JAFP-84-1040, Monthly Operating Rept for Oct 1984

Monthly Operating Rept for Oct 1984

ML20099C654
Person / Time
Site:	FitzPatrick
Issue date:	10/31/1984
From:	Jackie Cook, Glovier H POWER AUTHORITY OF THE STATE OF NEW YORK (NEW YORK
To:	NRC OFFICE OF ADMINISTRATION (ADM), NRC OFFICE OF INSPECTION & ENFORCEMENT (IE)
References
JAFP-84-1040, NUDOCS 8411200012
Download: ML20099C654 (17)

Text

W .,

.c t

k ,

OPERATING DATA REPORT i DOCKET NO. 50-333 DATE Nov 1984 COMPLETED BY J. Cook TELEPHONE (315)342-3840 OPERATING STATUS FitzPatrick Notes 1.Ud h

2. Reporting Period: 841001 --841031

3. Licensed Thermal Power (MWt): 2436

4. Nameplate Rating (Gross MWe): 883 >,

5. Det}p Electrical Rating (Net MWe): 821 s

6. Maximum Dependable Capacity (Gross MWe): 830

7. Maximum Dependable Capacity (Net MWe): 810

8. If Changes Occur in Capacity Ratings (Irems Number 3 Through 7) Since Last Report, Give Reasons:

NONE

• d.,

9. Power Level To Which Restricted,if Any (Net MWe):

10. Reasons For Restrictions,If Any:

This Month Yr.-to-Date Cumulative I1. Hours In Reporting Period 745 7320 81217

12. Number Of flours Reactor Was Critical 50.4 5763.4 36292.Z

13. Reactor Reserve Shutdown Hours 0 0 0

14. Hours Generator On-Line 0 5578.8 56778.4

15. Unit Reserve Shutdown Hours 0 0 0

16. Gross Thermal Energy Generated (MWH) 0 12825528 120562114

17. Gross Electrical Energy Generated (MWH) 0 4269330 41488520

18. Net Electrical Energy Generated (MWH) 0 4133175 39631815

19. Unit Service Factor 0 76.2% 69.9%

20. Unit Availability Factor 0 76.2% 69.9%

21. Unit Capacity Factor (Using MDC Net) 0 69.7% . 63.5%

22. Unit Capacity Factor (Using DER Net) _ 0 68.8% 59.4% .

23. Unit Forced Outage Rate 0 4.7% 13.7%

24. Shutdowns Scheduled Over Next 6 Months (Type.Date.and Duration of Each):

4 Refueling outage scheduled for January 25, 1985 to last approximately 60 days.

25. If Shut Down At End Of Report Period. Estimated Date of Startup: November 7, 1984

26. Units in Test Status (Prior to Commercial Operation): Forecast Achieved INITIAL CRITICALITY INITIAL ELECTRICITY COMMERCIAL OPERATION < \

8411200012 841031 PDR ADOCK 05000333 ,

R PDR

[ .

r , -f3YER ACE DAll.Y UNIT POWER LEVEL DOCKETNO. 50-333 WIT FitzPatrick

\ \

DATE November, 1984 J. Coolc COMPLETED.BY

~ .

TELEPHONE (315)342-3840 , [

4 i g .

MONTH O'ciOBER1984

. DAY ' AVERAGE DAILY POWER LEVEL DAY AVERAGE DAILY POWER LEVEL (MWe-Net) .

(MWe-Net) g 0 0

1. g7 2- *0 gg 0 0 0

. 3 ,,

4 0 20 0 4 0 s 0 5 ' 21 U U 6 n 7 U O D'

O O 8 24 9

0 3 'O 2

10 0 26 0 0 0

. 11 27 12 U

s U \

13 0 0 l 29 14 30

. s 15 0 3g 0 0

16 _,'

. }  ;

SUMMARY

The Unit remained shutdown this month for IHSI and general plant maintenance.

• e

~/

Y P

& -- - ..m. e. mm1 m, _ _:.,,.---,v- .

n. - . .__P_-

- UNITSilUTDOWNS AND POWER REDUCTIONS DOCKET NO. 50.-333

. UNIT NAME FitzPatrick DATE Nov. 1984 REPORT MONTil October 1984 COMPLETED BY .T. ('nnk TELEPilONE ' (315)342-3.840 e.

