|
---|
Category:NOTICE OF VIOLATION OF A REGULATION
MONTHYEARML20206E3331999-04-28028 April 1999 Notice of Violation from Insp on 990105-022.Violation Noted: Between 981222 & 990105,low Temp Condition with Potential to Cause Freezing of Common Min Flow Line Was Not Identified Nor Cause Determined ML20207L1211999-03-10010 March 1999 Notice of Violation from Insp on 990105-0222.Violation Noted:As of 990129,Operations Manual 3.7, AOP & EOP Sets Use & Adherence, Rev 5,major Procedure Prescribing Activities Affecting Quality,Inappropriate for Circumstance ML20199H5621999-01-15015 January 1999 Notice of Violation from Insp on 981121-990104.Violations Noted:As of 981015,adequate VT-2 Visual Exam of Pressure Retaining Boundary of Sfsp Common to Units 1 & 2 Not Performed During Each Code Insp Period ML20151Y2571998-09-11011 September 1998 Notice of Violations from Insp on 980608-12 & 0715-16. Violations Noted:Licensee Failed to Determine Lowest Voltages Available at Breaker Close & Trip Coils Since Original Installation of Breaker ML20249C2851998-06-19019 June 1998 Notice of Violation from Insp on 980414-0523.Violation Noted:Licensee Did Not Test Some Refueling Sys Interlocks During Refueling Shutdowns from Time of Initial Plant Refueling Through 980422 ML20249A0621998-06-11011 June 1998 Notice of Violation from Insp on 980518-22.Violation Noted: Two Emergency Plan SRDs Available for Use in Emergency Plan Sampling Kits,Not Calibrated in Dec 1997 ML20247D6681998-05-0505 May 1998 Notice of Violation from Insp on 971216-980309.Violations Noted:Weld Procedure Wps GT-SM/1.1-1 Pb,Rev 4,used to Fabricate SG Replacement Main Steam & Feedwater Welds,Did Not Meet Requirements of QW-409.1 ML20217J4521998-04-0101 April 1998 Notice of Violation from Insp on 980310-18.Violation Noted: as of 980313,licensee Failed to Establish Measures to Assure That Conditions Adverse to Quality,Promptly Identified & Corrected ML20217D3451998-03-21021 March 1998 Notice of Violation from Insp on 980120-0302.Violation Noted:Replacement of 10CFR50,App B,Criterion V,State,In Part,That Activities Affecting Quality Shall Be Prescribed by Documented Instructions IR 07100020/20110071998-02-19019 February 1998 Notice of Violation from Insp on 971020-1107.Violation Noted:Danger Tags 97-753 & 97-800 Were Installed on 971007 & 18,w/o Tag Sequence Numbers Being Assigned to Danger Tag Location Sheet ML20202E9641998-02-10010 February 1998 NOV from Insp on 971201-980120.Violation Noted:From 980108- 09,operators Failed to Initiate Actions within 1 H to Place Unit in Hot Shutdown When Both Unit 1 safety-related 4,160- Volt Buses Were Powered from Standby Emergency Power Supply IR 07100021/20110301997-12-22022 December 1997 Notice of Violation from Insp on 971021-1130.Violation Noted:As of 971125,four Operability Determinations Prepared as Corrective Actions for Testing Nonconformance Documented in Condition Repts Failed to Justify Operability IR 07100020/20120051997-12-18018 December 1997 Notice of Violation from Insp on 971020-1205.Violation Noted:From 941031-970812,licensee Had Implemented Exemption from Biennial Written & Annual Operating Tests Required of Licensed Operators for 2 Individuals Assigned to Exam Team ML20211P3531997-10-14014 October 1997 Notice of Violation from Insp on 970707-11.Violation Noted: as of 970711,surveillance Procedure E-M3-1, Emergency Lighting, Not Adequate & Did Not Include Data Sheet That Adequately Captured Emergency Lighting Battery ML20211J8831997-10-0404 