ML20043A206
| ML20043A206 | |
| Person / Time | |
|---|---|
| Site: | Peach Bottom  |
| Issue date: | 04/30/1990 |
| From: | Baron M, Kankus R PECO ENERGY CO., (FORMERLY PHILADELPHIA ELECTRIC |
| To: | NRC OFFICE OF INFORMATION RESOURCES MANAGEMENT (IRM) |
| References | |
| CCN-90-14095, NUDOCS 9005210002 | |
| Download: ML20043A206 (14) | |
Text
.
N-90-14093 CC PHILADELPHIA ELECTRIC COMPANY Pl%Cll BOTTOM ATOMIC POWl:A STATION R. D.1. Box 208 Delta, Itnnsylvania 17314 P&W DorlthTHE PUG FR Of IRCELLENc (717) 4$6-7014 May 15, 1990 Docket Nos. 50 277 50 278 t
l U.S. Nuclear Regulatory Commission Document Control Desk r
l Washington DC' 20555
SUBJECT:
Peach Bottom Atomic Power Station Monthly Operating Report i
Gentlemen:
Enclosed are twelve copies of the monthly operating report for Peach Bottom Units 2 and 3 for the month of April 1990 forwarded pursuant to Technical Specification 6.9.1.d under the guidance of Regulatory Guide 10.1, Revision 4.
i Sincerely, j
'%fik.Nl hf cmc Enclosure ec:
R.A. Burricelli, Public Service Electric & Gas l
T.M. Gerusky, Commonwealth of Pennsylvania J.J. Lyash, USNRC Senior Resident inspector T.E. Magette, State of Maryland T.T. Martin, Administrator, Region I, USNRC l
H.C. Schwemm, Atlantic Electric t
l J. Urban, Delmaiva Power INPO Records Center i
i CON 90 NRC 9003210002 90043o,
gos p-aoOCx osOOO27 PDC
NRC Mnathly Operstless Summary Peach Bottom Atomic Power Station April 1990 UNIT 2 The unit bepan the month shut down with methities required for demonstrating Emergency Senice Water system operability m progress. Safety evaluations were approved and dual unit flow testing was accomplished on April
- 11. The mode switch was placed in Startup on April 17.
The generator was synchronized to the grid on April 21, but high vibration wiped both generator exciter bearings h
the same day. During the week, the bearings were replaced and the generator exciter was aligned. The unit was placed in Startup on April 28 and was synchronized to the grid the next day. The unit ended the month in the i
run mode with power increasing.
UNIT 3 Unit 3 began the month at 100% power and continued at that level until April 18, when it took a 100 MWe load drop for demineralizer backwash and precoating. The condensate demineralizers could not regenerate at full power because one demineralizer was out of service for repairs to the head gasket and drain valve. The unit was returned to nominal 100% power two days later. The unit ended the month at 99.5% power. The slight i
reduction in power was caused by condenser inefficiency.
l l
1 l
1 r
CCLM90.NRC
[
L-g s,
c
.+
OPERATING DATA REPORT DOCKET NO. 50 - 277' DATE MAY 15. 1990-COMPLETED BY PHILADELPHIA ELECTRIC COMPANY M. J. BARON ~
~, i SUPERVISOR REPORTS GROUP;
. PEACH BOTTOM ATOMIC POWER STATIDN l
TELEPHONE (717) 456-7014 EXT. 3321 r
OPERATING STATUS
- 1. UNIT NAME: PEACH BOTTOM UNIT 2 NOTES:
2, REPORTING PERIDOF APRIL, 1990 THE UNIT REMAINED SHUT DOWN FOR MOST
'3. LICENSED THERMAL POWER (MWT).
- 3293 0F THE MONTH FOR ESW FLOW TESTING.
- 4. NAMEFLATE RATING (GROSS MWE):.
1152
- 5. DESIGN ELECTRICAL-RATING (NET MWE)r 1065.
