ML20082M823
ML20082M823 | |
Person / Time | |
---|---|
Site: | Limerick ![]() |
Issue date: | 08/09/1991 |
From: | Carmody J, Dennin E PECO ENERGY CO., (FORMERLY PHILADELPHIA ELECTRIC |
To: | |
Shared Package | |
ML20082M812 | List: |
References | |
PECO-COLR-L1R3, PECO-COLR-L1R3-R01, PECO-COLR-L1R3-R1, NUDOCS 9109060025 | |
Download: ML20082M823 (20) | |
Text
{{#Wiki_filter:. I 4 ENCLOSURE PECO Fuel Management Section PECO-COLR-L1R3 L1R3 Core Operating Limits Report Page 1, Rev. 1 CORE OPERATING LIMITS REPORT i FOR LIMERICK GENERATING STATION UNIT 1 RELOAD 3, CYCLE 4 , i I t
?
Prepared By: f' h- Date: E E!'N / i E.P. Dennin Engincer . Reviewed By: ' Date: !4 /
/ ll Independent Reviewer [
Approved By: Y <.- Date: E" -% , v ~ J.M. Carmody Supervising Engineer ; I I 9109060025 910327 PDR ' l P ADOCK O*5000352 PDR
i
- PECO Fuel Management Section PECO-COLR-L1R3 L1R3 Care-Operating Limits Report Page 2, Rev.- 1 LIST OF EFFECTIVE PAGES Page(s) -Revision 1-20 1 l
PECO Fuel Management Section PECO-COLR-LlR3 L1R3 Core Operating Limits Report Page 3, Rev. 1 INTRODUCTION AND
SUMMARY
This report provides the cycle-specific parameter limits for: Average Planar Linear Heat Generation Rate ( APLHGR) ; Minimum Critical Power Ratio (MCPR); Flow Adjustment Factor (Kg) ; Linear Heat Generation Rate (LHGR); and Rod Block Monitor flow biased upscale and:high flow clamped setpoints for Limerick Generating Station Unit 1, Cycle 4, Reload 3. These values have been determined using NRC-approved methodology and are established such that all applicable limits of the plant safety analysis are met. This report is submitted in accordance with Technical Specification 6.9.1 of Reference (1). Preparation of this report was performed in accordance with PECO Nuclear Group Procedure NP-llF122. APLHGR LIMITS The limiting APLHGR value for the most limiting lattice (excluding natural uranium) of each fuel type as a function of AVERAGE PLANAR EXPOSURE is given in Figures 1 through 7. Figures 1 through 7 are used when hand calculations are required as specified in Technical Specification 3.2.1. The reduction factor for use during single recirculation loop operation is given in Table 1. These limits are documented in Reference (3). l MCPR LIMITS The MCPR value for use in Technical Specification 3.2.3 for each fuel type is given in Figures 8 through 11. The Kf core flow adjustment factor for use in Technical Specification 3.2.3 is given in Figure 12. These limits are documented in Reference (2). The MCPR values given are the bounding values for Increased Core Flow (up to 105% power), Feedwater Temperature Reduction (up to 60 degrees F), Power Coastdown, and a combination of all cf these options. Curves are also provided for inoperable Recirc Pump Trip or inoperable Steam Bypass System.
-PECO Fuel Management Section PECO-COLR-LlR3 -L1R3 Core Operating Limits Report Page 4, Rev. 1 ROD BLOCK MONITOR SETPOINTS .The N-value for the RBM flow biased upscale and high flow clamped setpoints for use in Technical Specification 3.3.6 is given in Table 2. This value is documented in Referenes (2). l LINEAR HEAT GENERATION RATES The LHGR value - for use in Technical Specification 3.2.4 for each fuel type is.given in Table 3. These values are documented in Reference (4). l STEAM BYPASS SYSTEM OPERABILITY The operability requirements.for the steam _ bypass system for use'in Technical Specifications 3.7.8 and 4.7.8.C are found in Table 4. If these requirements cannot be met the MCPR limits for inoperable steam bypass system must be used. These values are documented in References (2) and (4).