No. Date g

.! E 3y .Yh I Icensee E

% Cause & Curreceive

, 3g ,3 g 5 Event g'ir Action to H

5 u!

dE 3gc Repurs ar in U n. } .

.  ! Prevent Recurrence 6 '

12 8410'01 S 745 B 1 N/A N/A N/A ,840915 Shutdown for maintenance a'nd 1HSI (cumulative hrs.1121) z.

I 2 3. 4 F: Forced Reason: Method:

S: Scheduled A. Equipment Failure (Explain) Exhibit G . Instructiims 14fanual for Preparation or Daia

n. Maintenance of Test 2. Manual Scram. Entry Sheels for 1.icensee C. Refueling 3. Automatic Scram.

D. Regulatory Restriction Event Report (1.ER) File INUREG.

4.Other (Explain) 0161)

E. Operator Training & License Examination F.Adminisitative 5

G Operaliunal Error (Explaint ll Olhe' r IExplain) Exhibit i .Same Source 1

-m'

.n

, .j. ,

'M- r e

s C - NARRATIVE

SUMMARY

'0F OPERATING EXPERIENCE OCTOBER 1984 l 4 1 The FitzPatrick plant remained shutdown' for the montti to , conduct In' duction i l Heat Stress Improvements and general' plant maintenance'.

~

j f ;Startup commenced on October 29th'and the unit:is expectad to return to

( service on November 7,1984~.

_r-2

'?

-)

A 4

/

.l

s J

NEWYORK POWER AUTil0HITY-JM1ES A.FITZPATRICK NUCLEAR POWER PLANT

, _LIAINTEllAllCE .SUA1h1ARY L OCTOBER, 1984 ,

WOHitHEQUESTNO. Il0Y/ CAUSE OF HESULTS OF Acil0N TAltEN HEl' AIR DATE SYSIEh1 4 00A1PotlENT fl0. DETECTED A1ALFUNCTi0fl I E ' E b1AI. FUNCTION gjCR 0R .l 841026 00 026469 I&C Bad Cal. and Diode IRM Drawer has Replaced Cal. &' 80 SPARE Logic Card Pioblem Diode Logic Card f

t 841010 00 029130 16C Broken by.Foxboro Replace Static Install Static .5 SPARE Rep. Allignment Screw Allignment Screw 841031 01-125 037155 OPS Bad Filter DP Guage Reading Changed Filter 1 01-125-F-1A .8 Should Alarm 841001 02 029176 I&C Removed From 09-45 Verify Functions Tested Relay-Return 2 2E-K5A During Maintenance Proper 1'y to Stock 841009 02 029510 OPS Unknown s . Perform Cal Check Performed Steps 16 02FT110C-H & Recalibrate of ISP-63-1 841023 02 026471 I&C N/A SRV Acoustic Test / Replaced C&L Active 37 02-RV-71 (ALL) Repair Monitoring G' Passive System Transducers 841009 02 033948 OPS Unknown Passive Transducer Verified Acc 4 02-RV-7111 Out of Spec Reading (ST221 i

841029 0' 2 037301 OPS Unknown Timer Times in 107 Reset Timer to 116 2 2EK5A Sec. 841014 02-3 023084 I&C Position of Switch F-ISP-77 Couldn't Repositioned Switch 4 ^l LITS-73 In Yarway Reset Lo Trip. in Yarway 841014 02-3 033934 OPS Span on Level Recorder Eq-193, Adjusted Span .

i 02-3-LR-98 Recorder Off Feed Eq) 200  !

841025 02-3 037311 OPS N/A Not Tracking Performed Steps of 20 LT-86 Properly IMP 2-3.4 840929 02-3 029116 I&C Inst-ument Drift Transmitter Switch Replaced With New 28 LIS-101D (Switch Set.Pt. O'ut of Tol. From Factory '

• t

~

. ~

HEWY0llK POWEll AUTil0lllTY-JAhlES A.FITZPATillCK NUCLEAll POWEll PLANT-8 MAINTENAtlCE

SUMMARY

j, UL 1Ushtt, l'J O +

1

• DATE SYSTEM W0ltK REQUEST NO. Il0W CAUSE OF RESULTS OF ACTION TAKEN HEPAIR COMPONENI No. DETECTED MALFUNCil0N P MALFUNCTION yC 0 RS

, 841002 03 023814 I&C Mispositioned Wires SWT. Cover Rubbing Repositioned Wires 6 i.