- 6. MAXIMUM DEPENDA8LE CAPACITY (GRD55 MWE): 1098-
- 7. KAXIMUM DEPENDABLE CAPACITY (NET MWE):
[h5b I
8.' IF CHANGES' 0CCUR IN CAPACITY RATINGS (I hMk NUMBER 3 THROUGH 7).$1NCE LAST REPOR
- 9. POWER LEVEL' TO WHICH RESTRICTED IF ANY (NET MWE):
f 4
- 10. REASONS FOR RESTRICTIONS.. IF ANY:
TH1$ MONTH YR-10-0 ATE CUMULATIVE-
- 11. HOURS. IN REPORilNG PERIOD
. 719 2.879 '
138.695
+
- 12. NUMBER OF HOURS REACTOR WAS CRITICAL' 138.6 1.556.4 81.082.7
- 13. REACTOR RESERVE SHUTOOWN HOURS 0.0 O.0 :
0.0
- 14. HOUR $ GENERATOR ON.LINE 46.9-1.445.6'
- 78.050,8L
- 15. UNIT RESERVE SHUTDOWN HOUR $
0.0
- 0.0 0.0
- 16. GROS $ THERMAL ENERGY GENERATED (HWH) 87.552.
4.0$0.624 :
229.346.817
- 17. GROSS ELECTRICAL ENERGY GENERATED (MWH) 11.800' 1.320.200.
.75.380.090.
18.NETtLtCTRICAL-ENERGYGENERATED(MWH)-
5.990 11.271.1241 72.125.973
- PAGE 1 0F-2 h
b j
u-s a:;
m
+
r
',1 l
g i
i r
- p OPERATINGDATARfPORT(CONTINUCD).
iDOCKET NO. $0 - 277:
~
Daft MAY 15,'1990 THl$ HDNTH1 YR O-DATE;
- CUMULATIVE.
g-T r
- 19. UNIT, SERVICE FACTOR =
6.5 50.2. 6 -
' $6.3 :
- 20. UNIT AVAILABillTY TACTOR ?-
- 6. 5 -
' 50.2.........'.....
56.3) 21.. UNIT.CAPACITYFACTDR(USINGMDCNET) 0.8=
4
- 41.8.
49.3
~v
- 22. UNIT CAPACITY FACTOR (U$1NS DER NIT)!
' O.8.,
'41.6
'48.8
- 1 -
. 23. UNIT FDRCEO OUTAGE RATE -
- 93.5' 133.7 14.9
.........e..
- p;
- 24. $HUTDOWNS SCHEDULEO OVER NEXT 6 MONTHS' (T,YP[, DAT(,(AND DURATION OF. [ACH): -
!$. IF $HUTDOWN AT tND OF' REPDRT PERIOD,.tsTIMATED DATE OF STARTUPs.
i 26.' UNITS IN TEST STATUS (PRIOR TO COMMERCIAL OPERATION):
FDRECAST 'ACHIEVt0-INITIAL CRITICALITY 09/16/73 4
INITIAL ELECTRICITY-
'02/18/74.'
1 COMMERCIAL DPERATION.
07/05/74-PAGE 2 0F 2 s
4 I
i Y.l t
I s
r l j
t-(
i 4
OPERATING DATA REPORT DOCKET NO. 50 - 278"
..c..........................
DATE KAi IE;1990 L'
' COMPLETED BY PHILADELPHIA ELECTRIC COMPANY l M. J.-BARON-G:
1 SUPERVISOR REPORTS GROUP
' PEACH BOTTOM ATOMIC POWER $TATION-
. TELEPHONE (717) 456 7014 EXT. 3321 -
~
GPERATING $TATUS=
3"
- 1. UNIT NAME: t!ACK BOTTOM UNIT 3 NOTES:
i
-2. REPDP. TING PERIOD '....APRll, 1990
'3.LICENSEDTHERMALPOWER(MWT):
3293 4.NAMEPLATELATING(GROS $MWE):
'1152.
'$.DESIGNELECTRICALRATING(NETMWE):
1065?
- 6. MAXIMUM DEPENDABLE CAPACITY (GROS $ MWE):11098 7 NAXIMUM DEPENDABLE CAPACITY (NET MWE):
1035'
'B.
IF CHANGFS DCCUR IN CAPACITY RATINGS (ITEMS NUMBER.3 THROUGH 7) SINCE LAST REPORT, GIVE REASDNS 9, POWER LEVEL TO WHICH RESTRICTED, IF ANY (NET MWE):
- 10. REASONS FDR RESTRICTIONS, IF ANY:
- i THl$ MONTH YR TO-0 ATE-
~ CUMUL'AilVE l-
- 11. HOURS IN REPDRTING PERIOD 719 -
2,879-
.134,591 o
'12. NUMBER OF HOURS REACTOR VAS CRITICAL 719.0
,2,710.5-79,869.3
- 13. REACTOR RESERVE SHUTOOWN HOURS 0.0 0.0..
