05000298/FIN-2011003-12

Finding

Title

Licensee-Identified Violation

Description

Title 10 CFR Part 50, Appendix B, Criterion XVI, Corrective Actions, requires, in part, that Measures shall be established to assure that conditions adverse to quality, such as failures, malfunctions, deficiencies, deviations, defective material and equipment, and nonconformances are promptly identified and corrected. Contrary to the above, the licensee failed to promptly identify and correct a condition adverse to quality, associated with bolted fasteners on emergency diesel generator number 2. Specifically, the licensee had postponed implementation of a corrective action, from a previous loose bolting issue associated with the overspeed governor, to perform a 100 percent torque check of all fasteners on the diesel from June until August 2010 due to conflicting work week schedules. As a result, when the bolting was checked the bolts for the overspeed governor were found loose again, and the licensee determined that the loose bolts had been a result of improper maintenance performed when reassembling the joint from the previous bolting issue. Using Manual Chapter 0609.04, Phase 1 Initial Screening and Characterization of Findings, the inspectors determined this finding to be of very low safety significance because there was not a design or qualification deficiency that resulted in a loss of operability or functionality, it did not create a loss of system safety function or of a single train for greater than the technical specification allowed outage time, it did not represent an actual loss of risk significant equipment, and it did not affect seismic, flooding, or severe weather initiating events.

12
Site:	Cooper
Report	IR 05000298/2011003 Section 4OA7
Date counted	Jun 30, 2011 (2011Q2)
Type:	NCV: Green
cornerstone	Mitigating Systems
Identified by:	Licensee-identified
Inspection Procedure:
Inspectors (proximate)	G Pick J Josey L Ricketson M Chambers M Young N Greene V Gaddy
INPO aspect
'
v • d • e

Finding - Cooper - IR 05000298/2011003

1(0)2(6)3(12)4(7)5(9)6(5)7(0)8(6)9(1)10(0)201(0)202(1)301(0)403(0)501(0)

