ML20309B093
| ML20309B093 | |
| Person / Time | |
|---|---|
| Site: | Consolidated Interim Storage Facility |
| Issue date: | 11/03/2020 |
| From: | Public Commenter Public Commenter |
| To: | NRC/NMSS/DREFS |
| NRC/NMSS/DREFS | |
| References | |
| 85FR27447 | |
| Download: ML20309B093 (9) | |
Text
From:
Kevin Kamps <kevin@beyondnuclear.org>
Sent:
Tuesday, November 3, 2020 9:44 PM To:
WCS_CISFEIS Resource
Subject:
[External_Sender] Beyond Nuclear's 28th set of public comments, re:
Docket ID NRC-2016-0231, and report number NUREG-2239, NRC's ISP/WCS CISF DEIS, re: A Brief History of Irradiated Nuclear Fuel Shipments: Atomic Waste Transport Incidents and Acciden...
Dear NRC Staff,
We submit these comments on behalf of our members and supporters, not only in New Mexico and Texas, near the targeted ISP/WCS CISF site, but across both of these states, and the rest of the country, along road, rail, and waterway routes that would be used for high risk, highly radioactive waste shipments to ISP/WCS's CISF, as well as to Yucca Mountain, Nevada, on Western Shoshone land -- wrongly and illegally assumed by ISP/WCS, as well as by NRC, to someday (or some decade, or some century) become a permanent disposal repository. This unnecessarily repeated, multiple legged, cross-continental transport of highly radioactive waste, is another significant aspect of the EJ (Environmental Justice) burden associated with this ISP/WCS CISF scheme.
The following subject matter has gotten little to no attention in NRC's ISP/WCS CISF DEIS, a far cry from NEPA's legally binding "hard look" requirement:
A Brief History of Irradiated Nuclear Fuel Shipments: Atomic Waste Transport Incidents and Accidents the Nuclear Power Industry Doesnt Want You to Know About This backgrounder, cut and pasted in below, within brackets, is also posted online here: <https://www.nirs.org/wp-content/uploads/radwaste/hlwtransport/accidentshistorybrochure.p df>. I wrote it in 2002, while serving as Nuclear Waste Specialist at NIRS.
It is relevant as public comment on the ISP CISF DEIS because it discusses the significant, large risks of highly radioactive waste shipping, with a focus on documented very serious problems in
the past with Nuclear Assurance Corporation (NAC) shipping containers. NAC is a major partner in the ISP scheme.
Even if these older NAC containers are not to be used at ISP (and they very well may be used), such problems are still a big red flag re: NAC quality assurance (QA) violations in design, fabrication, and use of its containers, which carries major safety significant implications.
There are also very serious questions about NAC's safety culture, or lack thereof, documented in the backgrounder below.
As mentioned in previous comments in this proceeding, as well as the Holtec/ELEA CISF DEIS public comment proceeding, shocking QA violation revelations re: Holtec containers, by Oscar Shirani of Exelon/Commonwealth Edison, and Dr. Ross Landsman of NRC Region III, beg the question, do such QA violations extend to other cask and canister models, such as NAC's? The brief history below indicates that yes, indeed, that may very well be the case, raising very serious health, safety, and environmental protection concerns re: ISP's CISF scheme.
Similarly, QA and technical specification violations involving Transnuclear NUHOMs dry cask storage at Davis-Besse nuclear power plant in Ohio, and QA and tech. spec. violations involving Ventilated Storage Casks (VSC-24s) at Palisades nuclear power plant in Michigan, Point Beach nuclear power plant in Wisconsin, and Arkansas Nuclear One, show that indeed, there is a widespread problem with QA and tech. spec. violations across the nuclear power industry, involving many, to most, to all, models of irradiated nuclear fuel shipping and storage canisters and casks.
This carries dire implications for risks to safety, health, and environment in the ISP CISF scheme.
[A Brief History of Irradiated Nuclear Fuel Shipments:
Atomic Waste Transport Incidents and Accidents the Nuclear Power Industry Doesnt Want You to Know About The nuclear industry would have you believe that the transportation of irradiated fuel rods is completely safe. Its Washington, D.C. lobbying arm, the Nuclear Energy Institute (NEI), claims that 2,900 shipments of irradiated nuclear fuel have traveled U.S. highways and railroads since 1964 with absolutely no radiation leaks nor container cracks. Although NEI admits that eight accidents have occurred, they quickly point out that only four involved containers loaded with used (a euphemism for highly radioactive) nuclear fuel. But in a 1996 State of Nevada Agency for Nuclear Projects report (based on U.S. Atomic Energy Commission and Department of Energy documentation), Reported Incidents Involving Spent Nuclear Fuel Shipments, 1949 to Present, a full 72 incidents are briefly described. 4 involved accidental radioactive material contamination beyond the vehicle, 4 contamination confined to the vehicle, 13 traffic accidents with no release or contamination, 49 of accidental container surface contamination, and 2 incidents with no descriptions. Three of the incidents resulting in contamination beyond the vehicle occurred in 1960 (a leaking rail cask that contaminated small areas at three rail yards), 1962 (a leaking truck cask that contaminated a roadway), and 1964 (a leaking truck cask that contaminated a terminal) - which may explain why NEI has chosen 1965 as the year to start counting safe shipments. However, a slow drip from bottom front end of empty cask while stored in transportation terminal occurred in a truck cask in 1984. Why arent these incidents acknowledged by NEI? The report listed incidents as late as the early 1990s. [The 1996 Nevada report cited above is posted online here:
<http://www.state.nv.us/nucwaste/trans/nucinc01.htm>.]
