ML16257A454: Difference between revisions
StriderTol (talk | contribs) (Created page by program invented by StriderTol) |
StriderTol (talk | contribs) (Created page by program invented by StriderTol) |
||
Line 42: | Line 42: | ||
* MAPLHGR four and three recirculation loop operation multipliers | * MAPLHGR four and three recirculation loop operation multipliers | ||
* Linear Heat Generation Rate (LHGR) | * Linear Heat Generation Rate (LHGR) | ||
* Limiting Power I Flow Line This report is prepared in accordance with Technical Specification 6.6.5 of Reference | * Limiting Power I Flow Line This report is prepared in accordance with Technical Specification 6.6.5 of Reference | ||
: 1. Power and flow dependent limits are listed for various power and flow levels. Linear interpolation is to be used to find intermediate values. Nine Mile Point Unit I is a non-ARTs plant that utilizes ELLLA operating domain. The data presented in this report is valid for all licensed operating domains on the operating map, including: | : 1. Power and flow dependent limits are listed for various power and flow levels. Linear interpolation is to be used to find intermediate values. Nine Mile Point Unit I is a non-ARTs plant that utilizes ELLLA operating domain. The data presented in this report is valid for all licensed operating domains on the operating map, including: | ||
* Extended Load Line Limit down to the minimum licensed core flow (i.e., 85.0% of rated) during full power operation, | * Extended Load Line Limit down to the minimum licensed core flow (i.e., 85.0% of rated) during full power operation, | ||
* Rated core flow is 67 .5 Mlb/hr, | * Rated core flow is 67 .5 Mlb/hr, | ||
* End-of-cycle coastdown to a minimum power level of 40% of rated power, | * End-of-cycle coastdown to a minimum power level of 40% of rated power, | ||
* Feed water temperature of no more than -I 0°F off nominal is licensed for this cycle. Further information on the cycle-specific analyses for Nine Mile Point Unit I Cycle 22 and the associated operating domains discussed above is available in Reference | * Feed water temperature of no more than -I 0°F off nominal is licensed for this cycle. Further information on the cycle-specific analyses for Nine Mile Point Unit I Cycle 22 and the associated operating domains discussed above is available in Reference | ||
: 2. Page 6 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 3.0 MAPLHGR Limits 3.1 Technical Specification 3.1.7.a, 3.1.7.e 3 .2 Description The MAPLHGR limits for each bundle type as a function of average planar exposure is given in Tables 3-1 through 3-9. For partial loop operation, a fuel-type-dependent multiplier is used, which is shown in Table 3-10. For operation with either four or three recirculation loops in service, multiply the most limiting values shown in Tables 3-1 through 3-3 by the GE 11 value in Table 3-10 and multiply the most limiting values shown in Tables 3-4 through 3-9 by the GNF2 value in Table 3-10. The power and flow dependent multipliers for MAPLHGR have been removed and replaced with LHGRF AC(P) and LHGRF AC(F); therefore, MAPF AC(P) and MAPF AC(F) are equal to 1.0 for all power and flow conditions (Reference 2). LHGRF AC(P) and LHGRF AC(F) are addressed in Section 5.0. Table 3-1 MAPLHGR Versus Average Planar Exposure-Bundle: | : 2. Page 6 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 3.0 MAPLHGR Limits 3.1 Technical Specification 3.1.7.a, 3.1.7.e 3 .2 Description The MAPLHGR limits for each bundle type as a function of average planar exposure is given in Tables 3-1 through 3-9. For partial loop operation, a fuel-type-dependent multiplier is used, which is shown in Table 3-10. For operation with either four or three recirculation loops in service, multiply the most limiting values shown in Tables 3-1 through 3-3 by the GE 11 value in Table 3-10 and multiply the most limiting values shown in Tables 3-4 through 3-9 by the GNF2 value in Table 3-10. The power and flow dependent multipliers for MAPLHGR have been removed and replaced with LHGRF AC(P) and LHGRF AC(F); therefore, MAPF AC(P) and MAPF AC(F) are equal to 1.0 for all power and flow conditions (Reference 2). LHGRF AC(P) and LHGRF AC(F) are addressed in Section 5.0. Table 3-1 MAPLHGR Versus Average Planar Exposure-Bundle: | ||
GE11-P9DUB376-12GZ-100T-145-T6-2586 (Reference | GE11-P9DUB376-12GZ-100T-145-T6-2586 (Reference | ||
: 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 9.63 0.20 9.63 1.00 9.60 5.00 9.40 10.00 9.37 15.00 9.24 20.00 8.76 25.00 8.34 35.00 8.10 45.00 8.03 55.00 8.02 65.00 6.18 1 These MAPLHGRs are not lattice dependent. | : 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 9.63 0.20 9.63 1.00 9.60 5.00 9.40 10.00 9.37 15.00 9.24 20.00 8.76 25.00 8.34 35.00 8.10 45.00 8.03 55.00 8.02 65.00 6.18 1 These MAPLHGRs are not lattice dependent. | ||
Page 7 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table3-2 MAPLHGR Versus Average Planar Exposure-Bundle: | Page 7 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table3-2 MAPLHGR Versus Average Planar Exposure-Bundle: | ||
GE11-P9DUB381-14GZ-100T-145-T6-2946 (Reference | GE11-P9DUB381-14GZ-100T-145-T6-2946 (Reference | ||
: 2) MAPLHGR Limit 1 Average Planar (kW/ft) Exposure (GWD/ST) Lattice Lattice Lattice Lattice Lattice Lattice 7433 7439 7440 7441 7442 7443 0.00 10.24 10.24 10.19 10.l9 10.19 10.19 0.20 10.24 10.24 10.19 10.19 10.19 10.19 1.00 10.20 10.20 10.19 10.19 10.19 10.19 5.00 9.91 9.91 9.85 9.85 9.85 9.85 10.00 9.42 9.42 9.34 . 9.34 9.34 9.34 15.00 9.22 9.22 9.19 9.19 9.19 9.19 20.00 9.18 9.18 9.19 9.19 9.19 9.19 25.00 8.64 8.64 8.63 8.63 8.63 8.63 35.00 8.08 8.08 8.08 8.08 8.08 8.08 45.00 8.02 8.02 7.99 7.99 7.99 7.99 55.00 8.00 8.00 7.99 7.99 7.99 7.99 65.00 7.97 7.97 7.96 7.96 7.96 7.96 Table3-3 MAPLHGR Versus Average Planar Exposure -Bundle: GEll-P9DUB380-13GZ-lOOT-145-T6-2948 (Reference | : 2) MAPLHGR Limit 1 Average Planar (kW/ft) Exposure (GWD/ST) Lattice Lattice Lattice Lattice Lattice Lattice 7433 7439 7440 7441 7442 7443 0.00 10.24 10.24 10.19 10.l9 10.19 10.19 0.20 10.24 10.24 10.19 10.19 10.19 10.19 1.00 10.20 10.20 10.19 10.19 10.19 10.19 5.00 9.91 9.91 9.85 9.85 9.85 9.85 10.00 9.42 9.42 9.34 . 9.34 9.34 9.34 15.00 9.22 9.22 9.19 9.19 9.19 9.19 20.00 9.18 9.18 9.19 9.19 9.19 9.19 25.00 8.64 8.64 8.63 8.63 8.63 8.63 35.00 8.08 8.08 8.08 8.08 8.08 8.08 45.00 8.02 8.02 7.99 7.99 7.99 7.99 55.00 8.00 8.00 7.99 7.99 7.99 7.99 65.00 7.97 7.97 7.96 7.96 7.96 7.96 Table3-3 MAPLHGR Versus Average Planar Exposure -Bundle: GEll-P9DUB380-13GZ-lOOT-145-T6-2948 (Reference | ||
