ML18026A539: Difference between revisions
StriderTol (talk | contribs) (Created page by program invented by StriderTol) |
StriderTol (talk | contribs) (Created page by program invented by StriderTol) |
||
(2 intermediate revisions by the same user not shown) | |||
Line 3: | Line 3: | ||
| issue date = 06/24/1996 | | issue date = 06/24/1996 | ||
| title = Provides Response to Violations Noted in Insp Repts 50-387/96-04 & 50-388/96-04.Corrective Actions:All Doors to Decontamination Bldg on Refueling Floor Immediately Posted on 960201 | | title = Provides Response to Violations Noted in Insp Repts 50-387/96-04 & 50-388/96-04.Corrective Actions:All Doors to Decontamination Bldg on Refueling Floor Immediately Posted on 960201 | ||
| author name = | | author name = Byram R | ||
| author affiliation = PENNSYLVANIA POWER & LIGHT CO. | | author affiliation = PENNSYLVANIA POWER & LIGHT CO. | ||
| addressee name = | | addressee name = | ||
Line 14: | Line 14: | ||
| page count = 8 | | page count = 8 | ||
}} | }} | ||
=Text= | =Text= | ||
{{#Wiki_filter:Pennsylvania | {{#Wiki_filter:Pennsylvania Power 8 Light Gompany Two North Ninth Street ~ Allentown, PA 18101-1179 ~ 610/774-5151 Robert G. Byram Senior Vice Preslderr r-iVuclear 610/774-7502 Fax: 610i774-5019 Jl.iw 24 1996 U. S. Nuclear Regulatory Commission Attn: Document Control Desk Mail Stop P 1-137 Washington, D. C. 20555 SUSQUEHANNA STEAM ELECTRIC STATION REPLY TO A NOTICE OF VIOLATION (50-387/96-04-02; 50-388/96-04-02 AND 50-387/96-04-03; 50-388/96-04-03) Docket Nos. 50-387 and 50-388 This letter provides Pennsylvania Power and Light Company's response to the Notice of Violation (50-387/96-04-02; 50-388/96-04-02 and 50-387/96-04-03; 50-388/96-04-03) contained in NRC Integrated Inspection Report 50-387/96-04 and 50-388/96-04 dated May 23, 1996. | ||
Power 8 Light Gompany Two North Ninth Street~Allentown, PA 18101-1179 | I The notice required submittal of a written reply within thirty (30) day of the date of the letter. | ||
~610/774-5151 | We trust that the Commjssion will find the attached response acceptable. | ||
Robert G.Byram Senior Vice Preslderr r-iVuclear | Ifyou have any additional questions, please contact Mr. R. D. Kichline at (610) 774-7705. | ||
610/774-7502 | Very truly yours, Attac nt copy: NRC Region I Ms. M. Banerjee NRC Sr. Resident Inspector Mr. C. Poslusny, Jr. NRC Sr. Project Manager | ||
Fax: 610i774-5019 | |||
Jl.iw 24 1996 U.S.Nuclear Regulatory | ATTACHMENTTO PLA-4473 Page 1 of 6 (387/96-04-02; 3SS/96-04-02) | ||
Commission | Pursuant to 10CFR20.1003, a high radiation area is an area, accessible to individuals, in which radiation levels could result in excess of 0.100 rem in 1 hour at 30 centimeters from the radiation source or from any surface that the radiation penetrates. | ||
Attn: Document Control Desk Mail Stop P 1-137 Washington, D.C.20555 SUSQUEHANNA | Contrary to the above, on January 4; 1996, through February 1, 1996, a high radiation area in the decontamination building on the refueling floor (818 ft. elevation), with dose rates up to 0.800 rem in 1 hour at 30 centimeters from the radiation source (a vacuum), was not conspicuously posted as a high radiation area. | ||
STEAM ELECTRIC STATION REPLY TO A NOTICE OF VIOLATION (50-387/96-04-02; | RLQHHLSc: | ||
50-388/96-04-02 | pe ~ | ||
AND 50-387/96-04-03; | On January 4, 1996, a radiation source (under-water vacuum housing) was placed in the decontamination building on the refueling floor (818 ft. elevation). The dose of the vacuum housing warranted that the decontamination building be posted as a high radiation area. This posting was performed on February 1, 1996. The causes for the failure to post the decontamination building between January 4, 1996, and February 1, 1996, are: | ||
50-388/96-04-03) | ~ On January 4, 1996 only one door of the decontamination building was posted indicating that the building was a high radiation area. The need to post the | ||
Docket Nos.50-387 and 50-388 This letter provides Pennsylvania | ~ | ||
Power and Light Company's response to the Notice of Violation (50-387/96-04-02; | remaining doors went undetected because of a lack of clear procedural and work practice guidance which resulted in human error. As a result no survey of the decontamination building was completed after the vacuum housing was placed in it, and the need to post all doors went uncorrected until February 1, 1996, when the vacuum housing was identified as a high radiation source. | ||
50-388/96-04-02 | ~ Surveys that were conducted subsequent to placing the vacuum housing in the decontamination building also failed to identify the posting deficiencies. The initial survey performed on January 4, 1996, was incomplete. Another survey of the building was conducted on January 8, 1996, but was only performed at one corner of the building and did not identify any unusual radiation conditions. | ||