The report noted the scant nature of available data: Description of the events and equipment are insufficient to evaluate the failure mechanisms or sources of contamination. Such poor documentation will make it difficult to learn from past accidents. In addition, information on shipments of U.S. Navy irradiated nuclear fuel is classified from the public for reasons of national
security: if there have been incidents or accidents, it will be difficult or impossible to find out. Upon closer examination, though, innocent enough sounding incidents are actually quite significant. An 8/25/1980 incident is reported as surface contamination on cask, but theres much more to the story, as Dr. Marvin Resnikoff revealed in his classic 1983 book The Next Nuclear Gamble: Transportation and Storage of Nuclear Waste...
A NAC-1 truck cask (a Nuclear Assurance Corporation container capable of shipping one irradiated fuel assembly) was delivered to the San Onofre nuclear plant in California on August 20, 1980. Unknown to the workers about to handle the cask at San Onofre, this cask had been used four months earlier to ship a leaking fuel assembly from the Oyster Creek, NJ nuclear plant to a research facility near Columbus, Ohio. The cask had become so severely contaminated in the process that NAC added external lead shielding, to try to lower the exposure to workers and the public from the harmful radiation doses being given off. When the empty cask arrived at San Onofre, the radiation level in the truck drivers cab was over twice the maximum legal limit. Two NAC technicians flew out to decontaminate the cask, which at points emitted 11 to 40 times the legal limit of radiation. A San Onofre health physics technician assisted - his role, to safeguard the workers health against harmful radioactivity. However, U.S. Nuclear Regulatory Commission (NRC) documents reveal that the technician was not qualified for this particular task: He had no familiarity with irradiated (spent) fuel casks, and he received no briefing or instruction with regard to the potential hazard of working with this contaminated cask nor even what procedure or actions were going to be performed.
The NAC technicians opened a capped pipe leading to the interior of the cask. Highly contaminated water began pouring out. One NAC worker caught it in a plastic bag and measured the radiation. The water emitted up to 100 rems/hour of radiation, a level high enough to deliver a lethal dose to an adult after just five hours of whole-body exposure. Shorter exposure time to such intense radiation can also lead to other forms of severe health and genetic damage. The NAC workers used a paper towel to wipe up moisture in the pipe. The paper towel then gave off an even higher 300 rems/hr. One NAC worker attempted to place the plastic bags filled with contaminated waste into a shielded container. When it wouldnt fit, he held his breath,
turned his head, pushed the bags into the cavity while puncturing them with a screwdriver. No standard air samples were taken, and no proper respiratory safety equipment was used. NRC later fined San Onofre $125,000 for lax health physics supervision. Water samples showed that contamination was so high that the release of several gallons of water from this cask could have resulted in billions of dollars in clean up costs.
The very same NAC-1 cask later exceeded its radioactive decay heat temperature limit, had a leaking valve, and had a radioactive hot spot that mysteriously moved from one end of the cask to the other after it had been decontaminated several times.
In Feb., 1981 another NAC-1 cask at Oyster Creek was found to have surface contamination, even though it was empty and had not shipped fuel for five months. A layer of heavy paint was applied to hold the contamination in place during the casks next journey, to Ohio. However, water soluble paint was used. It began to dissolve during a rain storm in Pennsylvania. The drivers noticed the paint peeling off, but continued on, apparently oblivious that radioactive contaminants were probably falling off onto the highway for hundreds of miles. How much radiation was released will never be known.
NAC took 5 days to report the incident to NRC, which then took no action anyway.
High surface contamination incidents continued. Casks arrived at the La Crosse, WI nuclear plant with radiation levels 90 times the legal limit. NRC allowed the casks to be used, merely requiring them to be wrapped in a large plastic bag. Only after the shipments were completed did NRC require the casks to be decontaminated. Unfortunately, the La Crosse management did not warn their workers about the cask, and several were contaminated when they handled it without gloves. The NRC reported that in less than a year, this particular cask had excess surface contamination 7 times, and released some radiation during transit.
NAC also had used faulty casks for more than 5 years, from 1974 to 1979, to ship irradiated fuel more than 300,000 miles. The casks bowed out of shape, a defect that NRC noted could compromise its crashworthiness. However, NAC only reported bowing problems after shipments had been completed.
