ML13325A986
| ML13325A986 | |
| Person / Time | |
|---|---|
| Site: | San Onofre  |
| Issue date: | 10/31/1991 |
| From: | SOUTHERN CALIFORNIA EDISON CO. |
| To: | |
| References | |
| PROC-911031-02, NUDOCS 9112020059 | |
| Download: ML13325A986 (26) | |
Text
SONGS MANUAL OF EMERGENCY EVENTS TABLE OF CONTENTS TABLE F CONTENTS i
LIST OF FFECTIVE PAGES iii REVISION R CORD iv FOREWORD v
- 1.
Introducti to the SONGS Nuclear React s
I-1 Reactor Cool nt System 1-2 Pressurizer 1-3 Secondary Syste 1-4 Protective Barrie s 1-5 Safety Injection S stem 1-7 Residual Heat Remova System 1-8 Chemical and Volume C ntrol System 1-9 Electrical Support Syst m I-10 Radioactive Waste Dispos 1 System Unit 1 1-12 Units 2 and 3 1-13 Figures 1-1 to 1-19 II. Background Infor ation About Rad'ation II-1 Makeup of M terial II-1 Table II-1. Radioactive Decay fo a
One Hour Half-Life 11-2 Radioa ive Materials in Nuclear Re tors 11-4 Measu ing Radiation 11-5 Rev. 2.02 I
/1/89
SONGS MANUAL OF EMERGENCY EVENTS TABLE OF CONTENTS (continued)
PAGE III. Biological Effects of Radiation III-1 Introduction III-1 Nature of Radiation Biology III-1 Prompt Health Effects (Non-Stochastic) 111-2 Late Health Effects (Stochastic) 111-3 Carcinogenic Effects 111-3 Genetic Effects 111-4 Risk Estimates 111-5 Somatic Risks from Nuclear Power Operation 111-6 Radiation Protection Guidance 111-6 Philosophy of Radiation Protection 111-7 Table III-1: Effects of Ionizing Radiation 111-9 Table 111-2: Biological.Significance of External Radiation Levels III-10 Glossary of Radiological Terms 111-12 IV. Emergency Events IV-1 IV-1 Unusual Event IV-2 IV-2 Alert IV-24 IV-3 Site Area Emergency IV-47 IV-4 General Emergency IV-65 Rev.
2.02 ii 12/1/89
SONGS MANUAL OF EMERGENCY EVENTS LIST OF EFFECTIVE PAGES PAGE REV PAGE REV PAGE REV i
2 111-12 2
IV-36 2
ii 2
111-13 2
IV-37 2
iii 2
111-14 2
IV-38 2
iv 2
IV-39 2
v 2
IV-40 2
vi 2
IV-41 2
IV-42 2
IV-43 2
1-1 2
IV-1 2
IV-44 2.02 1-2 2
IV-2 2
IV-45 2.02 1-3 2
IV-3 2
IV-46 2
1-4 2
IV-4 2
IV-47 2
1-5 2
IV-5 2
IV-48 2
1-6 2
IV-6 2
IV-49 2
1-7 2
IV-7 2
IV-50 2
1-8 2
IV-8 2
IV-51 2
1-9 2
IV-9 2
IV-52 2
1-10 2
IV-10 2
IV-53 2
I-11 2
IV-11 2
IV-54 2
1-12 2
IV-12 2
IV-55 2
1-13 2
IV-13 2
IV-56 2
1-14 2
IV-14 2.01 IV-57 2
IV-15 2
IV-58 2
IV-16 2
IV-59 2
11-1 2
IV-17 2
IV-60 2
11-2 2
IV-18 2
IV-61 2
11-3 2
IV-19 2.03 IV-62 2
11-4 2
IV-20 2.03 IV-63 2.02 11-5 2
IV-21 2.01 IV-64 2
11-6 2
IV-22 2.01 IV-65 2
IV-23 2
IV-66 2
IV-24 2
IV-67 2
111-1 2
IV-25 2
IV-68 2
111-2 2
IV-26 2
IV-69 2
111-3 2
IV-27 2
IV-70 2
111-4 2
IV-28 2
IV-71 2
III-5 2
IV-29 2
IV-72 2
111-6 2
IV-30 2
IV-73 2
111-7 2
IV-31 2
IV-74 2
111-8 2