REFERENCES
- 1) " Technical Specifications and Bases for Limerick Generating Station Unit 1", Docket No. 50-352 Appendix A to License No. NPF-39,
- 2) " Supplemental Reload Licensing Submittal for Limerick Generating Station Unit 1, Reload 3", General Electric Company Document No. 23A6519, Rev. O.
- 3) " Basis for MAPLHGR Technical Specifications for Limerick 1", NEDE-31401-P, August 1990.
- 4) " General Electric Standard Application for Reactor Fuel",
NEDE-24011-P-A-9, latest revision.
4 e 14 - , , , gy
! 4 i
mo i t i I t
- uO o
I
- l. ! $ $C 13 - ,
o m_ THIS FIGURE IS REFERRED TO BY 12.1 12.5 12 2 ff g 12. ly . 121N9 ii TECHNICAL SPECIFICATION 3.2.1 5$ 12 l gg i i r- e v l I.2 i j 82 - l
. N g o.7 Eh h
10
\10.0 '
m3 ' 914
%2W D N \ 8.7 DO '
h EH N 3r 8 b Z i 7 1 6 , 3 i ; ; ; ; , , O 5.000 10.000 15.000 20.000 25.000 30.000 35.000 40.000 45.000 mm AVERAGE PLANAR EXPOSURE (MWDTD gg MAXIMUM AVERAGE PLANAR LINEAR HEAT GENERATION RATE (MAPLHGR) VERSUS (9%g 5 AVERAGE PLANAR EXPOSURE "U FUEL TYPE BP8CiB248 (BP8x8R) 3 FIGURE 1
~ ! ! i i i l ! . l l THIS FIGURE IS REFERRED TO BY E 2' 12'.8 12'9 12 9 **-
13 - . f l TECHNICAL SPECIFICATION 3.2.1 og 12f' ! l tj , l gj b 11.8 11.8 / ! I' l l ! 5$a g h'12 ./ , i, a l l i 1 i c3 ?. - um z tu
, l 'ql.2 ,
i '"
, g '~
uz , ; .6 hO l f ; \ Qh.1 iu gio - . ,
' j Nz m un ! t - !
l 9,4 30 , i " 1 I i s Itr ! u 0 ~ Z ! I' '
~3 l
7 - ! , j I i
! f I l l } l l l 0 5,000 10,000 15,000 20,000 25,000 30,000 35,000 40,000 45,000
(( l AVERAGE PLANAR EXPOSURE (MWDfr) *9
-a MAXIMUM AVERAGE PLANAR LINEAR HEAT E'8 GENERATION RATE (MAPLHGR) VERSUS AVERAGE PLANAR EXPOSURE $[
3 FUEL TYPE BP8CIB163 (BP8x8R) FIGURE 2
- a. -i 14 - ., .
1 CA m o-I i ( ! I
}' "O t ?, ; e f { @m l ! i ;
i a1 Og 13 - j. 1 ! 1 i t-38 l Ra a E
- i -- -11.9 THIS FIGURE IS REFERRED TO BY d *3 % 12 - -
gh I I 2 11.3 TECHNICAL SPECIFICATION 3.2.1 EE u en -: t t 4 ztu- 11,0 - 1 ! =e - mR-
! , r : i i i n.
11 -
/ {- ;. J t -{
t ; -- _g 5 o" ;
- i l' i 10.5 ! " '?
tu z 10.7 ! ! ; ! i OO l
, L j ! @ 10 - i- i- 9i8 i !
E i
! , jb2 !
s tu no 9-l r i i i ! x : t t ss i ; 8.5 !
$6 2 I-I i
l i i 7.9 ! m 8 i i + i
~ ! ! 1 A 11 l ! . , ; -l z i i l ; ; ; !
_a ! ! i , 7- t 1
. , 4 , i i [
i : , 3 i t
- , r !