Eventually, 4 of 6 NAC-1s were pulled from the road due to the bowing
problem. The NAC-1 had been regarded as the workhorse of irradiated fuel transport in the U.S. before its problems surfaced.
In addition to its glowing safety record, the U.S. nuclear industry also speaks proudly of its many decades of experience in transporting spent nuclear fuel. However, 2,900 shipments over the past 35 years averages out to just over 80 shipments per year. Most of those involved relatively short transport distances (traversing 3 or fewer states), and took place many years ago. The 1970s and early to mid 1980s account for most of the irradiated fuel shipments. From 1988 to 1997, there were only 205 total shipments in the U.S. In 1996 and 1997, there were only a total of 30 shipments. For more than a decade, there has been very little experience accumulated. In the year 2001, a grand total of 3 truck shipments were carried out under the Dept. of Energy. Under the proposed Yucca Mountain scheme, there could be three or more shipments daily for decades into the future. Thus, there have been very limited numbers of shipments, traveling very limited distances, carrying limited amounts of irradiated fuel, over the past two decades. In fact, many of those with the most experience in irradiated fuel shipment within the nuclear industry have already retired.
When confronted about the serious lack of experience in the U.S., the nuclear industry often points to the European and Japanese experience. There have been much larger numbers of irradiated fuel shipments in Western Europe and Japan, because those countries send irradiated fuel to reprocessing facilities. However, Europe has had its own irradiated fuel transport controversies.
The numbers alone show the intensity of the resistance to irradiated fuel shipments to interim storage sites in Germany. March, 1997: 6 casks, 173 injured, 500 arrested, 20,000 protestors, 30,000 police, $100 million. March, 1998: 6 casks, scores injured, 1,000 arrested, 7,000 protestors, 30,000 police,
$100 million. November, 2001: 6 casks, dozens injured, hundreds arrested, 10,000 protestors, 15,000 police, $25 million. These intense protests have significantly slowed the attempted interim storage at Gorleben and Ahaus, Germany. Irradiated fuel shipments between Europe and Japan, some traveling through the Panama Canal, have also been dogged by protests and controversy on a growing scale, including official opposition by Caribbean, South American, and Asian governments along the shipping routes.
From the early 1980s to the late 1990s, contamination incidents like those in the U.S. were occurring on irradiated fuel casks being shipped to and from COGEMAs* La Hague reprocessing plant in France. But this was kept secret from the public by the nuclear industry and government agencies. It took the work of investigative reporters and activists to break the story in 1997. On May 12, 1998 according to Reuters, French officials admitted that contamination from German casks bound for COGEMA had exceeded radiation limits by up to 3,000 times.
When the nuclear industry and government talk about a spotless record of transporting spent nuclear fuel, its important to look beneath the surface.
---Kevin Kamps, revised May 16, 2002 Nuclear Information & Resource Service, www.nirs.org]
- COGEMA was later renamed Areva. Areva was later renamed Orano.
Orano is a major partner in the ISP CISF scheme.
Please address the subject matter above, re: our many objections to NRC's outrageous conduct of this ISP/WCS CISF public comment proceeding.
And please acknowledge your receipt of these comments, and confirm their inclusion as official public comments in the record of this docket.
Thank you.
Sincerely, Kay Drey, President, Board of Directors, Beyond Nuclear and Kevin Kamps, Radioactive Waste Specialist, Beyond Nuclear Kevin Kamps Radioactive Waste Specialist Beyond Nuclear 7304 Carroll Avenue, #182 Takoma Park, Maryland 20912
Cell: (240) 462-3216 kevin@beyondnuclear.org www.beyondnuclear.org Beyond Nuclear aims to educate and activate the public about the connections between nuclear power and nuclear weapons and the need to abolish both to safeguard our future. Beyond Nuclear advocates for an energy future that is sustainable, benign and democratic.
Federal Register Notice:
85FR27447 Comment Number:
10350 Mail Envelope Properties (CAFNCop5bLJyiUYC3EOa0vwqEDPve=ksJDpmjXB7P4tORk1-u9g)
Subject:
[External_Sender] Beyond Nuclear's 28th set of public comments, re: Docket ID NRC-2016-0231, and report number NUREG-2239, NRC's ISP/WCS CISF DEIS, re: A Brief History of Irradiated Nuclear Fuel Shipments: Atomic Waste Transport Incidents and Acciden...
Sent Date:
11/3/2020 9:44:29 PM Received Date:
11/3/2020 9:44:50 PM From:
Kevin Kamps Created By:
kevin@beyondnuclear.org Recipients:
Post Office:
mail.gmail.com Files Size Date & Time MESSAGE 15169 11/3/2020 9:44:50 PM Options Priority:
Standard Return Notification:
No Reply Requested:
No Sensitivity:
Normal Expiration Date:
Recipients Received: