L-2015-160, WCAP-17939-NP, Revision 0, Analysis of Capsule 97 Degrees from the Florida Power & Light Company St. Lucie, Unit 2, Reactor Vessel Radiation Surveillance Program, Part 2 of 3
Text
Westinghouse Non-Proprietary Class 3 A-1 APPENDIX A VALIDATION OF THE RADIATION TRANSPORT MODELS BASED ON NEUTRON DOSIMETRY MEASUREMENTS A.1 NEUTRON DOSIMETRY Comparisons of measured dosimetry results to both the calculated and least-squares adjusted values for all surveillance capsules withdrawn from service to date at St. Lucie Unit 2 are described herein. The sensor sets from these capsules have been analyzed in accordance with the current dosimetry evaluation methodology described in Regulatory Guide 1.190, "Calculational and Dosimetry Methods for Determining Pressure Vessel Neutron Fluence" [Reference A-1]. One of the main purposes for presenting this material is to demonstrate that the overall measurements agree with the calculated and least-squares adjusted values to within +/- 20% as specified by Regulatory Guide 1.190, thus serving to validate the calculated neutron exposures previously reported in Section 6.2 of this report.A.1.1 Sensor Reaction Rate Determinations In this section, the results of the evaluations of the three surveillance capsules analyzed to date as part of the St. Lucie Unit 2 Reactor Vessel Materials Surveillance Program are presented.
The capsule designation, location within the reactor, and time of withdrawal of each of these dosimetry sets were as follows: Capsule Azimuthal Withdrawal Time Irradiation Time Location [EFPY]830 End of Cycle 1 1.11 2630 End of Cycle 9 11.07 970 End of Cycle 20 25.55 The passive neutron sensors- included in the evaluations of surveillance Capsules 83', 2630, and 970 are summarized as follows: WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-2 Reaction Of Capsule Capsule Capsule Sensor Material Interest 830 2630 970 Copper (Cd) 6 3 Cu(nu())6°Co X X X Titanium 4 6 Ti(n,p)4 6 Sc X X X Iron 5 4 Fe(n,p)5 4 Mn X X X Nickel (Cd) 5 8 Ni(n,p)5 8 Co X X X Uranium-238*
2 3 8 U(n,f)FP X X X Cobalt-Aluminum*
59C0(n Y)60 X X X Note:* The cobalt-aluminum and uranium monitors for this plant include both bare and cadmium-covered sensors.The capsules also contained sulfur monitors, which were not analyzed because of the short half-life of the activation product isotope (3 2 p, 14.3 days). Pertinent physical and nuclear characteristics of the passive neutron sensors analyzed are listed in Table A-1.The use of passive monitors such as those listed above do not yield a direct measure of the energy-dependent neutron fluence rate at the point of interest.
Rather, the activation or fission process is a measure of the integrated effect that the time- and energy-dependent neutron fluence rate has on the target material over the course of the irradiation period. An accurate assessment of the average neutron fluence rate level incident on the various monitors may be derived from the activation measurements only if the irradiation parameters are well known. In particular, the following variables are of interest:* the measured specific activity of each monitor,* the physical characteristics of each monitor,* the operating history of the reactor, a the energy response of each monitor, and* the neutron energy spectrum at the monitor location.The radiometric counting of the sensors from Capsule 970 was carried out by Pace Analytical Services, Inc. The radiometric counting followed established ASTM procedures.
The irradiation history of the reactor over the irradiation periods experienced by Capsules 830, 2630, and 970 was based on the monthly power generation of St. Lucie Unit 2 from initial reactor criticality through the end of the dosimetry evaluation period. For the sensor sets utilized in the surveillance capsules, the half-lives of the product isotopes are long enough that a monthly histogram describing reactor operation has proven to be an adequate representation for use in radioactive decay corrections for the reactions of interest in the exposure evaluations.
The irradiation history applicable to Capsules 830, 263', and 970 is given in Table A-2.WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-3 Having the measured specific activities, the physical characteristics of the sensors, and the operating history of the reactor, reaction rates referenced to full-power operation were determined from the following equation: A N o F Y Y P' Cj [1- e- t j] [e-Xt&J]Pref where: R = Reaction rate averaged over the irradiation period and referenced to operation at a core power level of Pref (rps/nucleus).
A = Measured specific activity (dps/g).No = Number of target element atoms per gram of sensor.F = Atom fraction of the target isotope in the target element.Y = Number of product atoms produced per reaction.Pi = Average core power level during irradiation period j (MW).Pref = Maximum or reference power level of the reactor (MW).C -= Calculated ratio of 4i(E > 1.0 MeV) during irradiation period j to the time weighted average f(E > 1.0 MeV) over the entire irradiation period.= Decay constant of the product isotope (1/sec).tj = Length of irradiation period j (sec).tdj = Decay time following irradiation period j (sec).The summation is carried out over the total number of monthly intervals comprising the irradiation period.In the equation describing the reaction rate calculation, the ratio [Pj]/[Pref]
accounts for month-by-month variation of reactor core power level within any given fuel cycle as well as over multiple fuel cycles. The ratio Cj, which was calculated for each fuel cycle using the transport methodology discussed in Section 6.2, accounts for the change in sensor reaction rates caused by variations in fluence rate level induced by changes in core spatial power distributions from fuel cycle to fuel cycle. For a single-cycle irradiation, Cj is normally taken to be 1.0. However, for multiple-cycle irradiations, the additional Cj term should be employed.
The impact of changing fluence rate levels for constant power operation can be quite significant for sensor sets that have been irradiated for many cycles in a reactor that has transitioned from WCAP- 1 7939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-4 non-low-leakage to low-leakage fuel management or for sensor sets contained in surveillance capsules that have been moved from one capsule location to another. The fuel-cycle-specific neutron fluence rate values along with the computed values for Cj are listed in Table A-3. These fluence rate values represent the capsule- and cycle-dependent results at the radial and azimuthal center of the respective capsules at core midplane.Prior to using the measured reaction rates in the least-squares evaluations of the dosimetry sensor sets, additional corrections were made to the 2 3 8 U cadmium-covered measurements to account for the presence of 2 3.U impurities in the sensors, as well as to adjust for the build-in of plutonium isotopes over the course of the irradiation.
Corrections were also made to the 2 3 8 U sensor reaction rates to account for gamma-ray-induced fission reactions that occurred over the course of the capsule irradiations.
The correction factors corresponding to the St. Lucie Unit 2 fission sensor reaction rates are summarized as follows: Correction Capsule 830 Capsule Capsule 970 2630 2 3 5 U Impurity/Pu Build- 0.8786 0.8459 0.8010 in 2 3 8 U(,,f) 0.8725 0.8757 0.8771 Net 2 3 8 U Correction 0.7666 0.7407 0.7026 The correction factors for Capsules 830, 2630 and 970 were applied in a multiplicative fashion to the decay-corrected cadmium-covered uranium fission sensor reaction rates.Results of the sensor reaction rate detenninations for Capsules 830, 263', and 970, are given in Table A-4.In Table A-4, the measured specific activities, decay-corrected saturated specific activities, and computed reaction rates for each sensor are listed. The cadmium-covered fission sensor reaction rates are listed both with and without the applied corrections for 2 3 5 U impurities, plutonium build-in, and gamma-ray-induced fission effects in the cases of Capsule 830 and 97'.A.1.2 Least-Squares Evaluation of Sensor Sets Least-squares adjustment methods provide the capability of combining the measurement data with the corresponding neutron transport calculations resulting in a best-estimate neutron energy spectrum with associated uncertainties.
Best-estimates for key exposure parameters such as fluence rate (E > 1.0 MeV)or dpa/s along with their uncertainties are then easily obtained from the adjusted spectrum.
In general, the least-squares methods, as applied to surveillance capsule dosimetry evaluations, act to reconcile the measured sensor reaction rate data, dosimetry reaction cross sections, and the calculated neutron energy spectrum within their respective uncertainties.
For example, R i +/-6 Ri ~(Cyig i p +/-~ )Qg 6 ,p g WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-5 relates a set of measured reaction rates, Ri, to a single neutron spectrum, kg, through the multigroup dosimeter reaction cross sections, c~ig, each with an uncertainty
- 5. The primary objective of the least-squares evaluation is to produce unbiased estimates of the neutron exposure parameters at the location of the measurement.
For the least-squares evaluation of the St. Lucie Unit 2 surveillance capsule dosimetry, the FERRET code [Reference A-2] was employed to combine the results of the plant-specific neutron transport calculations and sensor set reaction rate measurements to determine best-estimate values of exposure parameters (fluence rate (E > 1.0 MeV) and dpa) along with associated uncertainties for the three in-vessel capsules analyzed to date.The application of the least-squares methodology requires the following input: 1. The calculated neutron energy spectrum and associated uncertainties at the measurement location.2. The measured reaction rates and associated uncertainty for each sensor contained in the multiple foil set.3. The energy-dependent dosimetry reaction cross sections and associated uncertainties for each sensor contained in the multiple foil sensor set.For the St. Lucie Unit 2 application, the calculated neutron spectrum was obtained from the results of plant-specific neutron transport calculations described in Section 6.2 of this report. The sensor reaction rates were derived from the measured specific activities using the procedures described in Section A. 1.1.The dosimetry reaction cross sections and uncertainties were obtained from the SNLRML dosimetry cross-section library [Reference A-3]. The SNLRML library is an evaluated dosimetry reaction cross-section compilation recommended for use in LWR evaluations by ASTM Standard E1018,"Application of ASTM Evaluated Cross-Section Data File, Matrix E706 (IEB)" [Reference A-4].The uncertainties associated with the measured reaction rates, dosimetry cross sections, and calculated neutron spectrum were input to the least-squares procedure in the form of variances and covariances.
The assignment of the input uncertainties followed the guidance provided in ASTM Standard E944,"Application of Neutron Spectrum Adjustment Methods in Reactor Surveillance" [Reference A-5].The following provides a summary of the uncertainties associated with the least-squares evaluation of the St. Lucie Unit 2 surveillance capsule sensor sets.Reaction Rate Uncertainties The overall uncertainty associated with the measured reaction rates includes components due to the basic measurement process, irradiation history corrections, and corrections for competing reactions.
A high level of accuracy in the reaction rate determinations is ensured by utilizing laboratory procedures that conform to the ASTM National Consensus Standards for reaction rate determinations for each sensor type.WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-6 After combining all of these uncertainty components, the sensor reaction rates derived from the counting and data evaluation procedures were assigned the following net uncertainties for input to the least-squares evaluation:
Reaction Uncertainty 63Cu(nl,(,)6°Co 5%5 4 Fe(n,p)5 4 Mn 5%5 8 Ni(n,p)5 8 Co 5%4 6 Ti(n,p)4 6 Sc 5%2 3 8 U(n,f)FP 10%5 9 Co(n,y)6°Co 5%These uncertainties are given at the l level.Dosimetry Cross-Section Uncertainties The reaction rate cross sections used in the least-squares evaluations were taken from the SNLRML library. This data library provides reaction cross sections and associated uncertainties, including covariances, for 66 dosimetry sensors in common use. Both cross sections and uncertainties are provided in a fine inultigroup structure for use in least-squares adjustment applications.
These cross sections were compiled from recent cross-section evaluations, and they have been tested for accuracy and consistency for least-squares evaluations.
Further, the library has been empirically tested for use in fission spectra determination, as well as in the fluence and energy characterization of 14 MeV neutron sources.For sensors included in the St. Lucie Unit 2 surveillance program, the following uncertainties in the fission spectrum averaged cross sections are provided in the SNLRML documentation package.Reaction Uncertainty 6 3 Cu(nct)6 0 Co 4.08-4.16%
5 4 Fe(n,p)" 4 Mn 3.05-3.11%
5 8 Ni(n,p)5 8 Co 4.49-4.56%
4 6 Ti(n,p)4 6 5c 4.50-4.87%
2 3 8 U(n,f)1 3 7 Cs 0.54-0.64%
5 9 Co(n,y)6 0 Co 0.79-3.59%
These tabulated ranges provide an indication of the dosimetry cross-section uncertainties associated with the sensor sets used in LWR irradiations.
Calculated Neutron Snectrum WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-7 The neutron spectra inputs to the least-squares adjustment procedure were obtained directly from the results of plant-specific transport calculations for each surveillance capsule irradiation period and location.
The spectrum for each capsule was input in an absolute sense (rather than as simply a relative spectral shape). Therefore, within the constraints of the assigned uncertainties, the calculated data were treated equally with the measurements.
While the uncertainties associated with the reaction rates were obtained from the measurement procedures and counting benchmarks and the dosimetry cross-section uncertainties were supplied directly with the SNLRML library, the uncertainty matrix for the calculated spectrum was constructed from the following relationship:
Mgg, +Rg *Rgn *Pgg, where &1 specifies an overall fractional normalization uncertainty and the fractional uncertainties Rg and Rg, specify additional random groupwise uncertainties that are correlated with a correlation matrix given by: Pg9, =[1-0169g, +0eH where H (g-g')2 2y 2 The first term in the correlation matrix equation specifies purely random uncertainties, while the second term describes the short-range correlations over a group range y (0 specifies the strength of the latter term). The value of 6 is 1.0 when g = g', and is 0.0 otherwise.
The set of parameters defining the input covariance matrix for the St. Lucie Unit 2 calculated spectra was as follows: Fluence Rate Normalization Uncertainty (R 1) 15%Fluence Rate Group Uncertainties (Rg, Rg,)(E > 0.0055 MeV) 15%(0.68 eV < E < 0.0055 MeV) 25%(E < 0.68 eV) 50%Short Range Correlation (0)(E > 0.0055 MeV) 0.9 (0.68 eV < E < 0.0055 MeV) 0.5 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-8 (E < 0.68 eV) 0.5 Fluence Rate Group Correlation Range (y)(E > 0.0055 MeV) 6 (0.68 eV < E < 0.0055 MeV) 3 (E < 0.68 eV) 2 A.1.3 Comparisons of Measurements and Calculations Results of the least-squares evaluations of the dosimetry from the St. Lucie Unit 2 surveillance capsules withdrawn to date are provided in Tables A-5, A-6, and A-7 for Capsules 830, 2630, and 970, respectively.
In these tables, measured, calculated, and best-estimate values for sensor reaction rates are given for each capsule. Also provided in this tabulation are ratios of the measured reaction rates to both the calculated and least-squares adjusted reaction rates. These ratios of M/C and M/BE illustrate the consistency of the fit of the calculated neutron energy spectra to the measured reaction rates both before and after adjustment.
Additionally, comparisons of the calculated and best-estimate values of neutron fluence rate (E > 1.0 MeV) and iron atom displacement rate are tabulated along with the BE/C ratios observed for each of the capsules.For Capsule 2630, the cadmium-covered uranium monitor was discarded.
For all three capsules, both bare and cadmium-covered cobalt-aluminum monitors were discarded.
For Capsule 970, the copper monitor was discarded.
The data for these dosimetry reactions were discarded because they were outside the expected values. For all capsules, the bare uranium monitors were not included because the U-235 impurity content and the thermal fluence rate on the capsule are not known with enough accuracy to correct the measurement readings.The data comparisons provided in Tables A-5 through A-7 show that the adjustments to the calculated spectra are relatively small and well within the assigned uncertainties for the calculated spectra, measured sensor reaction rates, and dosimetry reaction cross sections.
Further, these results indicate that the use of the least-squares evaluation results in a reduction in the uncertainties associated with the exposure of the surveillance capsules.
From Section 6.4 of this report, the calculational uncertainty is specified as 13% at the 1cy level.Further comparisons of the measurement results with calculations are given in Tables A-8 and A-9. These comparisons are given on two levels. In Table A-8, calculations of individual threshold sensor reaction rates are compared directly with the corresponding measurements.
These threshold reaction rate comparisons provide a good evaluation of the accuracy of the fast neutron portion of the calculated energy spectra. In Table A-9, calculations of fast neutron exposure rates in terms of fluence rate (E > 1.0 MeV) and dpa/s are compared with the best-estimate results obtained from the least-squares evaluation of the capsule dosimetry results. These two levels of comparison yield consistent and similar results with all measurement-to-calculation comparisons falling well within the 20% limits specified as the acceptance criteria in Regulatory Guide 1.190.In the case of the direct comparison of measured and calculated sensor reaction rates, for the individual threshold foils considered in the least-squares analysis, the average M/C comparisons for fast neutron WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-9 reactions range from 0.77 to 1.24 in the data set. The overall average M/C ratio for the entire set of St. Lucie Unit 2 data is 1.07 with an associated standard deviation of 13.8%.In the comparisons of best-estimate and calculated fast neutron exposure parameters, the corresponding BE/C comparisons for the capsule data sets range from 0.96 to 1.09 for neutron fluence rate (E > 1.0 MeV) and from 0.97 to 1.09 for iron atom displacement rate. The overall average BE/C ratios for neutron fluence rate (E > 1.0 MeV) and iron atom displacement rate are 1.02 with a standard deviation of 6.4% and 1.03 with a standard deviation of 5.9%, respectively.
Based on these comparisons, it is concluded that the calculated fast neutron exposures provided in Section 6.2 of this report are validated for use in the assessment of the condition of the materials comprising the beltline region of the St. Lucie Unit 2 reactor pressure vessel.WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-10 Table A-I Nuclear Parameters Used in the Evaluation of Neutron Sensors 90%Reaction Atomic Weight Target Product Fission Response of A tomi Atom Half-life Yield Range(a)Interest [g/g-atomJ Fraction [days] [%] RneVa 6 3 Cu (na) 6 0 Co 63.546 0.6917 1925.5 n/a 4.53- 11.0 4 6 Ti (n,p) 4 6 Sc 47.867 0.0825 83.79 n/a 3.70 -9.43 5 4 Fe (n,p) 5 4 Mn 55.845 0.05845 312.11 n/a 2.27-7.54 5 8 Ni (n,p) 5 8 Co 58.693 0.68077 70.82 n/a 1.98 -7.51 2 3 8 U (n,f) 1 3 7 Cs 238.051 0.99958 10983.07 6.02 1.44-6.69 5 9 Co (n,y) 6 0 Co 58.933 0.0017 1925.5 n/a non-threshold Notes: (a) The 90% response range is defined such that, in the neutron spectrum characteristic of the St. Lucie Unit 2 surveillance capsules, approximately 90% of the sensor response is due to neutrons in the energy range specified with approximately 5% of the total response due to neutrons with energies below the lower limit and 5% of the total response due to neutrons with energies above the upper limit (Reference A-6).WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-]lI Table A-2 Monthly Thermal Generation during the First 20 Fuel Cycles of the St. Lucie Unit 2 Reactor Cycle 1 Cycle 2 Cycle 3 Cycle 4 Month MWt-h Month MWt-h Month MWt-h Month MWt-h Jun-83 77926.4 Nov-84 92205 Jun-86 1944000 Nov-87 44010 Jul-83 449305.6 Dec-84 1137132 Jul-86 1767420 Dec-87 1717686 Aug-83 1776204.8 Jan-85 1980612 Aug-86 1809675 Jan-88 2004831 Sep-83 712576 Feb-85 1732374 Sep-86 1805706 Feb-88 1876149 Oct-83 1759590.4 Mar-85 1668411 Oct-86 1940733 Mar-88 2005047 Nov-83 1896012.8 Apr-85 1208763 Nov-86 504603 Apr-88 1968381 Dec-83 1814732.8 May-85 1879416 Dec-86 1937385 May-88 1942731 Jan-84 1525376 Jun-85 1944000 Jan-87 2001213 Jun-88 1988577 Feb-84 1671398.4 Jul-85 1876581 Feb-87 1809918 Jul-88 1940463 Mar-84 1903718.4 Aug-85 636444 Mar-87 1839456 Aug-88 1996110 Apr-84 1843200 Sep-85 636471 Apr-87 1881387 Sep-88 1986417 May-84 1834828.8 Oct-85 1921941 May-87 1880118 Oct-88 1844235 Jun-84 1843200 Nov-85 1944000 Jun-87 2000862 Nov-88 1985391 Jul-84 1840819.2 Dec-85 1767420 Jul-87 1708263 Dec-88 1943757 Aug-84 1901286.4 Jan-86 1809675 Aug-87 1904904 Jan-89 2007369 Sep-84 1216230.4 Feb-86 1805706 Sep-87 1942947 Feb-89 185814 Oct-84 854195.2 Mar-86 1940733 Oct-87 224100 Mar-89 0 Apr-86 504603 May-86 0 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-12 Table A-2 (Continued)