: 2) MAPLHGR Limit1 Average Planar (kW/ft) Exposure (GWD/ST) Lattice Lattice Lattice Lattice Lattice Lattice 7433 7449 7450 7451 7447 7448 0.00 9.71 9.71 9.69 9.69 9.69 9.69 0.20 9.71 9.71 9.69 9.69 9.69 9.69 1.00 9.68 9.68 9.67 9.67 9.67 9.67 5.00 9.56 9.56 9.50 9.50 .9.50 9.50 10.00 9.38 9.38 9.32 9.32 9.32 9.32 15.00 9.23 9.23 9.24 9.24 9.24 9.24 20.00 9.28 9.28 9.31 9.31 9.31 9.31 25.00. 8.43 8.43 8.45 8.45 8.45 8.45 35.00 8.09 8.09 8.09 8.09 8.09 8.09 45.00 7.98 7.98 8.02 8.02 8.02 8.02 55.00 7.97 7.97 7.98 7.98 7.98 7.98 65.00 7.91 7.91 7.93 7.93 7.93 7.93 1 These MAPLHGRs are lattice dependent. | : 2) MAPLHGR Limit1 Average Planar (kW/ft) Exposure (GWD/ST) Lattice Lattice Lattice Lattice Lattice Lattice 7433 7449 7450 7451 7447 7448 0.00 9.71 9.71 9.69 9.69 9.69 9.69 0.20 9.71 9.71 9.69 9.69 9.69 9.69 1.00 9.68 9.68 9.67 9.67 9.67 9.67 5.00 9.56 9.56 9.50 9.50 .9.50 9.50 10.00 9.38 9.38 9.32 9.32 9.32 9.32 15.00 9.23 9.23 9.24 9.24 9.24 9.24 20.00 9.28 9.28 9.31 9.31 9.31 9.31 25.00. 8.43 8.43 8.45 8.45 8.45 8.45 35.00 8.09 8.09 8.09 8.09 8.09 8.09 45.00 7.98 7.98 8.02 8.02 8.02 8.02 55.00 7.97 7.97 7.98 7.98 7.98 7.98 65.00 7.91 7.91 7.93 7.93 7.93 7.93 1 These MAPLHGRs are lattice dependent. | ||
Page 8 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table 3-4 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-PlODG2B384-16GZ-100T2-145-T6-3351 (Reference | Page 8 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table 3-4 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-PlODG2B384-16GZ-100T2-145-T6-3351 (Reference | ||
: 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.91 0.20 7.91 1.00 7.88 5.00 7.81 .10.00 7.70 15.00 7.58 20.00 7.03 25.00 6.68 35.00 6.51 45.00 6.27 55.00 6.14 65.00 6.05 Table 3-5 MAPLHGR Versus Average Planar Exposure-Bundle: GNF2-PlODG2B386-13GZ-lOOT2-145-T6-3352 (Reference | : 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.91 0.20 7.91 1.00 7.88 5.00 7.81 .10.00 7.70 15.00 7.58 20.00 7.03 25.00 6.68 35.00 6.51 45.00 6.27 55.00 6.14 65.00 6.05 Table 3-5 MAPLHGR Versus Average Planar Exposure-Bundle: GNF2-PlODG2B386-13GZ-lOOT2-145-T6-3352 (Reference | ||
: 2) Average Planar Exposure MAPLHGR Limit1 (GWD/ST) (kW/ft) 0.00 7.81 0.20 7.81 1.00 7.92 5.00 7.83 10.00 7.71 15.00 7.73 20.00 7.09 25.00 6.68 35.00 6.52 45.00 6.26 55.00 6.15 65.00 6.05 1 These MAPLHGRs are not lattice dependent. | : 2) Average Planar Exposure MAPLHGR Limit1 (GWD/ST) (kW/ft) 0.00 7.81 0.20 7.81 1.00 7.92 5.00 7.83 10.00 7.71 15.00 7.73 20.00 7.09 25.00 6.68 35.00 6.52 45.00 6.26 55.00 6.15 65.00 6.05 1 These MAPLHGRs are not lattice dependent. | ||
Page 9 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table3-6 MAPLHGR Versus Average Planar Exposure-Bundle: GNF2-PlODG2B384-16GZ-100T2-145-T6-4133 (Reference | Page 9 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table3-6 MAPLHGR Versus Average Planar Exposure-Bundle: GNF2-PlODG2B384-16GZ-100T2-145-T6-4133 (Reference | ||
: 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.90 0.20 7.90 1.00 7.85 5.00 7.79 10.00 7.73 15.00 7.74 20.00 7.06 25.00 6.68 35.00 6.51 45.00 6.28 55.00 6.15 65.00 6.05 Table3-7 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-Pl ODG2B386-13GZ-1 OOT2-145-T6-4134 (Reference | : 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.90 0.20 7.90 1.00 7.85 5.00 7.79 10.00 7.73 15.00 7.74 20.00 7.06 25.00 6.68 35.00 6.51 45.00 6.28 55.00 6.15 65.00 6.05 Table3-7 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-Pl ODG2B386-13GZ-1 OOT2-145-T6-4134 (Reference | ||
: 2) Average Planar Exposure MAPLHGR Limit1 (GWD/ST) (kW/ft) 0.00 7.78 0.20 7.78 1.00 7.84 5.00 7.83 10.00 7.71 15.00 7.73 20.00 7.09 25.00 6.67 35.00 6.52 45.00 6.26 55.00 6.15 65.00 6.05 1 These MAPLHGRs are not lattice dependent. | : 2) Average Planar Exposure MAPLHGR Limit1 (GWD/ST) (kW/ft) 0.00 7.78 0.20 7.78 1.00 7.84 5.00 7.83 10.00 7.71 15.00 7.73 20.00 7.09 25.00 6.67 35.00 6.52 45.00 6.26 55.00 6.15 65.00 6.05 1 These MAPLHGRs are not lattice dependent. | ||
Page 10 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. *1 Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table3-8 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-Pl ODG2B371-l 6GZ-1 OOT2-145-T6-4312 (Reference | Page 10 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. *1 Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table3-8 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-Pl ODG2B371-l 6GZ-1 OOT2-145-T6-4312 (Reference | ||
: 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.96 0.20 7.96 1.00 7.96 5.00 7.88 10.00 7.76 15.00 7.63 20.00 7.16 25.00 6.68 35.00 6.50 45.00 6.29 55.00 6.18 65.00 6.09 Table 3-9 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-P10DG2B375-ll G5.0-100T2-145-T6-4313 (Reference | : 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.96 0.20 7.96 1.00 7.96 5.00 7.88 10.00 7.76 15.00 7.63 20.00 7.16 25.00 6.68 35.00 6.50 45.00 6.29 55.00 6.18 65.00 6.09 Table 3-9 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-P10DG2B375-ll G5.0-100T2-145-T6-4313 (Reference | ||
: 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.90 0.20 7.90 1.00 7.91 5.00 7.85 10.00 7.76 15.00 7.65 20.00 7.25 25.00 6.69 35.00 6.45 45.00 6.28 55.00 6.17 65.00 6.08 Table3-10 MAPLHGR Multiplier for Four and Three Recirculation Loop Operation (Reference | : 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.90 0.20 7.90 1.00 7.91 5.00 7.85 10.00 7.76 15.00 7.65 20.00 7.25 25.00 6.69 35.00 6.45 45.00 6.28 55.00 6.17 65.00 6.08 Table3-10 MAPLHGR Multiplier for Four and Three Recirculation Loop Operation (Reference | ||
: 2) Fuel Type Four and Three Loop Operation Multiplier2 GEll 0.98 GNF2 0.99 1 These MAPLHGRs are not lattice dependent. | : 2) Fuel Type Four and Three Loop Operation Multiplier2 GEll 0.98 GNF2 0.99 1 These MAPLHGRs are not lattice dependent. | ||