IV-32 2
IV-75 2
111-9 2
IV-33 2
IV-76 2
111-10 2
IV-34 2
IV-77 2
11 -11 2
IV-35 2
IV-78 2.02 IV-79 2
Rev. 2.03 111 7/9/90
SONGS MANUAL OF EMERGENCY EVENTS TABLE OF CONTENTS PAGE TABLE OF CONTENTS i
LIST OF EFFECTIVE PAGES iii REVISION RECORD iv FOREWORD v
I. Introduction to the SONGS Nuclear Reactors I-1 Reactor Coolant System 1-2 Pressurizer 1-3 Secondary System 104 Protective Barriers 105 Safety Injection System 1-7 Residual Heqt Removal System I-8 Chemical and Volume Control System 1-9 Electrical Support Systems I-10 Radioactive Waste Disposal System Unit 1 1-12 Units 2 and 3 1-13 Figures 1-1 to 1-19 1-15 II. Background Information About Radiation 11-1 Makeup of Material II-1 Table 1:
Radioactive Decay for a One Hour Half-Life 11-2 Radioactive Materials in Nuclear Reactors 11-4 Measuring Radiation 11-5
' Rev. 2.04 10/91
SONGS MANUAL OF EMERGENCY EVENTS TABLE OF CONTENTS (continued)
PAGE III.
Biological Effects of Radiation III-1 Introduction III-1 Nature of Radiation Biology III-1 Prompt Health Effects (Non-Stochastic) 111-2 Late Health Effects (Stochastic) 111-3 Carcinogenic Effects 111-3 Genetic Effects 111-4 Risk Estimates 111-5 Somatic Risks from Nuclear Power Operation 111-6 Radiation Protection Guidance 111-6 Philosophy of Radiation Protection 111-7 Table III-1:
Effects of Ionizing Radiation 111-9 Table III-2:
Biological Significance of External Radiation Levels III-10 Glossary of Radiological Terms 111-12 IV. Emergency Events Iv-1 IV-1 Unusual Event IV-2 IV-2 Alert IV-24 IV-3 Site Area Emergency IV-47 IV-4 General Emergency IV-65 Rev 2.04 ii 10/91
SONGS MANUAL OF EMERGENCY EVENTS LIST OF EFFECTIVE PAGES PAGE REV.
PAGE REV.
PAGE REV.
i 2.04 111-12 2
IV-36 2
ii 2.04 111-13 2
IV-37 2
iii 2.04 111-14 2
IV-38 2
iv 2.04 IV-39 2
v 2
IV-40 2
vi 2
IV-41 2
IV-42*
2 IV-43 2
I-1 2
IV-1 2
IV-44 2.02 1-2 2
IV-2 2
IV-45 2.02 1-3 2
IV-3 2
IV-46 2
1-4 2
IV-4 2
IV-47 2
1-5 2
IV-5 2
IV-48 2
1-6 2
IV-6 2
IV-49 2
1-7 2
IV-7 2
IV-50 2
1-8 2
IV-8 2
IV-51 2
1-9 2
IV-9 2
IV-52 2
1-10 2
IV-10 2
IV-53 2
I-11 2
IV-11 2
IV-54 2
1-12 2
IV-12 2
IV-55 2
1-13 2
IV-13 2
IV-56 2
1-14 2
IV-14 2.01 IV-57 2
1 33 2
IV-15 2
IV-58 2
IV-16 2
IV-59 2
II-1 2
IV-17 2
IV-60 2
11-2 2
IV-18 2
IV-61 2
11-3 2
IV-19 2.03 IV-62 2
11-4 2
IV-20 2.03 IV-63 2.02 11-5 2
IV-21 2.01 IV-64 2
11-6 2
IV-22 2.01 IV-65 2
IV-23 2
IV-66 2
III-1 2
IV-24 2
IV-67 2
111-2 2
IV-25 2
IV-68 2
111-3 2
IV-26 2
IV-69 2
111-4 2
IV-27 2
IV-70 2
111-5 2
IV-28 2
IV-71 2
111-6 2
IV-29 2
IV-72 2
111-7 2
IV-30 2
IV-73 2
111-8 2
IV-31 2
IV-74 2
111-9 2
IV-32 2
IV-75 2
111-10 2
IV-33 2
IV-76 2
11-11 2
IV-34 2
IV-77 2
IV-35 2
IV-78 2.02 IV-79 2
Rev.