O~ l i I i l i i I
.l 0 5.000 10.000 15,000 20.000 25,000 30 000 35.000 40,000 45,000 -l t
i un i I
. AVERAGE PLANAR EXPOSURE (MWD /T) g'*A - 9o i
4 MAXIMUM AVERAGE PLANAR LINEAR HEAT yO 1-GENERATION RATE (MAPLHGR) VERSUS ~. 5'
. f- l AVERAGE PLANAR EXPOSURE 5 u
FUEL T(PE BP8CIB094 (BP8x8R) - .l t FIGURE 3 - !
. o . c - . - s. --.. , . _
-4 ro "m
BaO 14
~ , , g, I ! I ! . E_
i: i THIS FIGURE IS REFERRED TO BY 8-gia - !
, .4 ' TECHNICAi_ SPECIFICATION 3.2.1 c ..] !! E ' ~ . *12 7 7'N ,' -
tr 2.44 12 j ?
/ ,12.07 < 12 - ' '
i. 1 i 3a f n-
- /11.76 l 11~52 !
l I 12[.04 s j. l I l gg 20-
.m zl1 'i ; ; l l c i - -~ ~ 'B 3 09 l l J- !
i i a g Wg i i i- ! jo - l l .;- Egz , i ;- j 1 i ym 4
! : ?
I ! t 3 0 l ! y 9 -- ,
.6 i ,
- . l l !
. I J I ! f, - '
t i ., 2:tr ! t ! ! l' i l-
<8 -
1- t . 4 tB 4 j l t z : ' i' ! i l
~1 !- > ! ! [ . .
7 - ;
; j i j { 3 i'
i : ! i i, l:i ' t '.
! ! 6.86 i : t^
6- 1 i l i i ). I i i
- O 5,000 10,000 15,000 20,000 25.000 30,000 35,000 40,000 45,000 50,000 l
AVERAGE PLANAR EXPOSURE (MWD /T) ,o
=m oo MAXIMUM AVERAGE PLANAR LINEAR HEAT
- o.
- GENERATION RATE (MAPLHGR) VERSUS 68, AVERAGE PLANAR EXPOSURE- ? 5:
FUELTYPE BC320A (GE82WR) - "S-n U l. l .
- FIGURE 4
' B g '.
14 - ,. . i ., , ,. ; 1 E.P. i 1 i- ! l o E. i l THIS FIGURE IS REFERRED TO BY a-~a-E s 13 _ .t t ! P. c 112 12. TECHNICAL SPECIFICATION 3.2.1- 2 *3. e6 1 L r *
- i 12. , ' ?-
12.2 'i 1. !- .i 9 gu ,j/p2.0' 'I ~j 5fT-I 12."
- n. g 12 - / 11.8 '
l , i ..g e . 2 til Z / ! i i 11 6 "O 11.2. f f ,
'j [j f' f f-d[k11 tu -l -{ i s ! ; ; N ! i' I !
i s to 10 - 10'.1 ~i 1 l- }- DO ' : l
! ( I i j l 2 f- .! -l ; j [ .
g .'3 t i ; .
< t ; >
gy 9- ; j f t i j 88 I \ b Z Y * *
\
y 8- ! ; { 8 I ,
. i l f I l ! !
I J i ; 7- . ! t t' , t l 2 ! !. !
\s , i . .
6- # l l 1 Y 5,000 10,000 15,000 20,000 25,000 30,000 35,000 40,000 45,000 -50.000 0 oo-
' AVERAGE PLANAR EXPOSURE (MWD /T) ag *9.
o MAXIMUM AVERAGE PLANAR LINEAR HEAT m 8 GENERATION RATE (MAPLHGR) VERSUS E5 "E
- AVERAGE PLANAR EXPOSURE x FUELT(PE BC318A (GE84WR) -
FIGURE 5
C3 Do 14 "O l I l l l
" I 9n I
si og l- l 1 / 13 N.3-! t i 4 . F13- t /;j3,3 .
