ENDORSEMENTS) 8 "l**2k-& b DATE i
900 431 Page 2
O
/
NIS-2 OWNER'S REPORT OF REPAIR OR
""*""" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI i
A OWNER Florid 3 Power Corporation DATE 4
P.O. Box 14042 3.y.94
)
St. Petersburg, FL 33733-4042 PLANT Florida Power Corporation
- 2. Crystal River Energy Complex - UN/T 3 15780 W. Power Line Street Crystal River, FL 34428 8708 Page / of 2 VORK PERFORMED BY (NAME) REPAIR ORGANIZATION. P O NUMBER. VWt NUMBER, ETC.
3' f%hDA kJSA CWif. WA 32fo.f4 2.
ADORESS
/.C24;O W. Pb W & UAIE.S M CMJTK /2/Vav. a 5/. M4Le IDENTIFICATON OF SYSTEM A
1 MS 1
APPUCABLE CONSTRUCTION CODE EDTION ADOENDA, CODE CASES
, 5a. ygg3 gy,, , , , (, y pi,9
' APPUCABLE EDTION OF SECTION XI UTIUZED FOR REPA1RS OR ADDENDA CODE CASES 5b. REPLACEueNTS
/4 $3 S 63 ADMa)DA t
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED COMPONENT MANUFACTURER SERIAL NUMBER BO. NO. IDENTIFICATION BUILT OR REPLACEMENT YES NO P/M St/Abt27 /kuG4 M/M6 84000L N/A MIN- /t*O AWA A&Mc1D X PNJtAMT MGC AA% 7300/9 AVA MJ//-/.r0 WA REMf2H2Wr 4 l
l i
11794 RET: Lde of Plant RESP: Nudest Engmeenng 900 431
i .
NIS-2 CONTINUATION M 2I[aff[., P.go 2 of Z, DESCRIPTION OF WORK MRo4c2 Olb JNU8tt4t.
t
! 7.
MESSURE TEST TEMP
?ESTS CONOUGTED
'F l 8. g g ,,,,.ie 0 en...a O m in. m o.r t,no e,...ur. 0 3., a/s 9.i um REMARKS (INCLUDE MANUF ACTURER'S DAY A REPORT NUMBER. IF APPUCABLE)
NoAfG 9.
l CERTIFICATE OF COMPLIANCE W3 certify that the statements made in this report are correct and this O Repair beplacement conforms to f
l S:ction XI of the ASME Code. I m
TITLE DATE
( C#aER OR O#4ER S 4E G TURE
. ~ $/ w OtAx@t hs,aece '7,k'R YC, l
i i CERTIFICATE OF INSPECTION I, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of honD4 ,
7N F #J~6 J / I Co . of l employed by
/ N J ,C7~ have inspected the l to l components described in this Owner's Report during the period /"-d -9 6 7-24-9 /- and state that to the best of my knowledge and belief, the Owner has i
! performed examinations and taken corrective measures described in this Owner's Report in accordance with
! the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, l
l concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither l the inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
l 4td,AMt oG A/G 7t'sm ANC/ i"il / 9 f COMMISSIONS (NATIONAL BOARD. ST ATE, PROVINCE OR ENDORSEMENTS)
I INSPECTOR'S SIGNATURE 7-79-9 6 oATE 000 431 Page 2
NIS-2 OWNER'S REPORT OF REPAIR OR 9,,,,,,,,,,, REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI CWNER FloridE Power Corporation DATE I* P.O. Box 14042 St. Petersburg, FL 33733 4042 pp 9g l PLANT Florida Power Corporation l
- 2. ery. .i niv. ,en ,,,y e ,pi , ,y 4,,7 3
! 15780 W. Power Line Street Crystal River, FL 34428 6708 Page / of Z WORK FERFORMED BY (NAME) REPAfR ORGANIZATION, P O NUMBER. WR NUMBER, ETC.
3 FloAfM puW&c. Cad. og 374 472 If740 W. A4Arv. uns ~rr~ OtMrk. DVJrE < t=Z 3HtB IDENTIF6 CATION OF SYSTEM
- 4. pg APPLICABLE CONSTRUCTION CODE EDITION ADDENDA. CODE CASES 5a. y 3 g 3 g_g ,, , , , ,, y gp APPUCABLE EDITION OF SECTION XI UTIUZED FOR REPAIRS OR ADDENDA. CODE CASES Sb. REPLACEMENTS
/%3 J. i3 Az%%/DR
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPLACED COMPONENT MANUFACTURER SERIAL NUMBER BD. NO. IDENTIFICATION BUILT REPAIRED'ACEMENT OR REPL vgs no l hPG SUAbG~ /MfGL PtDidG- 7D092 Mjf MSV--/% N/4 age /M g AN JuRtvt7 /bwSL Pt/tas 130/19 y/4 n/V-/24 g/; x;;tiggg7- pc l
I l
l l
l l
i i
I 11/94 RET: Life of Pierit RESP: Nucseat Engmeenng 900 431 a
4 NIS-2 CONTINUATION 4//C .0&?{ P.ge 7 of 2,,
DESCRIPTION OF WORM
/lEAAw otD %t4& M .