03-LS-231E On Wire

.g 841004 03 037382 OPS Bad Rod Selector ~ 2 Rods Can be Replaced Rod 6 -l-Rod 34-27 Switch Selected at Once Selector Switch l'

841014 03 _

036270 OPS Enclosure Assembly Water Leakage Into Tightened and 7 LS-231B Leak Switch llous. Reinstalled Encl Assembly .

841017 03 029182 I&C Intermittent Replace Switch Replaced Defective 8 NA , Operation (Rod Select Switch) Switch 841007 05 023015 I&C Modiflcatipn Replace Relays on Performed F-ISP-60 220 IlFA Relays MI-84-080 "A" RPS Syst "A" RPS 841005 06 023081 I&C - Setpoint Inaccuracy Adjust Switch Performed 5.3 of 2

LR/PR-9 7 Setpoint ISP-5-4 ,

p

,p 841003 07 037156 OPS CRD Work-Cable A SRM Reading Replaced Cable 6 ~,

NM-31A Pulled Downscale Connector

_ ,I 841003 07 037378 OPS Bad Cable Connector Dectector Cable Replaced Cable 8 11 IRM Pulled Free Connector 841029 07 033600 OPS Out of Adjustment Check Drive Speed Adjusted Tip Drive 10 l!

7- NM-101AD On Tip Mech Mechanisms 841012 07 037249 OPS Short in Cable "11" IRM Went Burned Short Out of 66 i

II IRM - Upscale In-Op Cable  !

841005 07 034146 OPS Bad Cable Connector Replace Connector Replaced Cable 2 S,,LPRM20-13C Connector 841004 07 023044 I6C Bad Connector Repair Undervessel Replaced Connector 2 LPRM20-37A Connectors ' ,.

i . .

4 NEWY0 ilk POWEll AUTil0lllTY-JAhlES A.FITZPATRICK NUCLEAll POWER PLANT l , MAINTENANCE

SUMMARY

OCTOBER, 1984 ,

DATE UESJ NO. Il0Y/ CAUSE OF RESULTS OF. ACTION TAKEN REPAIR SYSTEM COMPONENT No. DETECTED MALFUNCil0N MALFUNCTION 10 PHECLUDE TIME HECURRENCE il0URS 841004 07 023045 I6C Bad Connector 7

Repair Undervessel Replaced Connector 2 l LPRM12-21A Connectors

~ .

841004 07 028313 OPS Loose Connector LPRM Reading ^

Cleaned & 6.5 LPRM44-37C Downscale-Bypassed Reconnected 841010 07 034096 OPS Dirty Connector LPRMDrift1Eg Cleaned Performed 9 LPRM12-45D Plateau Cury 841010 07 034105 OPS Dirty Connector Reading Between Cleaned, Performed 17 36-3/3 25&50% While SD Plateau Curv 841012 07 023083 16C Noisy Power Sypply ISP-71 Voltage Replaced Caps 12 1RM-E Drifted C1&C2 & Trim Pot i 841016 07 O_33,520 OPS Defective Switch RBM Monitor Didn't. Replaced Rod Select 8 NM-82B Read Rx Pwr Switch 841005 07 034144 OPS To Compensate For Need Count Performed Step 2 APRM A Correct # of* Input Circuitry Reset Of IMP 7.6 841013 07 337190 OPS INOP CKT Activated C APRM Failed to Adjusted Count CKT 8 APRM C By Count CKT Operate Prop

_. '841010 07 024728 OPS Dirty Connector LPRM 36-29C Drifted Cleaned & Repaired 9 LPRM36-29C Upscale Ran IMP 7.22 841010 07 024735 OPS Unknown Spiked Upscale Ran IMP 7.22 &T.D.R 9 i - lpm 4 04-21A ,

a 841017 07 037207 OPS Inst. Drift 125 Meter only Coes Adjusted IRM Drawer 4

, A IRM to 117 per IMP 7.3 841005 07 028532 I&C Normal Maint. P lac Indexers Indexers 23

. INDEXERS g Whebu lt i . .