Monthly Thermal Generation during the First 20 Fuel Cycles of the St. Lucie Unit 2 Reactor Cycle 5 Cycle 6 Cycle 7 Cycle 8 Month MWt-h Month MWt-h Month MWt-h Month MWt-h Apr-89 4104 Dec-90 1381455 Jun-92 55701 Apr-94 25758 May-89 1759914 Jan-91 2007180 Jul-92 1589409 May-94 1862433 Jun-89 1901313 Feb-91 1812861 Aug-92 1688445 Jun-94 1794069 Jul-89 1943163 Mar-91 2005695 Sep-92 2007072 Jul-94 1784862 Aug-89 1952694 Apr-91 2001969 Oct-92 1941273 Aug-94 1923669 Sep-8 9 1728081 May-91 1868535 Nov-92 1696059 Sep-94 2003265 Oct-8 9 1941246 Jun-91 1908360 Dec-92 1054836 Oct-94 1943055 Nov-89 1965789 Jul-91 1943352 Jan-93 973647 Nov-94 2010636 Dec-89 1919214 Aug-91 2008233 Feb-93 0 Dec-94 1878660 Jan-90 1190835 Sep-91 1965492 Mar-93 0 Jan-95 2007909 Feb-90 1804896 Oct-91 1900233 Apr-93 1715769 Feb-95 1615734 Mar-90 2008800 Nov-91 1975995 May-93 1509597 Mar-95 1938141 Apr-90 1992222 Dec-91 1918809 Jun-93 1998945 Apr-95 1965816 May-90 1856385 Jan-92 1962414 Jul-93 1792800 May-95 1937871 Jun-90 1985877 Feb-92 1848690 Aug-93 1754973 Jun-95 1973430 Jul-90 1922562 Mar-92 1931121 Sep-93 1724598 Jul-95 1844829 Aug-90 958149 Apr-92 1472364 Oct-93 1804491 Aug-95 1671489 Sep-90 1752894 May-92 0 Nov-93 1004832 Sep-95 1927206 Oct-90 121689 Dec-93 1311687 Oct-95 572130 Nov-90 0 Jan-94 2006586 Nov-95 0 Feb-94 995193 Dec-95 0 Mar-94 0 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A- 13 Table A-2 (Continued)
Monthly Thermal Generation during the First 20 Fuel Cycles of the St. Lucie Unit 2 Reactor Cycle 9 Cycle 10 Cycle 11 Cycle 12 Month MWt-h Month MWt-h Month MWt-h Month MWt-h Jan-96 1295973 May-97 322002 Dec-98 1401975 May-00 858465.1 Feb-96 1868589 Jun-97 1939032 Jan-99 2006856 Jun-00 1943271 Mar-96 1994166 Jul-97 2005398 Feb-99 1797417 Jul-00 2006586 Apr-96 1848393 Aug-97 2006181 Mar-99 2007720 Aug-00 1981287 May-96 1922103 Sep-97 1929528 Apr-99 1797660 Sep-00 1941219 Jun-96 1428354 Oct-97 2009340 May-99 2007612 Oct-00 2010096 Jul-96 1942704 Nov-97 1941597 Jun-99 1356642 Nov-00 1941921 Aug-96 2005317 Dec-97 2006748 Jul-99 2007504 Dec-00 2006181 Sep-96 1995354 Jan-98 2003292 Aug-99 2007585 Jan-01 2007261 Oct-96 1945269 Feb-98 1812483 Sep-99 1917378 Feb-01 1812942 Nov-96 2002158 Mar-98 1882791 Oct-99 2009772 Mar-01 1756107 Dec-96 1938546 Apr-98 1939329 Nov-99 1942218 Apr-01 1940490 Jan-97 1977102 May-98 1988064 Dec-99 2006181 May-01 2007801 Feb-97 1774494 Jun-98 1942623 Jan-00 2007072 Jun-01 1937790 Mar-97 2006451 Jul-98 2006694 Feb-00 1877823 Jul-01 2008044 Apr-97 1016928 Aug-98 2007585 Mar-00 2007747 Aug-01 2007774 Sep-98 1941327 Apr-00 1010070 Sep-01 1942704 Oct-98 2008260 Oct-01 2010582 Nov-98 491076 Nov-01 1600533 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-14 Table A-2 (Continued)
Monthly Thermal Generation during the First Eighteen Fuel Cycles of the St. Lucie Unit 2 Reactor Cycle 13 Cycle 14 Cycle 15 Cycle 16 Month MWt-h Month MWt-h Month MWt-h Month MWt-h Dec-01 277182 Jun-03 790587 Feb-05 777627 Jun-06 925398.1 Jan-02 2008071 Jul-03 2007288 Mar-05 2007314 Jul-06 2006667 Feb-02 1749789 Aug-03 2006612 Apr-05 1940409 Aug-06 2007584 Mar-02 2008395 Sep-03 1926774 May-05 2007747 Sep-06 1941543 Apr-02 1940706 Oct-03 2006667 Jun-05 1942083 Oct-06 1997082 May-02 2004723 Nov-03 1942947 Jul-05 2007936 Nov-06 1942110 Jun-02 .1943541 Dec-03 1418877 Aug-05 1920348 Dec-06 1949832 Jul-02 2008368 Jan-04 2007126 Sep-05 1943190 Jan-07 2007288 Aug-02 2006640 Feb-04 1849122 Oct-05 1737612 Feb-07 1813455 Sep-02 1943433 Mar-04 2007558 Nov-05 1943271 Mar-07 2003022 Oct-02 2011203 Apr-04 1940409 Dec-05 2007990 Apr-07 1942731 Nov-02 1943163 May-04 2007423 Jan-06 1639440 May-07 2006289 Dec-02 2006802 Jun-04 1943109 Feb-06 1812726 Jun-07 1942812 Jan-03 2007774 Jul-04 2007774 Mar-06 2007530 Jul-07 2007531 Feb-03 1813806 Aug-00 2007855 Apr-06 1430109 Aug-07 1154925 Mar-03 2004102 Sep-04 639359.9 May-06 0 Sep-07 1898883 Apr-03 923751 Oct-04 1745523 Oct-07 0 May-03 0 Nov-04 1943028 Nov-07 0 Dec-04 1572831 Dec-07 0 Jan-05 94068 WCAP-17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-15 Table A-2 (Continued)
Monthly Thermal Generation during the First 20 Fuel Cycles of the St. Lucie Unit 2 Reactor Cycle 17 Cycle 18 Cycle 19 Cycle20 Month MWt-h Month MWt-h Month MWt-h Month MWt-h Jan-08 1508382 Jun-09 1009449 May- 11 1232037 Nov-12 274034.8 Feb-08 1362879 Jul-09 931364.9 Jun-1 1 1850148 Dec-12 1950587 Mar-08 1986390 Aug-09 1962522 Jul-i1 2005262 Jan-13 2244886 Apr-08 1933362 Sep-09 644652 Aug-11 1833380 Feb-13 2027628 May-08 2003643 Oct-09 2006937 Sep-11 1941597 Mar-13 2241625 Jun-08 1671381 Nov-09 1939599 Oct-1 1 2006883 Apr-13 2172648 Jul-08 2006775 Dec-09 2006910 Nov-11 1942704 May-13 2180742 Aug-08 .2007018 Jan-10 1953072 Dec-11 2005452 Jun-13 1843589 Sep-08 1941435 Feb-10 1811997 Jan-12 1997703 Jul-13 2245007 Oct-08 2007180 Mar-10 2003454 Feb-12 1876635 Aug-13 2244826 Nov-08 1945026 Apr-10 1466208 Mar-12 2000322 Sep-13 2172648 Dec-08 2007153 May-10 2006478 Apr- 12 1939490 Oct- 13 2245038 Jan-09 2007099 Jun-10 1941786 May-12 1857437 Nov-13 1975986 Feb-09 1811403 Jul-10 1988685 Jun-12 1911330 Dec-13 2236491 Mar-09 1929609 Aug-10 2006612 Jul- 12 1655451 Jan-14 2240296 Apr-09 1446741 Sep-10 1907523 Aug- 12 207036 Feb-14 2027266 May-09 0 Oct- 10 2006262 Sep-12 0 Mar- 14 125964.2 Nov-10 1941003 Oct-12 0 Dec-10 2006478 Jan-11 83430.01 Feb-11 0 Mar-11 0 Apr-11 0 WCAP-17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-16 Table A-3 Surveillance Elevation Capsule Fluence Rate for Cj Factors Calculation, Core Midplane Cycle > 1.0 MeV) [n/cm 2sl Fuel Cycle Length Capsule 830 Capsule 2630 Capsule 970 1 1.11 3.99E+ 10 3.99E+10 3.99E+ 10 2 1.12 3.74E+10 3.74E+10 3 1.22 3.37E+10 3.37E+10 4 1.16 2.48E+10 2.48E+10 5 1.3 2.45E+ 10 2.45E+10 6 1.35 2.41E+10 2.41E+10 7 1.21 2.60E+ 10 2.60E+ 10 8 1.38 1.60E+ 10 1.60E+10 9 1.22 2.44E+ 10 2.44E+10 10 1.44 2.59E+10 11 1.32 2.32E+10 12 1.51 2.27E+10 13 1.29 2.52E+10 14 1.43 2.21E+10 15 1.15 2.58E+10 16 1.25 2.66E+10 17 1.25 2.52E+10 18 1.42 2.46E+ 10 19 1.19 3.08E+10 20 1.23 3.l5E+10 Average (Cycle Length -3.99E+10 2.87E+10 2.79E+10 Weighted)WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-17 Table A-3 (Continued)
Surveillance Capsule Cj Factors Calculation, Core Midplane Elevation Cycle Ci Length Capsule Fuel Cycle [EFPY] Capsule 830 2630 Capsule 970 1 1.11 1.0 1.4 1.4 2 1.12 1.3 1.3 3 1.22 1.2 1.2 4 1.16 0.9 0.9 5 1.3 0.9 0.9 6 1.35 0.8 0.9 7 1.21 0.9 0.9 8 1.38 0.6 0.6 9 1.22 0.9 0.9 10 1.44 0.9 11 1.32 0.8 12 1.51 0.8 13 1.29 0.9 14 1.43 0.8 15 1.15 0.9 16 1.25 1.0 17 1.25 0.9 18 1.42 0.9 19 1.19 1.1 20 1.23 1.1 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A- 18 Table A-4a Measured Sensor Activities and Reaction Rates for Surveillance Capsule 830 Radially Corrected Target Product Measured Corrected Reaction Reaction Corre tare Product Activity Saturated Rate Rate Reaction Isotope Isotope (dps/g)")
Activity (rps/atom) (rpsfatom)(dps/g) (rps/atom)
Cu-63 Co-60 6.07E+04 4.49E+05 6.85E-17 Cu-63 Co-60 6.59E+04 4.88E+05 7.44E- 17 Cu-63 Co-60 6.48E+04 4.80E+05 7.32E- 17 7.20E- 17 7.20E- 17 Ti-46 Sc-46 1.02E+06 1.13E+06 1.09E- 15 Ti-46 Sc-46 9.22E+05 1.03E+06 9.87E-16 Ti-46 Sc-46 9.08E+05 1.01E+06 9.72E-16 1.02E-15 1.02E-15 Fe-54 Mn-54 2.06E+06 3.57E+06 5.67E- 15 Fe-54 Mn-54 2.15E+06 3.73E+06 5.91E-15 Fe-54 Mn-54 2.08E+06 3.61E+06 5.72E-15 5.77E-15 5.77E-15 Ni-58 Co-58 4.88E+07 5.37E+07 7.68E-15 Ni-58 Co-58 4.79E+07 5.27E+07 7.54E-15 Ni-58 Co-58 4.78E+07 5.26E+07 7.52E-15 7.58E-15 7.58E-15 U-238 Cs-137 7.22E+04 2.86E+06 1.88E-14 U-238 Cs-137 7.51E+04 2.97E+06 1.95E-14 U-238 Cs-137 5.70E+04 2.26E+06 1.48E-14 1.77E-14 1.36E-14 Note: 1. Measured activity decay corrected to October 12, 1984 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-19 Table A-4b Measured Sensor Activities and Reaction Rates for Surveillance Capsule 263'Radially A Corrected Measured Corrected Reaction Reaction Average Target Product Activity Saturated Rate Reaction Rato Isotope Isotope Actiy AStiaityurpt Rate Rate (dps/g)Ati (rps/atom) (rps/atom)
Rate (dps/g) (rps/atom)
Cu-63 Co-60 1.91E+05 3.42E+05 5.22E-17 Cu-63 Co-60 1.78E+05 3.19E+05 4.86E- 17 Cu-63 Co-60 1.83E+05 3.28E+05 5.OOE-17 5.03E-17 5.03E-17 Ti-46 Sc-46 8.45E+04 8.11E+05 7.81E-16 Ti-46 Sc-46 8.04E+04 7.72E+05 7.43E-16 Ti-46 Sc-46 7.89E+04 7.57E+05 7.30E-16 7.51E-16 7.51E-16 Fe-54 Mn-54 1.13E+06 2.74E+06 4.35E-15 Fe-54 Mn-54 1.09E+06 2.65E+06 4.20E- 15 Fe-54 Mn-54 1.06E+06 2.57E+06 4.08E-15 4.21E-15 4.21E-15 Ni-58 Co-58 2.74E+06 3.84E+07 5.50E-15 Ni-58 Co-58 2.63E+06 3.69E+07 5.28E-15 Ni-58 Co-58 2.58E+06 3.62E+07 5.18E-15 5.32E-15 5.32E-15 Note: 1. Measured activity, decay corrected to December 28, 1997 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-20 Table A-4c Measured Sensor Activities and Reaction Rates for Surveillance Capsule 970 Radially Average Corrected Target Product Measured Corrected Reaction Reaction Average Isotope Isotope Activity Saturated Rate Rate Reaction (dps/g)"'
Activity (rps/atom) (rps/atom)
Rate (dps/g) (rps/atom)_(rps/atom)
