05000440/FIN-2009003-08

Finding

Title

Dose Overrun on RWP 09-6035 for the Alternate Decay Heat Removal Project

Description

The inspectors identified an URI associated with the licensees ALARA planning and work controls for the alternate decay heat removal project. The inspectors reviewed a CAP record (CR 09-55801) that described the significant dose overrun on Radiation Work Permit (RWP) 09-6035, for the alternate decay heat removal project. The work was ongoing during the current refueling outage (RFO 12). Based on the initial assessment of the inspectors, there appeared to be a potential performance deficiency associated with the planning and execution of this work. The actual dose incurred was several times more than the initial dose estimate and the reasons and radiological impact for the increased dose was not well understood. Since the work activity was not completed, the inspectors could not assess the total dose for the activity nor the full scope and impact of the work controls. Consequently, this issue remains under review by the NRC to determine if it represents a performance deficiency and is categorized as URI 0500440/2009003-08

08
Site:	Perry
Report	IR 05000440/2009003 Section 2OS2
Date counted	Jun 30, 2009 (2009Q2)
Type:	URI: Green
cornerstone	Mitigating Systems
Identified by:	NRC identified
Inspection Procedure:	IP 71121.02
Inspectors (proximate)	A Wilson J Tapp R Russell E Coffman R Leidy J Cameron P Voss T Hartman P Smagacz E Denison M Marshfield D Szwarc W Slawinski C Moore M Phalen M Bielbym Wilk M Marshfield M Phalen D Jones M Franke J Bashore R Leidy J Cameron R Murray C Tilton J Coroju-Sandi
INPO aspect
'
v • d • e

Finding - Perry - IR 05000440/2009003

14(0)16(0)1(0)2(7)3(14)4(6)5(5)6(1)7(3)8(0)301(0)402(0)403(0)404(0)501(0)13(0)

IR 05000440/2009003: 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Finding List (Perry) @ 2009Q2

