ML20133D402
| ML20133D402 | |
| Person / Time | |
|---|---|
| Site: | Vogtle  |
| Issue date: | 05/16/1985 |
| From: | Grace J NRC OFFICE OF INSPECTION & ENFORCEMENT (IE REGION II) |
| To: | Kelly R GEORGIA POWER CO. |
| References | |
| NUDOCS 8507220193 | |
| Download: ML20133D402 (3) | |
See also: IR 05000424/1985006
Text
ell0th
.
MAY 161985
Georgia Power Company
ATTN: Mr. R. J. Kelly
Executive Vice President
P. O. Box 4545
Atlanta, GA 30302
,
Gentlemen:
SUBJECT:
REPORT NCS. 50-424/85-06 AND 50-425/85-06
Thank you for your response af April 16, 1985, responding to our Notice of
Violation issued March 18, 1985, concerning activities conducted under NRC
Construction Permit Nos. CPPR-108 and CPPR-109 at your Vogtle facility. We have
evaluated your response and found that it meets the requirements of 10 CrR 2.201
to the extent that your response acknowledged the violation. We have carefully
considered thp basis for your evaluation, and,for the reasons presented in the
enclosure to this letter, we have concluded that the violation was not completely
addressed.
Therefore, in accordance with 10 CFR 2.201(a), please submit to this office
within 30 days of the date of this letter a written statement describing steps
which have been taken to correct the violation and the results achieved,
corrective steps which will be taken to aboid further violations, and the date
when full compliance will be achieved.
It should be noted, that the Bechtel Power Specification No. X4AZ01, Division PS,
should be Section 5.9.3, not Section 5.9.2 as indicated in the violation.
We appreciate your cooperation in this matter.
Sincerely,
S\\
J. Nelson Grace
Regional Administrator
Enclosure:
Staff Assessment of Licensee Response
cc w/ encl:
R. E. Con n y, Senior Vice President
Nuclear Power
D, O. Foster, Vice President
and General Manager Vogtle Project
H. H. Gregory, III, General
Manager, Vogtle Nuclear Construction
G. Bockhold, Jr. , Vogtle
Plant Manager
(cc cont'd - see page 2)
0507220193 850516
ADOCK 05000424
a
-
35 0 l
\\
\\
.
Georgia Power Company
2
MAY 161985
(cc cont'd)
L. T. Gucwa, Chief
Nuclear Engineer
Ruble A. Thomas,
Vice President-Licensing Vogtle
Project
Ed Groover, Quality
Assurance Site Manager
C. W. Hayes, QA Manager
-
J. T. Beckham, V1ce President
& General Manager - Operations
J. A. Bailey, Project Licensing
Manager
George F. Trowbridge, Esq.
Shaw, Pittman, Potts and Trowbridge
Bruce W. Churchill, Esq.
Shaw, Pittman, Potts and Trowbridge
Ernest L. Blake, Jr., Esq.
Shaw, Pittman, Potts and Trowbridge
James E. Joiner, Troutman, Sanders,
Lockerman and Ashmore
James G. Ledbetter, Commissioner
Department of Human Resources
Charles H. Badger, Office of
Planning and Budget, Management
Review Division
Deppish Kirkland, III, Counsel
Office of the Consumer's Utility
Council
Douglas C. Teper, Georgians Against
Nuclear Energy
Laurie Fowler, Legal Environmental
Assistance Foundation
Tim Johnson, Executive Director
Educational Campaign for a Prosperous
Morton B. Margulies, Esq., Chairman
Administrative Judge, Atomic Safety
and Licensing Board Panel
Dr. Oscar H. Paris, Administrative Judge
Atomic Safety and Licensing Board Panel
Gustave A. Linenberger, Jr., Administrative
Judge, Atomic Safety and Licensing Board
Panel
bec w/ encl:
E. Reise, ELD
M. Sinkule, RII
NRC Resident Inspector
Document Control Desk
State of Georgia
f
RII
RI
RII
RI
RII
RI
.g
ias:sa
Blake
dt
PBemis
VBrownlee
Mbiker
ins J
shinski
g/d
/7 /85
5/9/8E
5/y /85
5/ 1 /85
5/g/85
5/1 /85
5/j
85
5/
85
..
.
ENCLOSURE
STAFF ASSESSMENT OF LICENSEE RESPONSE
The Notice of Violation addresses the requirement for the establishment of
measures to assure required documentation reflects "as-built" conditions of
supports so that a proper evaluation by the design engineers can be performed.
The installation-of filler plates in conjunction with pipe straps involves adding
a plate and welds which are subjected to tensile and shear forces. Neither the
welds nor the structural plate are addressed or documented in the final as-built
drawings or calculations.
It is our position that the filler plates used in pipe supports do nat come under
the tolerance criteria of paragraph P5.6.4 of Bechtel's specification X4AZ01 for
the modifications of the supports.
They are additional load bearing members
which should be acknowledged by the pipe support design engineers.
Therefore, for reasons stated above, documentation of pipe support filler plates
is required to complete the as-built support drawings and calculations.
.
,
-
,
-
,-
- - - , , , . -
-