and 50-387/96-04-03; | Subsequently, a survey conducted on January 15, 1996, did identify slightly elevated dose rates at one location-outside the building. However, the slightly elevated dose rates were considered insignificant because the health physics technician performing the survey did not recognize that the elevated dose rates were from a high radiation source, i.e., the vacuum housing. | ||
50-388/96-04-03) | |||
contained in NRC Integrated | ATTACHMENTTO PLA-4473 Page 2 of 6 W | ||
Inspection | 'll doors to the decontamination building on the refueling floor were immediately posted on February, 1, 1996, following identification that the vacuum housing was a high radiation source. Subsequently, a new rope barricade was erected to prevent access to the decontamination building. Therefore compliance with high radiation area posting requirements was achieved. | ||
Report 50-387/96-04 | : b. Although functionally adequate, numerous procedures have been revised to clarify station survey, posting, and work practices when working with radioactive equipment. These procedural revisions will strengthen the station's radiation controls program. | ||
and 50-388/96-04 | C. The health physics technician involved in this event was counseled 'as to the necessity to complete survey and posting requirements pursuant to station procedures. | ||
dated May 23, 1996.I The notice required submittal of a written reply within thirty (30)day of the date of the letter.We trust that the Commjssion | : d. Health Physics training was conducted which will enhance a "questioning attitude" regarding radiological changes noted during routine surveys. The purpose of this training was to sensitize the health physics technicians on the need to follow-up and perform additional investigative surveys when elevated radiation levels are measured. | ||
will find the attached response acceptable. | : e. Locking devices were placed on the decontamination building doors so that in the future this facility can be locked when radiation levels require locked radiation controls. | ||
A "radiological safety note" was distributed to station personnel reiterating the necessity of controlling radiological postings. | |||
questions, please contact Mr.R.D.Kichline at (610)774-7705.Very truly yours, Attac nt copy: NRC Region I Ms.M.Banerjee NRC Sr.Resident Inspector Mr.C.Poslusny, Jr.NRC Sr.Project Manager | Appropriate radiological controls work programs, and work priorities and communication enhancements associated with outage management activities have been developed. These programs will increase the sensitivity of station personnel to station radiological control concerns, thereby reducing the occurrence events. | ||
of'imilar | |||
: h. Areas of the plant which were not already under locked high radiation controls were surveyed and upgraded as necessary to ensure the station was in compliance with NRC posting and barricade requirements. | |||
3SS/96-04-02) | |||
Pursuant to 10CFR20.1003, a high radiation area is an area, accessible | ATTACHMENTTO PLA-4473 Page3 of6 An independent walk-down, by first line supervisors, of high radiation posting changes is now required. This corrective action, which is in response to a subsequent posting event, adds assurances that the 10CFR20 and plant Technical Specification posting and barricading requirements are'being promptly and correctly implemented. | ||
to individuals, in which radiation levels could result in excess of 0.100 rem in 1 hour at 30 centimeters | W'P&L management immediately commissioned an intensive investigation to establish the cause and recommend corrective actions in response to this event. The resultant corrective actions taken to address this event were expeditiously dispositioned. PP&L, therefore, considers the corrective actions identified above to satisfactorily address this violation. | ||
from the radiation source or from any surface that the radiation penetrates. | Based on the action taken in 2.a above, PP&L is in full compliance. | ||
Contrary to the above, on January 4;1996, through February 1, 1996, a high radiation area in the decontamination | |||
building on the refueling floor (818 ft.elevation), with dose rates up to 0.800 rem in 1 hour at 30 centimeters | ATTACHMENTTO PLA-4473 page4of6 | ||
from the radiation source (a vacuum), was not conspicuously | ' g jgQ~~ (387/96-04-03; 388/96-04-03) | ||
posted as a high radiation area.RLQHHLSc: pe~On January 4, 1996, a radiation source (under-water | Pursuant to 10CFR20.1003, survey means an evaluation of the radiological conditions and potential hazards incident to the production, use, transfer, release, disposal, or presence of radioactive material or other sources of radiation. | ||
