LIC-05-0135, Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps: Difference between revisions
StriderTol (talk | contribs) (Created page by program invented by StriderTol) |
StriderTol (talk | contribs) (Created page by program invented by StriderTol) |
||
(2 intermediate revisions by the same user not shown) | |||
Line 3: | Line 3: | ||
| issue date = 05/30/2006 | | issue date = 05/30/2006 | ||
| title = Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps | | title = Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps | ||
| author name = Gambhir S | | author name = Gambhir S | ||
| author affiliation = Omaha Public Power District | | author affiliation = Omaha Public Power District | ||
| addressee name = | | addressee name = | ||
Line 13: | Line 13: | ||
| document type = Letter type:LIC | | document type = Letter type:LIC | ||
| page count = 5 | | page count = 5 | ||
| project = | |||
| stage = Response to RAI | |||
}} | }} | ||
=Text= | =Text= | ||
{{#Wiki_filter:444 South 16th Street Mall Omaha NE 68102-2247 May 30,2006 LIC-06-0059 U.S. Nuclear Regulatory Commission ATTN: Document Control Desk Washington, D.C. 20555-0001 | {{#Wiki_filter:444 South 16th Street Mall Omaha NE 68102-2247 May 30,2006 LIC-06-0059 U.S. Nuclear Regulatory Commission ATTN: Document Control Desk Washington, D.C. 20555-0001 | ||
==References:== | ==References:== | ||
: 1. Docket No. 50-285 2. Letter from Ross Ridenoure (OPPD) to Document Control Desk (NRC dated December 19, 2005, Fort Calhoun Station Unit No. 1 License Amendment Request, "Reduce the Number of Required Operable Containment Spray Pumps" (LIC-05 | : 1. Docket No. 50-285 | ||
-0 | : 2. Letter from Ross Ridenoure (OPPD) to Document Control Desk (NRC dated December 19, 2005, Fort Calhoun Station Unit No. 1 License Amendment Request, "Reduce the Number of Required Operable Containment Spray Pumps" (LIC-05-0 13 5) | ||
(ML053550199) | |||
==SUBJECT:== | ==SUBJECT:== | ||
Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps The Omaha Public Power District (OPPD) previously submitted Reference 2 in accordance with 10 CFR 50.90 to reduce the required number of operable Containment Spray (CS) pumps from three to two in order to enhance net positive suction head (NPSH) margins. | Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps The Omaha Public Power District (OPPD) previously submitted Reference 2 in accordance with 10 CFR 50.90 to reduce the required number of operable Containment Spray (CS) pumps from three to two in order to enhance net positive suction head (NPSH) margins. This letter provides the response to the NRC's questions presented in an email dated April 18,2006, related to human factors aspects of Reference 2. | ||
This letter provides the response to the NRC's questions presented in an email dated April 18,2006, related to human factors aspects of Reference 2. No commitments to the NRC are made in this letter. I declare under penalty of perjury that the foregoing is true and correct. (Executed May 30,2006) If you have any questions or require additional information, please contact Thomas R. Byme at (402) 533-7368. Division Manager Nuclear Projects Employment with Equal Opportunity U. S. Nuclear Regulatory Commission LIC-06-0059 Page 2 | No commitments to the NRC are made in this letter. I declare under penalty of perjury that the foregoing is true and correct. (Executed May 30,2006) | ||
How much time will the operator have to stop CS pump SI-3C before the RAS signal? What are the procedural controls that would serve to limit such an error by the operator? | If you have any questions or require additional information, please contact Thomas R. | ||
What are the actions the operator must take to recover in a timely matter if the CS pump SI-3C is started? OPPD Response: | Byme at (402) 533-7368. | ||
The operator will have a minimum of 20 minutes to stop the CS pump before RAS. Assuming that all engineered safeguards start as originally designed, the minimum time to RAS during a large break Loss of Coolant Accident (LOCA) is approximately 20 minutes. After removal of the auto-start feature from Containment Spray Pump SI-3C, time to RAS is extended to 24 minutes. Should the operator inadvertently start SI-3C Containment Spray Pump, the first opportunity to shut it off is during the safety status function check, which is performed by the Shift Technical Advisor at ten (10) minute intervals as required in EOP-03, Loss of Coolant Accident; EOP-05, Uncontrolled Heat Extraction; EOP-20, Functional Recovery Procedure; and AOP-22, Reactor Coolant Leak. The EOP steps are planned to require verification that sufficient spray flow is available with the allowed number (2) of spray pumps in operation. | Division Manager Nuclear Projects Employment with Equal Opportunity | ||
If containment spray pumps or HPSI pumps show any sign of distress caused by a plugged strainer, then the EOPs provide guidance for shutting down the pumps. If SI-3C is discovered running, it will be shut off in accordance with the EOP instructions. NRC Question 2: In the Administrative Controls section, the licensee mentions that there will be administrative controls to limit the usage of CS pump SI-3C when less than two CS pumps are operating unless there are "extenuating circumstances." What are these extenuating circumstances in which the operator may manually operate the CS pump SI- 3C and how will these circumstances be reflected into the emergency operating procedures? And will any of these extenuating circumstances that call for manual LIC-06-0059 | |||