2 The 4-loop MAPLHGR multiplier is applicable up to 100% of rated power and 100% ofrated core flow if the Out-of-Service (OOS) loop is isolated or un-isolated from the reactor. The 3-loop MAPLHGR Multiplier is applicable to 90% rated power and 75% rated core flow regardless of whether the OOS recirculation loops are isolated or un-isolated. | 2 The 4-loop MAPLHGR multiplier is applicable up to 100% of rated power and 100% ofrated core flow if the Out-of-Service (OOS) loop is isolated or un-isolated from the reactor. The 3-loop MAPLHGR Multiplier is applicable to 90% rated power and 75% rated core flow regardless of whether the OOS recirculation loops are isolated or un-isolated. | ||
Line 70: | Line 70: | ||
Table 4-1 and 4-2 limits are bounding for both GEl 1 and GNF2 fuel types. The power dependent MCPR limits are presented in Table 4-3 and are valid for both GEl 1 and GNF2 fuel types (Reference 2). When core thermal power is greater than or equal to 45% of rated, the applicable Kp multiplier from Table 4-3 is applied to the applicable rated condition OLMCPR value in Table 4-1 or adjusted OLMCPR value determined by using Table 4-2. Below 45% rated thermal power, the MCPR(P) limits in Table 4-3 are applied directly. | Table 4-1 and 4-2 limits are bounding for both GEl 1 and GNF2 fuel types. The power dependent MCPR limits are presented in Table 4-3 and are valid for both GEl 1 and GNF2 fuel types (Reference 2). When core thermal power is greater than or equal to 45% of rated, the applicable Kp multiplier from Table 4-3 is applied to the applicable rated condition OLMCPR value in Table 4-1 or adjusted OLMCPR value determined by using Table 4-2. Below 45% rated thermal power, the MCPR(P) limits in Table 4-3 are applied directly. | ||
The appropriate MCPR(P) or Kp value may be determined by linear interpolation. | The appropriate MCPR(P) or Kp value may be determined by linear interpolation. | ||
The flow adjusted OLMCPR is determined by multiplying the applicable rated condition OLM CPR provided by either Table 4-1 or 4-2 by the applicable Kf multiplier given in Table 4-4. The Kf multipliers are valid for both GEl 1 and GNF2 fuel types and are documented in Reference | The flow adjusted OLMCPR is determined by multiplying the applicable rated condition OLM CPR provided by either Table 4-1 or 4-2 by the applicable Kf multiplier given in Table 4-4. The Kf multipliers are valid for both GEl 1 and GNF2 fuel types and are documented in Reference | ||
: 2. The appropriate Kfvalue may be determined by linear interpolation. | : 2. The appropriate Kfvalue may be determined by linear interpolation. | ||
Table 4-1 Operating Limit Minimum Critical Power Ratio (OLMCPR) (All Fuel Types, Four/Five Recirculation Loop Operation) (Reference | Table 4-1 Operating Limit Minimum Critical Power Ratio (OLMCPR) (All Fuel Types, Four/Five Recirculation Loop Operation) (Reference | ||
: 2) Feedwater Pump SCRAM Time Cycle Exposure Combination 1 Option 2 <EOR-3609 MWd/ST MWd/ST FWP Combination 1 B 1.47 1.54 A 1.57 1.64 FWP Combination 2 B 1.52 1.59 A 1.62 1.69 1 0LMCPR values are independent of pressure regulator in-service or out-of service conditions. | : 2) Feedwater Pump SCRAM Time Cycle Exposure Combination 1 Option 2 <EOR-3609 MWd/ST MWd/ST FWP Combination 1 B 1.47 1.54 A 1.57 1.64 FWP Combination 2 B 1.52 1.59 A 1.62 1.69 1 0LMCPR values are independent of pressure regulator in-service or out-of service conditions. | ||
2 For tau ('r) = 0, use SCRAM Time Option B limits. For ('r) = 1, use SCRAM Time Option A limits. When tau does not equal 0 or 1, use linear interpolation. | 2 For tau ('r) = 0, use SCRAM Time Option B limits. For ('r) = 1, use SCRAM Time Option A limits. When tau does not equal 0 or 1, use linear interpolation. | ||
Tau is defined as: T = ('tave -TB) I (TA -<B) where TA= 0.868 seconds, control rod average scram insertion time limit to notch 39 TB= 0.612 + 1.6s * [ N11 r.r=1 N;1 112 | Tau is defined as: T = ('tave -TB) I (TA -<B) where TA= 0.868 seconds, control rod average scram insertion time limit to notch 39 TB= 0.612 + 1.6s * [ N11 r.r=1 N;1 112 | ||
* 0.016 Tave= r.r=1 N;r; I r.r=1 N; . where n =number of surveillance tests performed in cycle; N; = number of active control rods measured in the ;*h surveillance test; T; = average scram time to notch 39 of all rods measures in the ;'h surveillance test; and N 1 =total number of active rods measured. | * 0.016 Tave= r.r=1 N;r; I r.r=1 N; . where n =number of surveillance tests performed in cycle; N; = number of active control rods measured in the ;*h surveillance test; T; = average scram time to notch 39 of all rods measures in the ;'h surveillance test; and N 1 =total number of active rods measured. | ||
Page 12 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 EOOS Table4-2 MCPR Adder for Three Recirculation Loop Operation (All Fuel Types) (Reference | Page 12 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 EOOS Table4-2 MCPR Adder for Three Recirculation Loop Operation (All Fuel Types) (Reference | ||
: 2) Three Recirculation Loop Operation 0.03 Adder 1 Table 4-3 Power Dependent MCPR Limits and Multipliers MCPR(P) and Kp (All Fuel Types) (Reference | : 2) Three Recirculation Loop Operation 0.03 Adder 1 Table 4-3 Power Dependent MCPR Limits and Multipliers MCPR(P) and Kp (All Fuel Types) (Reference | ||
: 2) Core Core Thermal Power (% of Rated) Flow 0 25 <45 65 85 >85 100 Combination | : 2) Core Core Thermal Power (% of Rated) Flow 0 25 <45 65 85 >85 100 Combination | ||
(%of Operating Limit MCPR, Operating Limit MCPR Multiplier, Kp rated) FWP ::::; 60 Combination 1 > 60 FWP ::::; 60 Combination 2 >60 PROOS 2 ::::; 60 > 60 MCPR(P1 3.28 3.28 2.36 1.349 1.216 3.40 3.40 2.86 3.28 3.28 2.36 1.349 1.216 3.40 3.40 2.86 3.28 3.28 2.36 1.553 1.336 3.40 3.40 2.86 Table 4-4 Operating Limit MCPR Multiplier, Kf (All Fuel Types) (Reference | (%of Operating Limit MCPR, Operating Limit MCPR Multiplier, Kp rated) FWP ::::; 60 Combination 1 > 60 FWP ::::; 60 Combination 2 >60 PROOS 2 ::::; 60 > 60 MCPR(P1 3.28 3.28 2.36 1.349 1.216 3.40 3.40 2.86 3.28 3.28 2.36 1.349 1.216 3.40 3.40 2.86 3.28 3.28 2.36 1.553 1.336 3.40 3.40 2.86 Table 4-4 Operating Limit MCPR Multiplier, Kf (All Fuel Types) (Reference | ||
