ML18106A380

Submits Revised Commitment Re ISI Quarterly Dead Leg Samples for Units 1 & 2

ML18106A380
Person / Time
Site:	Salem
Issue date:	03/16/1998
From:	Storz L Public Service Enterprise Group
To:	NRC OFFICE OF INFORMATION RESOURCES MANAGEMENT (IRM)
References
IEB-79-017, IEB-79-17, LR-N980039, NUDOCS 9803230418
Download: ML18106A380 (3)

Text

......

• Public Service Electric and Gas

• Company Louis F. Storz Public Service Electric and Gas Company P.O. Box 236, Hancocks Bridge, NJ 08038 609-339-5700 Senior Vice President - Nuclear Operations LR - N980039

~AR 16 1998 United States Nuclear Regulatory Commission Document Control Desk Washington, D.C. 20555 REVISION TO COMMITMENT INSERVICE INSPECTION QUARTERLY DEAD LEG SAMPLES

-SALEN(GENERATING STATION SALEM GENERATING STATIONS UNIT NOS. 1 AND 2 DOCKET NOS. 50-272 AND 50-311 Gentlemen:

On March 2, 1979, Public Service Electric and Gas (PSE&G) responded to Circular 76-06 (Stress Corrosion Cracks in Stagnant, Low Pressure Stainless Piping Containing Boric Acid Solution at PWRs), and made the statement that "... contained fluid in critical systems will be sampled periodically and analyzed for chlorides and oxygen .... "

On December 27, 1979, PSE&G responded to Bulletin 79-17, Rev 1 (Pipe Cracks in Stagnant Borated Water Systems at PWR Plants), and stated that "... Our response to IE Circular 76-06 included the sampling and analysis for dissolved oxygen also.

• However, those portions of the systems affected by Circular 76-06 and Bulletin 79-17 are all supplied by oxygen saturated water with high boron concentration ..... Therefore, we have elected to maintain control over the stress-corrosion cracking propensity in stagnant lines through a program of chloride analysis of contained fluids, .... "

According to the PSE&G commitment management program, PSE&G is revising its commitment to quarterly chemical sampling of "dead leg" samples performed to satisfy NRC Circulars No. 76-06 and IE Bulletin 79-17 for Salem Nuclear Generating Station Unit Nos. 1 and 2.

In accordance with the requirements defined in Circular 76-06, a program was established to define the surveillance requirements at Salem Generating Station to assure that the effluent chemistry will maintain low levels of potential corrodants in stagnant borated water. Ten years of results show chloride levels to be consistently low at the specified sample points. During the ten years, no violation of the specification limits was observed. Although, several samples were initially found above

---

~~~ 32i&cit~ 6~855~7~--- ----------, ... -.I * 'I ~* I

.

~ ,, t 1~* ! I 1. JI

'

I* '

\\ u

, ***-J.:!'.!Jl:!;:.... ._._........:'~Ult

~

1 .

G

' " " ' 1-'nntea on - ,. ~' - * ,, u POO " - .., \ ,,- \ *

~ Recycled Paper ,, ' l ; .: ~l ~ J \AO ~.

Document Control Desk

• LR-N98003'9 the limits, resampling verification revealed satisfactory results. The most probable reason for the initial high analysis results (was) is sample container contamination.

Additionally, this sampling program has significantly increased the Chemistry Department radiation dose. Technicians sampling the dead legs usually contribute approximately 83% of the department's radiation dosage. Ten years of sampling experience clearly demonstrates that continued sampling will only unnecessarily increase personnel dose, with no observable technical or safety benefit. One of PSE&G's goals is to safely operate the nuclear Units, and to maintain personnel exposures As Low As Reasonable Achievable (ALARA). Based on the above information we are discontinuing the sampling program effective March 31, 1998.

The data containing the results from chemical sampling performed for Salem Units 1 and 2, are available at the Salem Generating Station for NRC review, if required.

Should there be any questions regarding this submittal, please do not hesitate to.

contact Mr. James Clancy of r;ny staff at (609) 339 3144.

Sincerely,

~~q 95-4933

• Document Control Desk

• LR-N9800~9 C Mr. Hubert J. Miller, Administrator - Region I U.S. Nuclear Regulatory Commission 475 Allendale Road King of Prussia, PA 19406 Mr. P. Milano, Licensing Project Manager - Salem U. S. Nuclear Regulatory Commission One White Flint North 11555 Rockville Pike Mail Stop 14E21 Rockville, MD 20852 Ms. M. Evans - Salem (S09)

USNRC Senior Resident Inspector Mr. K. Tosch, Manager, IV NJ Department of Environmental Protection Division of Environmental Quality Bureau of Nuclear Engineering CN 415 Trenton, NJ 08625 95-4933