0.0 :
i
- 14. HOUR $ GENERATOR ON LINE 719.0-2,642.8
'77,045.0?
v
.s..........
e
'15. UNIT RESERVE $HUTDOWN HOUR $ -
0.0
- 0.0 '
- 0.0
}
1; 16.GR0$$THERMALENERGYGENERATED(MWH) 2,357,832?
8,397,3411. 224,560,210-
^
t 17.GROSSELECTRICALENERGYGENERATED.(MWH) 781.200 12,790,300
.73,662,432 l
18.NETELECTRICALENERGYGENERATED(MWH) 755,823 2,706,333.
70,548,901
~PAGE 1 0F 2 l..
4
,g I
1 Y$
I
-s w
7-_---_____--------
l l-l-l OPf. RATING DATA REPORT (CONTINUED)
DOCKET NO. 30 - 278 DATE KAY 15, 1990 THis MONTH YR TO-DATE CUhuLA'1VE 19.-UNIT SERVICE FACTDR 100.0 91.8
$7,2
- 20. UNIT AVAILABILITY FACTDR 100.0 91.8
$7.2
- 21. UNIT CAPACITY FACTDR (USING MDC NET) 101.6 90.8 50.6 22.UNITCAPACITYFACTDR(USINGDERNET) 98.7 88.3 -
49.2
- 23. UNIT FDRCEO OUTAGE RATE 0.0 8.2 13.1
- 24. SHUTDOWNS SCHEDULED DVER NEXT 6 MONTHS (TYPE. DATE, AND DURATION OF EACH)
MIL-CYCLE MAINTENANCE OUTAGE STARTING DCTOBER 27 SCHEDULED FOR 21 DAYS.
25,1F SHUTDDWN AT END OF REPORT PERIOD, ESTIMATED DATE OF STARTUP:
26.UNITSINTESTSTATUS(PRIORTOCOMMERCIALOPERATION):
FORECAST. ACHIEVED INITIAL CRITICALITY 08/07/74 INITIAL ELECTRICITY
-09/01/74 CDMMERCIAL OPERATION 12/23/74 l
a f
l
Docket No. 50-277 Attachment to.
Monthly Operating Report for April 1990 UNIT 2 REFUELING INFORMATION 1,
Name of facility:
Peach Bottom Unit 2 2.
Scheduled date for next refueling shutdown:
Reload 8 scheduled for January 6,1991 3.
Scheduled date for restart following refueling:
Restart following refueling scheduled for April 5,1991 4.
Will refueling or resumption of operation therefore require a technical specification change or other license amendment?
Yes.
If answer is yes, what, in general, will these be?
Reload amendments for cycle 8.
L 5.
Scheduled date(s) for submitting proposed licensing action and supporting information:
To be determined.
6.
Important licensing considerations associated with refueling, e.g., new or different fuel design or supplier, unreviewed design or performance analysis methods, significant changes in fuel design, new operating procedures:
In order for PECo to do reload licensing analyses in-house for Unit 2 Cycle 9, NRC approval of one report (PECO-FMS 006) must be obtained by May 31,1990. This report is the last in a series of six reports to demonstrate PECo's ability to perform the analpes. The report has.
been submitted and is scheduled for completion in May 1990.
7.
The number of fuel assemblies (a) in the core and (b) in the spent fuel storage pool:
(a)
Core 764 Fuel Assemblics l
(b)
Fuel Pool.1734 Fuel Assemblies,58 Fuel Rods Docket No. 50-277 i
CCl490 NkC
Attachment to Monthly Operating -
Report for April 1990 Page 2 UNIT 2 REFUELING INFORMATION (Continued) 8.
The pret.cnt licensed spent fuel pool storage capacity and the size of any increase in licensed storage
. capacity that has been requested or is planned, in number of fuel assemblies:
The spent fuel pool storage capacity has been relicent.ed for 3819 fuel assemblics.
9.
The projected date of the last refueling that can be discharged to the spent fuel pool assuming the present capacity:
September 2003 without full core offload capability.
September 1997 with full core offload capability.
i CCnt90.NRC
Docket No..%278 Attachment to Monthly Operating Report for April 1990 UNIT 3 REFUELING INFORMATION 1.
Name of facility:
Peach llottom Unit 3 2.
Scheduled date for next refueling shutdowti:
Reload 8 scheduled for August 31,1991 3.
Scheduled date for restart following refueling Restart following refueling scheduled for Ncveraber 29,1991 4.