: 2) Flow MCPR (%rated) Multiplier, Kr' 0.0 1.500 45.0 1.500 >45.0 1.132 75.0 1.000 100.0 1.000 1.133 1.133 1.000 1.133 1.133 1.000 1.198 1.133 1.000 1 Increase the values in Table 4-1 and the MCPR(P) values in Table 4-3 by 0.03 in the event of Three Recirculation Loop Operation. | : 2) Flow MCPR (%rated) Multiplier, Kr' 0.0 1.500 45.0 1.500 >45.0 1.132 75.0 1.000 100.0 1.000 1.133 1.133 1.000 1.133 1.133 1.000 1.198 1.133 1.000 1 Increase the values in Table 4-1 and the MCPR(P) values in Table 4-3 by 0.03 in the event of Three Recirculation Loop Operation. | ||
2 Limits apply to PROOS coincident with FWP Combination 1 or 2. 3 Values are applicable up to a Maximum Runout Flow of 102.5% of rated. Values apply to operation in either FWP Combination 1 or 2 with or without Pressure Regulator in-service. | 2 Limits apply to PROOS coincident with FWP Combination 1 or 2. 3 Values are applicable up to a Maximum Runout Flow of 102.5% of rated. Values apply to operation in either FWP Combination 1 or 2 with or without Pressure Regulator in-service. | ||
Page 13 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine_ Mile Point 1 Cycle 22 5.0 LHGR Limits 5 .1 Technical Specification 3.1.7.b 5.2 Description The Linear Heat Generation Rate (LHGR) for all fuel bundles shall not exceed either 11.0 kW/ft 1 or the LHGR limits presented in Tables 5-1 and 5-2. Linear interpolation should be used for points not listed in Appendix A or Appendix B of Reference | Page 13 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine_ Mile Point 1 Cycle 22 5.0 LHGR Limits 5 .1 Technical Specification 3.1.7.b 5.2 Description The Linear Heat Generation Rate (LHGR) for all fuel bundles shall not exceed either 11.0 kW/ft 1 or the LHGR limits presented in Tables 5-1 and 5-2. Linear interpolation should be used for points not listed in Appendix A or Appendix B of Reference | ||
: 4. Power adjusted LHGR limits are required for operation with PROOS at greater than or equal to 45% RTP. Below 45% RTP, no additional limits are required. | : 4. Power adjusted LHGR limits are required for operation with PROOS at greater than or equal to 45% RTP. Below 45% RTP, no additional limits are required. | ||
These power dependent LHGR multipliers (LHGRFAC(P)) | These power dependent LHGR multipliers (LHGRFAC(P)) | ||
Line 89: | Line 89: | ||
The appropriate LHGRFAC(P) values may be determined by linear interpolation. | The appropriate LHGRFAC(P) values may be determined by linear interpolation. | ||
Flow dependent LHGR multipliers (LHGRFAC(F)) | Flow dependent LHGR multipliers (LHGRFAC(F)) | ||
are not required (Reference 2). Table 5-1 Linear Heat Generation Rate Limits -U0 2 Rods (References 3 and 4) Fuel Type LHGR GEll See Appendix A GNF2 1 See Appendix B of Reference 4 Table 5-2 Linear Heat Generation Rate Limits -Gadolinia Rods (References 3 and 4) Fuel Type LHGR GEll See Appendix A GNF2 1 See Appendix B of Reference 4 1 GNF2 LHGR limit has been set down to a maximum value of 11 kW/ft to address Emergency Procedure Guidelines (EPG) requirements (Reference 6). Page 14 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point I , Rev. I I Core Operating Limits Report for Nine Mile Point J Cycle 22 Table 5-3 Power Dependent LHGR Multiplier LHGRFAC(P) for PROOS (All Fuel Types) (Reference | are not required (Reference 2). Table 5-1 Linear Heat Generation Rate Limits -U0 2 Rods (References 3 and 4) Fuel Type LHGR GEll See Appendix A GNF2 1 See Appendix B of Reference 4 Table 5-2 Linear Heat Generation Rate Limits -Gadolinia Rods (References 3 and 4) Fuel Type LHGR GEll See Appendix A GNF2 1 See Appendix B of Reference 4 1 GNF2 LHGR limit has been set down to a maximum value of 11 kW/ft to address Emergency Procedure Guidelines (EPG) requirements (Reference 6). Page 14 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point I , Rev. I I Core Operating Limits Report for Nine Mile Point J Cycle 22 Table 5-3 Power Dependent LHGR Multiplier LHGRFAC(P) for PROOS (All Fuel Types) (Reference | ||
: 2) Scram Time Option Core Thermal Power (% of rated) 0 <45 2:45 65 85 Option A (i.e. -r > 0) 1.000 1.000 0.518 0.518 0.636 Option B 1.000 1.000 0.737 0.867 0.987 6.0 Limiting Power/Flow Line 6.1 Technical Specification 3.1.7.d , 3.1.7.e 6.2 Description 100 1.000 1.000 The Nine Mile Point Unit 1 power/flow relationship is shown in the figure below. 120 100 ,-.., "O .... "" ci:: 80 .... 0 = '-' ... 60 0 c.. "" E ... .c 40 E-... 0 u 20 0 0 Figure 6-1 Limiting Power/Flow Line (References 5, 7, and 8) 85.0 -V'"" Power= 0.55* w + 53 20 40 60 80 Core Flow (% of Rated) Page 15 of35 I 00.0) ( 00.0 , I 00.0) 100 120 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 7.0 Modes of Operation | : 2) Scram Time Option Core Thermal Power (% of rated) 0 <45 2:45 65 85 Option A (i.e. -r > 0) 1.000 1.000 0.518 0.518 0.636 Option B 1.000 1.000 0.737 0.867 0.987 6.0 Limiting Power/Flow Line 6.1 Technical Specification 3.1.7.d , 3.1.7.e 6.2 Description 100 1.000 1.000 The Nine Mile Point Unit 1 power/flow relationship is shown in the figure below. 120 100 ,-.., "O .... "" ci:: 80 .... 0 = '-' ... 60 0 c.. "" E ... .c 40 E-... 0 u 20 0 0 Figure 6-1 Limiting Power/Flow Line (References 5, 7, and 8) 85.0 -V'"" Power= 0.55* w + 53 20 40 60 80 Core Flow (% of Rated) Page 15 of35 I 00.0) ( 00.0 , I 00.0) 100 120 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 7.0 Modes of Operation | ||
Line 96: | Line 96: | ||
The allowable modes of operation are found in Table 7-1. Operation with PROOS is supported in all modes of operation, provided the restrictions identified in the applicable station procedures are met. All EOOS options allow for three recirculation loop operation. | The allowable modes of operation are found in Table 7-1. Operation with PROOS is supported in all modes of operation, provided the restrictions identified in the applicable station procedures are met. All EOOS options allow for three recirculation loop operation. | ||
Operation up to 67.5 Mlb/hr *core flow is licensed for this cycle (Reference 2). Each mode supports operation with up to 10°F reduction in feedwater temperature and each mode may be coincident with coastdown operation. | Operation up to 67.5 Mlb/hr *core flow is licensed for this cycle (Reference 2). Each mode supports operation with up to 10°F reduction in feedwater temperature and each mode may be coincident with coastdown operation. | ||