+

NEWYORK POWER AUTil0lllTY-JMlES A.FITZPATRICK NUCLEAR POWER PLANT

_MAINTEllANCE .

SUMMARY

, OCTOBER, 1984 ,

A W0ltK REQUEST NO. IIOYI CAUSE OF RESULTS OF ACTION TAKEN REPAIR DATE SYSTEM COMPONENT No. DETECTED MALIUNCTIDH MALFUNCTION TO PRECLUDE TIME-

'ilECURRENCE Il0URS i 841023 07 023086 I6C Many Problems in Reading Different - Replace IRM "A"- 60

' IRM-A The Drawer Than O'hers t With New Unit See WRED 00/026469

841023 07 023048 I&C Age Check Operation Replaced Tip Purge

' 32 NM-113 Valve i

841014 10 023305 OPS Changing Light Has Burned Out XFMR Replaced CTRL Box 70 10-LS-105B Bulbs W/0 Isolt or Circuit & CTRL Board

841017 10 027188 OPS Instrument Drift Did Not Indicate Adjusted Cain 6 Ls-103 Dry 841023 12 036247 OPS N/A-Tech 9pec e Change Set Pt. Of Performed ISP-9 6 j TS-139 Change Temp. Switch

! 841025 16 037229 OPS Bad Relay Card Conflicts W/ Other rep aced Relay l 24 PODIT M101 Indications Card l'

841024 16 037305 OPS Slow Leak X-104 Requires Recharged to 30 1.5-X-104D Recharging PSIA 841028 '17 034160 OPS Meter Not Adjusted Reading To Low, Adjusted Zero On 9 RM-150B Failed F-ST-11 Meter 1 841014 17 037243 OPS Bad Switch Rad Monitor Replaced Defective 30 I

RIS-456B Response Erratic Switch i 841004 23 024004 OPS Instrument Not Indicates Flow Equalized 2 l

8 FIC-108 Equalized W/ HPCI Off Instrument

. 841005 23 023080 OPS' Transmitter Re-Orient Test Rerouted Piping 4 PI-96 Installed Below Vlv Drain Valve As Instructed

'l 841024 23 037237 OPS Loose Screws LS Does Not Shut Tighten Switch 3 j LS-90 23-A0V-53 Screws That Hold I

, u4 , .

1llllllll)lll Il \ l lll llll ll l l!!I RIE S R 2 AMU l'

1 2 ETl I0 R i s

NEE he E

d n

K DC tc u UN i o ALE TCR ws F

T N R E R S r m N o e 0 U lP d t l A C ei b L I C OE cn o P ao r A TH lM p

P R e n o E RO N W e O r P A R F N s A OI O e e g

E T ht cn a L S T C t e t n C L N i t l o _

U U U wt oi _

N S F Si m

Vt a

E L er C c K R A ge Di C Y M nt d I

an on R RA RI NI .

T A M P M ,

Z U T S. N I

FO F .E 4 OI T C 8 A N 9 E C .

S A 1 S N E N ,

U FU e n 1 E R A L g w h T E CA A o A N I B

O M /

e k n

T s n J-Y A

M C

O U U T

l D l

E WT l

0 C S S l

i 0 E P P T l O O I

T U E A D R

E .

O W N o B,

O T _N A P 7 1 9 I 4 0 3 2 Kl U N 0 1 1 -

i E 3 - 4 C 0 N 2 Z 3 B Y 0 A 0 I O H .

WE U I

P M

N O C

M E

7 1 .

T 2 7 -

^

S Y

S 8 9 E 1 0 T 0 0 1 1 A 4 4 D 8 8 i

i

JAMES A. FITZPAT HICK NUCLEAH POWt:.H PLANI

.  : .y . .s.s '

=

l SAFETY RELATED ELECTRICAL a MECl4ANICAL MAINTENANCE SUMMART

..1.u .;

f f[r *.1.?6 DATE SYShEM M REMSU HOW DETECTED CAUSE OF MALFUNCTION ACTION TAKEN TO PREQ UDE RECURRENCE T ME COMPONENT # -

, HOUR' 10/8 02 37338 OPS Pilot Sea,t Leak ' Replaced pilot assembly 24 RV 71E -

9/16 00 27052 N/A No malfunc, '

tion Visual snubber inspection 22 Snubbers 9/14 10 25474 Visual Low fluid level Replaced snubber 1 Snubber -

10-15A-S-306 .

10/2 02 25481 Visual fluid drained out Re fill ed and function 4 Snubber while removing fo r tested 02-2 o t h e r wo. rk S-8 e

10/2 02 25479 Visual Damaged while Replaced snubber 4 02-2 removing fpr other S-8 work 1 e

e e

4 JAMES A. FITZPAiHICK NUCLEAH POWt.H PLANI

, g

, .N SAFETY RELATED ELECTRICAL 'S MECHANICAL MAINTENANCE SUMMART

.: $;7.Ihh WORK REQUEST # IME ACTION TAKEN TO PRECLUDE RECtflRENCE DATE SYSTEM HOW DETECTED' CAUSE OF MALFUNCTION COMPONENT # -

, HOUR!

'10/3 00 25475 Visual Loose parts Tightened paddles, jam nuts 12 Various ,. and pipe clamps snubbers ,

10/9 93 25359 N/A N/A - Modified generator 90 EDG C heaters and air barfIe 10/7 93 26784 OPS Broken fuse block Replaced fuse block 1 Bkr.

10512 10/7 93 31596 Visual Flexible conduit Replaced conduit- 6 C-EDG torn 9/23 03 23421 OPS Faulty position Replaced probe 10 CRD indication. probe 23 ,

m 9/21 13 21168 N/A N/A -

l Replaced motor torque and 40 MOV-15 limit switches fo r environ-mental qualification

(

9/16 23 23919 UPS Misadjusted contac- Replaced torque and limit 62 MOV-58 tot interlock switches, adjusted contactor

. interlock I

I

~

....9

JAMES A. FITZPATRICK NUCLEAR POWEH PLANI

~-

f'  %.s

=

,j ,N SAFETY RELATED ELECTRICAL 'a MECHANICAL MAINTENANCE SUMMART Q)};.N DATE SYSTEM M REMST # HOW DETECTED CAUSE OF MALFUNCTION ACTION TAKEN TO PRECLUDE RECURRENCE- IME COMPONENT # '

, HOURf

,10/11 02 31180 Hi, Temperature - Replaced pilot 84 RV-71C leaking pilot -

10/9 24 37.542 OPS Bent li nk.a g e Straightened linkage 15 E001 ,

10/9 93 25560 N/A N/A Modify generator heaters 90 EDU A ,

and air barfle 10/7 71 34149 OPS Dirty actuator "

Cleaned-

• 14 ICB-2 i 10/8 71 22602 OPS Broken light socket Replaced socket 2 10550 Breaker - -

e s 10/8 71 24560 UPS Broken fuse block Replaced fuse block 1 10530 1 Breaker 10/17 15 37335 OPS Sheared key . Replaced key 2 MOV-102 ,

10/22 15 37177 OPS Misadjusted limit Readjusted limit switch 2

. SOV-215 switch

--.e

JAMES A. FITZPATHICK NUCLEAR POWEH PLANI m

..i .

N SAFETY RELATED ELECTRICAL a M.ECHANICAL MAINTENANCE

SUMMARY

.4.'t,

. bi p' , W REPAll DATE SYSTEM REESU HOW DETECTED CAUSE OF MALFUNCTION ACTION TAKEN TO PRECLUDE RECURRENCE TIME COMPONENT # ,

, HOURE 10/18 14 37197 OPS Worn moto'r pinion , Replaced motor pinion and 42 MOV-11A and key *

- key s'

10/17 71- 22655 Visual Warped cel1 cover . Jumpered cell ..- 2 BAT 30 ,;

10/19 03 22587 N.D.E. Cracked collet Discarded flange / collet 30 CRD 2972 housing housing assembly ,

10/18 03 22590 N.D.E. Cracked collet Discarded flang e/c olle t 30 CR0 3210 ho6 sing housing assembly 10/16 03 22588 N.D.E. Cracked collet Discarded flange / collet 30 CRD 3743 housing housing assembly 10/18 03 22591 N.D.E. Cracked collet Discarded flange / collet 30 CRD 3736 housing housing assembly 4

e 9

a -- . _ - - - - - - - _ - - _ _ _ _ _ _ - - _ _

JAMES A. FITZPATRICK NUCLEAR POWt:.H PLANI

..; : m's.'