vacuum housing)was placed in the decontamination | Contrary to the above, as of April 4, 1996, the licensee did not make surveys to assure compliance with 10CFR20.2001(a), which describes authorized meaits of disposing of licensed material. Specifically, on September 21, 1995, (Note: The tanker was released offsite on September 14, 1995, as stated in Inspection Report 50-387/96-04 and 50-388/96-04) the licensee did not perform a survey before disposing of sludge in a tanker truck as normal, non-radioactive waste. On prior occasions, the tanker truck contained radioactive water above the lower limits of detection for effluent releases. 4 RcBQ~H1K On February 29, 1996, PP&L was notified, by an organization in Montreal, Quebec Canada, that a tanker truck previously used by PP&L (PP&L identification ¹255-216) had a radioactive materials label affixed to the tanker. Prior to releasing the tanker offsite, the tanker (which had previously contained slightly contaminated water) was surveyed using existing procedures, and determined to be acceptable for offsite release. | ||
building on the refueling floor (818 ft.elevation). | Prior to transport to Montreal, Quebec the tanker was thoroughly cleaned at a truck washing facility in Pennsylvania. | ||
The dose of the vacuum housing warranted that the decontamination | To determine ifthe tanker may have been contaminated or ifother potentially radioactive material may have been in the tanker following release from the site, a tanker (PP&L identification ¹255-212) that had been used in a similar manner, was surveyed. The survey identified a small amount of slightly radioactive sludge in the bottom of the tanker. Dose calculations performed on this sludge concluded that any dose received would have been a small fraction of applicable dose limits for a member of the public and, based on transportation regulations, the sludge found would have been classified as an "exempt quantity." Because of the process used by PP&L to determine ifradioactivity was associated with the tanker, the tanker may have contained similar or slightly lower amounts of slightly radioactive sludge. Therefore, it was concluded that an inadequate survey had been performed on tanker ¹255-216. | ||
building be posted as a high radiation area.This posting was performed on February 1, 1996.The causes for the failure to post the decontamination | ~ The reason for the inadequate survey performed on the subject tanker, prior to its release offsite on September 14, 1995, was that: | ||
building between January 4, 1996, and February 1, 1996, are:~On January 4, 1996 only one door of the decontamination | |||
building was posted indicating | ATTACHMENTTO PLA-4473 Page 5 of 6 | ||
that the building was a high radiation area.The need to post the~remaining doors went undetected | ~ No procedural guidance existed that specifically looked for or removed unnecessary labeling prior to release from the radiologically controlled area (RCA) or the site. | ||
because of a lack of clear procedural | ~ The procedure used to survey for contamination (HP-TP-602) was less than adequate in that it did not specifically require an internal survey of the tanker. | ||
and work practice guidance which resulted in human error.As a result no survey of the decontamination | ~ No overall procedure existed to control the process for use, surveying, sampling, or release of the tanker by the several affected functional organizations within PPAL. | ||
building was completed after the vacuum housing was placed in it, and the need to post all doors went uncorrected | Although each functional organization has procedures to address their specific activity, the lack of a comprehensive governing procedure contributed to a lack of training related to aspects of releasing of material offsite, weak programmatic control of tankers for release from the RCA and site, less than adequate contamination control of empty containers, and less than adequate work plans for completely emptying the tanker. | ||
until February 1, 1996, when the vacuum housing was identified | : a. The remaining tankers at Susquehanna that are utilized for similar purposes have been relocated within the protected area, and have been physically secured. This will ensure positive control of these tankers prior to release offsite. | ||
as a high radiation source.~Surveys that were conducted subsequent | : b. Nuclear Department procedures (NDAP-00-0627 and HP-TP-0602) have been revised to require that the internal surfaces of tankers be surveyed prior to exiting the site.. | ||
to placing the vacuum housing in the decontamination | C. Nuclear Department Administrative Procedure (NDAP-00-0627) has been revised to incorporate steps that remove unnecessary labels on tankers prior to release offsite. Incorporation of a specific procedural step to remove labels in this NDAP, which applies across functional organizations, provides assurances that only required labeling willbe attached to tankers exiting the site. | ||
building also failed to identify the posting deficiencies. | The truck wash facility was surveyed. No nuclides attributable to nuclear power | ||