The minimum coastdown power level is 40% per GEST AR II (Methodology Document 1 ). Options Table 7-1 Modes of Operation (Reference | The minimum coastdown power level is 40% per GEST AR II (Methodology Document 1 ). Options Table 7-1 Modes of Operation (Reference | ||
: 2) Four/Five-loop Operation, FWP Combination 1, Option A or B Four/Five-loop Operation, FWP Combination 2, Option A or B PROOS, Four/Five-loop Operation, FWP Combination 1 or 2, Option A or B Three-loop Operation, FWP Combination 1, Option A or B Three-loop Operation, FWP Combination 2, Option A or B PROOS, Three-loop Operation, FWP Combination 1 or 2, Option A orB Allowed Operatin!! | : 2) Four/Five-loop Operation, FWP Combination 1, Option A or B Four/Five-loop Operation, FWP Combination 2, Option A or B PROOS, Four/Five-loop Operation, FWP Combination 1 or 2, Option A or B Three-loop Operation, FWP Combination 1, Option A or B Three-loop Operation, FWP Combination 2, Option A or B PROOS, Three-loop Operation, FWP Combination 1 or 2, Option A orB Allowed Operatin!! | ||
Re2ion Yes Yes Yes Yes 1 Yes 1 Yes 1 1 In 3-loop operation, power is limited to 90% ofrated power/75% | Re2ion Yes Yes Yes Yes 1 Yes 1 Yes 1 1 In 3-loop operation, power is limited to 90% ofrated power/75% | ||
of rated core flow regardless of whether the OOS recirculation loops are isolated or un-isolated as described in Section 3 (Reference 2). Page 16 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 8.0 Methodology The analytical methods used to determine the core operating limits shall be those previously reviewed and approved by the NRC, specifically those described in the following document: | of rated core flow regardless of whether the OOS recirculation loops are isolated or un-isolated as described in Section 3 (Reference 2). Page 16 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 8.0 Methodology The analytical methods used to determine the core operating limits shall be those previously reviewed and approved by the NRC, specifically those described in the following document: | ||
: 1. "General Electric Standard Application for Reactor Fuel," NEDE-24011-P-A-20, December 2013 and U.S. Supplement NEDE-24011-P-A-20-US, December 2013. 9.0 References | : 1. "General Electric Standard Application for Reactor Fuel," NEDE-24011-P-A-20, December 2013 and U.S. Supplement NEDE-24011-P-A-20-US, December 2013. 9.0 References | ||
: 1. "Nine Mile Point Nuclear Station, Unit 1 Renewed Facility Operating License", Docket No. 50-220, License No. DPR-63, Appendix A-Radiological Technical Specifications. | : 1. "Nine Mile Point Nuclear Station, Unit 1 Renewed Facility Operating License", Docket No. 50-220, License No. DPR-63, Appendix A-Radiological Technical Specifications. | ||
: 2. "Supplemental Reload Licensing Report for Nine Mile Point 1 Reload 23 Cycle 22", Global Nuclear Fuel Document No. 002N2884-SRLR, Revision 2, January 2016. 3. "Fuel Bundle Information Report for Nine Mile Point I Reload 23 Cycle 22", Global Nuclear Fuel Document No. 002N2885-FBIR, Revision 0, November 2014. 4. "GNF2 Advantage Generic Compliance with NEDE-24011-P-A (GESTAR II)," Global Nuclear Fuel Document No. NEDC-33270P, Revision 5, May 2013. 5. "Limiting Relationship Between Core Power and Core Flow Rate (TAC 63532)," NRC Letter, Nine Mile Point 1 Technical Specification Amendment 92 to Facility Operating License No. DPR-63, March 24, 1987. 6. "Nine Mile Point Nuclear Station Unit I GNF2 ECCS-LOCA Evaluation," GE Hitachi Nuclear Energy Document No. 0000-0098-3457-R2/000NI 093-RO, January 2014. 7. "General Electric Boiling Water Reactor Extended Load Line Limit Analysis for Nine Mile Point 1 Cycle 9," General Electric Document No. NEDC-31126, February 1986. 8. "Nine Mile Point I Cycle 24 Limiting Load Line Analysis," Global Nuclear Fuel Letter, Document No. 002N5662-RO, March 18, 2015. Page 17 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Appendix A Page 18 of35}} | : 2. "Supplemental Reload Licensing Report for Nine Mile Point 1 Reload 23 Cycle 22", Global Nuclear Fuel Document No. 002N2884-SRLR, Revision 2, January 2016. 3. "Fuel Bundle Information Report for Nine Mile Point I Reload 23 Cycle 22", Global Nuclear Fuel Document No. 002N2885-FBIR, Revision 0, November 2014. 4. "GNF2 Advantage Generic Compliance with NEDE-24011-P-A (GESTAR II)," Global Nuclear Fuel Document No. NEDC-33270P, Revision 5, May 2013. 5. "Limiting Relationship Between Core Power and Core Flow Rate (TAC 63532)," NRC Letter, Nine Mile Point 1 Technical Specification Amendment 92 to Facility Operating License No. DPR-63, March 24, 1987. 6. "Nine Mile Point Nuclear Station Unit I GNF2 ECCS-LOCA Evaluation," GE Hitachi Nuclear Energy Document No. 0000-0098-3457-R2/000NI 093-RO, January 2014. 7. "General Electric Boiling Water Reactor Extended Load Line Limit Analysis for Nine Mile Point 1 Cycle 9," General Electric Document No. NEDC-31126, February 1986. 8. "Nine Mile Point I Cycle 24 Limiting Load Line Analysis," Global Nuclear Fuel Letter, Document No. 002N5662-RO, March 18, 2015. Page 17 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Appendix A Page 18 of35}} |
Revision as of 01:55, 27 April 2019
ML16257A454 | |
Person / Time | |
---|---|
Site: | Nine Mile Point ![]() |
Issue date: | 09/09/2016 |
From: | Moore D M Exelon Generation Co |
To: | Document Control Desk, Office of Nuclear Reactor Regulation |
References | |
NMP1L 3104 | |
Download: ML16257A454 (21) | |
Text
I.
7' Exelon Generation NMP1L 3104 September 9, 2016 U.S. Nuclear Regulatory Commission Attn: Document Control Desk Washington, DC 20555-001
Subject:
Nine Mile Point Nuclear Station, Unit 1 Renewed Facility Operating License No. DPR-63 NRC Docket No. 50-220 Core Operating Limits Report Technical Specification
6.6.5 Enclosed
is a copy of the Core Operating Limits Report, Cycle 22, Revision 1 for Nine Mile Point Unit 1 (NMP1 ). This report is being submitted pursuant to NMP1 Technical Specification 6.6.5.d. The COLR is being revised to allow four loop operation at rated power with one loop isolated.
Should you have any questions regarding the information in this submittal, please contact me at (315) 349-5219.
