ML11347A195: Difference between revisions

From kanterella
Jump to navigation Jump to search
(Created page by program invented by StriderTol)
(Created page by program invented by StriderTol)
 
Line 15: Line 15:


=Text=
=Text=
{{#Wiki_filter:Thomas Mogren Manager -Engineering Services R.E. Ginna Nuclear Power Plant, LLC 1503 Lake Road C E N G Ontario, New York 14519-9364 a joint venture of 585.771.5208 0 Cwonstlaton Ene .VON 585.771.3392 Fax Thomas.Mogren@cengllc.com December 6, 2011 U.S. Nuclear Regulatory Commission Washington, D.C. 20555-0001 ATTENTION:
{{#Wiki_filter:Thomas Mogren Manager - Engineering Services R.E. Ginna Nuclear Power Plant, LLC CEN G a joint venture of 1503 Lake Road Ontario, New York 14519-9364 585.771.5208 0     Cwonstlaton   #.Cn*58.71.20 Ene   .     VON                                           585.771.3392 Fax Thomas.Mogren@cengllc.com December 6, 2011 U.S. Nuclear Regulatory Commission Washington, D.C. 20555-0001 ATTENTION:             Document Control Desk
Document Control Desk  


==SUBJECT:==
==SUBJECT:==
R.E. Ginna Nuclear Power Plant Docket No. 50-244 Thirty (30) Day Special Report -Inoperable Radiation Monitors Radiation monitors R-31 and R-32, "A" and "B" Main Steam Radiation Monitors, respectively, have been inoperable for greater than 30 days. This special report is submitted in accordance with Section 3.3 and Table 3.3-1, Action 1, of the R.E. Ginna Nuclear Power Plant Offsite Dose Calculation Manual (ODCM), Revision 27, which requires that these radiation monitors be operable in Modes 1, 2, and 3.Radiation monitors R-31 and R-32 were taken out of service on 10/26/11 for maintenance that involved replacing degraded cables. Upon restoration after the scheduled maintenance, both systems failed. Detailed trouble shooting and maintenance since then has identified several failed circuit boards and sub-components.
R.E. Ginna Nuclear Power Plant Docket No. 50-244 Thirty (30) Day Special Report - Inoperable Radiation Monitors Radiation monitors R-31 and R-32, "A" and "B" Main Steam Radiation Monitors, respectively, have been inoperable for greater than 30 days. This special report is submitted in accordance with Section 3.3 and Table 3.3-1, Action 1, of the R.E. Ginna Nuclear Power Plant Offsite Dose Calculation Manual (ODCM), Revision 27, which requires that these radiation monitors be operable in Modes 1, 2, and 3.
Repairs and component replacements were performed from available stock, however the system faults were not resolved.
Radiation monitors R-31 and R-32 were taken out of service on 10/26/11 for maintenance that involved replacing degraded cables. Upon restoration after the scheduled maintenance, both systems failed. Detailed trouble shooting and maintenance since then has identified several failed circuit boards and sub-components. Repairs and component replacements were performed from available stock, however the system faults were not resolved. This system is no longer supported by the original equipment manufacturer and new replacement parts are not available. Industry peers were contacted, but were unable to provide spare components due to similar obsolescence concerns.
This system is no longer supported by the original equipment manufacturer and new replacement parts are not available.
As a compensatory measure, procedures direct Radiation Protection or Operations to perform local readings as necessary for emergency plan response. To supplement this compensatory measure, remote reading electronic dosimeters have been setup on the main steam lines and procedures have been revised to recognize this compensatory measure. The control room has the ability to monitor these dosimeters. The long term corrective action is to perform a plant modification to replace the radiation monitoring system with a modem system. This modification is expected to be completed by June 8, 2012. Resolution to this issue will be tracked by Condition Report CR-2011-008244.
Industry peers were contacted, but were unable to provide spare components due to similar obsolescence concerns.As a compensatory measure, procedures direct Radiation Protection or Operations to perform local readings as necessary for emergency plan response.
('JPLAIRC- I00c2140I
To supplement this compensatory measure, remote reading electronic dosimeters have been setup on the main steam lines and procedures have been revised to recognize this compensatory measure. The control room has the ability to monitor these dosimeters.
 