Cu-63 Co-60 4.86E+05 6.21E+05 9.47E- 17 Cu-63 Co-60 4.50E+05 5.75E+05 8.77E- 17 Cu-63 Co-60 4.43E+05 5.66E+05 8.63E- 17 8.96E- 17 8.96E- 17 Ti-46 Sc-46 1.55E+05 7.88E+05 7.60E-16 Ti-46 Sc-46 1.44E+05 .7.32E+05 7.06E-16 Ti-46 Sc-46 1.37E+05 6.97E+05 6.71E-16 7.12E-16 7.12E-16 Fe-54 Mn-54 1.61E+06 2.44E+06 3.87E-15 Fe-54 Mn-54 1.56E+06 2.36E+06 3.75E-15 Fe-54 Mn-54 1.54E+06 2.33E+06 3.70E- 15 3.77E-15 3.77E- 15 Ni-58 Co-58 4.98E+06 3.54E+07 5.07E-15 Ni-58 Co-58 4.81E+06 3.42E+07 4.90E-15 Ni-58 Co-58 4.89E+06 3.48E+07 4.98E-15 4.98E-15 4.98E-15 U-238 Cs-137 9.OOE+05 2.17E+06 1.42E-14 U-238 Cs-137 8.45E+05 2.03E+06 1.34E-14 U-238 Cs-137 9.01E+05 2.17E+06 1.42E-14 1.39E-14 9.79E-15 Co-59 Co-60 1.40E+08 1.79E+08 1.03E- 11 Co-59 Co-60 1.27E+08 1.62E+08 9.34E-12 Co-59 Co-60 1.14E+08 1.46E+08 8.38E-12 9.34E-12 9.34E-12 Co-59 2 Co-60 1.75E+07 2.24E+07 1.29E- 12 Co-59 2 Co-60 1.69E+07 2.16E+07 1.24E- 12 Co-59 2 Co-60 1.97E+07 2.52E+07 1.45E-12 1.33E-12 1.33E-12 Notes: I. Measured activity decay corrected to October 15, 2014 2. Cadmium covered WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-21 Table A-5 Least-Squares Evaluation of Dosimetry in Surveillance Capsule 830 (7-Degree Azimuth, Core Midplane)
Cycle 1 Irradiation Reaction Rate (rps/atom)
Reaction Measured Calculated Best- M/C M/BE BE/C (M) (C) Estimate (M) (c)(BE)Cu-63(n,a)Co-60 7.20E-17 5.61E-17 6.88E-17 1.28 1.04 1.23 Ti-46(n,p)Sc-46 1.02E-15 8.87E-16 1.03E-15 1.15 0.99 1.16 Fe-54(n,p)Mn-54 5.77E-15 5.12E-15 5.69E-15 1.13 1.01 1.11 Ni-58(n,p)Co-58 7.58E-15 6.69E-15 7.42E-15 1.13 1.02 1.11 U-238(n,f)Cs-137 1.36E-14 1.78E-14 1.85E-14 0.76 0.74 1.04 Average 1.09 0.96 1.13% standard deviation 17.9 12.9 6.2 Calculated Best-Integral Quantity (C) % Unc. Estimate % Unc. BE/C (BE)Fluence rate E > 1.0 MeV 3.99E+10 13 4.04E+10 6 1.01 (n/cmZ-s)Fluence rate E > 0.1 MeV 7.55E+10 -7.44E+10 9 0.98 (n/cm 2-s)dpa/s 5.74E- 11 13 5.88E- 11 6 1.02 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-22 Table A-6 Least-Squares Evaluation of Dosimetry in Surveillance Capsule 2630 (7-Degree Azimuth, Core Midplane)
Cycles 1 Through 9 Irradiation Reaction Rate (rps/atom)
Reaction Measured Calculated Best- M/C M/BE BE/C (M) (C) Estimate (M) (C)(BE)Cu-63(n,a)Co-60 5.03E-17 4.21E-17 4.91E-17 1.19 1.02 1.17 Ti-46(n,p)Sc-46 7.51E-16 6.57E-16 7.50E-16 1.14 1.00 1.14 Fe-54(n,p)Mn-54 4.21E-15 3.74E-15 4.20E-15 1.13 1.00 1.12 Ni-58(n,p)Co-58 5.32E-15 4.89E-15 5.43E-15 1.09 0.98 1.11 Average 1.14 1.00 1.14% standard deviation 3.6 1.6 .:2.3 Integral Calculated Best-Quantity (C) % Unc. Estimate % Unc. BE/C Quantiy (C)(BE)Fluence rate.E > 1.0 MeV 2.87E+10 13 3.13E+10 7 1.09 (n/cm 2-s)Fluence rate E > 0.1 MeV 5.41E+10 -5.82E+10 10 1.07 (n/cm 2-s)dpa/s 4.14E- 11 13 4.52E- 11 6 1.09 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-23 Table A-7 Least-Squares Evaluation of Dosimetry in Surveillance Capsule 970 (7-Degree Azimuth, Core Midplane)
Cycles 1 Through 20 Irradiation Reaction Rate (rps/atom)
Reaction Measured Calculated Best- MIC MIBE BE/C (M) (C) Estimate (M) (C)(BE)Ti-46(n,p)Sc-46 7.12E-16 6.43E-16 6.91E-16 1.11 1.03 1.07 Fe-54(n,p)Mn-54 3.77E-15 3.65E-15 3.75E-15 1.03 1.01 1.03 Ni-58(n,p)Co-58 4.98E-15 4.77E-15 4.91E-15 1.05 1.02 1.03 U-238(n,f)Cs-137 9.79E-15 1.25E-14 1.23E-14 0.78 0.79 0.99 Average 0.99 0.96 1.03% standard deviation 14.7 12.0 3.2 Best-CalculatedBet Integral Quantity (C) % Unc. Estimate % Unc. BE/C (C) (BE)Fluence rate E > 1.0 MeV 2.79E+10 13 2.71E+10 6 0.96 (l/Cm 2-s)Fluence rate E > 0.1 MeV 5.26E+10 -5.01E+10 9 0.95 (n/cm 2-s)dpals 4.03E- 11 13 3.93E- 11 6 0.97 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-24 Table A-8 Comparison of Measured/Calculated (M/C) Sensor Reaction Rate Ratios for Fast Neutron Threshold Reactions Capsule 63 46 54 8M/c Cpu 6Cu(n,) 4Ti(n,p) Fe(n,p) SNi(n,p) U(n,f)830 1.28 1.15 1.13 1.13 0.76 2630 1.19 1.14 1.13 1.09 -970 -1.11 1.03 1.05 0.78 Average 1.24 1.13 1.10 1.09 0.77%Standard 5.2 1.8 5.3 3.7 1.8 Deviation Average 1.07% Standard 13.8 Deviation Table A-9 Comparison of Best-Estimate/Calculated (BE/C) Exposure Rate Ratios BE/C Capsule Neutron Fluence Rate (E> 1. MeV)Iron Atom Displacement Rate (E > 1.0 MeV)830 1.01 1.02 2630 1.09 1.09 970 0.96 0.97 Average 1.02 1.03% Standard deviation 6.4 5.9 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 A-25 A.2 REFERENCES A-1 U.S. Nuclear Regulatory Commission Regulatory Guide 1.190, Calculational and Dosimetr, Methods for Determining Pressure Vessel Neutron Fluence, March 2001.A-2 A. Schmittroth, FERRET Data Analysis Core, HEDL-TME 79-40, Hanford Engineering Development Laboratory, Richland, WA, September 1979.A-3 RSICC Data Library Collection DLC-178, SNLRML Recommended Doshnetry Cross-Section Compendium, July 1994.A-4 ASTM Standard E1018-09 (Reapproved 2013), Standard Guide for Application of ASTM Evaluated Cross Section Data File, Matrix E706 (JIB), 2014.A-5 ASTM Standard E944-13, Standard Guide for Application of Neutron Spectrum Adjustment Methods in Reactor Surveillance, E 706 (11A), 2014.A-6 ASTM Standard E844-09, Standard Guide for Sensor Set Design and Irradiation for Reactor Surveillance, E 706 (IIC), 2014.WCAP- 17939-NP May 2015 WCAP-17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-1 APPENDIX B LOAD-TIME RECORDS FOR CHARPY SPECIMEN TESTS* "IXX" denotes Intermediate Shell Plate M-605-1, longitudinal orientation
- "2XX" denotes Intermediate Shell Plate M-605- 1, transverse orientation
- "3XX" denotes weld material* "4XX" denotes heat-affected zone material Note that the instrumented Charpy data is not required per ASTM Standards E 185-82 or E23-12c.WCAP- 17939-NP May 2015 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-2 Load-1 25.66 Ib Time-1 -0.75 ms 5O0 400 300 20C 10C 00.00 10.00 10.00 i0.00-~~~L (I~AAIJ A AOAA.4 A A oAA..AA,.
A. AAA &a.sep.A..
A.&0.00 1.00 2.00 3.00 Time-1 (ms)15D: Tested at 70 0 F Time-i -0.72 ms 4.00 5.00 6.00 Load-1 21-94 lb 5000.00 4000.00 3000.00 2000.00 1000.00 k hO 1 A A hM A -,A&. --A -A. A- A I-I , I I I A, mý , 0.00 1.00 2.00 3.00 Time-I (ms)14M: Tested at 95°F 4.00 5.00 6.00 5000.00f 4000.00 3000.00 2000.00 1000.00 J A n M A hAm j. N -A IIA. A. AA. &A., A.& A M A 0.00 1.00 200 3.00 Time-1 (ms)124: Tested at 110OF 4.00 5.00 6.00 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-3 Load-i 329.07 lb lime-1 0.85 ms 5000.00 4000.00 3000.00 2000.00 1000.00 0.0 1 .. ., Oh 0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-i (ms)liD: Tested at 120OF Load-1 36.65 lb Time-1 -0.75 ms 5000.00 4000.00 3000.00 o2 1000.00 0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-i (ms)14D: Tested at 140OF Load-i 36.65 lb Tire-1 -0.75 ms 5000.00 4000.00'7 3000.00-0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-i (ms)13K: Tested at 1501F WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-4'73000.W PII 2000.00 1000.00 0.00 0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-1 (ms)117: Tested at 170'F 5000.00 4000.00'7 3000,00 2000.00 1000.00 0.00 0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-1 (ins)13C: Tested at 200OF 5000 .00 4000.00'7 3000.00 2000 .00 1000.00 0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-1 (ins)143: Tested at 200OF WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-5 Load-1 36.53 lb Time-1 -0.75 ms 8.J 5000.00 4000.00 3000.00 2000.00 1000.00 0.00 0.0 0 1.00 2.00 3.00 Time-1 (ms)15J: Tested at 260'F 4.00 5.00 6.00 5000.(4000.('7 3000.(Time-1 (ms)12B: Tested at 300'F Time-I -0 72 m.Load-1 10.97 lb 5000.00 4000.00'7 3000.00 20 2000.00 1000.00 N nJ nnJ I i i i i -..T ...0.00 1.00 2.00 3.00 Time-1 (ms)127: Tested at 375°F 4.00 5.00 6.00 WCAP- 17939-NP May 2015 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-6 0.00 1.00 2.00 3.00 4.00 5.00 Time-1 (ms)21B: Tested at 70'F 6.00 500 400 300 200 100 0.00 3.00 0.00" 0.00 0 0fflIL 2~~d4~Ak 4 JA.s AI.4~&M p A. NM 4 f A-. N 0.00 1.00 2.00 3.00 Time-i (ms)22K: Tested at 95°F 400 5.00 6.00 5000.00 4000.00 3000.00 2000.00 1000.00 0.00 1.00 2.00 3.00 4.00 5.00 Time-i (ms)24M: Tested at 120'F 6.00 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-7 5000.00 4000.00 o, 3000.00 AAA&A1~ At.M ~ AA.ILL& A..e..u. a 2000.00 1000.00^^^JOW A AA A AA Pm A k A ..nn I I .. .A .-4. 1 --.--0.00 1.00 2.00 3.00 Time-1 (ms)25D: Tested at 140OF 4.00 5.00 6.00"7 Time-i (ms)24P: Tested at 150°F 3'7 0 1 0.00 1.00 2.00 3.00 4.00 5.00 Time-i (ms)26E: Tested at 170'F 6.00 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-8 Load-I 1463 lb Time-I -fl 75 mc Time-1 -0 75 rns 5000.00 4000.00 3000.00 2000.00 1000.00 r AiuA'j ALLIA IA. IALL.# IAL hA*I.A-.Le L Pk ufiq -Aý m 0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-1 (ms)21U: Tested at 2001F 0.00 1.00 2.00 3.00 4.00 5.00 Time-1 (ms)21Y: Tested at 200OF 6.00 2.00 3.00 Time-i (ins)25M: Tested at 230°F 6.00 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-9 5000.00-4000.00'7 3000.00 2000.00 1000.00 1 30.00 0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-1 (ms)23A: Tested at 2701F 5000.00 4000.00 3000.00 2000.00 1000.00 0.00 .......0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-i (ms)21D: Tested at 3001F 5000.00 4000.00 3000.00 2000.00 1000.00 0,001 .. A .. ' &.A-0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-1 (ms)263: Tested at 3751F WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-10 Load-1 21.95 Ib Time-1 -0.75 ms 5000.00 4000.00 3000.0 2000.00 1000.00 I~fttfLA~lI~.A..A~iJ+/-
1.A ARA.AAAAA. ) A.. .nfln t ...................
d ....... a ..........