! ; } ; ~8 g 4 - "/ i 13.0 : !
sg mg 12.5 ' i i THIS FIGURE IS ItCFERRED TO BY 5a ea
?x\ j gs12-. ;
12 3 7 TECHNICAL SPEOlFiCATION 3.2.1 {E h m z 33 _r
, /11.3 II I i1.5 i ;
f I l h Nl 1 i , i i es S sh ! ! : l' : l l D E 10 - I l ! 10.2 l sW i , i no ; i . > fb y I 9-~
, 1 \; 8.8 m !.
h8 3
-- i i
j 4 { i 7-
- l I
! i, 6- ; ; j , ; j j ; ,
0 5,000 10,000 15,000 20,000 25,000 30,000 35,000 40,000 45,000 50,000 AVERAGE PLANAR EXPOSURE (MWDTI) ;y y eo MAXIMUM AVERAGE PLANAR UNEAR HEAT
*9 6o GENERATION RATE (MAPU-iGR) VERSUS in y AVERAGE PLANAR EXPOSURE -7,/-
FUELTYPE BC322A (GE84WR) B FIGURE 6
~
I '
.. . m o.. m . o .-
9,m.C 14 - ** - t l- '1 {' i ; Og.
- j l-Ll! ' "
l3' gg
~
I- 33 l -0*ki12.7 THIS FIGURE IS REFERRED TO BY/ [ 13 - 12p/,M'13 - TECHNICAL SPECIFICATION 3.2.1 *2
~
I I-M'yi \'sQ2.' '4 . 1 ,
,ya g h 12 < ! t-j-
2$ Z~ P' i t i N .s1 1.4' t -! mn 3m H 11.6 i i
- }
o < j
.1 j
33
,mI 11 ~_ 'l } l 'K . !
2
--s ez po j ; ; N'sQO.1 ! ,
y 10 - - j l
}
{ f 2E am 1 l
! i i !
MN . t {- 9 - 20 F
! j i
i N8!5 N
~ 'I1 1 l !
d I 8- l e i . i
$ 3 l .! ! .
f I z'7- : i 4 .
- 1 -
i i ! l , 1 4 t 1 i r i j i : 4 ; i !5.9 6- 1 j l i e i .
- > ,j 2 i i { !
~
l 1 i i 1 I i I (, 0 5,000 10,000 15,000 20,000. 25,000 30,- 4 35,000 40,000 45,000 50,000 AVERAGE PLANAR EXPOSUR _ (MWD /T) _yy , -eo. l .
=o.
MAXIMUM AVERAGE PLANAR LINEAR HEAT C 6: o GENERATION RATE.(MAPLHGR) VERSUS - .F g
- AVERAGE PLANAR EXPOSURE $&
FUEL TYPE P8CWB319 (GE8x8NB) . , B r l r FIGURE 7 i l ':! 1.__-.._,_._._..........._..._..., _ _ _ _ . . . _ . _ . , _ . . . _ _ _ _ . _ . . . . _ _ . _ _ . _ __ _ _ _ _ _ _ _.
[ , , 5 PECO Fuel Management'Section PECO-COLR-LlR3 L1R3 Core Operating Limits Report. Page-12, Rev, 1- ; 1,44 1.44 1,42 - ~ - - - 1.42 THIS FIGURE IS REFERRED TO BY i u -- -- TECHNICAL SPECIFICATION 3.2.3 _[ g i t 1.38 - -- --- - - ---- 1.38 1.36 -- - - -
;- 1.36 l B !
7 To EO C y [O h ' 1.34- -- - - - - 1.34 x - {gg;2000 # g /p 1 f '~ p - b .1.32 " -- - - ~
-- 9 -
1.32 j 2 _ 0
= ---~--3 0. i 1.3 '- ~- - --
1.3
- 1.28 -- - -
OC w - 1.28 ;
' EOC-2000 M37 50 E 4
{ { i 1.26 -- - - - - - -- - - - - ---- - - - - - - - - 1.26 _/ BOC TO EOC-2000 MWO/ST ; 1.24 -- - - - -- - - -
-j 1.24 !