October 1997 NOV from Insp on 970825-29.Violation noted:11 Emergency Plan SRDs Not Calibr in June 1997 & Had Not Been Calibr Since Dec 1996 ML20211B1901997-09-17017 September 1997 Notice of Violation from Insp on 970304-0805.Violation Noted:As of Feb 1997,test Program Did Not Ensure That Testing Required to Demonstrate Satisfactory Performance of CCW cross-connect valves,CC-722A & CC-722B Was Identified ML20217A2611997-09-15015 September 1997 Notice of Violation from Insp on 970519-0613.Violations Noted:Inspectors Identified on 970613 That Weld Procedure Wps GT-SM/3.3-2 Pb,Rev 1,did Not Meet Requirements of QW-409.1 ML20217K2871997-08-0808 August 1997 Notice of Violations from Insp on 961202-970314.Violations Noted:Licensee Did Not Identify & Promptly Correct Condition Adverse to Quality Re Operation of Safety Injection Pump ML20151K4081997-07-29029 July 1997 Notice of Violation from Insp on 970707-11.Violation Noted: Technician Performing Maint Removed Bypass Filters & Failed to Discard Them ML20137M8521997-04-0303 April 1997 Notice of Violation from Insp on 970303-07.Violation Noted: on 970225,individual Signed in on Standing Radiation Permit 97-0004-1,entered Area Posted, High Radiation Area, Radiography in Progress ML20135E3441997-02-27027 February 1997 Notice of Violation from Insp on 961217-970127.Violation Noted:Licensee Identified That on 961216,auxiliary Operator Was Preparing Unit 2 Residual Heat Removal Sys for Fill & Vent Evolution & Did Not Open Valve 2RH-709A,as Required ML20147A7711997-01-23023 January 1997 Notice of Violation from Insp on 961120-1127.Violation Noted:Battery Chargers D-107 & D-108 Would Not Function Properly If Aligned to DC Bus W/O Battery Also Conducted Due to Design ML20133C4331997-01-0202 January 1997 Notice of Violation from Insp on 961028-0906.Violation Noted:Licensee Failed to Ensure That Byproduct Matl Was Possessed & Used,Iaw License Conditions 2.C,2.D or 2.E ML20129D9941996-10-18018 October 1996 Notice of Violation from Insp on 960826-0925.Violation Noted:On 960404,worker Present in C CVCS Hold Up Tank Cubicle Posted High Radiation Area,Rwp Required, W/O Being Signed on RWP ML20059A2301993-12-23023 December 1993 Notice of Violation from Insp on 931026-1206.Violation Noted:Licensee Did Not Rept Initiation of Nuclear Plant Shutdown Required by TS 15.3.0.A ML20058C9461993-11-18018 November 1993 Notice of Violation from Insp on 930907-1025.Violation Noted:Work Instructions Were Not Appropriate Such as Replacing Bearings of Safety Injection Pump & Performing Electrical Distribution System Meter Calibrations ML20057E8171993-10-0606 October 1993 Notice of Violation from Insp on 930802-0903.Violation Noted:Controlling Work Document Did Not Provide Quantitative Acceptance Criteria for Establishing Leak Tightness of Boundary Valves ML20125C7481992-12-0808 December 1992 Notice of Violation & Proposed Imposition of Civil Penalty in Amount of $75,000.Violations Noted:While Reactor Made Critical on 911113,foreign Matl Exclusion Disk Left in Section of Sys Piping Leading to Suction of Injection Pump ML20126B4391992-12-0808 December 1992 Notice of Violation from Insp on 921013-1122.Violation Noted:On 921026,maint Electrician Did Not Open Isolation Knife Switch as Required by Procedure Rmp 74 Prior to Depressing Relay Test Button ML20127D8761992-09-0404 September 1992 Notice of Violation from Insp on 920629-0823.Violation Noted:Battery Cable on G-501 Auxiliary Diesel Was Reconnected to Battery