The long term corrective action is to perform a plant modification to replace the radiation monitoring system with a modem system. This modification is expected to be completed by June 8, 2012. Resolution to this issue will be tracked by Condition Report CR-2011-008244.
Document Control Desk December 6, 2011 Page 2 There are no new commitments identified in this letter. Should you have questions regarding this matter, please contact Thomas Harding at 585.771.5219 or Thomas.HardingJr@CENGLLC.com.
('JPLAIRC-I00c2140I Document Control Desk December 6, 2011 Page 2 There are no new commitments identified in this letter. Should you have questions regarding this matter, please contact Thomas Harding at 585.771.5219 or Thomas.HardingJr@CENGLLC.com.
Very truly yours Thomas Mogren cc:     W.M. Dean, NRC D. V. Pickett, NRC Resident Inspector, NRC (Ginna)}}
Very truly yours Thomas Mogren cc: W.M. Dean, NRC D. V. Pickett, NRC Resident Inspector, NRC (Ginna)}}

Latest revision as of 12:00, 12 November 2019

R. E. Ginna Nuclear Power Plant - Thirty (30) Day Special Report - Inoperable Radiation Monitors
ML11347A195
Person / Time
Site: Ginna Constellation icon.png
Issue date: 12/06/2011
From: Mogren T
Constellation Energy Nuclear Group, EDF Group
To:
Document Control Desk, Office of Nuclear Reactor Regulation
References
Download: ML11347A195 (2)
v • d • e


Text

Thomas Mogren Manager - Engineering Services R.E. Ginna Nuclear Power Plant, LLC CEN G a joint venture of 1503 Lake Road Ontario, New York 14519-9364 585.771.5208 0 Cwonstlaton #.Cn*58.71.20 Ene . VON 585.771.3392 Fax Thomas.Mogren@cengllc.com December 6, 2011 U.S. Nuclear Regulatory Commission Washington, D.C. 20555-0001 ATTENTION: Document Control Desk

SUBJECT:

R.E. Ginna Nuclear Power Plant Docket No. 50-244 Thirty (30) Day Special Report - Inoperable Radiation Monitors Radiation monitors R-31 and R-32, "A" and "B" Main Steam Radiation Monitors, respectively, have been inoperable for greater than 30 days. This special report is submitted in accordance with Section 3.3 and Table 3.3-1, Action 1, of the R.E. Ginna Nuclear Power Plant Offsite Dose Calculation Manual (ODCM), Revision 27, which requires that these radiation monitors be operable in Modes 1, 2, and 3.

Radiation monitors R-31 and R-32 were taken out of service on 10/26/11 for maintenance that involved replacing degraded cables. Upon restoration after the scheduled maintenance, both systems failed. Detailed trouble shooting and maintenance since then has identified several failed circuit boards and sub-components. Repairs and component replacements were performed from available stock, however the system faults were not resolved. This system is no longer supported by the original equipment manufacturer and new replacement parts are not available. Industry peers were contacted, but were unable to provide spare components due to similar obsolescence concerns.

As a compensatory measure, procedures direct Radiation Protection or Operations to perform local readings as necessary for emergency plan response. To supplement this compensatory measure, remote reading electronic dosimeters have been setup on the main steam lines and procedures have been revised to recognize this compensatory measure. The control room has the ability to monitor these dosimeters. The long term corrective action is to perform a plant modification to replace the radiation monitoring system with a modem system. This modification is expected to be completed by June 8, 2012. Resolution to this issue will be tracked by Condition Report CR-2011-008244.

('JPLAIRC- I00c2140I

Document Control Desk December 6, 2011 Page 2 There are no new commitments identified in this letter. Should you have questions regarding this matter, please contact Thomas Harding at 585.771.5219 or Thomas.HardingJr@CENGLLC.com.

Very truly yours Thomas Mogren cc: W.M. Dean, NRC D. V. Pickett, NRC Resident Inspector, NRC (Ginna)

Retrieved from "https://kanterella.com/w/index.php?title=ML11347A195&oldid=2109068"