The initial survey performed on January 4, 1996, was incomplete. | . plant operation were identified. | ||
Another survey of the building was conducted on January 8, 1996, but was only performed at one corner of the building and did not identify any unusual radiation conditions. | The internal structure of several tankers has been inspected to determine if there are any physical obstructions that will prevent the complete draining of material from the tanker. This inspection concluded. that there are no major structural internals that should prevent the complete draining of a tanker. At least two designs have been identified; however, they present no significant impediments to emptying the tankers. | ||
Subsequently, a survey conducted on January 15, 1996, did identify slightly elevated dose rates at one location-outside | |||
the building.However, the slightly elevated dose rates were considered | ATTACHMENTTO PLA-4473 Page6of6 PP&L correspondence was sent to the organization in Montreal, Quebec, who received the tanker, stating that there was not a radiological hazard associated with the tanker, and that the label could be removed. | ||
insignificant | W W'1 Surveys of the remaining tankers that were utilized for similar purposes will be performed to assure that they are not radioactively contaminated nor contain . | ||
because the health physics technician | radioactive sludge above station release limits. These surveys are scheduled to be completed by July 31, 1996. | ||
performing | : b. Inspections of the remaining tankers that, were utilized for similar purposes will be conducted to assure that inappropriate labels have been removed. These inspections are scheduled to be completed by July 31, 1996. | ||
the survey did not recognize that the elevated dose rates were from a high radiation source, i.e., the vacuum housing. | C. Requirements associated with tanker activities within the protected area will be enhanced to assure that adequate controls exist for the use, surveying, sampling, labeling, etc. of tankers. These requirements are scheduled to be developed and implemented by July 31, 1996. | ||
The overall program for controlling and coordinating the process for removing material from the RCA and site will be evaluated. This evaluation is scheduled to be completed by July 31, 1996. | |||
Training will be provided, to applicable functional organizations, that addresses the release of materials from the RCA that may be slightly radioactive. This training will contain elements associated with appropriate. lower limits of detection (LLD's), plate out mechanisms and the diferent requirements for release of materials from the RCA and offsite. Initial training for key functional organizations is scheduled to be completed by September 30, 1996. | |||
Based on 2.a and 2.b above, PP&L is in full compliance.}} | |||
building on the refueling floor were immediately | |||
posted on February, 1, 1996, following identification | |||
that the vacuum housing was a high radiation source.Subsequently, a new rope barricade was erected to prevent access to the decontamination | |||
building.Therefore compliance | |||
with high radiation area posting requirements | |||
was achieved.b.Although functionally | |||
adequate, numerous procedures | |||
have been revised to clarify station survey, posting, and work practices when working with radioactive | |||
equipment. | |||
These procedural | |||
revisions will strengthen | |||
the station's radiation controls program.C.The health physics technician | |||
involved in this event was counseled'as to the necessity to complete survey and posting requirements | |||
pursuant to station procedures. | |||
d.Health Physics training was conducted which will enhance a"questioning | |||
attitude" regarding radiological | |||
changes noted during routine surveys.The purpose of this training was to sensitize the health physics technicians | |||
on the need to follow-up and perform additional | |||
investigative | |||
surveys when elevated radiation levels are measured.e.Locking devices were placed on the decontamination | |||
building doors so that in the future this facility can be locked when radiation levels require locked radiation controls.A"radiological | |||
safety note" was distributed | |||
to station personnel reiterating | |||
the necessity of controlling | |||
radiological | |||
postings.Appropriate | |||
radiological | |||
controls work programs, and work priorities | |||
and communication | |||
enhancements | |||
associated | |||
with outage management | |||
activities | |||
have been developed. | |||
These programs will increase the sensitivity | |||
of station personnel to station radiological | |||
control concerns, thereby reducing the occurrence | |||
of'imilar | |||
with NRC posting and barricade requirements. | |||