d ' b i i 1.22 l 1.22 f ' r i 1.2 i 1.2 ' 0 0.1 0.2 0.3 OA 0.5 0.6 0.7 0.8 0.9 1 I , MCPR VS TAU l FUEL TYPES BP8X8R, GE82WR, & GE84WR : , (INCREASED CORE FLOW & FEEDWATER TEMPERATURE REDUCTION [ WITH OPERABLE STEAM BYPASS) ! i : l FIGURE 8 ! l l
-r--1 y-
PECC Fuel Management Section PECO-COLR-L1R3 L1R3 Core Operating Limits Report Page 13, Rev. 1 , 1.50 1.50 i, i 1.48 --
~ ~
1 48 I THIS FIGURE IS REFERRED TO BY [
~
TECHNICAL SPECIFICATION 3.2.3 1.46 1,46 - - -
' ~ ~ ' --
1,44 -- - - - - - -- - - - - - - - - - - - - - - 1.44 1.42 - 1.42 ! gPT
~
l ; EOC-2000 MWO/ST TO 1.40 1,40 m
. b 1,38 - - - - - - - - - -- - -- - - -
1.38 1.36 - - - - - 00 MWO/ST WlO RPT-- - - - 1.36 ;
- - t O EOC FOR GEB4WR___.
1.34 -
- -~ EOC;20MI g%g & GEB2WR_ 1 1.34 . ~
gwOlsT TO EOC F j , 1,32. - - - -- - - - - - - - - 1.32 1*30
'j 1.30 -- -- - - - - - - ~ -
l L BOC TO EOC-2000 1.28 1.pe N 1.26 1.26 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1 l T , MCPR VS TAU FUEL TYPES BP8X8R, GE82WR, & GE84WR - (INCREASED CORE FLOW & FEEDWATER TEMPERATURE REDUCTION WITH INOPERABLE STEAM BYPASS) i FIGURE 9 i F
c !
.PECO Fuel ~ Management Section PECO-COIR-LlR3 L1R3 Core Operating ~ Limits Report Page 14, Rev. 1 ;
[
't 1.44 i 1.44 ,
_ J ! 1.42 -- - THIS FIGURE IS REFERRED TO BY 1.42 ; 4 i _ _.] TECHNICAL SPECIFICATION 3.2.3 p _
, ,4 i
1.38 -- -- - - - - - - - - 1.38 i i !
~ ~
i , 1.36 - ~ - - - - - - p 1.36 I ! 1.34 - - - - - - - W 7 TO EOC '~ ~ f- -- 1.34 dC5000 p/ { CC
. # ~ +
1.32 - 1S 1.32 1.3
'jg EO oMhh - - - - 1.3 i
t
- -- --/ ^
j- - ' - --- - + i 1.28 - - - - - -
- 1.28 ! -
BOC TO EOC-2000 MWD /ST i ! 1.26 --- -- -- - -- --- - 1.26 e
~
l l 1.24 - j 1 .24 , _ a ; 3 1.22 - -
'1.22 1.2 1.2 f 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1 !
T , t MCPR VS TAU j FUEL TYPE GE8X8NB : i (INCREASED CORE FLOW & FEEDWATER TEMPERATURE REDUCTION ' WITH OPERABLE STEAM BYPASS) l FIGURE 10
?
.. ~ . _.
