05000482/FIN-2011004-04

Finding

Title

Excessive Oil Contamination for Turbine-Driven Auxiliary Feedwater Pump

Description

Wolf Creek uses international standards organization, the solid contamination code, to measure the number and size distribution of oil particulates. Each number describes a particle size distribution and the particle count scale is logarithmic. Wolf Creek Procedure I-ENG-004, Lubricating Oil Analysis, Revision 3A, has an alert limit of greater than 18/15 and an action limit of 19/16. On August 11, 2011, the oil analysis results were 23/21. On August 15, after several oil exchanges and us of an in-line filtration skid, the oil was returned to the alert level of greater than 18/15. Subsequent oil analysis of the as-found oil by an independent laboratory confirmed the elevated particulates and elevated water concentration. Analytical ferrography found that the particles consisted of ferrous debris from normal rubbing, fatigue, spherical wear, and oxidation. Wolf Creek has since contracted with a vendor to determine the operability impact on the turbine and governor. The inspectors will review that analysis to close this item. Therefore, this issue is unresolved pending more inspection of the vendor analysis of the turbine: URI 05000482/2011004-04, Excessive Oil Contamination for Turbine-Driven Auxiliary Feedwater Pump.

04
Site:	Wolf Creek
Report	IR 05000482/2011004 Section 4OA3
Date counted	Sep 30, 2011 (2011Q3)
Type:	URI:
cornerstone	Mitigating Systems
Identified by:	NRC identified
Inspection Procedure:	IP 71153
Inspectors (proximate)	C Peabody G Miller J Bashore L Carson L Willoughby N Makris S Alferink C Longc Longc Peabody C Speer G Guerra J Laughlin J Watkins L Ricketson N Greene N Makris N O'Keefe R Kopriva S Hedger
INPO aspect
'
v • d • e

Finding - Wolf Creek - IR 05000482/2011004

1(0)2(14)3(12)4(9)5(6)6(2)7(6)8(0)9(2)402(0)403(0)25(0)