Will refueling or resumption of operation thereafter require a technical specification change or other license amendment?
Yes.
If answer is yes, wiiat, in general, will these be?
Reload amendments for cycle 8.
5.
Scheduled date(s) for submitting proposed licensing action and supporting information:
To be determined.
6.
Important licensing considerations associated with refueling, e.g., new or different fuel design or supplier, unreviewed design or performance analysis methods, significant changes in fuel design, new operating procedures:
In order for PECo to do reload licensing analyses in house for Unit 3 Cycle 9, NRC approval of one report (PECO-FMS4M; must be obtahied by May 31,1990.. This report is the last in a series of six reports to demonstrate PECo's ability to perform the analyres. The report has been submitted and is scheduled for completion in May 1990.
7.
The number of fuel assemblics (a) in the core and (b) in the spent fuel storage pool:
(a)
Core - 764 Fuel Assemblics (b)
Fuel Pool 1496 Fuel Assemblics,6 Fuel Rods CON 90.NkC
l.
Docket No. 50-278 Attachment to Monthly Operating Report for April 1990 Page 2 UNIT 3 REFUri ING INFORMATION (Continued) 8.
. The present licensed spent fuel pool storage capacity and the size of any increase in licensed storage capacity that has been requested or is planned, m number of fuel assemblies:
The spent fuel pool storage capacity has been relicensed for 3819 fuel assemblics. Modification of the fuel pool is expected to be complete in the fourth quarter of 1990.
9.
The projected date of the last refueling that can be discharged to the spent fuel pool assuming the present capacity:
With the current fuel pool capacity (prior to the completion of the fuel pool rcracking modification):
September 1996 without full core offload capability.
End of next cycle with full core offload capability (est. January 1991).
With increased fuel pool capacity (subsequent to the completion of the fuel pool reracking modification):
September 2004 without full core offload capabill:y.
September 1998 with full core offload capability.
l l
I i
CCH90.NRC
^ ^ ' "
R.
~
cT
,!l
,~
t r
s q:l
!: c,
r
--.4_
.j 7,
e y,
4 AVERAGE DA!LY' UNIT POWER LEVEL' i
4-DOCKET NO. $0 277-UNIT. PEACH BOTTOM UNIT 2-DATE MAY 15,:1990:
'43,'
_ COMPANY PHILADELPHIA ELECTRIC COMPANY.
H. J. BARON ~
v
--SUPERVISOR-REPORT $ GROUP '
PEACH BOTTOM ATOMIC POWER STATIONS i
' TELEPHONE (?!?) 466 7014 EKT, 3321 1
4 s
?
MONTH APRll 1990 t
f 0AY'. AVERAGE DAILY POWER LEVEL-D DAY.. AVERAGE DAILY POWER LEVEL-'
'(MWE-NET)
,(MWE. NET)-
+
1 0
'17 0
T
-~
18.
0 _
-2f
.0
.1--'
E 3
0 19-0-
4 0
'20
. O'
- (
- 5:
0=
21.
19
'6
.0-
. 22 0
3
- 7' O
23 0
r.
8 0
' 24 0
9.
0" 25.
'O'
',M 10 0-26 0=
1 t
11 0-27
~
01 v
12 0
28 -
0
+
-y- >
l 13 0
29
~110'
..,m e.-~
p.
r\\:
1
' ~
14 0
30 316 i
l..
15 0
e~i 16 0'
ds t
)
Y,g...
'I- ;
t p
I e
i N
'(
i
+; 1.
t-r
(
5
.l 4
v f
1 4
Q_e
- . (_
AVERAGE DAILY UNIT POWER LEVEL DOCKET NO, 50 - 278 3
UNIT PEACH BOTTOM UNIT 3-
- i
- DATE MAY 15, 1990
[COMPANYPHILADELPHIAELECTRICCOMPANY M J. BARON
' SUPERVISOR
.- )
REPORTS GROUP PEACH BOTTOM ATOMIC POWER STATION I?u1 HONE (717)' 456-7014 EXT. 3321 MONTH APRl![1990 DAY.- AVERAGE DAILY P E P, LEVEL DAY.'