walk-down, by first line supervisors, of high radiation posting changes is now required.This corrective | |||
action, which is in response to a subsequent | |||
posting event, adds assurances | |||
that the 10CFR20 and plant Technical Specification | |||
posting and barricading | |||
requirements | |||
are'being promptly and correctly implemented. | |||
W'P&L management | |||
immediately | |||
commissioned | |||
an intensive investigation | |||
to establish the cause and recommend corrective | |||
actions in response to this event.The resultant corrective | |||
actions taken to address this event were expeditiously | |||
dispositioned. | |||
PP&L, therefore, considers the corrective | |||
actions identified | |||
above to satisfactorily | |||
address this violation. | |||
Based on the action taken in 2.a above, PP&L is in full compliance. | |||
388/96-04-03) | |||
Pursuant to 10CFR20.1003, survey means an evaluation | |||
of the radiological | |||
conditions | |||
and potential hazards incident to the production, use, transfer, release, disposal, or presence of radioactive | |||
material or other sources of radiation. | |||
Contrary to the above, as of April 4, 1996, the licensee did not make surveys to assure compliance | |||
with 10CFR20.2001(a), which describes authorized | |||
meaits of disposing of licensed material.Specifically, on September 21, 1995, (Note: The tanker was released offsite on September 14, 1995, as stated in Inspection | |||
Report 50-387/96-04 | |||
and 50-388/96-04) | |||
the licensee did not perform a survey before disposing of sludge in a tanker truck as normal, non-radioactive | |||
waste.On prior occasions, the tanker truck contained radioactive | |||
water above the lower limits of detection for effluent releases.4 RcBQ~H1K On February 29, 1996, PP&L was notified, by an organization | |||
in Montreal, Quebec Canada, that a tanker truck previously | |||
used by PP&L (PP&L identification | |||
¹255-216)had a radioactive | |||
materials label affixed to the tanker.Prior to releasing the tanker offsite, the tanker (which had previously | |||
contained slightly contaminated | |||
water)was surveyed using existing procedures, and determined | |||
to be acceptable | |||
for offsite release.Prior to transport to Montreal, Quebec the tanker was thoroughly | |||
cleaned at a truck washing facility in Pennsylvania. | |||
To determine | |||
or | |||
radioactive | |||
material may have been in the tanker following release from the site, a tanker (PP&L identification | |||
¹255-212)that had been used in a similar manner, was surveyed.The survey identified | |||
a small amount of slightly radioactive | |||
sludge in the bottom of the tanker.Dose calculations | |||
performed on this sludge concluded that any dose received would have been a small fraction of applicable | |||
dose limits for a member of the public and, based on transportation | |||
regulations, the sludge found would have been classified | |||
as an"exempt quantity." Because of the process used by PP&L to determine | |||
was associated | |||
with the tanker, the tanker may have contained similar or slightly lower amounts of slightly radioactive | |||
sludge.Therefore, it was concluded that an inadequate | |||
survey had been performed on tanker¹255-216.~The reason for the inadequate | |||
survey performed on the subject tanker, prior to its release offsite on September 14, 1995, was that: | |||
guidance existed that specifically | |||
looked for or removed unnecessary | |||
labeling prior to release from the radiologically | |||
controlled | |||
area (RCA)or the site.~The procedure used to survey for contamination (HP-TP-602) | |||
was less than adequate in that it did not specifically | |||
require an internal survey of the tanker.~No overall procedure existed to control the process for use, surveying, sampling, or release of the tanker by the several affected functional | |||
organizations | |||
within PPAL.Although each functional | |||
organization | |||
has procedures | |||
to address their specific activity, the lack of a comprehensive | |||
governing procedure contributed | |||
to a lack of training related to aspects of releasing of material offsite, weak programmatic | |||
control of tankers for release from the RCA and site, less than adequate contamination | |||
control of empty containers, and less than adequate work plans for completely | |||
emptying the tanker.a.The remaining tankers at Susquehanna | |||
that are utilized for similar purposes have been relocated within the protected area, and have been physically | |||
secured.This will ensure positive control of these tankers prior to release offsite.b.Nuclear Department | |||
procedures (NDAP-00-0627 | |||
and HP-TP-0602) | |||
have been revised to require that the internal surfaces of tankers be surveyed prior to exiting the site..C.Nuclear Department | |||
Administrative | |||
Procedure (NDAP-00-0627) | |||
has been revised to incorporate | |||
steps that remove unnecessary | |||
labels on tankers prior to release offsite.Incorporation | |||
of a specific procedural | |||
step to remove labels in this NDAP, which applies across functional | |||
organizations, provides assurances | |||
that only required labeling | |||
to nuclear power.plant operation were identified. | |||
The internal structure of several tankers has been inspected to determine if there are any physical obstructions | |||
that will prevent the complete draining of material from the tanker.This inspection | |||
concluded. | |||
that there are no major structural | |||
internals that should prevent the complete draining of a tanker.At least two designs have been identified; | |||
however, they present no significant | |||
impediments | |||
to emptying the tankers. | |||
was sent to the organization | |||
in Montreal, Quebec, who received the tanker, stating that there was not a radiological | |||
hazard associated | |||
with the tanker, and that the label could be removed.W W'1 Surveys of the remaining tankers that were utilized for similar purposes will be performed to assure that they are not radioactively | |||
contaminated | |||
nor contain.radioactive | |||
sludge above station release limits.These surveys are scheduled to be completed by July 31, 1996.b.Inspections | |||
of the remaining tankers that, were utilized for similar purposes will be conducted to assure that inappropriate | |||
labels have been removed.These inspections | |||
are scheduled to be completed by July 31, 1996.C.Requirements | |||
associated | |||
with tanker activities | |||
within the protected area will be enhanced to assure that adequate controls exist for the use, surveying, sampling, labeling, etc.of tankers.These requirements | |||
are scheduled to be developed and implemented | |||
by July 31, 1996.The overall program for controlling | |||
and coordinating | |||
the process for removing material from the RCA and site will be evaluated. | |||
This evaluation | |||
is scheduled to be completed by July 31, 1996.Training will be provided, to applicable | |||
functional | |||
organizations, that addresses the release of materials from the RCA that may be slightly radioactive. | |||
This training will contain elements associated | |||
with appropriate. | |||
lower limits of detection (LLD's), plate out mechanisms | |||
and the diferent requirements | |||
for release of materials from the RCA and offsite.Initial training for key functional | |||
organizations | |||
is scheduled to be completed by September 30, 1996.Based on 2.a and 2.b above, PP&L is in full compliance. | |||
}} |
Latest revision as of 02:06, 22 October 2019
ML18026A539 | |
Person / Time | |
---|---|
Site: | Susquehanna ![]() |
Issue date: | 06/24/1996 |
From: | Byram R PENNSYLVANIA POWER & LIGHT CO. |
To: | NRC OFFICE OF INFORMATION RESOURCES MANAGEMENT (IRM) |
References | |
PLA-4473, NUDOCS 9606280252 | |
Download: ML18026A539 (8) | |
Text
Pennsylvania Power 8 Light Gompany Two North Ninth Street ~ Allentown, PA 18101-1179 ~ 610/774-5151 Robert G. Byram Senior Vice Preslderr r-iVuclear 610/774-7502 Fax: 610i774-5019 Jl.iw 24 1996 U. S. Nuclear Regulatory Commission Attn: Document Control Desk Mail Stop P 1-137 Washington, D. C. 20555 SUSQUEHANNA STEAM ELECTRIC STATION REPLY TO A NOTICE OF VIOLATION (50-387/96-04-02; 50-388/96-04-02 AND 50-387/96-04-03; 50-388/96-04-03) Docket Nos. 50-387 and 50-388 This letter provides Pennsylvania Power and Light Company's response to the Notice of Violation (50-387/96-04-02; 50-388/96-04-02 and 50-387/96-04-03; 50-388/96-04-03) contained in NRC Integrated Inspection Report 50-387/96-04 and 50-388/96-04 dated May 23, 1996.
I The notice required submittal of a written reply within thirty (30) day of the date of the letter.
We trust that the Commjssion will find the attached response acceptable.
Ifyou have any additional questions, please contact Mr. R. D. Kichline at (610) 774-7705.
Very truly yours, Attac nt copy: NRC Region I Ms. M. Banerjee NRC Sr. Resident Inspector Mr. C. Poslusny, Jr. NRC Sr. Project Manager
ATTACHMENTTO PLA-4473 Page 1 of 6 (387/96-04-02; 3SS/96-04-02)
Pursuant to 10CFR20.1003, a high radiation area is an area, accessible to individuals, in which radiation levels could result in excess of 0.100 rem in 1 hour1.157407e-5 days <br />2.777778e-4 hours <br />1.653439e-6 weeks <br />3.805e-7 months <br /> at 30 centimeters from the radiation source or from any surface that the radiation penetrates.
Contrary to the above, on January 4; 1996, through February 1, 1996, a high radiation area in the decontamination building on the refueling floor (818 ft. elevation), with dose rates up to 0.800 rem in 1 hour1.157407e-5 days <br />2.777778e-4 hours <br />1.653439e-6 weeks <br />3.805e-7 months <br /> at 30 centimeters from the radiation source (a vacuum), was not conspicuously posted as a high radiation area.
RLQHHLSc:
pe ~
On January 4, 1996, a radiation source (under-water vacuum housing) was placed in the decontamination building on the refueling floor (818 ft. elevation). The dose of the vacuum housing warranted that the decontamination building be posted as a high radiation area. This posting was performed on February 1, 1996. The causes for the failure to post the decontamination building between January 4, 1996, and February 1, 1996, are:
~ On January 4, 1996 only one door of the decontamination building was posted indicating that the building was a high radiation area. The need to post the
~
remaining doors went undetected because of a lack of clear procedural and work practice guidance which resulted in human error. As a result no survey of the decontamination building was completed after the vacuum housing was placed in it, and the need to post all doors went uncorrected until February 1, 1996, when the vacuum housing was identified as a high radiation source.
~ Surveys that were conducted subsequent to placing the vacuum housing in the decontamination building also failed to identify the posting deficiencies. The initial survey performed on January 4, 1996, was incomplete. Another survey of the building was conducted on January 8, 1996, but was only performed at one corner of the building and did not identify any unusual radiation conditions.
Subsequently, a survey conducted on January 15, 1996, did identify slightly elevated dose rates at one location-outside the building. However, the slightly elevated dose rates were considered insignificant because the health physics technician performing the survey did not recognize that the elevated dose rates were from a high radiation source, i.e., the vacuum housing.
ATTACHMENTTO PLA-4473 Page 2 of 6 W
'll doors to the decontamination building on the refueling floor were immediately posted on February, 1, 1996, following identification that the vacuum housing was a high radiation source. Subsequently, a new rope barricade was erected to prevent access to the decontamination building. Therefore compliance with high radiation area posting requirements was achieved.
- b. Although functionally adequate, numerous procedures have been revised to clarify station survey, posting, and work practices when working with radioactive equipment. These procedural revisions will strengthen the station's radiation controls program.
C. The health physics technician involved in this event was counseled 'as to the necessity to complete survey and posting requirements pursuant to station procedures.
- d. Health Physics training was conducted which will enhance a "questioning attitude" regarding radiological changes noted during routine surveys. The purpose of this training was to sensitize the health physics technicians on the need to follow-up and perform additional investigative surveys when elevated radiation levels are measured.
- e. Locking devices were placed on the decontamination building doors so that in the future this facility can be locked when radiation levels require locked radiation controls.
A "radiological safety note" was distributed to station personnel reiterating the necessity of controlling radiological postings.
Appropriate radiological controls work programs, and work priorities and communication enhancements associated with outage management activities have been developed. These programs will increase the sensitivity of station personnel to station radiological control concerns, thereby reducing the occurrence events.
of'imilar
- h. Areas of the plant which were not already under locked high radiation controls were surveyed and upgraded as necessary to ensure the station was in compliance with NRC posting and barricade requirements.
ATTACHMENTTO PLA-4473 Page3 of6 An independent walk-down, by first line supervisors, of high radiation posting changes is now required. This corrective action, which is in response to a subsequent posting event, adds assurances that the 10CFR20 and plant Technical Specification posting and barricading requirements are'being promptly and correctly implemented.
W'P&L management immediately commissioned an intensive investigation to establish the cause and recommend corrective actions in response to this event. The resultant corrective actions taken to address this event were expeditiously dispositioned. PP&L, therefore, considers the corrective actions identified above to satisfactorily address this violation.
Based on the action taken in 2.a above, PP&L is in full compliance.
ATTACHMENTTO PLA-4473 page4of6
' g jgQ~~ (387/96-04-03; 388/96-04-03)
Pursuant to 10CFR20.1003, survey means an evaluation of the radiological conditions and potential hazards incident to the production, use, transfer, release, disposal, or presence of radioactive material or other sources of radiation.
Contrary to the above, as of April 4, 1996, the licensee did not make surveys to assure compliance with 10CFR20.2001(a), which describes authorized meaits of disposing of licensed material. Specifically, on September 21, 1995, (Note: The tanker was released offsite on September 14, 1995, as stated in Inspection Report 50-387/96-04 and 50-388/96-04) the licensee did not perform a survey before disposing of sludge in a tanker truck as normal, non-radioactive waste. On prior occasions, the tanker truck contained radioactive water above the lower limits of detection for effluent releases. 4 RcBQ~H1K On February 29, 1996, PP&L was notified, by an organization in Montreal, Quebec Canada, that a tanker truck previously used by PP&L (PP&L identification ¹255-216) had a radioactive materials label affixed to the tanker. Prior to releasing the tanker offsite, the tanker (which had previously contained slightly contaminated water) was surveyed using existing procedures, and determined to be acceptable for offsite release.