~,j SAFETY RELATED ELECTRicia a MECHANICAL MAINTENANCE SUMMART thf,h.k REPAli WORK REQUEST # TIME DATE SYSTEM Il0W DETECTED' CAUSE CF MALFUNCTION ACTION TAKEN TO PRECLUDE RECURRENCE COMPONENT # -

, HOURE, 10/17 14 37198 OPS Loose seats Tightened seats 8 MOV-5A 10/2A 23 37226 Visual Damaaed pipe' threads Chased threads 1 HPI-711 -

10/24 23 25497 Visual Nicked wire insula- Teped wire - 2 832 COM tion 10/24 23 37191 OPS Position indicating Adjusted P.I. switches 4

- A0V-42 switches rifidadjusted -

A0V-43 .

i 10/17 23 29624 OPS Position indicating Adjusted P.I. switches 13 A0V-53 switches misadjusted l

10/29 23 22639 Visual Leaking pressure Replaced pressure seal 298 MOV-15 seal .

j 11/2 23 22656 OPS Seized motor bearing Replaced bearings 52 P-140 4

e

JAMES A. FITZPATHICK NUCLEAR POWt:.H PLANI

.. i .

.s SAFETY RELATED ELECTRICAL & MECHANICAL MAINTENANCE

SUMMARY

hIhh REPAll DATE SYSTEM M RE N # HOW DETECTED CAUSE OF MALFUNCTION Action TAKEN TO PRECLUDE RECURRENCE TIME COMPONENT # . ,

.HOURE.

10/25 10 37317 Visual Worn packing -

Adjusted packing ," 6 MOV-2.7A .

10/23 10 25496 OPS Insufficient spring Replaced limitorque limit 12 MOV-32 tension switch assembly

' ~

10/23 13 36260 N/A No, malfunction Replaced-limit switches per 169 i 23 13 HOV-1 Modification M1-84-014 23 HOV-1 10/22 13 29029 OPS Misadjusted ilmit . Adjusted limit switch 2 HOV-2 switch a

j 4

11/5 13 34244 OPS Limitorque. motor ,

Replaced motor 22

. MOV-131 shorted ,

e

@ =

..__.-.s.

f.

JAMES A. FITZPATHIGK NUGLEAR POWt:.H PLANI 3

~-

i

, r.

\-s SAFETY RELATED ELECTRICAL 'fi MECHANICAL MAINTENANCE

SUMMARY

. Y.;.~

.3,k.(.6 WORK REQUEST # TIME DATE SYSTEM HOW DETECTED' CAUSE OF MALFUNCTION ACTION TAKEN TO PRECLUDE RECURRENCE COMPONENT # - ,

,- HOUR

• 11/3 23 34212 S.I. Err.atic overspeed Replaced tappet, pin weight 116 TU-2 trip-chipped tappet and spring 10/25 29 37314 Visual Wor'n packing Adjusted 2 A0V-80C , ,

10/25 29 37315 Visual Worn packing Adjusted 2 A D V-8 0 D .

10/26 46 37275 L Lit i Seat leakage Lupped seat and disc . 20 ESW 168 10/12 46 25433 N/A No malfunction Disassembled to provide 3 t emporary d ry well cooling.

Reassembled e

i

+

3 I

9

.._ _.e.

,? 4 4, James A. Fit Patrick Nuclear Power Plant P.O. 80 41-Lycoming, New York 13093 315 342.3840 Harold A. Glovier

1. > NewYorkPbwer

& Authority November 8, 1984 JAFP 84-1040 Director, Office of Inspection and Enforcement U.S. Nuclear Regulatory Comission Washington, D.C. 20555 ATTENTION: DOCUMENT CONTROL DESK

REFERENCE:

DOCKET NO. 50-333

Dear Sir:

Enclosed please find the J. A. FitzPatrick Operating Status Report for the month of October, 1984. Refueling information remains the same as previously submitted.

If there are any questions concerning this report, please contact John Cook at (315) 342-3840, Ext.'439.

IIAROLD A. GLOVIER HAb :mac cc: Internal Distribution Enclosures

(

l I l

l l