........................
............
.... ..... .U .UU , ..0.00 1.00 2.00 3.00 Tine-i (ms)36E: Tested at -60'F 4.00 5.00 6.00 5000.00 4000.00 3000.00 2000.00 000.00--- I i ^eL .. AA .. .-,-- L .----h q .-.-., 0.00 Lo 5000.00 4000.00 3000.00 2000.00 1000.00 1.00 2.00 3.00 Time-1 (ms)34U: Tested at -40'F Time-1 -0.75 ms 4.00 5.00'ad-1 40.26 Ib s.00 I6AJ k &A ,A A1 L.i A ,~ A~i/ LAtA &A, IAA, .A 4_A , -O &,A n.k 00l nI nnl 0.00 1 .00 2.00 3.00 Time-1 (ms)32E: Tested at -30°F 4 00 5.00 6.WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-11 0.00 1.00 2.00 3.00 4.00 5.00 Time-1 (ms)31A: Tested at -25 0 F 6.00 0.00 1.00 2.00 3.00 4.00 5.00 Time-1 (ms)355: Tested at -20 0 F 6.00 5000.00 4000.00 3000.00 2000.00 1000.00 ft A /t N. .~&n nr) I 0.00 1.00 2.00 3.00 4.00 5.00 6.00 Time-i (ms)37P: Tested at 0°F WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-12 o=..a Time-I (ms)32A: Tested at 20°F 5000.00 4000.00 3000.00 2000.00 1000.00 Time-1 (ms)32B: Tested at 70°F 9 5000.00 4000.00 3000.00 2000.00 1000.00 n nnl ; : ; ;0.00 1.00 2.00 3.00 Time-i (ms)354: Tested at 120'F 4.00 5.00 6.00 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-13 5000.00 4000.00 3000.00 2000.0W 1000.00 0.00.0.'5000.00 400000 3000.00 2000,00 1000.00 Time-1 (ms)37Y: Tested at 170'F Time-i -0.72 ms load-I 21.92 Ib n Ufin ; 0.00 1.00 2.00 3.00 Time-i (ms)311: Tested at 250'F 4.00 5.00 6.00 ,%5000.00 4000.00 3000.00 2000.00 1000.001 0.00 1.00 2.00 3.00 4.00 5.00 Time-i (mw)32L: Tested at 300'F 6.00 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-14 Load-1 43.94 lb Time-1 -0.75 ms 5000.00 4000.00 S3000.00 2000.00 1000.00 A. AA.J.LA A I nnn I I I I ---, A- ..-.N- A , -, 0.00 1.00 2.00 3.00 Time-i (ms)425: Tested at 50'F 4.00 5.00 6.00 5 4'3 Time-1 (ms)43D: Tested at 70'F 0.00 1.00 2.00 3.00 4.00 5.00 Time-1 (ms)41P: Tested at IOO°F 6.00 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-15 Time-1 (ms)456: Tested at 120'F 0.00 1.00 2.00 3.00 4.00 5.00 Time-i (ms)46Y: Tested at 130OF 6.00 n-i 0.00 1.00 2.00 3.00 4.00 5.00 Time-1 (ms)43K: Tested at 140OF 6.00 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-16 5000.00 4000.00 7 3000.00 .0, Time-1 (ms)47L: Tested at 150°F"7 2 0.00 1..00 2.00 3.00 4.00 5.00 Time-1 (ms)473: Tested at 170°F 6.00 5000.00 4000.00 3000.00" 2000.00 1000.00.0.00 1.00 2.00 3.00 4.00 5.00 Time-i (ms)42C: Tested at 180°F 6.00 WCAP- 17939-NP May 2015 WCAP- I17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 B-17 o, 0.00 1.00 2.00 3.00 4.00 5.00 Time-I (ms)42D: Tested at 250'F 6.00 5000.00 4000.00 3000.00" 2000-.00 100i.00 0.00 0.1 5000.00 4000.00 3000.00 2000.00 1000.00 Time-i (ms)46A: Tested at 300'FI P 0.00 1.00 2.00 3.00 Time-1 (ms)47D: Tested at 3750F 4.00 5.00 6.00 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-1 APPENDIX C CHARPY V-NOTCH PLOTS FOR EACH CAPSULE USING SYMMETRIC HYPERBOLIC TANGENT CURVE-FITTING METHOD C.1 METHODOLOGY Contained in Table C-I are the upper-shelf energy (USE) values that are used as input for the generation of the Charpy V-notch plots using CVGRAPH, Version 6.0. The definition for USE is given in ASTM E185-82 [Ref. C-I], Section 4.18, and reads as follows: "upper shelf energy level -the average energy value for all Charpy specimens (normally three)whose test temperature is above the upper end of the transition region. For specimens tested in sets of three at each test temperature, the set having the highest average may be regarded as defining the upper shelf energy." Westinghouse reports the average of all Charpy data (>_ 95% shear) as the USE, excluding any values that are deemed outliers using engineering judgment.
Hence, the Capsule 970 USE values reported in Table C-1 were determined by applying this methodology to the Charpy data tabulated in Tables 5-1 through 5-4 of this report. USE values documented in Table C-I for the unirradiated material, as well as Capsules 830 and 263', were also determined by applying the methodology described above to the Charpy impact data reported in BAW-1880, Revision 0 [Ref. C-2], and WCAP-15040, Revision I[Ref. C-3]. The USE values reported in Table C-I were used in generation of the Charpy V-notch curves.The lower-shelf energy values were fixed at 2.2 ft-lb for all cases. The lower-shelf lateral expansion values were fixed at 1.0 mils in order to be consistent with the previous capsule analysis [Ref. C-3].Upper-shelf L.E. is not typically fixed in CVGRAPH; however, due to excessive data scatter for select capsule materials, the upper shelf L.E. value will be fixed in the summary plots, as documented in Section 5 of this report, for T-L and SRM materials in Capsule 263* and L-T and T-L materials in Capsule 97*. The individual L.E. plots for these materials, as documented in this Appendix, will still allow the upper-shelf L.E. to float for comparison between the two methods. The fixed upper-shelf L.E. values were determined using the same Charpy V-Notch test specimens that were used for the upper-shelf energy determinations and are shown in Table C-2.WCAP- 17939-NP May 2015 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-2 Westinghouse Non-Proprietary Class 3 C-2 Table C-1 Upper-Shelf Energy Values (ft-lb) Fixed in CVGRAPH Intermediate Shell Plate M-605-1 Longitudinal Orientation 134 119 N/A 108 Intermediate Shell Plate M-605-1 103 102 79 78 Transverse Orientation Surveillance Program Weld Metal 115 100 105 95 (Heat # 83637)Heat-Affected Zone (HAZ) Material 105 119 130 93 Standard Reference Material (SRM) 122 N/A 86 N/A Table C-2 Upper-Shelf L.E. Values (mils) Fixed in the CVGRAPH Summary Plots Intermediate Shell Plate M-605-1 Longitudinal Orientation (see Figure 5-2 of this report)N/A 87 Intermediate Shell Plate M-605-1 7 Transverse Orientation (see Figure 5-5 of this report)Standard Reference Material (SRM) 75 N/A (see Figure 5-14 of this report)CVGRAPH, Version 6.0 plots of all surveillance data are provided in following the reference list.this appendix, on the pages C.2 REFERENCES C-1 ASTM E 185-82, Standard Practice for Conducting Surveillance Nuclear Power Reactor Vessels, E706(IF), ASTM, 1982.Tests for Light-Water Cooled C-2 BAW-1880, Revision 0, Analysis of Capsule W-83 Florida Power and Light Company St. Lucie Plant Unit No. 2 Reactor Vessel Materials Surveillance Program, September 1985.C-3 WCAP-15040, Revision 1, Analysis of Capsule 2630from the Florida Power & Light Company St. Lucie Unit 2 Reactor Vessel Radiation Surveillance Program, February 2010.WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-3 C.3 CVGRAPH VERSION 6.0 INDIVIDUAL PLOTS UNIRRADIATED IS PLATE M-605-1 (LONGrITUDINL)
CVCih 6-0: Hypabalic Taqwd Qxive Primted an 1"215 635 AM A =6&14 B =65A9 C =UHO.ZTO =64-16D = OM Canelidion Coefficient
= 0391 Equdi~m is A + B
- gnIXC1-T0>'(C4D1Y))]
Uppe~bffBmff 134 00 (ixedD Lo we S W ueff = 2 _0 Oized)TenVA30 ft-ba=-S.40 0 F TempW5 ft-Ub--3A0P F Td 50 ithbs33_20-F Flait St. Lucie 2 OkimntziozriT MAienal SA533B1 Capa&uiUnirrad Hlat A-349-2 Thxwe: 160 140 120 Q go 60 40 20 0 g--300-200 1400 0 100 200 300 400 50o 60O Temperature (0 F)CVzaph 60 Page 112 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-4 Plmt St. lii 2 .Material-SA33BI Heat -14W0-LT Capsule: Unirrad Fhxmm-UNIZRADIATED IS PLATE M-605l- (LONGITUDINAL)