Sincerely, Dennis M. Moore Regulatory Assurance Manager, Nine Mile Point Nuclear Station Exelon Generation Company, LLC DMM/RSP
Enclosure:
Core Operating Limits Report for Nine Mile Point Unit 1 Cycle 22 Revision 1 cc: NRC Regional Administrator, Region I NRC Project Manager NRC Senior Resident Inspector Enclosure Core OperatingUmits Report For Nine Mile Point Unit 1 Cycle 22 Revision 1 Enclosure Core Operating Limits Report For Nine Mile Point Unit 1 Cycle 22 Revision 1 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point l, Rev. I I Core Operating Limits Report for Nine Mile Point I Cycle 22 CORE OPERATING LIMITS REPORT Prepared By: FOR NINE MILE POINT NUCLEAR STATION UNIT1RELOAD23CYCLE22 M Kosciuk T. Stathes Date:
Reviewed By: A,,;......, Date: ?/tS//, I Reviewed By: Reviewed By: Approved By: Station Qualified Review By: B. Miller Independent Reviewer J. Darweesh Reactor Engineering Reviewer Page 1 of JS Date: {). / /
/! b bate: 02/15/2016 Date: 2/15 / 2016
,_ Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table of Contents Page 1.0 Tenns and Definitions 5 2.0 General lnfonnation 6 3.0 MAPLHGR Limits 7 4.0 MCPRLimits 12 5.0 LHGRLimits 14 6.0 Limiting Power I Flow Line 15 7.0 Modes of Operation 16 8.0 Methodology 17 9.0 References 17 Appendix A 18 Page 2 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Revision Rev. Number -1 Rev. Number -0 Record of COLR Nine Mile Point 1 Cycle 22 Revisions Description Revise Reference 2 and Reference 6 and revise footnotes for Table 3-10 and Table 7-1. The COLR Nine Mile Point 1, Rev. 0 FCMS version has an illegible Appendix A (Figures B-1 thru B-9) (see IR 2626201 ). Appendix A has been verified to be legible in Revision 1. New Issuance for Cycle 22 Page3 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 List of Tables Page Table 3-1 MAPLHGR Versus Average Planar Exposure -Bundle: GE11-P9DUB376-12GZ-100T-145-T6-2586 7 Table 3-2 MAPLHGR Versus Average Planar Exposure-Bundle: GE11-P9DUB381-14GZ-100T-145-T6-2946 8 Table 3-3 MAPLHGR Versus Average Planar Exposure -Bundle: GE11-P9DUB380-13GZ-100T-145-T6-2948 8 Table 3-4 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-P 1ODG2B384-16GZ-1OOT2-145-T6-33 51 9 Table 3-5 MAPLHGR Versus Average Planar Exposure-Bundle: GNF2-PlODG2B386-13GZ-lOOT2-145-T6-3352 9 Table 3-6 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-PlODG2B384-16GZ-lOOT2-145-T6-4133 10 Table 3-7 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-Pl ODG2B3 86-13GZ-1 OOT2-145-T6-4134 10 Table 3-8 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-P10DG2B371-16GZ-100T2-145-T6-4312 11 Table 3-9 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-PlODG2B375-11G5.0-lOOT2-145-T6-4313 11 Table 3-10 MAPLHGR Multiplier for Four and Three Recirculation Loop Operation 11 Table 4-1 Operating Limit Minimum Critical Power Ratio (OLMCPR) 12 Table 4-2 MCPR Adder for Three Recirculation Loop Operation 13 I-Table4-3 Power Dependent MCPR Limits and Multipliers MCPR(P) and Kp 13 Table 4-4 Operating Limit MCPR Multiplier, Kf 13 Table 5-1 Linear Heat Generation Rate Limits -00 2 Rods 14 Table 5-2 Linear Heat Generation Rate Limits -Gadolinia Rods 14 Table 5-3 Power Dependent LHGR Multiplier LHGRF AC(P) for PROOS 15 Table 7-1 Modes of Operation 16 List of Figures Figure 6-1 Limiting Power/Flow Line 15 Page 4 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 1.0 Terms and Definitions ARTS APRM, Rod Block, and Technical Specification Improvement Program ELLLA Extended Load Line Limit Analysis EOOS Equipment Out of Service EOR End of Rated. The cycle exposure at which reactor power is equal to rated thermal power with recirculation system flow equal to 100%, all control rods fully withdrawn, all feedwater heating in service and equilibrium Xenon. FWP Combination 1 Feedwater Pump Combination 1 as defined in Nl-OP-16, i.e. Turbine Driven Feedwater Pump (TDFWP) in service AND one Motor Driven Feedwater Pump (MDFWP) in service (bounds TDFWP in service OR one MDFWP in service OR two MDFWPs in service).
FWP Combination 2 Feedwater Pump Combination 2 as defined in Nl-OP-16, i.e. TDFWP in service AND two MDFWPs in service. Kp Off-rated power dependent OLMCPR multiplier Kf Off-rated flow dependent OLMCPR multiplier LHGR Linear Heat Generation Rate LHGRF AC(F) Off-rated LHGR flow dependent thermal limit multipliers LHGRF AC(P) Off-rated LHGR power dependent thermal limit multipliers MAPF AC(F) Off-rated flow dependent MAPLHGR multiplier MAPF AC(P) Off-rated power dependent MAPLHGR multiplier MAPLHGR Maximum Average Planar Linear Heat Generation Rate MCPR Minimum Critical Power Ratio MCPR(F) Off-rated flow dependent OLMCPR MCPR(P) Off-rated power dependent OLMCPR OLMCPR Operating Limit Minimum Critical Power Ratio OOS Out of Service PROOS Pressure Regulator Out of Service Page 5 of35
,, Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 2.0 General Information This report provides the following cycle-specific parameter limits for Nine Mile Point Nuclear Station Unit 1 Cycle 22:
- Maximum Average Planar Linear Heat Generation Rate (MAPLHGR)
- Operating Limit Minimum Critical Power Ratio (OLMCPR)
- Three recirculation loop operation MCPR adjustment
- MAPLHGR four and three recirculation loop operation multipliers
- Linear Heat Generation Rate (LHGR)
- Limiting Power I Flow Line This report is prepared in accordance with Technical Specification 6.6.5 of Reference
- 1. Power and flow dependent limits are listed for various power and flow levels. Linear interpolation is to be used to find intermediate values. Nine Mile Point Unit I is a non-ARTs plant that utilizes ELLLA operating domain. The data presented in this report is valid for all licensed operating domains on the operating map, including:
- Extended Load Line Limit down to the minimum licensed core flow (i.e., 85.0% of rated) during full power operation,
- Rated core flow is 67 .5 Mlb/hr,
- End-of-cycle coastdown to a minimum power level of 40% of rated power,
- Feed water temperature of no more than -I 0°F off nominal is licensed for this cycle. Further information on the cycle-specific analyses for Nine Mile Point Unit I Cycle 22 and the associated operating domains discussed above is available in Reference
- 2. Page 6 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 3.0 MAPLHGR Limits 3.1 Technical Specification 3.1.7.a, 3.1.7.e 3 .2 Description The MAPLHGR limits for each bundle type as a function of average planar exposure is given in Tables 3-1 through 3-9. For partial loop operation, a fuel-type-dependent multiplier is used, which is shown in Table 3-10. For operation with either four or three recirculation loops in service, multiply the most limiting values shown in Tables 3-1 through 3-3 by the GE 11 value in Table 3-10 and multiply the most limiting values shown in Tables 3-4 through 3-9 by the GNF2 value in Table 3-10. The power and flow dependent multipliers for MAPLHGR have been removed and replaced with LHGRF AC(P) and LHGRF AC(F); therefore, MAPF AC(P) and MAPF AC(F) are equal to 1.0 for all power and flow conditions (Reference 2). LHGRF AC(P) and LHGRF AC(F) are addressed in Section 5.0. Table 3-1 MAPLHGR Versus Average Planar Exposure-Bundle:
GE11-P9DUB376-12GZ-100T-145-T6-2586 (Reference
- 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 9.63 0.20 9.63 1.00 9.60 5.00 9.40 10.00 9.37 15.00 9.24 20.00 8.76 25.00 8.34 35.00 8.10 45.00 8.03 55.00 8.02 65.00 6.18 1 These MAPLHGRs are not lattice dependent.