The LAR specifies that "administrative controls will be incorporated into plant procedures to limit the use of CS Pump | U. S. Nuclear Regulatory Commission LIC-06-0059 Page 2 - Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps c: Director of Consumer Health Services, Department of Regulation and Licensure, Nebraska Health and Human Services, State of Nebraska | ||
LIC-06-0059 Page 1 Attachment 1 Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps | |||
LIC-06-0059 Page 2 Attachment 1 Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps NRC Question 1: | |||
In the Human Factors section of the Technical Analysis, the licensee mentions that if the operator were to inadvertently operate CS [Containment Spray] pump SI-3C, the operator would be required to take prompt action to stop the CS pump prior to the Recirculation Actuation Signal (RAS). How much time will the operator have to stop CS pump SI-3C before the RAS signal? What are the procedural controls that would serve to limit such an error by the operator? What are the actions the operator must take to recover in a timely matter if the CS pump SI-3C is started? | |||
OPPD Response: | |||
The operator will have a minimum of 20 minutes to stop the CS pump before RAS. | |||
Assuming that all engineered safeguards start as originally designed, the minimum time to RAS during a large break Loss of Coolant Accident (LOCA) is approximately 20 minutes. After removal of the auto-start feature from Containment Spray Pump SI-3C, time to RAS is extended to 24 minutes. Should the operator inadvertently start SI-3C Containment Spray Pump, the first opportunity to shut it off is during the safety status function check, which is performed by the Shift Technical Advisor at ten (10) minute intervals as required in EOP-03, Loss of Coolant Accident; EOP-05, Uncontrolled Heat Extraction; EOP-20, Functional Recovery Procedure; and AOP-22, Reactor Coolant Leak. The EOP steps are planned to require verification that sufficient spray flow is available with the allowed number (2) of spray pumps in operation. If containment spray pumps or HPSI pumps show any sign of distress caused by a plugged strainer, then the EOPs provide guidance for shutting down the pumps. If SI-3C is discovered running, it will be shut off in accordance with the EOP instructions. | |||
NRC Question 2: | |||
In the Administrative Controls section, the licensee mentions that there will be administrative controls to limit the usage of CS pump SI-3C when less than two CS pumps are operating unless there are "extenuating circumstances." What are these extenuating circumstances in which the operator may manually operate the CS pump SI-3C and how will these circumstances be reflected into the emergency operating procedures? And will any of these extenuating circumstances that call for manual | |||
LIC-06-0059 Page 3 operation of this CS pump be time-critical operator actions? If so, how will these times be validated? | |||
OPPD Response: | |||
The LAR specifies that "administrative controls will be incorporated into plant procedures to limit the use of CS Pump S I 3 C to when there are less than two CS pumps operating (and then only one pump utilizing containment sump strainer SI-12A) unless there are other extenuating circumstances which will be defined in the emergency operating procedures." The EOPs are planned to be revised to specify that operation of SI-3C is allowed only if SI-3B is not running, or if only SI-3A is operating and the safety function is not met, i.e., containment spray flow is less than 2300 gpm. The EOPs are also planned to be revised to contain specific caution statements against operating SI-3B and SI-3C at the same time. Since no extenuating circumstances for running the third CS pump, SI-3C, have been identified, the last two questions do not apply.}} |
Latest revision as of 19:01, 23 November 2019
ML061510099 | |
Person / Time | |
---|---|
Site: | Fort Calhoun ![]() |
Issue date: | 05/30/2006 |
From: | Gambhir S Omaha Public Power District |
To: | Document Control Desk, Office of Nuclear Reactor Regulation |
References | |
LIC-05-0135, LIC-06-0059 | |
Download: ML061510099 (5) | |
Text
444 South 16th Street Mall Omaha NE 68102-2247 May 30,2006 LIC-06-0059 U.S. Nuclear Regulatory Commission ATTN: Document Control Desk Washington, D.C. 20555-0001
References:
- 1. Docket No. 50-285
- 2. Letter from Ross Ridenoure (OPPD) to Document Control Desk (NRC dated December 19, 2005, Fort Calhoun Station Unit No. 1 License Amendment Request, "Reduce the Number of Required Operable Containment Spray Pumps" (LIC-05-0 13 5)
SUBJECT:
Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps The Omaha Public Power District (OPPD) previously submitted Reference 2 in accordance with 10 CFR 50.90 to reduce the required number of operable Containment Spray (CS) pumps from three to two in order to enhance net positive suction head (NPSH) margins. This letter provides the response to the NRC's questions presented in an email dated April 18,2006, related to human factors aspects of Reference 2.
