JAFP-84-0672, Monthly Operating Rept for June 1984

Monthly Operating Rept for June 1984

ML20090C195
Person / Time
Site:	FitzPatrick
Issue date:	06/30/1984
From:	Jackie Cook, Corbin McNeil POWER AUTHORITY OF THE STATE OF NEW YORK (NEW YORK
To:	NRC OFFICE OF ADMINISTRATION (ADM), NRC OFFICE OF INSPECTION & ENFORCEMENT (IE)
References
JAFP-84-0672, JAFP-84-672, NUDOCS 8407130199
Download: ML20090C195 (7)

Text

.

-- _ _ - _ . _ _ ~ ._ -_ . - _ _ -

[

t OPERATING DATA REPORT [

DOCKET NO. 50-333 l DATE July y, 1984  ;

I COMPLETED BY J. LOOK l j

TELEPHONE (315) 342-3840 ,

f OPERATING STATUS f FitzPatrick Notes I. 1. Unit Name:

l 2. Reporting Period: 840601-840630 ,

j 's. Licensed Thermal Power (MWt):

2436 7

4. Nameplate Rating (Gross MWe): 883 l

5. Design Electrical Rating (Net MWe): 821  ;

i 6. Maximum Dependable Capacity (Gross MWe): 830 j

7. Maximum Dependable Capacity (Net MWe): 310

. 8. If Changes Occur in Capacity Ratings (Items Number 3 Through 7) Since Last Report, Give Reasons:  !

None -

4

9. Power Level To Which Restricted,if Any (Net MWe): None i

10. Reasons For Restrictions,if Any

[

[

This Month Yr. to-Date Cumulative

II. Hours In Reporting Period 720 4367 78264 ,

12. Number Of Hours Reactor Was Critical 645.3 3^82.6 56511,4 t

13. Reector Reartve Shutdown Hours 0 0 0  ;

L I4. Hours Generator On-Line 610.8 3875.4 55075 L 0 0 0

15. Unit Reserve Shutdown Hours [

16. Gross Thermal Energy Generated (MWH) 1385472 8943144 116679730 t

17. Gross Electrical Energy Generated (MWH) '461460 3000090 40219280 -

18. Net Electrical Energy Generated (MWH) 447590 2904695 38403335 '

l

19. Unit Service Factor 84.87. 88.7% 70.47. j r 20. Unit Availability Factor 84.8% 88.7% 70.4% '

21. Unit Capecity Factor (Using MDC Net) / 6. /7. 82.17. 66.07. j

22. Unit Capacity Factor (Using DER Net) . 75.77. 81.0% 59.8% i

23. Unit Forced Outage Rate 0 37. 3.6% 13.9% ,

24.' Shutdowns Scheduled Over Next 6 Months (Type. Date. and Duration of Each):

f

, Maintenance outage to commence on or about 840914: to last anorx 30 days

25. If Shut Down At End Of Report Period. Estimated Date o'Startup: }

26. Units In Test Status (Prior to Commercial Operation): Forecast Achieved i t

INITIAL CRITICALITY [

INITIAL ELECTRICITY I COMMERCIAL OPERATION '

t 0 {

, AVERAGE DA!!.Y UNIT POWER LEVEL DOCKET NO. 55-333 UNIT FitzPatrick

. July 9, 1934 DATE J Cook COMPLETED,8Y TELEPHONE (315) 342-3840 MONTH "-

June 1984

. DAY AVERAGE DAILY POWER LEVEL DAY AVERAGE DAILY POWER LEVEL (MWe-Ne0 .

IMWe Net!

792 .

37 , 790 2 794 is 793 3 794 g, 794 4 794 20 796 5

704 '

21 796 6 797 22 569 7

795 23 15 s 772 24 0

, 718 25 0

10 -

788 26 0

. 11 790 27 77

. . 790 -

358 12 28 13 .

792 29 490 _

. 14 790 30 596 15

• 785 3g ----

16 784 .

SUMMARY

The FitzPatrick Piant operated at near full thernal power for the first twenty-9ne days of the recorting period. On 840621, the Unit was taken citt of service for maintenance and was back on line on 840627.

m e .. . ,m m- p .. . ,. . . . . ,. ...r.  :- -m. --

^

c UNITSilUTDC.!NS AND POWER REDUCTIONS DOCKET NO. .50-333 _

UNIT N AME _FitzPatrick DATE Julv 9. 1984 REPORT MONTil June 1984 COMPLETED BY J Cook TELErilONE 1315) 342-3840

%. .o C

N. . . Daic

,$ ?

3g "s 4Y3 Licensee Ew,

% Cause & Curreceive

.. [ i j j& Even 3,7 Aoion to H

fE E jgg Report a mO g{. Preveni Recurrence 6

i 840621 7 S 33.5 B 2 N/A

~ N/A N/A Shutdown to ohotograph sunoorts

- , in Drywell and steam tunnel 4

8 840625 F 41.2 A 3 84-013 TG FLT Reactor scram on high pressure from turbine trio on byoass valve closure caused by dirt in EHC Fluid Filters. Cleaned j

filters and returned to service.

i -

j-l j .

l. -

1 2 3 4 l F: Forced Reason: Method:

5: Scheduled Exhible G. Instintsions A Equiprnent Failure (Emplain) 1 Manual for Prepa,ation of Daia n Mainienance or Test 2 Manual Scram. Enity Sheets for 1.icensee C. Refueling 3 Automaile Scram. Eveni Repore il I!IO file INilREG-D Regulatory Restriction 4-Oiher (Explain) 0161)

E-Operator Training & License Examinailun

. F.Administ rative 5 G-Operaniunal Ensur IEmplain)

Exhibii 1 Same Somce

, Il-Oiher IE mplain) <

NARRATIVE

SUMMARY

OF OPERATING EXPERIENCE JUNE 1984 The Unit operated at near full thermal power for the first twenty-one days of the reporting period.