2.04 10/91 111
SONGS MANUAL OF EMERGENCY EVENTS REVISION RECORD DATE REVISION #
DESCRIPTION ENTERED INITIALS REV. 0 Initial Issue SONGS Unit 1 Manual of Emergency Events REV. 0.01 Combined SONGS Uni ts 1,2,& 3 Manual of Emergency Events REV. 1 Issued as separate document from SONGS Emergency Plan REV. 1.01 Incorporate revisions to Station EPIPs and correct typos.
REV. 2 Incorporate revisions to Station EPIPs.
REV. 2.01 Incorporate revisions to Station EPIPs (codes 01-5, F1-1, G1-1, G1-2, F2-1, F3-1 and F4-1).
REV. 2.02 Incorporate revisions to Station EPIPs (codes Fl-1, F2-1, F3-1 and F4-1).
REV. 2.03 Revise Fl-1 in response to NRC concerns.
Rev. 2.03 iv 7/9/90
AM N LTN-
I --- ----MP-DLTO 0
L D
I TURBINE GENERATORS 4
DIESEL GENERATORSAILCA 6~
~ COTO3OM I A UXILIAR BLD G-2 FIGURE 1-1 AREA MAP
A u2 p CL 0
n Ln ow a
FIGURE 1-2 SITE PLAN
TRANSMISSION CONTAINMENT LINES ENCLOSURE STEAM SAFETY SAFETY SPRA
@9VLEAUTO STEAM DUMP (GRELIEF VALVE
@(ATMOSPHERE)
PRESSURIZER P PA REACTOR@
HEAD KOCEAN REACTORHIHPESR VESSEL TRIETR ICLTN COREFIGRE 1
S REACTOR POWER PLAN
@PRESSURE RELIEF PUMP PCII TANK STEAM LOCKIN VALVEE MANUA HOG A IGH PRWESRE LALONPESUR
CONTROL ROD DRIVE MECHANISMS VESSEL HEAD INLET OUTLET COLD LEG HOT LEG CORE 1n 4 o MAIN FLOW NOTE:
WATER FLOWS INTO THE VESSEL AROUND THE OUTSIDE OF THE CORE TO THE BOTTOM OF THE VESSEL, UP THROUGH THE CORE, PICKING UP HEAT; THEN OUT OF THE VESSEL.
FIGURE 1-4 REACTOR VESSEL
P ORV a*----
ISOLATION VALVES
- PORV SPRAY VALVES-FROM COLD LEG SAFETY OF PRIMARY RELIEFS SCOOLANT SYSTEM TO PRESSURIZER RELIEF TANK STE AM BL ANKE T PRIMARY WATER HEATERS NOTE: PORVS ARE ONLY ON SONG-1 PLANT SURGE LINE TO & FROM HOT LEG PRIMARY COOLANT SYSTEM FIGURE 1-5 PRESSURIZER
D 0_0 00 STEAM TO TURBINE DO DO 30 MOISTURE SEPARATORS 300 0 0 00000 o 0 000og go o
~og g go a 0~
0 o0
~O MOISTURE S...-
STEAM 0
0 0o0 oo g 0
1googg 0 -0ow 000000000000 0 00 0 00
~0000 000 0000 000000 00000 3
O 00000 0
~0000000000000 0 00go0 D
000000
....- SECONDARY WATER
-~---
FEEDWATER STUBE BUNDLES
..-*PRIMARY WATER FRO RLEGO INLET OUTLETkDI A
REACO FIGURE 1-6 STEAM GENERATOR
REFUELING WATER MOTOR CONTROL VALVE STORAGE TANK FEEDWATER/1
-i PMPSPuMPs 2
240000 GalIons LOOP A M
COLD LEGS-
-LOOP B 1
7 M
-LOOP C
FIGURE 1-7 SAFETY INJECTION SYSTEM (SIS)
SONGS 1
- MOTOR CONTROL VALVE REFUELING WATER STORAGE TANK M
COLD LEGS LOOP B
-LOOP C
7 FIGURE 1-8
-LOOP D
-SAFETY INJECTION SYSTEM (SIS)
SONGS 2&3
RESIDUAL HEAT EXCHANGERS RHR PUMPS M
M MOTOR CONTROL VALVE FIGURE 1-9 RESIDUAL HEAT REMOVAL SYSTEM (RHR)
O TEMPERATURE CONTROL VALVE COMPONENT RESIDUAL HEAT COOLINGI EXCHANGER STR(EGASET/W
/0LD LEGED IO REGENATIVER FTEMPERATUR C H E M L A D VVOLUME CONTROL TANK COLD LEG HEAT EXCHANGER BOR80 ACI TAN CHARGING PUMP PRESSURIZER 7MOTOR
'\\
CONTROL M VALVE FROM REFUELING WATER gSTORAGE TANK FIGURE 1-10 CHEMICAL AND VOLUME CONTROL SYSTEM
LEGEND:
NEW
""*SPACE ASSIGNED FOR FUTURE USE El CONTROL BREAKER BUS 9
1 8 17-UNIT 3 AUX TRANSFORMER SO 3 TURBINE SDG & E 3-GENERATOR I12
.. 1 1 10 SCE
- h
- u**
9 SO 2 TURBINE 7-GENERATOR 6
UNIT 2 AUX.
4-TRANSFORMER 3-UNIT 1 AUX TRANSFORMER SO 1 TURBINE BAY NO.
GENERATOR NOTE: ONLY ONE OF TWO BUSES SHOWN FIGURE 1-11 SWITCHYARDS DIAGRAM
<SWITCHYARD TO CONSUMER MAIN TRANSFORMER PILANT GENERATOR.
EMERGE NCY DIESEL 4160V 4160V SWITCHBOARD S4160V 4160V SWITCHBOARD FIGURE 1-12 ELECTRICAL SYSTEM (PLANT SHUTDOWN)
TYPICAL.
NOTE: OVERLAY INDICATES ACTIVE PORTION OF SYSTEM
EMERGENCYj DIESEL 800 iggw
.M.-
i~
.4.1T
~
EMERGENCY FIGURE 1-13 ELECTRICAL SYSTEM (PLANT OPERATING)
TYPICAL NOTE: OVERLAY INDICATES ACTIVE PORTION OF SYSTEM
SWITCHYARD TO CONSUMER MAIN TRANSFORMER GNRTOR EMERGENCY 4160V DIESEL SWITCHBOARD 40 480V SWITCHBOARD 4160V 4160V SWITCHBOARD
- T O
BATTERY T4Y60V NT E:
CHARGER 4160V FS W
CHTYEAT 4160VYAR SWTCBORDSWTCBOR 41480V 41480V EMERGENCY SWITCHBOARD DIESEL elGURE 1-14 ELECTRICAL SYSTEM (EMERGENCY BATTERY)
TYPICAL NOTE:0OVERLAY INDICATES ACTIVE PORTION OF SYSTEM
SWITCHYARD TO CONSUMER MAIN TRANSFORMER PLANT GENERATOR ELCRCLSSE EMERGENCY41ESEL 4160V 4160V SWITCHBOARD 4160V BTEY C
AUX 4160V.