IR 05000298/2011003: 1 2 3 4 5 6 7 8 9 10 11 12

Finding List (Cooper) @ 2011Q2

CCA Matrix: 2011Q2

	Q	CCA	Title
05000298/FIN-2010004-02	2010Q3	P.2	Failure to Follow Procedure Results in Repeat Equipment Failure
05000298/FIN-2010004-01	2010Q3	H.14	Failure to Adequately Monitor the Performance of the Screen Wash System
05000298/FIN-2010005-03	2010Q4	P.5	Failure to Adequately Assess and Manage Risk During Maintenance Activities
05000298/FIN-2010006-01	2010Q4	P.1	Inadequate Post-Fire Safe Shutdown Procedures
05000298/FIN-2010006-02	2010Q4	H.14	Failure to Monitor the Performance of the Emergency Lights Against the Maintenance Rule Criteria
05000298/FIN-2010005-01	2010Q4	H.14	Failure to Implement Fire Protection Plan Requirements Related to Hot Work Activities
05000298/FIN-2010005-02	2010Q4	H.14	Failure to Assess and Manage Risk for Electrical Switchyard Impacting Maintenance
05000298/FIN-2010005-05	2010Q4		Diesel Generator Overspeed Governor Loose Bolting Issue
05000298/FIN-2010005-06	2010Q4		Failure to Update Flood Protection for Safety Related Buildings
05000298/FIN-2010005-04	2010Q4	P.3	Failure to Have Guidelines for the Choice of Protective Actions During an Emergency Consistent with Federal Guidance
05000298/FIN-2010007-04	2010Q4	P.5	Inadequate Design Control
05000298/FIN-2010007-06	2010Q4	S.2	Faulty General Electric Switches
05000298/FIN-2010007-01	2010Q4	H.7	Failure to Translate Design and Operating Requirements into Procedures
05000298/FIN-2010007-02	2010Q4	H.14	Failure to promptly Correct Conditions Adverse to Quality
05000298/FIN-2010007-03	2010Q4	H.7	Inadequate Test Control
05000298/FIN-2010007-05	2010Q4	H.14	Ice Deflector Pontoon Barge Storage in Service Water Discharge Canal
05000298/FIN-2010007-07	2010Q4		URI 05000298/2007011-07, Fuel Oil Storage Tank Required Submergence To Prevent Vortexing And Available Volume Are Marginal Without Accounting For Instrument Uncertainties
05000298/FIN-2010007-08	2010Q4		URI 05000298/2007011-08, High Pressure Coolant Pump Swap-Over from Emergency Condensate Storage Tank to Torus Vortex Calculation
05000298/FIN-2011009-01	2011Q1	P.2	Inadequate Post-Fire Safe Shutdown Procedures
05000298/FIN-2011002-02	2011Q1	P.3	Failure to Assess and Manage Risk for Maintenance That Could Impact Initiating Events
05000298/FIN-2011002-04	2011Q1	P.3	Repeat Failure to Follow Procedure for Initiating Condition Reports
05000298/FIN-2011002-03	2011Q1	H.8	Failure to Adequately Implement Foreign Material Exclusion Controls
05000298/FIN-2011002-01	2011Q1	H.14	Failure to Properly Evaluate All Senior Operator License Holders during Annual Operating Test
05000298/FIN-2011002-05	2011Q1	H.14	Failure to Notify the NRC within Eight Hours of a Nonemergency Event
05000298/FIN-2011003-08	2011Q2	H.12	Failure to Follow Procedure Results in Degraded Emergency Diesel Generator
05000298/FIN-2011006-05	2011Q2	H.14	Failure to Correctly Translate Design Requirements into Installed Plant Configuration
05000298/FIN-2011003-01	2011Q2	H.14	Failure to Assess Potential Adverse Effects on Internal Flooding Analysis
05000298/FIN-2011008-01	2011Q2	H.8	Unclear Work Instructions
05000298/FIN-2011008-02	2011Q2	H.5	Failure to Recognize Work Order Risk
05000298/FIN-2011008-03	2011Q2	H.12	Failure to Implement Human Performance Procedure
05000298/FIN-2011008-04	2011Q2	H.14	Failure to Revise Unclear Work Instructions
05000298/FIN-2011008-05	2011Q2	H.5	Failure to Perform an Adequate High Radiation Area Briefing
05000298/FIN-2011008-06	2011Q2	H.12	Failure to Follow Radiation Protection Job Coverage Procedures
05000298/FIN-2011003-04	2011Q2		Communication of an NRC Inspectors Presence by Station Personnel
05000298/FIN-2011006-02	2011Q2	P.2	Failure to Report Conditions Prohibited by Technical Specifications and Safety System Functional Failures
05000298/FIN-2011006-03	2011Q2	P.2	Failure to Perform 10 CFR 50.59 Evaluation for Design Change
05000298/FIN-2011006-04	2011Q2	P.2	Failure to Take Action for an Ineffective Corrective Action
05000298/FIN-2011003-02	2011Q2	P.2	Failure to Follow Procedure Results in Inadequate Operability Determinations
05000298/FIN-2011003-03	2011Q2	H.4 H.5	Failure to Follow Procedure Results in Personnel Contaminations
05000298/FIN-2011003-05	2011Q2	H.11 H.12	Failure to Follow Radiation Work Permit Requirements
05000298/FIN-2011003-06	2011Q2		Failure to Correctly Translate Design Requirements into Installed Plant Configuration
05000298/FIN-2011003-07	2011Q2		Failure to Adequately Assess and Manage Risk When Disabling A Hazard Barrier
05000298/FIN-2011003-09	2011Q2	H.6	Failure to Initiate Condition Reports for Nonconformances Identified During System Walk Downs
05000298/FIN-2011003-10	2011Q2	P.1	Failure to Promptly Correct an Adverse Condition Related to Emergency Core Cooling System Venting
05000298/FIN-2011006-01	2011Q2	P.1	Failure to Promptly Identify and Correct Conditions Adverse to Quality

Self-Identified List (Cooper)

	Q	Title
05000298/FIN-2010004-03	2010Q3	Licensee-Identified Violation
05000298/FIN-2010403-01	2010Q4	Security
05000298/FIN-2011002-06	2011Q1	Licensee-Identified Violation
05000298/FIN-2011003-11	2011Q2	Licensee-Identified Violation
05000298/FIN-2011003-12	2011Q2	Licensee-Identified Violation

[Cooper Findings full list]

05000298/FIN-2011003-12

Navigation menu

Search