Prior to Danger Tag Location Sheet Authorizing Return to Svc of Equipment to Operations Group ML20058H1161990-10-30030 October 1990 Notice of Violation from Insp on 900905-1015.Violation Noted:Inadvertent Actuation of RPS Occurred When Two of Three Containment Pressure Bistables Tripped & Was Not Reported Until 901011,over One Yr from Date of Occurrence ML20055J3751990-06-0808 June 1990 Notice of Violation from Insp on 900525.Violation Noted: Failure to Make Adequate Surveys or Evaluations Necessary & Reasonable to Ensure Compliance W/Occupational Dose Limits After Health Physics Technologist Handled 142.5 Mci Fuel ML20245G7761989-06-21021 June 1989 Notice of Violation from Insp on 890301-0531.Violation Noted:On 890505,technician Failed to Install Analog Simulator for 1A Steam Generator Scheduled to Be Drained Below Low Level Setpoint to Facilitate Maint ML20195B3591988-10-21021 October 1988 Notice of Violation from Insp on 880926-30.Violations Noted:Instructor Not Always Present During Exam Given to Students Having Completed General Employee Training ML20155D5531988-05-19019 May 1988 Notice of Violation from Insp on 880418-22.Violation Noted: Failure to Use Flashing Red Light as Warning Device When Dose Rate Exceeded 1000 M/H & Radiation Surveys Performed While Fuel Element in Stationary Position ML20154H2471988-05-16016 May 1988 Notice of Violation from Insp on 880316-0430.Violation Noted:Instrument & Control Supervisor Submitted Request for Equipment Isolation to Duty Shift Supervisor W/O Specifying Time & Date of Planned Work Activity IR 07100020/20120301988-02-0202 February 1988 Notice of Violation from Insp on 871020-1230.Violations Noted:On 871114,during Plant Startup,Reactor Pressure Increased Above 150 Psig with RCIC Sys in Secured Status IR 07100020/20110191988-01-0404 January 1988 Notice of Violation from Insp on 871020-1119.Violations Noted:Emergency Diesel Generator 2J Electrically Overloaded Due to Inadequate Surveillance Procedure & Failure to Follow Procedures ML20236G5121987-10-29029 October 1987 Notice of Violation & Proposed Imposition of Civil Penalty in Amount of $25,000.Violation Noted:Msivs Could Not Close Because Dc Control Power Removed from Associated Solenoids & Event Not Reported within Required 4 H ML20236L7161987-07-29029 July 1987 Notice of Violation from Insp on 870217-20 & 0601-0715. Violations Noted:Licensee Disposed of Plant Sludge Onsite Contaminated W/Licensed Matl & Auxiliary Operator Failed to Reopen Air Start Isolation Valves While Performing TS-1 ML20235Q7231987-07-14014 July 1987 Notice of Violation from Insp on 870428-0519.Violation Noted:Two Authorized Contractor Technicians Handled Container of Licensed Matl Containing Highly Radioactive Particles & Container Not Labeled or Identified ML20215G8651987-04-0707 April 1987 Notice of Violation from Insp on 870201-0331 ML20216J1241987-03-11011 March 1987 Partially Withheld Notice of Violation & Proposed Imposition of Civil Penalty in Amount of $50,000 for Insp Repts 50-266/86-12 & 50-301/86-01 on 860718-0807 ML20207L8091987-01-0707 January 1987 Notice of Violation from Insp on 860926-1211 ML20211K2371986-11-0505 November 1986 Notice of Violation from Insp on 860807-08 & 1016-17 ML20212L2391986-08-0808 August 1986 Notice of Violation from Insp on 860601-0731 ML20197H1281986-05-14014 May 1986 Notice of Violation from Insp on 850722-26.Violations Noted: File Did Not Demonstrate That Single Specimen of Rockbestos Coaxial Cable Used for Entire Test Sequence,Nor Was Analysis of Discrepancy Provided in Support of Qualification IR 05000801/20090301985-10-10010 October 1985 Notice of Violation from Insp on 850801-0930 IR 05000301/20040301985-08-21021 August 1985 Notice of Violation from Insp on 850301-0430 ML20133F4581985-08-0101 August 1985 Notice of Violation from Insp on 850624-27,0703 & 18 1999-04-28