FROM 416VI SWIITCHAR ARD...
4160V 4. OVH80ARD.
FIGURE 1-15 ELECTRICAL SYSTEM (EMERGENCY DIESEL)
TYPICAL NOTE:0OVERLAY INDICATES ACTIVE PORTION OF SYSTI
GAS DISCHARGE HEADER T MAIN GAS STACK COLLECTION HEADER SWASTE GAS LIQUID 2
AS SURGE TANK RADIOACTIVE FLAS WASTE TANK TO GAS SYSTEM LIQUID RADIOACTIVE FLSH HOLDING TANK TANK
-(ONE OF THREE)
PUMP TO GAS SYSTEM HOLDING TANK COOLING WATER ION EXCHANGER UM (ONE OF FOUR)
- .*.*GAS
- STRIPPER SPENT RESIN FLUSH5 MSTRP MONTOR CIRSULA NNTERLOCK
--- ---- I DISPOSABLE 1
FILTER WAE.U..VCIRCWATER FIGUR 1-16 MONITOR TANK 1:
.:.NT..R/MOPUM (ONE OF TWO) 9 0
$NELC IRADIATION MONITOR RADIATION sTO INTERLOCK/SO AV MONITOR 8
VALVE CIRCULATING WATER SYSTEM TANK PUMP CIRCULATING TO INTERLOCK WATER PUMP (DVALVE FIGURE 1 -16 RADIOACTIVE WASTE DISPOSAL SYSTEM SONGS 1
GAS MONITORS MAIN GAS DICHARGESTACK FROM FUEL BUILDING HASDDISCHARGE GA STRPER UG R1OLDING NITROGEN TANK VENT*
M TA*K
~@
- FIGURE.1-17 CRYOGENIC
.I.PO
@S TREATMENT S (CVI UNIT)FITR NITROGEN COOLING.
GAS STORAGE TANK (ONE OF THREE)
DERTION ARGE GANK FROM GAS STRIPPER, FLASH TANK &GA MONITOR TANK 10GAS COMPRESSOR FIGURE 1-17 RADIOACTIVE WASTE DISPOSAL SYSTEM SONGS 1
RAIOACTIVE WASTE LIQUID RADIOACTIVE HOLDING TANK 0
TO GAS SYSTEM FILTER COOLING WATER ION EXCHANGER HOLDING
- * *TANK PUMP (ONE OF TWO)
STRIPPER (ONE OF TWO)
SPENT RESIN FLUSH TO GAS SYSTEM RADIOACTIVE HOLDING TANK ION EXCHAN4GER(OEFFUR R(ONE OF TWO) 69 NEO RADIOACTIVE IN WA T N DIPOSLM YSP SGAS STEM T
- GAS 9
INEROC RAD00TIOVE HOLDINGIN TANKR PUMP GASE SYSTMAV SPENTURESI 7-18 RADOATIVWSTEDIP RADIAYTION0M SOMOITO 2&3
MAIN STACK*->
FROM FUEL
-BUILDING GAS DISCHARGE HEADER 9
6e FROM 16GAS HOLDING MONITORS TANK MONITOR**
FAN RADIATION*
MONITOR FILTERS 300000000000000 30000000000000c c ooooooooooooo GA TRAETN OOOOOOOOOOOaOOC L00000000000000 GAS STORAGE TANK 0000000000000O<
00000000000000
)0000000000000 00000000000000
)OOOOOOOOOOOOOC GAS WASTE GAS COLLECTION SURGE TANK HEADER FROM GAS STRIPER 12GAS COMPRESSOR
..4,.(ONE OF TWO)
MONITOR IONS FIGURE 1-19 RADIOACTIVE WASTE DISPOSAL SYSTEM SONGS 2&3