Prior to transport to Montreal, Quebec the tanker was thoroughly cleaned at a truck washing facility in Pennsylvania.
To determine ifthe tanker may have been contaminated or ifother potentially radioactive material may have been in the tanker following release from the site, a tanker (PP&L identification ¹255-212) that had been used in a similar manner, was surveyed. The survey identified a small amount of slightly radioactive sludge in the bottom of the tanker. Dose calculations performed on this sludge concluded that any dose received would have been a small fraction of applicable dose limits for a member of the public and, based on transportation regulations, the sludge found would have been classified as an "exempt quantity." Because of the process used by PP&L to determine ifradioactivity was associated with the tanker, the tanker may have contained similar or slightly lower amounts of slightly radioactive sludge. Therefore, it was concluded that an inadequate survey had been performed on tanker ¹255-216.
~ The reason for the inadequate survey performed on the subject tanker, prior to its release offsite on September 14, 1995, was that:
ATTACHMENTTO PLA-4473 Page 5 of 6
~ No procedural guidance existed that specifically looked for or removed unnecessary labeling prior to release from the radiologically controlled area (RCA) or the site.
~ The procedure used to survey for contamination (HP-TP-602) was less than adequate in that it did not specifically require an internal survey of the tanker.
~ No overall procedure existed to control the process for use, surveying, sampling, or release of the tanker by the several affected functional organizations within PPAL.
Although each functional organization has procedures to address their specific activity, the lack of a comprehensive governing procedure contributed to a lack of training related to aspects of releasing of material offsite, weak programmatic control of tankers for release from the RCA and site, less than adequate contamination control of empty containers, and less than adequate work plans for completely emptying the tanker.
- a. The remaining tankers at Susquehanna that are utilized for similar purposes have been relocated within the protected area, and have been physically secured. This will ensure positive control of these tankers prior to release offsite.
- b. Nuclear Department procedures (NDAP-00-0627 and HP-TP-0602) have been revised to require that the internal surfaces of tankers be surveyed prior to exiting the site..
C. Nuclear Department Administrative Procedure (NDAP-00-0627) has been revised to incorporate steps that remove unnecessary labels on tankers prior to release offsite. Incorporation of a specific procedural step to remove labels in this NDAP, which applies across functional organizations, provides assurances that only required labeling willbe attached to tankers exiting the site.
The truck wash facility was surveyed. No nuclides attributable to nuclear power
. plant operation were identified.
The internal structure of several tankers has been inspected to determine if there are any physical obstructions that will prevent the complete draining of material from the tanker. This inspection concluded. that there are no major structural internals that should prevent the complete draining of a tanker. At least two designs have been identified; however, they present no significant impediments to emptying the tankers.
ATTACHMENTTO PLA-4473 Page6of6 PP&L correspondence was sent to the organization in Montreal, Quebec, who received the tanker, stating that there was not a radiological hazard associated with the tanker, and that the label could be removed.
W W'1 Surveys of the remaining tankers that were utilized for similar purposes will be performed to assure that they are not radioactively contaminated nor contain .
radioactive sludge above station release limits. These surveys are scheduled to be completed by July 31, 1996.
- b. Inspections of the remaining tankers that, were utilized for similar purposes will be conducted to assure that inappropriate labels have been removed. These inspections are scheduled to be completed by July 31, 1996.
C. Requirements associated with tanker activities within the protected area will be enhanced to assure that adequate controls exist for the use, surveying, sampling, labeling, etc. of tankers. These requirements are scheduled to be developed and implemented by July 31, 1996.
The overall program for controlling and coordinating the process for removing material from the RCA and site will be evaluated. This evaluation is scheduled to be completed by July 31, 1996.
Training will be provided, to applicable functional organizations, that addresses the release of materials from the RCA that may be slightly radioactive. This training will contain elements associated with appropriate. lower limits of detection (LLD's), plate out mechanisms and the diferent requirements for release of materials from the RCA and offsite. Initial training for key functional organizations is scheduled to be completed by September 30, 1996.
Based on 2.a and 2.b above, PP&L is in full compliance.