Charpy V-Notch Data Temperatur (F) Inrut CVN' .camfwed CVN DiffenIal-40 15.0 19.5 -4.49-_'20 20.0 25.7 70-1 33.0 33.1 -010 20 45.0 43.0 2.01 40 51.0 53.8 -2.24 50 40.0 59.6 -19.63 50 1020 596 4237 50 46.0 59.6 -13.63 60 54.0 65.6 -1156 60 35.0 65.6 -30.56 60 860 65.6 20.44 60 33.0 65,6 70 90.) 71.5 19,47 70 89.0 71.5 17.47 22 101.0 7&6 22-39 85 87.0 80-4 6.65 105 101.0 91.4 9,60 150 73.0 111.0 -38.02 122.0 123.6 -1.64 250 141.0 129.6 1139 300 136.0 132.2 3.81 350 122.0 1333 -1126 400 142.0 133,7 830 450 139.0 133.9 5.12 aCGraph 610 01109,015 psge!m WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-5 Westinghouse Non-Proprietary Class 3 C-5 UNIRRADLATED IS PLATE M-605-1 (LONGITUDINAL)
CVCaph 6.0-. H13pedhc'Tangent Cmrve Pnnied ca 121/201410.16 AM A-= 43.24 B=42=-f C = S6. T = 30.0S D = .O Conelatim Coelfident
= 0.74 Equatim is A + B -[anh(9TOX'(C+-Y1))j L'er Sbef LE. =5.4 Lower Shf LE. = 1.00 Fixd)TwV(35 mlh= 13. 10- F Plo~t St. Indie 2 Orientztio LIT%fatexiaL S.AS3B1 Capwk Uli-a 1Hst A-9490-2 Thxne-e: O.OOE-*W akn Wi C C 4 1~100 90 70 -60 50 40 30 20 10 0-300-200 -100 0 100 200 300 400 500 600 Temperature (0 F),Grzuqh 6-0 12/01/2014 PapeV2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-6 Plant St. IAcie 2 Makii[ SA533B ieat A-8490-2 Onmtwr LT Capmie: Unirrad FbteL G.0E+N00 nkme UNIRRADTATED IS PLATE M-605-1 (LONGITUDINAL)
Char-py V-Notch Data Temperiture
('I) Innt L E. Com~puted L L Differcnial
-40 16.0 14-9 1-10-20 22?0 21.1 0.85-1 31-0 2g.6 235 20 A0.0 38.3 -33 40 51.0 481 292 50 41.0 52.8 -101.2 5D 7910 52-8 25.18 50 42.0 518 -10o-2 60 49.0 57-3 33 60 34,0 573 -233 60 70.0 57.3 12167 60 33,0 57-3 -2433 70 80 61.5 650 70 79.0 61.5 17.50 82 76.0 66.0 10.02 85 71.0 67.0 4.00 105 78.0 72.B 5.17 150 67-0 80.5 -13,54 200 86o 83.9 2.13 250 90.0 5.0 M.04 300 85.0 853 -032 350 87.0 85.4 1.57 400 8LO 855 -4.46 450 K6.O 85.5 0.53 CVGraph 6.0 12*.1(2014 1ae202 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-7 UMRRADIATED IS PLATE M-605-1 (LONGJITUDINAL)
CVGuph 6.0. Herbofc Tzmgent Cuve Prined an 124112014 10:18 AM A= 50.00 B = 50.00 C = 90.93 T0 = 88,3 D = 0.00 Carrcoah~Coe5cieut=
0389 Eqyutim is A + B *Tanh((r-TY(C+D1))1Shff %Shear 1 0000 t(F=4e Lower Shelf/ZShear 0.00 (Fhed)TfAhUE at
-8130 Plant St. Lade 2 Orienialioz LT MaferijaL S.4533B1 Cq:& Umdra Bust A-490-2 Fbience. 0.OIJEtO zdai 110 100 s0 80 70 60 50 40 U I..'30 20O 0-300 CV6ralmo0-200 -100 0 100 200 300 400 500 600 Temperature (0 F)12/01,2014 Page 112 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-8 Plant St. Lade 2 Mateia: SA-53BI Heat A-4I-2 Oiientmimo LT Capsde: Uuilrad Fhmm_. LOOE+40 UNIRRADIATED IS PLATE M-605-1 (LONGITUDINAL)
Charpy V-Notch Data Tempmautr, (t F) Inu "%km comput %Sh DiffenW-40 0.0 5.6 -5.62-20 10.0 85 154-1 10.0 123 -230 20 10H0 18-2 -821 40 20.0 25.7 -5.69 50 10.0 30.1 -20.10 50 700 301 39-90 50 10.0 30.1 -20.10 60 30.0 349 92 60 10.0 34-9 -24.92 60 60.0 349 25.08 60 10.0 34.9 -24.92 70 70.0 40.1 29.93 70 40.0 40.1 -0107 V 60.0 46-5 13-46 85 60.0 48.2 11.82 105 60.0 59.1 0.92 150 50.0 79-5 53 200 100.0 92.1 7.90 2 10D0.0 97.2 2.79 300 100.0 99.1 0-94 350 100.0 99.7 032 400 100.0 99.9 0.11 450 100.0 10O.0 0.04 CVGrxph 60/0112014 Page 211 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-9 Westinghouse Non-Proprietary Class 3 C-9 UNIRRADIATED IS PLATE M-605-1 (TRANSVERSE)
CVGtzh6.0:
Hyperbolir Tangent Curve Punted an 12/1/2014 10-4 AM A = 52.60 B = 50.40 C = 95.21 TO = 76.33 D = 0.00 Coaelatio Coeffcient
= 0-931 Eqtuadwis A + 9 frsW(r4DUY(41Jl))J Uppfe fEnug = 103-00 (FnznD) LowuSheWfErnc
= 220 (FireM Terfnp@M ft-bS= 30.40r F Terpn35 R-AW= 41.70F F Tm*Q_0 ft--= ý71.5T F Flait St. Lucic 2 Oficntatim-TL Matenal: SA.W3BI Capsule: Uuirrad Heat A-84902 Hurmce, (0 9r+4000zaue 120 100 (U'80 60 40 20-300 CVGriq 6.0-200 -100 0 100 200 300 400 500 600 Temperature (0 F)12/010014 Page 1/2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-10 Plnt St. Lucie 2 NMterial:
SA&5&3BI Heat A-490-2 TL Captor Unimd HFu 0.OE+000 rtCm'UNIRRADIATED IS PLATE M-605-1 (TRANSVERSE)
Charpy V-Notch Data Temperature 0F Input "-N Computed CN DiffereuWt
-40 6-0 103 -4.25-20 23.0 14ý0 903 2 2.0 19.7 3-32 10 27.0 25.- 1.17 40 31.0 343 -315 50 44.0 39.0 4.99 50 49.0 39.0 9.99 50 42.0 39.0 2.99 60 39.0 440 -5A4 60 37-0 44.0 -7.04 60 29-0 44.0 -15X0 70 46-0 493 -3.25 85 63.0 57.2 5.82 105 71-0 673 3.67 125 85.0 763 8.67 150 44.0 853 -4132 155 107-0 86- 20.20 176 108.0 919 16.06 200 108.0 960 1193 250 83.0 100.4 -17.44 300 100-0 102.1 -2.09 350 10&.0 1027 5.32 400 107-0 102.9 4.11 450 105.0 103.0 2.04 CV-Grmh 6.0 12/01,2014 PaWe212 WCAP-1 7939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-11 U'NIRRADIATED IS PLATE M-605-1 (TRANSVERSE)
CVGrqh 6.0: Hypeihc Tangent Curve Prnted on 1211/2014 10:51 AM A= 39.30 B =3830 C = 95.27 TO = 4M_88 D = 0.00 Cmm atim Coefficiea=
0-937 Equatio iA+ B * (TxDr-TGY(C4DT))]
Uper Shb&LIE = 77.60 Lower sbkf LE E 100 oFmixe Ten_35 mis= 3A20- F Plant SL Lucie 2 Ofientation TL Matleiia.
SA:-33BI C"&il. Uuinýa Heat A-8*902 FluKe- 0 OOE+000 iadcm?0, 0 0, (U (U (U 80 70 60 50 40 30 20 o, L mI 300-200 -100 0 100 200 300 400 500 600 Temperature (0 F)CvQxph6.0 12/01/2014 Page 2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-12 Plnt St. Txci 2 Mlatena SAS33BI. Heat A-8-90-2 Ofienmio TL Cvme: Thn'md Fhwm O.OOE-4O Amcmn UNIRRADIATED IS PLATE M-605-1 (TRANSVERSE)
Charpy V-Notch Data T" -tre e F) Intmt L E. Cmupted L L DifreuW-40 7.0 113 -427-20 23-0 15.6 7.40 2 24.0 21.8 2.16 20 30.0 28.0 1-97 40 35.0 35.7 -0.74 50 43.0 39.8 3.25 50 46.0 39.8 6-25 50 42.0 39.8 225 60 360 43.8 -7.75 60 41.0 43.8 -2.75 60 29.0 43.8 -14.75 70 46.0 47.7 -1.65 85 59.0 532 5.14 105 020 59.6 2.43 125 73.0 64.7 8.29 150 46.0 69.4 -23.41 155 79.0 70.1 8.85 176 S3.0 72.6 1037 20 83.0 74.5 8,48 250 75.0 76-5 -149 300 79,0 772 0.79 350 79.0 77-5 1.54 400 71.0 77.6 -6.55 450 73.0 77.6 4358 VGraph 6.0 12101P.014 Page i'2 WCAP-1 7939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-13 UNIRRADIATED IS PLATE M-605-1 (TRANSVERSE)
CVGiph 6.A Hypebi Tangnt Curve Pjfmd on 12/112014 10:.3 AM A= 5.0M B = 0.00 C-- 45.34 -D = 37.05 D = 0.0o Carelation Coefficaiet
= 09V7 Equatim i A +EB -C1xn Ty(C+D'))]
Ugmer Shelf .SA r = 100.00 Fixec Lowe Shelf %.Sbear= 0.00 (Fixe Temperature at 5W0 Shew= 87.10 Plant SL Lucie 2 tkiatation:
TL MateriaL SA33BI Capsule. Uvirrad Heat A-890-2 Fhiaene O.OOE+M0 z/cmz 110 100 9.$4.I-70 60 50 40 30 20-10-0-300 cVC=Oh6.0-200 -100 0 100 200 300 400 500 600 Temperature (0 F)12MI/M14 Pag 1V2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C- 14 Westinghouse Non-Proprietary Class 3 C-14 Plant St Lade 2 NMahTal: SA5RklB1 Heat A-1490-i Ckietaio IL Capsule: Un-ad Fhwam 0.00E+0Q0
,,cmýUNHUIIADLUTED IS PLATE M-605-1 (TRANSVERSE)
Charpy V-Notch Data Tempetmahm ( I) Input %Shear Computed %Siear Differrafial
-40 0.0 OA -037-20 10.0 0.9 9.12 2 lO.0 23 7.71 20 10.0 4.9 .5.06 40 10-0 112 -1.15 50 30.0 163 13.67 50 20.0 16.3 3.67 50 10.0 163 -633-60 0.o 23-3 -327 60 30.0 233 6.73 60 20.0 233 -327 70 20.0 310 -1204 95 40.0 47.7 -7 34 105 90.0 69-9 11.18 125 90.0 841 5.79 150 W0.0 94.1 -1414 155 100.0 9512 4.75 176 100.0 991 1.94 200 100.0 993 0.63 250 100.0 99.9 0.08 300 100.0 100o0 0o01 350 10o.0 1o00 O.o0 400 1000. 100.O 0.00 450 100.0 100.0 0.00 CVGaph 6.0 12/01/2014 PA212 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-15 IJNLRRADIATED SURVEILLANCE PROGRAM WELD METAIL CVCuph6 fbpezbdc&,Twi uv~wePrin~d i 12/1/214 10:7 AM A=5S@B= 56AD C=911'= 1.89D= 0.00 Cwebiatimu1Cafficdet=0199 Eqwa1co is A+ B
- rWIT0Y)(C4M)I Upper SheV~mff=
115-00 (Fixed) Lawa Slhlffnemgy 21_0 (Fixe Tmq(43G ft-lbu-50.500 F TemV@35 ft-nb--3990aF Tenp50 ft-lb.-12500 F Plant St Lucie 2 Orienbica6 NA, Mzen2L_ &S6W Capmle. Unirrd Hleat &3637 Fbxace- DAOE4400 ukmW 140 120 100 S 60 z 40 20 0 =-300-200 -100 0 100 200 300 400 500 600 Temperature (0 F)CVGaph 610 12/01/2014 Pipe V2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-16 Plant St LAcf 2 MNfafial:
SAW Heat 83637 0 P Capmle: Ugni-ad Fkezre O)00 E-00 nkiun UNIRRADIATED SURVEILLANCE PROGRAM WELD METAL Charpy V-Notch Data Temefture IfD Input Computed CVN Diffrmt6l-40 10.0 35.0 -24.95-30 62.0 40.1 21.88-30 41.0 40-1 0.88-30 19to 401 -21.12-25 29.0 42-9 -13.85-25 61.0 42.9 19.15-25 38.0 429 -4.85--20 50.0 45.7 433-1 93.0 56.9 36.14 10 61.0 69.4 -836 40 60.0 803 -11.34 70 74.0 93.6 -19,62 85 118.0 996 1938 105 95.0 103.7 -8.74 i50 124.0 1104 13.59 200 106.0 113.4 -738 250 1N.0 114.4 &.56 300 99.0 114.8 -16.81 350 127.0 1149 12.07 400 117.0 115.0 2.02 45D 108.0 115.0 -6.99 CVVGaph 6.0 12/01P2014 Page.212 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3C C-17 UNIRRADIATED SURVEILLANCE PROGRAM WELD METAL CVqapk64-Hypfbdic Tangent Curve Pzinid 121/2014 10-59 AM A=44.64 8=3M.6-C=
7.72 TO=-102 D =0.00 CmOxiami Cef = 0.917 Eutim is A+ B * -rJan(f-_roY(C+DI))J
.2S Lwe, SheEL.E = 1.00 (Fixe Tereqa35 mfls-27.10 rF Plant St. Lude2I Manigt &SAW Capwk: U~ra Heat 833 Fbrem0 .OOE+00 u/tin 0 100-80-70 60 50-40 30 20 10 .0-300-200 -100 0 100 200 300 400 500 600 Temperature (I F)cvcnvh 6_0 12/01/2014 Page 112 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-18 Westinghouse Non-Proprietary Class 3 C-i 8 Plant St. Luck 2 Makmia SAW Heat 8W637 06mftb=NA Capsule: IUnirwr Fhnce: 0,00E+0O0 n/ic UI.HRADIATED SURVEILLANCE PROGRAM WELD METAL Charpy V-Notch Data TVWarU (r) Input L E. Computd LE. Dwffremnti
-40 1.0 2&0 -101-30 49,0 33,4 15.61-30 31.0 33.4 39-30 16.0 33.4 -1739-25 270 362 -9.24-2 54.0 36.2 17.76-25 29,0 36.2 -7.24-20 45.0 39.2 5S4-1 73.0 50.5 22.50 20 53.0 6-1I -9.10 40 60.0 71,0 -1098 70 6-70 797 -1175 85 96.0 2.4 1356 105 88.0 84.8 3.19 150 93.0 872 536 200 91.0 880 2.99 25 92.0 88.2 3-79 300 80.0 .983 -8.26 350 88.0 883 -0.27 400 86.0 883 -2.27 450 87.01 83 -128 Ca 6.0 1M12014 Page 212 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-19 UNIRRADIATED SURVEILLANCE PROGRAM WELD METAL CVGraph6.0 Hyperbolic Ta tCurve mPrin. 12/12014 11:01 AM A= 50.00 B = 50.00 C= 5.87 TO=L28 D = 0.00 Onevfiicm C t=0.94g Equiwao is A + B *{Tz*Df-1WDC+mT)]
Upper Sf.Shear=
I0000 (FO Lower Shetf %Shear = 0.00 (FixecD Temehat iat50% Shear = 1.30 Plaut St. Luk 2 ofieutafijiX4, Malfenal SAW Capsule. t~nhrra Heat &%637 Fhuaxe 0.O-00E0 u/au 1 110 l00 90 80 1~A U 70 60 50 40 30 2o 10-0--30O CVrp6.o-200 -100 0 100 200 300 400 500 600 Temperature (Q F)12/01/2014 Page V2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-20 Plant St. Lade 2 Matkmdx: SAW Heat S3637 NA, Capszke Unirrad FlUmxe 0.OOE+000 akcm?UNIRRADIATED SURVEILLANCE PROGRAM WELD METAL Charpy V-Notch Data Tenpernare (I F) IRu $ -Samr Camputtd %Shear Differential
-40 20.0 272 -720.30 50.0 32.2 17.83 ,30 30.0 322 -2.17-30 30.0 322 17-25 30.0 34.8 -4.1V-25 40.0 34.3 5.8-25 20.0 34.1 -14.82-20 30.0 37.6 -7,58-1 8OO 4&6 3136 20 50.0 61.0 -10.98 40 i00 71ý6 -1157 70 80.0 83.7 -3.73 95 100.0 88-0 1196 105 90.0 922 -222 150 100.0 9712 2.20 200 100.0 99.1 0.87 250 I00.0 99.7 026 300 100.0 99.9 0.0o 350 100.0 100.0 0,02 400 100.0 100.0 0.01 450 100.0 100.0 000 12"DO120:14 Pae 2"2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-21 UNIRIIADLATED HEAT AFFECTED ZONE CV&mph 6.0: Hf)Vbob Tangmt Cu-u Poizdoi 119115 6-42 AM A = 560 B = 5L40 C =119.75 TO=26-19 D) = 0.00 Cxielali Coeftient=
0.497 Equatizmis A +B
- ils(TI-7P)XC4{Y))1 UjpW SlweffMw"=
105-00 (FimI ImwShelf EhuU= 2-0 (Fixe4)TTa3O fi 1bs=-33.1IrvF Ternp(35 ftD-90 0 F TwpA50 ft-1lbw 17.W0 F Pbht St. Lade 2~O NA 20w 175 150 J-. 100 75 0 --300 Matimuit &S&ASBL 40:Uninad0 Heit A-84902-M0 -100 0 100 200 300 40N 500 600 Temperature (0 F)CVcr~h6-0 01/0912015 Page 1/WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-22?lant St. Lucie 2 crimutatioa INA Matmiak SA53Bi Capsuil T-irrad ThNace.UNURRADIATED HEAT AFFECTED ZONE fleat.A449W-2 Charpy V-Notch Data Tmuyratwre
() I9%m C "N C~ompted CN7 Differen&Ia
-40 170 27.7 -10.74-20 21,0 34.7 -7.67-1 90.0 411 47.91 20 41.0 50.9 -990 40 21.0 59.5 -38A6 50 67.0 63.6 3-35 50 49,0 63.6 -14.5 50 16.0 636 -47.65 60 59.0 6737 -8.70 60 61.0 673 -6.70 60 179.0 67.7 111.30 70 62.0 71-6 57 85 45,0 77.0 -31.96 105 103.0 932 19.76 150 !1.0 93.4 37.56 200 5.0 99.6 -41.65 250 111.0 1026 1.39 300 68.0 103.9 95 350 67.0 1045 -3754 400 122O 104.1 17-20 450 107.0 104.9 2.09 CVGnph 6.0 01,'09!2015 Page 2P WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-23 UINIRADIATED HEAT AFFECTED ZONE CV~rqt6,0:
Hypffbo&i Twgft Curve Printed on 1,912015:53AM A=37.08S B=36.OS C=ILCA D=1&.460D=O.@
C~aihm Coe~daA=O0.27 E~quation is A +B~
- rad(Ct1DXC+D'fl)1 UppfSheffLE_
=73.16 Lf~~efefLE LIOO{fiz4d Temp35ihl=&50 F Pilot St. Lacie 2 Odeabdon INA MateriaL-S.AM3BI Cquak Uimxrzd Th~wxe Heat A-8490-2 80 70~60 40 430 2O 10-300-200 -100 0 100 200 300 400 500 600 Temperature (0 F)CVcraxph 60 01F9/2015 Page 1/2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-24 PAs= St. Luck!Orim3it~io1 NA Mfitl SAA'3B1 Capsule: UHAT A TNmE: UN'IRRADIATED HEAT AFFECTEDJ ZONqE Heat Charpy V-Notch Data Teperaur (IF) Ipt L E. Cmaputed L L Diffemtial AO 20.0 21.7 -1.66-20 2.0 268 -0.83-1 56.0 322 23.78 20 31-0 31.4 -7A3 40 23.0 44-3 -2128 50 57.0 47.1 9.92 50 41.0 47-1 -6.08 50 17.0 47J1 -30.09 60 49.0 49. -0.75 60 51.0 49.8 1.25 60 93.0 49.8 33.25 70 52.0 523 -028 85 41.0 55.7 -14.75 105 75.0 5937 1528 150 U2O 66.1 1593 200 54.0 69-9 -15.97 250 77,0 71,7 532 300 66.0 725 -6.50 350 68.0 72.9 -4.87 400 16.0 73.0 Z97 450 77.0 73.1 3.90 mZVraii 6.0 01t09'15 pate 2/2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-25 LTJNRRADIATED BEAT AFFECTED ZONE CVC~ph6.0:
Hypeboki Tngat Cuve Pdated am IiWM15 7: 10 AM~A = SOA B= SUO C =93,19 TV =552A6D =0.00 Camiehfimi C4oefmcitt
= 0.957 Equatimis A+ +B -DY(T (C+DI))]Upper Sef %Slew=100.00 (Fhxe I~we %f %Mmr-OA (FzeD~Thiuarixne at 50 Sbw = 52.10 Plant St Lwuc 2 Or- 1n1- NA MfalimaL SA533BI Cap"Ik Unirrad FbumrE Heat A-40-2 110 100 9o 80 Sw 70 fS&:ý 6050 30 20 10 kq AW, k A% o .. .' o ... .%F 'It --T* /o-0---0-300 -200-100 0 100 200 300 400 500 Temperature
(* F)600 cvGrah 6.0 01/0912015 Page 1/2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-26 PI~t St Lucie 2 Oxieubtfioac NA Nfaitev SAW~BI Cqpmle: LUirrad Fbaxme.IJNIRRADLATED HLEAT AFFECTED ZONE Heat A-149-2 Charpy V-Notch Data Temperature
? F) Input %Shem Computed %Sbear Differential
-40 20.0 122 7.S3-20 20.0 17.6 2.45-1 40.0 24.2 15.75 20 30.0 33.4 -3.44 40 30.0 43.6 55 50 70-0 48-9 21.12 50 50.0 48.9 1.12 50 20.0 48.9 -2,8 60 30.0 54.2 -24.24 60 40.0 54-2 -1424 60 100.0 54- 45.76 70 60.0 595 050 85 40.0 67.0 -2%.96 105 100.0 "57 24.31 150 100.0 89.1 10.90 200 100.0 96.0 4.01 250 100.0 98.6 1.41 300 i00.0 99.5 0.49 350 100.0 99.8 0.17 400 100.0 99.9 0.06 450 100.0 100.0 0.02 CVGnph 6.0 01/092_015 Page 2X2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-27 UNIRRADIATED STANDARD REFERENCE MATERIAL CVGzh 6.0: Hypedvhi TangW Curve Pinoteda 12/1/2014 12:22 PM A=6210 B= 59.90 C = 6928 TO = 67.0 D = 0.00 Caela-aum 0=989 Euitia is A + B- t-r*(T-1DY(C+rD))]