On 840621, shutdown was commenced and the Unit was off line on 840623 for maintenance. Start-up began on 840625. The generator was in service for approxi-mately 30 seconds when a turbine trip occurred due to a bypass valve closure followed by a reactor scram on high pressure. Repairs were completed and the Unit was back in service on 840627.

At the end of the reporting period, the FitzPatrick Plant is operating at approximately 596 MWe.

1 NEWYORK POWER AUTHORITY-JAMES A.FITZPATRICK NUCLEAR POWER PLANT FAINTENANCE

SUMMARY

June 1984 1

WORK REQUESTNO. HOW CAUSE GF RESULTS OF ACTION TAKEN REPAIR i DATE SYSTEM P T E COMPONENT NO. DETECTED MALFUNCTION MALFUNCTION yCU H R j

840625 00 029050 Spare IRM M Replace C1 & g2 JIC Old Capacitors ,

8 WA supnlles/ repair on both supplies i

l 840626 03 029632 OPS Broken wire Group light doenRprd cold solder (d 12 l 03-14-17 not light wire on brd 840618 03 031586 OPS Cwo diodes :: witch Gives RBM INOPS Returned diodes 10 18-39 3d on relay downscale to proper places Replaced relay l 840618 03 031590 OPS Faulty relay / Gives RBM INOPS card in Module

) 30-11 component problei downscale el S40623 03 024049 OPS Press. Ind/ switch Low oressure Performed IMP 3.5; 7 1 HCU 46-19 ut f alib. alarm to soon found no problem 1

840614 03 031501 OPc Defective relays RBM downscale Replaced defec- 4 l

30-39 K4A&B, MOD #1 when rod 30-39 tive relays i

840612 07 031608 OPS Switch housing Unable to get Tightened nut on l

I LPRM28-218 is loose out of oDerate switch l 840625 07 023474 OPS Age H 0 E M stops ReMace tb Mh g M TIP DR. A " ""7 " 8 '

840622 07 029144 JIC Power supply INOP found nearlsReolaced suoply 2 l IRM-C drift out of toler with stock rep.

I 840624 07 031463 OPS Black pen was ou1 Black een did Cal. both red & 2 l 67-R-45 of cal'. not reach 10 Sco black n_ ens 840621 10 029142 JIC Defective switch RHR PDIP switch Renlaced RHR pumt 8 PS-120A out of toler dischrg switch

- 840621 10 029142 JIC Defective switch Press Sw found Replace RHR pump PS-120A out of tolerance dischrg sw, tested 8

NEWYORK POWER AUTHORITY-JAMES A.FITZPATRICK NUCLEAR POWER PLANT MAINTENANCE

SUMMARY

JUNE 1984 ,

WORK REQUEST NO. HOW CAUSE OF RESULTS OF ACTION TAKEN REPAIR I A TO PRECLUDE TIME COMPONENT NO. DETECTED MALFUNCTION MALFUNCTION RECURRENCE HOURS 840624 11 031617 OPS Faulty lamn in Sticking relay Repled lamp / 16 11-67B the relay tested ,

t 840624 11 024234 OPS Coupling screws Light out when Tightened screws 2 ll-67A very loose still continuit tested lamp 840624 11 031617 OPS Burned out lamp Light out when Repled bulb 16 ll-67B still continuou s tested OK 840624 2-3 023455 JIC Worn valve Hi side vent Repled vent vlv; 4 LIS-57B leaks perf. ISP3-1 840607 27 029524 OPS Drive gear Strip chart Rpled: XFRMR, 64 BR-104A stripped recorder stickin gpower trans,  !

h,,11 on nv 840624 93 029]38 JIC .Tes t . returt.ed Tested fine; ut of toler- returned to PS-9B ance service 840624 93 029138 JIC Test eant re-

~

Pressure switch 4 PS-9B tuped out of tested fine Cal.

840612 99 027555 SEC SW not being Palm switch Chekd/uctking 5 A272-27 pressed in time causing problems procerly 840621 99 026089 SEC Faulty triac in Will not cycle / Rpled triac, 24

1. 1 heater ekt go into alarm lamn driver, adj 840621 99 026090 SEC Needed adjustmen : Constant sys Adj flow & sensi -

24

1. 2 fault /exn det # 2 tivity level e

d

. J:mes A. Fit:Pztrick Nuchir Powtr Pirnt Po. Brn 41 Lycorrurvj, New York 13093 315 342.3840

1. > NewYorkPower 4# Authority Memorandum ;

July 9, 1984 JAFP-84-0672 -

Director, Office of Inspection i and Enforcement U.S. Nuclear Regulatory Commission  :

i Washington, D.C. 20555 ATTENTION: DOCU'4ENT CONTROL DESK

REFERENCE:

DOCKET NO. 50-333 l

i

Dear Sir:

i l

The Operating Status Report for the month of June 1984 ,

is enclosed. The refueling information remains the same l as previously submitted.

t If there are any questions concerning this report, contact John Cook at (315) 342-3840, Ext. 439.

Very truly yours, CORBIN A. MC NEILL, JR.

CAM:JPC:caf cc: Internal Distribution Enclosures i 3

l 6

?

_ . . - . , . . - . _ . _ . _.-