CCA Matrix: 2009Q2

	Q	CCA	Title
05000440/FIN-2008004-07	2008Q3	H.8	Loss of Configuration Control of the Hydrogen Water Chemistry Injection System Resulting in High Radiation Levels (Section 4OA3.3)
05000440/FIN-2008004-06	2008Q3	H.11 H.12	Failure to Adequately Manage Risk Associated With Working Around a Risk-Significant Underground Vault
05000440/FIN-2008004-05	2008Q3	H.7	Adequacy of Airlock Ball Valve Maintenance (4OA2.3)
05000440/FIN-2008004-04	2008Q3	H.12	Failure to Use Procedures for Work Affecting Safety
05000440/FIN-2008004-03	2008Q3	H.5	Failure to Implement a Procedurally-Required Risk Management Activity for a Protected Train (Section 1R13.2)
05000440/FIN-2008004-02	2008Q3	H.5	Failure to Implement Compensatory Measures for a Risk-Management Activity
05000440/FIN-2008004-01	2008Q3	H.11 H.12	Impaired Fire Barrier for Safety-Related Building
05000440/FIN-2008005-01	2008Q4	H.7	Inspection Procedure for RPV Head Strongback Omitted Non-Destructive Testing of Structural Welds
05000440/FIN-2008005-04	2008Q4	P.2	Failure To Report All 10 CFR 50.73 Reportable Events Associated With the Discovery of Loose Containment Grating
05000440/FIN-2008005-05	2008Q4		Unplanned Unavailability of the Motor Feedwater Pump After it was Placed in 10 CFR 50.65(a)(1) status
05000440/FIN-2008005-02	2008Q4		Containment Polar Crane Trolley Seismic Restraints Did Not Meet Seismic Category I Requirements
05000440/FIN-2008005-03	2008Q4	P.1 P.1(a)	Loss of the V-1F and V-2F Non-Vital Buses Resulting in the Loss of Technical Support Center Computers
05000440/FIN-2009002-06	2009Q1	H.5	Maintenance on HPCS System resulted in Emergency Operating Procedure Entry
05000440/FIN-2009002-05	2009Q1		Failure to Document All Applicable Hazards on Shipping Manifest
05000440/FIN-2009002-04	2009Q1	H.2	Failure to Perform an Adequate Evaluation to Determine the Use of Respiratory Protection Equipment and/or Engineering Controls
05000440/FIN-2009002-03	2009Q1	H.4 H.5	Loss of Service Air to Main Steam Line Plugs
05000440/FIN-2009002-02	2009Q1	P.2	Inadequate Inspections on the RPV Head Strongback Lifting Device Major Load-Carrying Welds and Critical Areas
05000440/FIN-2009002-01	2009Q1	P.2	Ineffective Corrective Actions Associated with the Motor Feedwater Pump in 10 CFR 50.65(a)(1) Status
05000440/FIN-2009006-01	2009Q1	H.2	Failure to Adhere to Procedures for Scaffold Affecting Containment Systems (Section 4OA2.1)
05000440/FIN-2009003-11	2009Q2	P.2	RHR System Over-pressurization Due to Failure to Implement Corrective Actions for a Condition Adverse to Quality
05000440/FIN-2009003-10	2009Q2	H.11 H.12	Work on Wrong Relay Affecting Shutdown Cooling
05000440/FIN-2009003-08	2009Q2		Dose Overrun on RWP 09-6035 for the Alternate Decay Heat Removal Project
05000440/FIN-2009003-06	2009Q2	H.4 H.5	Failure to Barricade and Conspicuously Post a High Radiation Area
05000440/FIN-2009003-05	2009Q2	H.14	Failure to Implement Adequate Compensatory Measures Associated with Moving Burned Fuel Coincident with Workers on the 360 Platform
05000440/FIN-2009003-03	2009Q2	H.2	Inability to Operate the RHR Common Suction Line Valve
05000440/FIN-2009003-02	2009Q2	H.2 H.5	Failure to Follow Industrial Safety Manual Results in Damage to Fuel Handling Building Roll-up Door
05000440/FIN-2009003-01	2009Q2	H.5	RCS Temperature Below Minimum Allowed by TS Due to Inadequate Station Procedures
05000440/FIN-2009003-04	2009Q2	H.11 H.12	Failure to Prevent Contact of Energized Components Renders RCIC System Inoperable
05000440/FIN-2009007-03	2009Q2	P.2	Failure to Provide Required Electrical Isolation for Post-Fire Safe Shutdown Electrical Circuits
05000440/FIN-2009007-02	2009Q2		Failure to Assure That Systems Structures and Components Necessary to Achieve and Maintain Hot Shutdown Conditions Were Free of Fire Damage Without Repair Actions
05000440/FIN-2009003-09	2009Q2	H.5	Loss of Shutdown Cooling Water Flow to Reactor Vessel
05000440/FIN-2009007-01	2009Q2		Failure to Maintain Procedures for Post-Fire Operation of Control Room HVAC Fans and Control of Remote Shutdown Room Toolbox Inventory
05000440/FIN-2009003-07	2009Q2		Employee Disregarded portal Monitor Alarm

Self-Identified List (Perry)

	Q	Title
05000440/FIN-2008004-08	2008Q3	Licensee-Identified Violation
05000440/FIN-2008004-09	2008Q3	Licensee-Identified Violation
05000440/FIN-2008004-10	2008Q3	Licensee-Identified Violation
05000440/FIN-2008005-06	2008Q4	Licensee-Identified Violation
05000440/FIN-2008005-07	2008Q4	Licensee-Identified Violation
05000440/FIN-2009002-07	2009Q1	Licensee-Identified Violation
05000440/FIN-2009003-14	2009Q2	Licensee-Identified Violation
05000440/FIN-2009003-12	2009Q2	Licensee-Identified Violation
05000440/FIN-2009003-13	2009Q2	Licensee-Identified Violation

[Perry Findings full list]

05000440/FIN-2009003-08

Navigation menu

Search