UTn SH Ememgy = 12200 (Fixd) f eSl=*F Ty2.20 (F-ze ." Tw4OMA-fl-L-25.ýF TaIWj*,5 ft-Iis= 33.6ir F Tempg5O fl4b=153.100F FIXnt St.Lu~cie2 Orieiubicmr LT MaitmikL S.453381 CpuzIe- Unfirrad Heat: BESSr-OLM Fkzuwe: &00E4000 x/aaz N-O U 140-120 -_100 -60 40 --* --20 =-300 -200 -100 0 100 200 300 40W 500 Temperature (I F)CVGph 6.0 12/01(2014 Page w WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-28 Westinghouse Non-Proprietary Class 3 C-28 Plant St Lacie 2 Matera SA533BI Heat HSST-CIMY Odentafi-LT Capsuek tninad Thi.p O.o0E+0f00 ko UNTIRRADIATED STANDARD REFERENCE MATERIAL Charpy V-Notch Data Temperat-u F) Input CN CompNed CVN -Differeniial
-40 10.0 7.4 262 0 16.0 17.2 -1.22 20 18.0 26-6 -8.56 25 37.0 29.5 732 35 27.0 360 -9.03 40 51.0 39.6 1135 70 68.0 64.4 3.57 85 66.0 77.1 -11.08 105 99.0 91.8 7.19 150 108.0 111.9 -3.92 200 1260 119.5 6.54 250 121.0 121.4 -039 300 1220 121.9 0.14 350 122.0 122-0 0.03 400 130.0 122.0 8.01 CVG-%ap 6.0 12/0L'2014 Page 212 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-29 UNILRRADIATED STANDARD REFERENCE MATERIAL ,CVC~ph 6,0 Hyperbolic Tmzgent Come Printed on 12/1/2014 12:27 PM A =39.06 B = MA0 C= 6L.78 TO = 44.58 D = 0.00 ConebtficnCoeffiisent
0977 Equzatio is A +.H 4 [Th(r.-0DY(C4D )l)U~pper wbffLE_=77.11 1owex SlrIfLE_
1.00 Fied)TeimW5inlaW=39,000 F Plant St. Lucfr 2 Orebi- LT MateraL- SA533BI Capsmk-Unirra Heit HSST-OIMY Thkerme 0.OOE4409 a/rm"'I0 90 80 70 60 50 40 30 20 10 01=-300-200 -100 0 100 200 300 400 500 600 Temperature (0 F)12/01/2014 CVGraph 6.0 Page 12 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-30 Wetnhos o-Poretr lss3C3 Plait St. Lade i2 Matra- &W4313B1 Heat HSST-OWMY Ofientaiav LT Capume: Uirrad Fliea 0.OOE+OON Wcm1 UINIRRADIATED STA-NDARD REFERENCE MATERIAL Charpy V-Notch Data Tempamtnr ( F) IutLE. Compuwyd L E DiffereuntaI
-40 110 5.6 537 0 18.0 15.5 2.46 20 17-0 2437 -7.67 25 31.0 27.4 3.61 35 26.0 33-2 -720 40 45.0 362 8.76 70 55.0 53.9 1.11 85 53.0 60-9 -7.92 105 73.0 67.7 5.32 150 92.0 74-7 732 200 79.0 76.6 238 250 71.0 77-0 -6.01 300 74.0 77.1 -3,09 350 78.0 77-1 0.29 400 76.0 77.1 -111 CVGraph 6,0 12/01,2014WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-31 UNIRRADIATED STAN3DARD REFERENCE MATERIL CVGph 6.0- Hypebok Tanget CAve Ptinted on 12W112014 12-30 M A =50.00 B-50.00 C5_65 T0 7S9SSD 0.00 calas coeffctiag
= o996 Equatim is A + B
- lTan(T'-T0Y(QC+D))]
Upper Sbelf %Sbear= 100.00 (Fixed) Lomw Shelf %.Sw = 0o00 (Fed)Tempermate at 50. Shear 79.00 Plant St. Lucie 2 Ornextatim-LT MatikiaL-SA533BI capui1- Uin-ad Hent H35T-O1MY Fhixe: DLUOE*40 zkWi 110-100 90 80-70 60 50 40 30 .20 10 0-300-200 -100 0 100 200 300 400 500 600 Temperature (0 F)CVGnqh6_0 1210112014 Page V12 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-32 Plant St. Luce 2 Matexial:
SAO3B1 Heat: HSST-01MY Orientafton LT Capsule: Fluamce 0.OOE+000 UNIRRADIATED STANDARD REFERENCE MATERIAL Charpy V-Notch Data Temperature C 'F) Input %Shear Computed %Shear Differential
-40 0.0 11 -1.08 0 10.0 4.7 5-25 20 10.0 9.6 037 25 10.0 11.4 -1.41 35 10.0 15.8 -5.85 40 20.0 18.5 1.45 70 50.0 41.6 8.42 85 50.0 55.7 -5.72 105 70.0 72.9 -2.90 150 100.0 93.7 630 10 100.0 99.0 1.00 250 100.0 99.8 0.15 300 100.0 100.0 0.02 350 100.0 1000 0.00 400 100.0 100.0 0.00 CVGraph 6.0 12/01/2014 Page 2/2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-33 CAPSULE 830 IS PLATE M-605-1 (LONGITUDINAL)
CVGda 6.0 Hybolic Tagit Cuw Pdnted o 12/m 1- PM A = 60.60 B = A.40 C= 76.31 TO 81.38 D = 0.00 Coarltkm Coefficient
= 0-949 Equaticuiis A + B- rTa*rn(WlY(C+IY1))]
Upper ShelfYEW = 119-00 (Fixud Lower Sibyff ne 2-10 (FredD TmV* A-rbs= 36.70- F ThnpW35 .Ibg- 4530F F Tw@M50 fi-bs= 673_ F Plant St. LUC*e 2 Ofieataliow LT Matffnal:
&A533BI.Capsiwe SY 3um Heat A-490'2 140 120 I.100 8s 60 40 20 a =-300-200 -100 0 100 200 300 400 So0 600 Temperature (0 F)CVGraph 6.0 12/01/2014 pwit WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-34 Westinghouse Non-Proprietary Class 3 C-34 Plant St. Luaci OrkutatimL Li 2 Maleal- SA533B1 Calm& B3Q Fimp CAPSULE 830 IS PLATE M-605-1 (LONGITUDINAL)
Charpy V-Notch Data at A-U19-2 Tnmrau re IF) i t CNw Computed CUN Differential 1 10.0 15,0 -5.02 25 6.0 241 -18.07 35 48.0 29.1 18.92 48 40.0 36.7 3-29 60 43.0 44,9 -1.75 78 61.0 5&0 7 116 87.0 853 1-72 140 71.0 9-2 -2715 156 125.0 1044 20.64 217 125.0 115.7 932 300 112.0 11&.6 -6.61 401 119.0 119.0 0.03 CVGrph 6.0 120112014 Page 2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-35 CAPSULE 830 IS PLATE M-605-1 (LONGITUDINAL)
CVGrCh 6.0: Hyperbc Tangent Curve Pmftd ca 121b'2014 1:06 PM A = -4325 B=-42-5 C = 96.4 TO= 70.23 D = 0A Cwelation Coefiait = 0940 Equation is A +B
- fTanX(T-T0-(C4++1)]
Upper SheffLE = 85.49 Lower~wef LE = 1.00 (F'ed)Terop@5 unl zo51.20 F Plant St. Lucie 2 Orientation-LT Mstenial:
SAS33BL capsule: BY Heat A-8490-2 Fhuxmc 100 90 80 0 Cu Cu 70 60 50 40 30 20 10 0=-300-200 -100 0 100 200 300 400 500 600 Temperature (Q F)CVGrVh 6.0 12/01V2014 page 112 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-36 Westinghouse Non-Proprietary Class 3 C-36 Plout St. Luc OnenttiwwL-2 Material SA:%3B1 CAPSULE 830 IS PLATE M-605-I (LONGITUDINAL)
Charpy V-Notch Data eat A-8490-2 Temperatre (OF) TnptL L Computed L E Diffemi 1 26.0 17.2 8.76 25 5.0 24.8 -19.77 35 40.0 23.5 11"53 43 35.0 3317 1-32 60 37.0 38.8 -138 78 43.0 46.6 136 116 66.0 61.9 4.09 140 56.0 69.4 -13.40 156 810 733 7-72 217 86.0 81,6 435 300 85.0 84g 022 401 82.0 85,4 -3.40 C.rGrap- 6.0 1IM_-014 Pape 2)2 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-37 CAPSULE 830 IS PLATE M-605-1 (LONGITUDINAL)
CVGCirh 6A Hypibdi Taqxat Cmve Pinted an 1211M2014 1 10 PM A=5.400 B = 5000 C = 66.65 T = 12L91D =0.00 Carehtm Coeeffieaft
= 0.952is A + B
- ITat-1CTo+Dr1))]
Upr& S f.S1ea= 100.00 -(Fnxed) Lowe ShefSbear
= 0(00Fixe Temperafwe at 50% Shear = 122.00 IFlut St. Lade?Oic~iMLatoiLT MaitexiaL SMWBIR capsule: 83'Heat A-4090-2 Fkmwe: 110 100 90 80 70 60 50 40 I-CD 30-20 ....10-0-300 CVcar60o-200 -100 0 100 200 300 400 500 600 Temperature (1 F)12/01/2014 Page 12 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-38 Plant St. Laid~VretimL I 2Uijal: S-W53B1 IB SCapse: 83 Fbince.CAPSULE 830 IS PLATE M-605-1 (LONGITUDI-NAL)
Charpy V-Notch Data eat A.-490-.Temmture ( Input h %sar Comutned %Shear Differential 1 5.0 2.6 2.41 25 0.0 5-2 -5.18 35 10.0 6.9 3,.14 42 10.0 9.8 0.18 60 10.0 13-5 -3.50 78 20.0 21.1 -1.12 116 65.0 4516 19.42 140 30.0 63.2 -33_25 156 90.0 73.6 16.45 217 100.0 94.5 5.45 300 100.0 99.5 0.43 401 100.0 100.0 0.02 CVGraph 6.0 12/012014 Page 122 WCAP-17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-39 Westinghouse Non-Proprietary Class 3 C-39 CAPSULE 830 IS PLATE M-605-1 (TRANSVERSE)6.0: Hypftbola Tangent Cýxw Pnted on 1211/2014 1:15 PM A= 5.1.0 B= 490 C = W.78 TO = I1344D =0.00 Coefficient=
0972 Equations A + B- [Tan( OT-Y(tC+DTI))]
Upp S1eIfEmngy=
102.00 (Fixed Lower SlffEnrgy
= 220 (Fie Tmozp30 A-lm-= 59-80 F Temp@35 ft-1b- 7320- F Tenj50 F Plant SL Lack 2 Oxemlin Miterijal SAW3BI capswil: V3 Heat A-8490-2 Amhce: 120 100 CA f 4-I-60 40 20*0u::-300-200 -400 0 100 200 300 400 500 600 Temperature (0 1)CVGraph 6.0 3121012014 Page 1/2 WCAP- 17939-NP May 2015 WCAP- 17939-NP May 2015 Revision 0 Westinghouse Non-Proprietary Class 3 C-40 plant $tLuefr 2-kritm T1L iaterial:
S&8533B1 Cmpe: S3W Fre CAPSULE 830 IS PLATE M-605-1 (TRANSVERSE)
Charpy V-Notch Data Heat A-8490-2 Temperature (F) 1U dt Computed CVN Differetial 1 13-0 14- 16 47 24.0 253 -1.69 60 32-0 30.1 1.92 78 44.0 36.9 7.09 113 49.0 51.9 -3.90 140 51.0 63.6 -12.64 157 83.0 70.5 12.53 217 78.0 88.3 -1028 252 104.0 94.1 9.88 300 106.0 98.5 7.52 350 97,0 100.5 -3.52 401 99.0 101A 39 CVfiph 6.0 12/01M2014 Page 2 WCAP- 17939-NP May 2015 Revision 0