i PECO Fuel Management Section PECO-COLR-L1R3 , L1R3 Core Operating Limits Report Page 15, Rev. 1 - 1.50 1.50 1.48 --~ THIS FIGURE IS REFERRED TO BY
' ~ ~ -
1 48 ' 1.46 -- F---- - 1.46 . 3,44 _ _ . . - . _ _ _ _ _ . . . _ - _ . _ _ . _ _ . _ _ _ _ . _ -__ _ , _ . _ 3,44 j 1'42 - -- - - - --- - - - - - - - - - - - - - ' 1'42 l oo gwolsTTO EOCWlo _ i 1.40 - - - - - - - - - 1.40 CC . b 1.38 - - ------ --- - - - - - - - - - - - - - - -- 1.38 2 1.36 - - 1.36 ST TO EOC 1.34 - - - EOC 1.34
,/ ,
1.32 1.32 - - - -
~
1.30 - - -
~ -- --- BOC TO_EOG20% -
1.30 i
- , 1.28 1.23 - -1 ,
1.26 1.26 : 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1 ! T MCPR VS TAU : FUEL TYPE GE8X8NB (INCREASED CORE FLOW & FEEDWATER TEMPERATURE REDUCTION WITH INOPERABLE STEAM BYPASS) , j i FIGURE 11 i
b Kt Factor vs Core Flow. !5 1.4 - e
. Z._' -
O. E @g-NN .gg 5 1 \ N'Nx THIS FIGURE IS REFERRED TO BY ec-!, 1.3 - NNNx TECHNICAL SPECIFICATION 3.2.3
~
1.g . s.
,N,s'x N 'N ya.
N N 'N ' x B a-B NN x s s
\\s _
1.2 'Nxx 'x ' N N N. %.,. 's'N, x '-
's Kf 7x ,x'x D
x xN xx xx 'N . s's'N 'N N
' N.
1.1 ~
'pg~X gNQs Ng Nx'N axn m m a.,cau.u. 4, , / /,xs ~.
pdm Sc,That / rw unum- - iozss [/ / y'. #'N~'N x N ,*N'NN'N iw N N N an uaamonuuma,--uzasor.a
, y/
s 1-f N Maakami = 117 0% ' ou 0.9 - 7 7 i i i i i ag
*O 20 30 40 50 60 70 80 90. 100 -e6O Core Flow % of Hated ?5 Lc .n FIGURE 12
_ _ . _ _ . . - _ . ~ . . . . _ . . . .__ _ _- _ _ . .
PECO Fuel-Management Section PECO-COLR-L1R3 L1R3 Core Operating Limits Report Page 17, Rev. 1 TABLE 1 SINGLE LOOP REDUCTION FACTOR 0.89 THIS TABLE IS REFERRED TO BY ! i
, TECHNICAL SPECIFICATION 3.2.1
j % . PECO Fuel Management Section PECO-COLR-L1R3 . LlR3 Core Operating Limits Report Page 18, Rev. 1 5 f i. t L P TABLE 2 j i ROD BLOCK MONITOR SETPOINT : N=106 r r i l THIS TABLE IS REFERRED TO BY ! ;
! TECHNICAL SPECIFICATION 3.3.6 t i
r r t r b t k
l-PECO Fuel Management Section PECO-COLR-L1R3 LlR3 Core Operating Limits Report Page 19, Rev. 1 TABLE __3. LINEAR HEAT GENERATION RATE LIMITS FUEL TYPE MAXIMUM VALUE BP/P8X8R 13.4 {W/ft GE8X8EB (GE82WR & GE84WR) 14.4 KW/ft i GE8x8NB 14.4 KW/ft THIS TABLE IS REFERRED TO BY
! TECHNICAL SPECIFICATION 3.2.4 '
4 c PECO Fuel 3* stro cr' Section PEco-COLR-LlR3 LiR3 Core JPt n s
- Limits Report Page 20, Rev. 1 TABLE _1 I I '
TURBINE BYPA88 VALVE PARWLETERS k TURBINE BYPASS SYSTEM RESPONSE TIME L Maximum delay time before 0.1 sec ! start of bypass valve opening following generation of the j turbine ~oypass valve flow cignal l Maximum time after generation 0.3 sec y of a turbine bypass valve flow f I signal for bypass valve position to reach 80% of full stroke (includes the above delay time) _ MINIMUM REOUIRED BYPASS VALVES TQ MAINTAIN SYSTEM OPERABILITY. Number of valves = 9 THIS TABLE IS REFERRED TO BY TECHNICAL SPECIFICATIONS 3.7.8 & 4.7.8.C : 1
- - - _ - _ _ _ _ _ _ _ - _ . _ . _ .}}