[Table view] Category:TEXT-INSPECTION & AUDIT & I&E CIRCULARS
MONTHYEARIR 05000266/19990151999-09-30030 September 1999 Insp Repts 50-266/99-15 & 50-301/99-15 on 990830-0903.No Violations Noted.Major Areas Inspected:Operations & Training IR 05000266/19990131999-09-29029 September 1999 Insp Repts 50-266/99-13 & 50-301/99-13 on 990714-0830.No Violations Noted.Major Areas Inspected:Aspects of Licensee Operations,Maint,Engineering & Plant Support IR 05000266/19993011999-09-0808 September 1999 NRC Operator Licensing Exam Repts 50-266/99-301OL & 50-301/99-301OL (Including Graded Tests) for Tests Administered on 990726-0802 IR 05000266/19990141999-08-31031 August 1999 Insp Repts 50-266/99-14 & 50-301/99-14 on 990726-30.No Violations Noted.Major Areas Inspected:Access Authorization Program,Alarm Stations & Communications.Security Mgt Also Inspected IR 05000266/19990091999-07-28028 July 1999 Insp Repts 50-266/99-09 & 50-301/99-09 on 990528-0713. Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support IR 05000266/19990121999-07-14014 July 1999 Insp Repts 50-266/99-12 & 50-301/99-12 on 990614-18.No Violations Noted.Major Areas Inspected:Implementation of Inservice Test Program & MOVs Capability,Per GL 96-05 IR 05000266/19990081999-06-18018 June 1999 Insp Repts 50-266/99-08 & 50-301/99-08 on 990411-0527.No Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support PNO-III-99-027, on 990514,Unit 1 Was Manually Tripped Due to Steam Leak from 4B Feedwater Heater.Nrc Resident Inspectors Monitored Activities in CR Following Reactor Trip & Monitoring Progress of Repair Work.Licensee Notified NRC1999-05-19019 May 1999 PNO-III-99-027:on 990514,Unit 1 Was Manually Tripped Due to Steam Leak from 4B Feedwater Heater.Nrc Resident Inspectors Monitored Activities in CR Following Reactor Trip & Monitoring Progress of Repair Work.Licensee Notified NRC IR 05000266/19990061999-05-0707 May 1999 Insp Repts 50-266/99-06 & 50-301/99-06 on 990223-0410. Non-cited Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support ML20206E3331999-04-28028 April 1999 Notice of Violation from Insp on 990105-022.Violation Noted: Between 981222 & 990105,low Temp Condition with Potential to Cause Freezing of Common Min Flow Line Was Not Identified Nor Cause Determined IR 05000266/19990051999-04-20020 April 1999 Insp Repts 50-266/99-05 & 50-301/99-05 on 990222-0312. Violations Noted.Major Areas Inspected:Effectiveness & Engineering & Technical Support Organization in Performance of Routine & Reactive Site Activities & Problem Prevention IR 05000266/19990101999-04-19019 April 1999 Insp Repts 50-266/99-10 & 50-301/99-10 on 990329-0401.No Violations Noted.Major Areas Inspected:Review of Emergency Preparedness Program & Aspect of Plant Support IR 05000266/19990071999-03-16016 March 1999 Insp Repts 50-266/99-07 & 50-301/99-07 on 990216-19.No Violations Noted.Major Areas Inspected:Routine Insp of Radiation Protection & Chemistry Program Which Included Water Chemistry Control Program ML20204D8311999-03-12012 March 1999 Insp Rept 50-266/99-04 on 990105-0222.One Violations of NRC Requirements Occurred & Being Treated as non-cited