AVERAGE DAILY POWER (EVEL (HWE-NET)<
.(MWE-NET)-
1 1022 17 1017 2
1013
.18-1048-3 1051 19 1038 4
1065 20 1049
/
5 1065 El 1056 6
1066 22 1052 i
7 1062 23 1052 i
8 1070 24 1051
}
9 1065 25 1037 1
i 10 106,6 26 1028=
i 11 1054 27 1024' 12 1073 28 1018 13 1062 29 1020 i'
14 1070 30 1021 15 1062 j
16 1107 i
-1 I,
1 r,
tf i
1 UNIT SHUTDOWNS AND POWER REDUCTIONS DOCKET NO. 50 - 277 UNIT NAME PEACH BOTTOM UNIT 2L DATE MAY 15. 1990 REPORT MONTH APkil '1993 COMPLETED BY PHILADELPHIA ELECTRIC COMPANY
-M. J.' BARON SUPERVISOR-REPORTS GROUP PEACH BOTTOM ATOMIC POWER STATION TELEPHONE (717) 456-7014, EXT. 3321 1
METHOD OF-
' LICENSEE.
SYSTEM COMPONENT CAUSE AND CORRECTIVE TYPE DURATION REASON SHUTTING DOWN EVENT -
CODE CODE ACTION TO'
. NO.
DATE (1)
(HOUM)
(2)
REACTOR (3).
. REPORT #
(4)
(5)
PREVENT RECURRENCE
- 5 900401 F
481.5 0
1
-N/A' XX XXXXXX ESV FLOW NEW ST AND SAFETY EVALUATION.
~
6 900421 F
190.6 A
4 N/A-HA
-TURBIN.
' TURBINE MANUALLY TRIPPED DUE TO HIGH-VIBRATION. REACTOR WAS NOT SHUT DOWN.
i 1
672.1
]
d 1
-i (1)
(2)
(3)
.(4) j i
F - FORCED REASON METHOD EXHIBIT'G. INSTRUCTIONS-
- $ - SCHEDULED A-EQUIPMENTFAILURE(EXPLAIN) 1 - MANUAL-FOR PREPARATION OF DATAa B - MAINTENANCE OR TEST 2. MANUAL SCRAM.
ENTRY SHEETS FOR LICENSEE C - REFUELING 3 - Alff0HATIC SCRAM.
EVENTREPORT(LER) i D - REGULATORY RESTRICTION 4 - OTHER-(EXPLAIN)
FILE (NUREG-0161) 1 E - OPERATOR TRAINING + LICENSE EXAMINATION
.F.- ADMINISTRATIVE (5)
G-OPERATIONALERROR(EXPLAIN)
H-OTHER(EXPLAIN)
EXHlBli 1. SAME SOURCE
.j 1
1 I
-e 1
3 l
l i
.I'
i
- 1. '
.. A
,,,-.s**
i
' UNIT SHUTDOWNS AND POWER REDUCTIONS
- DDCKET NO. 50 - 278 UN.fi NAME PEACH BOTTDM UNIT 3 DATE MAY 15, 1990 REPDRT MONTH.. APRIL, 1990 CDMPLETED BY PHILADELPHIA ELECTRIC COMPANY,
M. J. BARON -
, SUPERVISDR -
REPDRTS GROUP
?
PEACH BOTTOM ATOMIC POWER STATION
TELEPHONE (717)456-7014 EXT,3321-METHOD OF
' LICENSEE SYSTEM COMPONENT CAUSE AND CDRRECTIVE TYPE DURATION REASON SHUTT!hG 00VN EVENT CODE CODE ACTION TO NO.
DATE (1)
. (HOURS)
(2)
REACTDR (3)
REPDRT #
(4)
(5)
PREVENT RECURRENCE
~
J 4
(1)'
(2)
(3)
.(4)
F - FDRCED REASON METHOD EXHIBIT G - INSTRUCTIONS S -SCHEDULED' A - EQUIPMENT FAILURE (EXPLAIN) 1 - MANUAL FOR PREPARATION OF DATA B - MAINTENANCE DR TEST' 2 - MANUAL SCRAM.
- ENTRY SHEETS FOR LICENSEE.
C - REFUELING 3 - AUTOMATIC SCRAM.
EVENTREPORT(LER) 0 - REGULATORY RESTRICTION 4 - OTHER (EXPLAIN)
FILE-(NUREG-0161)
E - OPERATOR TRAINING + LICENSE EXAMINATION F - ADMINISTRATIVE
.(5)!
G-OPERATIONALERRDR(EXPLAIN)
H-OTHER(EXPLAIN)
EXHIBIT I - SAME SOURCE
'h 1
L
-i
!=
4 l
a i
a
.i
< z
.