Page 7 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table3-2 MAPLHGR Versus Average Planar Exposure-Bundle:
GE11-P9DUB381-14GZ-100T-145-T6-2946 (Reference
- 2) MAPLHGR Limit 1 Average Planar (kW/ft) Exposure (GWD/ST) Lattice Lattice Lattice Lattice Lattice Lattice 7433 7439 7440 7441 7442 7443 0.00 10.24 10.24 10.19 10.l9 10.19 10.19 0.20 10.24 10.24 10.19 10.19 10.19 10.19 1.00 10.20 10.20 10.19 10.19 10.19 10.19 5.00 9.91 9.91 9.85 9.85 9.85 9.85 10.00 9.42 9.42 9.34 . 9.34 9.34 9.34 15.00 9.22 9.22 9.19 9.19 9.19 9.19 20.00 9.18 9.18 9.19 9.19 9.19 9.19 25.00 8.64 8.64 8.63 8.63 8.63 8.63 35.00 8.08 8.08 8.08 8.08 8.08 8.08 45.00 8.02 8.02 7.99 7.99 7.99 7.99 55.00 8.00 8.00 7.99 7.99 7.99 7.99 65.00 7.97 7.97 7.96 7.96 7.96 7.96 Table3-3 MAPLHGR Versus Average Planar Exposure -Bundle: GEll-P9DUB380-13GZ-lOOT-145-T6-2948 (Reference
- 2) MAPLHGR Limit1 Average Planar (kW/ft) Exposure (GWD/ST) Lattice Lattice Lattice Lattice Lattice Lattice 7433 7449 7450 7451 7447 7448 0.00 9.71 9.71 9.69 9.69 9.69 9.69 0.20 9.71 9.71 9.69 9.69 9.69 9.69 1.00 9.68 9.68 9.67 9.67 9.67 9.67 5.00 9.56 9.56 9.50 9.50 .9.50 9.50 10.00 9.38 9.38 9.32 9.32 9.32 9.32 15.00 9.23 9.23 9.24 9.24 9.24 9.24 20.00 9.28 9.28 9.31 9.31 9.31 9.31 25.00. 8.43 8.43 8.45 8.45 8.45 8.45 35.00 8.09 8.09 8.09 8.09 8.09 8.09 45.00 7.98 7.98 8.02 8.02 8.02 8.02 55.00 7.97 7.97 7.98 7.98 7.98 7.98 65.00 7.91 7.91 7.93 7.93 7.93 7.93 1 These MAPLHGRs are lattice dependent.
Page 8 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table 3-4 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-PlODG2B384-16GZ-100T2-145-T6-3351 (Reference
- 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.91 0.20 7.91 1.00 7.88 5.00 7.81 .10.00 7.70 15.00 7.58 20.00 7.03 25.00 6.68 35.00 6.51 45.00 6.27 55.00 6.14 65.00 6.05 Table 3-5 MAPLHGR Versus Average Planar Exposure-Bundle: GNF2-PlODG2B386-13GZ-lOOT2-145-T6-3352 (Reference
- 2) Average Planar Exposure MAPLHGR Limit1 (GWD/ST) (kW/ft) 0.00 7.81 0.20 7.81 1.00 7.92 5.00 7.83 10.00 7.71 15.00 7.73 20.00 7.09 25.00 6.68 35.00 6.52 45.00 6.26 55.00 6.15 65.00 6.05 1 These MAPLHGRs are not lattice dependent.
Page 9 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table3-6 MAPLHGR Versus Average Planar Exposure-Bundle: GNF2-PlODG2B384-16GZ-100T2-145-T6-4133 (Reference
- 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.90 0.20 7.90 1.00 7.85 5.00 7.79 10.00 7.73 15.00 7.74 20.00 7.06 25.00 6.68 35.00 6.51 45.00 6.28 55.00 6.15 65.00 6.05 Table3-7 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-Pl ODG2B386-13GZ-1 OOT2-145-T6-4134 (Reference
- 2) Average Planar Exposure MAPLHGR Limit1 (GWD/ST) (kW/ft) 0.00 7.78 0.20 7.78 1.00 7.84 5.00 7.83 10.00 7.71 15.00 7.73 20.00 7.09 25.00 6.67 35.00 6.52 45.00 6.26 55.00 6.15 65.00 6.05 1 These MAPLHGRs are not lattice dependent.
Page 10 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. *1 Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Table3-8 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-Pl ODG2B371-l 6GZ-1 OOT2-145-T6-4312 (Reference
- 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.96 0.20 7.96 1.00 7.96 5.00 7.88 10.00 7.76 15.00 7.63 20.00 7.16 25.00 6.68 35.00 6.50 45.00 6.29 55.00 6.18 65.00 6.09 Table 3-9 MAPLHGR Versus Average Planar Exposure -Bundle: GNF2-P10DG2B375-ll G5.0-100T2-145-T6-4313 (Reference
- 2) Average Planar Exposure MAPLHGR Limit 1 (GWD/ST) (kW/ft) 0.00 7.90 0.20 7.90 1.00 7.91 5.00 7.85 10.00 7.76 15.00 7.65 20.00 7.25 25.00 6.69 35.00 6.45 45.00 6.28 55.00 6.17 65.00 6.08 Table3-10 MAPLHGR Multiplier for Four and Three Recirculation Loop Operation (Reference
- 2) Fuel Type Four and Three Loop Operation Multiplier2 GEll 0.98 GNF2 0.99 1 These MAPLHGRs are not lattice dependent.
2 The 4-loop MAPLHGR multiplier is applicable up to 100% of rated power and 100% ofrated core flow if the Out-of-Service (OOS) loop is isolated or un-isolated from the reactor. The 3-loop MAPLHGR Multiplier is applicable to 90% rated power and 75% rated core flow regardless of whether the OOS recirculation loops are isolated or un-isolated.
Page 11 of35
'I Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 4.0 MCPR Limits 4.1 Technical Specification 3.1.7.c, 3.1.7.e 4.2 Description The OLMCPR is determined for a given power and flow condition by evaluating the power dependent MCPR and the flow dependent MCPR and selecting the greater of the two. Tables 4-1 and 4-2 are derived from Reference 2 and are valid for all Cycle 22 operating domains. Nine Mile Point Unit 1 Cycle 22 has a mid-cycle MCPR breakpoint, as defined in Table 4-1. An adder, presented in Table 4-2, is required to be applied to all limits in Table 4-1 and MCPR(P) in Table 4-3 in the event of three recirculation loop operation.
Table 4-1 and 4-2 limits are bounding for both GEl 1 and GNF2 fuel types. The power dependent MCPR limits are presented in Table 4-3 and are valid for both GEl 1 and GNF2 fuel types (Reference 2). When core thermal power is greater than or equal to 45% of rated, the applicable Kp multiplier from Table 4-3 is applied to the applicable rated condition OLMCPR value in Table 4-1 or adjusted OLMCPR value determined by using Table 4-2. Below 45% rated thermal power, the MCPR(P) limits in Table 4-3 are applied directly.
The appropriate MCPR(P) or Kp value may be determined by linear interpolation.
The flow adjusted OLMCPR is determined by multiplying the applicable rated condition OLM CPR provided by either Table 4-1 or 4-2 by the applicable Kf multiplier given in Table 4-4. The Kf multipliers are valid for both GEl 1 and GNF2 fuel types and are documented in Reference
- 2. The appropriate Kfvalue may be determined by linear interpolation.
Table 4-1 Operating Limit Minimum Critical Power Ratio (OLMCPR) (All Fuel Types, Four/Five Recirculation Loop Operation) (Reference
- 2) Feedwater Pump SCRAM Time Cycle Exposure Combination 1 Option 2 <EOR-3609 MWd/ST MWd/ST FWP Combination 1 B 1.47 1.54 A 1.57 1.64 FWP Combination 2 B 1.52 1.59 A 1.62 1.69 1 0LMCPR values are independent of pressure regulator in-service or out-of service conditions.
2 For tau ('r) = 0, use SCRAM Time Option B limits. For ('r) = 1, use SCRAM Time Option A limits. When tau does not equal 0 or 1, use linear interpolation.
Tau is defined as: T = ('tave -TB) I (TA -<B) where TA= 0.868 seconds, control rod average scram insertion time limit to notch 39 TB= 0.612 + 1.6s * [ N11 r.r=1 N;1 112
- 0.016 Tave= r.r=1 N;r; I r.r=1 N; . where n =number of surveillance tests performed in cycle; N; = number of active control rods measured in the ;*h surveillance test; T; = average scram time to notch 39 of all rods measures in the ;'h surveillance test; and N 1 =total number of active rods measured.
Page 12 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 EOOS Table4-2 MCPR Adder for Three Recirculation Loop Operation (All Fuel Types) (Reference
- 2) Three Recirculation Loop Operation 0.03 Adder 1 Table 4-3 Power Dependent MCPR Limits and Multipliers MCPR(P) and Kp (All Fuel Types) (Reference
- 2) Core Core Thermal Power (% of Rated) Flow 0 25 <45 65 85 >85 100 Combination
(%of Operating Limit MCPR, Operating Limit MCPR Multiplier, Kp rated) FWP ::::; 60 Combination 1 > 60 FWP ::::; 60 Combination 2 >60 PROOS 2 ::::; 60 > 60 MCPR(P1 3.28 3.28 2.36 1.349 1.216 3.40 3.40 2.86 3.28 3.28 2.36 1.349 1.216 3.40 3.40 2.86 3.28 3.28 2.36 1.553 1.336 3.40 3.40 2.86 Table 4-4 Operating Limit MCPR Multiplier, Kf (All Fuel Types) (Reference
- 2) Flow MCPR (%rated) Multiplier, Kr' 0.0 1.500 45.0 1.500 >45.0 1.132 75.0 1.000 100.0 1.000 1.133 1.133 1.000 1.133 1.133 1.000 1.198 1.133 1.000 1 Increase the values in Table 4-1 and the MCPR(P) values in Table 4-3 by 0.03 in the event of Three Recirculation Loop Operation.
2 Limits apply to PROOS coincident with FWP Combination 1 or 2. 3 Values are applicable up to a Maximum Runout Flow of 102.5% of rated. Values apply to operation in either FWP Combination 1 or 2 with or without Pressure Regulator in-service.
Page 13 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine_ Mile Point 1 Cycle 22 5.0 LHGR Limits 5 .1 Technical Specification 3.1.7.b 5.2 Description The Linear Heat Generation Rate (LHGR) for all fuel bundles shall not exceed either 11.0 kW/ft 1 or the LHGR limits presented in Tables 5-1 and 5-2. Linear interpolation should be used for points not listed in Appendix A or Appendix B of Reference
- 4. Power adjusted LHGR limits are required for operation with PROOS at greater than or equal to 45% RTP. Below 45% RTP, no additional limits are required.
These power dependent LHGR multipliers (LHGRFAC(P))
are provided in Table 5-3 for Option Band Option A scram times and are applicable to both GEl 1 and GNF2 fuel types (Reference 2). The power adjusted LHGR is determined by multiplying the applicable Appendix A LHGR limit by the LHGR multiplier, LHGRF AC(P). The LHGRF AC(P) curves are independent of recirculation loop operability.
The appropriate LHGRFAC(P) values may be determined by linear interpolation.
Flow dependent LHGR multipliers (LHGRFAC(F))
are not required (Reference 2). Table 5-1 Linear Heat Generation Rate Limits -U0 2 Rods (References 3 and 4) Fuel Type LHGR GEll See Appendix A GNF2 1 See Appendix B of Reference 4 Table 5-2 Linear Heat Generation Rate Limits -Gadolinia Rods (References 3 and 4) Fuel Type LHGR GEll See Appendix A GNF2 1 See Appendix B of Reference 4 1 GNF2 LHGR limit has been set down to a maximum value of 11 kW/ft to address Emergency Procedure Guidelines (EPG) requirements (Reference 6). Page 14 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point I , Rev. I I Core Operating Limits Report for Nine Mile Point J Cycle 22 Table 5-3 Power Dependent LHGR Multiplier LHGRFAC(P) for PROOS (All Fuel Types) (Reference
- 2) Scram Time Option Core Thermal Power (% of rated) 0 <45 2:45 65 85 Option A (i.e. -r > 0) 1.000 1.000 0.518 0.518 0.636 Option B 1.000 1.000 0.737 0.867 0.987 6.0 Limiting Power/Flow Line 6.1 Technical Specification 3.1.7.d , 3.1.7.e 6.2 Description 100 1.000 1.000 The Nine Mile Point Unit 1 power/flow relationship is shown in the figure below. 120 100 ,-.., "O .... "" ci:: 80 .... 0 = '-' ... 60 0 c.. "" E ... .c 40 E-... 0 u 20 0 0 Figure 6-1 Limiting Power/Flow Line (References 5, 7, and 8) 85.0 -V'"" Power= 0.55* w + 53 20 40 60 80 Core Flow (% of Rated) Page 15 of35 I 00.0) ( 00.0 , I 00.0) 100 120 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 7.0 Modes of Operation
7.1 Description
The allowable modes of operation are found in Table 7-1. Operation with PROOS is supported in all modes of operation, provided the restrictions identified in the applicable station procedures are met. All EOOS options allow for three recirculation loop operation.
Operation up to 67.5 Mlb/hr *core flow is licensed for this cycle (Reference 2). Each mode supports operation with up to 10°F reduction in feedwater temperature and each mode may be coincident with coastdown operation.
The minimum coastdown power level is 40% per GEST AR II (Methodology Document 1 ). Options Table 7-1 Modes of Operation (Reference
- 2) Four/Five-loop Operation, FWP Combination 1, Option A or B Four/Five-loop Operation, FWP Combination 2, Option A or B PROOS, Four/Five-loop Operation, FWP Combination 1 or 2, Option A or B Three-loop Operation, FWP Combination 1, Option A or B Three-loop Operation, FWP Combination 2, Option A or B PROOS, Three-loop Operation, FWP Combination 1 or 2, Option A orB Allowed Operatin!!
Re2ion Yes Yes Yes Yes 1 Yes 1 Yes 1 1 In 3-loop operation, power is limited to 90% ofrated power/75%
of rated core flow regardless of whether the OOS recirculation loops are isolated or un-isolated as described in Section 3 (Reference 2). Page 16 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 8.0 Methodology The analytical methods used to determine the core operating limits shall be those previously reviewed and approved by the NRC, specifically those described in the following document:
- 1. "General Electric Standard Application for Reactor Fuel," NEDE-24011-P-A-20, December 2013 and U.S. Supplement NEDE-24011-P-A-20-US, December 2013. 9.0 References
- 1. "Nine Mile Point Nuclear Station, Unit 1 Renewed Facility Operating License", Docket No. 50-220, License No. DPR-63, Appendix A-Radiological Technical Specifications.
- 2. "Supplemental Reload Licensing Report for Nine Mile Point 1 Reload 23 Cycle 22", Global Nuclear Fuel Document No. 002N2884-SRLR, Revision 2, January 2016. 3. "Fuel Bundle Information Report for Nine Mile Point I Reload 23 Cycle 22", Global Nuclear Fuel Document No. 002N2885-FBIR, Revision 0, November 2014. 4. "GNF2 Advantage Generic Compliance with NEDE-24011-P-A (GESTAR II)," Global Nuclear Fuel Document No. NEDC-33270P, Revision 5, May 2013. 5. "Limiting Relationship Between Core Power and Core Flow Rate (TAC 63532)," NRC Letter, Nine Mile Point 1 Technical Specification Amendment 92 to Facility Operating License No. DPR-63, March 24, 1987. 6. "Nine Mile Point Nuclear Station Unit I GNF2 ECCS-LOCA Evaluation," GE Hitachi Nuclear Energy Document No. 0000-0098-3457-R2/000NI 093-RO, January 2014. 7. "General Electric Boiling Water Reactor Extended Load Line Limit Analysis for Nine Mile Point 1 Cycle 9," General Electric Document No. NEDC-31126, February 1986. 8. "Nine Mile Point I Cycle 24 Limiting Load Line Analysis," Global Nuclear Fuel Letter, Document No. 002N5662-RO, March 18, 2015. Page 17 of35 Exelon Nuclear -Nuclear Fuels Doc ID: COLR Nine Mile Point 1, Rev. 1 I Core Operating Limits Report for Nine Mile Point 1 Cycle 22 Appendix A Page 18 of35