Violation.Major Areas Inspected:Operations,Maint & Engineering IR 05000266/19990021999-03-10010 March 1999 Insp Repts 50-266/99-02 & 50-301/99-02 on 990105-0222. Violations Noted.Major Areas Inspected:Licensee Operations, Maint,Engineering & Plant Support ML20207L1211999-03-10010 March 1999 Notice of Violation from Insp on 990105-0222.Violation Noted:As of 990129,Operations Manual 3.7, AOP & EOP Sets Use & Adherence, Rev 5,major Procedure Prescribing Activities Affecting Quality,Inappropriate for Circumstance IR 05000266/19990031999-02-0101 February 1999 Insp Repts 50-266/99-03 & 50-301/99-03 on 990111-15.No Violations Noted.Major Areas Inspected:Review of Plant Support Activities Relating to Physical Protection of Facility ML20199H5621999-01-15015 January 1999 Notice of Violation from Insp on 981121-990104.Violations Noted:As of 981015,adequate VT-2 Visual Exam of Pressure Retaining Boundary of Sfsp Common to Units 1 & 2 Not Performed During Each Code Insp Period IR 05000266/19980211999-01-15015 January 1999 Insp Repts 50-266/98-21 & 50-301/98-21 on 981121-990104. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support IR 05000266/19980221998-12-24024 December 1998 Insp Repts 50-266/98-22 & 50-301/98-22 on 981208-10.No Violations Noted.Major Areas Inspected:Maint Rule Program IR 05000206/19980191998-12-0404 December 1998 Insp Repts 50-206/98-19 & 50-301/98-19 on 981004.No Violations Noted.Major Areas Inspected:Licensee Operations, Engineering,Maint & Plant Support IR 05000266/19980201998-11-30030 November 1998 Insp Rept 50-266/98-20 & 50-301/98-20 on 981102-06.No Violations Noted.Major Areas Inspected:Plant Biennial Exercise of Emergency Plan IR 05000266/19980171998-10-26026 October 1998 Insp Repts 50-266/98-17 & 50-301/98-17 on 980818-1005.No Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000266/19980181998-10-0202 October 1998 Insp Repts 50-266/98-18 & 50-301/98-18 on 980831-0904.No Violations Noted.Major Areas Inspected:Radiation Protection Program,Including Review of Whole Body Counter Calibration, Portable Instrument Calibration & Routine Contamination ML20151Y2571998-09-11011 September 1998 Notice of Violations from Insp on 980608-12 & 0715-16. Violations Noted:Licensee Failed to Determine Lowest Voltages Available at Breaker Close & Trip Coils Since Original Installation of Breaker IR 05000266/19980131998-09-11011 September 1998 Insp Repts 50-266/98-13 & 50-301/98-13 on 980608-12 & 0715-16.Violations Noted.Major Areas Inspected:Adequacy of Licensee Programs,Procedures,Training,Equipment & Supporting Documentation for Maint of Medium Voltage & Low Voltage IR 05000266/19980151998-09-11011 September 1998 Insp Repts 50-266/98-15 & 50-301/98-15 on 980720-31.No Violations Noted.Major Areas Inspected:Adequacy of Licensee Programs,Procedures,Training & Supporting Documentation to Ensure TS Required Surveillance Testing IR 05000266/19980141998-09-0303 September 1998 Insp Repts 50-266/98-14 & 50-301/98-14 on 980707-0817.No Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000266/19980161998-08-10010 August 1998 Insp Repts 50-266/98-16 & 50-301/98-16 on 980713-17.No Violations Noted.Major Areas Inspected:Review of Plant Support Activities Re Physical Protection of Facility IR 05000266/19983011998-07-29029 July 1998 NRC Operator Licensing Exam Repts 50-266/98-301 & 50-301/98-301 (Including Completed & Graded Tests) for Tests Administered on 980622-25.One SRO License Applicant Passed All Portions of Exam & Issued Operating License ML20236V6621998-07-29029 July 1998 Insp Repts 50-266/98-11 & 50-301/98-11 on 980526-0706. No Violations Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support IR 05000266/19980091998-06-19019 June 1998 Insp Repts 50-266/98-09 & 50-301/98-09 on 980414-0523. Violation Noted.Major Areas Inspected:Operations,Maint, Engineering & Plant Support ML20249C2851998-06-19019 June 1998 Notice of Violation from Insp on 980414-0523.Violation Noted:Licensee Did Not Test Some Refueling Sys Interlocks During Refueling Shutdowns from Time of Initial Plant Refueling Through 980422 ML20249A0621998-06-11011 June 1998 Notice of Violation from Insp on 980518-22.Violation Noted: Two Emergency Plan SRDs Available for Use in Emergency Plan Sampling Kits,Not Calibrated in Dec 1997 IR 05000266/19980121998-06-11011 June 1998 Insp Repts 50-266/98-12 & 50-301/98-12 on 980518-22. Violations Noted.Major Areas Inspected:Review of Unit 1 Refueling Outage Doses,Solid Radwaste Mgt,Transportation of Radioactive Matls & Health Physics Program IR 05000266/19980071998-06-0303 June 1998 Insp Rept 50-266/98-07 on 980310-13,16,17,0401-02,22,24 & 0504-05.No Violations Noted.Major Areas Inspected: Maint & Engineeing IR 05000301/19980051998-05-0505 May 1998 Insp Rept 50-301/98-05 on 971216-980309.Violations Noted. Major Areas Inspected:Maint ML20247D6681998-05-0505 May 1998 Notice of Violation from Insp on 971216-980309.Violations Noted:Weld Procedure Wps GT-SM/1.1-1 Pb,Rev 4,used to Fabricate SG Replacement Main Steam & Feedwater Welds,Did Not Meet Requirements of QW-409.1 ML20247D2961998-05-0505 May 1998 Insp Repts 50-266/98-06 & 50-301/98-06 on 980303-0413. Violations Noted.Major Areas Inspected:Licensee Operations, Engineering,Maint & Plant Support IR 05000266/19980081998-04-15015 April 1998 Insp Repts 50-266/98-08 & 50-301/98-08 on 980316-20.No Violations Noted.Major Areas Inspected:Radiation Protection Performance During Refueling Outage ML20217J4571998-04-0101 April 1998 Insp Repts 50-266/98-10 & 50-301/98-10 on 980310-18. Violations Noted.Major Areas Inspected:Review of Measuring & Test Equipment Procedures ML20217J4521998-04-0101 April 1998 Notice of Violation from Insp on 980310-18.Violation Noted: as of 980313,licensee Failed to Establish Measures to Assure That Conditions Adverse to Quality,Promptly Identified & Corrected ML20217D3531998-03-21021 March 1998 Insp Repts 50-266/98-03 & 50-301/98-03 on 980120-0302. Violations Noted.Major Areas Inspected:Operations, Maintenance,Engineering & Plant Support ML20217D3451998-03-21021 March 1998 Notice of Violation from Insp on 980120-0302.Violation Noted:Replacement of 10CFR50,App B,Criterion V,State,In Part,That Activities Affecting Quality Shall Be Prescribed by Documented Instructions PNO-III-98-023, on 980305,unit 2 Completed TS-required Shutdown After Declaring CCW Sys Inoperable.While Shutdown, Licensee Plans to Conduct More Detailed Analysis of Postulated Failure1998-03-0606 March 1998 PNO-III-98-023:on 980305,unit 2 Completed TS-required Shutdown After Declaring CCW Sys Inoperable.While Shutdown, Licensee Plans to Conduct More Detailed Analysis of Postulated Failure IR 05000266/19980041998-02-27027 February 1998 Insp Repts 50-266/98-04 & 50-301/98-04 on 980202-06.No Violations Noted.Major Areas Inspected:Review of Health Physics Dept Preparations for Unit 1 Refueling Outage, Including ALARA Planning & Work Planning IR 07100020/20110071998-02-19019 February 1998 Notice of Violation from Insp on 