No commitments to the NRC are made in this letter. I declare under penalty of perjury that the foregoing is true and correct. (Executed May 30,2006)
If you have any questions or require additional information, please contact Thomas R.
Byme at (402) 533-7368.
Division Manager Nuclear Projects Employment with Equal Opportunity
U. S. Nuclear Regulatory Commission LIC-06-0059 Page 2 - Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps c: Director of Consumer Health Services, Department of Regulation and Licensure, Nebraska Health and Human Services, State of Nebraska
LIC-06-0059 Page 1 Attachment 1 Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps
LIC-06-0059 Page 2 Attachment 1 Response to Request for Additional Information on the License Amendment Request to Reduce the Number of Required Operable Containment Spray Pumps NRC Question 1:
In the Human Factors section of the Technical Analysis, the licensee mentions that if the operator were to inadvertently operate CS [Containment Spray] pump SI-3C, the operator would be required to take prompt action to stop the CS pump prior to the Recirculation Actuation Signal (RAS). How much time will the operator have to stop CS pump SI-3C before the RAS signal? What are the procedural controls that would serve to limit such an error by the operator? What are the actions the operator must take to recover in a timely matter if the CS pump SI-3C is started?
OPPD Response:
The operator will have a minimum of 20 minutes to stop the CS pump before RAS.
Assuming that all engineered safeguards start as originally designed, the minimum time to RAS during a large break Loss of Coolant Accident (LOCA) is approximately 20 minutes. After removal of the auto-start feature from Containment Spray Pump SI-3C, time to RAS is extended to 24 minutes. Should the operator inadvertently start SI-3C Containment Spray Pump, the first opportunity to shut it off is during the safety status function check, which is performed by the Shift Technical Advisor at ten (10) minute intervals as required in EOP-03, Loss of Coolant Accident; EOP-05, Uncontrolled Heat Extraction; EOP-20, Functional Recovery Procedure; and AOP-22, Reactor Coolant Leak. The EOP steps are planned to require verification that sufficient spray flow is available with the allowed number (2) of spray pumps in operation. If containment spray pumps or HPSI pumps show any sign of distress caused by a plugged strainer, then the EOPs provide guidance for shutting down the pumps. If SI-3C is discovered running, it will be shut off in accordance with the EOP instructions.
NRC Question 2:
In the Administrative Controls section, the licensee mentions that there will be administrative controls to limit the usage of CS pump SI-3C when less than two CS pumps are operating unless there are "extenuating circumstances." What are these extenuating circumstances in which the operator may manually operate the CS pump SI-3C and how will these circumstances be reflected into the emergency operating procedures? And will any of these extenuating circumstances that call for manual
LIC-06-0059 Page 3 operation of this CS pump be time-critical operator actions? If so, how will these times be validated?
OPPD Response:
The LAR specifies that "administrative controls will be incorporated into plant procedures to limit the use of CS Pump S I 3 C to when there are less than two CS pumps operating (and then only one pump utilizing containment sump strainer SI-12A) unless there are other extenuating circumstances which will be defined in the emergency operating procedures." The EOPs are planned to be revised to specify that operation of SI-3C is allowed only if SI-3B is not running, or if only SI-3A is operating and the safety function is not met, i.e., containment spray flow is less than 2300 gpm. The EOPs are also planned to be revised to contain specific caution statements against operating SI-3B and SI-3C at the same time. Since no extenuating circumstances for running the third CS pump, SI-3C, have been identified, the last two questions do not apply.