7.
oREssVRE TEST TEMP
'Esis CONDUCT ED O 4,o,..i.i.e O pneum.ie O nom,n.i op.r.iin, p,...ur. O oin., N/A rii va *F REMARKS (,NCLUDE MANUF ACTURER S DATA REPORT NUMBER IF APPUCABLE)
A/DAJ6 9.
CERTIFICATE OF COMPLIANCE Wa certify that the statements made in this report are correct and this C Repair O Replacement conforms to Section XI of the ASME Code.
TirLE ;4TE C#4ER QR R - GNEE SaGNATURE AsY/ j warAt D,,mr a 9b9hG
/ I
/ f
CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of hoab4 ,
employed by 7//P //fd Z9 FIG . of
/Mr7Fod C have inspected the components described in this Owner's Report during the period /-8 4 6 to 7-Z '/-9 6 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the Inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
l
) t h r b b k t.J S A/G 7f8 AdQ rC/h' T
D INSPECTOR'S SIGNATURE COMMISSIONS (NATIONAL BOARD, ST ATE. PROVINCE OR ENDORSEMENTS) 7 7'l-96 oats 900 431 Page 2
NIS-2 OWNER'S REPORT OF REPAIR OR 9""'""" REPLACEMENT AS REQUIRED BY THE PROVISIONS OF ASME CODE SECTION XI OWNER FloridI Power Corporation DATE P.O. Box 14042 St. Petersburg, FL 33733-4042 5-/8-M PLANT Florida Power Corporation
- 2. e,y. i Riv., gn.,,y compi. . ywr 3 15780 W. Power Line Street Crystal River, FL 344234708 page / of Z vcRK PERFORMED BY (NAME3 REPAIR ORGANIZATION, P O. NUtI8EN. WR NUMBER. ETC.
3 R.af2M fbWEL CotP. p/g 3/942g ADDRESS
/S740 W. PalErt tJdE J7 4 cci5;M. Aty' E / ,R 34428 IDENTIFICATION OF SYSTEM
- 4. ac APPUCABLE CONSTRUCTION CODE EDITION ADDENDA, CODE CASES Sa. gggy g3f,7 ,, g,9 gg APPUCABLE EDITION OF SECTION XI UTIUZED FOR REPAIRS OR ADDENDA, CODE CASES Sb. REPtACEMENTS
'/923 J G A&WD4
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF NAME OF MANUFACTURER'S NATIONAL OTHER YEAR REPAIRED, REPLACED COMPONENT MANUFACTURER SERIAL NUMBER BD.NO. IDENTIFICATION BUILT OR REPLACEMENT vEs T VALM fbkW P//tMG NM NM RCH '20 R & f b % ' M 6 /7~~ /
.Su/%sr*
Vau/E B4et P/hdG- N/A AM RCH i/ f.EfYACG et& W V
,2)f%W l
l l
l 1144 RET: LWe of Plant RtSP: Nuoear Engmeenng 900 431
9 e
NIS-2 CONTINUATION wil v%ftf P.ee 2. at z DESCR:PTION OF WORK HablFf hPs CIAMPs FM t/AWS RO/-B AA/D AC/-M.
- 7. (06tD JWMS TD //4Wi 7bts.r.
'ESTS CONDUCTED PRESSURE 'EST TEMP 0 nomin.i on.r.i.no pr...or. Ooin., N4 pi ///R r Osvero.i.i. O en.um. tie REMARES (INCLUDE MANUF ACTURER S DATA REPORT NUMBER IF APPLICABLE)
N/A 9.
CERTIFICATE OF COMPLIANCE W3 certify that the statements made in this report are correct and this Repair b Replacement conforms to Szction XI of the ASME Code.
a.:E omER OR ow > pNE NATURE Ty_
I- n -tborot san e 7bG.bc.
t i
< / j' CERTIFICATE OF INSPECTION 1, the undersigned, holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors and the State or Province of /h?hD4 ,
4 employed by 7Nf MA IU Co - of r4M7TWA , & have inspected the components described in this Owner's Report during the period / 946 to j 7-29 -9 6 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the Inspector nor his employer shall be liable in any manner for any personal injury or property damage or a loss of any kind arising from or connected with this inspection.