971020-1107.Violation Noted:Danger Tags 97-753 & 97-800 Were Installed on 971007 & 18,w/o Tag Sequence Numbers Being Assigned to Danger Tag Location Sheet ML20203D4361998-02-19019 February 1998 Insp Repts 50-266/97-23 & 50-301/97-23 on 971020-1107. Violations Noted.Major Areas Inspected:Licensee Controls in Area of SEs as Well as Effectiveness of Licensee Controls in Identifying,Resolving & Correcting Problems IR 05000266/19970221998-02-18018 February 1998 Insp Repts 50-266/97-22 & 50-301/97-22 on 971104-980203.No Violations Noted.Major Areas Inspected:Review of 20 Licensee Event Repts Submitted Between 960909 & 971215 ML20202E9641998-02-10010 February 1998 NOV from Insp on 971201-980120.Violation Noted:From 980108- 09,operators Failed to Initiate Actions within 1 H to Place Unit in Hot Shutdown When Both Unit 1 safety-related 4,160- Volt Buses Were Powered from Standby Emergency Power Supply 1999-09-08
[Table view] |
Inspection Report - - 2011007 |
---|
|
|
Text
__
_
6 .-
NOTICE OF VIOLATION Wisconsin Electric Power Company Docket No. 50-266; 50-301
-
Point Beach Nuclear Plant . License No. DPR 24; DPR 27 During an NRC inspection conducted from October 20 through November 7,1997, violations of NRC requirements were identified. In accordance with NUREG 1600," General Statement of
< Policy and Procedure for NRC Enforcement Actions," the violations are listed below; I
! .
.
l CFR Part 50, Appendix B, Criterion V, "In=tructions, Procedures, and Drawings,"
). requires in part, that activitbs affecting quality be prescribed by documented
! procadures, of a type appropricte to the circumstances'and that the activities be accomplished !n accordance with these procedures. The procedures are to include ,
4 appropriate quantitative or qualitative acceptance criteria for determining that important activities have been satisfactorily accomplished.
'
Procedure NP 1.9.15, " anger Tag Procedure," Revision 3, Section 6.2.1 stated, in
! part, that the preparer . ill fill out the danger tag location sheet with tag sequence
!
-
numbers. Section 6.3.o . %ted, in part, that the qualified tagger shall position
,
equipment / components aJ specified in the " sequence" column and " required position"
'- column on the danger tag location sheet.
! - Procedure NP 5.3.7, " Operability Determinations,". Attachment A. " Management _
- - Expectations for Performing a Written Prompt Operability Determination," described
types of conditions that should receive a written operability evaluation if the system, 4 structure, or component was to remain in service. _ ltem 2.6 of this attachment listed one type of condition as " Errors in testing, testing methodology, instrumentation or data that
,
could invalidate surveillance testing that is used to demonstrate continued operability of SSCs (systems, structures, and components)."
Contrary to the above:
l Danger tags97-753 and 97-800 were installed on October 7,1997, and -
- October 18,1997, withe ;t tag sequence numbers being assigned to the danger
- tag location sheet.
b_ Although condition report QCR 97-0148, dated July 18,1997, documented that requirements for testing safety related relief valves per ASME Section XI 1986-OM-1(1981) were not met in all cases, no prompt operability determination had been completed for all the affected valves as of November 7,199 This is a Severity Level IV violation (Supplement 1).
,
a
4 9002260055 900219 -
gDR ADOCK 05000266
,
PM
'
.a .- . - =. .-
_ _ _ _ _ _ _ _ . _ . . _ . _ .
\
.
Notice of Vlolation 2 CFR Part 50, Appendix B, Criterion Xil, " Control of Measuring and Test Equipment,"
requires, in part, that measures be established to assure that instruments and other measuring and testing devices used in activities affecting quality are properly controlled, calibrated, and adjusted at specified periods to maintain accuracy within necessary limit Contrary to the above, on October 21,1997, while performing technical specification surveillance procedures 2f iP 9071 1 "A05 4160/480 Degraded and Loss of Voltage Relay Monthly Survelllance and 2RMP 90712 "A06 4160/480 Degraded and Loss of Voltage Reiay Monthly Surveillance" on Unit 2, personnel used an uncalibrated stopwatch to measure the 4.16 kV bus undervoltage relays 2 274/A05,2 275/A05,
! 2 276/A05,2 27-4/A06(27-4),2 27 5/A06(27-5) and 2 27-6/A06(27-6) pickup time delay setpoint value This is a Severity Level IV violation (Supplement 1). CFR Part 50 Appendix B, Criterion XVI," Corrective Action," requires, in part, that measures be established to assure that conditions adverse to quality, such as deficiencies and nonconformances, are promptly identified and corrected. Violation 50-266/96002-05(DRP),50-301/96002-05(DRP), dated April 17,1996, identified that changes to the plant, systems and parameters were not routinely updated into the final safety analysis report (FSAR).
Contrary to the above, as of November 7,1997, corrective actions to the above violation were not sufficient to assure that previous changes to plant systems that affected the FSAR were identified and corrected as follows: During a screening on October 1,1997, the licensee failed to identify that the FSAR had never been updated to reflect a change to procedures which occurred in 198 The licensee had not revised the FSAR to correct the description of the effects of a loss of a transmission line to the plant, althougn the need for such a revision was identified in 1993.
,
This is a Severity Level IV violation (Supplement 1).
Pursuant to the provisions of 10 CFR 2.201, Wisconsin Electric is hereby required to submit a written statement - t <planation to the U.S. Nuclear Regulatory Commission, ATTN: Document Control Desk, Was,hington, DC 20555-0001, with a copy to the Regional Administrator, Region Ill, and a copy to the NRC Resident inspector, within 30 days of the date of the letter transmitting this Notice. This reply should be clearly marked as a " Reply to a Notice of Violation" and should include: (1) the reason for the violation, or if contested, the basis for
. _ _ _ _ _ _ - - _ _ _ _ -
.
f Notice of Violation 3 disputing the violation or the severity level; (2) the corrective steps taken and the results achieved; (3) the corrective steps to be taken to avoid ft1her violations; and (4) the date when full compliance will be achieved. Your resr~1se may reference or include previous docketed correspondence,if the correspondence adequately addresses the required response. if an adequate reply is not received within the time specified in this Notice, an order or a Demand for information may be issued as to why the license should not be modified, suspended, or revoked, or why such other action as may be proper should not be taken. Where good cause is shown, consideration may be given to extendir.g your response time, if you contest ti..s enforcement action, you should also provide a copy of your reaponse to the Director, Office of Enforcement, U.S. Nuclear Regul? tory Commission, Washington, DC 20555-000 Because your response will be placed in the NRC Public Document Room (PDR), to the extent j
,
possible, it should not include any personal privacy, proprietary, or safeguards information so that it can be placed in the PDR without redaction if personal privact or proprietary !ntormation i
'
is necessary to provide an acceptable response, then please provide a bracketed copy of your response that identifies the information that should be protected and a redacted copy of your response that deletes such information, if you request withholding of such material, you must specifically identify the portions of your response that you seek to have withheld and provide in detail the bases for your claim of withholding (e.g., explain why the disclosure of information will create an unwarranted invasion of personal privacy or provide the information required by 10 CFR 2.790(b) to support a request for withholding confidential commercial or financial information).
Dated at Lisle, Illinois, thisti th day of February 1998 l
-. _____________d