IR 05000482/2011004: 1 2 3 4 5 6 7 8 9

Finding List (Wolf Creek) @ 2011Q3

CCA Matrix: 2011Q3

	Q	CCA	Title
05000482/FIN-2010007-04	2010Q4		Emergency Diesel Generator Specified Rating did not Address Engine Operation at Design Basis Extreme Meteorological Temperature Conditions
05000482/FIN-2010005-05	2010Q4	P.1	Failure to Identify Boric Acid Leak on Instrument Lines to Reactor Coolant System
05000482/FIN-2010005-06	2010Q4	H.12	Failure to Have Procedures to Prevent Draining Radioactive Systems into Nonradioactive Systems
05000482/FIN-2010005-07	2010Q4	P.1	Failure to Have Adequate Procedures for Meteorological Monitoring
05000482/FIN-2010005-08	2010Q4	P.5	Inadequate Procedures for Establishing Feedwater Preheat
05000482/FIN-2010005-09	2010Q4	P.5	Inadequate Procedures to Ensure Proper Main Feed Pump Speed During Startup
05000482/FIN-2010007-01	2010Q4		Inadequate Design of Component Cooling Water Safety/Nonsafety Isolation
05000482/FIN-2010007-02	2010Q4	H.7	Failure to Perform Tornado Damper Testing
05000482/FIN-2010007-03	2010Q4		Inadequate Auxiliary Feedwater Pump Suction Line Break Analysis and Design
05000482/FIN-2010008-01	2010Q4	H.14	Failure to Promptly Identify and Correct a Condition Adverse to Quality
05000482/FIN-2010007-05	2010Q4	H.9	Failure to Translate Design Requirements to Operating Procedures for the Transfer of Residual Heat Removal and Containment Spray Suction to the Containment Recirculation Sumps
05000482/FIN-2010005-01	2010Q4	H.14	Failure to Properly Identify and Evaluate Degraded Piping in the Train A Essential Service Water System
05000482/FIN-2010005-02	2010Q4	H.14	Failure to Account for Water Hammer Stresses in Essential Service Water System Calculations
05000482/FIN-2010005-03	2010Q4	H.7	Failure to Maintain Operator Licensing Examination Integrity
05000482/FIN-2010005-04	2010Q4	P.2	Failure to Evaluate Corrosion Mechanism in Accordance with Code Case N513
05000482/FIN-2010005-10	2010Q4	H.7	Inadequate Procedure for Steam Generator Hi-Hi Turbine Trip
05000482/FIN-2010005-11	2010Q4	H.1	Inadequate Simulation Facility Fidelity
05000482/FIN-2010008-02	2010Q4		Inadequate Procedure for Fill and Vent of the Component Cooling Water System
05000482/FIN-2010008-03	2010Q4	P.2	Failure to Perform an Adequate Operability Evaluation
05000482/FIN-2010008-04	2010Q4	P.2	Failure to Identify and Correct Inadequate RHR Fill and Vent Procedures
05000482/FIN-2011002-10	2011Q1	H.13	Repetitive Failure to Enter Technical Specifications for Auxiliary Feedwater Suction Valve Testing
05000482/FIN-2011006-01	2011Q1	H.9 H.2(b)	Failure to Trend Emergency Diesel Generator Chemistry Parameters Results in an Unplanned Technical Specification Entry
05000482/FIN-2011002-01	2011Q1	H.14	Inadequate Design Control of the Fuel Oil Storage Tank Fill System
05000482/FIN-2011002-02	2011Q1	H.5	Inadequate Clearance Order Isolated Cooling to Inservice Safety-Related Equipment
05000482/FIN-2011002-03	2011Q1	P.2	Failure to Monitor the Performance of Nonsafety-Related Systems and Components Used in the Plant Emergency Operating Procedures under 10 CFR 50.65 Programs
05000482/FIN-2011002-04	2011Q1	P.2	Failure to Follow 10 CFR 50.65 a(2) for Main Control Board Annunciator Power Supply Failures
05000482/FIN-2011002-05	2011Q1		Inadequate Calculation for Vital Switchgear Cooling
05000482/FIN-2011002-06	2011Q1	P.2	Failure to Perform an Operability Determination for Degradation of the Fuel Oil Storage Tank
05000482/FIN-2011002-07	2011Q1	H.4 H.5	Failure to Verify Ultimate Heat Sink Sedimentation Levels within Design Bases
05000482/FIN-2011002-08	2011Q1	P.3	Inadequate Fill and Vent of Component Cooling Water
05000482/FIN-2011002-09	2011Q1	H.5	Inadequate Clearance Order Disables Power Operated Relief Valve Low temperature Overpressure Function
05000482/FIN-2011002-11	2011Q1	H.4 H.5	Failure to Follow Radiation Work Permit Instructions
05000482/FIN-2011003-02	2011Q2	H.12	Failure to Properly Establish Clearance Order Boundary Isolation Resulting in Loss of Component Cooling Water Inventory
05000482/FIN-2011003-01	2011Q2	P.3	No Procedure for Debris in Transformed and Tank Yards Prior to Severe Weather
05000482/FIN-2011003-10	2011Q2	P.2	Failure to Analyze for Vortexing in Containment Spray Additive Tank
05000482/FIN-2011003-09	2011Q2	P.3	Inadequate Fire Watch Defeats Halon Fire Suppression in Vital Switchgear Rooms During Fire
05000482/FIN-2011003-08	2011Q2	H.7	Failure to Maintain Reactor Coolant System Pressure Below Relief Valve Setpoint
05000482/FIN-2011003-07	2011Q2	P.2	Failure to Correct Procedure for Opening Main Steam Isolation Valves
05000482/FIN-2011003-06	2011Q2	P.3	Inadequate Acceptance Criteria for Postmaintenance Testing of the Startup Feedwater Pump
05000482/FIN-2011003-05	2011Q2	H.9	Failure to Assure Configuration Control of Safety-Related Systems
05000482/FIN-2011003-04	2011Q2	H.7	Failure to Assure Separation of Stainless Steel and Carbon Steel Grinding and Cutting Equipment
05000482/FIN-2011003-03	2011Q2	H.9	Failure to Assure Fillet Weld Met Size Requirements on Train B Charging Header Vent Line
05000482/FIN-2011004-05	2011Q3	H.14	Failure to Maintain Steam Generator Level Above Lo Lo Level Setpoint
05000482/FIN-2011004-04	2011Q3		Excessive Oil Contamination for Turbine-Driven Auxiliary Feedwater Pump
05000482/FIN-2011004-03	2011Q3		Failure to Follow ASME Code Case OMN-1 for Butterfly Valves
05000482/FIN-2011004-02	2011Q3	H.7	Technical Support Center External Door Propped Open without Impairment
05000482/FIN-2011004-01	2011Q3		Switchyard Component Failures Cause Loss of Ring Bus and Loss of Offsite Power

Self-Identified List (Wolf Creek)

	Q	Title
05000482/FIN-2011006-02	2011Q1	N/A
05000482/FIN-2011002-12	2011Q1	Licensee-Identified Violation
05000482/FIN-2011002-13	2011Q1	Licensee-Identified Violation
05000482/FIN-2011002-14	2011Q1	Licensee-Identified Violation
05000482/FIN-2011003-11	2011Q2	Licensee-Identified Violation
05000482/FIN-2011003-12	2011Q2	Licensee-Identified Violation
05000482/FIN-2011004-06	2011Q3	Licensee-Identified Violation
05000482/FIN-2011004-07	2011Q3	Licensee-Identified Violation
05000482/FIN-2011004-08	2011Q3	Licensee-Identified Violation
05000482/FIN-2011004-09	2011Q3	Licensee-Identified Violation

[Wolf Creek Findings full list]

05000482/FIN-2011004-04

Navigation menu

Search