&&W8YV AM wsv Mc/ Fr. /W COMMISSIONS { NATIONAL BOARD, STATE, PROVINCE OR ENDORSEMENTS)
INSPECTOR'S SIGNATURE 7-2M 6 oarE 900 431 Page 2
. e NIS-2 OWNER'S REPORT OF REPAIR OR REPLACEMENT AS REQUIRED BY THE PROVISIONS S""*""" OF ASME CODE SECTION XI OWNER Florida Power Corporation DATE l' P.O. Box 14042 St. Petersburg, FL 33733-4042 /- l l. / 4 d #
ptANT Flor 6da Power Corporation
- 2. crygt.i Riv., Energy Compi.x - va>Y 3 16780 W. Power Line Street Crystal River. FL 34428 670s Page / of )_
WORK PERFORMED BY (NAME) REPAIR ORGANIZATION. P O. NUMBER. WR NUMBER. ETC.
ADORESS F/oc:L Powc, w o. UG26499
$$]$0 (A.). O c wo r- L }ne h 'f, bf HTY*I E
- V ' r' / 3YW2$
IDENTIFICATION'OF SYSTEM /
Dec. Ne. -/- ( DH)
APPuCABtE CONSTRUCTION CeE eDTiON ADoeNoA. CooE CASES U SAS G3I- l 196 3 hll A '
APPUCABLE EDTION OF SECTION XI UTIUZED FOR REPAIRS OR ADDENDA. CODE CASES Sb. REPLACEMENTS Ii23 F-d; hon ,$ , , ,, c , (993 U.
- 6. Identification of Components Repaired or Replaced and Replacement Components NAME OF COMPONENT NAME OF MANUFACTURER MANUFACTURER'S SERIAL NUMBER NATIONAL BD. NO.
OTHER IDENTIFICATION YEAR BUILT REPAlRED, REPLACED OR REPLACEMENT vES hNO Roe Swan,J Pw Pio.x % y 750m2 NIn 9HA-2.I ILIlw L ,t..,) i t' f Rn SnI' 1 P~. P.o.~) % s 7soo1, ivin C)/in-11 silw f
Ik ta <.w x f '
] ' I f
1144 RET: Lde of Plant RE8P: Nuclear Engmeenng 900 431
~ ~ '
"C M ' N ' T ' * . . * . .
_ _ _g
~
NIS-2 CONTINUATION G//Ljfb$$$ Pagehof l l
DESCRIPTION OF VORK eO LCe O$$ D h c., $ br r*
I 7.
TESTS CONDUCTED PRESSURE TEST TEMP O syoro.t.iie O Pneum. tic 0 womin.i op.r.iina e r...ur. Ooin., pfe p i jv/r 5 ,
/ I REMAPKS (INCLUDE MANUF ACTURER S DAT A REPORT NUMBER. IF APPLICABLE)
Neu I
- 9. l CERTIFICATE OF COMPLIANCE Wa certify that the statements made in this report are correct and this Repair h Replacement conforms to Szction XI of the ASME Code.
, A OWNER OR OWN . D # EE 'GNATURE TITLE DATE r - esse d Q L 0 x. m 1!2 6 i */
CERTIFICATE OF INSPECTION I, the undersigned, holding a valid commission issued by the National Board of Boiler aqd Pressure Vessel inspectors and the State or Province of Fu&M ,
employed by D E Ars 6 1 / r G . of
/4 k 6 v 0 W have inspected the components described in this Owner's Report during the period /-8 4 4 to M'?- 96 and state that to the best of my knowledge and belief, the Owner has performed examinations and taken corrective measures described in this Owner's Report in accordance with the requirements of the ASME Code,Section XI.
By signing this certificate, neither the inspector nor his employer makes any warranty, expressed or implied, concerning the examinations and corrective measures described in this Owner's Report. Furthermore, neither the Inspector nor his employer shall be liable in any manner for any personalinjury or property damage or a loss of any kind arising from or connected with this inspection.
&br 0 Nb l[WO H A// N /Yf INSPECTOR'S SIGNATURE COMMIS$40NS (NATIONAL BOARD. STATE. PROVINCE OR ENDORSEMENTS) 7-24 JJ 4 DATE 900 431 Page 2